2002 Toyota Camry Owners Manual

mended speed lower.

limit, whichever

D Drive carefully avoiding bumps, holes, and sharp turns, which may cause the vehicle to bounce.

D Avoid sharp turns or locked−wheel braking, as use of chains may ad- versely affect vehicle handling.

D When driving with chains installed, be sure to drive carefully. Slow down before entering the curves to avoid losing control of the vehicle. Otherwise an accident may occur.

NOTICE

Do not attempt to use a tire chain on the compact spare tire, as it may re- sult in damage to the vehicle as well as the tire.

AP_Camry_U (L/O 0201)

Replacement with used wheels is not rec- ommended as they may have been sub- jected to rough treatment or high mileage and could fail without warning. Also, bent wheels which have been straightened may have structural damage and therefore should not be used. Never use an inner tube in a leaking wheel which is designed for a tubeless tire.

Replacing wheels WHEN TO REPLACE YOUR WHEELS If you have wheel damage such as bending, cracks or heavy corrosion, the wheel should be replaced. If you fail to replace damaged wheels, the tire may slip off the wheel or cause loss of handling control. WHEEL SELECTION When replacing wheels, care should be taken to ensure that the wheels are re- placed by ones with the same load ca- pacity, diameter, rim width, and offset. Correct replacement wheels are available at your Toyota dealer. A wheel of a different size or type may adversely affect handling, wheel and bear- ing life, brake cooling, speedometer/odom- eter calibration, stopping ability, headlight aim, bumper height, vehicle ground clear- ance, and tire or snow chain clearance to the body and chassis.

2002 MY CAMRY_U (OM33567U)

259

AP_Camry_U (L/O 0201)

Aluminum wheel precautions D When aluminum wheels, check tight after driving your vehicle the first 1600
km (1000 miles).

the wheel nuts are

installing that

repaired, or D If you have changed your the wheel nuts are still tight after driving 1600 km (1000 miles).

rotated, tires, check

that

D When using tire chains, be careful not

to damage the aluminum wheels.

D Use only the Toyota wheel nuts and for your aluminum

wrench designed wheels.

D When balancing your wheels, use only Toyota balance weights or equivalent and a plastic or rubber hammer.

D As with any wheel, periodically check your aluminum wheels for damage. If damaged, replace immediately.

260

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

2002 MY CAMRY_U (OM33567U)

261

AP_Camry_U (L/O 0201)

SECTION 7− 3

DO−IT−YOURSELF MAINTENANCE Electrical components Checking battery condition Battery recharging precautions Checking and replacing fuses Adding washer fluid Replacing light bulbs

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

263
264
265
266
266

262

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Checking battery condition— —Precautions

CAUTION

BATTERY PRECAUTIONS The battery produces flammable and explosive hydrogen gas. D Do not cause a spark from the bat-

tery with tools.

D Do not smoke or light a match near

the battery.

The electrolyte contains poisonous and corrosive sulfuric acid. D Avoid contact with eyes, skin or

clothes.

D Never ingest electrolyte. D Wear protective safety glasses when

working near the battery.

D Keep children away from the bat-

tery.

EMERGENCY MEASURES D If electrolyte gets

in your eyes, flush your eyes with clean water immediately immediate medical attention. If possible, con- tinue to apply water with a sponge or cloth while en route to the medi- cal office.

and get

D If electrolyte gets on your skin, thoroughly wash the contact area. If you feel pain or burning, get medi- cal attention immediately.

D If electrolyte gets on your clothes, there is a possibility of its soaking through to your skin, so immediate- ly take off the exposed clothing and follow the procedure above, if nec- essary.

D If you accidentally swallow electro- lyte, drink a large quantity of water or milk. Follow with milk of magne- sia, beaten raw egg or vegetable oil. Then go immediately for emer- gency help.

D Warning: Battery posts,

terminals and related accessories contain lead and lead compounds, chemicals known to the State of California to cause reproductive harm. Wash hands after handling.

cancer

and

—Checking battery exterior

Terminals

Ground cable

Hold−down clamp

Check the battery for corroded or loose terminal connections, cracks, or loose hold−down clamp. a. If the battery is corroded, wash it off with a solution of warm water and bak- ing soda. Coat the outside of the termi- nals with grease to prevent further cor- rosion.

b. If the terminal connections are loose, their clamp nuts—but do not

tighten overtighten.

c. Tighten

the hold−down clamp only enough to keep the battery firmly in place. Overtightening may damage the battery case.

2002 MY CAMRY_U (OM33567U)

263

AP_Camry_U (L/O 0201)

—Checking battery condition

NOTICE

Type A

z Be sure the engine and all accesso- ries are off before performing main- tenance.

z When checking the battery, remove the ground cable from the negative terminal (“−” mark) first and rein- stall it last.

z Be careful not to cause a short cir-

cuit with tools.

z Take care no solution gets into the

battery when washing it.

If the battery is disconnected or run down, the moon roof may not operate automatically and the jam protection func- tion will not function correctly after you reconnect, replace or recharge the battery. In any of these cases, you should normal- ize the moon roof. To normalize the moon roof, see “Electric moon roof” on page 32
in Section 1−2.

Green

Dark

Clear or light yellow

Type B

Blue

White

Red

CHECKING BY INDICATOR Check the battery condition by the indi- cator color.

Indicator color

Type A

Type B

Green

Blue

Dark

White

Clear or

light yellow

Red

Condition

Good

Charging necessary. Have battery checked by your Toyota dealer. Have battery checked by your Toyota dealer.

Battery recharging precautions During recharging, the battery is pro- ducing hydrogen gas. Therefore, before recharging: 1. If recharging with the battery installed on the vehicle, be sure to disconnect the ground cable.

2. Be sure the power switch on the re- charger the charger cables to the battery and when disconnecting them.

is off when connecting

CAUTION

D Always charge the battery in an un- confined area. Do not charge the battery in a garage or closed room where there is not sufficient ventila- tion.

D Only do a slow charge (5 A or less). Charging at a quicker rate is dangerous. The battery may ex- plode, causing personal injuries.

NOTICE

Never recharge the battery while the engine is running. Also, be sure all accessories are turned off.

264

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Checking and replacing fuses

Type A

Good

Blown

Type B

Good

Blown

Type C

Good

Blown

If the headlights or other electrical components do not work, check the fuses. If any of the fuses are blown, they must be replaced. See “Fuse locations” on page 245 in Sec- tion 7−1 for locations of the fuses. Turn the ignition switch and inoperative component off. Pull a suspected fuse straight out and check it. Determine which fuse may be causing the problem. The lid of the fuse box shows the name of the circuit for each fuse. See page 278 in Section 8 of this manual for the functions controlled by each circuit.

can you “CIG” or

Type A fuses can be pulled out by the pull−out tool. The location of the pull−out tool is shown in the illustration. If you are not sure whether the fuse has blown, try replacing the suspected fuse with one that you know is good. If the fuse has blown, push a new fuse into the clip. Only install a fuse with the amperage rat- ing designated on the fuse box lid. If you do not have a spare fuse, in an emergency the “POWER POINT” “MIR−HTR”, fuse, which may be dispensable for normal driving, and use it if its amperage rating is the same. If you cannot use one of the same amper- age, use one that is lower, but as close as possible to, the rating. If the amperage is fuse might blow out again but this does not indicate anything wrong. Be sure to get the correct fuse as soon as possible and return the substitute to its original clip. It is a good idea to purchase a set of spare fuses and keep them in your ve- hicle for emergencies.

that specified,

lower

than

pull

out

the

2002 MY CAMRY_U (OM33567U)

265

AP_Camry_U (L/O 0201)

the new

If fuse immediately blows out, there is a problem with the electrical sys- tem. Have your Toyota dealer correct it as soon as possible.

CAUTION

Never use a fuse with a higher am- perage rating, or any other object, in place of a fuse. This may cause ex- tensive damage and possibly a fire.

Adding washer fluid If any washer does not work or low windshield washer fluid level warning light comes on, the washer tank may be empty. Add washer fluid. You may use plain water as washer fluid. in cold areas where tempera- However, tures freezing point, use fluid containing antifreeze. This washer product is available at your Toyota dealer and most auto parts stores. Follow the manufacturer’s directions for how much to mix with water.

range below

NOTICE

Do not use engine antifreeze or any other substitute because it may dam- age your vehicle’s paint.

266

2002 MY CAMRY_U (OM33567U)

following

illustrations show how

Replacing light bulbs— The to gain access to the bulbs. When replacing a bulb, make sure the ignition switch and light switch are off. Use bulbs with the wattage ratings given in the table.

CAUTION

D To prevent yourself from burning, do not replace the light bulbs while they are hot.

D Halogen bulbs have pressurized gas inside and require special handling. They can burst or shatter if scratched or dropped. Hold a bulb only by its plastic or metal case. Do not touch the glass part of a bulb with bare hands.

NOTICE

Only use a bulb of the listed type.

AP_Camry_U (L/O 0201)

W Type

Light bulbs

Bulb No. —

W Type

Trunk light (type A)

Trunk light (type B)

—

A: HB3 halogen bulbs B: HB4 halogen bulbs C: Wedge base bulbs D: Double end bulbs

the

The inside of the lens of exterior lights such as headlights may temporarily fog up when the lens becomes wet in the rain or in a car wash. This is not a problem because the is caused by fogging temperature difference between the outside and the windshield fogged up in the rain. However, if there is a large drop of water on the inside of the lens, or if there is water pooled light, contact your Toyota dealer.

inside of

inside

lens,

just

like

the

the

Light bulbs

Headlights (high)

Headlights (low)

Front fog lights

Parking, front side marker and front turn signal lights Tail and rear side marker lights Rear turn signal lights Stop/tail lights

Back−up lights

License plate lights

High mounted stoplight Personal lights

Interior light (type A) Interior light (type B) Vanity lights

Glove box light

Bulb No. 9005

9006

9006

60

51

51

3457

30/8

194

3.8

921

18

3057

27/7

921

—

921

—

—

—

—

—

18

18

4.9

1.4

2002 MY CAMRY_U (OM33567U)

267

AP_Camry_U (L/O 0201)

—Headlights

High beam (inside)

Low beam (outside)

1. Open the hood. Turn the bulb base counterclockwise to the front of the vehicle as shown.

2. Unplug the connector while depress-

ing the lock release.

If the connector is tight, wiggle it.

3. Plug in a new bulb into the connec- tor and install it into the mounting hole. is not necessary after replacing Aiming the bulb. When aiming adjustment is nec- essary, contact your Toyota dealer.

268

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

—Parking, front side marker and front turn signal lights

—Tail, rear side maker, rear turn signal, back−up and stop/tail lights (type A)

a: Tail and rear side marker light b: Rear turn signal light c: Back−up light d: Stop/tail light

2002 MY CAMRY_U (OM33567U)

269

AP_Camry_U (L/O 0201)

—Tail, rear side maker, rear turn signal, back−up and stop/tail lights (type B)

—High mounted stoplight

a: Tail and rear side marker light b: Rear turn signal light c: Back−up light d: Stop/tail light

270

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

—Front fog and license plate lights If either the left or right front fog or license plate lights burns out, contact your Toyota dealer.

NOTICE

Do not try to replace the front fog or license plate light bulbs by yourself. You may damage the vehicle.

2002 MY CAMRY_U (OM33567U)

271

AP_Camry_U (L/O 0201)

SECTION 8

SPECIFICATIONS Dimensions and weight Engine Fuel Service specifications Tires Fuses

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

274
274
275
275
278
278

2002 MY CAMRY_U (OM33567U)

273

AP_Camry_U (L/O 0201)

Dimensions and weight

Overall length

Overall width

Overall height∗1

Wheelbase

Front tread

Rear tread

Vehicle capacity weight (occupants + luggage) ∗1: Unladen vehicle ∗2: With 205/65R15 tires ∗3: With 215/60R16 tires

mm (in.)

mm (in.)

mm (in.)

mm (in.)

mm (in.)

mm (in.)

kg (lb.)

4805 (189.2)

1795

1490
1500

(70.7) (58.7)∗2
(59.1)∗3

2720 (107.1)

1545

(60.8)

1535

(60.4)

410

(900)

Engine Model:

2AZ−FE and 1MZ−FE

Type:

2AZ−FE engine

4 cylinder in line, 4 cycle, gasoline

1MZ−FE engine

6 cylinder V type 4 cycle, gasoline

Bore and stroke, mm (in.):

2AZ−FE engine

88.5 96.0 (3.48 3.78)

1MZ−FE engine

87.5 83.0 (3.44 3.27)

Displacement, cm3 (cu. in.):

2AZ−FE engine 1MZ−FE engine

2362 (144.1) 2995 (182.8)

274

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Fuel Fuel type:

2AZ−FE engine

Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher

1MZ−FE engine

Unleaded gasoline, Octane Rating 87
(Research Octane Number 91) or higher. For improved vehicle perfor- mance, the use of premium unleaded gasoline with an Octane Rating of 91
(Research Octane Number 96) or higher is recommended.

Fuel tank capacity, L (gal., Imp. gal.):

70 (18.5, 15.4)

Service specifications ENGINE Valve clearance (engine cold), mm (in.):

2AZ−FE engine

Intake Exhaust

0.19—0.29 (0.007—0.011) 0.30—0.40 (0.012—0.016)

1MZ−FE engine

Intake Exhaust

0.15—0.25 (0.006—0.010) 0.25—0.35 (0.010—0.014)

Spark plug type:

DENSO NGK

SK20R11
IFR6A11

Spark plug gap, mm(in.):

1.1 (0.043)

Drive belt roughs No.BT−33−73F (used belt), Ibf:

tension measured with Bor- gauge

tension

drive

belt

ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.):

2AZ−FE engine

With filter Without filter 1MZ−FE engine

With filter Without filter

Oil grade:

3.8 (4.0, 3.3) 3.6 (3.8, 3.2)

4.7 (5.0, 4.1) 4.5 (4.8, 4.0)

API grade SJ “Energy−Conserving”, SL “Energy−Conserving” ILSAC multigrade engine oil is recommended.

or

Recommended oil viscosity (SAE):

1MZ−FE engine

115"20

5W-30 Preferred

Temperature range anticipated before next oil change

2002 MY CAMRY_U (OM33567U)

275

AP_Camry_U (L/O 0201)

COOLING SYSTEM Total capacity, L (qt., Imp. qt.):

2AZ−FE engine 1MZ−FE engine

Coolant type:

6.2 (6.6, 5.4) 9.2 (9.8, 8.1)

CLUTCH Pedal free play, mm (in.):

5—15 (0.2—0.6)

Fluid type:

SAE J1703 or FMVSS No.116 DOT 3

“TOYOTA Long Life Coolant” or equiva- lent With ethylene−glycol type coolant for a proper corrosion protection of aluminum components Do not use alcohol type antifreeze or plain water alone.

MANUAL TRANSAXLE Oil capacity, L (qt., Imp. qt.):

2.5 (2.6, 2.2)

Oil type:

Gear oil API GL−4 or GL−5

Recommended oil viscosity:

SAE 75W−90

BATTERY Open voltage∗ at 20_C (68_F): 12.6—12.8V Fully charged 12.2—12.4V Half charged 11.8—12.0V Discharged

∗: Voltage that is checked 20 minutes af- ter the key is removed with all the lights turned off Charging rates:

5 A max.

Note: If replacement is necessary, make sure to do so with a battery that meets the same standard as the original.

276

2002 MY CAMRY_U (OM33567U)

AUTOMATIC TRANSAXLE Fluid capacity (drain and refill), L (qt., Imp. qt.):

2AZ−FE engine 1MZ−FE engine

Fluid type:

3.9 (4.1, 3.4) 3.5 (3.7, 3.1)

in

listed

Guide”

is necessary

Automatic transmission fluid Type T−IV Change automatic transmission fluid only as necessary. Generally, to change it automatic transmission fluid only if your vehicle is driven under one of the Special your Operating Conditions “Scheduled Maintenance or “Owner’s Manual Supplement”. When changing the automatic transmission fluid, use only Toyota Genuine ATF Type T−IV (ATF JWS3309 or NWS6500) in to aid assuring optimum transaxle performance. Notice: Using automatic transmission fluid other than Toyota Genuine ATF Type T−IV may cause deterioration in shift quality, locking up of your trans- mission accompanied by vibration, and ultimately damage the automatic trans- mission of your vehicle.

AP_Camry_U (L/O 0201)

STEERING Wheel free play:

Less than 30 mm (1.2 in.)

Power steering fluid type:

Automatic transmission fluid DEXRONrII or III

BRAKES Minimum pedal clearance when depressed with the force of 490 N (50 kgf, 110 lbf) with the engine running, mm (in.):

Fixed type Adjustable type (in frontmost position)

63 (2.5)

59 (2.3)

Pedal free play, mm (in.):

Fixed type Adjustable type (in frontmost position)

1—6 (0.04—0.24)

1—8 (0.04—0.31)

Pad wear limit, mm (in.):

1.0 (0.04)

Lining wear limit, mm (in.):

1.0 (0.04)

Lever type parking brake

Parking brake adjustment when pulled with the force of 196 N (20 kgf, 44 lbf):

6—9 clicks

Pedal type parking brake

Parking brake adjustment when de- pressed with the force of 300 N (31 kgf, 67 lbf):

3—6 clicks

Fluid type:

SAE J1703 or FMVSS No.116 DOT 3

2002 MY CAMRY_U (OM33567U)

277

AP_Camry_U (L/O 0201)

Tires Tire size and pressure: Normal driving

Fuses

kPa (kgf/cm2 or bar, psi)

Tire size

Front

Rear

Wheel size

P205/65R15 92T

200 (2.0, 29)

200 (2.0, 29)

15 6 1/2 JJ

P205/65R15 92H

200 (2.0, 29)

200 (2.0, 29)

15 6 1/2 JJ

P215/60R16 94V

200 (2.0, 29)

200 (2.0, 29)

16 6 1/2 JJ

When driving under the above vehicle conditions at sustained high speeds above 160
km/h (100 mph), in countries where such speeds are permitted by−law, inflate the front and rear tires to 240 kPa (2.4 kgf/cm2 or bar, 35 psi) provided that it does not exceed the maximum cold tire pressure molded on the tire sidewall.

Compact spare tire T145/80R16 105M

kPa (kgf/cm2 or bar, psi)

450 (45, 65)

Wheel size 16 4T

Trailer driving

kPa (kgf/cm2 or bar, psi)

Tire size

P205/65R15 92T

P205/65R15 92H

P215/60R16 94V

Front

220 (2.2, 32)

220 (2.2, 32)

200 (2.0, 29)

Rear

220 (2.2, 32)

220 (2.2, 32)

200 (2.0, 29)

Wheel nut torque, N·m (kgf·m, ft·lbf):

104 (10.5, 77)

NOTE: For a complete information on tires (e.g. replacing tires or replacing wheels), see “Checking tire pressure” through “Aluminum wheel precautions”, pages 255 through 260, in Section 7−2.

Engine compartment

278

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

15. IG2 10 A: Multiport fuel injection sys- tem/sequential multiport injection system, SRS airbag system, front seat belt pretensioners, cruise control sys- tem

fuel

16. DOOR1 25 A: Multiplex communication system (power door lock system, auto− door locking system, wireless remote control system)

Engine compartment (with vehicle skid control system)

Instrument panel

Fuses (type A) 1. HEAD LH LWR 15 A: Left−hand head-

light (low beam)

2. HEAD RH LWR 15 A: Right−hand

headlight (low beam)

3. DRL 5 A: Daytime running light system 4. A/C 10 A: Air conditioning system 5. SPARE 10 A: Spare fuse 6. SPARE 15 A: Spare fuse 7. SPARE 5 A: Spare fuse 8. AM2 30 A: Starting system, “IGN” and

“IG2” fuses

9. HEAD LH UPR 10 A: Left−hand head-

light (high beam)

10. HEAD RH UPR 10 A: Right−hand

headlight (high beam)

11. ST 5 A: Multiport fuel injection system/ sequential multiport fuel injection sys- tem

12. TEL 5 A: No circuit 13. ALT−S 5 A: Charging system 14. IGN 15 A: Starting system

17. EFI 20 A: Multiport fuel injection sys- injection

tem/sequential multiport system

fuel

18. HORN 10 A: Horns 19. D.C.C 30 A: “ECU−B”, “RAD NO.1”

and “DOME” fuses

20. A/F 25 A: Multiport fuel injection sys- injection

tem/sequential multiport system

fuel

21. ETCS 10 A: Multiport

fuel

system/sequential multiport tion system

injection injec-

fuel

22. HAZ 15 A: Emergency flashers 23. ABS NO.4 7.5 A: Anti−lock brake sys- tem, vehicle skid control system, trac- tion control system, brake assist sys- tem

2002 MY CAMRY_U (OM33567U)

279

AP_Camry_U (L/O 0201)

24. ECU−B 10 A: Multiplex communication system (power door lock system, secu- rity system, auto−door locking system, automatic light control system, head- light delay off system, tail light auto cut system, illuminated entry system, daytime running light system, wireless remote control system), air conditioning system

light, personal lights,

25. DOME 7.5 A: Ignition switch light, inte- trunk light, rior vanity lights, garage door opener, clock, outside temperature gauge, mul- ti−information display

26. CIG 15 A: Cigarette lighter 27. ECU−ACC 5 A: Power rear view mir-

rors, clock, multi−information display

28. RAD NO.2 10 A: Car audio system,

navigation system

29. POWER POINT 15 A: Power outlets 30. RAD NO.1 20 A: Car audio system,

navigation system

31. GAUGE1 10 A: Gauges and meters, clock, outside temperature gauge, mul- ti−information display, shift lock system, seat belt reminder lights

32. ECU−IG 10 A: SRS airbag system, power windows, anti−lock brake system

33. WIPER 25 A: Windshield wipers 280

34. HTR 10 A: Air conditioning systems 35. MIR HTR 10 A: Outside rear view mir-

ror heaters

36. AM1 5 A: Starting system 37. FOG 15 A: Front fog lights 38. SUN−SHADE 15 A: No circuit 39. GAUGE2 10 A: Auto anti−glare inside rear view mirror, compass, electric moon roof, back−up lights, automatic transmission indicator lights, automatic light control system, cruise control sys- tem

40. PANEL 10 A: Glove box light, clock, outside temperature gauge, multi−infor- cluster mation lights, lights, over- drive−off indicator light

instrument panel

instrument

display,

41. TAIL 10 A: Tail lights, parking lights,

license plate lights

42. PWR NO.4 20 A: Rear passenger’s

power window (left side)

43. PWR NO.2 20 A: Front passenger’s front passenger’s

lock system,

door power window

44. OBD 7.5 A: On−board diagnosis sys-

tem

45. SEAT HTR 20 A: Seat heaters 46. WASHER 15 A: Windshield washer

2002 MY CAMRY_U (OM33567U)

47. FAN RLY 10 A: Electric cooling fans 48. STOP 15 A: Stop lights, high mounted system,

brake

anti−lock stoplight, cruise control system

49. FUEL OPEN 5 A: No circuit 50. DOOR NO.2 25 A: Multiplex commu- nication system (power door lock sys- tem, auto−door locking system, wire- less remote control system)

51. AMP 25 A: No circuit 52. PWR NO.3 20 A: Rear passenger’s

power window (right side)

Fuses (type B) 53. MAIN 40 A: “HEAD LH LWR”, “HEAD RH LWR”, “HEAD LH UPR”, “HEAD LH UPR” and “DRL” fuses

54. ABS NO.2 40 A: Anti−lock brake sys- tem, vehicle skid control system, trac- tion control system, brake assist sys- tem

55. RDI 30 A: Electric cooling fan 56. CDS 30 A: Electric cooling fan 57. HTR 50 A: Air conditioning system 58. ADJ PDL 30 A: Power adjustable ped-

als

AP_Camry_U (L/O 0201)

59. ABS NO.3 40 A: Anti−lock brake sys- tem, vehicle skid control system, trac- tion control system, brake assist sys- tem

60. PWR SEAT 30 A: Power seats 61. PWR NO.1 30 A: Driver’s door lock system, driver’s power window, electric moon roof

“PWR NO.1”,

62. DEF 40 A: Rear window defogger Fuses (type C) 63. ALT 100 A (with 2AZ−FE engine) or ALT 120 A (with 1MZ−FE engine): “PWR NO.2”, “DEF”, “PWR NO.3”, “STOP”, “DOOR NO.2”, “OBD”, “PWR SEAT”, “FUEL OPEN”, “FOG”, “AMP”, “PANEL”, “TAIL”, “AM1”, “CIG”, “POWER POINT”, “RAD NO.2”, “ECU−ACC”, “GAUGE1”, “GAUGE2”, “WIPER”, “WASHER”, “HTR (10 A)”, “SEAT HTR”, and “SUN−SHADE” fuses

“PWR NO.4”,

“ECU−IG”,

64. ABS NO.1 60 A: Anti−lock brake sys- tem, vehicle skid control system, trac- tion control system, brake assist sys- tem

2002 MY CAMRY_U (OM33567U)

281

AP_Camry_U (L/O 0201)

282

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

SECTION 9

REPORTING SAFETY DEFECTS FOR U.S. OWNERS AND UNIFORM TIRE QUALITY GRADING Reporting safety defects for U.S. owners Uniform tire quality grading

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

284
284

2002 MY CAMRY_U (OM33567U)

283

AP_Camry_U (L/O 0201)

To contact NHTSA, you may ei- ther call the Auto Safety Hotline toll−free at 1−800−424−9393 (or 366−0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hot- line.

Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.

campaign.

284

2002 MY CAMRY_U (OM33567U)

Uniform tire quality grading This information has been prepared in ac- cordance with regulations issued by the National Highway Traffic Safety Adminis- tration of the U.S. Department of Trans- portation. It provides the purchasers and/ or prospective purchasers of Toyota vehicles with information on uniform tire quality grading. Your Toyota dealer will help answer any questions you may have as you read this information. DOT quality grades—All passenger car tires must conform to Federal Safety Requirements these grades. Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A

in addition

to

from

treadwear grade

Treadwear—The is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150
would wear one and a half (1−1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual condi- tions of their use, however, and may de- part significantly the norm due to variations in driving habits, service prac- tices and differences in road characteris- tics and climate. Traction AA, A, B, C—The traction grades, from highest to lowest, are AA, A, B, and C, and they represent the tire’s ability to stop on wet pavement as mea- sured under controlled conditions on spe- cified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this is based on braking (straight ahead) traction tests and does not include cornering (turning) traction.

tire

AP_Camry_U (L/O 0201)

Temperature A, B, C—The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissi- pate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to de- generate and reduce tire life, and exces- sive temperature can lead to sudden tire failure. The grade C corresponds to a lev- el of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No.109. Grades B and A represent higher levels of perfor- mance on the laboratory test wheel than the minimum required by law. Warning: The temperature grades for this tire are established for a tire that is prop- erly inflated and not overloaded. Exces- sive speed, underinflation, or excessive loading, either separately or in combina- tion, can cause heat buildup and possible tire failure.

2002 MY CAMRY_U (OM33567U)

285

AP_Camry_U (L/O 0201)

286

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Quick index D If a service reminder indicator or warning buzzer comes on D If your vehicle will not start D If your engine stalls while driving D If your vehicle overheats D If you have a flat tire D If your vehicle needs to be towed D Tips for driving during break−in period D How to start the engine D General maintenance D Complete index Gas station information Fuel type:

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

99
211
214
215
216
224
181
197
238
NO TAG

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

bU 8

2AZ−FE engine: UNLEADED gasoline, Octane Rating 87 (Research Octane Number 91) or higher 1MZ−FE engine: UNLEADED gasoline, Octane Rating 87
(Research Octane Number 91) or higher. For improved vehicle performance, the use of premium unleaded gasoline with an Octane Rating of 91 (Research Octane Number 96) or higher is recommended. See page 181 for detailed information.

Fuel tank capacity:

70 L (18.5 gal., 15.4 lmp. gal.)

Engine oil:

API grade SJ “Energy−Conserving”, SL “Energy−Conserving” or multigrade engine oil is recommended. See page 251 for detailed information.

ILSAC

Automatic transmission fluid:

Automatic transmission fluid Type T−IV

Tire information: See pages 255 through 260. Tire pressure: See page 278.

2002 MY CAMRY_U (OM33567U)

Publication No. OM33567U Part No. 01999-33567
Printed in Japan 01−0112−00

U)

AP_Camry_U (L/O 0201)

WE REALLY CARE ABOUT YOU Ċ PLEASE BUCKLE UP

Toyota has made a special effort to encourage use of seat belts.

Toyota belts are:

D Comfortable D Easy to use D Convenient

We encourage you to use your belts every time you drive.

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

You should know as much about the quality and importance of proper maintenance of your new vehicle as the people who built it.

The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly perform your own maintenance.

The best way to keep your new vehicle in top running order is to maintain it properly from the moment you drive it off the showroom floor.

The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle.

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Maintenance procedures for the engine, chassis, body, electrical system, and more, are clearly explained and illustrated.

Periodic maintenance and tune−up

Periodic maintenance and tune−up helps to pre- vent small problems from growing into larger ones lat- er on. The repair manual outlines exactly what main- tenance is required and clearly explains how to do the work yourself step−by−step.

Areas covered include such things as spark plug re- placement, valve clearance adjustment and engine oil and filter replacement.

Where to obtain the

Repair Manual

The repair manual for CAMRY, written in Eng- lish, may be purchased as applicable from any Toyota dealer. Pub. Name: 2002 CAMRY Repair Manual Pub. No.: RM881U1 (Maintenance, Preparation, Service specifications and Diagnos- tics) RM881U2 (Engine, Chassis and Body)

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Foreword

Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the following pages carefully. When it comes to service, remember that your Toyota dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality maintenance and any other assistance you may require. If there is not a Toyota dealer near you, or you need emergency assistance for any reason, please call the following number:

D U.S. OWNERS: D CANADIAN OWNERS: Toyota Canada Customer Interaction Centre

Toyota Customer Assistance Center

Toll−free:1−800−331−4331
Toll−free:1−888−TOYOTA−8 (1−888−869−6828)

Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle.

© 2001 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Important information about this manual

Safety and vehicle damage warnings

Safety symbol

Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows:

CAUTION

This is a warning against something which may cause injury to people if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk to yourself and other people.

NOTICE

This is a warning against something which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.

the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”.

ii

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Important information about your Toyota

New vehicle warranty

Your new vehicle is covered by the following Toyota limited warranties:

D New vehicle warranty D Emission control systems warranty D Others

For further information, please refer to the “Owner’s War- ranty Information Booklet”, or “Owner’s Manual Supple- ment”.

Your responsibility for

maintenance

It is the owner’s responsibility to make sure that the speci- fied maintenance is performed. Section 6 gives details of these maintenance requirements. Also included in Section 6 is general maintenance. For scheduled maintenance in- formation, please refer to the “Scheduled Maintenance Guide” or “Owner’s Manual Supplement”.

Accessories, spare parts and modification of your Toyota

A wide variety of non−genuine spare parts and accessories for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these prod- ucts and is not responsible for their performance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle.

This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durability, and may even violate governmental regulations. In addi- tion, damage or performance problems resulting from the modification may not be covered under warranty.

iii

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Spark ignition system of your

Scrapping of your Toyota

If

The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt preten- sioner removed and disposed of by the qualified service shop or by your Toyota dealer before you dispose of your vehicle.

the vehicle

Toyota

The spark ignition system in your Toyota meets all require- ments of the Canadian Interference−Causing Equipment Standard.

Installation of a mobile two−way radio system

fuel

injection system/sequential multiport

As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as multiport fuel injection system, electronic throttle control system, cruise control system, anti−lock brake system, traction control system, vehicle skid control system, SRS airbag system and seat belt pretensioner system, be sure to check with your Toyota dealer for precautionary measures or special instructions regarding installation.

iv

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

SECTION 1− 1

OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls

Instrument panel overview

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Instrument cluster overview

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Indicator symbols on the instrument panel

. . . . . . . . . . . . . . . . . . . . . . .

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Instrument panel overview "With lever type parking brake

1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Center vents 5. Personal lights 6. Electric moon roof switch 7. Garage door opener 8. Auxiliary boxes 9. Power door lock switches 10. Power window switches 11. Glove box 12. Cup holder 13. Parking brake lever 14. Automatic transmission selector lever

or manual transmission gear shift lever

15. Instrument panel light control dial 16. Window lock switch 17. Power rear view mirror control switches

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

"With pedal type parking brake

1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Center vents 5. Personal lights 6. Electric moon roof switch 7. Garage door opener 8. Auxiliary boxes 9. Power door lock switches 10. Power window switches 11. Rear vents 12. Glove box 13. Cup holder 14. Automatic transmission selector lever 15. Instrument panel light control dial 16. Parking brake pedal 17. Window lock switch 18. Power rear view mirror control switches

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

"With manual air conditioning controls

1. Headlight and turn signal switch and

front fog light switch

2. Wiper and washer switches 3. Emergency flasher switch 4. Clock/outside temperature gauge and

multi−information display

5. Car audio 6. Theft deterrent system/engine

immobiliser system indicator light

7. Rear window and outside rear view

mirror defogger switch

8. Air conditioning controls 9. Power outlet 10. Seat heater switches 11. Cruise control switch 12. Ignition switch 13. Tilt steering lock release lever 14. Multi−information display control

switches

15. Hood lock release lever 16. Traction control system off switch 17. Power adjustable pedals switch

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

"With automatic air conditioning controls

1. Headlight and turn signal switch and

front fog light switch

2. Wiper and washer switches 3. Emergency flasher switch 4. Clock/outside temperature gauge and

multi−information display

5. Car audio 6. Theft deterrent system/engine

immobiliser system indicator light

7. Rear window and outside rear view

mirror defogger switch

8. Air conditioning controls 9. Power outlet 10. Seat heater switches 11. Cruise control switch 12. Ignition switch 13. Tilt steering lock release lever 14. Multi−information display control

switches

15. Hood lock release lever 16. Traction control system off switch 17. Power adjustable pedals switch

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Instrument cluster overview

1. Tachometer 2. Engine coolant temperature gauge 3. Service reminder indicators and

indicator lights

4. Speedometer 5. Fuel gauge

6. Odometer and two trip meters 7. Trip meter reset knob

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Indicator symbols on the instrument panel

or

Brake system warning light∗1

or

Anti−lock brake system warning light∗1

Driver’s seat belt reminder light∗1

Open door warning light∗1

Front passenger’s seat belt reminder light∗1

SRS warning light∗1

Discharge warning light∗1

Malfunction indicator lamp∗1

Low windshield washer fluid level warning light∗1

Vehicle skid control system and traction control system warning light∗1

Low engine oil pressure warning light∗1

Turn signal indicator lights

Low fuel level warning light∗1

Headlight high beam indicator light

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Automatic transmission indicator lights

Overdrive−off indicator light

Slip indicator light

Traction control system off indicator light

Cruise control indicator light∗2

∗1: For details, see “Service reminder buzzers” on page 99 in Section 1−5.

indicators and warning

∗2: If this light flashes, see “Cruise control” on page 118 in Sec-

tion 1−6.

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

SECTION 1− 2

OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors Keys Engine immobiliser system Side doors Power windows Trunk lid Hood Theft deterrent system Fuel tank cap Electric moon roof

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

10
13
15
23
25
27
28
30
32

2002 MY CAMRY_U (OM33567U)

AP_Camry_U (L/O 0201)

Keys (without engine immobiliser system)

Keys (with engine immobiliser system)

Your vehicle is supplied with two kinds of keys. 1. Master key—

This key works in every lock. Since the doors and trunk lid can be locked without a key, you should al- ways carry a spare master key in case you accidentally lock your keys inside the vehicle. 2. Sub key—

KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by a Toyota dealer using the key number. We recommend you to write down the key number and keep it in safe place.

This key will not work in the glove box and trunk. To protect things locked in the glove box or trunk when you have your vehi- cle at valet parking, leave the sub key with the attendant.

10

2002 MY CAMRY_U (OM33567U)

Your vehicle is supplied with two kinds of keys. 1. Master key (black)—

in every

This key works lock. Your Toyota dealer will need it to make you a new key with built−in transponder chip. Since the doors and trunk lid can be locked without a key, you should al- ways carry a spare master key in case you accidentally lock your keys inside