02 SIENNA_U (L/O 0107)
the new
If fuse immediately blows out, there is a problem with the electrical sys- tem. Have your Toyota dealer correct it as soon as possible.
CAUTION
Never use a fuse with a higher am- perage rating, or any other object, in place of a fuse. This may cause ex- tensive damage and possibly a fire.
Adding washer fluid If any washer does not work or low windshield washer fluid level warning light comes on, the washer tank may be empty. Add washer fluid. You may use plain water as washer fluid. in cold areas where tempera- However, tures freezing point, use fluid containing antifreeze. This washer product is available at your Toyota dealer and most auto parts stores. Follow the manufacturer’s directions for how much to mix with water.
range below
NOTICE
Do not use engine antifreeze or any other substitute because it may dam- age your vehicle’s paint.
following
illustrations show how
Replacing light bulbs— The to gain access to the bulbs. When replacing a bulb, make sure the ignition switch and light switch are off. Use bulbs with the wattage ratings given in the table.
CAUTION
D To prevent yourself from burning, do not replace the light bulbs while they are hot.
D Halogen bulbs have pressurized gas inside and require special handling. They can burst or shatter if scratched or dropped. Hold a bulb only by its plastic or metal case. Do not touch the glass part of a bulb with bare hands.
NOTICE
Only use a bulb of the listed type.
2002 MY SIENNA_U (OM45407U)
307
the
The inside of the lens of exterior lights such as headlights may temporarily fog up when the lens becomes wet in the rain or in a car wash. This is not a problem because the is caused by fogging temperature difference between the outside and the windshield fogged up in the rain. However, if there is a large drop of water on the inside of the lens, or if there is water pooled light, contact your Toyota dealer.
inside of
inside
lens,
just
like
the
the
02 SIENNA_U (L/O 0107)
Light bulbs
Bulb No.
Type
Headlights Front fog lights Front turn signal and parking/side marker lights Rear turn signal lights Stop/tail lights Back−up lights License plate lights High mounted stoplight Front personal lights Front interior light Center personal lights Rear interior light Vanity mirror lights Door courtesy lights Luggage compartment light
— —
3157A
—
7743
921
168
921
—
—
—
—
—
194
—
60/55
51
27/8
21
21/5
18
18
3.8
A: HB2 halogen bulbs B: HB3 halogen bulbs C: Single end bulbs D: Wedge base bulbs E: Double end bulbs
308
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
—Headlights
“TOP PULL” mark
1. Open the hood. Unplug the connec-
tor. Remove the rubber cover. If the connector is tight, wiggle it.
2. Release
the bulb retaining spring and remove the bulb. Install a new bulb and the bulb retaining spring.
To install a bulb, align the tabs of the bulb with the mounting hole.
the cutouts of
3. Install
the rubber cover with
the “TOP PULL” mark upward, and snuggle on the boss. Then plug in the connector.
Make sure the rubber cover fits snugly on the connector and the headlight body. Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer.
2002 MY SIENNA_U (OM45407U)
309
02 SIENNA_U (L/O 0107)
—Front turn signal and parking/side marker lights
—Front fog lights If either the left or right front fog burns out, contact your Toyota dealer.
NOTICE
Do not try to replace the front fog lights bulbs by yourself. You may damage the vehicle.
Use a Phillips−head screwdriver.
310
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
—Rear turn signal and, stop/tail lights
—Stop/tail and back−up lights
Left side of the vehicle
Remove the bolts.
a: Stop/tail light b: Rear turn signal light
Right side of the vehicle
2002 MY SIENNA_U (OM45407U)
311
Remove the strap and handle.
02 SIENNA_U (L/O 0107)
—License plate lights
a: Back−up light b: Stop/tail light
Use a Phillips−head screwdriver.
312
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
—High mounted stoplight
Use a Phillips−head screwdriver.
2002 MY SIENNA_U (OM45407U)
313
02 SIENNA_U (L/O 0107)
314
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
SECTION 8
SPECIFICATIONS Dimensions and weight Engine Fuel Service specifications Tires Fuses
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
316
316
317
317
319
320
2002 MY SIENNA_U (OM45407U)
315
02 SIENNA_U (L/O 0107)
Dimensions and weight
Overall length
Overall width
Overall height
Wheelbase
Front tread
Rear tread
Vehicle capacity weight (occupants + luggage)
∗: Unladen vehicle
mm (in.)
mm (in.)
mm (in.)
mm (in.)
mm (in.)
mm (in.)
kg (lb.)
4930 (194.1)
1865
1710
(73.4) (67.3)∗
2900 (114.2)
1565
(61.6)
1610
(63.4)
511 (1127)
Engine Model:
1MZ−FE
Type:
6 cylinder V type 4 cycle, gasoline
Bore and stroke, mm (in.):
87.5 83.0 (3.44 3.27)
Displacement, cm3 (cu. in.):
2995 (182.8)
316
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Fuel Fuel type:
Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher.
For improved vehicle performance, the
use of premium unleaded gasoline with
an Octane Rating of 91 (Research Oc-
tane Number 96) or higher is recom-
mended.
Fuel tank capacity, L (gal., Imp. gal.):
79 (21, 17.5)
Service specifications ENGINE Valve clearance (engine cold), mm (in.):
Intake Exhaust
0.15—0.25 (0.006—0.010) 0.25—0.35 (0.010—0.014)
Spark plug type:
DENSO NGK
SK20R11
IFR6A11
Spark plug gap, mm (in.):
1.1 (0.043)
Recommended oil viscosity (SAE):
5W-30 Preferred
Drive belt roughs No.BT−33−73F (used belt), Ibf:
tension measured with Bor- gauge
tension
drive
belt
Generator belt Power steering pump belt
125"10
115"20
ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.):
With filter Without filter
Oil grade:
4.7 (5.0, 4.1) 4.5 (4.8, 4.0)
API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recom- mended.
Temperature range anticipated before next oil change
COOLING SYSTEM Total capacity, L (qt., Imp. qt.):
10.4 (11.0, 9.2)
Coolant type:
“TOYOTA Long Life Coolant” or equiva- lent With ethylene−glycol type coolant for a proper corrosion protection of aluminum components Do not use alcohol type antifreeze or plain water alone.
2002 MY SIENNA_U (OM45407U)
317
02 SIENNA_U (L/O 0107)
BRAKES Minimum pedal clearance when depressed with the force of 490 N (50 kgf, 110 lbf) with the engine running, mm (in.):
96 (3.8)
Pedal free play, mm (in.):
1—6 (0.04—0.24)
Pad wear limit, mm (in.):
1.0 (0.04)
Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment when depressed with the force of 294 N (30 kgf, 66 lbf):
3—5 clicks
Fluid type:
fluid D−ll or
SAE J1703 or FMVSS No.116 DOT 3
STEERING Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type:
Automatic transmission fluid DEXRONrII or III
BATTERY Open voltage∗ at 20_C (68_F):
12.6—12.8 V 12.2—12.4 V 11.8—12.0 V
Fully charged Half charged Discharged
∗: Voltage that is checked 20 minutes af- the
is removed with all
the key
ter lights turned off
Charging rates:
5 A max.
AUTOMATIC TRANSAXLE Fluid capacity (drain and refill), L (qt., Imp. qt.):
Up to 4.75 (5.0, 4.2)
Fluid type:
Automatic DEXRONrIII (DEXRONrII)
transmission
318
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Wheel nut torque, N·m (kgf·m, ft·lbf):
104 (10.5, 77)
NOTE: For a complete
information on tires (e.g. replacing tires or re- placing wheels), see “Checking tire pressure” through “Aluminum wheel precautions” in Section 7−2.
Tires Tire size and pressure: Normal driving
Tire size
P205/70R15 95S
P215/65R15 95S
T145/80D16
Tire pressure,
kPa (kgf/cm2 or bar, psi)
240 (2.4, 35)
220 (2.2, 32)∗1
240 (2.4, 35)∗2
420 (4.2, 60)
∗1: Vehicle load up to 6 passengers ∗2: Up to vehicle capacity weight Trailer towing
Wheel size
15 6 1/2JJ
15 6 1/2JJ
16 4T
Tire size
P205/70R15 95S
P215/65R15 95S
Tire pressure,
kPa (kgf/cm2 or bar, psi)
240 (2.4, 35)
240 (2.4, 35)
Wheel size
15 6 1/2JJ
15 6 1/2JJ
When driving under the above vehicle load conditions at sustained high speeds above 160 km/h (100 mph), in countries where such speeds are permitted by−law, inflate the front and rear tires to 240 kPa (2.4 kgf/cm2 or bar, 35 psi) provided that it does not exceed the maximum cold tire pressure molded on the tire sidewall.
2002 MY SIENNA_U (OM45407U)
319
02 SIENNA_U (L/O 0107)
Fuses
Engine compartment
Fuses (type A) 1. SEAT HTR 20 A: Seat heaters 2. A/F HTR 25 A: Air fuel ratio sensor 3. SPARE 10 A: Spare fuse 4. SPARE 15 A: Spare fuse 5. SPARE 30 A: Spare fuse 6. ALT−S 5 A: Charging system 7. HEAD (RH) 15 A: Right−hand headlight
(high beam)
Engine compartment (with towing package)
320
Engine compartment (without towing package)
2002 MY SIENNA_U (OM45407U)
8. EFI 15 A: Multiport fuel injection sys- injection
tem/sequential multiport system
fuel
02 SIENNA_U (L/O 0107)
18. ABS NO.2 25 A: Vehicle skid control
system
19. H−LP LH (LO) 10 A: Left−hand head-
light (low beam)
20. H−LP RH (LO) 10 A: Right−hand head-
light (low beam)
21. ABS NO.4 5 A: Vehicle skid control
system
22. HEATER 10 A: Air conditioning system,
rear window defogger
23. GAUGE 10 A: Gauges and meters, service reminder indicators and warning buzzers (except discharge and open door warning light), power windows, daytime running light system, back−up lights, power sliding door, auto anti− glare inside rear view mirror, compass 24. WIPER 25 A: Windshield wipers and washer, rear window wiper and washer 25. MIRROR−HEATER 10 A: Multiport fuel system/sequential multiport injection fuel injection system, outside rear view mirror defogger
26. ECU−IG 15 A: Cruise control system, anti−lock brake system, vehicle skid control system, locking with wireless remote control system, theft deterrent system
Instrument panel
Instrument panel
9. HORN 10 A: Horn, theft deterrent sys-
tem
10. HAZARD 10 A: Emergency flashers 11. AM2 30 A:
“IGN” and
“STARTER”
fuses
12. HEAD (LH) 15 A: Left−hand headlight
(high beam)
13. RADIO NO.1 20 A: Car audio system
14. DOME 10 A: Clock, personal
lights, vanity mirror lights, door courtesy lights, luggage compartment light, open door warning light, ignition switch light, theft deterrent system, daytime running light system, interior lights, air condi- tioning system, wireless remote control, garage door opener
15. ECU−B 10 A: Cruise control system, SRS warning light, power sliding door
16. FOG 20 A: Front fog lights 17. ABS NO.3 25 A: Vehicle skid control
system
2002 MY SIENNA_U (OM45407U)
321
02 SIENNA_U (L/O 0107)
50. PWR 30 A: Power windows, electric moon roof, power seat, power sliding door (right side), “PWR−VENT” fuse
51. AM1 40 A:
“ECU−IG”, “GAUGE” and “TURN” fuses
“CIG”, “WIPER”,
“RADIO NO.2”, “HEATER”,
Fuses (type C) 52. ALT 140 A: Charging system,
ABS”, fuses
“INP”,
“HTR” and
“FL “R/R A/C”
53. INP 100 A: “AM1” and “DEF” fuses 54. FL ABS 60 A: Anti−lock brake system
27. IGN 5 A: Gauges and meters, charging system, SRS airbag system, seat belt injection pretensioners, multiport system/sequential multiport injec- tion system
fuel
fuel
28. STOP 15 A: Stop lights, cruise control tail
system, high−mounted stoplight, lights
29. TAIL 10 A: Parking lights, front side marker lights, license plate lights, tail lights, power sliding door
30. PWR−VENT 15 A: Power rear quarter
windows
31. OBD 7.5 A: On−board diagnosis sys-
tem
32. PWR−OUTLET 15 A: Power outlets 33. STARTER 5 A: Multiport fuel injection injec-
system/sequential multiport tion system
fuel
34. DOOR 25 A: Power door lock system,
theft deterrent system
35. PANEL 7.5 A: Gauge and meter, car audio system, clock, air conditioning system, instrument panel light control, rear window defogger, electronically controlled automatic transmission sys- tem, parking lights, seat heaters, power rear quarter windows, power sliding door
emergency
flashers,
322
36. TURN 7.5 A: Turn signal lights, emer-
gency flashers
37. RADIO NO.2 7.5 A: Car audio system 38. CIG 15 A: Cigarette lighter, clock, pow- er rear view mirror controls, SRS air- bag system, seat belt pretensioners, back−up lights, theft deterrent system, air conditioning system
39. A/C 5 A: Front air conditioning system Fuses (type B) 40. CDS 40 A: Electric cooling fans 41. RDI 40 A: Electric cooling fans 42. CDS 30 A: Electric cooling fans 43. RDI 30 A: Electric cooling fans 44. MAIN 40 A: Daytime running light sys- tem, “H−LP RH (LO)” and “H−LP LH (LO)” fuses
45. R/R A/C 40 A: Rear air conditioning
system
46. HTR 50 A: Front air conditioning sys-
tem
47. PWR SLD 30 A: Power sliding door
(left side)
48. Rr CLR 40 A: Rear air conditioning
system
49. DEF 30 A: Rear window defogger,
“MIRROR−HEATER” fuse
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
SECTION 9
REPORTING SAFETY DEFECTS FOR U.S. OWNERS AND UNIFORM TIRE QUALITY GRADING Reporting safety defects for U.S. owners Uniform tire quality grading
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
324
324
2002 MY SIENNA_U (OM45407U)
323
02 SIENNA_U (L/O 0107)
To contact NHTSA, you may ei- ther call the Auto Safety Hotline toll−free at 1−800−424−9393 (or 366−0123 in Washington, D.C. area) or write to: NHTSA, U.S.De- partment of Transportation, Wash- ington, D.C. 20590. You can also obtain other information about mo- tor vehicle safety from the Hotline.
Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.
campaign.
324
2002 MY SIENNA_U (OM45407U)
Uniform tire quality grading This information has been prepared in ac- cordance with regulations issued by the National Highway Traffic Safety Adminis- tration of the U.S. Department of Trans- portation. It provides the purchasers and/ or prospective purchasers of Toyota vehicles with information on uniform tire quality grading. Your Toyota dealer will help answer any questions you may have as you read this information. DOT quality grades—All passenger car tires must conform to Federal Safety Requirements these grades. Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A
in addition
to
from
treadwear grade
Treadwear—The
is a
comparative rating based on the wear rate
of the tire when tested under controlled
conditions on a specified government test
course. For example, a tire graded 150
would wear one and a half (1−1/2) times
as well on the government course as a
tire graded 100. The relative performance
of tires depends upon the actual condi-
tions of their use, however, and may de-
part significantly
the norm due to
variations in driving habits, service prac-
tices and differences in road characteris-
tics and climate.
Traction AA, A, B, C—The
traction
grades, from highest to lowest, are AA, A,
B, and C, and they represent the tire’s
ability to stop on wet pavement as mea-
sured under controlled conditions on spe-
cified government test surfaces of asphalt
and concrete. A tire marked C may have
poor traction performance.
Warning: The traction grade assigned to
this
is based on braking (straight
ahead) traction tests and does not include
cornering (turning) traction.
tire
02 SIENNA_U (L/O 0107)
Temperature A, B, C—The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissi- pate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to de- generate and reduce tire life, and exces- sive temperature can lead to sudden tire failure. The grade C corresponds to a lev- el of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No.109. Grades B and A represent higher levels of perfor- mance on the laboratory test wheel than the minimum required by law. Warning: The temperature grades for this tire are established for a tire that is prop- erly inflated and not overloaded. Exces- sive speed, underinflation, or excessive loading, either separately or in combina- tion, can cause heat buildup and possible tire failure.
2002 MY SIENNA_U (OM45407U)
325
02 SIENNA_U (L/O 0107)
326
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Quick index D If a service reminder indicator or warning buzzer comes on D If your vehicle will not start D If your engine stalls while driving D If your vehicle overheats D If you have a flat tire D If your vehicle needs to be towed D Tips for driving during break−in period D How to start the engine D General maintenance Gas station information Fuel type:
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
138
252
255
255
256
265
224
240
279
UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher. For improved vehicle performance, the use of premium unleaded gasoline with an Octane Rating of 91 (Research Octane Number 96) or higher is recommended. See page 224 for detailed information.
Fuel tank capacity: 79 L (21 gal., 17.5 lmp. gal.) Engine oil:
API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recommended. See page 292 for detailed information.
Automatic transmission fluid:
Automatic transmission fluid D−II or DEXRONrIII (DEXRONrII)
Tire information: See pages 296 through 301. Tire pressure: See page 319.
gU−7
Publication No. OM45407U
Part No. 01999-45407
Printed in Japan 01−0107−00
(U)
02 SIENNA_U (L/O 0107)
You should know as much about the quality and importance of proper maintenance of your new vehicle as the people who built it.
The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly perform your own maintenance.
The best way to keep your new vehicle in top running order is to maintain it properly from the moment you drive it off the showroom floor.
The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle.
02 SIENNA_U (L/O 0107)
Maintenance procedures for the engine, chassis, body, electrical system, and more, are clearly explained and illustrated.
Periodic maintenance and tune−up
Periodic maintenance and tune−up helps to pre- vent small problems from growing into larger ones lat- er on. The repair manual outlines exactly what main- tenance is required and clearly explains how to do the work yourself step−by−step.
Areas covered include such things as spark plug re- placement, valve clearance adjustment and engine oil and filter replacement.
Where to obtain the
Repair Manual
The repair manual for SIENNA, written in Eng- lish, may be purchased as applicable from any Toyota dealer. Pub. Name: 2002 SIENNA Repair Manual Pub. No.: RM871U1 (Maintenance, Preparation, Service specifications and Diagnos- tics) RM871U2 (Engine, Chassis and Body)
02 SIENNA_U (L/O 0107)
Foreword
Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the following pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality maintenance and any other assistance you may require. If there is not a Toyota dealer near you, or you need emergency assistance for any reason, please call the following number:
D U.S. OWNERS: D CANADIAN OWNERS: Toyota Canada Customer Interaction Centre
Toyota Customer Assistance Center
Toll−free:1−800−331−4331
Toll−free:1−888−TOYOTA−8 (1−888−869−6828)
Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle.
© 2001 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Important information about this manual
Safety and vehicle damage warnings
Safety symbol
Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows:
CAUTION
This is a warning against something which may cause injury to people if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk to yourself and other people.
NOTICE
This is a warning against something which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.
the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”.
ii
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Important information about your Toyota
New vehicle warranty
Your new vehicle is covered by the following Toyota limited warranties:
D New vehicle warranty D Emission control systems warranty D Others further
information, please refer
Information Booklet” or
For Warranty Supplement”.
to the “Owner’s “Owner’s Manual
Your responsibility for
maintenance
It is the owner’s responsibility to make sure that the speci- fied maintenance is performed. Section 6 gives details of these maintenance requirements. Also included in Section 6 is general maintenance. For scheduled maintenance in- formation, please refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”.
Accessories, spare parts and modification of your Toyota
A wide variety of non−genuine spare parts and accessories for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these prod- ucts and is not responsible for their performance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle.
This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durability, and may even violate governmental regulations. In addi- tion, damage or performance problems resulting from the modification may not be covered under warranty.
iii
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Spark ignition system of your
Scrapping of your Toyota
If
The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by the qualified service shop or by your Toyota dealer before you dispose of your vehicle.
the vehicle
Toyota
The spark ignition system in your Toyota meets all require- ments of the Canadian Interference−Causing Equipment Standard.
Installation of a mobile two−way radio system
As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as multi- port fuel injection system/sequential multiport fuel injection system, cruise control system, anti−lock brake system, traction control system, vehicle skid control system, SRS airbag system and seat belt pretensioner system, be sure to check with your Toyota dealer for precautionary mea- sures or special instructions regarding installation.
iv
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
SECTION 1− 1
OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview Instrument cluster overview Indicator symbols on the instrument panel
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Instrument panel overview
1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Automatic transmission selector lever 5. Center vents 6. Garage door opener, garage door
opener box or auxiliary box
7. Electric moon roof switch, front
personal light or front interior light switch
8. Front personal lights or front interior
light
9. Power door lock switches 10. Power window switches 11. Glove box 12. Auxiliary boxes 13. Tilt steering lock release lever 14. Hood lock release lever 15. Parking brake pedal 16. Window lock switch
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
1. Headlight, turn signal and front fog
light switches
2. Wiper and washer switches 3. Clock and front passenger’s seat belt
reminder light
4. Emergency flasher switch 5. Front air conditioning controls 6. Rear fan speed selector or rear fan
position selector
7. Rear window and outside rear view
mirror defoggers switch
8. Car audio 9. Seat heater switches 10. Ashtray 11. Power sliding door switches 12. Power outlet 13. Cigarette lighter 14. Power rear quarter window switch 15. Ignition switch 16. Cruise control switch 17. Audio remote control buttons 18. Power sliding door off switch
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
19. Tire pressure warning system reset switch or traction control system off switch
20. Theft deterrent system/Engine
immobiliser system indicator light
21. Power rear view mirror control switches 22. Instrument panel light control dial
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Instrument cluster overview "With tachometer
1. Engine coolant temperature gauge 2. Tachometer 3. Service reminder indicators and
indicator lights
4. Speedometer 5. Fuel gauge 6. Trip meter reset knob
7. Odometer and two trip meters
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
"Without tachometer
1. Engine coolant temperature gauge 2. Service reminder indicators and
indicator lights
3. Speedometer
4. Odometer and two trip meters 5. Fuel gauge 6. Trip meter reset knob
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Indicator symbols on the instrument panel
or
Brake system warning light∗1
or
Anti−lock brake system warning light∗1
Driver’s seat belt reminder light∗1
Open door warning light∗1
Front passenger’s seat belt reminder light∗1
Open power sliding door warning light∗1
Discharge warning light∗1
SRS warning light∗1
or
Malfunction indicator lamp∗1
Vehicle skid control system/traction control
system warning light∗1
Low windshield washer fluid level warning light∗1
Low fuel level warning light∗1
Low tire pressure warning light∗1
Low engine oil pressure warning light∗1
Turn signal indicator lights
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Headlight high beam indicator light
Overdrive−off indicator light
Cruise control indicator light∗2
Automatic transmission indicator lights
Slip indicator light
Traction control system off indicator light
∗1: For details, see “Service reminder indicators and warning
buzzers” in Section 1−5.
∗2: If this light flashes, see “Cruise control” in Section 1−6.
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
SECTION 1− 2
OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors
Keys
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
Engine immobiliser system
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
13
Front doors
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
14
Sliding door
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
16
Power sliding door
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
19
Wireless remote control
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
24
Power windows
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
30
Power rear quarter windows
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
32
Center side windows and manual rear quarter windows
. . . . . . . . . .
33
Back door
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
33
Hood
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
34
Theft deterrent system
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
35
Fuel tank cap
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
37
Electric moon roof
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
39
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Keys (without engine immobiliser system)
Keys (with engine immobiliser system)
Your vehicle is supplied with two kinds of keys. 1. Master key—This key works in every
lock.
2. Sub key—This key will not work in the
glove box.
To protect things locked in the glove box when you have your vehicle parked, leave the sub key with the attendant. Since the front doors and sliding doors can be locked without a key, you should always carry a spare master key in case you accidentally lock your keys inside the vehicle.
KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by a Toyota dealer using the key number. We recommend you to write down the key number and keep it in safe place.
Your vehicle is supplied with two kinds of keys. 1. Master key (black)—This key works in lock. Your Toyota dealer will every need it to make you a new key with built−in transponder chip.
2. Sub key (gray)—This key will not work
in the glove box.
A transponder chip for engine immobiliser system has been filled in the head of the master and sub keys. These chips are needed to enable the system to function correctly, so be careful not to lose these keys. If you make your own duplicate key, you will not be able to cancel the system or start the engine.
10
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
To protect things locked in the glove box when you have your vehicle parked, leave the sub key with the attendant. Since the front doors and sliding doors can be locked without a key, you should always carry a spare master key in case you accidentally lock your keys inside the vehicle.
NOTICE
the
When using a key containing a trans- ponder chip, observe following precautions: z When starting the engine, do not use the key with a key ring resting on the key grip and do not press the key ring against the key grip. Otherwise the engine may not start, or may stop soon after it starts.
z When starting the engine, do not use the key with other transponder keys around (including keys of oth- er vehicles) and do not press other key plates against the key grip. Otherwise the engine may not start, or may stop soon after it starts. If this happens, remove the key once and then insert it again after taking off other transponder keys (includ- ing keys of other vehicles) from the ring or while gripping or covering them with your hand to start the engine.
2002 MY SIENNA_U (OM45407U)
11
02 SIENNA_U (L/O 0107)
z Do not cover the key grip with any material that cuts off electromagnet- ic waves.
z Do not knock the key hard against
other objects.
z Do not leave the key exposed to high temperatures for a long period, such as on the dashboard and hood under the direct sunlight.
z Do not put the key
in water or
wash it in an ultrasonic washer.
z Do not bend the key grip.
z Do not use the key with electromag-
netic materials.
KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by a Toyota dealer using the key number. We recommend you to write down the key number and keep it in safe place.
12
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Engine immobiliser system
Inserting the registered key in the ignition switch automatically cancels the system, which enables the engine to start. The indicator light will go off. For your Toyota dealer to make you a new key with built−in transponder chip, your dealer will need your key number and master key. However, there is a limit to the number of additional keys your Toyota dealer can make for you. If you make your own duplicate key, you will not be able to cancel the sys- tem or start the engine.
NOTICE
remove or disas- Do not modify, immobiliser sys- semble the engine tem. If any unauthorized changes or modifications are made, the proper operation of the system cannot be guaranteed.
immobiliser system
The engine is a theft prevention system. When you in- sert the key in the ignition switch, the transponder chip the key’s head transmits an electronic code to the ve- hicle. The engine will start, only when the electronic code in the chip corre- sponds to the registered ID code for the vehicle.
in
indicator
light will start
The system is automatically set when the key is removed from the ignition switch. The flashing to show the system is set. If any of the following indicator conditions occurs, contact your Toyota dealer. D The
light stays on except when the theft deterrent system is set- ting or activating. (See “Theft deterrent system”.)
indicator
D The indicator light does not start flash- ing when the key is removed from the ignition switch.
D The indicator light flashes unsteady.
2002 MY SIENNA_U (OM45407U)
13
02 SIENNA_U (L/O 0107)
For vehicles sold in U.S.A.
For vehicles sold in Canada
Front doors
This device complies with RSS−210 of Industry Canada. Operation is subject to the following two conditions: (1) This device may not cause interfer- ence, and (2) this device must accept any interference that may cause undesired operation of the device.
interference,
including
FCC ID: MOZ RI−4BTY MADE IN JAPAN This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, includ- ing interference that may cause unde- sired operation.
CAUTION
Changes or modifications not ex- pressly approved by the party respon- sible for compliance could void the user’s authority to operate the equip- ment.
14
2002 MY SIENNA_U (OM45407U)
LOCKING AND UNLOCKING WITH KEY Insert the key into the keyhole and turn it. To lock: Turn the key forward. To unlock: Turn the key backward. Vehicles with power door lock system—All the doors lock and unlock simultaneously with either front door. In the driver’s door lock, turning the key once will unlock the driver’s door and twice in succession will unlock all the doors simultaneously.
02 SIENNA_U (L/O 0107)
LOCKING AND UNLOCKING WITH POWER DOOR LOCK SWITCH Push the switch. To lock: Push the switch on the front side. To unlock: Push the switch on the rear side. All the doors lock or unlock simultaneous- ly.
CAUTION
Before driving, be sure that the doors are closed and locked, especially when small children are in the ve- hicle. Along with the proper use of locking the doors helps seat belts, prevent the driver and passengers from being thrown out from the ve- hicle during an accident. It also helps prevent the doors from being opened unintentionally.
Driver’s side
LOCKING AND UNLOCKING WITH INSIDE LOCK KNOB Move the lock knob. To lock: Push the knob forward. To unlock: Pull the knob backward. Closing the front door with the lock knob in the lock position will also lock the front door. Be careful not to lock your keys in the vehicle. Vehicles with power door sys- tem—The door cannot be locked if you leave the key in the ignition switch.
lock
Passenger’s side
2002 MY SIENNA_U (OM45407U)
15
02 SIENNA_U (L/O 0107)
Sliding door
CLOSING FROM OUTSIDE To close the fully−opened sliding door, pull the outside handle toward you and then close the door.
Lock release button
LOCKING AND UNLOCKING WITH KEY (on some models) Insert the key into the keyhole and turn it. To lock: Turn the key forward. To unlock: Turn the key backward.
LOCKING AND UNLOCKING WITH INSIDE LOCK KNOB Move the lock knob. To lock: Push the knob downward. To unlock: Push the knob upward. To open the sliding door, push the lock release button and then open the door.
16
2002 MY SIENNA_U (OM45407U)
lock
Vehicles with power door sys- tem—The sliding doors will be locked si- multaneously when either front door or the back door is locked with the power door lock switch or key. If you lock either front door or the back door with the power door lock switch or key while the sliding door is open, the sliding door will be locked after it is closed. (For instructions, see “Front doors” or “Back door” in this sec- tion.) Closing the sliding door with the lock knob in the lock position will also lock the slid- ing door. Be careful not to lock your keys in the vehicle. CLOSING FROM INSIDE To close push the close the door.
fully−opened sliding door, then
the lock release button and
02 SIENNA_U (L/O 0107)
D When the vehicle is stopped on a gradient, the door will slide faster when opening or closing, so be es- pecially careful that the passengers do not get hit or pinched by the door.
the door
D When stopping on a downward slope, open fully while passengers are getting on or off. Do not pull the outside handle or push the lock release button while the door is open as the door could suddenly close by itself causing in- jury.
NOTICE
Do not close the sliding door by ap- plying the brakes. Doing so could cause the door to be damaged.
CAUTION
D When closing the sliding door, con- firm safety of the area around. Keep the heads, hands and other parts of the bodies of all occupants away from the sliding door. Other- wise, they will be possibly caught and pinched by the closing door causing an unexpected serious inju- ry.
2002 MY SIENNA_U (OM45407U)
17
02 SIENNA_U (L/O 0107)
Vehicles with power sliding door system— If the power sliding door system is on, the child−protector feature is cancelled when someone pushes one of the “DOOR L”, “DOOR R” and “PWR DOOR” switches the vehicle or “POWER DOOR”, inside “D−PWR DOOR” and “P−PWR DOOR” the wireless remote control switches of transmitter. (For details, “Power sliding door” in this section.)
see
CAUTION
Make sure to turn off the power slid- ing door system after the child−protectors.
locking
SLIDING DOOR CHILD−PROTECTORS Open the sliding door fully and move the lock lever to the “LOCK” position as shown on the label. Then close the sliding door. If the child−protector is locked, you cannot open the sliding door from the inside. We recommend using feature whenever small children are in the vehicle.
this
DOOR
SLIDING
HALF−OPENED STOPPER When opening the left side sliding door, it stops at the half−opened position if the fuel filler door is opened. Left and right side power sliding door models—The left side power sliding door does not operate when the fuel filler door is open.
NOTICE
Avoid forcibly opening the left side sliding door refueling. Otherwise, the fuel filler door may be damaged.
fully when
18
2002 MY SIENNA_U (OM45407U)
02 SIENNA_U (L/O 0107)
Power sliding door Some vehicles are equipped with a power sliding door. This system has the following functions: D The power sliding door can be oper- ated with the “DOOR L”, “DOOR R” and “PWR DOOR” switches inside the vehicle or “POWER DOOR”, “D−PWR DOOR” and “P−PWR DOOR” switches of the wireless remote control transmit- ter. (For details about the wireless re- mote control transmitter, see “Wireless remote control” in this section.) D If you move the sliding door
to the opening or closing direction by hand, the sliding door will automatically and completely open or close after you let go of the sliding door.
CAUTION
Do not leave small children or pets unattended in your vehicle. They could operate the power sliding door, and they themselves or others could be injured. Turn off the power sliding door system when the power sliding door is not in use.
When the power sliding door system is on, you can open and close the sliding door with the “DOOR L”, “DOOR R” and “PWR DOOR” switches inside the vehicle or “POWER DOOR”, “D−PWR DOOR” and “P−PWR DOOR” switches of the wireless remote control transmitter even if the slid- ing door child−protector is locked. If small children or pets are in the vehicle, turn off the system to prevent the accidental op- eration of the door.
CAUTION
When jacking up the vehicle, turn off the power sliding door system and close the sliding door completely.
NOTICE
When your vehicle goes through an automatic car wash, make sure the power sliding door system is off.
the power sliding door,
“PWR DOOR OFF” SWITCH This switch is used to turn on and off the power sliding door system. For op- erating the “PWR DOOR OFF” switch on the instru- ment panel must be pushed out. (The orange line on the top of the switch indicates that the system is on.) To dis- able the power sliding door feature, push in the switch.
2002 MY SIENNA_U (OM45407U)
19
02 SIENNA_U (L/O 0107)
D To open the power sliding door when the ignition key is in the “ON” position, the transmission selector lever must be in “P”. (To close the sliding door from the fully−opened or half−opened posi- tion, the transmission selector lever is not required to be in “P”.)
Left and right side power sliding door models—The left side power sliding door does not operate when the fuel filler door is opened.
CAUTION
If you shift the automatic transmis- sion selector lever out of “P” and accelerate before the power sliding door is closed completely, the sliding door may reverse to the open posi- tion. A child or others could fall out of the vehicle and be injured. Always make sure the power sliding door is closed and latched before you start driving.
the switch. The power sliding
OPENING AND CLOSING WITH “DOOR L”, “DOOR R” AND “PWR DOOR” SWITCHES Push door opens and closes completely. Left side power sliding door— To open: Push the “DOOR L” switch or “PWR DOOR” switch of the left side cen- ter pillar. To close: Push the “DOOR L” switch or “PWR DOOR” switch of the left side cen- ter pillar again. Right side power sliding door— To open: Push the “DOOR R” switch or “PWR DOOR” switch of the right side cen- ter pillar. To close: Push the “DOOR R” switch or “PWR DOOR” switch of the right side cen- ter pillar again. Opening and closing can be performed by the “PWR DOOR” switches under the following con- ditions: D The sliding door is unlocked. D The power sliding door system is on. is
“PWR DOOR OFF” switch
“DOOR R” and
“DOOR L”,
(The pushed out.)
2002 MY SIENNA_U (OM45407U)
Instrument panel
Center pillar
20
02 SIENNA_U (L/O 0107)
OPENING BY HAND
When the power sliding door system is
on, if you pull the outside door handle or
push the inside lock release button to re-
lease the sliding door, it will then automat-
ically and completely open.
When the power sliding door system is
off, open the sliding door as usual.
CLOSING BY HAND
When the power sliding door system is
on, if you slide the door about 10 cm (4
in.) to the closing direction and let the
door go,
it will automatically and com-
pletely close.
When the power sliding door system is
off, close the sliding door as usual.
“DOOR R” and inside
If you forcibly close the power sliding door by hand when the ignition key is in the “ON” position, the open power sliding door warning light may stay on. In this case, try opening and closing the power sliding door again by hand slowly, or use one of the “DOOR L”, “PWR DOOR” switches the vehicle or “POWER DOOR”, “D−PWR DOOR” and “P−PWR DOOR” switches of the wireless remote control transmitter. If you shift out of “P” when the power sliding door is opened or in the process of closing with the power sliding door sys- tem on, a buzzer will sound and the open power sliding door warning light will flash. This is a warning that the sliding door is not completely closed.
DOOR
POWER
OPEN SLIDING WARNING LIGHT AND BUZZER This light on the instrument panel comes on if the power sliding door is not com- pletely closed with the ignition key in the “ON” position. (See “Service reminder indi- cators and warning buzzers” in Section 1−5.)
2002 MY SIENNA_U (OM45407U)
21
02 SIENNA_U (L/O 0107)
The resistance must be as strong as the force of the moving door, or stronger. As the sliding door approaches fully− closed or fully−opened position, its moving force increases significantly. If the sliding door receives a strong im- pact, this function may work even if noth- ing is caught.
the
CAUTION
Power sliding door could injure people if they are caught in the door path. When using the power sliding door, observe the following: D Never try jamming any part of your jam protection
body to make the function work intentionally.
D You must always make sure
the heads, hands and other parts of the bodies of all occupants are away from the sliding door. If someone’s neck, head or hand gets caught in a closing sliding door, it could re- sult in a serious injury. When any- one closes the power sliding door, make sure he/she operates the slid- ing door safely.
NOTICE