2004 Toyota Highlander Owners Manual

Download PDF Manual
lights Stop/tail lights Back−up lights High mounted stop light License plate lights Interior lights Personal lights Vanity lights Door courtesy lights Bulb No. 9006 9005 9006 51 60 51 — 21/5 168 — 7443 7440 921 — — — — — 21 21/5 21 16 Glove box light #74 1.2 ’04 HIGHLANDER_U (L/O 0308) —Headlights A: HB4 halogen bulbs B: HB3 halogen bulbs C: Single end bulbs D: Wedge base bulbs (amber) E: Wedge base bulbs (clear) F: Double end bulbs 1. Open the hood. Turn the bulb base counterclockwise to the front of the vehicle as shown. 393 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) —Front fog, front turn signal/ parking and front side marker, and rear side marker lights If any of the following lights burns out, contact your Toyota dealer. D Front fog lights D Front turn signals/parking and front side marker lights D Rear side marker lights NOTICE Do not try to replace any of the light bulbs mentioned above by yourself. You may damage the vehicle. 2. Pull the bulb out of the bulb base and install a new bulb. If the connector is tight, wiggle it. 3. Insert the bulb base into the mount- ing hole by turning it clockwise. Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer. 394 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) —Rear turn signal, stop/tail and back−up lights —High mounted stoplight a: Stop/tail light b: Rear turn signal light c: Stop/tail light d: Back−up light 395 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) —License plate light Use a Phillips−head screwdriver. 396 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) SECTION 8 SPECIFICATIONS Specifications Dimensions and weights Engine Fuel Service specifications Tires Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 398 398 399 399 402 402 397 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Engine Model: 2AZ−FE and 3MZ−FE Type: 2AZ−FE engine 4 cylinder in line, 4 cycle, gasoline 3MZ−FE engine 6 cylinder V type 4 cycle, gasoline Bore and stroke, mm (in.): 2AZ−FE engine 88.5 96.0 (3.48 3.78) 3MZ−FE engine 92.0 83.0 (3.62 3.27) Displacement, cm3 (cu. in.): 2AZ−FE engine 2362 (144.1) 3MZ−FE engine 3311 (202.1) Dimensions and weights Two−wheel drive models Four−wheel drive models 4690 (184.6) 1825 1680 1735 (71.9) (66.1)∗2 (68.3)∗3 2715 (106.9) 1580 (62.2) 1565 (61.6) (860)∗4 390 526 (1159)∗5 1360 (3000)∗6 1585 (3500)∗7 4690 (184.6) 1825 1690 1745 (71.9) (66.5)∗2 (68.7)∗3 2715 (106.9) 1575 (62.0) 1555 (61.2) (860)∗4 390 526 (1159)∗5 1360 (3000)∗6 1585 (3500)∗7 Overall length Overall width Overall height∗1 Wheelbase Front tread Rear tread mm (in.) mm (in.) mm (in.) mm (in.) mm (in.) mm (in.) kg (lb.) kg (lb.) Vehicle capacity weight (occupants + luggage) Towing capacity (trailer weight + cargo weight) ∗1: Unladen vehicle ∗2: Without roof rails ∗3: With roof rails ∗4: Without third seat ∗5: With third seat ∗6: 2AZ−FE engine ∗7: 3MZ−FE engine 398 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) Fuel Fuel type: 2AZ−FE engine Unleaded gasoline, Octane Rating 87 (Research Octane Number 91) or higher 3MZ−FE engine Unleaded gasoline, Octane Rating 87 (Research Octane Number 91) or higher. For improved vehicle perfor- mance, the use of premium unleaded gasoline with an Octane Rating of 91 (Research Octane Number 96) or higher is recommended. Fuel tank capacity, L (gal., Imp. gal.): 72.5 (19.1, 16.0) ’04 HIGHLANDER_U (L/O 0308) Service specifications ENGINE Valve clearance (engine cold), mm (in.): 2AZ−FE engine Intake Exhaust 0.19—0.29 (0.007—0.011) 0.30—0.40 (0.012—0.016) 3MZ−FE engine Intake Exhaust 0.15—0.25 (0.006—0.010) 0.25—0.35 (0.010—0.014) Spark plug type: DENSO NGK SK20R11 IFR6A11 Spark plug gap, mm(in.): 1.1 (0.043) Drive belt roughs No.BT−33−73F (used belt), Ibf: tension measured with Bor- gauge tension drive belt 2AZ−FE engine Automatic adjustment 3MZ−FE engine 125"10 ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.): 2AZ−FE engine With filter Without filter 3MZ−FE engine 3.8 (4.0, 3.3) 3.6 (3.8, 3.2) With filter Without filter 4.7 (5.0, 4.1) 4.5 (4.8, 4.0) “Toyota Genuine Motor Oil” in your Toyota vehicle. Use Toyota approved “Toyota Genuine Motor Oil” or equivalent to grade and viscosity. Oil grade: following satisfy filled the is API grade SL “Energy−Conserving” or ILSAC multigrade engine oil 399 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Recommended oil viscosity: SAE 5W−30 Outside temperature Please contact your Toyota dealer for fur- ther details. COOLING SYSTEM Total capacity, L (qt., Imp. qt.): 2AZ−FE engine With rear heater Without rear heater 3MZ−FE engine With rear heater Without rear heater 7.7 8.5 6.3 7.1 (8.1, (9.0, (6.7, (7.5, 6.8) 7.5)∗ 5.5) 6.2)∗ 10.7 (11.3, 9.4) 11.4 (12.0, 10.0)∗ 9.4 (9.9, 10.1 (10.7, ∗: Vehicles with towing package Coolant type: 8.3) 8.9)∗ “Toyota Super Long Life Coolant” is filled in your Toyota vehicle at factory fill. In order to avoid technical problems, only use “Toyota Super Long Life Coolant” or similar high quality ethylene glycol based non−silicate, non−amine, non−nitrite, and non−borate coolant with long−life hybrid organic acid technology. Do not use plain water alone. Please contact your Toyota dealer for further details. 400 BATTERY Open voltage∗ at 20_C (68_F): 12.6—12.8V Fully charged 12.2—12.4V Half charged 11.8—12.0V Discharged ∗: Voltage that is checked 20 minutes af- ter the key is removed with all the lights turned off Charging rates: 5 A max. AUTOMATIC TRANSAXLE Fluid capacity (drain and refill), L (qt., Imp. qt.): Up to 3.5 (3.7, 3.1) Fluid type: Toyota Genuine ATF Type T−IV is necessary Change automatic transmission fluid only as necessary. Generally, to change it automatic transmission fluid only if your vehicle is driven under one of the Special your Operating Conditions “Scheduled Maintenance or “Owner’s Manual Supplement”. When changing the automatic transmission fluid, use only “Toyota Genuine ATF Type T−IV” (ATF JWS3309 or NWS6500) in to aid assuring optimum transaxle performance. Guide” listed in 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) STEERING Wheel free play: Less than 30 mm (1.2 in.) Power steering fluid type: Automatic transmission fluid DEXRONrII or III Notice: Using automatic transmission fluid other than “Toyota Genuine ATF Type T−IV” may cause deterioration in shift quality, locking up of your trans- mission accompanied by vibration, and ultimately damage the automatic trans- mission of your vehicle. Please contact your Toyota dealer for fur- ther details. TRANSFER (four−wheel drive models) Oil capacity, L (qt., Imp. qt.): 0.9 (1.0, 0.8) Oil type: Hypoid gear oil API GL−5 Recommended oil viscosity: Above −18_C (0_F) SAE 90 Below −18_C (0_F) SAE 80W or 80W−90 REAR DIFFERENTIAL (four−wheel drive models) Oil capacity, L (qt., Imp. qt.): 0.9 (1.0, 0.8) Oil type: Hypoid gear oil API GL−5 Recommended oil viscosity: Above −18_C (0_F) SAE 90 Below −18_C (0_F) SAE 80W or 80W−90 BRAKES Minimum pedal clearance when depressed with the force of 490 N (50 kgf, 110 lbf) with the engine running, mm (in.): 83 (3.3) Pedal free play, mm (in.): 2—3 (0.08—0.12) Pad wear limit, mm (in.): 1.0 (0.04) Lining wear limit, mm (in.): 1.0 (0.04) Parking brake adjustment when depressed with the force of 294 N (30 kgf, 66 lbf): 5—7 clicks Fluid type: SAE J1703 or FMVSS No.116 DOT 3 401 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Tires Tire size and cold tire inflation pressure: Fuses kPa (kgf/cm2 or bar, psi) Tire size Tire inflation pressure Front Rear Wheel size P225/70R16 101S 225/65R17 101S 210 (2.1, 31) 210 (2.1, 31) 210 (2.1, 31) 210 (2.1, 31) 16 6 1/2 JJ 17 6 1/2 JJ When driving under the above load condition at sustained high speeds above 160 km, in countries where such speeds are permitted by−low, inflate the front and rear tires to the following tire inflation pressure provided that it does not exceed the maximum cold tire inflation pressure molded on the tire sidewall. P225/70R16 101S tires 225/65R17 101S tires 240 kPa (2.4 kgf/cm2 or bar, 35 psi) 230 kPa (2.3 kgf/cm2 or bar, 33 psi) Wheel nut torque, N·m (kgf·m, ft·lbf): 103 (10.5, 76) NOTE: For a complete information on tires (e.g. replacing tires or replacing wheels), see “Checking tire inflation pressure” through “Aluminum wheel precautions”, pages 377 through 385, in Section 7−2. 402 Engine compartment 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) 14. H−LP RH UPR 10 A: Right−hand head- light (high beam) 15. ECU·B 7.5 A: Theft deterrent system, air conditioning system, gauges and meters, multiplex communication sys- tem, electronic moon roof 16. EFI NO.1 20 A: Multiport fuel injection injec- system/sequential multiport tion system, fuel pump fuel Engine compartment (with daytime running light system) 6. RR HTR 15 A: Rear air conditioning system 7. HEAD LP RH LWR 15 A: Right−hand headlight (low beam) 8. HEAD LP LH LWR 15 A: Left−hand headlight (low beam) 9. ALT−S 7.5 A: Charging system 10. POWER OUTLET2 20 A: Power outlets 11. TOWING 20 A: Trailer lights 12. HORN 10 A: Horns 13. SECURITY 15 A: Theft deterrent sys- tem 17. DOOR LOCK 25 A: Power door lock system, theft deterrent system 18. H−LP LH UPR 10 A: Left−hand head- light (high beam) 19. RAD NO.1 25 A: Car audio system 20. DOME 10 A: Personal lights, interior lights, vanity lights, ignition switch light, wireless remote control system, gauges and meters, navigation system 21. HAZARD 15 A: Emergency flashers, instrument panel light, trailer lights 22. SPARE 7.5 A: Spare fuse 23. SPARE 15 A: Spare fuse 24. SPARE 25 A: Spare fuse 25. IGN 10 A: Gauges and meters, SRS airbag system, multiport fuel injection system/sequential multiport injec- tion system fuel 403 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) Instrument panel Fuses (type A) 1. A/F 25 A: Air fuel ratio sensor 2. CRT 7.5 A: Rear seat entertainment system, navigation system 3. STARTER 7.5 A: Multiport fuel injection injec- system/sequential multiport tion system fuel 4. EFI NO.2 10 A: Multiport fuel injection injec- system/sequential multiport tion system fuel 5. ETCS 10 A: Multiport fuel system/sequential multiport tion system injection injec- fuel ’04 HIGHLANDER_U (L/O 0308) 26. RAD NO.2 7.5 A: Car audio system, shift lock system, navigation system, rear seat entertainment system, air conditioning system, multiplex commu- nication system 27. CIG 15 A: Cigarette lighter 28. P RR DOOR 20 A: Power windows 29. PWR OUTLET1 15 A: Power outlets 30. FR FOG 20 A: Front fog lights 31. ECU−IG 10 A: Electric moon roof, anti−lock brake system, vehicle stability control lock system, charging system, starting system system, shift 32. WIPER 25 A: Windshield wipers and washer 33. D RR DOOR 20 A: Power windows 34. D FR DOOR 25 A: Power windows, door courtesy lights, power door lock system 35. S/ROOF 20 A: Electric moon roof 36. HEATER 10 A: Air conditioning system, electric cooling fan, rear window defog- ger, outside rear view mirror defogger, gauges and meters 404 37. IG1 7.5 A: Back−up lights, vehicle sta- bility control system, multiport fuel in- jection system/sequential multiport fuel injection system, outside rear view mir- ror heaters, power door lock system, wireless remote control system, naviga- tion system, multiplex communication system 38. RR WIP 15 A: Rear window wiper 39. STOP 20 A: Stop lights, high mounted stoplight, anti−lock brake system, ve- hicle stability control system, shift lock system, trailer lights, multiplex commu- nication system, multiport fuel injection system/sequential multiport injec- tion system fuel 45. P FR DOOR 20 A: Power windows, door courtesy lights, multiplex commu- nication system 46. TAIL 10 A: Tail lights, license plate lights, instrument panel lights, front fog lights, lights, rear side marker lights, parking lights front side marker 47. PANEL 7.5 A: Instrument panel lights, trailer lights 48. DRL 7.5 A: Daytime running light sys- tem Fuses (type B) 49. AM2 30 A: Multiport fuel injection sys- injection tem/sequential multiport system, starting system fuel 40. OBD 7.5 A: On−board diagnosis sys- 50. ABS2 50 A: Anti−lock brake system, tem 41. SEAT HTR 15 A: Seat heaters 42. IG2 15 A: Multiport fuel injection sys- tem/sequential multiport injection system, charging system, starter sys- tem fuel 43. WASHER 20 A: Low windshield washer fluid level warning light 44. FR DEF 20 A: Air conditioning system, outside rear view mirror defoggers vehicle stability control system 51. ABS1 30 A: Anti−lock brake system, vehicle stability control system 52. HTR 50 A: Air conditioning system 53. RDI 30 A: Electric cooling fans 54. RR DEF 30 A: Rear window defoggers 55. CDS 30 A: Electric cooling fans 56. MAIN 40 A: “H−LP RH LWR”, “H−LP LH LWR”, “H−LP RH UPR” and “H−LP LH UPR” fuses 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) 57. AM1 40 A: Multiport fuel injection sys- injection tem/sequential multiport system, starting system fuel 58. POWER 30 A: Power seat Fuse (type C) 59. ALT 140 A: “POWER”, “STOP”, “FR DEF”, “TAIL”, “PANEL”, “S/ROOF”, “D FR DOOR”, “P FR DOOR”, “D RR DOOR”, “P RR DOOR” and “PWR OUTLET1” fuses “FR FOG”, “OBD”, 60. RDI 50 A: Electric cooling fans ’04 HIGHLANDER_U (L/O 0308) 405 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) 406 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) SECTION 9 REPORTING SAFETY DEFECTS FOR U.S. OWNERS Reporting safety defects for U.S. owners Reporting safety defects for U.S. owners . . . . . . . . . . . . . . . . . . . . . . 408 407 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) To contact NHTSA, you may ei- ther call the Auto Safety Hotline toll−free at 1−800−424−9393 (or 366−0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hot- line. Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc. campaign. 408 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Foreword Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the following pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality maintenance and any other assistance you may require. If there is not a Toyota dealer near you, or you need emergency assistance for any reason, please call the following number: D U.S. OWNERS: D CANADIAN OWNERS: Toyota Canada Customer Interaction Centre Toyota Customer Assistance Center Toll−free: 1−800−331−4331 Toll−free: 1−888−TOYOTA−8 (1−888−869−6828) Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle. © 2003 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Quick index D If a service reminder indicator or warning buzzer comes on D If your vehicle will not start D If your engine stalls while driving D If your vehicle overheats D If you have a flat tire D If your vehicle needs to be towed D Tips for driving during break−in period D How to start the engine D General maintenance Gas station information Fuel type: . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 129 324 327 328 329 341 283 310 359 2AZ−FE engine: UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher 3MZ−FE engine: UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher For improved vehicle performance, the use of premium unleaded gasoline with an Octane Rating of 91 (Research Octane Number 96) or higher is recommended. See page 283 for detailed information. Fuel tank capacity: 72.5 L (19.1 gal., 16.0 lmp.gal.) Engine oil: API grade SL “Energy−Conserving” or ILSAC multigrade engine oil is recommended. See page 373 for detailed information. Tire information: See pages 377 through 385. Tire inflation pressure: See page 402. U −5 Publication No. OM48478U Part No. 01999-48478 Printed in Japan 01−0308−00 ( U) 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Important information about this manual Safety and vehicle damage warnings Safety symbol Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows: CAUTION This is a warning against anything which may cause is ignored. You are injury to people if the warning informed about what you must or must not do in order to reduce the risk of injury to yourself and others. NOTICE This is a warning against anything which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment. the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”. ii 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Important information about your Toyota Occupant restraint systems Toyota encourages you and your family to take the time to read Section 1−3 of this Owner’s Manual carefully. In terms of helping you understand how you can receive the maximum benefit of the occupant restraint systems this vehicle provides, Section 1−3 of this Owner’s Manual is the most important Section for you and your family to read. Section 1−3 describes the function and operation concern- ing seats, seat belts, SRS airbags and child restraint sys- tems of this vehicle and some potential hazards you should be aware of. These systems work together along with the overall structure of this vehicle in order to provide occupant restraint in the event of a crash. The effect of each system can be enhanced when it is used properly and together with other systems. No single occupant re- straint system can, by itself, provide you or your family with the equal level of restraint which these systems can provide when used together. That is why it is important for you and your family to understand the purpose and proper use of each of these systems and how they relate to each other. iii The purpose of all occupant restraint systems is to help reduce the possibility of death or serious injury in the event of a collision. None of these systems, either individ- ually or together, can ensure that there is no injury in the event of collision. However, the more you know about these systems and how to use them properly, the greater your chances become of surviving an accident without death or serious injury. Seat belts provide the primary restraint to all occupants of the vehicle, and every occupant of the vehicle should wear seat belts properly at all times. Children should always be secured in child restraint systems that are appropriate for their age and size. SRS (Supplemental Restraint System) airbags are, as their names imply, designed to work with, and be supplemental to, seat belts and are not substitutes for them. SRS airbags can be very effective in reducing the risk of head and chest injuries by preventing contact of the head and chest with interior portions of the vehicle. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) In order to be effective, the SRS airbags must deploy with tremendous speed. The rapid deployment of the SRS air- bags makes the SRS airbags themselves potential sources of serious injury if an occupant is too close to an airbag, or if an object or some part of his or her body has been placed between the occupant and the airbag at the time of deployment. This is just one example of how the instruc- tions in Section 1−3 of this Owner’s Manual will help en- sure proper use of the occupant restraint systems, and increase the safety they can provide to you and your fami- ly in the event of an accident. Toyota recommends you to read the provisions in Section 1−3 carefully and refer to them as needed during your time of ownership of this vehicle. ’04 HIGHLANDER_U (L/O 0308) New vehicle warranty Your new vehicle is covered by the following Toyota limited warranties: D New vehicle warranty D Emission control systems warranty D Others further information, please refer Information Booklet” or For Warranty Supplement”. to the “Owner’s “Owner’s Manual Your responsibility for maintenance It is the owner’s responsibility to make sure that the specified maintenance is performed. Section 6 gives details of these maintenance requirements. Also included in Section 6 is general maintenance. For scheduled maintenance information, please refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”. iv 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Important health and safety information about your Toyota Accessories, spare parts and modification of your Toyota CAUTION D WARNING: Engine exhaust, some of its constitu- ents, and a wide variety of automobile compo- nents contain or emit chemicals known to the State of California to cause cancer and birth de- fects and other reproductive harm. In addition, oils, fuels and fluids contained in vehicles as well as waste produced by component wear con- tain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. D Battery posts, terminals and related accessories contain lead and lead compounds. Wash your hands after handling. Used engine oil contains chemicals that have caused cancer in laboratory animals. Always protect your skin by washing thoroughly with soap and water. A wide variety of non−genuine spare parts and accessories for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these prod- ucts and is not responsible for their performance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle. This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durability, and may even violate governmental regulations. In addi- tion, damage or performance problems resulting from the modification may not be covered under warranty. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Spark ignition system of your Tires and loading on your Toyota Toyota Underinflated or overinflated tire pressure and the excess load may result in the deterioration of steering ability and braking ability, leading to an accident. Check the tire inflation pressure periodi- cally and be sure to keep the load limits given in this Owner’s Manual. For details about tire inflation pressure and load limits, see pages 377 and 304. The spark ignition system in your Toyota meets all require- ments of the Canadian Interference−Causing Equipment Standard. Installation of a mobile two−way radio system As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as multi- port fuel injection system/sequential multiport fuel injection system, electronic throttle control system, cruise control system, anti−lock brake system, traction control system, vehicle stability control system, SRS airbag system and seat belt pretensioner system, be sure to check with your Toyota dealer for precautionary measures or special in- structions regarding installation. vi 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) Scrapping of your Toyota If The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by the qualified service shop or by your Toyota dealer before you dispose of your vehicle. the vehicle ’04 HIGHLANDER_U (L/O 0308) On−pavement and off−road driving tips This vehicle belongs to the utility vehicle class. Utility ve- hicles have a significantly higher rollover rate than other types of vehicles. This vehicle will handle and maneuver differently from an ordinary passenger car because it is designed for off−road use also. In addition, this vehicle has a higher ground clearance and center of gravity than that of an ordinary passenger car. This vehicle design fea- ture causes this type of vehicle to be more likely to rol- lover. Failure to operate this vehicle correctly may result in loss of control, accidents or vehicle rollover causing death or serious injury. Be sure to read “Off−road vehicle precau- tions” on page 282 in Section 2 and “Off−road driving pre- cautions” on page 312 in Section 3. vii 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Leak detection pump (2AZ−FE engine) This pump performs fuel evaporation leakage check. This check is done approximately five hours after the engine is turned off. So you may hear sound coming from under- neath the luggage compartment for several minutes. It does not indicate a malfunction. viii 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) You should know as much about the quality and importance of proper maintenance of your new vehicle as the people who built it. The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly perform your own maintenance. The best way to keep your new vehicle in top running order is to maintain it properly from the moment you drive it off the showroom floor. The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Maintenance procedures for the engine, chassis, body, electrical system, and more, are clearly explained and illustrated. Periodic maintenance and tune−up Periodic maintenance and tune−up helps to prevent small problems from growing into larger ones later on. The repair manual outlines exactly what maintenance is required and clearly explains how to do the work yourself step−by−step. Areas covered include such things as spark plug re- placement, valve clearance adjustment and engine oil and filter replacement. Where to obtain the Repair Manual The repair manual for HIGHLANDER, written in English, may be purchased as applicable from any Toyota dealer. Pub. Name: 2004 HIGHLANDER Repair Manual Pub. No.: RM1086U1 RM1086U2 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) WE REALLY CARE ABOUT YOU Ċ PLEASE BUCKLE UP Toyota has made a special effort to encourage use of seat belts. Toyota belts are: D Comfortable D Easy to use D Convenient We encourage you to use your belts every time you drive. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) SECTION 1− 1 OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview Instrument cluster overview Indicator symbols on the instrument panel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Instrument panel overview "Vehicles with rear seat entertainment system (view A) 1. Side defroster outlets 2. Instrument cluster 3. Center vents 4. Electric moon roof switch and personal lights 5. Garage door opener 6. Auxiliary boxes 7. Side vents 8. Power door lock switches 9. Power window switches 10. Glove box 11. Automatic transmission selector lever 12. Rear ashtray 13. Input terminal adapter 14. Power outlets 15. Cup holder 16. Container 17. Front ashtray 18. Audio remote control switches 19. Hood lock release lever 20. Parking brake pedal 21. Window lock switch 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) "Vehicles without rear seat entertainment system (view A) 1. Side defroster outlets 2. Instrument cluster 3. Center vents 4. Electric moon roof switch and personal lights 5. Garage door opener 6. Auxiliary boxes 7. Side vents 8. Power door lock switches 9. Power window switches 10. Glove box 11. Automatic transmission selector lever 12. Rear ashtray 13. Cup holder 14. Container 15. Power outlet 16. Front ashtray 17. Audio remote control switches 18. Hood lock release lever 19. Parking brake pedal 20. Window lock switch 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) "Vehicles with manual air conditioning controls (view B) 1. Headlight, turn signal and front fog light switches 2. Wiper and washer switches 3. Emergency flasher switch 4. Clock 5. Front passenger’s seat belt reminder light 6. Rear window and outside rear view mirror defogger and windshield wiper de−icer switch 7. Air conditioning controls 8. Car audio 9. “AIRBAG ON” and “AIRBAG OFF” indicator lights 10. Snow mode button 11. Seat heater switches 12. Cigarette lighter 13. “TRAC OFF” switch (two−wheel drive models) 14. Cruise control switch 15. Ignition switch 16. Tilt steering lock release lever 17. Tire pressure warning system reset switch 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) 18. Power outlet (115 VAC) main switch 19. Rear heater main switch 20. Theft deterrent system/engine immobilizer system indicator light 21. Power rear view mirror control switches 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) "Vehicles with automatic air conditioning controls (view B) 1. Headlight, turn signal and front fog light switches 2. Wiper and washer switches 3. Emergency flasher switch 4. Clock 5. Front passenger’s seat belt reminder light 6. Air conditioning controls and multi−information display 7. Rear window and outside rear view mirror defogger and windshield wiper de−icer switch 8. Car audio 9. “AIRBAG ON” and “AIRBAG OFF” indicator lights 10. Snow mode button 11. Seat heater switches 12. Cigarette lighter 13. “TRAC OFF” switch (two−wheel drive models) 14. Cruise control switch 15. Ignition switch 16. Tilt steering lock release lever 17. Tire pressure warning system reset switch 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) 18. Power outlet (115 VAC) main switch 19. Rear heater main switch 20. Theft deterrent system/engine immobilizer system indicator light 21. Power rear view mirror control switches 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Instrument cluster overview 1. Tachometer 2. Service reminder indicators and indicator lights 3. Speedometer 4. Fuel gauge 5. Low fuel level warning light 6. Engine coolant temperature gauge 7. Trip meter reset knob 8. Odometer and two trip meters 9. Instrument panel light control knob 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Indicator symbols on the instrument panel or Brake system warning light∗1 or Anti−lock brake system warning light∗1 Driver’s seat belt reminder light∗1 Open door warning light∗1 Front passenger’s seat belt reminder light∗1 Automatic transmission fluid temperature warning light∗1 Discharge warning light∗1 SRS warning light∗1 Low engine oil pressure warning light∗1 Vehicle stability control system warning light∗1 or Malfunction indicator lamp∗1 Low tire pressure warning light∗1 Low windshield washer light∗1 fluid level warning 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Engine oil replacement reminder light∗1 (for vehicles sold in U.S.A.) Snow mode indicator light “AIRBAG ON” indicator light Slip indicator light “AIRBAG OFF” indicator light Traction control system off indicator light Headlight high beam indicator light Cruise control indicator light∗2 Turn signal indicator lights or Automatic transmission indicator lights Overdrive−off indicator light 10 ∗1: For details, see “Service reminder indicators and warning ∗2: buzzers” on page 129 in Section 1−6. If this light flashes, see “Cruise control” on page 159 in Section 1−7. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) SECTION 1− 10 OPERATION OF INSTRUMENTS AND CONTROLS Other equipment Multi−information display Clock Compass Cigarette lighter and ashtrays Power outlets Power outlet Glove box Garage door opener Auxiliary boxes Container Cup holders Bottle holders Tie−down hooks Luggage cover Roof luggage carrier Floor mat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 258 259 260 264 265 266 267 267 270 272 273 275 275 276 278 280 information about the clock of a vehicle equipped with the separate “Navigation For Navigation system, please refer System Owner’s Manual”. to 257 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Multi−information display Air conditioning system on— Air conditioning system off— 258 The multi−information display indicates the following information. 1. Outside temperature 2. Average vehicle speed 3. Average fuel consumption 4. Instantaneous fuel consumption 5. Driving time 6. Air conditioning system on—The air conditioned temperature is displayed. Air conditioning system off—The air conditioned is not dis- played. temperature Every time you push the “INFO” button, the display toggles through this informa- tion. The displayed values in the multi−informa- tion display indicate general driving condi- tions. Accuracy varies with driving habits and road conditions. You can adjust the air conditioned temper- ature while the multi−information is operat- ing. 5 seconds has been passed after ad- justing the “INFO” button, the display will be back to the multi−information display. temperature or pushing the 1. Outside temperature (“OUTSIDE TEMP”) from indi- temperature The outside temperature display cates the outside air temperature. The displayed ranges −22_F (−30_C) up to 122_F (50_C). If there is some abnormality in the con- nection of the outside air temperature sen- sor, “−−_F” (“−−_C”) will appear on the display. If “−−_F” (“−−_C”) appears on the display, contact your Toyota dealer. There may be a case that “−−_F” (“−−_C”) appears momentarily when the ignition is quickly turned to “ON”. It is normal if it goes out soon. 2. Average vehicle speed (“AVG MPH” or “AVG km/h”) Average vehicle speed is calculated and displayed based on total driving dis- tance and total driving time with the engine running. The displayed value is updated every 10 seconds. To reset the calculation, push the “INFO” button for more than 1 second. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) 3. Average fuel consumption (“AVG MPG” or “AVG L/100 km”) total Average fuel consumption is calculated and displayed based on total driving distance and fuel consumption with the engine running. The displayed value is updated every 10 seconds. 4. Instantaneous fuel consumption (“MPG” or “L/100 km”) The instantaneous fuel consumption is calculated and displayed based on dis- tance and fuel consumption for 1 sec- onds with the engine running. The displayed value is updated every 2 seconds. Note that an accurate figure may not be shown in the following cases. D When the vehicle is stopped with the engine running, the display will indicate the extremely high fuel consumption. D When the vehicle is driving down a long slope, applying the engine brake, the display will indicate the extremely low fuel consumption. The calculation is reset when the ignition switch is turned off. ’04 HIGHLANDER_U (L/O 0308) Clock 5. Driving time (“E/T”) The elapsed time after the engine starts is displayed. When the engine is started, driving time is counted from 0:00. Up to 11:59 (11 hours, 59 minutes) can be displayed. When the driving time exceeds 11:59, the counter returns to 0:00. The calculation is reset when the ignition switch is turned off. The digital clock indicates the time. The key must be in the “ACC” or “ON” position. To reset the hour: Push the “H” button. To reset the minutes: Push the “M” button. If the electrical power source has been disconnected from the clock, the time dis- play will automatically be set to 1:00 (one o’clock). 259 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) Compass The direction is indicated on the inside rear view mirror. If the ignition switch was turned off with the system on, the system will automati- cally turn back on when the ignition switch is turned on. Push the “COMP” switch to turn the com- pass system on and off. 260 ’04 HIGHLANDER_U (L/O 0308) indicates the vehicle the direction The compass that the above case, it shows that the vehicle is heading north. is heading. In Displays NE SE SW NW Directions North Northeast East Southeast South Southwest West Northwest The compass may not show the correct direction in the following conditions: D The vehicle is stopped immediately af- ter turning. D The compass does not adjust while the vehicle is stopped. D The ignition switch is turned off imme- diately after turning. D The vehicle is on an inclined surface. D The vehicle is in a place where the earth’s magnetic field is subject to in- terference by artificial magnetic fields (underground parking, under a steel tower, between buildings, roof parking, near a crossing, near a large vehicle, etc.). D The vehicle is magnetized. (There is a magnet or a metal object on or near the inside rear view mirror.) D The battery has been disconnected. Your vehicle is out of the set zone. Refer to the “CALIBRATING THE COMPASS” be- low to set the zone number. The compass works to calibrate the direc- tion automatically while the vehicle is in motion, if deviation is small. For additional precision or calibrating, see COMPASS” below. for complete THE “CALIBRATING 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Compass sensor The compass sensor is in the inside rear view mirror. NOTICE Do not put magnets or a metal object on or near the inside rear view mirror of the vehicle. Doing this may cause malfunction of the compass sensor. the from CALIBRATING THE COMPASS (deviation calibration) the compass The direction display on true direction deter- deviates mined by the earth’s magnetic field. The angle of deviation varies according to the geographic position of the vehicle. To adjust this deviation, stop the vehicle, then push and hold the “COMP” switch until the zone number appears on the dis- play. Then push the “COMP” switch, refer- ring to the following map to select the number of the zone where the vehicle is. 261 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Hawaii: Saipan: 7 Samoa: 5 Puerto Rico: Guam: 10 After calibration, leaving the system for several seconds returns it to the compass mode. CAUTION Do not adjust the display while the vehicle is moving. Be sure to adjust the display only when the vehicle is stopped. Zone number 262 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Perform circling calibration just after you have purchased your Toyota. And then always perform circling calibration after the battery has been removed, re- placed or disconnected. D Do not perform circling calibration of the compass the earth’s magnetic field is subject to in- terference by artificial magnetic fields (underground parking, under a steel tower, between buildings, roof parking, near a crossing, near a large vehicle, etc.). in a place where D During calibration, do not operate elec- tric systems (moon roof, power win- dows, etc.) as they may interfere with the calibration. the direction display on CALIBRATING THE COMPASS (circling calibration) Sometimes the compass may not change after a turn. To rectify this, stop the vehicle and push and hold the “COMP” switch until “C” appears on the display. If “C” appears on the display because of a drastic change in the magnetic field, perform circling calibration. in a circle, drive around Drive the vehicle in a circle at 8 km/h (5 mph) or less. If there is not enough space to drive the block. After driving 1 to 3 circles in the above method, calibration is completed when the direction is shown on the display. If calibration cannot be performed because of the magnetized vehicle etc., take your vehicle to Toyota dealer. 263 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Cigarette lighter and ashtrays CAUTION D When doing the circling calibration, be sure to secure a wide space, and watch out for people and ve- hicles in the neighborhood. Do not violate any local traffic rules while performing circling calibration. D Do not adjust the display while the vehicle is moving. Be sure to adjust the display only when the vehicle is stopped. Cigarette lighter Rear ashtray 264 Front ashtray CIGARETTE LIGHTER To use the cigarette lighter, press it in. After it finishes heating up, it automati- cally pops out ready for use. If the engine is not running, the key must be in the “ACC” position. Do not hold the cigarette lighter pressed in. Use a Toyota genuine cigarette lighter or equivalent for replacement. 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Power outlets (12 VDC) ASHTRAYS Front ashtray: To use the ashtray, open the lid. When finished with your cigarette, thor- oughly extinguish it in the ashtray to pre- vent other cigarette butts from catching fire. After using the ashtray, push it back in completely. To remove the ashtray, pull the lid and pull it out. Rear ashtray: To use the ashtray, pull it out. When finished with your cigarette, thor- oughly extinguish it in the ashtray to pre- vent other cigarette butts from catching fire. After using the ashtray, push it back in completely. To remove the ashtray, press down on the lock spring plate and pull out. CAUTION To reduce the chance of in case of an accident or sudden stop while driving, always completely close the ashtray after use. injury Front Rear The power outlets (12 VDC) are de- signed for power supply for car acces- sories. The key must be in the “ACC” or “ON” position for the power outlets to be used. NOTICE the z To prevent fuse from being blown, do not use the electricity over the total vehicle capacity of 12VDC/120W (front and rear outlets together). z To prevent the battery from being discharged, do not use the power outlets longer than necessary when the engine is not running. z Close the power outlet lids when the power outlets are not in use. Inserting a foreign object other than the appropriate plug that fits the outlet, or allowing any liquid into the outlet may cause electrical fail- ure or short circuits. 265 2004 HIGHLANDER from Aug. ’03 Prod. (OM48478U) ’04 HIGHLANDER_U (L/O 0308) Power outlet (115 VAC) NOTICE z To prevent the battery from being discharged, do not use the power outlet longer than necessary when the engine is not running. z Close the power outlet lid when the power outlet is not in use. Inserting a foreign object other than the ap- propriate plug that fits the outlet may cause electrical failure or short circuits.

Boost Classifieds - Car Advice, Reviews, Events & Classifieds

2004 Toyota Highlander Owners Manual