374
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
•
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
375
Scheduled Maintenance Guide
Every 15,000 miles (24,000 km) Every 30,000 miles (48,000 km)
Every 37,500 miles (60,000 km) Every 60,000 miles (96,000 km)
Every 105,000 miles (168,000 km)
Every 150,000 miles (240,000 km)
Replace cabin air filter (if equipped)
Replace climate-controlled seat filter (if equipped)
Replace engine air filter
Replace fuel filter (Ranger)
Inspect valve clearances; adjust as necessary
(Transit Connect CNG vehicles)
Change automatic transmission fluid and filter on
5–speed TorqShift威 transmission; consult dealer for
requirements.
Replace front wheel bearing grease/grease seal if
non-sealed bearings are used (2WD vehicles)
Change engine coolant1
Change manual transmission fluid (except Escape)
Change rear axle fluid (Dana axles)
Replace spark plugs
Inspect accessory drive belt(s)2
Change automatic transmission fluid and filter
(except 5–speed TorqShift威 transmission) (filter
not required on 6F35, 6F50, DPS6 and AWF-21
transmissions); consult dealer for requirements.
Change front axle fluid (4WD vehicles)
Change manual transmission fluid (Escape)
Change rear axle fluid (RWD vehicles)
Change transfer case fluid (4WD vehicles)
Replace accessory drive belt(s) if not replaced
within the last 100,000 miles (160,000 km)
Replace front wheel bearings and seals if
non-sealed bearings are used (2WD vehicles)
1Initial replacement at 105,000 miles (160,000 km) or 72 months; every 45,000 miles (72,000 km) or 36 months thereafter 2Perform a follow-up inspection at 120,000 miles (192,000 km)
376
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
Maintenance schedule log
DEALER VALIDATION:
DEALER VALIDATION:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
377
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
DEALER VALIDATION:
DEALER VALIDATION:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
378
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
DEALER VALIDATION:
DEALER VALIDATION:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
379
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
SPECIAL OPERATING CONDITIONS If you operate your Ford/Lincoln/Mercury vehicle primarily in one of the more demanding Special Operating Conditions listed below, you will need to have some items maintained more frequently. If you only occasionally operate your vehicle under these conditions, it is not necessary to perform the additional maintenance. For specific recommendations, see your Ford or Lincoln Mercury dealership service advisor or technician.
Towing a trailer or using a camper or car-top carrier
Inspect frequently, service as required
– Inspect and lubricate U-joints
– See axle maintenance items under Exceptions
Every 5,000 miles (8,000 km) – Inspect wheels and related components for abnormal
Every 5,000 miles (8,000 km) or 6 months
noise, wear, looseness or drag – Rotate tires, inspect tires for wear and measure tread depth – Change engine oil and filter
– Inspect and lubricate U-joints
Every 30,000 miles (48,000 km) – Change automatic transmission fluid (except 6R80 and
TorqShift姞 transmissions) – Replace front wheel bearing grease/grease seals if non-sealed bearings are used (2WD vehicles)
Every 60,000 miles (96,000 km) – Change manual transmission fluid
– Change transfer case fluid (4WD vehicles)
380
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
Extensive idling and/or low-speed driving for long distances as in heavy
commercial use such as delivery, taxi, patrol car or livery
Inspect frequently, service as required
– Replace cabin air filter (if equipped)
– Replace engine air filter
Every 5,000 miles (8,000 km) – Inspect brake system
– Inspect wheels and related components for abnormal noise, wear, looseness or drag – Lubricate control arm and steering ball joints if equipped with grease fittings – Rotate tires, inspect tires for wear and measure tread depth – Inspect and lubricate U-joints
– Change engine oil and filter
Every 5,000 miles (8,000 km) or 6 months Every 5,000 miles (8,000 km), 6 months or 200 hours of engine operation
Every 15,000 miles (24,000 km) – Replace fuel filter (Ranger) Every 30,000 miles (48,000 km) – Change automatic transmission fluid (except 6R80 and
TorqShift姞 transmissions) – Replace front wheel bearing grease/grease seals if non-sealed bearings are used (2WD vehicles) Every 60,000 miles (96,000 km) – Change transfer case fluid (4WD vehicles)
– Replace spark plugs
381
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
Operating in dusty conditions such as unpaved or dusty roads
Inspect frequently, service as required
– Replace cabin air filter (if equipped)
– Replace engine air filter
Every 5,000 miles (8,000 km) – Inspect wheels and related components for abnormal
noise, wear, looseness or drag – Rotate tires, inspect tires for wear and measure tread depth – Change engine oil and filter
Every 5,000 miles (8,000 km) or 6 months
– Inspect and lubricate U-joints Every 15,000 miles (24,000 km) – Replace fuel filter (Ranger) Every 30,000 miles (48,000 km) – Change automatic transmission fluid (except 6R80 and
TorqShift姞 transmissions) – Replace front wheel bearing grease/grease seals if non-sealed bearings are used (2WD vehicles)
Every 50,000 miles (80,000 km) – Change manual transmission fluid
– Change rear axle lubricant (E-450 and F-450/550
only)
Every 60,000 miles (96,000 km) – Change transfer case fluid (4WD vehicles)
382
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
Off-road operation
Inspect frequently, service as required
Every 5,000 miles (8,000 km) or 6 months
joints and U-joints;
steering linkage, ball
– Inspect lubricate if equipped with grease fittings – Replace cabin air filter (if equipped) – Replace engine air filter – Change engine oil and filter
– Inspect wheels and related components for abnormal noise, wear, looseness or drag – Rotate tires, inspect tires for wear and measure tread depth
Every 30,000 miles (48,000 km) – Change automatic transmission fluid (except 6R80 and
TorqShift姞 transmissions) – Replace front wheel bearing grease/grease seals if non-sealed bearings are used (2WD vehicles)
Every 50,000 miles (80,000 km) – Change manual transmission fluid
– Change rear axle lubricant (E-450 and F-450/550
only)
Every 60,000 miles (96,000 km) – Change transfer case fluid (4WD vehicles)
Exclusive use of E85 (Flex Fuel Vehicles only)
Every oil change – If ran exclusively on E85, fill the fuel tank full with
regular unleaded fuel.
383
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
Special operating condition log
DEALER VALIDATION:
DEALER VALIDATION:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
384
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
DEALER VALIDATION:
DEALER VALIDATION:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
385
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
EXCEPTIONS In addition, there are several exceptions to the Normal Schedule. They are listed below:
Normal vehicle axle maintenance
❑ Rear axles and power take-off (PTO) units containing synthetic lubricant and light duty trucks equipped with Ford-design axles are lubricated for life. These lubricants are not to be checked or changed unless a leak is suspected, service is re- quired or the axle assembly has been submerged in water. The axle and PTO lubricant should be changed anytime the axle and PTO have been submerged in water. During extended trailer tow operation above 70°F (21°C) ambient and wide open throttle for extended periods above 45 mph (72 km/h), non-synthetic rear axle lubricants should be replaced every 3,000 miles (4,800 km) or 3 months, whichever occurs first. The 3,000 mile (4,800 km) lubricant change interval may be waived if the axle was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number F1TZ-19580-B or equivalent. Add friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction- Lok rear axles (refer to Maintenance product and specifications in the Maintenance and Specifications chapter for details). The axle lubricant should be changed anytime an axle has been submerged in water.
Police/Taxi/Livery vehicle axle maintenance
❑ Replace rear axle lubricant every 100,000 miles (160,000 km). Rear axle lubricant change may be waived if the axle was filled with 75W140 synthetic gear lubricant meeting Ford specification WSL-M2C192-A, part number FITZ-19580-B or equivalent. Add four ounces (118 mL) of additive friction modifier XL-3 (EST-M2C118-A) or equivalent for complete refill of Traction-Lok rear axles. The axle lubricant should be changed anytime the axle has been submerged in water.
E–450 and F–450/550 axle maintenance
❑ Replace rear axle lubricant every 100,000 miles (160,000 km) under normal driving conditions on all E–450 and
F–450/550 applications. For E–450 and F–450/550 vehicles operated at or near maximum Gross Vehicle Weights, the rear axle lubricant should be replaced every 50,000 miles (80,000 km). In addition, this 50,000 mile (80,000 km) schedule should be observed when the vehicles are operated under the Special Operating Conditions.
California fuel filter replacement
❑ If vehicle is registered in California, the California Air Resources Board has determined that the failure to perform this main- tenance item will not nullify the emission warranty or limit recall life. Ford Motor Company, however, urges you to have all recommended maintenance services performed at the specified inter- vals and to record all vehicle service.
liability prior to the completion of the vehicle’s useful
❑ Every two years - Change brake fluid
Class A Motorhome
386
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
Hot climate oil change intervals
❑ If operating conditions are normal and you drive your Ford, Lincoln or Mercury vehicle under typical, everyday conditions
and you are using an API performance category oil of SL or later (for example SM, etc.) then you can follow the 7,500 mile (12,000 km) normal service oil change intervals schedule. Vehicles operating in the Middle East, North Africa, Sub-Saharan Africa or locations with similar climates must follow the oil change interval of 3,000 mile (5,000 km) if the owner is using oils defined by the American Petroleum Institute (API) performance category of API SK or earlier (for ex- ample SJ, etc.).
Engine air filter & cabin air filter replacement
❑ Engine air filter and cabin air filter life is dependent on exposure to dusty and dirty conditions. Vehicles operated in these
conditions will require frequent inspection and replacement of the engine air filter and cabin air filter.
COOLANT CHANGE RECORD
❑ Initial change – 6 years or 105,000 miles (168,000 km) (whichever comes first). ❑ After initial change - every 3 years or 45,000 miles (72,000 km).
Engine coolant
387
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Scheduled Maintenance Guide
Engine coolant change log
DEALER VALIDATION:
DEALER VALIDATION:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
DEALER VALIDATION:
P&A CODE: HOURS: MILEAGE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
RO#: DATE:
388
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
A
ABS (see Brakes) .....................244
Accessory delay ..........................91
AdvanceTrac ..............................246
Air cleaner filter ...............348, 353
Air suspension ...........................252
description ..............................252
Airbag supplemental
restraint system ........173, 177, 179
and child safety seats ............175
description ..............173, 177, 179
disposal ....................................182
driver airbag ............175, 178, 180
indicator light .................177, 182
operation .................175, 178, 180
passenger airbag .....175, 178, 180
side airbag ...............................177
Antifreeze
(see Engine coolant) ................328
Anti-lock brake system
(see Brakes) ..............................244
Anti-theft system ..............132, 136
arming the system ..................136
disarming a triggered
system .....................................137
Armrests ....................................142
Audio system (see Radio) .........39
Automatic transmission
driving an automatic
overdrive .................................256
fluid, adding ............................348
fluid, checking ........................348
fluid, refill capacities ..............354
fluid, specification ..................354
Auxiliary input jack (Line in) ....46
Auxiliary power point .................87
Index
Axle
lubricant specifications ..........354
refill capacities ........................354
Battery .......................................326
acid, treating emergencies .....326
jumping a disabled battery ....296
maintenance-free ....................326
replacement, specifications ...353
servicing ..................................326
Belt-Minder威 .............................169
Booster seats .............................198
Brakes ........................................243
anti-lock ...................................244
anti-lock brake system (ABS)
warning light ...........................244
fluid, checking and adding ....347
fluid, refill capacities ..............354
fluid, specifications .................354
lubricant specifications ..........354
parking ....................................245
shift interlock ..................254–255
Bulbs ............................................76
Capacities for refilling fluids ....354
Car2U威 Home Automation
System .......................................101
Cargo cover ...............................112
Cargo management system ......111
Cassette tape player ...................39
Cell phone use ..............................9
Changing a tire .........................286
Child safety seats ......................187
in front seat ............................188
389
2011 Expedition (exd) Owners Guide, 1st Printing USA (fus)
Index
in rear seat ..............................188
LATCH .....................................191
recommendations ...................185
Child safety seats - booster