2001 Toyota Sienna Owners Manual

Clear or light yellow

Type B

Blue

White

Red

CHECKING BY HYDROMETER Check hydrometer color.

the battery condition by

the

Hydrometer color

Type A

Type B

Condition

Green

Blue

Good

Dark

White

Charging necessary. Have battery checked by your Toyota dealer.

Battery recharging precautions During recharging, the battery is pro- ducing hydrogen gas. Therefore, before recharging: 1. If recharging with the battery installed on the vehicle, be sure to disconnect the ground cable.

2. Be sure the power switch on the re- charger the charger cables to the battery and when disconnecting them.

is off when connecting

CAUTION

D Always charge the battery in an un- confined area. Do not charge the battery in a garage or closed room where there is not sufficient ventila- tion.

D Only do a slow charge (5 A or less). Charging at a quicker rate is dangerous. The battery may ex- plode, causing personal injuries.

NOTICE

Clear or

light yellow

Red

Have battery checked by your Toyota dealer.

Never recharge the battery while the engine is running. Also, be sure all accessories are turned off.

2001 MY SIENNA (OM45406U)

301

01 SIENNA_U (L/O0008)

Checking and replacing fuses

Type A

Type B

Type C

Good

Blown

Good

Blown

Good

Blown

If the headlights or other electrical components do not work, check the fuses. If any of the fuses are blown, they must be replaced. See “Fuse locations” in Section 7−1 for locations of the fuses. Turn the ignition switch and inoperative component off. Pull a suspected fuse straight out and check it. Determine which fuse may be causing the problem. The lid of the fuse box shows the name of the circuit for each fuse. See Section 8 of this manual for the functions controlled by each circuit.

302

2001 MY SIENNA (OM45406U)

Type A fuses can be pulled out by the pull−out tool. The location of the pull−out tool is shown in the illustration. If you are not sure whether the fuse has blown, try replacing the suspected fuse with one that you know is good. If the fuse has blown, push a new fuse into the clip. Only install a fuse with the amperage rat- ing designated on the fuse box lid. If you do not have a spare fuse, in an emergency you can pull out the “A/C”, “RADIO or “RADIO NO.1” fuse, which may be dispensable for normal driving, and use it if its amperage rating is the same. If you cannot use one of the same amper- age, use one that is lower, but as close as possible to, the rating. If the amperage is fuse might blow out again but this does not indicate anything wrong. Be sure to get the correct fuse as soon as possible and return the substitute to its original clip. It is a good idea to purchase a set of spare fuses and keep them in your ve- hicle for emergencies.

“PWR−OUTLET”

that specified,

NO.2”,

lower

than

the

01 SIENNA_U (L/O0008)

the new

If fuse immediately blows out, there is a problem with the electrical sys- tem. Have your Toyota dealer correct it as soon as possible.

CAUTION

Never use a fuse with a higher am- perage rating, or any other object, in place of a fuse. This may cause ex- tensive damage and possibly a fire.

Adding washer fluid If any washer does not work or low windshield washer fluid level warning light comes on, the washer tank may be empty. Add washer fluid. You may use plain water as washer fluid. in cold areas where tempera- However, tures freezing point, use fluid containing antifreeze. This washer product is available at your Toyota dealer and most auto parts stores. Follow the manufacturer’s directions for how much to mix with water.

range below

NOTICE

Do not use engine antifreeze or any other substitute because it may dam- age your vehicle’s paint.

following

illustrations show how

Replacing light bulbs— The to gain access to the bulbs. When replacing a bulb, make sure the ignition switch and light switch are off. Use bulbs with the wattage ratings given in the table.

CAUTION

Halogen bulbs have pressurized gas inside and require special handling. They can burst or shatter if scratched or dropped. Hold a bulb only by its plastic or metal case. Do not touch the glass part of a bulb with bare hands.

NOTICE

Only use a bulb of the listed type.

2001 MY SIENNA (OM45406U)

303

the

The inside of the lens of exterior lights such as headlights may temporarily fog up when the lens becomes wet in the rain or in a car wash. This is not a problem because the is caused by fogging temperature difference between the outside and the windshield fogged up in the rain. However, if there is a large drop of water on the inside of the lens, or if there is water pooled light, contact your Toyota dealer.

inside of

inside

lens,

just

like

the

the

01 SIENNA_U (L/O0008)

Light bulbs

Bulb No.

Type

Headlights Front fog lights Front turn signal and parking/side marker lights Rear turn signal lights Stop/tail lights Back−up lights License plate lights High mounted stoplight Front personal lights Front interior light Center personal lights Rear interior light Vanity mirror lights Door courtesy lights Luggage compartment light

— —

3157A

— 7743
921
168
921
— — — — — 194
—

60/55

60
27/8
21
21/5
18
18
3.8

A: HB2 halogen bulbs B: HB3 halogen bulbs C: Single end bulbs D: Wedge base bulbs E: Double end bulbs

304

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

—Headlights

1. Open the hood. Unplug the connec-

tor. Remove the rubber cover. If the connector is tight, wiggle it.

2. Release

the bulb retaining spring and remove the bulb. Install a new bulb and the bulb retaining spring.

To install a bulb, align the tabs of the bulb with the mounting hole.

the cutouts of

3. Install

the rubber cover with

the “TOP” mark upward, and snuggle on the boss. Then insert the connector. Make sure the rubber cover fits snugly on the connector and the headlight body. Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer.

2001 MY SIENNA (OM45406U)

305

01 SIENNA_U (L/O0008)

—Front turn signal and parking/side marker lights

—Front fog lights If either the left or right front fog burns out, contact your Toyota dealer.

NOTICE

Do not try to replace the front fog lights bulbs by yourself. You may damage the vehicle.

Use a Phillips−head screwdriver.

306

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

—Rear turn signal and, stop/tail lights

—Stop/tail and back−up lights

Left side of the vehicle

Remove the bolts.

a: Stop/tail light b: Rear turn signal light

Right side of the vehicle

2001 MY SIENNA (OM45406U)

307

Remove the strap and handle.

01 SIENNA_U (L/O0008)

—License plate lights

a: Back−up light b: Stop/tail light

Use a Phillips−head screwdriver.

308

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

—High mounted stoplight

Use a Phillips−head screwdriver.

2001 MY SIENNA (OM45406U)

309

01 SIENNA_U (L/O0008)

310

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

SECTION 8

SPECIFICATIONS Dimensions and weight Engine Fuel Service specifications Tires Fuses

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

312
312
313
313
315
316

2001 MY SIENNA (OM45406U)

311

01 SIENNA_U (L/O0008)

Dimensions and weight

Overall length

Overall width

Overall height

Wheelbase

Front tread

Rear tread

Vehicle capacity weight (occupants + luggage)

∗: Unladen vehicle

mm (in.)

mm (in.)

mm (in.)

mm (in.)

mm (in.)

mm (in.)

kg (lb.)

4930 (194.1)

1865

1710

(73.4) (67.3)∗

2900 (114.2)

1565

(61.6)

1610

(63.4)

526 (1160)

Engine Model:

1MZ−FE

Type:

6 cylinder V type 4 cycle, gasoline

Bore and stroke, mm (in.):

87.5 83.0 (3.44 3.27)

Displacement, cm3 (cu. in.):

2995 (182.8)

312

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Fuel Fuel type:

Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher. For improved vehicle performance, the use of premium unleaded gasoline with an Octane Rating of 91 (Research Oc- tane Number 96) or higher is recom- mended.

Fuel tank capacity, L (gal., Imp. gal.):

79 (21, 17.5)

Service specifications ENGINE Valve clearance (engine cold), mm (in.):

Intake Exhaust

0.15—0.25 (0.006—0.010) 0.25—0.35 (0.010—0.014)

Spark plug type:

DENSO NGK

SK20R11
IFR6A11

Spark plug gap, mm (in.):

1.1 (0.043)

Recommended oil viscosity (SAE):

5W-30 Preferred

Drive belt roughs No.BT−33−73F (used belt), Ibf:

tension measured with Bor- gauge

tension

drive

belt

Generator belt Power steering pump belt

125"10
115"20

ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.):

With filter Without filter

Oil grade:

4.7 (5.0, 4.1) 4.5 (4.8, 4.0)

API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recom- mended.

Temperature range anticipated before next oil change

COOLING SYSTEM Total capacity, L (qt., Imp. qt.):

10.4 (11.0, 9.2)

Coolant type:

“TOYOTA Long Life Coolant” or equiva- lent With ethylene−glycol type coolant for a proper corrosion protection of aluminum components Do not use alcohol type antifreeze or plain water alone.

2001 MY SIENNA (OM45406U)

313

01 SIENNA_U (L/O0008)

BRAKES Minimum pedal clearance when depressed with the force of 490 N (50 kgf, 110 lbf) with the engine running, mm (in.):

96 (3.8)

Pedal free play, mm (in.):

1—6 (0.04—0.24)

Pad wear limit, mm (in.):

1.0 (0.04)

Lining wear limit, mm (in.):

1.0 (0.04)

Parking brake adjustment when depressed with the force of 294 N (30 kgf, 66 lbf):

3—5 clicks

Fluid type:

BATTERY Open voltage∗ at 20_C (68_F):

12.6—12.8 V 12.2—12.4 V 11.8—12.0 V

Fully charged Half charged Discharged

∗: Voltage that is checked 20 minutes af- the

is removed with all

the key

ter lights turned off

Charging rates:

5 A max.

AUTOMATIC TRANSAXLE Fluid capacity (drain and refill), L (qt., Imp. qt.):

Up to 4.75 (5.0, 4.2)

Fluid type:

Automatic DEXRONrIII (DEXRONrII)

transmission

fluid D−ll or

SAE J1703 or FMVSS No.116 DOT 3

STEERING Wheel free play:

Less than 30 mm (1.2 in.)

Power steering fluid type:

Automatic transmission fluid DEXRONrII or III

314

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Wheel nut torque, N·m (kgf·m, ft·lbf):

104 (10.5, 77)

NOTE: For a complete

information on tires (e.g. replacing tires or re- placing wheels), see “Checking tire pressure” through “Aluminum wheel precautions” in Section 7−2.

Tires Tire size and pressure: Normal driving

Tire size

P205/70R15 95S

P215/65R15 95S

T145/80D16

Tire pressure,

kPa (kgf/cm2 or bar, psi)

240 (2.4, 35) 220 (2.2, 32)∗1
240 (2.4, 35)∗2
420 (4.2, 60)

∗1: Vehicle load up to 6 passengers ∗2: Up to vehicle capacity weight Trailer towing

Tire size

P205/70R15 95S

P215/65R15 95S

Tire pressure,

kPa (kgf/cm2 or bar, psi)

240 (2.4, 35)

240 (2.4, 35)

Wheel size

15 6.5JJ

15 6.5JJ

16 4T

Wheel size

15 6.5JJ

15 6.5JJ

When driving under the above vehicle load conditions at sustained high speeds above 160 km/h (100 mph), in countries where such speeds are permitted by−law, inflate the front and rear tires to 240 kPa (2.4 kgf/cm2 or bar, 35 psi) provided that it does not exceed the maximum cold tire pressure molded on the tire sidewall.

2001 MY SIENNA (OM45406U)

315

01 SIENNA_U (L/O0008)

Fuses

Engine compartment

Fuses (type A) 1. SEAT HTR 20 A: Seat heaters 2. A/F HTR 25 A: Air fuel ratio sensor 3. SPARE 10 A: Spare fuse 4. SPARE 15 A: Spare fuse 5. SPARE 30 A: Spare fuse 6. ALT−S 5 A: Charging system 7. HEAD (RH) 15 A: Right−hand headlight

(high beam)

Engine compartment (with towing package)

316

Engine compartment (without towing package)

2001 MY SIENNA (OM45406U)

8. EFI 15 A: Multiport fuel injection sys- injection

tem/sequential multiport system

fuel

01 SIENNA_U (L/O0008)

18. ABS NO.2 25 A: Vehicle skid control

system

19. H−LP LH (LO) 10 A: Left−hand head-

light (low beam)

20. H−LP RH (LO) 10 A: Right−hand head-

light (low beam)

21. ABS NO.4 5 A: Vehicle skid control

system

22. HEATER 10 A: Air conditioning system,

rear window defogger

23. GAUGE 10 A: Gauges and meters, service reminder indicators and warning buzzers (except discharge and open door warning light), power windows, daytime running light system, back−up lights, power sliding door, auto anti− glare inside rear view mirror, compass 24. WIPER 25 A: Windshield wipers and washer, rear window wiper and washer 25. MIRROR−HEATER 10 A: Multiport fuel system/sequential multiport injection fuel injection system, outside rear view mirror defogger

26. ECU−IG 15 A: Cruise control system, anti−lock brake system, vehicle skid control system, locking with wireless remote control system, theft deterrent system

Instrument panel

Instrument panel

9. HORN 10 A: Horn, theft deterrent sys-

tem

10. HAZARD 10 A: Emergency flashers 11. AM2 30 A:

“IGN” and

“STARTER”

fuses

12. HEAD (LH) 15 A: Left−hand headlight

(high beam)

13. RADIO NO.1 20 A: Car audio system

14. DOME 10 A: Clock, personal

lights, vanity mirror lights, door courtesy lights, luggage compartment light, open door warning light, ignition switch light, theft deterrent system, daytime running light system, interior lights, air condi- tioning system, wireless remote control, garage door opener

15. ECU−B 10 A: Cruise control system, SRS warning light, power sliding door

16. FOG 20 A: Front fog lights 17. ABS NO.3 25 A: Vehicle skid control

system

2001 MY SIENNA (OM45406U)

317

01 SIENNA_U (L/O0008)

50. PWR 30 A: Power windows, electric moon roof, power seat, power sliding door (right side), “PWR−VENT” fuse

51. AM1 40 A:

“ECU−IG”, “GAUGE” and “TURN” fuses

“CIG”, “WIPER”,

“RADIO NO.2”, “HEATER”,

Fuses (type C) 52. ALT 140 A: Charging system,

ABS”, fuses

“INP”,

“HTR” and

“FL “R/R A/C”

53. INP 100 A: “AM1” and “DEF” fuses 54. FL ABS 60 A: Anti−lock brake system

27. IGN 5 A: Gauges and meters, charging system, SRS airbag system, seat belt injection pretensioners, multiport system/sequential multiport injec- tion system

fuel

fuel

28. STOP 15 A: Stop lights, cruise control tail

system, high−mounted stoplight, lights

29. TAIL 10 A: Parking lights, front side marker lights, license plate lights, tail lights, power sliding door

30. PWR−VENT 15 A: Power rear quarter

windows

31. OBD 7.5 A: On−board diagnosis sys-

tem

32. PWR−OUTLET 15 A: Power outlets 33. STARTER 5 A: Multiport fuel injection injec-

system/sequential multiport tion system

fuel

34. DOOR 25 A: Power door lock system,

theft deterrent system

35. PANEL 7.5 A: Gauge and meter, car audio system, clock, air conditioning system, instrument panel light control, rear window defogger, electronically controlled automatic transmission sys- tem, parking lights, seat heaters, power rear quarter windows, power sliding door

emergency

flashers,

318

36. TURN 7.5 A: Turn signal lights, emer-

gency flashers

37. RADIO NO.2 7.5 A: Car audio system 38. CIG 15 A: Cigarette lighter, clock, pow- er rear view mirror controls, SRS air- bag system, seat belt pretensioners, back−up lights, theft deterrent system, air conditioning system

39. A/C 5 A: Front air conditioning system Fuses (type B) 40. CDS 40 A: Electric cooling fans 41. RDI 40 A: Electric cooling fans 42. CDS 30 A: Electric cooling fans 43. RDI 30 A: Electric cooling fans 44. MAIN 40 A: Daytime running light sys- tem, “H−LP RH (LO)” and “H−LP LH (LO)” fuses

45. R/R A/C 40 A: Rear air conditioning

system

46. HTR 50 A: Front air conditioning sys-

tem

47. PWR SLD 30 A: Power sliding door

(left side)

48. Rr CLR 40 A: Rear air conditioning

system

49. DEF 30 A: Rear window defogger,

“MIRROR−HEATER” fuse

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

SECTION 9

REPORTING SAFETY DEFECTS FOR U.S. OWNERS AND UNIFORM TIRE QUALITY GRADING Reporting safety defects for U.S. owners Uniform tire quality grading

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

320
320

2001 MY SIENNA (OM45406U)

319

01 SIENNA_U (L/O0008)

To contact NHTSA, you may either call the Auto Safety Hotline toll− at free (or 1−800−424−9393 366−0123 in Washington, D.C. area) or write to: NHTSA, U.S.De- partment of Transportation, Wash- ington, D.C. 20590. You can also obtain other information about mo- tor vehicle safety from the Hotline.

Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.

campaign.

320

2001 MY SIENNA (OM45406U)

Uniform tire quality grading This information has been prepared in ac- cordance with regulations issued by the National Highway Traffic Safety Adminis- tration of the U.S. Department of Trans- portation. It provides the purchasers and/ or prospective purchasers of Toyota vehicles with information on uniform tire quality grading. Your Toyota dealer will help answer any questions you may have as you read this information. DOT quality grades—All passenger car tires must conform to Federal Safety Requirements these grades. Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A

in addition

to

from

treadwear grade

Treadwear—The is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150
would wear one and a half (1−1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual condi- tions of their use, however, and may de- part significantly the norm due to variations in driving habits, service prac- tices and differences in road characteris- tics and climate. Traction AA, A, B, C—The traction grades, from highest to lowest, are AA, A, B, and C, and they represent the tire’s ability to stop on wet pavement as mea- sured under controlled conditions on spe- cified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this is based on braking (straight ahead) traction tests and does not include cornering (turning) traction.

tire

01 SIENNA_U (L/O0008)

Temperature A, B, C—The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissi- pate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to de- generate and reduce tire life, and exces- sive temperature can lead to sudden tire failure. The grade C corresponds to a lev- el of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No.109. Grades B and A represent higher levels of perfor- mance on the laboratory test wheel than the minimum required by law. Warning: The temperature grades for this tire are established for a tire that is prop- erly inflated and not overloaded. Exces- sive speed, underinflation, or excessive loading, either separately or in combina- tion, can cause heat buildup and possible tire failure.

2001 MY SIENNA (OM45406U)

321

01 SIENNA_U (L/O0008)

322

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

gU−6

Quick index D If a service reminder indicator or warning buzzer comes on D If your vehicle will not start D If your engine stalls while driving D If your vehicle overheats D If you have a flat tire D If your vehicle needs to be towed D Tips for driving during break−in period D How to start the engine D General maintenance Gas station information Fuel type:

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

138
250
253
253
254
263
222
238
277

UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher. For improved vehicle performance, the use of premium unleaded gasoline with an Octane Rating of 91 (Research Octane Number 96) or higher is recommended. See page 222 for detailed information.

Fuel tank capacity: 79 L (21 gal., 17.5 lmp. gal.) Engine oil:

API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recommended. See page 290 for detailed information.

Automatic transmission fluid:

Automatic transmission fluid D−II or DEXRONrIII (DEXRONrII)

Tire information: See pages 294 through 298. Tire pressure: See page 315.

2001 MY SIENNA (OM45406U)

Publication No. OM45406U Part No. 01999-45406
Printed in Japan 01−0008−00

(U)

01 SIENNA_U (L/O0008)

You should know as much about the quality and importance of proper maintenance of your new vehicle as the people who built it.

The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly perform your own maintenance.

The best way to keep your new vehicle in top running order is to maintain it properly from the moment you drive it off the showroom floor.

The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle.

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Maintenance procedures for the engine, chassis, body, electrical system, and more, are clearly explained and illustrated.

Periodic maintenance and tune−up

Periodic maintenance and tune−up helps to pre- vent small problems from growing into larger ones lat- er on. The repair manual outlines exactly what main- tenance is required and clearly explains how to do the work yourself step−by−step.

Areas covered include such things as spark plug re- placement, valve clearance adjustment and engine oil and filter replacement.

Where to obtain the

Repair Manual

The repair manual for SIENNA, written in Eng- lish, may be purchased as applicable from any Toyota dealer. Pub. Name: 2001 SIENNA Repair Manual Pub. No.: RM787U1 (Maintenance, Preparation, Service specifications and Diagnos- tics) RM787U2 (Engine, Chassis and Body)

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Foreword

Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the follow- ing pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality mainte- nance and any other assistance you may require. Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle.

© 2000 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Important information about this manual

Safety and vehicle damage warnings

Safety symbol

Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows:

CAUTION

This is a warning against something which may cause injury to people if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk to yourself and other people.

NOTICE

This is a warning against something which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.

the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”.

ii

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Important information about your Toyota

New vehicle warranty

Your new vehicle limited warranties:

is covered by

the

following Toyota

D New vehicle warranty D Emission control systems warranty D Others further

information, please refer

Information Booklet” or

For Warranty Supplement”.

to the “Owner’s “Owner’s Manual

Your responsibility for maintenance

It is the owner’s responsibility to make sure that the specified maintenance is performed. Section 6 gives de- tails of these maintenance requirements. Also included in Section 6 is general maintenance. For scheduled maintenance information, please refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”.

Accessories, spare parts and modification of your Toyota

A wide variety of non−genuine spare parts and accesso- ries for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these products and is not responsible for their perfor- mance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle.

This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durabili- ty, and may even violate governmental regulations. In addition, damage or performance problems resulting from the modification may not be covered under warranty.

iii

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Spark ignition system of

your Toyota

The spark ignition system in your Toyota meets all re- quirements of the Canadian Interference−Causing Equip- ment Standard.

Installation of a mobile two−way radio system

Scrapping of your Toyota

The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. If the vehicle is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt pretensioner removed and disposed of by the quali- fied service shop or by your Toyota dealer before you dispose of your vehicle.

fuel

injection system/sequential multiport

As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as multiport fuel injection system, cruise control system, anti−lock brake system, traction control system, vehicle skid control sys- tem, SRS airbag system and seat belt pretensioner sys- tem, be sure to check with your Toyota dealer for pre- cautionary measures or special regarding installation.

instructions

iv

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

SECTION 1− 1

OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview Instrument cluster overview Indicator symbols on the instrument panel

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Instrument panel overview

1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Automatic transmission selector lever 5. Center vents 6. Garage door opener, garage door

opener box or auxiliary box

7. Electric moon roof switch, front

personal light or front interior light switch

8. Front personal lights or front interior

light

9. Power door lock switches 10. Power window switches 11. Glove box 12. Auxiliary boxes 13. Tilt steering lock release lever 14. Hood lock release lever 15. Parking brake pedal 16. Window lock switch

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

1. Headlight, turn signal and front fog

light switches

2. Wiper and washer switches 3. Clock and front passenger’s seat belt

reminder light

4. Emergency flasher switch 5. Front air conditioning controls 6. Rear fan speed selector or rear fan

position selector

7. Rear window and outside rear view

mirror defoggers switch

8. Car audio 9. Seat heater switches 10. Ashtray 11. Power sliding door switches 12. Power outlet 13. Cigarette lighter 14. Power rear quarter window switch 15. Ignition switch 16. Cruise control switch 17. Audio remote control buttons 18. Power sliding door off switch

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

19. Tire pressure warning system reset switch or traction control system off switch

20. Theft deterrent system/Engine

immobiliser system indicator light

21. Power rear view mirror control switch 22. Instrument panel light control dial

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Instrument cluster overview "With tachometer

1. Engine coolant temperature gauge 2. Tachometer 3. Service reminder indicators and

indicator lights

4. Speedometer 5. Fuel gauge 6. Trip meter reset knob

7. Odometer and two trip meters

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

"Without tachometer

1. Engine coolant temperature gauge 2. Service reminder indicators and

indicator lights

3. Speedometer

4. Odometer and two trip meters 5. Fuel gauge 6. Trip meter reset knob

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Indicator symbols on the instrument panel

or

Brake system warning light∗1

or

Anti−lock brake system warning light∗1

Driver’s seat belt reminder light∗1

Open door warning light∗1

Front passenger’s seat belt reminder light∗1

Open power sliding door warning light∗1

Discharge warning light∗1

SRS warning light∗1

or

Malfunction indicator lamp∗1

Vehicle skid control system warning light∗1

Low windshield washer fluid level warning light∗1

Low fuel level warning light∗1

Low tire pressure warning light∗1

Low oil pressure warning light∗1

Traction control system off indicator/warning light∗1

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Turn signal indicator lights

Headlight high beam indicator light

Overdrive−off indicator light

Cruise control indicator light∗2

Automatic transmission indicator lights

Slip indicator light

∗1: For details, see “Service reminder indicators and warning

buzzers” in Section 1−5.

∗2: If this light flashes, see “Cruise control” in Section 1−6.

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

SECTION 1− 2

OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors

Keys

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

10

Engine immobiliser system

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

13

Front doors

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

14

Sliding door

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

16

Power sliding door

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

19

Wireless remote control

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

24

Power windows

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

29

Power rear quarter windows

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

31

Center side windows and manual rear quarter windows

. . . . . . . . . .

32

Back door

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

33

Hood

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

34

Theft deterrent system

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

35

Fuel tank cap

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

37

Electric moon roof

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

39

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

Keys (without engine immobiliser system)

Keys (with engine immobiliser system)

Your vehicle is supplied with two kinds of keys. 1. Master key—This key works in every

lock.

2. Sub key—This key will not work in the

glove box.

To protect things locked in the glove box when you have your vehicle parked, leave the sub key with the attendant. Since the doors can be locked without a key, you should always carry a spare master key in case you accidentally lock your keys inside the vehicle.

KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by a Toyota dealer using the key number. We recommend you to write down the key number and keep it in safe place.

Your vehicle is supplied with two kinds of keys. 1. Master key (black)—This key works in lock. Your Toyota dealer will every need it to make you a new key with built−in transponder chip.

2. Sub key (gray)—This key will not work

in the glove box.

A transponder chip for engine immobiliser system has been filled in the head of the master and sub keys. These chips are needed to enable the system to function correctly, so be careful not to lose these keys. If you make your own duplicate key, you will not be able to cancel the system or start the engine.

10

2001 MY SIENNA (OM45406U)

01 SIENNA_U (L/O0008)

To protect things locked in the glove box when you have your vehicle parked, leave the sub key with the attendant. Since the side door can be locked without a key, you should always carry a spare master key in case you accidentally lock your keys inside the vehicle.

NOTICE

the

When using a key containing a trans- ponder chip, observe following precautions: z When starting the engine, do not use the key with a key ring resting on the key grip and do not press the key ring against the key grip. Otherwise the engine may not start, or may stop soon after it starts.

z When starting the engine, do not use the key with other transponder keys around (including keys of oth- er vehicles) and do not press other key plates against the key grip. Otherwise the engine may not start, or may stop soon after it starts. If this happens, remove the key once and then insert it again after taking off other transponder keys (includ- ing keys of other vehicles) from the ring or while gripping or covering them with your hand to start the engine.

2001 MY SIENNA (OM45406U)

11

01 SIENNA_U (L/O0008)

z Do not cover the key grip with any material that cuts off electromagnet- ic waves.

z Do not knock the key hard against

other objects.

z Do not leave the key exposed to high temperatures for a long period, such as on the dashboard and hood under the direct sunlight.

z Do not put the key

in water or

wash it in an ultrasonic washer.

z Do not bend the key grip.

z Do not use the key with electromag-

netic materials.

KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by a Toyota dealer using the key number. We recommend you to write down the key number and keep it in safe place.

12

2001 MY SIENNA (OM45406U)

Engine immobiliser system

01 SIENNA_U (L/O0008)

Inserting the registered key in the ignition switch automatically cancels the system, which enables the engine to start. The indicator light will go off. For your Toyota dealer to make you a new key with built−in transponder chip, your dealer will need your key number and master key. However, there is a limit to the number of additional keys your Toyota dealer can make for you. If you make your own duplicate key, you will not be able to cancel the sys- tem or start the engine.

immobiliser system

The engine is a theft prevention system. When you in- sert the key in the ignition switch, the transponder chip the key’s head transmits an electronic code to the ve- hicle. The engine will start, only when the electronic code in the chip corre- sponds to the registered ID code for the vehicle.

in

indicator

light will start

The system is automatically set when the key is removed from the ignition switch. The flashing to show the system is set. If either of the following indicator condi- tions occurs, contact your Toyota dealer. D The light stays on except when the theft deterrent system is set- ting or activating. (See “Theft deterrent system”.)

indicator

D The indicator light does not start flash- ing when the key is removed from the ignition switch.

D The indicator light flashes unsteady.

2001 MY SIENNA (OM45406U)

13

01 SIENNA_U (L/O0008)

For vehicles sold in U.S.A.

For vehicles sold in Canada

Front doors

This device complies with RSS−210 of Industry Canada. Operation is subject to the following two conditions: (1) This device may not cause interfer- ence, and (2) this device must accept any interference that may cause undesired operation of the device.

interference,

including

FCC ID: MOZ RI−4BTY MADE IN JAPAN This device complies with Part 15 of the FCC Rules. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, includ- ing interference that may cause unde- sired operation.

CAUTION

Changes or modifications not ex- pressly approved by the party respon- sible for compliance could void the user’s authority to operate the equip- ment.

14

2001 MY SIENNA (OM45406U)

LOCKING AND UNLOCKING WITH KEY Insert the key into the keyhole and turn it. To lock: Turn the key forward. To unlock: Turn the key backward. Vehicles with power door lock system—All the doors lock and unlock simultaneously with either front door. In the driver’s door lock, turning the key once will unlock the driver’s door and twice in succession will unlock all the doors simultaneously.

01 SIENNA_U (L/O0008)

LOCKING AND UNLOCKING WITH POWER DOOR LOCK SWITCH Push the switch. To lock: Push the switch on the front side. To unlock: Push the switch on the rear side. All the doors lock or unlock simultaneous- ly.

CAUTION

Before driving, be sure that the doors are closed and locked, especially when small children are in the ve- hicle. Along with the proper use of locking the doors helps seat belts, prevent the driver and passengers from being thrown out from the ve- hicle during an accident. It also helps prevent the doors from being opened unintentionally.

Driver’s side

LOCKING AND UNLOCKING WITH INSIDE LOCK KNOB Move the lock knob. To lock: Push the knob forward. To unlock: Pull the knob backward. Closing the front door with the lock knob in the lock position will also lock the front door. Be careful not to lock your keys in the vehicle. Vehicles with power door sys- tem—The door cannot be locked if you leave the key in the ignition switch.

lock

Passenger’s side

2001 MY SIENNA (OM45406U)

15

01 SIENNA_U (L/O0008)

Sliding door

CLOSING FROM OUTSIDE To close the fully−opened sliding door, pull the outside handle toward you and then close the door.

Lock release button

LOCKING AND UNLOCKING WITH KEY (on some models) Insert the key into the keyhole and turn it. To lock: Turn the key forward. To unlock: Turn the key backward.

LOCKING AND UNLOCKING WITH INSIDE LOCK KNOB Move the lock knob. To lock: Push the knob downward. To unlock: Push the knob upward. To open the sliding door, push the lock release button and then open the door.

16

2001 MY SIENNA (OM45406U)

lock

Vehicles with power door sys- tem—The sliding doors will be locked si- multaneously when either front door or the back door is locked with the power door lock switch or key. If you lock either front door or the back door with the power door lock switch or key while the sliding door is open, the sliding door will be locked after it is closed. (For instructions, see “Front doors” or “Back door” in this sec- tion.) Closing the sliding door with the lock knob in the lock position will also lock the slid- ing door. Be careful not to lock your keys in the vehicle. CLOSING FROM INSIDE To close push the close the door.

fully−opened sliding door, then

the lock release button and

01 SIENNA_U (L/O0008)

D When the vehicle is stopped on a gradient, the door will slide faster when opening or closing, so be es- pecially careful that the passengers do not get hit or pinched by the door.

the door

D When stopping on a downward slope, open fully while passengers are getting on or off. Do not pull the outside handle or push the lock release button while the door is open as the door could suddenly close by itself causing in- jury.

NOTICE

Do not close the sliding door by ap- plying the brakes. Doing so could cause the door to be damaged.

CAUTION

D When closing the sliding door, con- firm safety of the area around. Keep the heads, hands and other parts of the bodies of all occupants away from the sliding door. Other- wise, they will be possibly caught and pinched by the closing door causing an unexpected serious inju- ry.

2001 MY SIENNA (OM45406U)

17

01 SIENNA_U (L/O0008)

Vehicles with power sliding door system— If the power sliding door system is on, the child−protector feature is cancelled when someone pushes one of the “DOOR L”, “DOOR R” and “POWER DOOR” switches the vehicle or “POWER DOOR”, inside “D−PWR DOOR” and “P−PWR DOOR” switches of the wireless remote control transmitter.

CAUTION

Make sure to turn off the power slid- ing door system after the child−protectors.

locking

SLIDING DOOR CHILD−PROTECTORS Open the sliding door fully and move the lock lever to the “LOCK” position as shown on the label. Then close the sliding door. If the child−protector is locked, you cannot open the sliding door from the inside. We recommend using feature whenever small children are in the vehicle.

this

DOOR

SLIDING

HALF−OPENED STOPPER When opening the left side sliding door, it stops at the half−opened position if the fuel filler door is opened. Left and right side power sliding door models—The left side power sliding door does not operate when the fuel filler door is open.

NOTICE

Avoid forcibly opening the left side sliding door refueling. Otherwise, the fuel filler door may be damaged.

fully when

18

2001 MY SIENNA (OM45406U)