2003 Hyundai Santa FE Owners Manual

should be checked when performing other un- der hood services. The system should be checked for leakage at the same time. Check to make certain that the clutch fluid level is always between the "MAX" and "MIN" level markings on the fluid reservoir. Fill as required. Fluid loss indicates a leak in the clutch system which should be inspected and repaired imme- diately. Consult your Hyundai dealer.

G130B02A-AAT To Replace the Fluid

Recommended brake fluid conforming to DOT 3 or DOT 4 specification should be used. The reservoir cap must be fully tightened to avoid contamination from foreign matter or moisture.

NOTE: Do not allow any other liquids to contami- nate the brake fluid. Seal damage will result.

G140B01A-AAT Checking the Air Conditioning Opera- tion

1. Start the engine and let it run at a fast idle for several minutes with the air conditioning set at the maximum cold setting. If the air coming out of the in-dash vents is not cold, have the air conditioning system inspected by your Hyundai dealer.

2.

DO-IT-YOURSELF MAINTENANCE 6- 17

G140D01A-AAT Checking the Compressor Drive Belt

2.7 V6

2.4 DOHC

Auto tensioner

WARNING:

Use caution when handling brake fluid. It can damage your vision if you get it in your eyes. It will also damage your vehicle's paint if spilled on it and not removed imme- diately.

G140A01A-AAT AIR CONDITIONING CARE Keeping the Condenser Clean

The air conditioning condenser (and engine radiator) should be checked periodically for accumulation of dirt, dead insects, leaves, etc. These can interfere with maximum cooling ef- ficiency. When removing such accumulations, brush or hose them away carefully to avoid bending the cooling fans.

CAUTION:

Running the air conditioning system for extended periods of time with a low refrig- erant level may damage the compressor.

COMP

Eng.pulley

Eng.pulley

0.315 in.

COMP HSM396

G140C01A-AAT Lubrication

To lubricate the compressor and the seals in the system, the air conditioning should be run for at least 10 minutes each week. This is particularly important during cool weather when the air conditioning system is not otherwise in use.

3.5 V6
Power steering pulley

Generator

Crank shaft apulley

A/C pulley

G140D02L

6- 18 DO-IT-YOURSELF MAINTENANCE

When the air conditioning is being used regu- larly, the compressor drive belt tension should be checked at least once a month with the engine turned off. To check the drive belt tension, press down on the belt halfway between the engine crankshaft and compressor pulleys. Pressing with your finger, you should not be able to deflect this belt anymore than 1/3 of an inch. If you have the instruments to check it, with a force of 22 lb. (98N), the deflection should be 0.315 inches (approx 8.0 mm). If the belt is too loose, have it adjusted by your Hyundai dealer.

G150A01A-AAT CHECKING STEERING WHEEL FREE-PLAY

G160A01A-AAT CHECKING CLUTCH PEDAL FREE-PLAY

0.24 ~ 0.51 in. (6 ~ 13 mm)

1.18 in. (30 mm)

G150A01O

To check the steering wheel free-play, stop the car with the wheels pointed straight ahead and gently move the steering wheel back and forth. Use very light finger pressure and be sensitive to changes in resistance that mark the limits of the free-play. If the free-play is greater than specified, have it inspected by your Hyundai dealer and adjusted or repaired if necessary.

G160A01E With the engine off, press lightly on the clutch pedal until you feel a change in resistance. This is the clutch pedal free-play. The free-play should be within the limits specified in the illus- tration. If it is not, have it inspected by your Hyundai dealer and adjusted or repaired if necessary.

G170A01A-AAT CHECKING BRAKE PEDAL FREE-PLAY

G180A01A-AAT CHECKING BRAKE PEDAL CLEARANCE

DO-IT-YOURSELF MAINTENANCE 6- 19

G190A01A-AAT CHECKING DRIVE BELTS

2.7 V6

Power steering

Auto tensioner

2.4 DOHC

Power steering

Eng.coolant

0.30~0.48 in. 0.24~0.35 in.

0.12 ~ 0.31 in. (3 ~ 8 mm)

2.95 in. (75 mm)

Generator

Generator

COMP

Eng.pulley

Eng.pulley

0.315 in.

COMP

HSM396

HXGS508
With the engine off, press down on the brake pedal several times to reduce the vacuum in the brake booster. Then, using your hand, press down slowly on the brake pedal until you feel a change in resistance. This is the brake pedal free-play. The free-play should be within the limits speci- fied in the illustration above. If it is not, have it inspected by your Hyundai dealer and adjusted or repaired if necessary.

G180A01L You need a helper to check the brake pedal clearance. With the engine running, have your helper press down on the brake pedal several times and then hold it down with a force of about 110 lbs (50 kg, 490 N). The brake pedal clear- ance is the distance from the top surface of the brake pedal to the asphalt sheeting under the floor mat. If the brake pedal clearance is not within the limits specified in the illustration, have it in- spected by your Hyundai dealer and adjusted or repaired if necessary.

3.5 V6
Power steering pulley

Generator

Crank shaft apulley

A/C pulley

G140D02L

6- 20 DO-IT-YOURSELF MAINTENANCE

Drive belts should be checked periodically for proper tension and adjusted if necessary. At the same time, belts should be examined for cracks, wear, fraying or other evidence of deterioration and replaced if necessary. Belt routing should also be checked to be sure there is no interference between the belts and other parts of the engine. After a belt is replaced, the new belt should be adjusted again after two or three weeks to eliminate slack resulting from initial stretching after use.

G200A01A-AAT CHECKING AND REPLACING FUSES Replacing a Fusible Link

CAUTION:

When replacing a fusible link, never use anything but a new fusible link with the same or lower amperage rating. Never use a piece of wire or a higher-rated fusible link. This could result in serious damage and create a fire hazard.

Melted Good

HSM390

A fusible link will melt if the electrical circuits from the battery are ever overloaded, thus prevent- ing damage to the entire wiring harness. (This could be caused by a short in the system drawing too much current.) If this ever happens, have a Hyundai dealer determine the cause, repair the system and replace the fusible link. The fusible links are located in a relay box for easy inspection.

G200B01A-AAT Replacing Accessory Fuse

HSM391
The fuse box for the lights and other electrical accessories will be found low on the dashboard on the driver's side. Inside the box you will find a list showing the circuits protected by each fuse.

If any of your car's lights or other electrical accessories stop working, a blown fuse could be the reason. If the fuse has burned out, you will see that the metal strip inside the fuse has burned through. If you suspect a blown fuse, follow this procedure:

1. Turn off the ignition and all other switches. 2. Open the fuse box and examine each fuse. Remove each fuse by pulling it toward you (a small "fuse puller" tool is contained in the fuse box to simplify this operation).

If you do not have a spare fuse, you may be able to borrow a fuse of the same or lower rating from an accessory you can tempo- rarily get along without (the radio or cigarette lighter, for example). Always remember to replace the borrowed fuse.

Good

Burned out

G200B03Y

HXGS416

3. Be sure to check all other fuses even if you find one that appears to have burned out. 4. Replace the blown fuse by pressing a new fuse of the same rating into place. The fuse should be a snug fit. If it is not, have the fuse clip repaired or replaced by a Hyundai dealer.

CAUTION:

A burned-out fuse indicates that there is a problem in the electrical circuit. If you re- place a fuse and it blows as soon as the accessory is turned on, the problem is serious and should be referred to a Hyundai dealer for diagnosis and repair. Never re- place a fuse with anything except a fuse with the same or a lower amperage rating. A higher capacity fuse could cause damage and create a fire hazard.

DO-IT-YOURSELF MAINTENANCE 6- 21

G210A01A-AAT CHECKING THE BATTERY

WARNING:

Batteries can be dangerous! When working with batteries, carefully observe the follow- ing precautions to avoid serious injuries.

The fluid in the battery contains a strong solution of sulfuric acid, which is poisonous and highly corrosive. Be careful not to spill it on yourself or the car. If you do spill battery fluid on yourself, immediately do the following:

o If battery fluid is on your skin, flush the affected areas with water for at least 15
minutes and then seek medical assistance. o If battery fluid is in your eyes, rinse out your eyes with water and get medical assistance as soon as possible. While you are being driven to get medical assistance, continue to rinse your eyes by using a sponge or soft cloth saturated with water.

o If you swallow battery fluid, drink a large quantity of water or milk followed by milk of magnesia, eat a raw egg or drink vegetable oil. Get medical assistance as soon as possible.

While batteries are being charged (either by a battery charger or by the vehicle's generator), they produce explosive gases. Always ob- serve these warnings to prevent injuries from occurring:

6- 22 DO-IT-YOURSELF MAINTENANCE

o Charge batteries only in a well ventilated

o Do not permit flames, sparks or smoking in

area.

the area.

o Keep children away from the area.

G210B02A-AAT Checking the Battery

Keep the battery clean. Any evidence of corro- sion around the battery posts or terminals should be removed using a solution of house- hold baking soda and warm water. After the battery terminals are dry, cover them with a light coating of grease.

PROPOSITION 65 WARNING: Battery posts, terminals, and related acces- sories contain lead and lead compounds, chemicals known to the state of California to cause cancer and reproductive harm. Wash hands after handling.

G220A01A-AAT CHECKING ELECTRIC COOLING FANS

G230A03A-AAT POWER STEERING FLUID LEVEL

WARNING:

The cooling fan is controlled by engine coolant temperature and may sometimes operate even when the engine is not run- ning. Use extreme caution when working near the blades of the coolant fan, so that you are not injured by a rotating fan blade. As the engine coolant temperature de- creases the fan will automatically shut off. This is a normal condition.

G220B01A-AAT Checking Engine Cooling Fan

The engine cooling fan should come on auto- matically if the engine coolant temperature is high.

G220C01A-AAT Checking Condenser Cooling Fan

The condenser coolant fan should come on automatically whenever the air conditioning is in operation.

G230A01O The power steering fluid level should be checked regularly. To check the power steering fluid level, be sure the engine is "OFF", then check to make certain that the power steering fluid level is between the "MAX" and "MIN" level markings on the fluid reservoir.

NOTE: Grinding noise from the power steering pump may be heard immediately after the engine is started in extremely cold condi- tions (below - 4°F). If the noise stops during warm up, there is no abnormal function in the system. It is due to a power steering fluid characteristic in extremely cold condi- tions.

DO-IT-YOURSELF MAINTENANCE 6- 23

6. Draw the vertical line (through the center of each headlight beam pattern) and the hori- zontal line (through the center of each head- light beam pattern) on the aiming screen. And then, draw the parallel line at 0.8 in. (21
mm) under the horizontal line.

7. Adjust each cut-off line of the low beam to the parallel line with a phillips screwdriver - VERTICAL AIMING.

WARNING:

Horizontal aiming should be adjusted by an authorized Hyundai dealer.

Recommended Fluid Use PSF-3 type fluid

G290A02O-AAT HEADLIGHT AIMING ADJUSTMENT

NOTE: Do not start the engine when the power steering oil reservoir is empty.

Vertical aiming

G240A01A-AAT POWER STEERING HOSES

It is suggested that you check the power steer- ing hose connections for fluid leakage at regular intervals. The power steering hoses should be replaced if there is severe surface cracking, scuffing or worn spots. Deterioration of the hose could cause premature failure.

G250A01A-AAT FOR MORE INFORMATION ABOUT YOUR HYUNDAI

If you desire additional information about main- taining and servicing your Hyundai, you may purchase a factory Shop Manual at your Hyundai dealer's parts department. This is the same manual used by dealership technicians and while it is highly technical it can be useful in obtaining a better understanding of your car and how it works.

G290A01O

Before performing aiming adjustment, make sure of the following. 1. Keep all tires inflated to the correct pressure. 2. Place the vehicle on level ground and press the front bumper & rear bumper down sev- eral times. Place vehicle at a distance of 118.1 in. (3m) from the test wall.

3. See that the vehicle is unloaded (except for full levels of coolant, engine oil and fuel, and spare tire, jack, and tools). Have the driver or equivalent weight placed in driver's seat. 4. Clean the head light lenses and turn on the

headlights (Low beam).

5. Open the hood.

6- 24 DO-IT-YOURSELF MAINTENANCE

G290B01Y-AAT Adjustment After Headlight Assembly Replacement

Vertical line

Horizontal line

Cut-off line

"P"

Ground line

G290A03O If the vehicle has had front body repair and the headlight assembly has been replaced, the headlight aiming should be checked using an aiming chart as shown in the illustration. Turn on the headlight switch. (Low Beam Position)

1. Adjust headlights so that main axis of light is parallel to center line of the body and is aligned with point "P" shown in the illustration. 2. Dotted lines in the illustration show the center

of headlights.

SPECIFICATION:

"H"; Horizontal center line of headlights from ground: 2WD : 32.5 in.(822 mm) 4WD : 33.3 in.(843 mm)

"W"; Distance between each headlight center: 46.5 in.(1,178 mm)

"L"; Distance between the headlights and the wall that the lights are tested against: 118 in. (3,000 mm).

G260A01L-AAT REPLACEMENT OF LIGHT BULBS

Before attempting to replace a light bulb, be sure the switch is turned to the "OFF" position. The next paragraph shows how to reach the light bulbs so they may be changed. Be sure to replace the burned-out bulb with one of the same number and wattage rating.

See page 6-30 for the wattage description.

G270A01O-AAT Headlight and Front Turn Signal Light

1. Allow the bulb to cool. Wear eye protection. 2. Open the engine hood. 3. Always grasp the bulb by its plastic base,

avoid touching the glass.

4. Using a socket wrench of the correct size, remove the headlight assembly mounting bolts.

HSM353

CAUTION:

Keep the lamps out of contact with petro- leum products, such as oil, gasoline, etc.

DO-IT-YOURSELF MAINTENANCE 6- 25

HSM331

9. Remove the protective cap from the re- placement bulb and install the new bulb by matching the plastic base with the headlight hole. Reattach the bulb spring and recon- nect the power cord.

10.Use the protective cap and carton to prompt-

ly dispose of the old bulb.

11.Check for proper headlight aim.

HSM328
5. Disconnect the power cord from the bulb

base in the back of the headlight.

HSM329
7. Disconnect the power cord from the bulb

base in the back of the headlight.

G270A01O 6. Turn the plastic cover counterclockwise

and remove it.

HSM330
8. Push the bulb spring to remove the headlight

bulb.

6- 26 DO-IT-YOURSELF MAINTENANCE

HSM332
12.To replace the front turn signal light bulb, take it out from the bulb holder and install the new bulb.

G270B01O-AAT Rear Combination Light

(3)

(2)

(1)

(4)

G270A03O

HSM352

WARNING:

This halogen bulb contains gas under pres- sure and if impacted could shatter, result- ing in flying fragments. Always wear eye protection when servicing the bulb. Protect the bulb against abrasions or scratches and against liquids when lighted. Turn the bulb on only when installing in a headlight. Replace the headlight if damaged or cracked. Keep the bulb out of the reach of children and dispose of the used bulb with care.

1. Open the tail gate. 2. Remove the mounting screws as shown

with a phillips screwdriver.

HSM337

G270C01O-AAT Luggage Compartment Light

DO-IT-YOURSELF MAINTENANCE 6- 27

HSM341

3. Replace with a new bulb.

HSM342

1. Open the tail gate. 2. Remove the cover with a flat-head screw-

driver.

(2)

(1)

(4)

(3)

HSM423
3. To replace the rear combination light (stop/ tail light, turn signal light, back-up light, side mark light), take it out from the bulb holder by turning it counterclockwise.

(1) Stop/Tail light (2) Turn signal light (3) Back-up light (4) Side mark light

4.

Install the new bulb.

6- 28 DO-IT-YOURSELF MAINTENANCE

G270E01O-AAT Front Side Mark Light

G270G01O-AAT Interior Light

HSM334
1. Remove the cover with a phillips screw-

driver.

2. Disconnect the power code.

HSM335

HSM343
1. Remove the cover with a flat-head screw-

driver.

3. Replace with a new bulb.

HSM336

2. Replace with a new bulb.

HSM344

G270H01O-AAT Glove Box Illuminated Light

DO-IT-YOURSELF MAINTENANCE 6- 29

HSM366

3. Disconnect the power cord.

G270E02L

1. Open the glove box. 2. Remove the cover with a flat-head screw-

driver.

4. Replace with a new bulb.

HTB284

6- 30 DO-IT-YOURSELF MAINTENANCE

G280A02O-AAT

10

11

G280A01O

No.

Part Name

Wattage

No.

Part Name

Wattage

Head Light (Low/High)

Front Fog Light (If installed)

Turn Signal Light

Side Mark Light

Glove Box Illuminated Light

Map Light

Interior Light

High Mounted Rear Stop Light

55/60

55

28

10

15

10

17

10

11

Luggage Compartment Light

License Plate Light

Rear Combination Light

Stop/Tail Light

Turn Signal Light

Back-up Light

Rear Side Mark Light

10

27/8

27

27

7. EMISSION CONTROL SYSTEMS

Emission Control System .................................................................7-2
EGR System ....................................................................................7-2
Catalytic Converter ..........................................................................7-3

7- 2 EMISSION CONTROL SYSTEMS

H010A02O-AAT EMISSION CONTROL SYSTEM

H010B01A-AAT 1. Crankcase Emission Control

Your Hyundai is equipped with an emission control system to meet all requirements of the U.S. Environmental Protection Agency or Cali- fornia Air Resources Board. There are three emission control systems which are as follows.

(1) Crankcase emission control system (2) Evaporative emission control system (3) Exhaust emission control system

In order to assure the proper function of the emission control systems, it is recommended that you have your car inspected and main- tained by an authorized Hyundai dealer in ac- cordance with the maintenance schedule in this manual.

Caution for Inspection and Maintenance Test (V6 Vehicle with Traction Control Sys- tem)

o To prevent the vehicle from misfiring during dynamometer testing, discon- nect the ABS connector in the engine compartment. (2.7 V6 only)

o For more information, see shop manual

(Wheel Speed Sensor).

o After the dynamometer testing is com- pleted, erase the ABS/TCS DTC (Diagnotic Trouble Code) with a GST (Generic Scan Tool) or Hi-Scan Pro.

System

The positive crankcase ventilation system is employed to prevent air pollution caused by blow-by gases being emitted from the crank- case. This system supplies filtered air to the crankcase through the air intake hose. Inside the crankcase, the fresh air mixes with blow-by gases, which then pass through the PCV valve and into the induction system.

H010C01S-AAT 2. Evaporative Emission Control (Includ- ing ORVR: Onboard Refueling Vapor Recovery) System

The Evaporative Emission Control System is designed to prevent fuel vapors from escaping into the atmosphere. (The ORVR system is designed to allow the vapors from of the fuel tank to be loaded into a canister while refueling at the gas station, pre- venting the escape of fuel vapors into the atmosphere.)

Canister

Fuel vapors generated inside the fuel tank are absorbed and stored in the canister. When the engine is running, the fuel vapors absorbed in the canister are drawn into the induction system through the purge control solenoid valve.

Purge Control Solenoid Valve (PCSV)

The purge control solenoid valve is controlled by the Engine Control Module (ECM); when the engine coolant temperature is low during idling, the PCSV closes so that evaporated fuel is not taken into the engine. After the engine warms- up during ordinary driving, the PCSV opens to introduce evaporated fuel to the engine.

H010D01A-AAT 3. Exhaust Emission Control System

The Exhaust Emission Control System is a highly effective system which controls exhaust emissions while maintaining good vehicle performace.

H010E01Y-AAT EGR SYSTEM (If installed)

This system helps reduce nitrogen oxides by recirculating a part of the exhaust gas into the engine, thereby reducing cylinder combustion temperature, which results in lower output of oxides of nitrogen.

EMISSION CONTROL SYSTEMS 7- 3

WARNING:

o Do not stop your Hyundai over any com- bustible material such as grass, paper, leaves or rags. These materials might contact the hot catalytic converter and a fire might result.

H020A01A-AAT CATALYTIC CONVERTER

Catalytic Converter

H020A01O All Hyundai vehicles are equipped with a mono- lith type three-way catalytic converter to re- duce the carbon monoxide, hydrocarbons and nitrogen oxides contained in the exhaust gas. Exhaust gases passing through the catalytic converter cause it to operate at a very high temperature. The introduction of large amounts of unburned gasoline into the exhaust may cause the catalytic converter to overheat and create a fire hazard. This risk may be reduced by observing the following:

WARNING:

o Use unleaded fuel only. o Maintain the engine in good operating condition. Extremely high catalytic con- verter temperatures can result from im- proper operation of the electrical, igni- tion or multiport electronic fuel injec- tion.

o If your engine stalls, pings, knocks, or is hard to start, have your Hyundai dealer inspect and repair the problem as soon as possible.

o Avoid driving with a very low fuel level. Running out of gasoline may cause the engine to misfire and result in damage to the catalytic converter.

o Avoid idling the engine for periods

longer than 10 minutes.

o The vehicle should not be pushed or pulled to get started. This may cause the catalytic converter to overheat and cre- ate a fire hazard.

o Do not touch the catalytic converter or any other part of the exhaust system while the catalytic converter is hot. Shut off the engine, wait for at least one hour before touching the catalytic converter or any other part of the exhaust system. o Remember that your Hyundai dealer is

your best source of assistance.

8. CONSUMER INFORMATION & REPORTING SAFETY DEFECTS

Vehicle Identification Number (VIN) .................................................8-2
Engine Number ................................................................................8-2
Recommended Inflation Pressures ..................................................8-2
Snow Tires .......................................................................................8-3
Tire Chains .......................................................................................8-3
Tire Rotation .....................................................................................8-4
Tire Balancing ..................................................................................8-4
Tire Traction .....................................................................................8-4
When to Replace Tires.....................................................................8-4
Spare Tire and Tools ........................................................................8-5
Warranties for Your Hyundai Vehicle ...............................................8-5
Consumer Information ......................................................................8-6
Reporting Safety Defects .................................................................8-7

8- 2 CONSUMER INFORMATION & REPORTING SAFETY DEFECTS

I010A01A-AAT VEHICLE IDENTIFICATION NUMBER (VIN)

I010B01A-AAT Engine Number

I020A01A-AAT TIRE INFORMATION

2.4 DOHC

2.7 V6

The tires supplied on your new Hyundai are chosen to provide the best performance for normal driving.

I010A01O

The vehicle identification number (VIN) is the number used in registering your car and in all legal matters pertaining to its ownership, etc. It can be found in three different places on your car:

3.5 V6

1. On the bulkhead between the engine and

passenger compartments.

2. On the left top side of the instrument panel where it can be seen by looking down through the windshield.

3. On the lower side of the center pillar outer

panel.

I030A02S-AAT RECOMMENDED INFLATION PRES- SURES

I010B01O

I030A01O The tire label located on the driver's side of the center pillar outer panel gives the tire pressures recommended for your vehicle.

I010B01L The engine number is stamped on the engine block as shown in the drawing.

RIM SIZE

TIRE SIZE

6.5Jx16

225/70R16

PRESSURE, kPa (PSI)

UP TO 2 PERSONS UP TO MAX.LOAD REAR FRONT 207(30) 221(32)

FRONT 221(32)

REAR 207(30)

CONSUMER INFORMATION & REPORTING SAFETY DEFECTS 8- 3

I040A01O-AAT SNOW TIRES

I050A03A-AAT TIRE CHAINS

If you equip your car with snow tires, they should be the same size and have the same load capacity as the original tires. Snow tires should be installed on all four wheels; otherwise, poor handling may result. Snow tires should carry 4 psi (28 kPa) more air pressure than the pressure recommended for the standard tires on the tire label on the driver's side of the center pillar , or up to the maximum pressure shown on the tire sidewall whichever is less. Do not drive faster than 75 mph (120 km/h) when your car is equipped with snow tires.

Tire chains, if necessary, should be installed on the front wheels. Be sure that the chains are installed in accordance with the manufacturer's instructions. To minimize tire and chain wear, do not continue to use tire chains when they are no longer needed.

WARNING:

o When driving on roads covered with snow or ice, drive at less than 20 mph (30
km/h).

o Use the SAE "S" class or wire & plastic

chains.

o If you have noise caused by chains con- tacting the body, retighten the chain to avoid contact with the vehicle body.

o To prevent body damage, retighten the

chains after driving 0.3 ~ 0.6 miles.

These pressures were chosen to provide the most satisfactory combination of ride comfort, tire wear and stability under normal conditions. Tire pressures should be checked at least monthly. Proper tire inflation pressures should be maintained for these reasons:

o Lower-than-recommended tire pressures cause uneven tread wear and poor handling. o Higher-than-recommended tire pressures increase the chance of damage from im- pacts and cause uneven tread wear.

CAUTION:

Always observe the following:

o Check pressures when the tires are cold. That is, after the car has been parked for at least three hours and hasn't been driven more than one mile or 1.6 km since starting up.

o Check the pressure of your spare tire each time you check the pressure of other tires.

o Never overload your car. Be especially careful about overloading if you equip your car with a luggage rack or car top carrier.

8- 4 CONSUMER INFORMATION & REPORTING SAFETY DEFECTS

I060A01O-AAT TIRE ROTATION

I070A01A-AAT TIRE BALANCING

A tire that is out of balance may affect handling and tire wear. The tires on your Hyundai were balanced before the car was delivered but may need balancing again during the years you own the car. Whenever a tire is dismounted for repair, it should be rebalanced before being reinstalled on the car.

I080A01A-AAT TIRE TRACTION

Tire traction can be reduced if you drive on worn tires, tires that are improperly inflated or on slippery road surfaces. Tires should be re- placed when tread wear indicators appear. To reduce the possibility of losing control, slow down whenever there is rain, snow or ice on the road.

Spare tire

HA1409

Tires should be rotated every 7,500 miles (12,000 km). If you notice that tires are wearing unevenly between rotations, have the car checked by a Hyundai dealer so the cause may be corrected. After rotating, adjust the tire pressures and be sure to check wheel nut torque.

CAUTION:

Do not mix bias-ply and radial-ply under any circumstances. This may cause dangerous handling char- acteristics.

I090A01A-AAT WHEN TO REPLACE TIRES

0.06 in. (1.6 mm)

Wear indicator

HGK248
The original tires on your car have tread wear indicators. The tread wear indicators appear when the tread depth is 0.06 in. (1.6 mm). The tire should be replaced when these appear as a solid bar across two or more grooves of the tread. Always replace your tires with those of the recommended size. If you change wheels, the new wheel's rim width and offset must meet Hyundai specification.

!

WARNING:

o Driving on worn-out tires is dangerous! Worn-out tires can cause loss of braking effectiveness, steering control and trac- tion. When replacing tires, never mix radial and bias ply tires on the same car. If you replace radial tires with bias-ply tires, they must be installed in sets of four.

o Using tires and wheels of other than the recommended sizes could cause un- usual handling characteristics that could cause death, serious injury, or property damage.

o Wheels that do not meet Hyundai's di- mensional specifications may fit poorly and result in damage to the vehicle, including broken wheel studs.

CONSUMER INFORMATION & REPORTING SAFETY DEFECTS 8- 5

I100A02E-AAT SPARE TIRE AND TOOLS

I110A01A-AAT SHOP MANUAL

A Hyundai Shop Manual is available from your authorized Hyundai dealer. It's written for pro- fessional technicians, but is simple enough for most mechanically-inclined owners to under- stand.

I120A02A-AAT WARRANTIES FOR YOUR HYUNDAI VEHICLE

Your Hyundai is delivered with the following:

D060B01O

Spare tire and wheel Wheel nut wrench, Wrench bar Jack

o New vehicle 60 Months/60,000 Miles Limited

Warranty.

o New vehicle 120 Months/100,000 Miles Lim- ited Powertrain Warranty (first owner only).

o Anti-Perforation Limited Warranty o Emission Defect Warranty - Federal Vehicle o California Emission Control System War-

ranty (if applicable)

o Emission Performance Warranty Federal

o Replacement Parts and Accessories Lim-

vehicle

ited Warranty

NOTE: Detailed warranty information is provided in your Hyundai Owner's Handbook.

8- 6 CONSUMER INFORMATION & REPORTING SAFETY DEFECTS

I130A01A-AAT CONSUMER INFORMATION

This consumer information has been prepared in accordance with regulations issued by the National Highway Traffic Safety Administration of the U.S. Department of Transportation. It provides the purchasers and/or prospective purchasers of Hyundai automobiles with infor- mation on uniform tire quality grading. Your Hyundai dealer will help answer any questions you may have as you read this information.

I130B03A-AAT Tire Quality Grading

Department of Transportation quality grades - All passenger vehicle tires must conform to Federal Safety Standards in addition to these grades. These quality grades are molded on the sidewall.

Treadwear - The treadwear grade is a com- parative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and a half (1
- 1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual conditions of their use, however, and may depart significantly from the norm due to variations in driving habits, service practices and differences in road char- acteristics and climate.

Traction AA, A, B, C - The traction grades, from highest to lowest, are AA, A, B, and C. Those grades represent the tire's ability to stop on wet pavement as measured under controlled conditions on specified government test sur- faces of asphalt and concrete. A tire marked C may have poor traction performance.

WARNING:

The traction grade assigned to this tire is based on straight-ahead braking traction tests, and does not include acceleration, cornering, hydroplaning, or peak traction characteristics.

Temperature A, B, C - The temperature grades are A (the highest), B, and C, representing the tire's resistance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor labo- ratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure. The grade C corresponds to a level of performance which all passenger car tires must meet under the Fed- eral Motor Vehicle Safety Standard No. 109. Grades B and A represent higher levels of performance on the laboratory test wheel than the minimum required by law.

WARNING:

The temperature grade for this tire is estab- lished for a tire that is properly inflated and not overloaded. Excessive speed, underinflation, or excessive loading, either separately or in combination, can cause heat buildup and possible tire failure.

Uniform Tire Quality Grading - Quality grades can be found on the tire sidewall between the tread shoulder and the maximum section width. For example : Treadwear 200 Traction AA Temperature A

I130D02A-AAT Hyundai motor vehicles are designed and manu- factured to meet or exceed all applicable safety standards.

For your safety, however, we strongly urge you to read and follow all directions in this Owner's Manual, particularly the information under the headings "NOTE", "CAUTION" and "WARN- ING".

If, after reading this manual, you have any questions regarding the operation of your ve- hicle, please contact your nearest Hyundai Motor America Regional Office as listed below:

CONSUMER INFORMATION & REPORTING SAFETY DEFECTS 8- 7

Eastern Region : Connecticut, Delaware, Maine, Maryland, Massachusetts, New Hamp- shire, New Jersey, New York, Pennsylvanina, Rhode Island, Vermont, Virginia, West Virginia.

Central Region: Illinois, Indiana, Missouri, lowa, Kansas, Kentucky, Michigan, Minnesota, Ne- braska, North Dakota, South Dakota, Ohio, Wisconsin.

Eastern Region 1100 Cranbury South River Road Jamesburg, NJ 08831
(800) 633-5151

Central Region 700 No. Enterprise Street Aurora, Illinois 60504
(800) 633-5151

Southern Region: Alabama, Arkansas, Florida, Georgia, Louisiana, Mississippi, North Caro- lina, South Carolina, Oklahoma, Tennessee, Texas.

Western Region: Alaska, Hawaii, Arizona, Cali- fornia, Colorado, ldaho, Montana, Nevada, New Mexico, Oregon, Texas, Utah, Washington, Wyoming.

Southern Region 270 Riverside parkway, Suite A Austell, GA 30168
(800) 633-5151

Western Region 10550 Talbert Avenue P.O.Box 20850
Fountain Valley, California 92728-0850
(800) 633-5151

I130C01A-AAT

REPORTING SAFETY DEFECTS If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying HYUNDAI MOTOR AMERICA. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy cam- paign. However, NHTSA cannot become involved in individual problems between you, your dealer, or HYUNDAI MOTOR AMERICA. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-888-327- 4236 or write to: NHTSA, U.S. Department of Transportation, Washington. D.C. 20590. You can also obtain other information about motor vehicle safety from the Hotline.

9. VEHICLE SPECIFICATIONS

Measurement ...................................................................................9-2
Engine ..............................................................................................9-3
Lubrication Chart ..............................................................................9-4

9- 2 VEHICLE SPECIFICATIONS

J010A01O-AAT MEASUREMENT

Overall length

Overall width

Overall height (unladen)

Wheel base

Wheel tread

Front

Rear

J020A01O-AAT POWER STEERING

Type

Wheel free play

Rack stroke

Oil pump type

J030A01O-AAT TIRE

Tire

Standard

177.1 in. (4500 mm)

71.5 in. (1820 mm)

65.9 in. (1675 mm)

103.1in. (2620 mm)

60.6 in. (1540 mm)

60.6 in. (1540 mm)

Rack and pinion

0 ~ 1.18 in. (0 ~ 30 mm)

5.5 in. (142 mm)

Vane type

J040A02O-AAT ELECTRICAL

Item

Battery

Generator

J050A01O-AAT BRAKE

Type

2.4 DOHC

2.7 V6

3.5 V6

MF 68 AH (12 V)

110A (13.5 V)

120A (13.5 V)

Dual hydraulic with brake booster

Front brake type

Ventilated disc

Rear brake type

Disc type

Parking brake

Cable operated on rear wheel

J060A01O-AAT FUEL SYSTEM

Fuel tank capacity

19 us.gal (15.8 imp.gal, 72 liter)

psi (kpa)

Size

225/70 R16

Tire pressure

30 (207)

VEHICLE SPECIFICATIONS 9- 3

J070A02O-AAT ENGINE

ITEMS

Engine Type

Bore x Stroke in. (mm)

Displacement cu.in. (cc)

Firing order

Spark plug

Type

Gap

Idle speed (rpm) - N, D, A/C OFF

Ignition timing (base)

Oil grade (API)

SPECIFICATIONS

2.4 DOHC

2.7 V6

3.5 V6

4-Cyl., In-line DOHC

6-Cyl., V-type DOHC

6-Cyl., V-type DOHC

3.41 x 3.94 (86.5 x 100)

3.41 x 2.95 (86.7 x 75)

3.66 x 3.38 (93 x 85.8)

143.5 (2,351)

1 - 3 - 4 - 2

162.1 (2,656)

1 - 2 - 3 - 4 - 5 - 6

213.4 (3,497)

1 - 2 - 3 - 4 - 5 - 6

CHAMPION : RN10PYP4

NGK : PGR5C-11

CHAMPION : RC10PYPB4

NGK : PFR5N-11

800 ± 100

BTDC 7° ± 5°

0.039 - 0.043 in. (1.0 - 1.1 mm)

700 ± 100

BTDC 12° ± 5°

BTDC 10° ± 5°

SH, SG or SG/CD and ABOVE multigrade and fuel-efficient oil

9- 4 VEHICLE SPECIFICATIONS

J080A04O-AAT LUBRICATION CHART

Item

Oil & Coolant Standard

Engine

API SH,

Hot Climate : SAE 20W-40, 20W-50 (ABOVE 32°F or 0°C)

SG or

Normal Climate : SAE 10W-30 10W-40, 10W-50 (ABOVE -10°F or -23°C)

SG/CD

Cold Climate : SAE 5W-30 5W-40 (BELOW 100°F or 38°C)

Transaxle

Manual

HYUNDAI GENUINE PARTS MTF 75W/90 (API GL-4)

Auto

HYUNDAI GENUINE ATF, DIAMOND ATF SP-III or SK ATF SP-III

Coolant

Transfer case

Rear axle

Power steering

Ethylene glycol base for aluminum radiator

API GL-5, SAE 80W/90 (SHELL SPIRAX AX Equivalent)

API GL-5, SAE 80W/90 (SHELL SPIRAX AX Equivalent)

PSF-3 type fluid

Brakes and clutch fluid

DOT 3, DOT 4 or Equivalent

J080A04O-AAT LUBRICATION CHART

Item

2.4 DOHC

2.7 V6

3.5 V6

Quantity (US. QTS) (lmp.qts, liter)

Engine

Drain & refill;

Drain & refill;

Drain & refill;

Without oil filter : 4.23 (3.52, 4.0)

Without oil filter : 4.44 (3.7, 4.2)

Without oil filter : 4.23 (3.52, 4.0)

With oil filter : 4.54 (3.78, 4.3)

With oil filter : 4.76 (3.96, 4.5)

With oil filter : 4.54 (3.78, 4.3)

VEHICLE SPECIFICATIONS 9- 5

Manual

Auto

Transaxle

Coolant

Transfer case

Rear axle

Power steering

Brakes and clutch fluid

2.43 (2.02, 2.3)

7.4 (6.16, 7.0)

0.95 (0.79, 0.9)

8.98 (7.48, 8.5)

0.85 (0.7, 0.8)

1.16 (0.97,1.1)

As required

8.66 (7.21, 8.2)

1.06 (0.88, 1.0)

10.INDEX

10

10- 2 INDEX

Air bag ............................................................................................... 1-29
Air Cleaner Filter ...............................................................................6-12
Air Conditioning

Care .............................................................................................. 6-17
Operation ............................................................................ 1-76, 6-17
Switch ........................................................................................... 1-75
Antenna .......................................................................................... 1-111
Ashtray .............................................................................................. 1-49
Audio System

Cassete tape player operation (D-285) ...................................... 1-95
Compact disc player operation (H260) ....................................... 1-89
Compact disc player operation (D-285) ...................................... 1-99
Compact disc player operation (D-295) ................................... 1-105
Stereo radio operation (H260) .....................................................1-86
Stereo radio operation (D-285) ...................................................1-92
Stereo radio operation (D-295) ................................................ 1-102

Battery ..................................................................................... 2-18, 6-21
Brake

Anti-lock brake system ................................................................2-10
Brake traction control system (BTCS) ........................................ 2-11
Checking the brakes ....................................................................6-15
Fluid .............................................................................................. 6-15
Pedal clearance ........................................................................... 6-19
Pedal free-play ............................................................................. 6-19
Practices ...................................................................................... 2-15
Breaking-In your New Hyundai .......................................................... 1-3

Calendar ............................................................................................ 1-47
Care of Cassette Tapes ................................................................ 1-109
Care of Disc ................................................................................... 1-109
Cargo Security Screen .....................................................................1-60
Catalytic Converter ............................................................................. 7-3
Child-Protector Rear Door Lock ......................................................... 1-6
Child Restraint System .....................................................................1-23

Installing a Child Restraint Seat with the

"Tether Anchorage" System .....................................................1-25
Securing the Child Restraint Seat with the "ISOFIX" System ....1-25
Cigarette Lighter ................................................................................1-48
Clock ................................................................................................. 1-47
Clutch

Checking fluid ...............................................................................6-16
Pedal free-play ............................................................................. 6-18

Combination Light

Auto light ....................................................................................... 1-44
Headlight flasher ..........................................................................1-44
Headlight switch ...........................................................................1-43
High-beam switch ........................................................................1-44
Lane change signal ......................................................................1-43
Parking light auto cut ....................................................................1-43
Turn signal operation ...................................................................1-43
Consumer Information ........................................................................ 8-6
Cooling Fans ..................................................................................... 6-22
Corrosion protection

Cleaning the interior ....................................................................... 4-4
Protecting your Hyundai from corrosion ....................................... 4-2
Washing and waxing ...................................................................... 4-3
Cruise Control ...................................................................................1-66

D Defrosting / Defogging ......................................................................1-77
Door

Locking, unlocking front door with a key ...................................... 1-4
Drink Holder ...................................................................................... 1-49
Drive Belts ......................................................................................... 6-19
Driving

Driving for economy ..................................................................... 2-16
Smooth cornering ......................................................................... 2-17
Winter driving ............................................................................... 2-17

Emission Control System ................................................................... 7-2
Engine

Before starting the engine .............................................................. 2-3
Compartment (2.4 DOHC) ............................................................ 6-2
Compartment (2.7 V6) ................................................................... 6-3
Compartment (3.5 V6) ................................................................... 6-4
Coolant ........................................................................................... 6-8
Coolant temperature gauge .........................................................1-41
If the engine overheats .................................................................. 3-3
Number ........................................................................................... 8-2
Oil ................................................................................................... 6-6
Starting ........................................................................................... 2-5
Engine Exhaust Can Be Dangerous .................................................. 2-2

Fan Speed Control ............................................................................1-70
Floor Mat Anchor ..............................................................................1-64
Fog Light

Front ............................................................................................. 1-46

INDEX 10- 3

Front Seats

Adjustable front seats .................................................................. 1-10
Adjustable headrests ...................................................................1-12
Adjusting seat forward and rearward .......................................... 1-11
Adjusting seatback angle .............................................................1-11

Fuel

Auto fuel cut switch ...................................................................... 1-62
Capacity ......................................................................................... 9-2
Gauge ........................................................................................... 1-40
Recommendations ......................................................................... 1-2

Fuel Filler Lid

Remote release ............................................................................ 1-62
Full-time 4WD Operation ..................................................................2-13
Fuses ................................................................................................ 6-20

General Checks .................................................................................. 6-5
Glove Box ..........................................................................................1-53

Hazard Warning System ..................................................................1-46
Heating and Cooling Control ............................................................. 1-69
Heating and Ventilation

Air flow control ..............................................................................1-71
Air intake control ..........................................................................1-70
Bi-level heating .............................................................................1-75
Defrosting / Defogging .................................................................1-77
Fan speed control (Blower control) ............................................. 1-70
Temperature control ....................................................................1-74
High-Mounted Rear Stoplight ............................................................1-61
Homelink Mirror ................................................................................. 1-56

10- 4 INDEX

Hood Release .................................................................................... 1-63
Horn ................................................................................................. 1-65

Odometer / Trip Odometer ...............................................................1-42

Ignition Switch ...................................................................................... 2-3
Instrument Cluster and Indicator Lights ........................................... 1-36
Instrument Panel Light Control (Rheostat) ....................................... 1-48

Jump Starting ...................................................................................... 3-2

Key

................................................................................................... 1-3
If you lose your keys ................................................................... 3-11
Positions ......................................................................................... 2-4

Light Bulbs Replacement ..................................................................6-24
Limited-Slip Differential ......................................................................2-15
Luggage Net ...................................................................................... 1-60

Maintenance Intervals

Explanation of scheduled maintenance items ............................... 5-7
Maintenance under severe usage conditions ............................... 5-6
Scheduled maintenance ................................................................ 5-4
Service requirements .................................................................... 5-2

Mirrors

Day-night inside rearview mirror ................................................. 1-55
Outside rear view mirror ..............................................................1-53

Parking Brake .................................................................................... 1-59
Power Driver's Seat ..........................................................................1-13
Power Outlet ...................................................................................... 1-48
Power Steering Fluid Level ...............................................................6-22

Rear Seat

Adjusting seatback angle .............................................................1-15
Folding rear seatback and seat cushion ....................................1-16
Rear Window Defroster Switch ........................................................1-47
Reporting Safety Defects ................................................................... 8-7
Roof Rack .........................................................................................1-61

Seat

Front ............................................................................................. 1-10
Rear .............................................................................................. 1-15
Seat warmer ................................................................................. 1-15

Seat Belts

3-point system ............................................................................. 1-20
2-point static type ......................................................................... 1-22
Pretensioner seat belt .................................................................. 1-28
Adjusting your seat belt ..................................................... 1-21, 1-22
Care of seat belts .........................................................................1-19
Precautions .................................................................................. 1-17

Shop Manual ........................................................................................ 8-5
Sound

Brake pad warning sound ............................................................1-40
Parking start warning sound ........................................................1-40
Spark Plugs ....................................................................................... 6-10
Spectacle Case ................................................................................. 1-52
Speedometer ..................................................................................... 1-41
Starting Procedure .............................................................................. 2-5
Steering Wheel Free play .................................................................6-18
Steering Wheel Tilt Lever ..................................................................1-65
Stereo Sound System ....................................................................... 1-84
Sunroof .............................................................................................. 1-50
Sun visor ........................................................................................... 1-64

Tachometer ....................................................................................... 1-41
Tail Gate ............................................................................................ 1-59
Tail gate window ...........................................................................1-59
Theft-Alarm System ............................................................................ 1-7
Tires

Balancing ........................................................................................ 8-4
Chains ............................................................................................ 8-3
Changing a flat tire ......................................................................... 3-6
If you have a flat tire ....................................................................... 3-5
Information ...................................................................................... 8-2
Pressure ......................................................................................... 8-2
Replacement .................................................................................. 8-4
Rotation .......................................................................................... 8-4
Snow tires ....................................................................................... 8-3
Spare tire ........................................................................................ 3-4
Traction .......................................................................................... 8-4

INDEX 10- 5

Towing

A trailer (or vehicle) ......................................................................2-19
Emergency ................................................................................... 3-11
If your car must be towed .............................................................. 3-9
Traction Control System ....................................................... 2-11 ~ 2-13
Transaxle

Automatic ........................................................................................ 2-7
Automatic transaxle fluid checking .............................................. 6-13
Manual ............................................................................................ 2-5
Manual transaxle oil checking ..................................................... 6-13

Vehicle Identification Number ............................................................. 8-2
Vehicle Specifications

Engine ............................................................................................. 9-3
Lubrication chart .................................................................. 9-4 ~ 9-5
Measurement ................................................................................. 9-2

Warning Lights and Indicator Lights ................................................. 1-37
Windows

Power ........................................................................................... 1-10
Windshield Wiper and Washer ..........................................................1-44
Tail gate wiper and washer switch .............................................. 1-46
Windshield Wiper Blades ..................................................................6-12

SERVICE STATION INFORMATION FUEL: UNLEADED gasoline only Pump Octane Rating of 87 (Research Octane Number 91) or higher.

FUEL TANK CAPACITY US.gal (Imp.gal., liter) 19 (15.8, 72)

TIRE PRESSURE: See the label on the driver's side of the center pillar outer panel.

OTHER TIRE INFORMATION: See pages 8-2 through 8-6.

HOOD RELEASE: Pull handle under left side of dash.

ENGINE OIL: API grade SH, SG or SG/CD multigrade and fuel efficient oil. Use SAE 10W-30, 10W-40 or 10W-50 if normal temperatures are above -10°F (-23°C). For other viscosity recommendations, see page 6-6 or 9-4.

MANUAL TRANSAXLE: HYUNDAI GENUINE PARTS MTF 75W/90 (API GL-4) Oil level should be up to filler-bolt hole in housing beside differential.

AUTOMATIC TRANSAXLE: Apply the parking brake, with the engine running, shift the selector lever through all ranges and return to “N” (Neutral) position. Then check the level of fluid on the dipstick. Use only HYUNDAI GENUINE ATF available at your dealer or DIAMOND ATF SP-III or SK ATF SP-III.

QUICK INDEX o Car will not start ....................................................................... 3-2
o Flat tire ..................................................................................... 3-5
o Warning light/chime comes on ................................... 1-37 ~ 1-40
o Engine overheats ...................................................................... 3-3
o Towing of your vehicle ............................................................. 3-9
o Starting the engine ................................................................... 2-5
o Driving tips for first 1,200 miles (2,000 km) .......................... 1-3
o Scheduled maintenance ............................................................ 5-4
o Reporting safety defects ........................................................... 8-7

Seoul Korea

Printing: FEB. 14, 2003
Publication No.: A26O-EU32P Printed in Korea

2003

A000A01A-AAT This Owner's Manual should be considered a part of the car and remain with it when it is sold for the use of the next owner.

OWNER'S I.D.

ORIGINAL OWNER

ADDRESS

CITY

DELIVERY DATE

STATE

ZIP CODE

(Date Sold to Original Retail purchaser)

DEALER NAME

DEALER NO.

ADDRESS

CITY

STATE

ZIP CODE

OWNER'S MANUAL

A030A02O-AAT

Operation Maintenance Specifications

HSM002

All information in this Owner's Manual is current at the time of publication. However, Hyundai reserves the right to make changes at any time so that our policy of continual product improvement may be carried out.

This manual applies to all Hyundai models and includes descriptions and explanations of optional as well as standard equipment. As a result, you may find material in this manual that does not apply to your specific vehicle.

A010A02A-AAT

WARRANTIES FOR YOUR HYUNDAI VEHICLE

o New Vehicle 60 Months/60,000 Miles Limited Warranty o New Vehicle 120 Months/100,000 Miles Limited Powertrain Warranty (first owner only) o Anti-Perforation Limited Warranty o Emission Defect Warranty - Federal Vehicle o California Emission Control System Warranty (if applicable) o Emission Performance Warranty - Federal Vehicle o Replacement Parts and Accessories Limited Warranty

NOTE: Detailed warranty information is provided in your Hyundai Owner's Handbook.

A020A01A-AAT

RESPONSIBILITY FOR MAINTENANCE

The maintenance requirements for your new Hyundai are found in Section 5. As the owner, it is your responsibility to see that all maintenance operations specified by the manufacturer are carried out at the appropriate intervals. When the vehicle is used in severe driving conditions, more frequent maintenance is required for some operations. Maintenance requirements for severe operating conditions are also included in Section 5.

A040A01A-AAT

FOREWORD

Thank you for choosing Hyundai. We are pleased to welcome you to the growing number of discriminating people who drive Hyundais. The advanced engineering and high-quality construction of each Hyundai we build is something of which we're very proud.

Your Owner's Manual will introduce you to the features and operation of your new Hyundai. It is suggested that you read it carefully because the information it contains can contribute greatly to the satisfaction you receive from your new car.

The manufacturer also recommends that all service and maintenance on your car be performed by an authorized Hyundai dealer. Hyundai dealers are prepared to provide high-quality service, maintenance and any other assistance that may be required.

A050A04A-AAT

HYUNDAI MOTOR COMPANY

Note:Because future owners will also need the information included in this manual, if you sell this Hyundai, please leave the manual in the vehicle for their use. Thank you.

CAUTION:

Severe engine and transaxle damage may result from the use of poor quality fuels and lubricants that do not meet Hyundai specifications. You must always use high quality fuels and lubricants that meet the specifica- tions listed on Page 9-4 in the Vehicle Specifications section of the Owner's Manual and which also appear in the Service Station Information on the back cover of the Owner's Manual.

Copyright 2003 Hyundai Motor Company. All rights reserved. No part of this publication may be reproduced, stored in any retrieval system or transmitted in any form or by any means without the prior written permission of Hyundai Motor Company.

A070A01A-AAT

CAUTION: MODIFICATIONS TO YOUR HYUNDAI

Your Hyundai should not be modified in any way. Such modifications may adversely affect the performance, safety or durability of your Hyundai and may, in addition, violate conditions of the limited warranties covering the vehicle. Certain modifications may also be in violation of regulations established by the U.S. Department of Transportation and other federal or state agencies.

A080A01S-AAT

TWO-WAY RADIO OR CELLULAR TELEPHONE INSTALLATION

Your vehicle is equipped with electronic fuel injection and other electronic components. It is possible for an improperly installed/adjusted two-way radio or cellular telephone to adversely affect electronic systems. For this reason, we recommend that you carefully follow the radio manufacturer's instructions or consult your Hyundai dealer for precautionary measures or special instructions if you choose to install one of these devices.

A090A01A-AAT

SAFETY AND VEHICLE DAMAGE WARNING

This manual includes information titled as WARNING, CAUTION and NOTE. These titles indicate the following:

WARNING:

CAUTION:

This indicates that a condition may result in harm, serious injury or death to you or other persons if the warning is not heeded. Follow the advice provided with the warning.

This indicates that a condition may result in damage to your vehicle or its equipment if the caution is not heeded. Follow the advice provided with the caution.

NOTE: This indicates that interesting or helpful information is being provided.

A100A03A-AAT Guide to Hyundai Genuine Parts 1. What are Hyundai Genuine Parts?

Hyundai Genuine Parts are the same parts used by Hyundai Motor Company to manu- facture vehicles. They are designed and tested for the optimum safety, performance, and reliability to our customers.

2. Why should you use genuine parts?

Hyundai Genuine Parts are engineered and built to meet rigid original manufacturing requirements. Using imitation, counterfeit or used salvage parts is not covered under the Hyundai New Vehicle Limited Warranty or any other Hyundai warranty. In addition, any damage to or failure of Genuine Hyundai Parts caused by the installation or failure of

an imitation, counterfeit or used salvage part is not covered by any Hyundai Warranty.

" To find the closest authorized dealer call 1-800-826-CARS "

3. How can you tell if you are purchasing

Hyundai Genuine Parts?

Look for the Hyundai Genuine Parts Logo on the package (see below).

Hyundai Genuine Parts exported to the United States are packaged with labels written only in English.

Hyundai Genuine Parts are only sold through authorized Hyundai Dealerships.

A100A03L

A100A01L

A100A02L

A100A04L

TABLE OF CONTENTS

SECTION PAGE

1. FEATURES OF YOUR HYUNDAI ...........................................................................1-1

2. DRIVING YOUR HYUNDAI .....................................................................................2-1

3. WHAT TO DO IN AN EMERGENCY .......................................................................3-1

4. CORROSION PREVENTION & APPEARANCE CARE ...........................................4-1

5. VEHICLE MAINTENANCE REQUIREMENTS ........................................................5-1

6. DO-IT-YOURSELF MAINTENANCE .......................................................................6-1

7. EMISSION CONTROL SYSTEMS .........................................................................7-1

8. CONSUMER INFORMATION & REPORTING SAFETY DEFECTS ........................8-1

9. VEHICLE SPECIFICATIONS .................................................................................9-1

10. INDEX .................................................................................................................. 10-1