2003 Toyota Tacoma Owners Manual

27/8

1156

27

1157

921

194

168

— —

—

—

—

27/8

18

3.8

10

1.4

282

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

—Headlights

1. Open the hood. Unplug the connec-

tor. Remove the rubber cover. If the connector is tight, wiggle it.

2. Release

the bulb retaining spring and remove the bulb. Install a new bulb and the bulb retaining spring.

To install a bulb, align the tabs of the bulb with the mounting hole.

the cutouts of

3. Install

the rubber cover with

the “TOP PULL” mark upward and fit it securely on the boss. Then plug in the connector.

Make sure the rubber cover fits securely on the bulb base and the mounting body. Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer.

2003 MY TACOMA (OM35800U)

283

’03 Tacoma U (L/O 0209)

—Parking lights

—Front turn signal lights

Use a Phillips–head screwdriver.

284

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

—Rear turn signal, stop/tail, and back–up lights

—License plate lights (type A)

Outer side screws 45 mm (1.8 in.)

Use a Phillips–head screwdriver.

Inner side screws 30 mm (1.2 in.)

a: Rear turn signal light b: Stop/tail light c: Back–up light

2003 MY TACOMA (OM35800U)

285

’03 Tacoma U (L/O 0209)

—License plate lights (type B)

—High mounted stoplight

Use a Phillips–head screwdriver.

Use a Phillips–head screwdriver.

286

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

SECTION 8

SPECIFICATIONS Dimensions Payload Engine Fuel Service specifications Tires Fuses

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

288
290
292
292
292
296
297

2003 MY TACOMA (OM35800U)

287

’03 Tacoma U (L/O 0209)

Dimensions TWO–WHEEL DRIVE MODELS EXCEPT PRE RUNNER

mm (in.)

Xtra–cab models 5010 (197.2)* 1
5155 (203.0)* 2

1690 (66.5) 1765 (69.5)* 3, 4

1590 (62.5)* 3, 4
1605 (63.2)* 4
1615 (63.6)* 5

3095 (121.9)

1450 (57.1)

1455 (57.3)

Overall length

Regular cab models 4540 (178.7)* 1
4685 (184.4)* 2

Overall width

1690

(66.5)

1625
1615
1620
1630

(64.0)* 4, 6
(63.6)* 5, 6
(63.8)* 4, 7
(64.2)* 5, 7

2625 (103.3)

1450

(57.1)

1455

(57.3)

Overall height* 8

Wheelbase

Front tread

Rear tread * 1: Without rear step bumper * 2: With rear step bumper * 3: With 5VZ–FE engine * 4: With P235/55R16 tires * 5: With P205/75R15 tires * 6: With automatic transmission * 7: With manual transmission * 8: Unladen vehicle

288

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

FOUR–WHEEL DRIVE MODELS AND PRE RUNNER

Regular cab models

4685 (184.4)

1690
1785

1720
1750

(66.5)* 1
(70.3)* 2

(67.7)* 1
(68.9)* 2

2625 (103.3)

1460
1500
1455
1495

(57.5)* 1
(59.1)* 2
(57.3)* 1
(58.9)* 2

Xtra–cab models

5155 (203.0)

1690
1785

1715
1745

(66.5)* 1
(70.3)* 2

(67.5)* 1
(68.7)* 2

3095 (121.9)

1460
1500
1455
1495

(57.5)* 1
(59.1)* 2
(57.3)* 1
(58.9)* 2

Overall length

Overall width

Overall height* 4

Wheelbase

Front tread

Rear tread

* 1: With P225/75R15 tires * 2: With P265/70R16 tires * 3: With roof rails * 4: Unladen vehicle

mm (in.)

Double cab models

5155 (203.0)

1785

(70.3) (67.5)* 1
(68.7)* 2
(70.1)* 1, 3
(71.3)* 2, 3

1715
1745
1780
1810
3095 (121.9)

1460
1500
1455
1495

(57.5)* 1
(59.1)* 2
(57.3)* 1
(58.9)* 2

2003 MY TACOMA (OM35800U)

289

’03 Tacoma U (L/O 0209)

Payload* Without off–road package

Two–wheel drive models

Four–wheel drive models

Pre Runner

2RZ–FE engine 2RZ–FE engine

5VZ–FE engine

3RZ–FE engine 3RZ–FE engine

5VZ–FE engine

3RZ–FE engine

5VZ–FE engine 5VZ–FE engine

Regular cab Regular cab

Xtra–cab Xtra–cab

Xtra–cab

Regular cab Regular cab

Xtra–cab Xtra–cab

Xtra–cab Xtra–cab

Double cab

Regular cab

Xtra–cab

Double cab

Xtra–cab

Double cab

Manual transmission

Automatic transmission

Manual transmission

Automatic transmission

Manual transmission

Manual transmission

Automatic transmission

Manual transmission

Automatic transmission

Manual transmission

Automatic transmission

Automatic transmission

Automatic transmission

Automatic transmission

Automatic transmission

Automatic transmission

Automatic transmission

kg (lb.)

669 (1475)

659 (1455)

691 (1525)

682 (1505)

612 (1350)

805 (1775)

791 (1745)

723 (1595)

709 (1565)

703 (1550)

691 (1525)

616 (1360)

893 (1970)

814 (1795)

741 (1635)

793 (1750)

721 (1590)

290

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

With off–road package

Four–wheel drive models Four–wheel drive models

Pre Runner Pre Runner

* : Occupants + luggage

3RZ–FE engine

5VZ–FE engine

3RZ–FE engine 3RZ–FE engine

5VZ–FE engine 5VZ–FE engine

Xtra–cab

Xtra–cab Xtra–cab

Double cab

Xtra–cab

Double cab

Xtra–cab

Double cab

Manual transmission

Manual transmission

Automatic transmission

Automatic transmission

Automatic transmission

Automatic transmission

Automatic transmission

Automatic transmission

kg (lb.)

703 (1550)

682 (1505)

671 (1480)

596 (1315)

793 (1750)

721 (1590)

773 (1705)

700 (1545)

2003 MY TACOMA (OM35800U)

291

’03 Tacoma U (L/O 0209)

Engine Model:

2RZ–FE, 3RZ–FE and 5VZ–FE

Type:

2RZ–FE and 3RZ–FE engines

4 cylinder in line, 4 cycle, gasoline

5VZ–FE engine

6 cylinder V type, 4 cycle, gasoline

Bore and stroke, mm (in.):

2RZ–FE engine

95.0 (cid:1) 86.0 (3.74 (cid:1) 3.39)

3RZ–FE engine

95.0 (cid:1) 95.0 (3.74 (cid:1) 3.74)

5VZ–FE engine

93.5 (cid:1) 82.0 (3.68 (cid:1) 3.23)

Displacement, cm3 (cu. in.):

2RZ–FE engine 3RZ–FE engine 5VZ–FE engine

2438 (148.8) 2694 (164.3) 3378 (206.1)

Fuel Fuel type:

Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher

Fuel tank capacity, L (gal., Imp. gal.):

Two–wheel drive models except Pre Runner

60 (16.0, 13.3)

Four–wheel drive models and Pre Runner

70 (18.5, 15.4)

Service specifications ENGINE Valve clearance (engine cold), mm (in.):

2RZ–FE and 3RZ–FE engines

Intake Exhaust

0.15—0.25 (0.006—0.010) 0.25—0.35 (0.010—0.014)

5VZ–FE engine

Intake Exhaust

0.13—0.23 (0.006—0.009) 0.27—0.37 (0.011—0.014)

Spark plug type:

2RZ–FE and 3RZ–FE engines K16R–U11
BKR5EYA–11

DENSO NGK

5VZ–FE engine

DENSO NGK

K16TR11
BKR5EKB–11

Spark plug gap, mm (in.):

1.1 (0.043)

292

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Drive belt roughs drive belt BT–33–73F (used belt), lbf:

tension measured with Bor- tension gauge No.

2RZ–FE and 3RZ–FE engines

Generator belt Air conditioning compressor belt

115(cid:2) 20

Power steering pump belt

100(cid:2) 20

100 +20
–15

5VZ–FE engine Generator belt Air conditioning compressor belt

100(cid:2) 20

Power steering pump belt

100(cid:2) 20

100 +20
–15

ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.):

Two–wheel drive models except Pre Runner

2RZ–FE engine

With filter Without filter 5VZ–FE engine

5.5 (5.8, 4.8) 4.8 (5.0, 4.2)

With filter Without filter

5.4 (5.7, 4.8) 5.1 (5.4, 4.5) Four–wheel drive models and Pre Runner

3RZ–FE engine

With filter Without filter 5VZ–FE engine

5.4 (5.7, 4.8) 4.7 (5.0, 4.1)

With filter Without filter

5.2 (5.5, 4.6) 4.9 (5.2, 4.3) “Toyota Genuine Motor Oil” in your Toyota vehicle. Use Toyota approved “Toyota Genuine Motor Oil” or equivalent to grade and viscosity. Oil grade:

following

satisfy

filled

the

is

API grade SL “Energy–Conserving” or ILSAC multigrade engine oil

Recommended oil viscosity:

SAE 5W–30

Outside temperature

Please contact your Toyota dealer for fur- ther details. COOLING SYSTEM Total capacity, L (qt., Imp. qt.):

Two–wheel drive models except Pre Runner

With manual transmission

2RZ–FE engine 5VZ–FE engine

8.0
(8.5, 7.0) 9.7 (10.3, 8.5)

With automatic transmission 7.8

2RZ–FE engine

(8.2, 6.9)

2003 MY TACOMA (OM35800U)

293

’03 Tacoma U (L/O 0209)

AUTOMATIC TRANSMISSION Fluid capacity (drain and refill), L (qt., Imp. qt.):

Two–wheel drive models except Pre Runner

Up to 2.4 (2.5, 2.1)

Four–wheel drive models and Pre Run- ner

Up to 2.0 (2.1, 1.8)

Fluid type:

2RZ–FE engine—

Toyota Genuine ATF DEXRON(cid:2)III (DEXRON(cid:2)II)

D–II

or

3RZ–FE and 5VZ–FE engines—

Toyota Genuine ATF Type T–IV Change automatic only as necessary.

transmission

fluid

Four–wheel drive models and Pre Runner

BATTERY Open voltage* at 20°C (68°F):

With manual transmission

3RZ–FE engine 5VZ–FE engine

8.3
(8.8, 7.3) 10.1 (10.7, 8.9)

With automatic transmission 8.2
(8.7, 7.2) 10.0 (10.5, 8.8)

3RZ–FE engine 5VZ–FE engine

Fully charged Half charged Discharged

12.6—12.8 V 12.2—12.4 V 11.8—12.0 V * : Voltage that is checked 20 minutes after the key is removed with all the lights turned off

Coolant type:

“Toyota Genuine Long Life Coolant” is filled in your Toyota vehicle. In order to avoid technical problems, we strongly recommend using “Toyota Genuine Long Life Coolant” or equivalent. With ethylene–glycol type coolant for a proper corrosion protection of aluminum components Do not use alcohol type antifreeze or plain water alone. Please contact your Toyota dealer for further details.

294

Charging rates:

5 A max.

CLUTCH Pedal free play, mm (in.):

5—15 (0.2—0.6)

Fluid type:

SAE J1703 or FMVSS No.116 DOT 3

MANUAL TRANSMISSION Oil capacity, L (qt., Imp. qt.):

2RZ–FE engine 3RZ–FE engine 5VZ–FE engine

Two–wheel drive models

Four–wheel drive models

2.6 (2.7, 2.3) 2.5 (2.6, 2.2)

2.6 (2.7, 2.3)

2.2 (2.3, 1.9)

Oil type:

Gear Oil API GL–4 or GL–5

Recommended oil viscosity:

SAE 75W–90

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

DIFFERENTIAL Oil capacity, L (qt., Imp. qt.):

Two–wheel drive models except Pre Runner

2RZ–FE engine 5VZ–FE engine

1.35 (1.4, 1.2) 2.55 (2.7, 2.2) Four–wheel drive models and Pre Runner

Front (except Pre Runner)

1.15 (1.2, 1.0)

Recommended oil viscosity:

Front

SAE 75W–90

Rear

Above –18(cid:1)C (0(cid:1)F)

SAE 90

Below –18(cid:1)C (0(cid:1)F)

SAE 80W or 80W–90

CHASSIS LUBRICATION Wheel bearings:

Rear

Short wheel base

With rear differential lock system

2.65 (2.8, 2.3) Without rear differential lock sys- tem

2.55 (2.7, 2.2)

Extra long wheel base

With rear differential lock system

2.95 (3.1, 2.6) Without rear differential lock sys- tem

2.45 (2.6, 2.2)

Oil type:

Hypoid Gear Oil API GL–5

Lithium base wheel bearing grease, NLGI No.2

Front drive shaft thrust bushings:

Synthetic oil and chassis grease, NLGI No.1

lithium soap base

Propeller shafts:

Spiders

Lithium base chassis grease, NLGI No.2

Slide yoke and double cardan joint

Molybdenum–disulfide chassis grease, NLGI No.2

lithium

base

2003 MY TACOMA (OM35800U)

295

your

Type

fluid only

transmission

Generally, it is necessary to change automatic if your vehicle is driven under one of the Special Operating Conditions listed in “Scheduled Maintenance Guide” or “Owner’s Manual Supple- ment”. When changing the automatic fluid, use only “Toyota transmission Genuine ATF (ATF JWS3309 or NWS6500) in assuring optimum transaxle perfor- mance. transmis- Notice: Using automatic sion fluid other than “Toyota Genu- ine ATF Type T–IV” may cause dete- rioration in shift quality, locking up of your transmission accompanied by vibration, and ultimately damage the automatic transmission of your vehicle.

to aid

T–IV”

Please contact your Toyota dealer for fur- ther details. TRANSFER Oil capacity, L (qt., Imp. qt.):

1.0 (1.1, 0.9)

Oil type:

Gear Oil API GL–4 or GL–5

Recommended oil viscosity:

SAE 75W–90

’03 Tacoma U (L/O 0209)

BRAKES Minimum pedal clearance when depressed with a pressure of 490 N (50 kgf, 110 lbf) when the engine is stopped and after de- press the brake pedal several times, mm (in.):

105 (4.1)

Pedal free play, mm (in.):

1—6 (0.04—0.24)

Pad wear limit, mm (in.):

1.0 (0.04)

Lining wear limit, mm (in.):

1.0 (0.04)

Parking brake adjustment when pulled with the force of 196 N (20 kgf, 44 lbf):

16—30 clicks

Fluid type:

SAE J1703 or FMVSS No.116 DOT 3

STEERING Wheel free play:

Less than 30 mm (1.2 in.)

Power steering fluid type:

Automatic transmission fluid DEXRON(cid:2)II or III

Tires

Tire size

Tire pressure

kPa (kgf/cm2 or bar, psi) Rear Front

P205/75R15 97S

200 (2.0, 29)

200 (2.0, 29)

P225/75R15 102S

180 (1.8, 26)

200 (2.0, 29)

Wheel size

15 (cid:1) 6J 15 (cid:1) 6JJ

15 (cid:1) 7J 15 (cid:1) 7JJ

P235/55R16 96T

200 (2.0, 29)

220 (2.2, 32)

16 (cid:1) 6 1/2JJ

P265/70R16 111S

180 (1.8, 26)

180 (1.8, 26)

P265/70R16 111T

180 (1.8, 26)

* 1: Double cab models * 2: Regular cab and Xtra–cab models Wheel nut torque, N·m (kgf·m, ft·lbf):

110 (11.5, 83)

180 (1.8, 26)* 1
200 (2.0, 29)* 2

16 (cid:1) 7J 16 (cid:1) 7JJ

16 (cid:1) 7JJ

NOTE: For a complete information on tires (e.g. replacing tires or replacing wheels), see “Checking tire pressure” through “Aluminum wheel precautions” in Sec- tion 7–2.

296

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Fuses

Engine compartment (without daytime run- ning light system)

Engine compartment (with daytime run- ning light system)

Instrument panel

Fuses (type A) 1. HEAD (RH) 10 A: Right–hand headlight 2. HEAD (LH) 10 A: Left–hand headlight 3. DRL 7.5 A: Daytime light

running

system

4. HEAD (HI RH) 10 A: Right–hand head- light (high beam), high beam indicator light

5. HEAD (HI LH) 10 A: Left–hand head-

light (high beam)

6. HEAD

(LO RH) 10 A: Right–hand

headlight (low beam)

7. HEAD (LO LH) 10 A: Left–hand head-

12. OBD 7.5 A: On–board diagnosis sys-

light (low beam)

tem

8. TAIL 10 A: Tail

lights,

licence plate

lights

9. A.C 10 A: Air conditioning system 10. ECTS 15 A: Multiport

fuel

system/sequential multiport tion system

injection injec-

fuel

11. DOME 15 A: Car audio system, interior light, clock, personal lights, door cour- tesy light, day time running light sys- tem, gauges and meters

13. EFI 20 A: Multiport fuel injection sys- injection

tem/sequential multiport system

fuel

14. ALT–S 7.5 A: Charging system 15. PWR OUTLET 15 A: Power outlet 16. ECU–IG 15 A: Cruise control system, system, automatic lock system, SRS

anti–lock transmission shift airbag system

brake

17. TURN 10 A: Turn signal lights, emer-

gency flashers

2003 MY TACOMA (OM35800U)

297

’03 Tacoma U (L/O 0209)

26. STOP 10 A: Stop lights, high mounted stoplight, cruise control system, anti– lock brake system, multiport fuel injec- tion system/sequential multiport fuel in- jection system

Fuses (type B) 27. POWER 30 A: Power windows, power

seat

28. J/B 50 A: All components in “POWER”, “ECU–B”

“STOP” and

“HORN–HAZ”, fuses

29. AM2 30 A: Ignition system, multiport fuel injection system/sequential fuel in- jection system

30. HEATER 50 A: All components in “A.C”

fuse

31. AM1 40 A: Starting system 32. ABS2 30 A: Anti–lock brake system Fuses (type C) 33. ABS 60 A: Anti–lock brake system 34. ALT 120 A: All components in “AM1”, “HEATER”, “A.C”, “TAIL”, “ALT–S” and “PWR OUTLET” fuses

18. WIPER 20 A: Windshield wipers and

washer

19. 4WD 20 A: A.D.D. control system, four–wheel drive control system, rear differential lock system 20. ACC 15 A: Cigarette

lighter, clock, power view mirrors, back–up lights, automatic transmission shift lock system, SRS airbag system, seat belt pretensioners, car audio system

rear

21. GAUGE 10 A: Day time running light system, back–up lights, cruise control system, rear differential lock system, electronically automatic transmission system, starting system, charging system, air conditioning sys- tem

controlled

22. IGN 7.5 A: Gauges and meters, SRS airbag system, seat belt pretensioners, multiport fuel injection system/sequen- tial multiport fuel injection system

23. ECU–B 7.5 A: SRS warning light, air

conditioning system

24. HORN–HAZ 15 A: Emergency flashers,

horns

25. STA 7.5 A: Clutch start cancel system,

starting system

298

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

SECTION 9

REPORTING SAFETY DEFECTS FOR U.S. OWNERS, UNIFORM TIRE QUALITY GRADING AND CAMPER INFORMATION Reporting safety defects for U.S. owners . . . . . . . . . . . . . . . . . . . . . . Uniform tire quality grading . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Camper information

300
300
301

2003 MY TACOMA (OM35800U)

299

’03 Tacoma U (L/O 0209)

To contact NHTSA, you may ei- ther call the Auto Safety Hotline toll–free at 1–800–424–9393 (or 366–0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hot- line.

Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., (Toll–free: 1–800–331–4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.

campaign.

Inc.

300

2003 MY TACOMA (OM35800U)

Uniform tire quality grading This information has been prepared in ac- cordance with regulations issued by the National Highway Traffic Safety Adminis- tration of the U.S. Department of Trans- portation. It provides the purchasers and/ or prospective purchasers of Toyota vehicles with information on uniform tire quality grading. Your Toyota dealer will help answer any questions you may have as you read this information. DOT quality grades—All passenger car tires must conform to Federal Safety Requirements these grades. Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A

in addition

to

from

treadwear grade

Treadwear—The is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150
would wear one and a half (1–1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual condi- tions of their use, however, and may de- part significantly the norm due to variations in driving habits, service prac- tices and differences in road characteris- tics and climate. Traction AA, A, B, C—The traction grades, from highest to lowest, are AA, A, B, and C, and they represent the tire’s ability to stop on wet pavement as mea- sured under controlled conditions on spe- cified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this is based on braking (straight ahead) traction tests and does not include cornering (turning) traction.

tire

’03 Tacoma U (L/O 0209)

of

Camper information— This information has been prepared in ac- cordance with regulation issued by the Na- tional Highway Traffic Safety Administra- tion of Transportation. It provides the purchasers and/or prospective purchasers of Toyota vehicles with information on truck–camper loading. Your Toyota dealer will help an- swer any questions you may have as you read this information.

the U.S. Department

Temperature A, B, C—The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissi- pate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to de- generate and reduce tire life, and exces- sive temperature can lead to sudden tire failure. The grade C corresponds to a lev- el of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No.109. Grades B and A represent higher levels of perfor- mance on the laboratory test wheel than the minimum required by law. Warning: The temperature grades for this tire are established for a tire that is prop- erly inflated and not overloaded. Exces- sive speed, underinflation, or excessive loading, either separately or in combina- tion, can cause heat buildup and possible tire failure.

2003 MY TACOMA (OM35800U)

301

’03 Tacoma U (L/O 0209)

—Center of gravity location

—Cargo weight rating and proper matching

Rear end of truck bed

Four–wheel drive models and Pre Runner

mm (in.)

Camper center of gravity

Recommended location for cargo center of gravity for cargo weight rating

1257
(49.5)

901
(35.5)

The figures given in the illustration indi- cate the recommended center of gravity zone.

Two–wheel drive models except Pre Runner

mm (in.)

Regular cab models Xtra–cab models 2RZ–FE engine

5VZ–FE engine

1397
(55.0)

1372
(54.0) 1397
(55.0)

965
(38.0)

927
(36.5) 927
(36.5)

CAUTION

Recommended center of gravity location zone

If a load is too far back, it can cause dangerous handling. If it is too far forward, the front axle may be over- loaded.

Cargo weight rating Two–wheel drive models except Pre Runner

Regular cab models with full options’ weight of 90 kg (205 lb.)

With 2 occupants

With 3 occupants

430 kg (950 lb.)

375 kg (830 lb.)

302

2003 MY TACOMA (OM35800U)

full options’

Xtra–cab models with weight of 85 kg (195 lb.) With 2 occupants seats and no occupants rear seats

in

the

front in the

With 3 occupants seats and no occupants rear seats

in

365 kg (815 lb.) front in the

the

365 kg (810 lb.) With 3 occupants front seats and 2 occupants in the rear seats

the

in

265 kg (590 lb.)

Four–wheel drive models and Pre Runner

Regular cab models with full options’ weight of 120 kg (265 lb.)

With 2 occupants

With 3 occupants

500 kg (1100 lb.)

465 kg (1025 lb.)

’03 Tacoma U (L/O 0209)

Xtra–cab models with weight of 125 kg (280 lb.)

full options’

Vehicles with off road package the

With 2 occupants seats and no occupants rear seats

in

front in the

340 kg (750 lb.) With 2 occupants front seats and 2 occupants in the rear seats

the

in

135 kg (300 lb.)

Vehicles without off road package

With 2 occupants seats and no occupants rear seats

in

the

front in the

With 3 occupants seats and no occupants rear seats

in

440 kg (975 lb.) front in the

the

370 kg (825 lb.) With 3 occupants front seats and 2 occupants in the rear seats

the

in

When the truck is used to carry a slide–in camper, the total cargo load of the truck consists of the manufacturer’s camper weight figure, the weight of installed addi- tional camper equipment not included in the manufacturer’s camper weight figure, the weight of camper cargo, and the weight of passengers in the camper. The total cargo load should not exceed the truck’s cargo weight rating and the camper’s center of gravity should fall with- in recommended center of gravity zone when installed.

truck’s

the

CAUTION

Be careful—overloading can cause dangerous braking and handling prob- lems, and can damage your vehicle and its tires.

235 kg (525 lb.)

2003 MY TACOMA (OM35800U)

303

’03 Tacoma U (L/O 0209)

—Gross axle and vehicle weight ratings

Gross axle weight rating

Gross vehicle weight rating

Front GAWR

Rear GAWR

Not exceed GVWR

GVWR Two–wheel drive models except Pre Runner

Regular cab models

Xtra–cab models

1920 kg (4250 lb.)

2040 kg (4500 lb.)

Four–wheel drive models and Pre Runner

2315 kg (5100 lb.) If weight ratings are exceeded, move or remove items to bring all weights below the ratings.

loose

items

loads should not exceed

Secure to prevent weight shifts that could affect the balance of your vehicle. When the truck camper is loaded, drive to a scale and weigh on the front and on the rear wheels separately to de- termine axle loads. Individual axle loads should not exceed either of the Gross Axle Weight Ratings (GAWR). The total of the axle the Gross Vehicle Weight Rating (GVWR). These ratings are given on the vehicle certification label which is located on the door latch post on the left side of the vehicle. See “Your Toyota’s identification” in Section 2 the Certification Label location. If weight ratings are exceeded, move or remove items to bring all weights below the ratings. 304

for

GAWR Two–wheel drive models except Pre Runner

Front Rear

1000 kg (2200 lb.) 1135 kg (2500 lb.)

Four–wheel drive models and Pre Runner

Front Rear

1200 kg (2650 lb.) 1270 kg (2800 lb.)

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Important information about this manual

Safety and vehicle damage warnings

Safety symbol

Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows:

CAUTION

This is a warning against anything which may cause injury to people if the warning is ignored. You are informed about what you must or must not do in order to reduce the risk of injury to yourself and others.

NOTICE

This is a warning against anything which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.

the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”.

ii

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Important information about your Toyota

New vehicle warranty

Your new vehicle is covered by the following Toyota limited warranties:

(cid:1) New vehicle warranty (cid:1) Emission control systems warranty (cid:1) Others

For further information, please refer to the “Owner’s War- ranty Information Booklet” or “Owner’s Manual Supple- ment”.

Your responsibility for

maintenance

It is the owner’s responsibility to make sure that the speci- fied maintenance is performed. Section 6 gives details of these maintenance requirements. Also included in Section 6 is general maintenance. For scheduled maintenance in- formation, please refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”.

Accessories, spare parts and modification of your Toyota

A wide variety of non–genuine spare parts and accessories for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these prod- ucts and is not responsible for their performance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle.

This vehicle should not be modified with non–genuine Toyota products. Modification with non–genuine Toyota products could affect its performance, safety or durability, and may even violate governmental regulations. In addi- tion, damage or performance problems resulting from the modification may not be covered under warranty.

iii

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Spark ignition system of your

Scrapping of your Toyota

If

The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by a qualified service shop or by your Toyota dealer before you dispose of your vehicle.

the vehicle

Toyota

The spark ignition system in your Toyota meets all require- ments of the Canadian Interference–Causing Equipment Standard.

Installation of a mobile two–way radio system

As the installation of a mobile two–way radio system in your vehicle could affect electronic systems such as multi- port fuel injection system/sequential multiport fuel injection system, electronic throttle control system, cruise control system, anti–lock brake system, SRS airbag system and seat belt pretensioner system, be sure to check with your Toyota dealer for precautionary measures or special instructions regarding installation.

iv

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

On–pavement and off–road

driving tips

(four–wheel drive models and

Pre Runner)

This vehicle will handle and maneuver differently from an ordinary passenger car because it is designed for off–road use also. It has a significantly higher rollover rate than other types of vehicles. In addition, this vehicle has a higher ground clearance and center of gravity than that of an ordinary passenger car. This vehicle design feature causes this type of vehicle to be more likely to rollover. Failure to operate this vehicle correctly may result in loss of control, accidents or vehicle rollover causing death or serious injury. Be sure to read “Off–road vehicle precau- tions” in Section 2 and “Off–road driving precautions” in Section 3.

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

vi

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Foreword

Welcome to the growing group of value–conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble–free motoring. For important information about this manual and your Toyota, read the following pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality maintenance and any other assistance you may require. If there is not a Toyota dealer near you, or you need emergency assistance for any reason, please call the following number:

(cid:1) U.S. OWNERS: (cid:1) CANADIAN OWNERS: Toyota Canada Customer Interaction Centre

Toyota Customer Assistance Center

Toll–free: 1–800–331–4331
Toll–free: 1–888–TOYOTA–8 (1–888–869–6828)

Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle.

 2002 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

f(cid:1)U-9

Quick index (cid:1) If a service reminder indicator or warning buzzer comes on (cid:1) If your vehicle will not start (cid:1) If your engine stalls while driving (cid:1) If you cannot increase the engine speed (cid:1) If your vehicle overheats (cid:1) If you have a flat tire (cid:1) If your vehicle becomes stuck (cid:1) If your vehicle needs to be towed (cid:1) Tips for driving during break–in period (cid:1) How to start the engine (cid:1) General maintenance (cid:1) Complete index Gas station information Fuel type:

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

119
222
225
225
226
227
237
238
193
208
253
NO TAG

UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher See page 193 for detailed information.

Fuel tank capacity:

Two–wheel drive models except Pre Runner

60 L (16.0 gal., 13.3 lmp. gal.)

Four–wheel drive models and Pre Runner

70 L (18.5 gal., 15.4 lmp. gal.)

Engine oil:

API grade SL “Energy–Conserving” or ILSAC multigrade engine oil is recom- mended. See page 267 for detailed information.

Tire information: See pages 271 through 276. Tire pressure: See page 296.

2003 MY TACOMA (OM35800U)

Publication No. OM35800U Part No. 01999-35800
Printed in Japan 01–0209–00

( U)

’03 Tacoma U (L/O 0209)

SECTION 1– 1

OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview Instrument cluster overview Indicator symbols on the instrument panel

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Instrument panel overview

1. Instrument cluster 2. Center vents 3. Personal lights or interior light 4. Side vents 5. Rear view mirror remote control levers 6. Glove box 7. Power door lock switches 8. Power window switches 9. Manual transmission gear shift lever or

automatic transmission selector lever

10. Rear console boxes 11. Cup holder 12. Power rear view mirror control switches 13. Front drive control lever 14. Tilt steering lock release lever 15. Hood lock release lever 16. Window lock switch

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

1. Headlight and turn signal switch 2. Wiper and washer switches 3. Emergency flasher switch 4. Passenger airbag manual on–off switch 5. Air conditioning controls 6. Car audio 7. Ashtray 8. Cigarette lighter 9. Power outlets 10. Clock 11. Parking brake lever 12. Ignition switch 13. Cruise control switch 14. Rear differential lock switch 15. Instrument panel light control knob 16. Clutch start cancel switch (manual

transmission) or driving pattern selector button (automatic transmission)

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Instrument cluster overview (cid:1)With tachometer

1. Engine coolant temperature gauge 2. Tachometer 3. Service reminder indicators and

indicator lights

4. Speedometer 5. Fuel gauge 6. Trip meter reset knob

7. Odometer and two trip meters

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

(cid:1)Without tachometer

1. Engine coolant temperature gauge 2. Service reminder indicators and

indicator lights

3. Speedometer 4. Odometer

5. Fuel gauge

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Indicator symbols on the instrument panel

Brake system warning light* 1

SRS warning light* 1

Seat belt reminder light* 1

Discharge warning light* 1

Low engine oil pressure warning light* 1

Malfunction indicator lamp* 1

Low fuel level warning light* 1

or

Anti–lock brake system warning light* 1

Unengaged “Park” warning light* 1

Automatic transmission fluid temperature warning light* 1

Low windshield washer light* 1

fluid

level warning

Headlight high beam indicator light

Turn signal indicator lights

Overdrive–off indicator light

Driving pattern (POWER mode) indicator light

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Four–wheel drive indicator light

Rear differential lock indicator light

Cruise control indicator light* 2

* 1: For details, see “Service reminder indicators and warning

buzzers” in Section 1–5.

* 2: If this light flashes, see “Cruise control” in Section 1–6.

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

SECTION 1– 2

OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors Keys Side doors Power windows Quarter windows Rear window Tailgate Hood Fuel tank cap Detachable moon roof Detachable sun shade

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

10
10
12
14
15
15
16
17
19
21

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

Side doors

Keys These keys work in every lock. Since the doors can be locked without a key, you should always carry a spare key in case you accidentally lock your key inside the vehicle.

KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by a Toyota dealer using the key number. We recommend writing down the key num- ber and storing it in a safe place.

LOCKING AND UNLOCKING WITH KEY Insert the key into the keyhole and turn it. To lock: Turn the key forward. To unlock: Turn the key backward. Vehicles with power door lock system— All lock and unlock simulta- neously with either front door. In the driv- er’s door lock, turning the key once will unlock the driver’s door and twice in suc- cession will unlock all the door simulta- neously.

the doors

10

2003 MY TACOMA (OM35800U)

’03 Tacoma U (L/O 0209)

lock: Push the switch down on the

LOCKING AND UNLOCKING WITH