belts.
D If the seat belt extender has been connected to the driver’s seat belt buckle without the driver actually wearing the seat belt, the SRS driv- er’s airbag system will judge that the driver this case, the driver’s airbag may not activate correctly, causing death or serious injury in the event of colli- sion. Be sure to wear the seat belt with the seat belt extender.
is wearing
it.
In
For instructions and precautions con- cerning the seating position, see “—Front seat precautions” on page 34 in this Section.
CAUTION
A member of a passenger risk group should never sit or be occupied in the front passenger seat with airbag off switch in the “AUTO” position. (For details, see “SRS driver airbag and front passenger airbag” on page 53 in this Section.)
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
59
08 02.19
LS13121
LS13162
LS13115
is
in use, since
D Do not sit on the edge of the seat or lean against the dashboard when the vehicle the front passenger airbag could inflate with considerable speed and force. Anyone who is up against, or very close to, an airbag when it inflates, can be killed or seriously injured. Sit up straight and well back in the seat, and always use your seat belt properly.
D Toyota strongly recommends that all infants and children be placed in the rear seat of the vehicle and be properly restrained.
D Do not hold a child on your lap or in your arms. Use a child restraint system in the rear seat. For instruc- tions concerning the installation of a child restraint system, see “Child restraint” on page 93 in this Sec- tion.
D Do not put anything or any part of your body on or in front of the dashboard or steering wheel pad that houses the front airbag sys- tem. They might restrict inflation or cause death or serious injury as they are projected rearward by the force of the deploying airbags. Like- wise, the driver and front passenger should not hold objects their arms or on their knees.
in
60
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
the
D Do not modify or remove any wir- ing. Do not modify, remove, strike or open any components such as the steering wheel pad, steering wheel, column cover, dashboard near front passenger airbag, front passenger airbag cover, front passenger airbag or airbag sensor assembly. Doing so may prevent the front airbag system from activating correctly, cause sudden activation of the system or disable the sys- tem, which could result in death or serious injury.
Failure to follow these instructions can result in death or serious injury. Consult your Toyota dealer about any repair and modification. If you wish to modify your vehicle for a person with a physical disability, It may consult your Toyota dealer. dangerously the SRS front airbags operation.
interfere with
NOTICE
consulting
Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the SRS airbag system in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player
z Modification of the suspension sys-
tem
z Modification of the front end struc-
ture
z Attachment of a grille guard (bull bar, kangaroo bar, etc.), snowplow, winches or any other equipment to the front end
z Repairs made on or near the front fenders, front end structure, con- steering sole, steering wheel, front passenger’s seat or dashboard near the front passenger airbag
column,
LS13104
sensor assembly,
light system monitors
This indicator comes on when the en- gine switch is turned to the “ON” posi- tion. It goes off after about 6 seconds. This means the SRS airbags are operat- ing properly. the This warning airbag front airbag sensors, driver’s seat position sensor, driver’s seat belt buckle switch, front passenger occupant classification system∗ and indicator light, passenger airbag off switch, seat belt pretensioner assemblies, inflators, interconnecting wiring and power sources. “Service reminder indicators and warning buzzers” on page 153 in Section 1−6.)
details,
(For
see
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
61
08 02.19
∗: The front passenger occupant classifica- tion system includes the front passenger occupant classification ECU, load sensor and front passenger’s seat belt buckle switch. If either of the following conditions occurs, this indicates a malfunction of the airbags or seat belt pretensioners. Contact your Toyota dealer as soon as possible. D The light does not come on when the engine switch is turned to the “ON” position or remains on for more than 6 seconds.
D The light comes on while driving. The SRS warning light will come on and front passenger occupant classification in- dicator light will indicate “OFF” if there is a malfunction in the front passenger occu- pant classification system.
SRS driver airbag and front passenger airbag (regular cab models with bench seat and double cab models)
LS13116
LS13117
In the following cases, contact your Toyota dealer as soon as possible: D The SRS airbags have been inflated. D The front of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS airbags to inflate.
The SRS (Supplemental Restraint Sys- tem) front airbags are designed to pro- vide further protection for the driver and right front passenger (regular cab models with bench seat) or front pas- senger (double cab models) in addition to the primary safety protection pro- vided by the seat belts.
front
D The pad section of the steering wheel or cover (shaded in the illustration) is scratched, cracked, or otherwise damaged.
passenger
airbag
NOTICE
Do not disconnect the battery cables before contacting your Toyota dealer.
62
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
Your vehicle is equipped with “ADVANCED AIRBAGS” designed based on US motor vehicle safety standards (FMVSS208). The airbag system controls airbag deployment power for the driver and front passenger. The driver airbag system consists of the driver seat’s position sensor etc. The front passenger’s airbag system consists of the front passenger occupant classification sensor etc. Vehicles with bench seat—The SRS air- bags are designed to protect the driver and right front passenger, and they are not designed to protect an occupant in the front center seating position. In response to a severe frontal impact, the SRS front airbags work with the seat belts to help reduce injury by inflating. The SRS front airbags help reduce injuries mainly to the driver’s or front passenger’s head or chest caused by hitting the ve- hicle interior.
or
seat)
bench
The SRS front passenger airbag will not activate if there is no passenger sitting in the right front passenger seat (regular cab models with front passenger seat (double cab models). However, the front passenger airbag may deploy if luggage is put in the seat. (As for occupant classification “Front passenger occupant classification system” on page 86 in this Section.) Always wear your seat belt properly.
passenger
system,
front
see
the
CAUTION
D The SRS front airbag system is de- signed only as a supplement to the primary protection of the driver and front passenger seat belt systems. The driver and front passenger can be killed or seriously injured by the inflating airbags if they do not wear the available seat belts properly. During sudden braking just before a collision, an unrestrained driver or front passenger can move for- ward into direct contact with or close proximity to the airbag which may then deploy during the colli- sion. To ensure maximum protection in an accident, the driver and all passengers the vehicle must wear their seat belts properly. Wear- ing a seat belt properly during an accident reduces the chances of death or serious injury or being thrown out of the vehicle. For in- structions and precautions concern- ing the seat belt system, see “Seat belts” on page 43 in this Section.
in
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
63
08 02.19
seriously
D Improperly seated and/or restrained infants and children can be killed by or the injured deploying airbags. An infant or child who is too small to use a seat belt should be properly secured using a child restraint system. As to double cab models, Toyota strongly all infants and children be placed in the rear seat of the vehicle and properly restrained. The rear seat is the safest for infants and children. the For installation of a child restraint system, see “Child restraint” on page 93 in this Section.
instructions concerning
recommends
that
The SRS front airbags are designed to deploy in severe (usually frontal) colli- sions where the magnitude and duration of the forward deceleration of the ve- hicle exceeds the designed threshold level. The SRS front airbags will deploy if the severity of the impact is above the de- signed threshold level, comparable to an approximate 25 km/h (15 mph) collision when the vehicle has the impact straight into a fixed barrier that does not move or deform. However, threshold velocity will be considerably higher if the vehicle strikes an object, such as a parked vehicle or sign pole, which can move or deform on impact, or if the vehicle is involved in an underride collision in which the front of the vehicle “underrides”, or goes under, the bed of a truck, etc.). It in some collisions where the forward deceleration of the ve- hicle is very close to the designed thresh- old level, the SRS front airbags and the seat belt pretensioners may not activate together. Always wear your seat belts properly.
(e.g. a collision
is possible
that
this
Collision from the rear
LS13123
Collision from the side
Vehicle rollover
The SRS front airbags are not generally designed to inflate if the vehicle is in- volved in a side or rear collision, if it rolls over, or if it is involved in a low− speed frontal collision. But, whenever a collision of any type causes sufficient forward deceleration of the vehicle, de- ployment of the SRS front airbags may occur.
64
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
Hitting a curb, edge of pavement or hard surface
LS13124
Falling into or jumping over a deep hole
LS13189d
Landing hard or vehicle falling
The SRS front airbags may also deploy if a serious impact occurs to the under- side of your vehicle. Some examples are shown in the illustration.
Regular cab models with bench seat
LS13125d
Double cab models
The SRS front airbag system consists mainly of the following components, and their locations are shown in the illustra- tion. 1. Front airbag sensors 2. Front passenger occupant classification
indicator light
3. Airbag module for front passenger
(airbag and inflator)
4. Front passenger occupant classification
ECU
5. Front passenger’s seat position sensor 6. Pressure sensor 7. Load sensor 8. Belt tension sensor 9. Front passenger’s seat belt buckle
switch
10. Driver’s seat belt buckle switch 11. Driver’s seat position sensor 12. Airbag sensor assembly 13. Airbag module for driver
(airbag and inflator)
14. SRS warning light The airbag sensor assembly consists of a safing sensor and airbag sensor.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
65
08 02.19
The airbag sensors constantly monitor the forward deceleration of the vehicle. If an impact results in a forward deceleration beyond the designed threshold level, the system triggers the airbag inflators. At this time a chemical reaction in the inflators very quickly fills the airbags with non−tox- ic gas to help restrain the forward motion of the occupants. The front airbags then quickly deflate, so that there is no ob- struction of the driver’s vision should it be necessary to continue driving. When the airbags inflate, they produce a loud noise and release some smoke and residue along with non−toxic gas. This does not indicate a fire. This smoke may remain inside the vehicle for some time, and may cause some minor irritation to the eyes, skin or breathing. Be sure to wash off any residue as soon as possible to prevent any potential skin irritation with soap and water. If you can safely exit from the vehicle, you should do so imme- diately.
injuries, especially
Deployment of the airbags happens in a fraction of a second, so the airbags must inflate with considerable force. While the system is designed to reduce serious inju- ries, primarily to the head and chest, it may also cause other, less severe injuries to the face, chest, arms and hands. These are usually in the nature of minor burns or abrasions and swelling, but the force of a deploying airbag can cause more seri- ous if an occupant’s hands, arms, chest or head is in close proximity to the airbag module at the time of deployment. This is why it is important for to: avoid placing any object or part of the body between the occupant and the airbag module; sit straight and well back into the seat; wear the available seat belt properly; and sit as far as possible from the airbag module, while still maintaining control of the ve- hicle. Parts of the airbag module (steering wheel hub, airbag cover and inflator) may be hot for several minutes after deployment, so do not inflate only once. The windshield may be damaged by absorbing some of the force of the inflat- ing airbag.
touch! The airbags
the occupant
CAUTION
The driver or front passenger who is too close to the steering wheel or dashboard during airbag deployment can be killed or seriously injured. Toyota strongly recommends that: D The driver sit as far back as pos- sible from the steering wheel while still maintaining control of the ve- hicle.
D The front passenger sit as far back
as possible from the dashboard.
D All vehicle occupants be properly restrained using the available seat belts.
D If the seat belt extender has been connected to the driver’s seat belt buckle without the driver actually wearing the seat belt, the SRS driv- er’s airbag system will judge that the driver this case, the driver’s airbag may not activate correctly, causing death or serious injury in the event of colli- sion. Be sure to wear the seat belt with the seat belt extender.
is wearing
it.
In
66
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
For instructions and precautions con- cerning the seating position, see “—Front seat precautions” on page 34 in this Section.
LS13121
LS13162
is
in use, since
D Do not sit on the edge of the seat or lean against the dashboard when the vehicle the front passenger airbag could inflate with considerable speed and force. Anyone who is up against, or very close to, an airbag when it inflates, can be killed or seriously injured. Sit up straight and well back in the seat, and always use your seat belt properly.
D Toyota strongly recommends that all infants and children be placed in the rear seat of the vehicle and be properly restrained.
D Do not hold a child on your lap or in your arms. Use a child restraint system in the rear seat. For instruc- tions concerning the installation of a child restraint system, see “Child restraint” on page 93 in this Sec- tion.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
67
08 02.19
Failure to follow these instructions can result in death or serious injury. Consult your Toyota dealer about any repair and modification. If you wish to modify your vehicle for a person with a physical disability, consult your Toyota dealer. It may dangerously the SRS front airbags operation.
interfere with
LS13184
D Do not put anything or any part of your body on or in front of the dashboard or steering wheel pad that houses the front airbag sys- tem. They might restrict inflation or cause death or serious injury as they are projected rearward by the force of the deploying airbags. Like- wise, the driver and front passenger should not hold objects their arms or on their knees.
in
the
D Do not modify or remove any wir- ing. Do not modify, remove, strike or open any components such as the steering wheel pad, steering wheel, column cover, dashboard near front passenger airbag, front passenger airbag cover, front passenger airbag or airbag sensor assembly. Doing so may prevent the front airbag system from activating correctly, cause sudden activation of the system or disable the sys- tem, which could result in death or serious injury.
D Bench seat only—Do not use seat accessory, such as a cushion or seat cover, that covers the front seat, or do not modify or replace the upholstery of front seat. Such accessories or changes may prevent the front passenger airbag system from activating correctly, disable the system or cause the front passenger airbag to inflate ac- cidentally, resulting in death or seri- ous injury.
the
68
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
NOTICE
consulting
front airbag system
Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the SRS in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player
z Modification of the suspension sys-
tem
z Modification of the front end struc-
ture
z Attachment of a grille guard (bull bar, kangaroo bar, etc.), snowplow, winches or any other equipment to the front end
z Repairs made on or near the front fenders, front end structure, con- steering sole, steering wheel, front passenger’s seat or dashboard near the front passenger airbag
column,
LS13104
sensor assembly,
light system monitors
This indicator comes on when the en- gine switch is turned to the “ON” posi- tion. It goes off after about 6 seconds. This means the SRS front airbags are operating properly. the This warning airbag front airbag sensors, side and curtain shield airbag sensors, curtain shield airbag sensors, driver’s seat position sensor, driver’s seat passenger belt occupant and seat belt pretensioner indicator assemblies, “RSCA OFF” indicator light, interconnecting wiring and power sources. (For details, see “Service reminder indicators and warning buzzers” on page 153 in Section 1−6.)
classification
system∗
inflators,
switch,
buckle
light,
front
∗: The front passenger occupant classifica- tion system includes the front passenger occupant classification ECU, pressure sen- sor, load sensor, front passenger’s seat belt buckle switch, front passenger’s seat position sensor and belt tension sensor. If either of the following conditions occurs, this indicates a malfunction of the airbags or seat belt pretensioners. Contact your Toyota dealer as soon as possible. D The light does not come on when the engine switch is turned to the “ON” position or remains on for more than 6 seconds.
D The light comes on while driving. The SRS warning light will come on and front passenger occupant classification in- dicator light will indicate “OFF” if there is a malfunction in the front passenger occu- pant classification system.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
69
08 02.19
Passenger airbag off switch (regular cab models with separate seats and access cab models only)
NOTICE
Do not disconnect the battery cables before contacting your Toyota dealer.
LS13185
LS13141a
In the following cases, contact your Toyota dealer as soon as possible: D The SRS front airbags have been in-
flated.
D The front of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS front airbags to inflate.
Indicator light
This off switch is designed to disable the front passenger airbag in order to allow usage, if necessary, of a member of a passenger risk group identified in TABLE 1 is occupying the front passen- ger seating position. (For details, see “SRS driver airbag and front passenger airbag” on page 53 in this Section.)
D The pad section of the steering wheel or cover (shaded in the illustration) is scratched, cracked, or otherwise damaged.
passenger
airbag
front
70
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
on
the
turn
varies
depending
Operate off switch as follows: Insert key into the keyhole. front passenger airbag To on—Turn the key clockwise to the “AUTO” position. At this time, the indicator light condition the occupant in the front passenger seat. (For details, see “Front passenger occupant classification system” on page 82 in this Section.) To front passenger airbag turn off—Turn the key counterclockwise to the “OFF” position and remove it. At this time, the “OFF” indicator light comes on. If the key is removed at any other position than “OFF”, the switch will automatically return to the “AUTO” position.
the
LS13140
The SRS warning light and the passen- ger airbag on−off indicator light will in- dicate “OFF” if there is a malfunction in the passenger airbag off switch.
CAUTION
D Do not turn off the passenger air- bag off switch except when a mem- ber of a passenger risk group iden- tified in TABLE 1 is occupying the front passenger seating position.
D When
the passenger airbag off switch is turned off, the front pas- senger airbag will not inflate in a collision and turning off the front passenger airbag can reduce the occupant protection which your ve- hicle safety systems can provide to you in- crease the likelihood of death or serious personal injuries.
in certain accidents and
For details, see “SRS driver airbag and front passenger airbag” on page 53 in this Section.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
71
08 02.19
SRS side airbags and curtain shield airbags
LS13126
The SRS (Supplemental Restraint Sys- tem) side airbags and curtain shield air- bags are designed to provide further protection for the driver, front passen- ger and rear outside passengers in addition to the primary safety protec- tion provided by the seat belts.
Roll sensing function: In response to a vehicle rollover, the cur- tain shield airbags on both sides work with the seat belts to help reduce injury by inflating. The curtain shield airbags help reduce injuries mainly to the driver’s, front passenger’s or rear passenger’s head and help prevent them from being thrown out of the vehicle. (This function can be turned off if inflation is not de- sired. See “Roll sensing of curtain shield airbags off switch” on page 92 in this Section.) The SRS curtain shield airbags may acti- vate even when the side airbags are not activated. Always wear your seat belt properly.
In response to a severe side impact, the SRS side airbags and curtain shield air- bags in the impacted side work with the seat belts to help reduce injury by inflat- ing. The SRS side airbags help reduce injuries mainly to the driver’s or front pas- senger’s chest. The SRS curtain shield airbags help reduce injuries mainly to the driver’s, front passenger’s or rear outside passenger’s head and help prevent them from being thrown out of the vehicle. The SRS side airbag on the passenger seat will not activate if there is no pas- senger sitting in the front passenger seat. However, the side airbag on the passen- ger seat may deploy if luggage is put in the seat. (As for the front passenger oc- cupant classification system, see “Front passenger occupant classification system” on page 86 in this Section.) The SRS curtain shield airbag on the pas- senger side are activated even with no passenger in the front seat or rear outside seat.
72
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
CAUTION
D The SRS side airbag and curtain shield airbag system is designed only as a supplement to the prima- ry protection of the driver, front passenger and rear outside passen- ger seat belt systems. To ensure maximum protection in an accident, the driver and all passenger in the vehicle must wear their seat belts properly. Wearing a seat belt prop- erly during an accident reduces the chances of death or serious injury or being thrown out of the vehicle. instructions and precautions For concerning the seat belt system, see “Seat belts” on page 43 in this Section.
D Do not allow anyone to lean his/her head or any part of his/her body against the door or the area of the seat, front pillar, rear pillar or roof side rail from which the SRS side airbag and curtain shield airbag deploy even is a child seated in the child restraint system. It is dangerous if the SRS side air- bag and curtain shield airbag in- flate, and the impact of the deploy- ing airbag could cause death or se- rious injury to the occupant.
if he/she
restraint
D Improperly seated and/or restrained infants and children can be killed or seriously injured by the deploy- ing airbags. An infant or child who is too small to use a seat belt should be properly secured using a child Toyota strongly recommends in- fants and children be placed in the rear seats of the vehicle and prop- erly restrained. The rear seats are the safest for infants and children. For the installation of a child restraint sys- tem, see “Child restraint” on page 93 in this Section.
instructions concerning
that all
system.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
73
08 02.19
LS13127
Collision from the rear
LS13128
LS13127
Collision from the front
Vehicle rollover
The SRS side airbags are not generally designed to inflate if the vehicle is in- volved in a front or rear collision, if it rolls over, or if it is involved in a low− speed side collision.
The SRS side airbags may not activate if the vehicle is subjected to a collision from the side at certain angles, or a collision to the side of the vehicle body other than the passenger compartment as shown in the illustration. The SRS side airbags are designed to inflate when the passenger compartment area suffers a severe the side. Always wear your seat belts properly.
impact
from
from
The SRS curtain shield airbags may not activate if the vehicle is subjected to a collision the side at certain angles, or a collision to the side of the vehicle body other than the passenger compartment as shown in the illustra- tion. The curtain shield airbags are designed to inflate when the passenger compartment area suffers a severe the side or vehicle rollover. Always wear your seat belts properly.
impact
from
74
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
LS13129
The angle of vehicle tip−up is marginal
Skidding vehicle hitting a curb stone
Collision from the front
LS13130
Collision from the rear
Hitting a curb, edge of pavement or hard surface
LS13124
Falling into or jumping over a deep hole
Pitch end over end
Landing hard or vehicle falling
The SRS curtain shield airbags may in- flate if the angle of vehicle tip−up is marginal or the skidding vehicle’s tires hit a curb stone laterally as shown in the illustration.
if
The SRS curtain shield airbags are not generally designed to inflate if the ve- hicle is involved in a front or rear colli- sion, if it pitches end over end, or if it is involved in a low−speed side colli- sion.
The SRS side and curtain shield airbags may deploy if a serious impact occurs to the underside of your vehicle. Some examples are shown in the illustration.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
75
08 02.19
LS13131c
The SRS side airbag and curtain shield airbag system consists mainly of the fol- lowing components, and their locations are shown in the illustration. 1. Curtain shield airbag modules
(airbag and inflator)
2. Front passenger occupant classification
ECU
3. Load sensor 4. Side airbag modules (airbag and inflator)
5. Curtain shield airbag sensors 6. Side and curtain shield airbag sensors 7. Front passenger’s seat belt buckle
switch
76
8. Front passenger occupant classification
indicator light
inflators and/or
9. Airbag sensor assembly 10. SRS warning light The SRS side airbag and curtain shield airbag system is controlled by the airbag sensor assembly. the side and In a severe side impact, curtain shield airbag sensor and/or the curtain shield airbag sensor trigger(s) the the curtain side airbag shield airbag time a chemical reaction in the inflators quickly fills the airbags with non−toxic gas to help restrain the occu- pants. In a vehicle rollover, the airbag sensor assembly triggers the curtain shield airbag inflator. At this time, a chemical reaction in the airbags with non−toxic gas to help restrain the lateral motion of the occupants.
the lateral motion of
inflators quickly
inflators. At
this
fills
the
When the airbags inflate, they produce a fairly loud noise and release some smoke and residue along with non−toxic gas. This does not indicate a fire. This smoke may remain inside the vehicle for some time, and may cause some minor irritation to the eyes, skin or breathing. Be sure to wash off any residue as soon as possible to prevent any potential skin irritation with soap and water. If you can safely exit from the vehicle, you should do so imme- diately. Deployment of the airbags happens in a fraction of a second, so the airbags must inflate with considerable force. While the system is designed to reduce serious inju- ries, it may also cause minor burns or abrasions and swelling. Front seats as well as parts of the front and rear pillars, and roof side rail may be hot for several minutes, but the airbags themselves will not be hot. The airbags are designed to inflate only once.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
CAUTION
inflate with
SRS side airbags and curtain shield airbags considerable force. To reduce the possibility of death or serious injury when they in- flate, the driver, front passenger and rear outside passengers must: D Wear their seat belts properly. D Remain properly seated with their backs upright and against the seats at all times.
Improper sitting and wearing of the seat belts may not retain you inside the vehicle.
LS13132
LS13193
D Make
sure
light
rollover
the “RSCA OFF” indicator is off. The curtain shield airbags will not inflate in a vehicle indicator light is on and you may be killed or seriously injured. For details, see “Roll sensing of curtain shield airbags off switch” on page 92 in this Section.
this
if
D Do not allow anyone to lean against the door when the vehicle is in use, since the side airbag and curtain shield airbag could inflate with con- siderable speed and force. Other- wise, he/she may be killed or seri- ously injured. Special care should be taken especially when you have a small child in the vehicle.
D Sit up straight and well back in the seat, distributing your weight evenly in the seat. Do not apply excessive weight the seats with a side airbag, and to the front pillar, rear pillar and roof side rail with a curtain shield airbag.
the outer side of
to
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
77
08 02.19
LS13133
LS13134
LS13135
inflate, since
D Do not allow anyone to get his/her head closer to the area where the side airbag and curtain shield air- bag these airbags could considerable speed and force. Otherwise, he/she may be killed or seriously injured. Special care should be taken espe- cially when you have a small child in the vehicle.
inflate with
D Do not allow anyone to kneel on the passenger seat, facing the pas- senger’s side door, since the side airbag and curtain shield airbag could considerable speed and force. Otherwise, he/she may be killed or seriously injured. Special care should be taken espe- cially when you have a small child in the vehicle.
inflate with
D Do not allow anyone to get his/her head or hands out of windows the curtain shield airbags since could inflate with considerable speed and force. Otherwise, he/she may be killed or seriously injured. Special care should be taken espe- cially when you have a small child in the vehicle.
78
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
LS13136
LS13137
D Do not attach a cup holder or any other device or object on or around the door. When the side airbag in- flates, the cup holder or any other device or object will be thrown with great force or the side airbag may not activate correctly, resulting in injury. Likewise, death or serious the driver and front passenger should not hold objects their arms or on their knees.
in
D Do not attach a microphone or any other device or object around the area where the curtain shield airbag activates such as on the windshield glass, side door glass, front and rear pillars, roof side rail and assist grips. When the curtain shield air- bags inflate, the microphone or oth- er device or object will be thrown away with great force or the curtain shield airbags may not activate cor- rectly, resulting in death or serious injury.
D Do not hook a hanger, heavy or sharp pointed objects on the coat hook. If the curtain shield airbag inflates, those items will be thrown away with great force or the curtain shield airbag may not activate cor- rectly, resulting in death or serious injury. When you hang clothes, hang them on the coat hook direct- ly.
D Do not use seat accessories which cover the parts where the side air- bags inflate. Such accessories may prevent the side airbags from acti- vating correctly, causing death or serious injury.
D Do not modify or replace the seats or upholstery of the seats with side airbags. Such changes may prevent the side airbag system from activat- ing correctly, disable the system or cause the side airbags to inflate ac- cidentally, resulting in death or seri- ous injury.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
79
08 02.19
D Do not disassemble or repair the front and rear pillars and roof side rail containing the curtain shield airbags. Such changes may disable the system or cause the curtain shield airbags to inflate accidental- ly, resulting in death or serious in- jury.
D Do not modify or change the sus- pension system. Such changes may cause the curtain shield airbags to inflate accidentally, which could re- sult in death or serious injury.
the manufacturer’s
D Do not use tires or wheels other than recom- mended size. Such a use may cause the curtain shield airbags to inflate accidentally, which could result in death or serious injury. For details, see “Checking and replacing tires” on page 379 in Section 7−2.
Failure to follow these instructions can result in death or serious injury. Consult your Toyota dealer about any repair and modification.
If you wish to modify your vehicle for a person with a physical disability, consult your Toyota dealer. It may dangerously the SRS side airbags and curtain shield air- bags operation.
interfere with
NOTICE
consulting
Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the SRS side airbag and curtain shield airbag system in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player
z Modification of the suspension sys-
tem
z Modification of the side structure of
the passenger compartment
z Repairs made on or near the con-
sole or front seat
LS13104
This indicator comes on when the en- gine switch is turned to the “ON” posi- tion. It goes off after about 6 seconds. This means the SRS side airbags and curtain shield airbags are operating properly.
80
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
front
light,
buckle
switch,
inflators,
system∗
classification
sensor assembly,
light system monitors
the This warning airbag front airbag sensors, side and curtain shield airbag sensors, curtain shield airbag sensors, driver’s seat position sensor, driver’s seat passenger belt occupant and seat belt pretensioner indicator assemblies, “RSCA OFF” indicator light, interconnecting wiring and power sources. (For details, see “Service reminder indicators and warning buzzers” on page 153 in Section 1−6.) ∗: The front passenger occupant classifica- tion system includes the front passenger occupant classification ECU, load sensor and front passenger’s seat belt buckle switch. If either of the following conditions occurs, this indicates a malfunction of the airbags or seat belt pretensioners. Contact your Toyota dealer as soon as possible. D The light does not come on when the turned to the “ON” engine switch is position or remains on for more than 6 seconds.
D The light comes on while driving. The SRS warning light will come on and front passenger occupant classification in- dicator light will indicate “OFF” if there is a malfunction in the front passenger occu- pant classification system.
LS13138c
In the following cases, contact your Toyota dealer as soon as possible: D Any of the SRS side airbags and cur- tain shield airbags have been inflated. D The portion of the doors (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS side airbags and curtain shield airbags to inflate.
D The surface of the seats with the side airbag (shaded is scratched, cracked, or otherwise dam- aged.
illustration)
the
in
D The portion of
the front pillars, rear pillars or headlining (padding) contain- ing inside (shaded in the illustration) is scratched, cracked, or otherwise damaged.
the curtain shield airbag
NOTICE
Do not disconnect the battery cables before contacting your Toyota dealer.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
81
08 02.19
Front passenger occupant classification system (regular cab models with separate seats and access cab models) Your vehicle is equipped with a front passenger occupant classification sys- tem. The system detects conditions 1—4 (Shown in the table on page 84) Based on these conditions, the systems below are activated or deactivated: D Front passenger airbag D Front passenger’s seat belt pretension-
er
The system monitors the weight and load on the front passenger seat, and the seat belt buckle switch to determine conditions 1—4. In order to ensure that the system de- tects the conditions correctly: D Do not place a heavy load on the front passenger seat or the seatback table, etc.
D Do not attach a commercial seatback table or other heavy item to the back of the front passenger seat.
D Do not apply pressure to the front pas- senger seat by resting hands or legs on the seatback.
82
LS13139a
The front passenger occupant classifi- cation indicator light indicates the ac- tuation of the front passenger airbag and front passenger seat belt preten- sioner. The front passenger occupant classifi- cation indicator light will indicate “ON” and “OFF” when the engine switch is turned the “ON” position. After about four seconds, it will go off. After that, the front passenger occupant clas- sification system operates and judges whether to indicate “ON” or “OFF”.
to
indicate
indicator
light will
The “OFF” when the engine switch is in the “ON” position with the condition 2 in the table shown below. If the front passenger occupant classifica- tion system determines that a person of adult size sits in the front passenger seat but the “OFF” indicator is illuminated, one of the following is likely to have occurred: D A rear passenger lifts the front passen-
ger seat cushion with their legs.
D Objects are placed under the front pas-
senger seat.
D The
front passenger seatback
in contact with the rear seat or the back wall.
is
To ensure that the system correctly de- tects the presence or absence of a person of adult size sitting in the front passenger seat, make sure that none of the above occur. Make sure that the “ON” indicator is illu- minated when a person of adult size is seated in the front passenger seat. If the “OFF” indicator is illuminated, follow the procedure below: 1. Turn the engine switch off. 2. Make sure the airbag off switch is set
to the “AUTO” position.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
3. Make sure
the
front passenger seat
belt is worn correctly.
4. Ask the front passenger to adjust the seatback to the upright position and to sit up straight on the center of the seat cushion, with his/her legs comfortably extended forward.
5. Turn the engine switch on, having the passenger remain in that position until the front passenger occupant classifica- tion system indicates “ON”.
indicator
light
LS13140
If the “OFF” indicator remains illuminated, either ask the passenger to move to the rear seat, or if that is not possible, move the front passenger seat fully rearward.
indicator
The SRS warning light will come on and the front passenger occupant clas- sification indicate “OFF” if there is a malfunction in the front passenger occupant classification system. Contact your Toyota dealer as soon as possible.
light will
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
83
08 02.19
Condition and operation in the front passenger occupant classification system
Indicator/warning light
Devices
Condition detected by the front passenger
occupant classification
system
Passenger
airbag off switch
position
Front passenger
occupant
classification indicator light
SRS warning
light
1. Adult∗1
2. Child∗2 or child
restraint system∗3
3. Unoccupied
4. There is a
malfunction in the system
“AUTO”
“OFF”
“AUTO”
“OFF”
“AUTO”
“OFF”
“AUTO”
“OFF”
“ON”
“OFF”
“OFF”∗5
Not illuminated
“OFF”
“OFF”
Off
Off
Off
On
Front
passenger’s
seat belt
reminder light
Flashing∗4
Flashing∗4
Front passenger
airbag
Activated
Deactivated
Front
passenger’s
seat belt
pretensioner
Activated
Deactivated
Activated
Off
Off
Deactivated
Deactivated
Activated
∗1: The system judges a person of adult size as an adult. When a smaller adult sits in the front passenger seat, the system may
recognize him/her as a child depending on his/her physique and posture.
∗2: When a larger child who has outgrown a child restraint system sits in the front passenger seat, the system may recognize him/her
as an adult depending on his/her physique or posture.
∗3: Never install a rear−facing child restraint system on the front passenger seat. A forward−facing child restraint system should only be installed on the front passenger seat when it is unavoidable. (See “Child restraint” on page 93 in this Section as for installing the child restraint system.)
∗4: In the event the front passenger does not wear a seat belt.
∗5: In case the indicator is not illuminated, see “Child restraint” on page 93 as for installing the child restraint system properly.
84
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
CAUTION
To avoid potential death or serious injury when the front passenger occu- pant classification system does not detect the conditions correctly, ob- serve the following. D Make sure the front passenger oc- cupant classification indicator light indicates “ON” when using the seat belt extender for the front passen- ger seat. If the indicator light indi- cates “OFF”, disconnect the extend- er tongue from the seat belt buckle, then reconnect the seat belt. Recon- nect the seat belt extender after making sure the indicator light indi- cates “ON”. If you use the seat belt extender while the light indicates “OFF”, the front passen- ger airbag may not activate correct- ly, which could cause death or seri- ous injury in the event of collision.
indicator
touches
the seatback
D Do not recline the front passenger seatback so far that it touches a rear seat or a backwall. This may cause the “OFF” indicator to be il- luminated, which indicates that the passenger’s airbags will not deploy in the event of a severe accident. If the rear seat or backwall, return the seat- back to a position where it does not touch the rear seat or backwall. Keep the front passenger seatback as upright as possible when the ve- hicle is moving. Reclining the seat- back excessively may lessen the ef- fectiveness of the seat belt system. D If an adult sits in the front passen- ger seat, the occupant classification indicator light should indicate “ON”. If illumi- nated, ask the passenger to sit up straight, well back in the seat, feet on the floor, and with the seat belt worn correctly. If the “OFF” indica- tor still remains illuminated, either ask the passenger to move to the rear seat, or if that is not possible, move the front passenger seat fully rearward.
the “OFF”
indicator
is
the
D Wear the seat belt properly. D Make sure
front passenger’s seat belt tab has not been left in- serted in the buckle before some- one sits front passenger seat.
the
in
D Do not place a heavy load on the front passenger seat or the seat- back table, etc.
D Do not apply pressure to the front passenger seat by resting hands or legs on the seatback.
D Do not let a rear passenger lift the front passenger seat with their feet or press on the seatback with their legs.
D Do not put objects under the front
passenger seat.
D Do not attach a commercial seat- back table or other heavy item to the back of front passenger seat.
the
D Child restraint systems installed on the rear seat should not contact the front seatbacks.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
85
08 02.19
D When it is unavoidable to install the forward−facing child restraint sys- tem on the front passenger seat, install the child restraint system on the the proper order. (As for the installation order, see “—Installation with seat belt” on page 96 in this Section.)
front passenger seat
in
D Do not modify or remove the front
seats.
D Do not kick
the
front passenger seat or subject it to severe impact. Otherwise, the SRS warning light may come on to indicate a malfunc- tion of the detection system. In this case, contact your Toyota dealer im- mediately.
(the
front
passenger
if observing
The occupant classification indicator light may indicate front passenger airbag may “ON” deploy) even the above in, or a cautions, when a child sits forward−facing child is installed on front passenger seat. Refer to all the cautions in “SRS driver airbag and front passenger airbag” on page 53 and “Child restraint” on page 93.
restraint system
the
D Do not apply pressure to the front pas- senger seat by resting hands or legs on the seatback.
D Regular cab models with bench seat— Do not use a seat accessory, such as a cushion or seat cover, that covers the seat cushion surface.
Front passenger occupant classification system (regular cab models with bench seat and double cab models) Your vehicle is equipped with a front passenger occupant classification sys- tem. The system detects conditions 1—4 (Shown in the table on page 89) Based on these conditions, the systems below are activated or deactivated: D Front passenger airbag D Side airbag on
front passenger
the
seat
D Front passenger’s seat belt pretension-
er
The system monitors the weight and load on the right front passenger seat (regular cab models with bench seat) or front passenger seat (double cab mod- els), and the seat belt buckle switch to determine conditions 1—4. In order to ensure the system detects the conditions correctly: D Double cab models—Do not place a heavy load on the front passenger seat or the seatback table, etc.
D Regular cab models with bench seat— Do not place a heavy load on the front passenger seat.
D Double cab models—Do not attach a commercial seatback table or other heavy item to the back of the front passenger seat.
86
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
LS13139b
The front passenger occupant classifi- cation indicator light indicates the ac- tuation of the front passenger airbag, side airbag on the front passenger seat and front passenger seat belt preten- sioner. The front passenger occupant classifi- cation indicator light will indicate “ON” and “OFF” when the engine switch is turned the “ON” position. After about four seconds, it will go off. After that, the front passenger occupant clas- sification system operates and judges whether to indicate “ON” or “OFF”.
to
indicate
indicator
light will
The “OFF” when the engine switch is in the “ON” position with the condition 2 in the table shown below. If the front passenger occupant classifica- tion system determines that a person of adult size sits in the front passenger seat but the “OFF” indicator is illuminated, one of the following is likely to have occurred: D A rear passenger lifts the front passen-
ger seat cushion with their legs.
D Objects are placed under the front pas-
senger seat.
D Double cab models—The front passen- ger seatback is in contact with the rear seat.
To ensure that the system correctly de- tects the presence or absence of a person of adult size sitting in the front passenger seat, make sure that none of the above occur.
Make sure that the “ON” indicator is illu- minated when a person of adult size is seated in the right front passenger seat (regular cab models with bench seat) or front passenger seat (double cab models). If the “OFF” indicator is illuminated, ask the passenger to sit up straight, well back in the seat, and with the seat belt worn correctly. If the “OFF” indicator remains illuminated, either ask the passenger to move to the rear seat, or if that is not possible, move the front passenger seat fully rearward.
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
87
08 02.19
LS13140
indicator
The SRS warning light will come on and the front passenger occupant clas- sification indicate “OFF” if there is a malfunction in the front passenger occupant classification system. Contact your Toyota dealer as soon as possible.
light will
88
2008 TACOMA from Apr. ’08 Prod. (OM35898U)
08 02.19
Condition and operation in the front passenger occupant classification system
Indicator/warning light
Devices
Condition detected by the front passenger
occupant classification
system∗1
1. Adult∗2
2. Child∗3 or child
restraint system∗4
3. Unoccupied
4. There is a
malfunction in the system
Front
passenger occupant
classification indicator light
“ON”
“OFF”∗6
Not
illuminated
“OFF”
SRS warning
light
Off
Off
Off
On
Front
passenger’s
seat belt
reminder light
Flashing∗5
Flashing∗5