Download PDF Manual

when the brake pads are worn to where replacement is required. If you hear a squealing or scraping noise the brake pads while driving, have checked and replaced by your Toyota dealer as soon as possible. Expensive ro- tor damage can result if the pads are not replaced when necessary.


D For better fuel economy, do not carry


unneeded weight.


CAUTION


D To prevent


luggage or packages from sliding forward during braking, do not stack anything in the en- larged trunk. Keep luggage or pack- ages low, as close to the floor as possible.


D Never allow anyone to ride in the enlarged trunk. It is not designed for passengers. They should ride in their seats with their seat belts properly fastened. Otherwise, they are much more likely to suffer seri- ous bodily injury, in the event of sudden braking or a collision.


D Do not place anything on the pack- age tray behind the rear seatback. Such items may be thrown about and possibly injure people in the vehicle during sudden braking or an accident.


D Do not drive with objects left on top of the instrument panel. They may interfere with the driver’s field of view. Or they may move during sharp vehicle acceleration or turn- ing, and impair the driver’s control of the vehicle. In an accident they may injure the vehicle occupants.


NOTICE


Do not load the vehicle beyond the vehicle capacity weight specified on page 274 in Section 8.


2002 MY CAMRY_U (OM33567U)


191


AP_Camry_U (L/O 0201)


Your Toyota’s identification— —Vehicle identification number


—Engine number


The vehicle identification number (VIN) is also on the Certification Label.


2AZ−FE engine


The vehicle identification number (VIN) is the legal identifier for your vehicle. This number is on the left top of the instrument panel, and can be seen through the windshield from outside. This is the primary identification number for your Toyota. It is used in registering the ownership of your vehicle.


192


2002 MY CAMRY_U (OM33567U)


1MZ−FE engine


The engine number is stamped on the engine block as shown.


AP_Camry_U (L/O 0201)


Suspension and chassis


CAUTION


Do not modify the suspension/chassis with lift kits, spacers, springs, etc. It can cause dangerous vehicle handling characteristics, resulting loss of control.


in


Theft prevention labels Your new vehicle carries theft preven- tion labels which are approximately 56
mm (2.20 in.) by 16 mm (0.63 in.). The purpose of these labels is to reduce the incidence of vehicle thefts by facilitat- ing the tracing and recovery of parts from stolen vehicles. The label is designed so that once it is applied to a surface, any attempt to remove it will result in destroy- ing the integrity of the label. Transferring these labels intact from one part to anoth- er, will be impossible.


NOTICE


You should not attempt to remove the theft prevention labels as it may vio- late certain state or federal laws.


2002 MY CAMRY_U (OM33567U)


193


AP_Camry_U (L/O 0201)


CAUTION


D Do not mix summer and all season tires on your vehicle as this can cause dangerous handling charac- teristics, resulting in loss of con- trol.


D Do not use tires other than the manufacturer’s designated tires, and never mix tires or wheels of the sizes different from the originally equipped tires and wheels.


Types of tires Determine what kind of tires your ve- hicle is originally equipped with. 1. Summer tires Summer tires are high−speed capability tires best suited to highway driving under dry conditions. Since summer tires do not have the same traction performance as snow tires, sum- mer tires are inadequate for driving on snow−covered or icy roads. For driving on snow−covered or icy roads, we recom- mend using snow tires. If installing snow tires, be sure to replace all four tires. 2. All season tires All season tires are designed to provide better traction in snow and to be adequate for driving in most winter conditions, as well as for use all year round. All season tires, however, do not have adequate traction performance compared with snow tires in heavy or loose snow. Also, all season tires fall short in accel- eration performance compared with summer tires in highway driving.


handling


and


194


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


2002 MY CAMRY_U (OM33567U)


195


AP_Camry_U (L/O 0201)


SECTION 3


STARTING AND DRIVING Before starting the engine How to start the engine Tips for driving in various conditions Winter driving tips Dinghy towing Trailer towing How to save fuel and make your vehicle last longer


. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .


197
197
198
199
200
201
207


196


2002 MY CAMRY_U (OM33567U)


Before starting the engine 1. Check the area around the vehicle be-


fore entering it.


2. Adjust seat position, seatback angle, restraint


seat cushion height, head height and steering wheel angle.


3. Vehicles with the power adjustable ped- als—Adjust the position of the acceler- ator and brake pedals.


4. Adjust the inside and outside rear view


mirrors.


5. Lock all doors. 6. Fasten seat belts.


AP_Camry_U (L/O 0201)


How to start the engine— (a) Before cranking 1. Apply the parking brake firmly. 2. Turn off unnecessary lights and acces-


sories.


into neutral. Hold


3. Manual transmission: Press the clutch pedal to the floor and shift the trans- mission the clutch pedal to the floor until the engine is started. A starter safety device will pre- vent the starter from operating if the clutch pedal is not fully depressed. Automatic transmission: Put the se- lector lever in “P”. If you need to re- start the engine while the vehicle is moving, put the selector lever in “N”. A starter safety device will prevent the starter the selector lever is in any drive position.


from operating if


4. Automatic


transmission only: De- press the brake pedal and hold it to the floor until driving off.


(b) Starting the engine Before starting the engine, be sure to fol- low the instructions in “(a) Before crank- ing”. Normal starting procedure The multiport fuel injection system/sequen- tial multiport fuel injection system in your engine automatically controls the proper air−fuel mixture for starting. You can start a cold or hot engine as follows: 1. With your foot off the accelerator ped- al, crank the engine by turning the key to “START”. Release it when the en- gine starts.


2. After the engine runs for about 10 se-


conds, you are ready to drive.


If the weather is below freezing, let the engine warm up for a few minutes before driving. If the engine stalls... Simply restart it, using the correct proce- dure given in normal starting. If the engine will not start... See “If your vehicle will not start” on page 211 in Section 4.


2002 MY CAMRY_U (OM33567U)


197


AP_Camry_U (L/O 0201)


NOTICE


z Do not crank for more than 30 se- conds at a time. This may overheat the starter and wiring systems.


z Do not race a cold engine. z If the engine becomes difficult to start or stalls frequently, have the engine checked immediately.


Tips for driving in various conditions D Always slow down in gusty crosswinds. This will allow you much better control. D Drive slowly onto curbs and, if pos- sible, at a right angle. Avoid driving onto high, sharp−edged objects and other road hazards. Failure to do so can lead to severe tire damage result- ing in tire bursts. Drive slowly when passing over bumps or travelling on a bumpy road. Other- wise, the impact could cause severe damage to the tires and/or wheels.


they


D When parking on a hill, turn the front wheels until touch the curb so that the vehicle will not roll. Apply the parking brake, and place the transmis- sion in “P” (automatic) or in first or reverse (manual). If necessary, block the wheels.


198


2002 MY CAMRY_U (OM33567U)


D Washing your vehicle or driving through deep water may get the brakes wet. To see whether they are wet, check that there is no traffic near you, and then press the pedal lightly. If you do not feel a normal braking force, the brakes are probably wet. To dry them, drive the vehicle cautiously while lightly pressing the brake pedal with the park- ing brake applied. If they still do not work safely, pull to the side of the road and call a Toyota dealer for assistance.


CAUTION


D Before driving off, make sure that the parking brake is fully released and reminder light is off.


the parking brake


D Do not


leave your vehicle unat- tended while the engine is running. D Do not rest your foot on the brake pedal while driving. It can cause dangerous overheating, needless wear, and poor fuel economy.


D To drive down a long or steep hill, reduce your speed and downshift. Remember, if you ride the brakes excessively, they may overheat and not work properly.


AP_Camry_U (L/O 0201)


D Be careful when accelerating, up- shifting, downshifting or braking on a slippery surface. Sudden accelera- tion or engine braking could cause the vehicle to spin or skid.


tire dealer


D Do not drive in excess of the speed limit. Even if the legal speed limit permits it, do not drive over 140
km/h (85 mph) unless your vehicle has high−speed capability tires. Driving over 140 km/h (85 mph) may result in tire failure, loss of control and possible injury. Be sure to con- sult a to determine whether the tires on your vehicle are high−speed capability tires or not before driving at such speeds. D Do not continue normal driving when the brakes are wet. If they are require a wet, your vehicle will longer stopping distance, and it may pull the brakes are applied. Also, the park- ing brake will not hold the vehicle securely.


to one side when


Winter driving tips Make sure you have a proper freeze protection of engine coolant. Your coolant must contain ethylene−glycol type corrosion protection of aluminum components. Use “TOYOTA Long Life Coolant” or equivalent. See page 252 in Section 7−2 for details about coolant type selection.


for a proper


coolant


NOTICE


Do not use alcohol type antifreeze or plain water alone.


When it is extremely cold, we recommend to use 60% solution for your Toyota, to provide protection down to about −50_C (−58_F). Do not use more than 70% solu- tion for better coolant performance. Check the condition of the battery and cables. Cold temperatures reduce the capacity of any battery, so it must be in top shape to provide enough power for winter start- ing. Section 7−3 tells you how to visually inspect the battery. Your Toyota dealer and most service stations will be pleased to check the level of charge.


Make sure the engine oil viscosity is suitable for the cold weather. See page 251 in Section 7−2 for recom- mended viscosity. Leaving a heavy sum- mer oil in your vehicle during winter months may cause harder starting. If you are not sure about which oil to use, call your Toyota dealer—he will be pleased to help. Keep the door locks from freezing. Squirt lock de−icer or glycerine into the locks to keep them from freezing. Use a washer fluid containing an anti- freeze solution. This product is available at your Toyota dealer and most auto parts stores. Follow the manufacturer’s directions for how much to mix with water.


NOTICE


Do not use engine antifreeze or any other substitute because it may dam- age your vehicle’s paint.


2002 MY CAMRY_U (OM33567U)


199


AP_Camry_U (L/O 0201)


Dinghy towing (with automatic transmission)


Dinghy towing (with manual transmission)


Your vehicle to be dinghy towed (with four wheels on the ground) behind a motorhome.


is not designed


Your vehicle can be dinghy towed (with four wheels on the ground) from the front behind a motorhome.


NOTICE


CAUTION


Do not tow your vehicle with four wheels on the ground. This may cause serious damage to your vehicle.


Dinghy towing requires special equip- ment and accessories. Please refer to your service outlet of the motorhome manufacture recommended equipment.


the


for


into


in and around


Do not use your parking brake when there is a possibility it could freeze. When parking, put the transmission into “P” (automatic) or first or reverse (manual) and block the rear wheels. Do not use the parking brake, or snow or water accumulated the freeze, parking brake mechanism may making it hard to release. Keep ice and snow from accumulating under the fenders. Ice and snow built up under your fenders can make steering difficult. During bad winter driving, stop and check under the fenders occasionally. Depending on where you are driving, we recommend you carry some emer- gency equipment. Some of the things you might put in the vehicle are tire chains, window scraper, bag of sand or salt, flares, small shovel, jumper cables, etc.


200


2002 MY CAMRY_U (OM33567U)


NOTICE


Dinghy towing does not eliminate the possibility of damage to your vehicle.


AP_Camry_U (L/O 0201)


DINGHY TOWING TIPS Before dinghy towing, be sure to ob- serve the following in order to reduce the damage to your vehicle. 1. Put the shift lever in neutral. 2. Turn the ignition switch to the “ACC” position. Make sure the audio is turned off and any item is not plugged into the power outlet.


NOTICE


To avoid the locking of the steering wheel, turn the ignition switch to the “ACC” position.


3. Release the parking brake. After dinghy towing, let the engine idle for more than 3 minutes before driving the vehicle.


NOTICE


Do not tow your vehicle from the rear. This may cause serious damage to your vehicle.


vehicle. Towing


Trailer towing Your vehicle is designed primarily as a passenger−carrying trailer will have an adverse effect on handling, performance, braking, durability and driving economy (fuel consumption, etc.). Your safety and satisfaction depend on the proper use of correct equipment and cautious driving habits. For your safety and the safety of others, you must not overload your vehicle or trailer. Toyota warranties do not apply to damage or malfunction caused by towing a trailer for commercial purposes. Ask your local further details before Toyota dealer towing.


for


NOTICE


When towing a trailer, be sure to con- sult your Toyota dealer for further in- formation on additional requirements such as a towing kit, etc.


2002 MY CAMRY_U (OM33567U)


201


AP_Camry_U (L/O 0201)


WEIGHT LIMITS Before towing, make sure the total trailer weight, gross vehicle weight, gross axle weight and trailer tongue load are all with- in the limits. The total trailer weight and tongue load can be measured with platform scales found at a highway weighing station, build- ing supply company, trucking company, junk yard, etc.


CAUTION


D The


total


trailer weight its cargo


(trailer weight plus load) must not exceed 907 kg (2000 lb.). Ex- ceeding this weight is dangerous.


D Trailer hitch assemblies have differ- ent weight capacities established by the hitch manufacturer. Even though the vehicle may be physically capa- ble of towing a higher weight, the operator must determine the maxi- mum weight rating of the particular hitch assembly and never exceed the maximum weight rating speci- fied for the trailer−hitch. Exceeding the maximum weight rating set by the trailer hitch manufacturer can cause an accident resulting in seri- ous personal injuries.


indicated on


D The gross vehicle weight must not the Gross Vehicle Weight exceed (GVWR) the Rating Certification Label. The gross ve- hicle weight is the sum of weights of the unloaded vehicle, driver, pas- sengers, luggage, hitch and trailer tongue includes the weight of any special equipment installed on your vehicle.


It also


load.


202


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


D The load on either the front or rear axle resulting from distribution of the gross vehicle weight on both axles must not exceed the Gross Axle Weight Rating (GAWR) listed on the Certification Label.


Total trailer weight


Tongue load


Tongue load


Total trailer weight


100 = 9 to 11%


D The trailer cargo


the


total


to 11% of


load should be distributed so that the tongue load is 9 trailer weight, not exceeding the maximum of 90 kg (200 lb.). Never load the trailer with more weight in the back than in the front. About 60% of the trailer load should be in the front half of the trailer and the remaining 40% in the rear.


HITCHES D Use only a hitch which


recom- mended by the hitch manufacturer and conforms to the total trailer weight re- quirement.


is


D Follow the directions supplied by the hitch manufacturer. Lubricate the hitch ball with a light coat of grease.


D Toyota recommends removing the trail- er hitch whenever you are not towing to reduce the possibility of additional damage caused by the hitch if your vehicle is struck from behind.


trailer


NOTICE


Do not use axle−mounted hitches as they can cause damage to the axle housing, wheel bearings, wheels or tires. Also, never install a hitch which may interfere with the normal function of an Energy Absorbing Bumper, if so equipped.


BRAKES AND SAFETY CHAINS D Toyota


recommends


trailers with brakes that conform to any applica- ble federal and state/provincial regu- lations.


2002 MY CAMRY_U (OM33567U)


203


AP_Camry_U (L/O 0201)


D A safety chain must always be used between the towing vehicle and the trailer. Leave sufficient slack in the chain for turns. The chain should cross under to prevent the tongue from dropping to the ground in case it becomes dam- aged or separated. For correct safety chain procedures, follow the hitch or trailer manufacturer’s recommenda- tions.


tongue


trailer


the


TIRES D Ensure


recommended cold


that your vehicle’s


the indicated below


tires are properly inflated. Adjust the tire pres- tire sure to pressure (see page 255 in Section 7−2 for instructions.): Tire pressure, kPa (kgf/cm2 or bar, psi) P205/65R15 92T or P205/65R15 92H 220 (2.2, 32) 220 (2.2, 32)


Front Rear


local


local


TRAILER LIGHTS D Trailer lights must comply with federal, regulations. state/provincial and See your recreational vehicle dealer or rental agency for the correct type of wiring and relays for your trail- er. Check for correct operation of the turn signals and stop lights each time you hitch up. Direct splicing may dam- age your vehicle’s electrical system and cause a malfunction of your lights.


CAUTION


D If the total trailer weight exceeds 453 kg (1000 lb.), trailer brakes are required.


D Never tap


into your vehicle’s hy- draulic system as it would lower its braking effectiveness.


D Never tow a trailer without using a safety chain securely attached to both the trailer and the vehicle. If damage occurs to the coupling unit or hitch ball, there is danger of the trailer wandering over into another lane.


P215/60R16 94V


Front Rear


200 (2.0, 29) 200 (2.0, 29) D The trailer tires should be inflated to the pressure recommended by the trail- er manufacturer in respect to the total trailer weight.


BREAK−IN SCHEDULE D Toyota recommends


that you do not tow a trailer with a new vehicle or a vehicle with any new power train com- ponent (engine, transmission, differen- tial, wheel bearing, etc.) for the first 800 km (500 miles) of driving.


MAINTENANCE D If you tow a trailer, your vehicle will require more frequent maintenance due to the additional load. For this informa- tion, please the scheduled maintenance information in the “Sched- uled Maintenance Guide” or “Owner’s Manual Supplement”.


refer


to


204


2002 MY CAMRY_U (OM33567U)


D Retighten all fixing bolts of the towing ball and bracket after approximately 1000 km (600 miles) of trailer driving.


AP_Camry_U (L/O 0201)


PRE−TOWING SAFETY CHECK D Check that your vehicle remains level when a loaded or unloaded trailer is hitched. Do not drive if the vehicle has an abnormal nose−up or nose−down condition, and check improper tongue load, overload, worn suspension or other possible causes.


for


D Make sure the trailer cargo is securely


loaded so that it can not shift.


D Check that your rear view mirrors con- form to any applicable federal, state/ provincial or local regulations. If not, install the rear view mirrors required for towing purpose.


TRAILER TOWING TIPS When towing a trailer, your vehicle will handle differently than when not tow- ing. The three main causes of vehicle− trailer accidents are driver error, exces- sive speed and improper trailer loading. Keep these in mind when towing: D Before starting out, check operation of the lights and all vehicle−trailer connec- tions. After driving a short distance, stop and recheck the lights and con- nections. Before actually towing a trail- er, practice turning, stopping and back- ing with a trailer in an area away from traffic until you learn the feel.


D Backing with a trailer is difficult and requires practice. Grip the bottom of the steering wheel and move your hand to the left to move the trailer to the left. Move your hand to the right to move the trailer to the right. (This pro- cedure that when backing without a trailer.) Also, just turn the steering wheel a little at time, avoiding sharp or prolonged turning. Have someone guide you when backing to reduce the risk of an acci- dent.


is generally opposite


to


increased when


D Because stopping distance may be in- vehicle−to−vehicle distance creased, should be towing a trailer. For each 16 km/h (10 mph) of speed, allow at least one vehicle and trailer length between you and the ve- hicle ahead. Avoid sudden braking as you may skid, resulting in jackknifing and loss of control. This is especially true on wet or slippery surfaces.


D Avoid jerky starts or sudden accelera- tion. If your vehicle has a manual transmission, prevent excessive clutch slippage by keeping engine rpm low and not racing the engine. Always start out in first gear.


D Avoid jerky steering and sharp turns. The trailer could hit your vehicle in a tight turn. Slow down before making a turn to avoid the necessity of sudden braking.


D Remember that when making a turn, the trailer wheels will be closer than the vehicle wheels to the inside of the turn. Therefore, compensate for this by making a turning radius with your vehicle.


than normal


larger


D Crosswinds and rough roads will ad- versely affect handling of your vehicle and trailer, causing sway. Pay attention to the rear from time to time to pre- pare yourself for being passed by large trucks or buses, which may cause your vehicle and trailer to sway. If swaying happens, firmly grip the steering wheel and immediately but gradually. Never increase speed. Steer straight ahead. If you make no extreme correction with the steering or brakes, the vehicle and trailer will stabilize.


reduce speed


D Be careful when passing other ve- hicles. Passing requires considerable distance. After passing a vehicle, do not forget the length of your trailer and be sure you have plenty of room be- fore changing lanes.


2002 MY CAMRY_U (OM33567U)


205


AP_Camry_U (L/O 0201)


D In order to maintain engine braking effi- ciency do not use fifth gear (manual transmission) or overdrive (automatic transmission).


(at


D Because of the added load of the trail- er, your vehicle’s engine may overheat on hot days temperatures over 30_C [85_F]) when going up a long or steep grade with a trailer. If the engine coolant indicates overheating, immediately turn off the air conditioning (if in use), pull off the road and stop in a safe spot. Refer to “If your vehicle overheats” on page 215 in Section 4.


temperature gauge


D Always place wheel blocks under both the vehicle and trailer wheels when parking. Apply the parking brake firmly. Put the transmission in “P” (automatic) or in first or reverse (manual). Avoid parking on a slope with a trailer, but if it cannot be avoided, do so only after performing the following:


1. Apply the brakes and hold. 2. Have someone place wheel blocks un- der both the vehicle and trailer wheels. 3. When the wheel blocks are in place, the


release your brakes slowly until blocks absorb the load.


4. Apply the parking brake firmly. 5. Shift into first or reverse (manual) or “P” (automatic) and turn off the engine. When restarting out after parking on a slope: 1. With the transmission in “P” position the clutch pedal de- the engine. transmission, be the brake pedal de-


(automatic) or pressed (With an automatic sure pressed.)


(manual), start


to keep


2. Shift into gear. 3. Release the parking brake (also foot brake on automatic transmission ve- hicles) and slowly pull or back away from the wheel blocks. Stop and apply your brakes.


4. Have someone retrieve the blocks.


206


2002 MY CAMRY_U (OM33567U)


CAUTION


towing speed


D Do not exceed 72 km/h (45 mph) or the posted limit, whichever is lower. Because insta- bility (swaying) of a towing vehicle− trailer in- creases as the speed increases, ex- ceeding 72 km/h (45 mph) may cause loss of control.


combination


usually


D Slow down and downshift before descending steep or long downhill grades. Do not make sudden down- shifts.


long or


D Avoid holding the brake pedal down too frequently. This could cause the brakes to overheat and result in reduced braking effi- ciency.


too


How to save fuel and make your vehicle last longer Improving fuel economy is easy—just take it easy. It will help make your vehicle last longer, too. Here are some specific tips on how to save money on both fuel and repairs: D Keep your tires inflated at the cor- rect pressure. Underinflation causes tire wear and wastes fuel. See page 255 in Section 7−2 for instructions. D Do not carry unneeded weight


in your vehicle. Excess weight puts a heavier the engine, causing greater fuel consumption.


load on


D Avoid lengthy warm−up idling. Once the engine is running smoothly, begin driving—but gently. Remember, howev- er, that on cold winter days this may take a little longer.


D Keep


the automatic


transmission overdrive turned on when engine braking is not required. Driving with the overdrive off will reduce the fuel economy. (For details, see “Automatic transmission” on page 108 in Section 1−6.)


D Accelerate


slowly


smoothly. Avoid jackrabbit starts. Get into high gear as quickly as possible.


and


AP_Camry_U (L/O 0201)


D Avoid long engine idling. If you have a long wait and you are not in traffic, it is better to turn off the engine and start again later.


D Avoid engine


lugging or over−rev- ving. Use a gear position suitable for the road on which you are travelling.


D Avoid continuous speeding up and slowing down. Stop−and−go driving wastes fuel.


D Avoid unnecessary stopping and braking. Maintain a steady pace. Try to time the traffic signals so you only need to stop as little as possible or take advantage of through streets to avoid traffic lights. Keep a proper dis- tance from other vehicles to avoid sud- den braking. This will also reduce wear on your brakes.


D Avoid heavy traffic or traffic


whenever possible.


jams


D Do not rest your foot on the clutch or brake pedal. This causes premature wear, overheating and poor fuel econo- my.


D Maintain a moderate speed on high- ways. The faster you drive, the greater the fuel consumption. By reducing your speed, you will cut down on fuel con- sumption.


2002 MY CAMRY_U (OM33567U)


the


D Keep


front wheels


in proper alignment. Avoid hitting the curb and slow down on rough roads. Improper alignment not only causes faster tire wear but also puts an extra load on the engine, which, in turn, wastes fuel. D Keep the bottom of your vehicle free from mud, etc. This not only lessens weight but also helps prevent corro- sion.


D Keep your vehicle tuned−up and in top shape. A dirty air cleaner, improp- er valve clearance, dirty plugs, dirty oil and grease, brakes not adjusted, etc. all lower engine performance and con- tribute to poor fuel economy. For longer life of all parts and lower operating costs, keep all maintenance work on schedule, and if you often drive under severe conditions, see that your vehicle frequent maintenance receives more (For scheduled maintenance informa- tion, please refer the “Scheduled Maintenance Guide” or “Owner’s Manu- al Supplement”).


to


207


AP_Camry_U (L/O 0201)


CAUTION


Never turn off the engine to coast down hills. Your power steering and brake booster will not function with- out the emission control system operates properly only when the engine is run- ning.


the engine running. Also,


208


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


2002 MY CAMRY_U (OM33567U)


209


AP_Camry_U (L/O 0201)


SECTION 4


IN CASE OF AN EMERGENCY If your vehicle will not start If your engine stalls while driving If you cannot increase the engine speed If your vehicle overheats If you have a flat tire If your vehicle needs to be towed If you cannot shift automatic transmission selector lever If you lose your keys If you lose your wireless remote control transmitter


. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .


211
214
214
215
216
224
228
229
229


210


2002 MY CAMRY_U (OM33567U)


to start


the engine


followed in


If your vehicle will not start— (a) Simple checks Before making these checks, make sure the correct starting you have procedure given “How the engine” on page 197 in Section 3 and that you have sufficient fuel. If your vehicle is immobiliser equipped with system, also check whether the other keys will start the engine. If they work, your key may be broken. Have the key checked at your Toyota dealer. If none of your keys work, the system is possibly broken. Call your Toyota dealer. (See “Keys (with engine immobiliser system)” on page 10 in Section 1−2.) If the engine is not turning over or is turning over too slowly— 1. Check the battery


terminals are


that


tight and clean.


2. If the battery terminals are O.K., switch


on the interior light.


3. If the light


is out, dim or goes out when the starter is cranked, the battery is discharged. You may try jump start- ing. See “(c) Jump starting” on page 212 for further instructions.


If the light is O.K., but the engine still will not start, it needs adjustment or repair. Call a Toyota dealer or qualified repair shop.


AP_Camry_U (L/O 0201)


NOTICE


Do not pull− or push−start the ve- hicle. It may damage the vehicle or cause a collision when the engine starts. Also the three−way catalytic converter may overheat and become a fire hazard.


If the engine turns over at its normal speed but will not start— 1. The engine may be flooded because of repeated cranking. See “(b) Starting a flooded engine” on page 211 for further instructions.


2. If the engine still will not start, it needs repair. Call a Toyota


adjustment or dealer or qualified repair shop.


(b) Starting a flooded engine If the engine will not start, your engine may be flooded because of repeated cranking. If this happens, turn the key to “START” the accelerator pedal held down. with Keep the key and accelerator pedal in these positions for 15 seconds and re- lease them. Then try starting the engine with your foot off the accelerator pedal. If the engine does not start after 15 se- conds of cranking, release the key, wait a few minutes and try again. If the engine still will not start, it needs adjustment or repair. Call a Toyota dealer or qualified repair shop for assistance.


NOTICE


Do not crank for more than 30 se- conds at a time. This may overheat the starter and wiring systems.


2002 MY CAMRY_U (OM33567U)


211


AP_Camry_U (L/O 0201)


JUMP STARTING PROCEDURE 1. If


the booster battery


installed in another vehicle, make sure the vehicles are not touching. Turn off all unneces- sary lights and accessories.


is


2. If required, remove all the vent plugs from the booster and discharged batter- ies. Lay a cloth over the open vents on the batteries. (This helps reduce the explosion hazard, personal injuries and burns.)


3. If the engine in the vehicle with the booster battery is not running, start it and let it run for a few minutes. During jump starting run the engine at about 2000 rpm with the accelerator pedal lightly depressed.


(c) Jump starting To avoid serious personal injury and damage to your vehicle which might re- sult from battery explosion, acid burns, electrical burns, or damaged electronic components, these instructions must be followed precisely. If you are unsure about how to follow this procedure, we strongly that you seek the help of a competent me- chanic or towing service.


recommend


CAUTION


D Batteries


contain


sulfuric


acid which is poisonous and corrosive. Wear protective safety glasses when jump starting, and avoid spilling acid on your skin, clothing, or ve- hicle.


D If you should accidentally get acid on yourself or in your eyes, remove any contaminated clothing and flush the affected area with water imme- diately. Then get immediate medical attention. If possible, continue to apply water with a sponge or cloth while enroute to the medical office.


D The gas normally produced by a battery will explode if a flame or spark is brought near. Use only standardized jumper cables and do not smoke or light a match while jump starting.


D Warning: Battery posts,


terminals and related accessories contain lead and lead compounds, chemicals known to the State of California to cause reproductive harm. Wash hands after handling.


cancer


and


NOTICE


The battery used for boosting must be 12 V. Do not jump start unless you are sure that the booster battery is correct.


212


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


Discharged battery


Jumper cable


Booster battery


Positive terminal (“+”mark)


Jumper cable


Discharged battery


Positive terminal (“+”mark)


Negative terminal (“−”mark)


Booster battery


4. Make the cable connections in the or-


der a, b, c, d. a. Connect the clamp of the positive (red) jumper cable to the positive (+) terminal on the discharged battery. b. Connect the clamp at the other end of the positive (red) jumper cable to the positive (+) terminal on the booster battery.


c. Connect the clamp of the negative (black) jumper cable to the negative (−) terminal on the booster battery. d. Connect the clamp at the other end of the negative (black) jumper cable to a solid, stationary, unpainted, metallic point of the vehicle with the discharged battery. The recommended connecting points are shown in the following illustrations:


Connecting point for 2AZ−FE engine


2002 MY CAMRY_U (OM33567U)


213


Connecting point for 1MZ−FE engine


AP_Camry_U (L/O 0201)


If your engine stalls while driving If your engine stalls while driving... 1. Reduce your speed gradually, keeping a straight line. Move cautiously off the road to a safe place.


2. Turn on your emergency flashers. 3. Try starting the engine again. If the engine will not start, see “If your vehicle will not start” on page 211 in this section.


CAUTION


If the engine is not running, the pow- er assist for the brakes and steering will not work so steering and braking will be much harder than usual.


Do not connect it to or near any part that moves when is cranked.


the engine


CAUTION


the connections,


When making to avoid serious injury, do not lean over the battery or accidentally the jumper cables or clamps touch any- thing except the correct battery termi- nals or the ground.


let


5. Start your engine in the normal way. After starting, run it at about 2000 rpm for several minutes with the accelerator pedal lightly depressed.


6. Carefully disconnect the cables in the exact reverse order: the negative cable and then the positive cable.


7. Carefully dispose of the battery cover cloths—they may now contain sulfuric acid.


8. If removed, replace all the battery vent


plugs.


If the cause of your battery discharging is not apparent (for example, lights left on), you should have it checked.


214


2002 MY CAMRY_U (OM33567U)


If you cannot increase the engine speed If the engine speed does not increase when the accelerator pedal is depressed, there may be a problem somewhere in your electronic throttle control system. At this time, vibration may occur. Howev- er, if you depress the accelerator pedal more firmly and slowly, you can drive your vehicle at low speeds. Have your vehicle checked by your Toyota dealer as soon as possible. Even if the abnormality of the electronic throttle control system is corrected during low speed driving, the system may not be recovered until the engine is stopped and the ignition key to “ACC” or “LOCK” position.


turned


is


CAUTION


Be especially careful to prevent erro- neous pedal operation.


AP_Camry_U (L/O 0201)


6. After


the engine coolant


temperature has cooled to normal, again check the coolant level in the reservoir. If neces- sary, bring it up to half full again. Seri- ous coolant loss indicates a leak in the system. You should have it checked as soon as possible at your Toyota dealer.


If your vehicle overheats If your engine coolant temperature gauge indicates overheating, if you ex- perience a loss of power, or if you hear a loud knocking or pinging noise, the engine has probably overheated. You should follow this procedure... 1. Pull safely off the road, stop the ve- turn on your emergency hicle and flashers. Put the transmission in “P” (automatic) or neutral (manual) and ap- ply the parking brake. Turn off the air conditioning if it is being used.


2. If coolant or steam is boiling out of the radiator or reservoir, stop the engine. Wait until the steam subsides before opening the hood. If there is no coolant boiling over or steam, leave the engine running and make sure the electric cooling fan is operating. If it is not, turn the ignition off.


CAUTION


injury, keep To help avoid personal the hood closed until there is no steam. Escaping steam or coolant is a sign of very high pressure.


3. Look for obvious coolant leaks from the radiator, hoses, and under the vehicle. However, note that water draining from the air conditioning is normal if it has been used.


CAUTION


the engine


When is running, keep hands and clothing away from the moving fan and engine drive belts.


4. If the coolant is leaking, stop the en- gine immediately. Call a Toyota dealer for assistance.


5. If there are no obvious leaks, check the coolant reservoir. If it is dry, add coolant to the reservoir while the en- gine is running. Fill it about half full.


CAUTION


Do not attempt to remove the radiator cap when the engine and radiator are hot. Serious injury could result from scalding hot fluid and steam blown out under pressure.


2002 MY CAMRY_U (OM33567U)


215


AP_Camry_U (L/O 0201)


D Do not start or run the engine while is supported by the


your vehicle jack.


D Raise the vehicle only high enough


to remove and change the tire.


NOTICE


Do not continue driving with a de- flated tire. Driving even a short dis- tance can damage a tire and wheel beyond repair.


D Stop the vehicle on a


the transmission


level firm ground, firmly set the parking brake in “P” and put (automatic) or (manual). Block the wheel diagonally opposite to the one being changed if neces- sary.


reverse


D Make sure to set the jack properly in the jack point. Raising the ve- hicle with improperly posi- tioned will damage the vehicle or may allow the vehicle to fall off the jack and cause personal injury.


jack


D Never get under the vehicle when the vehicle is supported by the jack alone.


D Use the jack only for lifting your


vehicle during wheel changing.


D Do not raise the vehicle with some-


one in the vehicle.


D When raising the vehicle, do not put an object on or under the jack.


If you have a flat tire— 1. Reduce your speed gradually, keeping a straight line. Move cautiously off the road to a safe place well away from the traffic. Avoid stopping on the center divider of a highway. Park on a level spot with firm ground.


2. Stop


the engine and


turn on your


emergency flashers.


3. Firmly set the parking brake and put the transmission in “P” (automatic) or reverse (manual).


4. Have everyone get out of the vehicle


on the side away from traffic.


5. Read oughly.


the


following


instructions


thor-


CAUTION


When jacking, be sure to observe the following to reduce the possibility of personal injury: D Follow jacking instructions. D Do not put any part of your body under the vehicle supported by the jack. Personal injury may occur.


216


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


The compact spare tire can be used many times, if necessary. It has tread life of up to 4800 km (3000 miles) depending on road conditions and your driving habits. When tread wear indicators appear on the tire, replace the tire. See also the tire section on page 255 in Section 7−2 for details on the tread wear indicators and other service information.


CAUTION


NOTICE


is the compact spare


reduced Your ground clearance when is tire installed so avoid driving over ob- stacles and drive slowly on rough, unpaved roads and speed bumps. Also, do not attempt to go through an automatic car wash as the vehicle may get caught, resulting in damage.


D The compact spare


tire was de- signed especially for your Toyota. Do not use it on any other vehicle. D Do not exceed 80 km/h (50 mph) the compact


when driving with spare tire.


D Avoid sudden acceleration, sudden deceleration and sharp turns with the compact spare tire.


2002 MY CAMRY_U (OM33567U)


217


Compact spare tire (on some models) The compact spare tire is designed for temporary emergency use only. The compact spare tire is identified by the distinctive wording “TEMPORARY USE ONLY” molded into the side wall of the tire. The standard tire should be repaired and replaced as soon as possible. The compact spare tire saves space in your luggage compartment, and its lighter weight helps to improve fuel economy and permits easier installation in case of a flat tire.


AP_Camry_U (L/O 0201)


—Required tools and spare tire


tools and spare


the required


1. Get tire. 1. Jack handle 2. Wheel nut wrench 3. Front towing eyelet


(on some models)


4. Jack 5. Spare tire


To prepare yourself for an emergency, you should familiarize yourself with the use of the jack, each of the tools and their stor- age locations.


With a compact spare tire


To remove the jack, turn the jack joint by hand until the jack becomes free.


Without a compact spare tire


218


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


—Blocking the wheel


To store the jack, align the hole of the jack head with the vehicle hook. Turn the jack joint until the jack base fits securely with the vehicle body. This prevents the jack from flying forward during a collision or sudden stop.


To remove the spare tire: 1. Loosen the nut and remove it. 2. Remove the spare tire cover. 3. Loosen the bolt and remove it. 4. Remove tire only)


the spacer.


(compact spare


2. Block the wheel diagonally opposite the flat tire to keep the vehicle from rolling when it is jacked up.


When blocking the wheel, place a wheel block from the front for the front wheels or from the rear for the rear wheels.


Then take the spare tire out of the ve- hicle. When storing the spare tire, put it in place with the outer side of the wheel facing up. Then secure the above removal steps in reverse order to prevent forward during a collision or sudden braking.


repeating


tire by


flying


from


the


it


2002 MY CAMRY_U (OM33567U)


219


AP_Camry_U (L/O 0201)


—Removing wheel ornament (steel wheels only)


—Loosening wheel nuts


—Positioning the jack


3. Remove the wheel ornament. Pry off the beveled end of the wheel nut wrench as shown.


the wheel ornament, using


CAUTION


Do not try to pull off the ornament by hand. Take due care in handling the ornament to avoid unexpected person- al injury.


4. Loosen all the wheel nuts. Always loosen the wheel nuts before rais- ing the vehicle. Turn the wheel nuts counterclockwise to loosen. To get maximum leverage, fit the wrench to the nut so that the handle is on the right side, as shown above. Grab the wrench near the end of the handle and pull up on the handle. Be careful that the wrench does not slip off the nut. Do not remove the nuts yet—just unscrew them about one−half turn.


5. Position the jack at the correct jack point as shown. Rotate the load rest 90_ from storage position to lifting position.


Make sure the jack level and solid place.


is positioned on a


220


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


—Raising your vehicle


—Changing wheels


CAUTION


Never get under the vehicle when the vehicle jack alone.


is supported by


the


6. After making sure that no one is in the vehicle, raise it high enough so that the spare tire can be installed. Remember you will need more ground clearance when putting on the spare tire than when removing the flat tire. To raise the vehicle, insert the jack handle into the jack (it is a loose fit) and turn it clockwise. As the jack touches the vehicle and begins to lift, double−check that it is properly positioned.


7. Remove the wheel nuts and change


tires. the


it


flat


the spare wheel


tire straight off and put


Lift aside. Roll into position and align the holes in the wheel with the bolts. Then lift up the wheel and get at least the top bolt started through its hole. Wiggle the tire and press it back over the other bolts.


2002 MY CAMRY_U (OM33567U)


221


AP_Camry_U (L/O 0201)


—Reinstalling wheel nuts


—Lowering your vehicle


Before putting on wheels, remove any cor- rosion on the mounting surfaces with a wire brush or such. Installation of wheels without good metal−to−metal contact at the mounting surface can cause wheel nuts to loosen and eventually cause a wheel to come off while driving. Therefore after the first 1600 km (1000 miles), check to see that the wheel nuts are tight.


8. Reinstall all the wheel nuts finger


tight.


Reinstall the wheel nuts (tapered end in- ward) and tighten them as much as you can by hand. Press back on the tire and see if you can tighten them more.


222


2002 MY CAMRY_U (OM33567U)


9. Lower


the vehicle completely and


tighten the wheel nuts.


Turn the jack handle counterclockwise to lower the vehicle. Use only the wheel nut wrench to tighten the nuts. Do not use other tools or any additional leverage other than your hands, such as a hammer, pipe or your foot. is securely en- Make sure gaged over the nut. Tighten each nut a little at a time in the order shown. Repeat the process until all the nuts are tight.


the wrench


AP_Camry_U (L/O 0201)


CAUTION


—Reinstalling wheel ornament (steel wheels only)


—After changing wheels 11. Check the air pressure of the re-


placed tire.


When lowering the vehicle, make sure all portions of your body and all oth- er persons around will not be injured as the ground.


the vehicle


lowered


to


is


10. Reinstall the wheel ornament. 1. Put the wheel ornament into position. Align the cutout of the wheel ornament with the valve stem as shown. 2. Tap it firmly with the side or heel of


your hand to snap it into place.


is


to


lower, drive slowly


Adjust the air pressure to the specification designed on page 278 in Section 8. If the pressure the nearest service station and fill to the cor- rect pressure. Do not forget to reinstall the tire inflation valve cap as dirt and moisture could get into the valve core and possibly cause air leakage. If the cap is missing, have a new one put on as soon as possible. 12. Restow all the tools, jack and flat


tire securely.


As soon after changing wheels as pos- sible, tighten the wheel nuts to the torque specified on page 278 in Section 8 with a torque wrench. Have a technician repair the flat tire and replace the spare tire with it.


CAUTION


CAUTION


Take due care in handling the orna- ment to avoid unexpected personal injury.


Before driving, make sure all the tools, jack and flat tire are securely in place in their storage location to reduce the possibility of personal in- jury during a collision or sudden braking.


2002 MY CAMRY_U (OM33567U)


223


If your vehicle needs to be towed—


(a) Towing with wheel lift type truck—


—From front


—From rear


(b) Using flat bed truck


AP_Camry_U (L/O 0201)


If towing is necessary, we recommend you to have it done by your Toyota dealer or a commercial tow truck ser- vice. In consultation with them, have your vehicle towed using either (a) or (b). Only when you cannot receive a towing service from a Toyota dealer or com- mercial tow truck service, tow your ve- hicle carefully in accordance with the instructions given in “—Emergency tow- ing” on page 225 in this section. Proper equipment will help ensure that your vehicle is not damaged while being towed. Commercial operators are generally aware of local laws pertaining to towing. Your vehicle can be damaged is towed incorrectly. Although most operators know the correct procedure, it is possible to make a mistake. To avoid damage to your vehicle, make sure the following pre- cautions are observed. If necessary, show this page to the tow truck driver. TOWING PRECAUTIONS: Use a safety chain system for all towing, and abide by the state/provincial and local laws. The wheels and axle on the ground must be in good condition. If they are damaged, use a towing dolly.


the state/provincial and


if


it


(a) Towing with wheel lift type truck


NOTICE


When lifting wheels, take care to en- sure adequate ground clearance for towing at the opposite end of the raised vehicle. Otherwise, the bumper and/or underbody of the towed vehicle will be damaged during towing.


From front—Release the parking brake. From rear— D Manual transmission:


We recommend using a towing dolly under the front wheels. If you do not use a towing dolly, place the ignition key in the “ACC” position and put the transmission in neutral.


NOTICE


Do not tow with the key removed or in the “LOCK” position when towing from the rear without a towing dolly. The steering lock mechanism is not strong enough front wheels straight.


to hold


the


224


2002 MY CAMRY_U (OM33567U)


AP_Camry_U (L/O 0201)


—Emergency towing


D Automatic transmission:


Use a wheels.


towing dolly under


the


front


(c) Towing with sling


type truck


NOTICE


Never tow a vehicle with an automatic transmission from the rear with the front wheels on the ground, as this may cause serious damage the transmission.


to


(b) Using flat bed truck


(c) Towing with sling type truck


Front (type A)


NOTICE


Do not tow with sling type truck, ei- ther from the front or rear. This may cause body damage.


2002 MY CAMRY_U (OM33567U)


225


Front (type B)


Loading...
x