2006 Ford F 150 Owners Manual

driving cycles without these or any other temporary malfunctions present, the indicator should turn off—A driving cycle consists of a cold engine startup followed by mixed city/highway driving. No additional vehicle service is required. If the available opportunity. Readiness for Inspection/Maintenance (I/M) testing In some localities, it may be a legal requirement to pass an I/M test of the on-board diagnostics system. If the description in the Warning lights and chimes section of the Instrument Cluster chapter. Your vehicle may not pass the I/M test with the If the vehicle’s powertrain system or its battery has just been serviced, the on-board diagnostics system is reset to a “not ready for I/M test” condition. To ready the on-board diagnostics system for I/M testing, a minimum of 30 minutes of city and highway driving is necessary as described below: • First, at least 10 minutes of driving on an expressway or highway. • Next, at least 20 minutes driving in stop-and-go, city-type traffic with

indicator remains on, have your vehicle serviced at the first

indicator is on, refer to the

indicator on.

at least four idle periods.

Allow the vehicle to sit for at least eight hours without starting the engine. Then, start the engine and complete the above driving cycle. The engine must warm up to its normal operating temperature. Once started, do not turn off the engine until the above driving cycle is complete.

302

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

POWER STEERING FLUID Check the power steering fluid. Refer to the scheduled maintenance information for the service interval schedules. If adding fluid is necessary, use MERCON威 ATF. 1. Start the engine and let it run until it reaches normal operating temperature (the engine coolant temperature gauge indicator will be near the center of the normal area between H and C). 2. While the engine idles, turn the steering wheel left and right several times. 3. Turn the engine off. 4. Check the fluid level in the reservoir. It should be between the MIN and MAX lines. Do not add fluid if the level is in this range. 5. If the fluid is low, add fluid in small amounts, continuously checking the level until it reaches the range between the MIN and MAX lines. Be sure to put the cap back on the reservoir.

BRAKE FLUID The fluid level will drop slowly as the brakes wear, and will rise when the brake components are replaced. Fluid levels between the “MIN” and “MAX” lines are within the normal operating range; there is no need to add fluid. If the fluid levels are outside of the normal operating range the performance of the system could be compromised; seek service from your authorized dealer immediately.

CLUTCH FLUID (IF EQUIPPED) Check the fluid level. Refer to scheduled maintenance information for the service interval schedules. During normal operation, the fluid level in the clutch reservoir should remain constant. If the fluid level drops, refill the fluid level to the step in the reservoir.

303

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Use only a DOT 3 brake fluid designed to meet Ford specifications. Refer to Lubricant specifications in this chapter.

Brake fluid is toxic. If brake fluid contacts the eyes, flush eyes with running water for 15 minutes. Seek medical attention if

irritation persists. If taken internally, drink water and induce vomiting. Seek medical attention immediately.

1. Clean the reservoir cap before removal to prevent dirt and water from entering the reservoir. 2. Remove cap and rubber diaphragm from reservoir. 3. Add fluid until the level reaches the step in the reservoir. 4. Reinstall rubber diaphragm and cap onto reservoir.

TRANSMISSION FLUID

Checking automatic transmission fluid (if equipped) Refer to your scheduled maintenance information for scheduled intervals for fluid checks and changes. Your transmission does not consume fluid. However, the fluid level should be checked if the transmission is not working properly, i.e., if the transmission slips or shifts slowly or if you notice some sign of fluid leakage.

304

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Automatic transmission fluid expands when warmed. To obtain an accurate fluid check, drive the vehicle until it is at normal operating temperature (approximately 20 miles [30 km]). If your vehicle has been operated for an extended period at high speeds, in city traffic during hot weather or pulling a trailer, the vehicle should be turned off for about 30
minutes to allow fluid to cool before checking. 1. Drive the vehicle 20 miles (30 km) or until it reaches normal operating temperature. 2. Park the vehicle on a level surface and engage the parking brake. 3. With the parking brake engaged and your foot on the brake pedal, start the engine and move the gearshift lever through all of the gear ranges. Allow sufficient time for each gear to engage. 4. Latch the gearshift lever in P (Park) and leave the engine running. 5. Remove the dipstick, wiping it clean with a clean, dry lint free rag. If necessary, refer to Identifying components in the engine compartment in this chapter for the location of the dipstick. 6. Install the dipstick making sure it is fully seated in the filler tube. 7. Remove the dipstick and inspect the fluid level. The fluid should be in the designated area for normal operating temperature or ambient temperature. Low fluid level Do not drive the vehicle if the fluid level is at the bottom of the dipstick and the ambient temperature is above 50°F (10°C).

5L 3P -7A020- CB

FoMoCo

COLD

Correct fluid level The transmission fluid should be checked at normal operating temperature 150°F-170°F (66°C-77°C) on a level surface. The normal operating temperature can be reached after approximately 20 miles (30
km) of driving. You can check the fluid without driving if the ambient temperature is above 50°F (10°C). However, if fluid is added at this time, an overfill condition could result when the vehicle reaches normal operating temperature.

305

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

The transmission fluid should be in this range if at normal operating temperature (150°F-170°F [66°C-77°C]).

COLD

FoMoCo

5L 3P -7A020- CB

The transmission fluid should be in this range if at ambient temperature (50°F-95°F [10°C-35°C]).

COLD

FoMoCo

5L 3P -7A020- CB

5L 3P -7A020- CB

COLD

FoMoCo

High fluid level Fluid levels above the safe range may result in transmission failure. An overfill condition of transmission fluid may cause shift and/or engagement concerns and/or possible damage. High fluid levels can be caused by an overheating condition. Adjusting automatic transmission fluid levels Before adding any fluid, make sure the correct type is used. The type of fluid used is normally indicated on the dipstick. Refer to Lubricant specifications in this chapter. Use of a non-approved automatic transmission fluid may cause internal transmission component damage. If necessary, add fluid in 1/2 pint (250 ml) increments through the filler tube until the level is correct. If an overfill occurs, excess fluid should be removed by an authorized dealer.

FoMoCo

COLD

5L 3P -7A020- CB

306

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

An overfill condition of transmission fluid may cause shift and/or engagement concerns and/or possible damage. Do not use supplemental transmission fluid additives, treatments or cleaning agents. The use of these materials may affect transmission operation and result in damage to internal transmission components.

Checking and adding manual transmission fluid (if equipped) 1. Clean the filler plug.

2. Remove the filler plug and inspect the fluid level.

307

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

3. Fluid level should be at bottom of the opening. 4. Add enough fluid through the filler opening so that the fluid level is at the bottom of the opening. 5. Install and tighten the fill plug securely.

Use only fluid that meets Ford specifications. Refer to the Lubricant specifications section in this chapter.

TRANSFER CASE FLUID (IF EQUIPPED) 1. Clean the filler plug. 2. Remove the filler plug and inspect the fluid level.

308

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

3. Add only enough fluid through the filler opening so that the fluid level is at the bottom of the opening.

Use only fluid that meets Ford specifications. Refer to the Lubricant specifications section in this chapter.

DRIVELINE UNIVERSAL JOINT AND SLIP YOKE Your vehicle may be equipped with universal joints that require lubrication. Refer to the scheduled maintenance information for maintenance intervals. If the original universal joints are replaced with universal joints equipped with grease fittings, lubrication will also be necessary.

AIR FILTER Refer to scheduled maintenance information for the appropriate intervals for changing the air filter element. When changing the air filter element, use only the Motorcraft air filter element listed. Refer to Motorcraft part numbers in this chapter.

To reduce the risk of vehicle damage and/or personal burn injuries do not start your engine with the air cleaner removed

and do not remove it while the engine is running.

309

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Changing the air filter element • 4.2L/4.6L engines 1. Loosen the clamp that secures the air filter element in place.

2. Carefully separate the two halves of the air filter housing. 3. Remove the air filter element from the open end of the air filter housing.

4. Install a new air filter element. 5. Reassemble the two halves of the air filter housing, aligning the notch and slot found on the top of each half. Secure the clamp, making sure not to crimp the air filter edges between the two halves of the air filter housing. This could cause filter damage and allow unmetered air to enter the engine if not properly seated. • 5.4L Engine 1. Release two retainer clamps.

310

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

2. Pull air filter tray assembly out toward front of vehicle and lift air filter element up and out of housing.

The air filter box needs to be free of any debris before installing a new air filter. 3. Install a new air filter element into the tray assembly. 4. Return air filter tray to original position by pressing firmly on the handle until all rearward movement stops and secure the two clamps.

MOTORCRAFT PART NUMBERS Component

Air filter element FA-1632
Battery

4.2L V6 engine 4.6L V8 engine 5.4L V8
engine FA-1754
BTX-59 or BTX-65-6503
FG-986-B FL-820-S

FA-1632
BTX-59 or BTX-65-6503
FG-986-B FL-820-S

BTX-59 or BTX-65-6503
FG-986-B FL-400-S

Fuel Filter Oil Filter PCV valve Spark plugs 1The PCV valve is a critical emission component. It is one of the items listed in scheduled maintenance information and is essential to the life and performance of your vehicle and to its emissions system.

311

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

For PCV valve replacement, see your authorized dealer. Refer to scheduled maintenance information for the appropriate intervals for changing the PCV valve. Replace the PCV valve with one that meets Ford material and design specifications for your vehicle, such as a Motorcraft or equivalent replacement part. The customer warranty may be void for any damage to the emissions system if such a PCV valve is not used. 2For spark plug replacement, see your authorized dealer. Refer to scheduled maintenance information for the appropriate intervals for changing the spark plugs. Replace the spark plugs with ones that meet Ford material and design specifications for your vehicle, such as Motorcraft or equivalent replacement parts. The customer warranty may be void for any damage to the engine if such spark plugs are not used. 3Heavy-duty battery, if equipped.

REFILL CAPACITIES Fluid

Ford Part Name Motorcraft High Performance DOT 3 Motor Vehicle Brake Fluid Motorcraft Premium Gold Engine Coolant (yellow-colored)

Application

Capacity

All

Fill to line or step (for clutch) on reservoir

4.2L V6 engine 4.6L V8 engine 5.4L V8 engine

17.6 quarts (16.7L) 20.5 quarts (19.4L) 20.9 quarts (19.8L)

Brake fluid and clutch fluid

Engine coolant1

312

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Application

Capacity

4.2L engine

6.0 quarts (5.7L)

4.6L engine

6.0 quarts (5.7L)

5.4L engine

7.0 quarts (6.6L)

Fluid

Engine oil (includes filter change)8

Fuel tank

Ford Part Name Motorcraft SAE 5W-20 Premium Synthetic Blend Motor Oil (US) Motorcraft SAE 5W-20 Super Premium Motor Oil (Canada) N/A

Reg. Cab 6.5’ box / SuperCab 5.5’ box SuperCrew 5.5’ box SuperCrew 6.5’ box

Reg. Cab 8’ box / SuperCab 6.5’ box / SuperCab 8’ box

26.0 gallons (98.4L)

30 gallons (113.6L) 27 gallons (102.2L) Standard 35.7 gallons (135.1L) Optional 27 gallons (102.1L) Standard 35.7 gallons (135.1L) Optional Fill to between MIN and MAX lines on reservoir 2.0 quarts (1.9L)2

4x4 vehicles

5–speed manual

3.75 quarts (3.5L)

Automatic 4R70E and 4R75E

13.9 quarts (13.2L)4

4x4 vehicles

3.7 pints (2.0L)

313

Power steering fluid

Motorcraft MERCON威 ATF

All

Transfer case fluid Transmission fluid3

Front axle

Motorcraft MERCON威 ATF Motorcraft MERCON威 ATF Motorcraft MERCON威V ATF Motorcraft SAE 80W-90
Premium Rear Axle Lubricant

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Application

Capacity

8.8/9.75 inch axle

5.5 pints (2.6L)6

10.25 inch axle

6.9 pints (3.3L)7

All

4.25 quarts (4.0L)

Fluid

Rear axle5

Windshield washer fluid

Ford Part Name Motorcraft SAE 75W-140 Rear Axle Lubricant (synthetic) Motorcraft Premium Windshield Washer Concentrate

1Add the coolant type originally equipped in your vehicle. 2Service refill capacity is determined by filling the transfer case to the bottom of the filler hole with the vehicle on a level surface. 3Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being added is of the correct type. Refer to your scheduled maintenance information to determine the correct service interval. Some transmission fluids may be labeled as dual usage, such as MERCON威 and MERCON威 V. These dual usage fluids are not to be used in an automatic transmission that requires use of the MERCON威 type fluid. However, these dual usage fluids may be used in transmissions that require the MERCON威 V type fluid. MERCON威 and MERCON威 V type fluids are not interchangeable. DO NOT mix MERCON威 and MERCON威 V. Use of a transmission fluid that indicates dual usage (MERCON威 and MERCON威 V) in an automatic transmission application requiring MERCON威 may cause transmission damage. Use of any fluid other than the recommended fluid may cause transmission damage. 4Approximate dry fill capacity including transmission fluid cooling system, actual refill capacities will vary based on vehicle application and transmission fluid cooling system (i.e. coolers size, cooling lines, auxiliary cooler capacities). The amount of transmission fluid and fluid level should be set by the indication on the dipstick’s normal operating range.

314

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

5Your vehicle’s rear axle is filled with a synthetic rear axle lubricant and is considered lubricated for life. These lubricants do not need to be checked or changed unless a leak is suspected, service is required or the axle assembly has been submerged in water. The axle lubricant should be changed any time the rear axle has been submerged in water. 6Service refill capacity is determined by filling the axle to 1/4-9/16 inch (6-14 mm) below the bottom of the filler hole with the vehicle on a level surface. Add 4 oz. (118 ml) of Additive Friction Modifier XL–3 or equivalent meeting Ford specification EST-M2C118–A, for complete fill of 8.8 inch and 9.75 inch Traction-Lok axles. 7Service refill capacity is determined by filling the axle to the bottom of the filler hole with the vehicle on a level surface. For 10.25 inch Traction-Lok axles, use 6.5 pints (3.1L) of Motorcraft SAE 75W-140 Synthetic Rear Axle Lubricant and 8 oz. (236 ml) of Additive Friction Modifier XL–3 or equivalent meeting Ford Specification EST-M2C118-A. 8Use of synthetic or synthetic blend motor oil is not mandatory. Engine oil need only meet the requirements of Ford specification WSS-M2C930-A and the API Certification mark.

LUBRICANT SPECIFICATIONS

Item

Front axle

(4X4)

Rear axle

Ford part name or equivalent

Motorcraft SAE

80W-90

Premium Rear Axle Lubricant Motorcraft SAE 75W-140 Rear Axle Lubricant (synthetic)1

Ford part number

Ford

specification

XY-80W-90-QL

WSP-M2C197-A

XY-75W140-QL

WSL-M2C192-A

315

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Item

Brake fluid and

clutch fluid

Ford part name or equivalent

Motorcraft High

Performance DOT 3 Motor Vehicle Brake

Fluid

Ford part number

Ford

specification

ESA-M6C25-A

PM-1 or PM-1-C

or

WSS-M6C62-A

Motorcraft

VC-7-A (except CA,

Engine coolant

Cooling system stop leak pellets

Engine oil

Seat tracks

Hinges, latches, striker plates, fuel filler door hinge and door

check arm

Lock cylinders

Premium Gold Engine Coolant (yellow-colored)

Motorcraft

Cooling System

Stop Leak

Pellets

Motorcraft SAE 5W-20 Premium Synthetic Blend Motor Oil (US) Motorcraft SAE

5W-20 Super

Premium Motor

Oil (Canada) Multi-Purpose

Grease

Motorcraft

Silicone Brake Caliper Grease and Dielectric

Compound Motorcraft

Penetrating and Lock Lubricant

OR and NM),

WSS-

VC-7-B (CA, OR and

M97B51-A1

NM)

VC-6

WSS-M99B37-B6

XO-5W20-QSP (US) CXO-5W20-LSP12

(Canada)

WSS-M2C930-A

and API

Certification

Mark

XG-4 or XL-5

ESB-M1C93-B

XG-3-A

ESE-M1C171-A

XL-1

none

316

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Item

Transmission

/steering/parking brake linkages

and pivots, brake and clutch pedal

shaft (if equipped)

Power steering fluid, transfer case fluid (4X4)

and manual transmission

fluid

Automatic transmission (4R70E and

4R75E)

Windshield washer fluid

Maintenance and Specifications

Ford part name or equivalent

Premium Long-Life Grease

Ford part number

Ford

specification

XG-1-C

ESA-M1C75-B

Motorcraft

MERCON威 ATF

XT-2-QDX

MERCON威

Motorcraft MERCON威V

ATF2

Motorcraft Premium Windshield

Washer

Concentrate

XT-5-QM

MERCON威V

ZC-32-A

WSB-M8B16-A2

1Use Additive Friction Modifier XL-3 or equivalent for complete refill of Traction-Lok axles. 2Ensure the correct automatic transmission fluid is used. Transmission fluid requirements are indicated on the dipstick or on the dipstick handle. Check the container to verify the fluid being added is of the correct type. Refer to your scheduled maintenance information to determine the correct service interval. Some transmission fluids may be labeled as dual usage, such as MERCON威 and MERCON威 V. These dual usage fluids are not to be used in an automatic transmission that requires use of the MERCON威 type fluid.

317

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

MERCON威 and MERCON威 V type fluids are not interchangeable. DO NOT mix MERCON威 and MERCON威 V. Use of a transmission fluid that indicates dual usage (MERCON威 and MERCON威 V) in an automatic transmission application requiring MERCON威 may cause transmission damage. Use of any fluid other than the recommended fluid may cause transmission damage.

ENGINE DATA Engine Cubic inches

Required fuel

4.2L V6 engine 4.6L V8 engine 5.4L V8 engine 256
87 octane

281
87 octane

330
87 octane or Ethanol (E 85)2
1-3-7-2-6-5-4-8
Coil on plug 0.040–0.050 inch (1.02–1.28mm)1
9.85:1

Firing order Ignition system EDIS

1-4-2-5-3-6

Spark plug gap

0.052–0.056 inch (1.32–1.42mm) 9.3:1

1-3-7-2-6-5-4-8
Coil on plug 0.052–0.056 inch (1.32–1.42mm) 9.37:1

Compression ratio 1The 5.4L 3V spark plug gap can’t be adjusted. 25.4L 3V FFV engines only.

318

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

VEHICLE DIMENSIONS

Vehicle dimensions

(1) Overall length (2) Overall width (3) Overall height – 4x2/4x4
(4) Wheelbase – 4x2/4x4
(5) Track - Front (5) Track - Rear

Regular Cab

Styleside 6.5’ box - inches (mm) 211.2 (5364)

Flareside 6.5’ box - inches (mm) 211.2 (5364)

Styleside 8.0’ box - inches (mm) 229.8 (5837)

78.9 (2005)

78.9 (2005)

78.9 (2005)

73.7 (1872) / 75.6 (1921)

73.8 (1875) / 75.6 (1921)

73.8 (1875) / 75.6 (1921)

126.0 (3198) / 126.0 (3198) 67.0 (1701)

126.0 (3198) / 126.0 (3198) 67.0 (1701)

144.5 (3671) / 144.5 (3671) 67.0 (1701)

67.0 (1701)

67.0 (1701)

67.0 (1701)

319

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

SuperCab

Styleside 5.5’ box - inches (mm)

217.8 (5532)

Styleside / Flareside 6.5’ box - inches (mm) 229.8 (5837)

Styleside 8.0’ box - inches (mm)

248.4 (6309)

78.9 (2005)

78.9 (2005)

78.9 (2005)

74.1 (1881) / 76.5 (1943)

73.5 (1866) / 75.6 (1919)

73.4 (1865) / 75.4 (1916)

132.5 (3366) / 132.5 (3366) 67.0 (1701)

144.5 (3671) / 144.5 (3671) 67.0 (1701)

163.1 (4143) / 163.1 (4143) 67.0 (1701)

67.0 (1701)

67.0 (1701)

67.0 (1701)

Vehicle dimensions

(1) Overall length (2) Overall width (3) Overall height – 4x2/4x4
(4) Wheelbase – 4x2/4x4
(5) Track - Front (5) Track - Rear

320

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Super Crew

Vehicle dimensions

Styleside 5.5’ box -

Styleside 6.5’ box -

(1) Overall length (2) Overall width (3) Overall height – 4x2/4x4

inches (mm) 223.8 (5685) 78.9 (2005)

inches (mm) 235.8 (5990) 78.9 (2005)

73.5 (1867) /

76.0 (1931)

73.5 (1867) /

76.0 (1931)

321

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

Vehicle dimensions

Styleside 5.5’ box -

Styleside 6.5’ box -

Super Crew

(4) Wheelbase (5) Track - Front (5) Track - Rear

inches (mm) 138.5 (3518) 67.0 (1701) 67.0 (1701)

inches (mm) 150.5 (3823 ) 67.0 (1701) 67.0 (1701)

322

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

IDENTIFYING YOUR VEHICLE

Safety Compliance Certification Label The National Highway Traffic Safety Administration Regulations require that a Safety Compliance Certification Label be affixed to a vehicle and prescribe where the Safety Compliance Certification Label may be located. The Safety Compliance Certification Label is located on the structure (B-Pillar) by the trailing edge of the driver’s door or the edge of the driver’s door.

Vehicle identification number (VIN) The vehicle identification number is located on the driver side instrument panel. Please note that in the graphic, XXXX is representative of your vehicle identification number.

XXXXXXXXXXXXXXXXX

323

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Maintenance and Specifications

The Vehicle Identification Number (VIN) contains the following information: 1. World manufacturer identifier 2. Brake system / Gross Vehicle Weight Rating (GVWR) / Restraint System 3. Vehicle line, series, body type 4. Engine type 5. Check digit 6. Model year 7. Assembly plant 8. Production sequence number

TRANSMISSION/TRANSAXLE CODE DESIGNATIONS You can find a transmission/transaxle code on the Safety Compliance Certification Label. The following table tells you which transmission or transaxle each code represents.

Description Four-speed automatic (4R70E) Four-speed automatic (4R75E) Five-speed manual (M5R2)

324

Code

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Accessories

GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local Ford or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle. In addition, each accessory is made from high quality materials and meets or exceeds Ford’s rigorous engineering and safety specifications. Ford Motor Company will repair or replace any properly dealer-installed Genuine Ford Accessories found to be defective in factory-supplied materials or workmanship during the warranty period, as well as any component damaged by the defective accessory. The accessories will be warranted for whichever provides you the greatest benefit: • 12 months or 12,000 miles (20,000 km) (whichever occurs first), or • the remainder of your new vehicle limited warranty. This means that Genuine Ford Accessories purchased along with your new vehicle and installed by a dealer are covered for the full length of your New Vehicle’s Limited Warranty — 3 years or 36,000 miles (60,000
km) (whichever occurs first). Contact your dealer for details and a copy of the warranty. Not all accessories are available for all models. The following is a list of several Genuine Ford Accessories. Not all accessories are available for all models. For a complete listing of the accessories that are available for your vehicle, please contact your dealer or visit our online store at: www.fordaccessoriesstore.com.

Exterior style Bug shields Deflectors Running boards Sliding rear windows - manual and power Splash guards Step bars Tonneau covers Wheels

Interior style Electrochromatic compass/temperature interior mirrors Floor mats Speed control

325

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Accessories

Lifestyle Bedliners and bedmats Cargo organization and management Rear seat entertainment systems Towing mirrors Trailer hitches, wiring harnesses and accessories

Peace of mind Mobile-Ease娂 hands free communication system Remote start Vehicle security systems For maximum vehicle performance, keep the following information in mind when adding accessories or equipment to your vehicle: • When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front or rear axle (GVWR or GAWR as indicated on the Safety Compliance Certification label). Consult your authorized dealer for specific weight information.

• The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the use of mobile communications systems — such as two-way radios, telephones and theft alarms - that are equipped with radio transmitters. Any such equipment installed in your vehicle should comply with FCC or CRTC regulations and should be installed only by a qualified service technician.

• Mobile communications systems may harm the operation of your

vehicle, particularly if they are not properly designed for automotive use. • To avoid interference with other vehicle functions, such as anti-lock braking systems, amateur radio users who install radios and antennas onto their vehicle should not locate the Amateur Radio Antennas in the area of the driver’s side hood. • Electrical or electronic accessories or components that are added to

the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability.

326

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Index

acid, treating emergencies .....283
jumping a disabled battery ....250
maintenance-free ....................283
replacement, specifications ...311
servicing ..................................283
Bed extender ..............................96
BeltMinder威 ...............................134

deactivating/activating the BeltMinder威 ............................136
Brakes ........................................204
anti-lock ...................................205
anti-lock brake system (ABS) warning light ...........................205
fluid, checking and adding ....303
fluid, refill capacities ..............312
fluid, specifications .........315, 318
lubricant specifications ..315, 318
parking ....................................206
shift interlock ..................209–210
Bulbs ............................................62

Capacities for refilling fluids ....312
Cell phone use ..............................9
Changing a tire .........................243
Child safety restraints ..............147
child safety belts ....................147
Child safety seats ......................151
attaching with tether straps ..158
in front seat ....................152, 155
in rear seat ..............152, 155, 158

Cleaning your vehicle

engine compartment ..............265
instrument panel ....................267
interior .....................................269
interior trim ............................269
plastic parts ............................266
safety belts ..............................269

327

Accessory delay ..........................74
Air cleaner filter ...............309–311
Air conditioning ....................50, 53
Airbag supplemental restraint system ................................138–139
and child safety seats ............141
description ..............................139
disposal ....................................143
driver airbag ....................139, 142
indicator light .........................143
operation .........................139, 142
passenger airbag .............139, 142
Ambulance packages ....................8
Antifreeze (see Engine coolant) ................285
Anti-lock brake system (see Brakes) ..............................205
Anti-theft system ......................109
arming the system ..................110
Armrests ....................................115
Audio system (see Radio) ................22, 24, 30, 35
Automatic transmission

driving an automatic overdrive .................................212
fluid, adding ............................304
fluid, checking ........................304
fluid, refill capacities ..............312
fluid, specification ..................318

Axle

lubricant specifications ..315, 318
refill capacities ........................312
traction lok ..............................208

Battery .......................................283

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Utilizing the Mediation/Arbitration Program ...................................259

Daytime running lamps (see Lamps) ................................58
Dipstick

automatic transmission fluid ..........................................304
engine oil .................................279

Doors

lubricant specifications ..........315

Driveline universal joint and slip yoke ....................................309
Driving under special conditions ..................215, 224, 228
sand .........................................226
snow and ice ...........................229
through water .................227, 230
DVD system .................................46

Electronic message center .........87
Emergencies, roadside

jump-starting ..........................250
Emergency Flashers .................235
Emission control system ..........300
Engine ................................318–319
cleaning ...................................265
coolant .....................................285
fail-safe cooling .......................289
idle speed control ...................283
lubrication specifications ..................315, 318
refill capacities ........................312
service points ..................275–277

Index

washing ....................................263
waxing .....................................264
wheels ......................................264
wiper blades ............................267

Climate control (see Air conditioning or Heating) ...........................47, 50, 53
Clock adjust

6-CD in dash .............................37
AM/FM Stereo ...........................23
AM/FM/CD .................................26
AM/FM/Tape/CD .......................32

Clutch

fluid ..........................................303
operation while driving ..........215
recommended shift speeds ....216
Compass, electronic ..............85, 87
calibration .................................87
set zone adjustment ...........87–88
Console ........................................68
overhead ....................................69

Controls

power seat ...............................115
steering column ........................79

Coolant

checking and adding ..............285
refill capacities ................288, 312
specifications ..................315, 318

Cruise control (see Speed control) ....................77
Customer Assistance ................233
Ford Extended Service Plan ..260
Getting assistance outside the U.S. and Canada .....................260
Getting roadside assistance ...233
Getting the service you need .........................................256
Ordering additional owner’s literature .................................261

328

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Index

octane rating ...........296, 318–319
quality ......................................296
running out of fuel .................297
safety information relating to automotive fuels .....................291

Fuel - flex fuel vehicle (FFV) .........................291, 295–296
Fuel pump shut-off switch .......235
Fuses ..................................236–237

Gas cap (see Fuel cap) ............294
Gas mileage (see Fuel economy) .................297
Gauges .........................................19

Hazard flashers .........................235
Head restraints .................113, 117
Headlamps ...................................57
aiming ........................................59
autolamp system .......................57
bulb specifications ....................62
daytime running lights .............58
flash to pass ..............................58
high beam .................................58
replacing bulbs .........................63
turning on and off ....................57

Heating

heater only system ...................47
heating and air conditioning system ...........................48, 50, 53

Homelink wireless control system ..........................................81
Hood ..........................................274

Ignition .......................200, 318–319

329

starting after a collision .........235
Engine block heater .................204
Engine oil ..................................279
checking and adding ..............279
dipstick ....................................279
filter, specifications ........282, 311
recommendations ...................282
refill capacities ........................312
specifications ..................315, 318
Exhaust fumes ..........................204

Fail safe cooling ........................289
Flexible Fuel Vehicle (FFV) ....291
Floor mats ...................................95
Fluid capacities .........................312
Foglamps .....................................58
Four-Wheel Drive vehicles .......219
driving off road .......................223
electronic shift ................221–222
indicator light .........................219
lever operated shift ................220
preparing to drive your vehicle .....................................209
Fuel ............................................291

calculating fuel economy ............................90, 297
cap ...........................................294
capacity ...................................312
choosing the right fuel ...........295
comparisons with EPA fuel economy estimates .................300
detergent in fuel .....................295
filling your vehicle with fuel ...........................291, 294, 297
filter, specifications ........290, 311
fuel pump shut-off switch .....235
improving fuel economy ........297

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Lane change indicator (see Turn signal) ........................60
Lights, warning and indicator ....12
anti-lock brakes (ABS) ..........205
Load limits .................................180
Loading instructions .................186
Locks

autolock ...................................106
childproof ..................................99
doors ..........................................98
Lubricant specifications ...315, 318
Lug nuts ....................................249
Lumbar support, seats .............115

Manual transmission .................215
reverse .....................................217
Message center ...........................87
english/metric button ...............91
system check button ................91
warning messages .....................92
Mirrors .........................................75

automatic dimming rearview mirror ........................................74
fold away ...................................75
heated ........................................76
programmable memory ..........101
side view mirrors (power) .......75
.........................................76
signal Moon roof ....................................80
Motorcraft parts ........271, 290, 311

Octane rating ............................296
Oil (see Engine oil) ..................279
Parking brake ............................206

Index

Illuminated visor mirror .............68
Infant seats (see Safety seats) 151
Inspection/maintenance (I/M) testing ........................................302
Instrument panel

cleaning ...................................267
cluster ........................................12
lighting up panel and interior .......................................59

Jack ............................................243
positioning ...............................243
storage .....................................243
Jump-starting your vehicle ......250

Keyless entry system ...............108
autolock ...................................106
keypad .....................................108
locking and unlocking doors ..109
programming entry code .......108
Keys .....................................98, 111
positions of the ignition .........200

Lamps

autolamp system .......................57
bulb replacement specifications chart ..................62
daytime running light ...............58
fog lamps ...................................58
headlamps .................................57
headlamps, flash to pass ..........58
instrument panel, dimming .....59
interior lamps .....................61–62
replacing bulbs ...................63, 66

330

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Index

Safety restraints .......119, 122, 124, 126, 128–132
BeltMinder威 ............................134
BeltMinder威, deactivating/activating ...........136
extension assembly ................132
for adults .........124, 126, 128–130
for children .............................147
lap belt ....................................127
Occupant Classification Sensor ......................................120
safety belt maintenance .........133
warning light and chime ........133
Safety seats for children ..........151
Safety Compliance Certification Label ....................323
Satellite Radio Information ........43
Seat belts (see Safety restraints) .............119
Seats ..........................................113
child safety seats ....................151
cleaning ...................................270
heated ................................53, 117
memory seat ...................101, 117

SecuriLock passive anti-theft system ................................109, 111
Servicing your vehicle ..............273
Setting the clock

AM/FM stereo ...........................23
AM/FM/CD .................................26
AM/FM/In-dash 6 CD ................37
AM/FM/Tape/CD .......................32
Snowplowing .................7, 230–231
Spark plugs, specifications .............311, 318–319
Special notice

ambulance conversions ..............8
four-wheel drive vehicles .......232

331

Parts (see Motorcraft parts) ....311
Passenger Occupant Classification Sensor .................120
Power distribution box (see Fuses) ...............................237
Power door locks ........................98
Power mirrors .............................75
Power point .................................71
Power steering ..........................208
fluid, checking and adding ....303
fluid, refill capacity ................312
fluid, specifications .........315, 318
Power Windows ...........................72
Preparing to drive your vehicle ........................................209

Radio ..........................22, 24, 30, 35
Relays ........................................236
Remote entry system .........99–100
illuminated entry ....................104
locking/unlocking doors ................................100–101
panic alarm .............................101
replacement/additional transmitters .............................103
replacing the batteries ...........102
Reverse sensing system ...........217
Roadside assistance ..................233

Safety Belt Maintenance ..........133
Safety belts (see Safety restraints) .........119, 122, 124, 126, 128–130, 132
Safety defects, reporting ..........262

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Traction control ........................207
Traction-lok rear axle ...............208
Transfer case

fluid checking .........................308
Transmission .............................209

brake-shift interlock (BSI) ................................209–210
fluid, checking and adding (automatic) .............................304
fluid, checking and adding (manual) .................................307
fluid, refill capacities ..............312
lubricant specifications ..315, 318
manual operation ....................215
..................................60

Turn signal

Vehicle dimensions ...........319, 323
Vehicle Identification Number (VIN) ..........................................323
Vehicle loading ..........................180
Ventilating your vehicle ...........204

Warning lights (see Lights) .......12
Washer fluid ..............................278
Water, Driving through .............230
Windows

power .........................................72
power down back window .......73

Windshield washer fluid and wipers ..........................................67
checking and adding fluid .....278
replacing wiper blades ...........278

Index

utility-type vehicles ....................8

Specification chart, lubricants ...........................315, 318
Speed control ..............................77
Starting a flex fuel vehicle .......203
Starting your vehicle ........................200–201, 203
jump starting ..........................250

Steering wheel

controls ......................................79
tilting .........................................67

Tailgate ..................................95–96
Temperature control (see Climate control) .................47
Tilt steering wheel ......................67
Tires ...........................166–168, 243
alignment ................................174
care ..........................................171
changing ..........................243, 246
checking the pressure ............171
inflating ...................................169
label .........................................179
replacing ..................................172
rotating ....................................174
safety practices .......................173
sidewall information ...............175
snow tires and chains ............180
spare tire .................................243
terminology .............................168
tire grades ...............................167
treadwear ........................167, 171
Towing .......................................186
recreational towing .................198
trailer towing ..........................186

332

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

333

334

335

336

Table of Contents

12

12
19
22

22
24
30
35
43
47

47
48
50
56
57

57
60
62
67

67
67
72
75
77
87
95

Introduction

Instrument Cluster

Warning lights and chimes Gauges

Entertainment Systems

AM/FM stereo AM/FM stereo with CD AM/FM stereo cassette with CD AM/FM stereo with in-dash six CD Satellite radio information

Climate Controls

Heater only Manual heating and air conditioning Automatic temperature control Rear window defroster

Lights

Headlamps Turn signal control Bulb replacement Driver Controls

Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Message center Tailgate

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

98

98
98
109
113

113
119
138
147
164

166
169
180
186
198
200

200
204
207
209
233

233
235
235
236
243
249
250
255
256

262

Table of Contents

Locks and Security

Keys Locks Anti-theft system

Seating and Safety Restraints

Seating Safety restraints Airbags Child restraints

Tires, Wheels and Loading

Tire information Tire inflation Vehicle loading Trailer towing Recreational towing

Driving

Starting Brakes Traction Control™ Transmission operation

Roadside Emergencies

Getting roadside assistance Hazard flasher switch Fuel pump shut-off switch Fuses and relays Changing tires Lug nut torque Jump starting Wrecker towing

Customer Assistance

Reporting safety defects (U.S. only)

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Cleaning

Maintenance and Specifications

Engine compartment Engine oil Battery Engine coolant Fuel information Air filter(s) Part numbers Refill capacities Lubricant specifications Engine data Accessories

Index

Table of Contents

263

273

275
279
283
285
291
309
311
312
315
318
325

327

All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without written authorization from Ford Motor Company. Ford may change the contents without notice and without incurring obligation.

Copyright © 2006 Ford Motor Company

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

CALIFORNIA Proposition 65 Warning

WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to

the State of California to cause cancer and birth defects or other reproductive harm. In addition, certain fluids contained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm.

CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it. For more information on Ford Motor Company and its products visit the following website: • In the United States: www.ford.com • In Canada: www.ford.ca • In Australia: www.ford.com.au • In Mexico: www.ford.com.mx Additional owner information is given in separate publications. This Owner’s Guide describes every option and model variant available and therefore some of the items covered may not apply to your particular vehicle. Furthermore, due to printing cycles it may describe options before they are generally available. Remember to pass on this Owner’s Guide when reselling the vehicle. It is an integral part of the vehicle.

Fuel pump shut-off switch: In the event of an accident the safety switch will automatically cut off the fuel supply to the

engine. The switch can also be activated through sudden vibration (e.g. collision when parking). To reset the switch, refer to the Fuel pump shut-off switch in the Roadside Emergencies chapter.

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

SAFETY AND ENVIRONMENT PROTECTION

Warning symbols in this guide

How can you reduce the risk of personal injury to yourself or others? In this guide, answers to such questions are contained in comments highlighted by the warning triangle symbol. These comments should be read and observed.

Warning symbols on your vehicle

When you see this symbol, it is imperative that you consult the relevant section of this guide before touching or attempting adjustment of any kind.

Protecting the environment We must all play our part in protecting the environment. Correct vehicle usage and the authorized disposal of waste, cleaning and lubrication materials are significant steps towards this aim. Information in this respect is highlighted in this guide with the tree symbol.

BREAKING-IN YOUR VEHICLE Your vehicle does not need an extensive break-in. Try not to drive continuously at the same speed for the first 1,000 miles (1,600 km) of new vehicle operation. Vary your speed frequently in order to give the moving parts a chance to break in. Drive your new vehicle at least 500 miles (800 km) before towing a trailer. Additionally, during the first 500 miles (800 km) that you tow a trailer, do not drive over 70 mph (112 km/h) and do not make starts at full throttle. This style of driving will help the engine and other parts of your vehicle break in at the heavier loads. For more detailed information about towing a trailer, refer to Trailer towing in the Tires, Wheels and Loading chapter. Do not add friction modifier compounds or special break-in oils during the first few thousand miles (kilometers) of operation, since these additives may prevent piston ring seating. See Engine oil in the Maintenance and Specifications chapter for more information on oil usage.

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

SPECIAL NOTICES

New Vehicle Limited Warranty For a detailed description of what is covered and what is not covered by your vehicle’s New Vehicle Limited Warranty, refer to the Warranty Guide that is provided to you along with your Owner’s Guide.

Special instructions For your added safety, your vehicle is fitted with sophisticated electronic controls.

Please read the section Supplemental restraint system (SRS) in the Seating and Safety Restraints chapter. Failure to follow the specific warnings and instructions could result in personal injury.

Front seat mounted rear-facing child or infant seats should NEVER be placed in front of an active passenger airbag.

Service Data Recording Service data recorders in your vehicle are capable of collecting and storing diagnostic information about your vehicle. This potentially includes information about the performance or status of various systems and modules in the vehicle, such as engine, throttle, steering or brake systems. In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access vehicle diagnostic information through a direct connection to your vehicle when diagnosing or servicing your vehicle.

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

Event Data Recording Other modules in your vehicle — event data recorders — are capable of collecting and storing data during a crash or near crash event. The recorded information may assist in the investigation of such an event. The modules may record information about both the vehicle and the occupants, potentially including information such as: • how various systems in your vehicle were operating; • whether or not the driver and passenger seatbelts were buckled; • how far (if at all) the driver was depressing the accelerator and/or the • how fast the vehicle was traveling; and • where the driver was positioning the steering wheel. To access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent, unless pursuant to court order or where required by law enforcement, other government authorities or other third parties acting with lawful authority. Other parties may seek to access the information independently of Ford Motor Company and Ford of Canada.

brake pedal;

Using your vehicle with a snowplow For more information and guidelines for using your vehicle with a snowplow, refer to the Driving chapter.

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

Using your vehicle as an ambulance Do not use this vehicle as an ambulance. Your vehicle is not equipped with the Ford Ambulance Preparation Package.

Notice to owners of pickup trucks and utility type vehicles

Utility vehicles have a significantly higher rollover rate than other types of vehicles.

Before you drive your vehicle, please read this Owner’s Guide carefully. Your vehicle is not a passenger car. As with other vehicles of this type, failure to operate this vehicle correctly may result in loss of vehicle control, vehicle rollover, personal injury or death. Be sure to read Driving off road in the Driving chapter. Notice to owners of the 2006 F150
Note: Your vehicle is equipped with high performance tires. When first driving the vehicle after it has been parked for a period of time, you may experience a temporary ride disturbance. This is a characteristic of the tires and should be no reason for concern. The condition should correct itself within 5-15 miles of driving. If the disturbance persists, have the tires serviced by an authorized dealer.

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

Cell phone use The use of Mobile Communications Equipment has become increasingly important in the conduct of business and personal affairs. However, drivers must not compromise their own or others’ safety when using such equipment. Mobile Communications can enhance personal safety and security when appropriately used, particularly in emergency situations. Safety must be paramount when using mobile communications equipment to avoid negating these benefits. Mobile Communication Equipment includes, but is not limited to cellular phones, pagers, portable email devices, in-vehicle communications systems, telematics devices and portable two-way radios.

A driver’s first responsibility is the safe operation of the vehicle. The most important thing you can do to prevent a crash is to

avoid distractions and pay attention to the road. Wait until it is safe to operate Mobile Communications Equipment.

Middle East/North Africa vehicle specific information For your particular global region, your vehicle may be equipped with features and options that are different from the ones that are described in this Owner’s Guide; therefore, a supplement has been supplied that complements this book. By referring to the pages in the provided supplement, you can properly identify those features, recommendations and specifications that are unique to your vehicle. Refer to this Owner’s Guide for all other required information and warnings.

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

These are some of the symbols you may see on your vehicle.

Vehicle Symbol Glossary

Safety Alert

See Owner’s Guide

Fasten Safety Belt

Airbag - Front

Airbag - Side

Child Seat

Child Seat Installation Warning

Child Seat Tether Anchor

Anti-Lock Brake System

Child Seat Lower Anchor

Brake System

Brake Fluid - Non-Petroleum Based

Powertrain Malfunction

Speed Control

Master Lighting Switch

Hazard Warning Flasher

Fog Lamps-Front

Fuse Compartment

Fuel Pump Reset

Windshield Wash/Wipe

Windshield Defrost/Demist

Rear Window Defrost/Demist

10

2006 F-150 (f12) Owners Guide (post-2002-fmt) USA (fus)

Introduction

Vehicle Symbol Glossary

Power Windows Front/Rear

Child Safety Door