2009 Toyota Tacoma Owners Manual

Cigarette lighter

Push the cigarette lighter.

The cigarette lighter will pop up when it is ready for use.

n The cigarette lighter can be used when

The engine switch is in the ACC or ON position.

CAUTION

n To avoid burns or fires

l Do not touch the metal parts of the cigarette lighter. l Do not hold the cigarette lighter down. It could overheat and cause a fire. l Do not insert anything other than the cigarette lighter into the outlet.

309

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 310 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features Power outlet (12V DC)

The power outlet can be used for 12 V accessories that run on less than 10A.

n The power outlet can be used when

The engine switch is in the ACC or ON position.

NOTICE

n To avoid damaging the power outlet

Close the power outlet lid when not in use. Foreign objects or liquids that enter the power outlet may cause a short cir- cuit.

n To prevent the fuse from being blown

Do not use an accessory that uses more than 12V/10A.

n To prevent the battery from being discharged

Do not use the power outlet longer than necessary when the engine is not running.

310

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 311 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features Power outlet (if 115V AC equipped)

The power outlet can be used for electrical appliances.

Main switch To use the power outlet, turn on the main switch. The power supply starts a few seconds after the main switch is pressed. Power outlet socket

Maximum available capacity of the power outlet

n While the vehicle is being driven

The maximum capacity of the power outlet is always 115V AC/ 100W.

n When the vehicle is stationary

The maximum capacity of the power outlet varies depending on the following conditions.

l The maximum capacity is 115V AC/400W when the following con-

dition applies: • The shift lever is in P or N. (automatic transmission)

311

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 312 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

• The shift lever is in N and the clutch pedal is not depressed.

(manual transmission)

A maximum capacity of 400W can only be restored by turning the power outlet main switch off and then on again under condition described above.

l The maximum capacity is 115V AC/100W when the following con-

dition applies: • The shift lever is moved to any positions other than P and N.

(automatic transmission)

• The clutch pedal is depressed. (manual transmission)

n The power outlet can be used when

The engine is started.

n The indicator light changes according the maximum available capacity,

as follows:

Indicates 115V AC/400W Indicates 115V AC/100W

n When the power outlet is in operation

The sound of the cooling fan may be heard from the front console box. This is normal and does not indicate a malfunction.

312

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 313 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

n If the engine is started with the power outlet main switch on

The maximum capacity of the power supply may decrease to below the stan- dard, or may be cut off completely, even when the vehicle is stationary.

n The protection circuit may be activated to cut the power supply if any

of the following conditions apply: l The engine is started with the power outlet main switch on. l Use of electrical appliances exceeding the maximum capacity is

attempted. A sound may be heard when the protection circuit is activated. This is normal and does not indicate a malfunction.

l Electrical appliances, which consume power exceeding 100W, have

been used continuously for a long time period.

l The total power usage by all electrical features (headlights, air condition- ing, etc.) has exceeded the total vehicle maximum for an extended period of time.

n If the protection circuit is activated and the power supply is cut, con-

duct the following procedure:

Park the vehicle in a safe place, and then securely apply the park- ing brake. Check and ensure the following conditions: •The shift lever is in P or N. (automatic transmission) •The shift lever is in N and the clutch pedal is not depressed. (manual transmission) Make sure that the power consumption of the electric appliance is within the maximum capacity of the power outlet and the appliance is not broken. Press the power outlet main switch again.

When the cabin temperature is high, open the windows to cool the tempera- ture down. Once it reaches the normal temperature, turn the power outlet main switch on again. If the power supply is not resumed even after performing the above proce- dure, have the vehicle inspected by a Toyota dealer.

313

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 314 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

CAUTION

n Using a power outlet

Observe the following precautions to reduce the risk of injury. l Use of the power outlet when it is wet with rain, drinking water or snow may result in electrical shocks and is extremely dangerous. The power outlet must be thoroughly dried before use.

l Do not allow children to use or play with the power outlet. l Be careful not to get any part of your body caught in the power outlet lid. l When using electrical appliances, strictly follow any cautions and notices

written on their labels and in the manufacturers’ instruction manuals.

l Do not modify, disassemble or repair the power outlet or its inverter, in any way. Doing so may result in unexpected malfunctions or accidents, which could cause serious damage or injuries. Contact a Toyota dealer for any necessary repairs.

n To prevent injuries and accidents, securely fix all electric appliances before use and do not use any appliances that may do any of the fol- lowing: l Distract the driver while driving, or hamper safe driving. l Result in a fire or burn injuries due to the appliance rolling, falling or over-

heating while driving.

l Emit steam, while the windows of the cabin are closed.

n To prevent unexpected accidents, such as electric shocks, do not per-

form any of the following. l Using the power outlet for electric heaters while sleeping. l Contaminating the power outlet with liquid substances or mud. l Handling electrical appliance plugs at the power outlet with wet hands or

feet. Inserting foreign objects into the power outlet.

l Using malfunctioning electric appliances.

Inserting inappropriate or badly fitting plugs into the power outlet.

314

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 315 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

NOTICE

n To avoid damaging the power outlet and the plug

l Close the power outlet lid when not in use. l Foreign objects or liquids that enter the power outlet may cause a short

circuit.

l Do not use plug adaptors to connect too many plugs to the power outlet. l After inserting a plug, gently close the power outlet lid.

n To prevent the fuse from being blown

Do not use a 115V AC appliance that requires more than maximum capacity. If a 115V AC appliance that consumes more than maximum capacity is used, the protection circuit will cut the power supply.

n Appliances that may not operate properly (115V AC)

The following 115V AC appliances may not operate even if their power con- sumption is under maximum capacity. l Appliances with high initial peak wattage l Measuring devices that process precise data. l Other appliances that require an extremely stable power supply

n To prevent the battery from being discharged

Turn off all the vehicle’s electronic equipment and accessories, such as the headlights and air conditioning, when electrical appliances that consume in excess of 100W are used continuously for long periods of time.

n To prevent any damage caused by heat

Do not use any electrical appliances that give off intense heat such as toast- ers, in any locations including the internal or external trim, seats and deck. l Do not use any electrical appliances, which are easily affected by vibration

or heat, inside the vehicle. Vibration while driving, or the heat of the sun while parking, may result in damage to those electrical appliances.

315

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 316 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

NOTICE

n If any electrical appliances are to be used while driving

Securely fasten both the appliances and their cables to prevent them from falling or getting caught any of the power train components.

n If the power outlet is loose when an electrical appliance plug is con-

nected Replace the outlet. Contact a Toyota dealer for any necessary replacements.

n If the power outlet gets dirty

Turn the main switch off and use a soft, clean cloth to wipe it gently. Do not use any cleansing materials, such as organic solvents, wax, or com- pound cleaners, as these may damage the power outlet or cause it to mal- function.

316

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 317 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features Seatback table (if equipped)

Front passenger’s seatback can be used as a temporary table only when the vehicle is stopped.

Fold down the front passen- ger’s seat to use the seatback table. (→P. 47)

CAUTION

n Caution while driving

Observe the following precautions to avoid death or serious injury. l Do not set up the seatback table. l Do not sit on or place anything on the seatback table.

NOTICE

n To prevent damage to the seatback table

Do not put heavy loads on the table.

317

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 318 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features Floor mat

Securely place a mat that matches the size of the space on the car- pet.

Secure the using the hooks provided.

front

floor mat

CAUTION

n When inserting the floor mat

Observe the following precautions. Failure to do so may result in the floor mat slipping and interfering with the movement of the pedals during driving, resulting in an accident. l Make sure the floor mat is properly placed on the vehicle carpet and the

correct side faces upward.

l Do not place floor mats on top of existing mats.

318

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 319 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features Luggage compartment features

Behind the rear seat (Double Cab models only)

Cargo net hooks (vehicles with sub woofer) Grocery bag hooks Flashlight holder Storage boxes Deck

Auxiliary boxes Tie-down cleats Deck hooks

TACOMA_U_(L/O_0805)

319

TACOMA_U.book Page 320 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

Auxiliary boxes

Left side

Turn the knob counterclock- wise. Open the lid.

Right side (vehicles without 115V power outlet)

Turn the knob counterclock- wise. Open the lid.

Right side (vehicles with 115V power outlet)

Turn the knob counterclock- wise. Open the lid.

320

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 321 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

CAUTION

n Caution while driving

Keep the auxiliary boxes closed and locked. Injuries may result in the event of an accident or sudden braking.

Deck hooks

Deck hooks are provided for securing loose items.

321

CAUTION

n When not in use

Keep the deck hooks folded.

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 322 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

Tie-down cleats

The deck rail system enables you to insert and move tie-down cleats to their best location along deck rails to secure a load.

Locking plate Thumb wheel Tie-down cleat

n Installing the tie-down cleat

Loosen the thumb wheel in a counterclockwise motion, and depress the wheel so that the locking plate maintains 0.5 in. (12.7 mm) gap.

0.5 in. (12.7 mm)

Deck rail Detent Locking plate

322

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 323 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

Insert the locking plate into the deck rail, rotate the tie-down cleat 90°, and release the thumb wheel.

Slide the cleat to the closest detent in the rail system. You will feel that the locking plate snaps into a detent.

Tighten the thumb wheel in a clockwise motion until the clutch mechanism ratchets.

Check the tie-down cleat to con- firm that it is locked into a detent and securely mounted to the deck rail system.

323

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 324 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

CAUTION

n Tie-down cleat precautions

l Properly install and tighten the tie-down cleats into the deck rail system.

Failure to properly install and tighten the tie-down cleats can cause cargo to become unsecured. Unsecured cargo can cause injury when the vehi- cle is in motion.

l Properly secure all cargo to prevent shifting or sliding during driving.

Failure to properly secure cargo can cause injury when the vehicle is in motion.

l Applying loads at an angle to the tie-down cleat greater than 45° or loads greater than 220 lb. (100 kg) may cause damage to the deck, deck rail system, tie-down cleat and/or the cargo.

l Do not exceed a total tensile load of 440 lb. (200 kg) per deck rail. l Do not install more than the following number of tie-down cleats per deck

rail: • Side rail:

Short deck—Max. 3 locations Long deck—Max. 4 locations

• Headboard rail: Max. 3 locations

Storage boxes (Double Cab models only)

Storage box is designed to place things like bottles.

Right side (vehicles without sub woofer)

324

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 325 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

Left side

n Removing the separator

Remove the separator. It can be installed in various positions as required.

Flashlight holder (Double Cab models only)

Flashlight holder is designed to hold the flashlight securely.

325

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 326 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

n Removing the flashlight holder

Remove the flashlight holder. It can be installed in various positions as required.

Grocery bag hooks (Double Cab models only)

Grocery bag hook is designed to hang things like grocery bag.

NOTICE

n Grocery bag hook weight capacity

Do not hang any object heavier than 7 lb. (3 kg) on the grocery bag hooks.

326

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 327 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

Cargo net hooks (Double Cab models with sub woofer)

Cargo net hooks are designed to hang the factory-supplied cargo net.

NOTICE

n To prevent damage to the cargo net hook Do not hang items other than the cargo net.

TACOMA_U_(L/O_0805)

327

TACOMA_U.book Page 328 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features Garage door opener box (if equipped)

The garage door opener box is designed to store a garage door opener transmitter. n Storing the transmitter in the box

Pull the lid down while pushing the knob.

Remove fastener square.

the hook-and-loop

328

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 329 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

Remove the paper strip covering the adhesive on back side of square. Adhere the square to back side of the transmitter near the center.

Place the transmitter with fas- tener square facing inside of box into the box.

Make sure the transmitter but- ton is located above button pins.

Remove spacers from the center panel. Place one spacer on the pin that would be below trans- mitter button when the cover is closed. Close the cover.

329

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 330 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

n Operating the garage door opener transmitter

When the garage door opener transmitter is properly installed, you can operate the transmitter by pushing the button of the cover.

Push the button.

n If a garage door opener transmitter has wire clip for sun visor

This clip must be removed prior to adhe- sion of the fastener.

n If the center panel does not touch your garage door opener transmitter l Check to see if the spacer is on the cor-

rect pin.

l Attach another spacer to the top of orig- inal spacer. Check operation. If required, continue to add spacers until contact is achieved.

n To prevent the transmitter from clattering during driving

If the transmitter is clattering during driving, fill in a piece of felt or pad.

330

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 331 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

CAUTION

n Caution while driving

Keep the garage door opener box closed. Injuries may result in the event of an accident or sudden braking.

n To prevent an accident

Keep the remaining spacers away from the children.

331

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 332 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features Compass (vehicles with accessory meter)

The compass on the accessory meter indicates the direction in which the vehicle is heading. n Operation

To turn the compass on or off, press the switch.

n Displays and directions

Display

NE SE SW NW

Direction

North

Northeast

East

Southeast

South

Southwest

West

Northwest

332

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 333 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

Calibrating the compass

Samoa: 5 Guam: 8 Saipan: 8

The direction display deviates from the true direction determined by the earth’s magnetic field. The amount of deviation varies according to the geographic position of the vehicle.

If you cross over a map boundary shown in illustration, the compass will deviate. To obtain higher precision or perfect calibration, refer to the following.

n Deviation calibration

Stop the vehicle where it is safe to drive in a circle.

the switch until VAR

Press appears on the display.

Press the switch, and referring to the map above, select the number of the zone where you are. If the direction is displayed several seconds after adjustment, the calibration is complete.

333

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 334 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

n Circling calibration

Stop the vehicle where it is safe to drive in a circle.

the switch until CAL

Press appears on the display.

At this time, the compass display is locked in N.

Drive the vehicle at 5
mph (8 km/h) or less in a circle until the direction is displayed. If there is not enough space to drive in a circle, drive around the block until the direction is displayed. When CAL goes off and the compass display returns to the normal mode, calibration is complete.

334

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 335 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

n Conditions unfavorable to correct operation

The compass may not show the correct direction in the following conditions: l The vehicle is stopped immediately after turning.

The compass does not adjust while the vehicle is stopped.

l The engine switch is turned off immediately after turning. l The vehicle is on an inclined surface. l The vehicle is in a place where the earth’s magnetic field is subject to interference by artificial magnetic fields (underground car park/parking lot, under a steel tower, between buildings, roof car park/parking lot, near an intersection, near a large vehicle, etc.).

l The vehicle has become magnetized.

(There is a magnet or metal object on or near the roof.)

l The battery has been disconnected.

CAUTION

n While driving the vehicle

Do not adjust the display. Be sure to adjust the display only when the vehicle is stopped.

n When doing the circling calibration

Be sure to secure a wide space, and watch out for people and vehicles in the neighborhood. Do not violate any local traffic rules while performing circling calibration.

335

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 336 Tuesday, April 8, 2008 9:01 AM

3-6. Other interior features

NOTICE

n To avoid the compass malfunctions

Do not place magnets or any metal objects on or near the roof. Doing this may cause a malfunction of the compass sensor.

n To ensure normal operation of the compass

l Do not perform circling calibration of the compass in a place where the earth’s magnetic field is subject to interference by artificial magnetic fields. l During calibration, do not operate electric systems (power windows, etc.)

as they may interfere with the calibration.

336

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 338 Tuesday, April 8, 2008 9:01 AM

4-1. Maintenance and care Cleaning and protecting the vehicle exterior

Perform the following to protect the vehicle and maintain it in prime condition.

l Working from top to bottom, liberally apply water to the vehicle body, wheel wells and underside of the vehicle to remove any dirt and dust. Wash the vehicle body using a sponge or soft cloth, such as a chamois.

l For hard-to-remove marks, use car wash soap and rinse thor-

oughly with water.

l Wipe away any water. l Wax the vehicle when the waterproof coating deteriorates. If water does not bead on a clean surface, apply wax when the vehicle body is cool.

n Automatic car washes

l Before washing the vehicle, do the following.

• Fold the mirrors back. • Remove the antenna.

l Brushes used in automatic car washes may scratch the vehicle surface

and harm your vehicle’s paint.

n High pressure car washes

Do not allow the nozzles of the car wash to come within close proximity of the windows. Before entering an automatic car wash, check that the fuel filler door on your vehicle is closed properly.

n Aluminum wheels (if equipped)

Remove any dirt immediately by using a neutral detergent. Do not use hard brushes or abrasive cleaners. Do not use strong or harsh chemical cleaners. Use the same mild detergent and wax as used on the paint.

n Bumpers and side moldings

Do not scrub with abrasive cleaners.

338

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 339 Tuesday, April 8, 2008 9:01 AM

4-1. Maintenance and care

n To prevent deterioration and body corrosion

l Wash the vehicle immediately in the following cases:

• After driving near the sea coast • After driving on salted roads • If you see coal tar or tree sap on the paint surface • If you see dead insects or insect droppings on the paint • After driving in an area contaminated with soot, oily smoke, mine dust,

iron powder or chemical substances

• If the vehicle becomes heavily soiled in dust or mud • If liquids such as benzene and gasoline are spilled on the paint surface If the paint is chipped or scratched, have it repaired immediately.

CAUTION

n Caution about the exhaust pipe

Exhaust gasses cause the exhaust pipe to become quite hot. When washing the vehicle, be careful not to touch the pipe until it has cooled sufficiently, as touching a hot exhaust pipe can cause burns.

NOTICE

n To protect your vehicle’s painted surfaces

Do not use organic cleaners such as benzene or gasoline.

n Cleaning the exterior lights

l Wash carefully. Do not use organic substances or scrub with a hard brush.

This may damage the surfaces of the lights.

l Do not apply wax on the surfaces of the lights.

Wax may cause damage to the lenses.

339

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 340 Tuesday, April 8, 2008 9:01 AM

4-1. Maintenance and care Cleaning and protecting the vehicle interior

The following procedures will help protect your vehicle’s interior and keep it in top condition: n Protecting the vehicle interior

Remove dirt and dust using a vacuum cleaner. Wipe dirty sur- faces with a cloth dampened with lukewarm water.

n Cleaning the leather areas

l Remove dirt and dust using a vacuum cleaner. l Wipe any excess dirt and dust with a soft cloth dampened with

diluted detergent. Use a diluted water solution of approximately 5% neutral wool deter- gent.

l Wring out any excess water from the cloth and thoroughly

wipe off all remaining traces of detergent.

l Wipe the surface with a dry, soft cloth to remove any remain- ing moisture. Allow the leather to dry in a shaded and venti- lated area.

n Synthetic leather areas

l Remove loose dirt using a vacuum cleaner. l Apply a mild soap solution to the synthetic leather using a

sponge or soft cloth.

l Allow the solution to soak in for a few minutes. Remove the

dirt and wipe off the solution with a clean, damp cloth.

n Caring for leather areas

Toyota recommends cleaning the interior of the vehicle at least twice a year to maintain the quality of the vehicle’s interior.

340

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 341 Tuesday, April 8, 2008 9:01 AM

4-1. Maintenance and care

n Shampooing the carpets

There are several commercial foaming-type cleaners available. Use a sponge or brush to apply the foam. Rub in overlapping circles. Do not apply water. The excellent results are obtained when keeping the carpet as dry as possible.

n Seat belts

Clean with mild soap and lukewarm water using a cloth or sponge. Also check the belts periodically for excessive wear, fraying or cuts.

CAUTION

n Water in the vehicle

l Be careful not to splash or spill liquid on the floor. l Do not get any of the SRS components or wiring in the vehicle interior wet.

(→P. 81) Electrical malfunction may cause the airbags to deploy or not function properly, resulting in death or severe injury.

341

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 342 Tuesday, April 8, 2008 9:01 AM

4-1. Maintenance and care

NOTICE

n Cleaning detergents

Do not use organic substances such as benzene or gasoline, acidic or alka- line solutions, dye, bleach or other detergent. Doing so may discolor the vehicle interior or cause streaks or damage to painted surfaces.

n Preventing damage to leather surfaces

Observe the following precautions to avoid damage to and deterioration of leather surfaces. l Remove any dust or dirt on leather surfaces immediately. l Do not expose the vehicle to direct sunlight for extended periods of time.

Park the vehicle in the shade, especially during summer.

l Do not place items made of vinyl, plastic, or that contain wax on the uphol- stery, as they may stick to the leather surface if the vehicle interior heats up significantly.

n Water on the floor

Do not wash the vehicle floor with water. Vehicle systems such as the audio system may be damaged if water comes into contact with electrical components under the floor of the vehicle, and may also cause the body to rust.

342

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 343 Tuesday, April 8, 2008 9:01 AM

4-2. Maintenance Maintenance requirements

To ensure safe and economical driving, day-to-day care and regular maintenance is essential. It is the owner’s responsibility to perform regular checks. Toyota recommends the following maintenance. n General maintenance

Should be performed on a daily basis. This can be done by your- self or by a Toyota dealer. n Scheduled maintenance

Should be performed at specified intervals according to the maintenance schedule. For details about maintenance items and schedules, refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”.

n Do-it-yourself maintenance

You can perform some maintenance procedures yourself. Please be aware that do-it-yourself maintenance may affect war- ranty coverage. The use of Toyota Repair Manuals is recommended. For details about warranty coverage, see the separate “Owner’s Warranty Information Booklet”, “Owner’s Manual Supplement”.

n Repair and replacement

It is recommended that genuine Toyota parts be used for repair to ensure performance of each system. If non-Toyota parts are used in replacement or if a repair shop other than Toyota dealer performs repairs, confirm the war- ranty coverage.

343

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 344 Tuesday, April 8, 2008 9:01 AM

4-2. Maintenance

n Allow inspection and repairs to be performed by a Toyota dealer

l Toyota technicians are well-trained specialists and are kept up to date with the latest service information. They are well informed about the operations of all systems on your vehicle.

l Keep a copy of the repair order. It proves that the maintenance that has been performed is under warranty coverage. If any problem should arise while your vehicle is under warranty, your Toyota dealer will promptly take care of it.

CAUTION

n Warning in handling of battery

l Engine exhaust, some of its constituents, and a wide variety of automobile components contain or emit chemicals known to the State of California to cause cancer and birth defects and other reproductive harm. Work in a well ventilated area.

l Oils, fuels and fluids contained in vehicles as well as waste produced by component wear contain or emit chemicals known to the State of Califor- nia to cause cancer and birth defects or other reproductive harm. Avoid exposure and wash any affected area immediately.

l Battery posts, terminals and related accessories contain lead and lead compounds which are known to cause brain damage. Wash your hands after handling. (→P. 368)

344

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 345 Tuesday, April 8, 2008 9:01 AM

4-2. Maintenance General maintenance

Listed below are the general maintenance items that should be per- formed at the intervals specified in the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”. It is recommended that any problem you notice should be brought to the attention of your Toyota dealer or qualified service shop for advice.

Engine compartment

Items

Battery Brake fluid Engine coolant Engine oil Exhaust system Power steering fluid

Radiator/condenser/hoses

Washer fluid

Check points

(→P. 368) Maintenance-free. At the correct level? (→P. 364) At the correct level? (→P. 363) At the correct level? (→P. 357) No fumes or strange sounds? At the correct level? (→P. 366) Not blocked with foreign matter? (→P. 364) At the correct level? (→P. 371)

345

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 346 Tuesday, April 8, 2008 9:01 AM

4-2. Maintenance

Vehicle interior

Items

Check points

• Moves smoothly (without uneven pedal effort or catching)? • Can the vehicle be hold securely on an incline with the shift lever in P? • Moves smoothly? • Does it have appropriate clear- ance and correct amount of free play? • Not pull to one side when applied? • Loss of brake effectiveness? • Spongy feeling brake pedal? • Pedal almost touches floor? • Moves smoothly? • Does it have correct amount of free play? • Move smoothly and lock securely? • Function properly? • Do all the lights come on? • Headlights aimed correctly? • Moves smoothly? • Can hold the vehicle securely on an incline? • Does the seat belt system oper- ate smoothly? • Are the belts undamaged? • Do the seat controls operate properly?

Accelerator pedal

Automatic transmission “Park” mechanism

Brake pedal

Brakes

Clutch pedal

Head restraints

Indicators/buzzers

Lights

Parking brake

Seat belts

Seats

346

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 347 Tuesday, April 8, 2008 9:01 AM

4-2. Maintenance

Items

Steering wheel

Vehicle exterior

Check points

• Moves smoothly? • Has correct free play? • No strange noises?

Items

Check points

Doors Engine hood

Fluid leaks

Tire

• Operate smoothly? • The lock system works properly? • Is there any leakage after park- ing? • Inflation pressure is correct? • Tire surfaces not worn or dam- aged? • Tires rotated according to the maintenance schedule? • Wheel nuts are not loose?

CAUTION

n If the engine is running

Turn the engine off and ensure that there is adequate ventilation before per- forming maintenance checks.

347

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 348 Tuesday, April 8, 2008 9:01 AM

4-2. Maintenance Emission inspection and maintenance (I/M) programs

Some states have vehicle emission inspection programs which include OBD (On Board Diagnostics) checks. The OBD system moni- tors the operation of the emission control system. n If the malfunction indicator lamp comes on

The OBD system determines that a problem exists somewhere in the emission control system. Your vehicle may not pass the I/ M test and may need to be repaired. Contact your Toyota dealer to service the vehicle.

n Your vehicle may not pass the I/M test:

l When the battery is disconnected or discharged

Readiness codes that are set during ordinary driving are erased. Also, depending on your driving habits, the readiness codes may not be completely set.

l When the fuel tank cap is loose

The malfunction indicator lamp comes on as a temporary mal- function and your vehicle may not pass the I/M test.

n When the malfunction indicator lamp goes off after several

driving trips The error code in the OBD system will not be cleared unless the vehicle is driven 40 or more times.

n If your vehicle does not pass the I/M test

Contact your Toyota dealer to prepare the vehicle for re-testing.

348

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 349 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance Do-it-yourself service precautions

If you perform maintenance yourself, be sure to follow the correct procedures as given in these sections.

Items

Parts and tools

Battery condition

(→P. 368)

Brake fluid level

(→P. 364)

Engine coolant level

(→P. 363)

Engine oil level

(→P. 357)

Fuses

(→P. 393)

• Warm water • Baking soda • Grease • Conventional wrench (for terminal clamp bolts) • FMVSS No.116 DOT 3 or SAE J1703 brake fluid • Rag or paper towel • “Toyota Super Long Life Coolant” or similar high quality ethylene glycol based non-silicate, non- amine, non-nitrite and non-borate coolant with long-life hybrid organic acid technology. U.S.A.: “Toyota Super Long Life Coolant” is pre-mixed with 50% coolant and 50% deionized water. Canada: “Toyota Super Long Life Coolant” is pre-mixed with 55% coolant and 45% deionized water. • Toyota Genuine Motor Oil or equivalent • Rag or paper towel • Funnel (used only for adding oil) • Fuse with same amperage rating as original

349

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 350 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance

Items

Parts and tools

Light bulbs

(→P. 403)

Power steering fluid level

(→P. 366)

Radiator and condenser

(→P. 364)

Tire inflation pressure (→P. 381)

Washer fluid

(→P. 371)

• Bulb with same number and watt- age rating as original • Phillips-head screwdriver • Conventional wrench • Automatic transmission fluid DEXRON® II or III • Rag or paper towel

⎯

• Tire pressure gauge • Compressed air source • Water • Washer fluid containing antifreeze (for winter use)

350

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 351 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance

CAUTION

The engine compartment contains many mechanisms and fluids that may move suddenly, become hot, or become electrically energized. To avoid death or serious injury observe the following precautions. n When working on the engine compartment

l Keep hands, clothing, and tools away from the moving fan and engine

drive belt.

l Be careful not to touch the engine, radiator, exhaust manifold, etc. right

after driving as they may be hot. Oil and other fluids may also be hot.

l Do not leave anything that may burn easily, such as paper or rags, in the

engine compartment.

l Do not smoke, cause sparks or expose an open flame to fuel or the bat-

tery. Fuel and battery fumes are flammable.

l Be extremely cautious when working on the battery. It contains poisonous

and corrosive sulfuric acid.

l Take care because brake fluid can harm your hands or eyes and damage

painted surfaces. If fluid gets on your hands or in your eyes, flush the affected area with clean water immediately. If you still experience discomfort, see a doctor.

n When working near the cooling fan or radiator grille

Be sure the engine switch is off. With the engine switch on, the cooling fan may automatically start to run if the air conditioning is on and/or the coolant temperature is high.

n Safety glasses

Wear safety glasses to prevent flying or falling material, fluid spray, etc. from getting in the eyes.

351

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 352 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance

NOTICE

n If you remove the air cleaner

Driving with the air cleaner removed may cause excessive engine wear due to dirt in the air. Also a backfire could cause a fire in the engine compart- ment.

n If the fluid level is low or high

It is normal for the brake fluid level to go down slightly as the brake pads wear or when the fluid level in the accumulator is high. If the reservoir needs frequent refilling, it may indicate a serious problem.

352

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 353 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance Hood

Release the lock from the inside of the vehicle to open the hood.

Pull the hood release lever. The hood will pop up slightly.

Pull up the hood catch lever and lift the hood.

353

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 354 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance

Hold the hood open by insert- ing the supporting rod into the slot.

CAUTION

n Pre-driving check

Check that the hood is fully closed and locked. If the hood is not locked properly, it may open while the vehicle is in motion and cause an accident, which may result in death or serious injury.

n After installing the support rod into the slot

Make sure the rod supports the hood securely from falling down on to your head or body.

NOTICE

n When closing the hood

Be sure to return the support rod to its clip before closing the hood. Closing the hood with the support rod up could cause the hood to bend.

354

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 355 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance Engine compartment

2.7 L 4-cylinder (2TR-FE) engine

Washer fluid tank (→P. 371) Radiator cap Engine coolant reservoir

(→P. 363)

Engine oil filler cap

(→P. 357) Power steering fluid reservoir (→P. 366)

Engine oil level dipstick

(→P. 357)

Brake fluid reservoir

Fuse box Battery Condenser Radiator

(→P. 364) (→P. 393) (→P. 368) (→P. 364) (→P. 364)

355

TACOMA_U_(L/O_0805)

TACOMA_U.book Page 356 Tuesday, April 8, 2008 9:01 AM

4-3. Do-it-yourself maintenance

4.0 L V6 (1GR-FE) engine

Washer fluid tank (→P. 371) Power steering fluid reservoir (→P. 366)

Radiator cap Engine oil level dipstick

(→P. 357)

Engine coolant reservoir

(→P. 363)

Engine oil filler cap

(→P. 357)

Brake fluid reservoir

Fuse box Battery Condenser Radiator

(→P. 364) (→P. 393) (→P. 368) (→P. 364)