’00CAMRY CNG (L/O9908)
SECTION 1− 1
OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview Instrument cluster overview Indicator symbols on the instrument panel
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Instrument panel overview
1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Center vents 5. Glove box 6. Garage door opener box or
auxiliary box
7. Power door lock switches 8. Power window switches 9. Cup holders 10. Cup holder or rear ashtray 11. Parking brake lever 12. Automatic transmission selector lever 13. Auxiliary box 14. Hood lock release lever 15. Window lock switch
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
1. Power rear view mirror control switch 2. Headlight and turn signal switch 3. Wiper and washer switches 4. Clock/outside temperature gauge 5. Emergency flasher switch 6. Car audio 7. Rear window and outside rear view
mirror defoggers switch 8. Air conditioning controls 9. Front ashtray 10. Power outlet 11. Cigarette lighter 12. Ignition switch 13. Cruise control switch 14. Tilt steering lock release lever 15. Instrument panel light control knob
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Instrument cluster overview
1. Engine coolant temperature gauge 2. Service reminder indicators and
indicator lights
3. Fuel gauge
4. Speedometer 5. Odometer and two trip meters 6. Tachometer
7. Trip meter reset knob 8. Low fuel level warning light
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Indicator symbols on the instrument panel
Brake system warning light∗1
Low windshield washer fluid level warning light∗1
Seat belt reminder light∗1
Discharge warning light∗1
Malfunction indicator lamp∗1
Turn signal indicator lights
Headlight high beam indicator light
Overdrive−off indicator light
Low oil pressure warning light∗1
Cruise control indicator light∗2
Anti−lock brake system warning light∗1
Automatic transmission indicator lights
Open door warning light∗1
Rear light failure warning light∗1
SRS warning light∗1
∗1: For details, see “Service reminder indicators and warning
buzzers” in Section 1−5.
∗2: If this light flashes, see “Cruise control” in Section 1−6.
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
SECTION 1− 2
OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors Keys Side doors Power windows Trunk lid Hood Refueling
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
12
13
14
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Keys
Side doors
Your vehicle is supplied with two kinds of keys. 1. Master key—This key works in every
lock.
2. Sub key—This key will not work in the
glove box and trunk.
To protect things locked in the glove box or trunk when you have your vehicle parked, leave the sub key with the atten- dant. Since lid can be locked without a key, you should always carry a spare master key in case you accidentally lock your keys inside the ve- hicle.
the doors and
trunk
KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by your authorized Toyota CNG dealer using the key number. We recommend you to write down the key number and keep it in safe place.
LOCKING AND UNLOCKING WITH KEY Insert the key into the keyhole and turn it. To lock: Turn the key forward. To unlock: Turn the key backward. All lock and unlock simulta- neously with either front door. In the driv- er’s door lock, turning the key once will unlock the driver’s door and twice in suc- cession will unlock all the doors simulta- neously.
the doors
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
LOCKING AND UNLOCKING WITH POWER DOOR LOCK SWITCH Push the switch. To lock: Push the switch on the front side. To unlock: Push the switch on the rear side. All the doors lock or unlock simultaneous- ly.
Driver’s side
LOCKING AND UNLOCKING WITH INSIDE LOCK BUTTON Move the lock button. To lock: Push the knob forward. To unlock: Pull the knob backward. Closing the door with the lock knob in the lock position will also lock the door. Be careful not to lock your keys in the ve- hicle. The door cannot be locked if you leave the key in the ignition switch.
Passenger’s side
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Power windows
CAUTION
Before driving, be sure that the doors are closed and locked, especially when small children are in the ve- hicle. Along with the proper use of seat belts, locking the doors helps prevent the driver and passengers from being thrown out from the ve- hicle during an accident. It also helps prevent the doors from being opened unintentionally.
The windows can be operated with the switch on each door. The power windows work when the ignition switch is in the “ON” position. Key off operation: If both front doors are closed, they work for 43 seconds even after the ignition switch is turned off. They stop working when either is opened. OPERATING THE DRIVER’S WINDOW Use the switch on the driver’s door. Normal operation: The window moves as long as you hold the switch. To open: Lightly push down the switch. To close: Pull up the switch.
front door
to
the
lock
lever
the “LOCK”
REAR DOOR CHILD−PROTECTORS Move position as shown on the label. This feature allows you to lock a rear door so it can be opened from the outside only, not from inside. We recommend us- ing this feature whenever small children are in the vehicle.
10
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Window lock switch
Automatic operation (to open only): Push the switch completely down and then release it. The window will fully open. To stop the window partway, lightly pull the switch up and then release it.
THE
PASSENGERS’
OPERATING WINDOWS Use the switches on the passengers’ doors. The driver’s door also has switches that control the passengers’ windows. The window moves as long as you hold the switch. To open: Push down the switch. To close: Pull up the switch. If you push in the window lock switch on the driver’s door, the passengers’ windows cannot be operated.
2000 CAMRY CNG (OM33519U)
11
’00CAMRY CNG (L/O9908)
Trunk lid—
CAUTION
Keep the trunk lid closed while driv- ing. This not only keeps the luggage from being thrown out but also pre- vents exhaust gases from entering the vehicle.
“Luggage stowage precautions”
To open the trunk lid from the outside, insert the master key and turn it clock- wise. in See Section 2 for precautions to observe for loading luggage. To close the trunk lid, lower it and press down on it. After closing the trunk lid, try pulling it up to make sure it is securely closed.
CAUTION
To avoid serious personal injury, you must do the following. D Always make sure the head, hands and other parts of the body of all occupants are kept completely in- side the vehicle before you close the power windows. If someone’s neck, head or hands gets caught in a closing window, it could result in a serious injury. When anyone closes the power windows, be sure that they operate the windows safe- ly.
D When small children are in the ve- hicle, never let them use the power window switches without supervi- sion. Use the window lock switch to prevent from making unex- pected use of the switches.
them
D Never leave small children alone in the vehicle, especially with the igni- tion key still inserted. They could use the power window switches and in a window. Unat- get tended children can become in- volved in serious accidents.
trapped
12
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
—Lock release lever
—Luggage security system
Hood
To open the trunk lid from the driver’s seat, pull up on the lock release lever.
This system deactivates the lock re- lease lever so that things locked in the trunk can be protected. After closing the trunk lid, insert the master key and turn it counterclockwise to deactivate the lock release lever. After closing the trunk lid, try pulling it up to make sure it is securely locked.
To open the hood: 1. Pull the hood lock release lever. The
hood will spring up slightly.
CAUTION
Before driving, be sure that the hood is closed and securely locked. Other- wise, the hood may open unexpected- ly while driving and an accident may occur.
2000 CAMRY CNG (OM33519U)
13
’00CAMRY CNG (L/O9908)
CAUTION
D In order to safety refuel and avoid serious personal the CNG station staff to refuel the ve- hicle with CNG for you.
injury, ask
D Do not start the engine while refuel- ing. As the natural gas is flam- mable, an explosion or a fire could occur. Also, do not smoke or allow open flames when refueling. D If you smell or hear fuel
leaking while refueling, immediately stop re- fueling. Do not refuel it until after the leak has been repaired.
that
meets
Refueling— —Refueling precaution When refueling, you must use a special nozzle ANSI/AGA NGV−1−1994 standards. There are three types of nozzles. Use a P36 type nozzle for this vehicle. If a P36 nozzle is not available at a nearby CNG station, you may use another type of nozzle, but you cannot expect to get a completely full tank with it. For your safety, ask and follow the in- structions at the refueling station when refueling. Before starting to refuel, wipe off mud or dirt that may be deposited around the fuel receptacle. You will hear a chattering noise from the tank when it is being filled, but this is quite normal. If you hear fuel leaking from the fuel re- ceptacle, stop refueling immediately and have your authorized Toyota CNG dealer check the fuel receptacle. For information on CNG stations, refer to the station “Refueling station information” on page iii in the beginning of this manu- al.
2. In front of the vehicle, pull up the the
lever and
lift
auxiliary catch hood.
Before closing the hood, check to see that you have not forgotten any tools, rags, etc. Then lower the hood and make sure it If necessary, press down gently on the front edge to lock it.
into place.
locks
14
2000 CAMRY CNG (OM33519U)
—Refueling method (high speed refueling)
This indicates that the refueling plug door is on the left side of your vehicle.
’00CAMRY CNG (L/O9908)
There are two ways of natural gas re- fueling: high and low speed. This manu- al explains typical high speed refueling. As for the low speed refueling method, follow the manufacturer for the refueling equipments. 1. To open the refueling plug door, pull
instructions provided by
the
2. Remove the rubber cap. Check there is no mud or dirt around the fuel receptacle.
the lever up. When refueling, turn off the engine.
2000 CAMRY CNG (OM33519U)
15
’00CAMRY CNG (L/O9908)
5. Refueling will stop automatically when the tank is full. When discon- necting the filling nozzle, follow the instructions of the refueling station. Reverse the procedure to disconnect the nozzle after filling the tank. When disconnecting the filling nozzle, you may hear a brief hissing sound as a small amount of fuel escapes, but this is nor- mal.
3. Fit the filling nozzle securely on the
fuel receptacle.
There are various types of filling nozzles so follow the instructions at each CNG station.
4. Turn the valve
lever to fasten the nozzle to the fuel receptacle and to start filling the tank.
16
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
SECTION 1− 3
OPERATION OF INSTRUMENTS AND CONTROLS Seats, Seat belts, Steering wheel and Mirrors
Seats
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
18
Front seats
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
18
Head restraints
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
20
Seat belts
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
20
SRS driver and front passenger airbags
. . . . . . . . . . . . . . . . . . . . . . . .
29
Child restraint
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
36
Tilt steering wheel
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
52
Outside rear view mirrors
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
53
Anti−glare inside rear view mirror
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
54
Sun visors
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
55
2000 CAMRY CNG (OM33519U)
17
’00CAMRY CNG (L/O9908)
Seats While the vehicle is being driven, all ve- hicle occupants should have the seatback upright, sit well back in the seat and prop- erly wear the seat belts provided.
Front seats— —Seat adjustment precautions Adjust the driver’s seat so that the foot pedals, steering wheel and instrument panel controls are within easy reach of the driver.
CAUTION
CAUTION
D While adjusting the seat, do not put your hands under the seat or near the moving parts. You may catch and injure your hands or fingers.
D Do not drive the vehicle unless the occupants are properly seated. Do top of a not allow sitting on folded−down seatback, or the luggage compartment. Persons not properly seated and/or properly re- strained by seat belts can be se- verely injured in the event of emer- gency braking or a collision.
in
D During driving, do not allow pas- to stand up or move sengers around between seats. Severe inju- ries can occur in the event of emer- gency braking or a collision.
D Adjustments should not be made while the vehicle is moving, as the seat may unexpectedly move and cause the driver to lose control of the vehicle.
D When adjusting the seat, be careful not to hit the seat against a pas- senger or luggage.
D After adjusting the seat position, try sliding it forward and backward to make sure it is locked in posi- tion.
D After adjusting the seatback, exert body pressure to make sure it is locked in position.
D Do not put objects under the seats. The objects may interfere with the seat−lock mechanism or unexpect- edly push up the seat position ad- justing lever; the seat may suddenly move, causing the driver to lose control of the vehicle.
18
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
—Adjusting front seats
1. SEAT POSITION ADJUSTING LEVER Pull the lever up. Then slide the seat to the desired position with slight body pressure and release the lever. 2. SEATBACK
ADJUSTING
ANGLE
3. SEAT CUSHION HEIGHT ADJUSTING
KNOB
Turn the knob either way.
LEVER
lever up. lean back to the desired angle
Lean forward and pull the Then and release the lever.
CAUTION
To reduce the risk of sliding under the lap belt during a collision, avoid reclining the seatback any more than needed. The seat belts provide maxi- mum protection in a frontal or rear collision when the driver and the pas- senger are sitting up straight and well back If you are reclined, the lap belt may slide past your hips and apply restraint forces directly to the abdomen. Therefore, in the event of a frontal collision, the risk of personal injury may increase with increasing recline of the seat- back.
in the seats.
2000 CAMRY CNG (OM33519U)
19
’00CAMRY CNG (L/O9908)
For your safety and comfort, adjust the head restraint before driving. To raise: Pull it up. To lower: Push it down while pressing the lock release button. Front head restraint only—You can also move the head restraint forward or back- ward. If such adjustment is desired, pull or push on the top of the head restraint. The head restraint is most effective when it is close to your head. Therefore, using a cushion on the seatback is not recom- mended.
CAUTION
D Adjust the center of the head re- straint so that it is closest to the top of your ears.
D After adjusting the head restraint, make sure it is locked in position. the head re-
D Do not drive with
straints removed.
Seat belts— —Seat belt precautions Toyota strongly urges that the driver and passengers in the vehicle be properly re- strained at all times with the seat belts provided. Failure to do so could increase the chance of injury and/or the severity of injury in accidents. Child. Use a child restraint system ap- propriate for the child until the child be- comes large enough to properly wear the vehicle’s seat belts. See “Child restraint” for details. If a child is too large for a child restraint system, the child should sit in the rear seat and must be restrained using the vehicle’s seat belt. According to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat. If a child must sit in the front seat, the seat belts should be worn properly. If an accident occurs and the seat belts are not worn properly, the force of the rapid infla- tion of the airbag may cause death or serious injury to the child.
2000 CAMRY CNG (OM33519U)
Head restraints
Front
Rear
20
’00CAMRY CNG (L/O9908)
D Keep the belts clean and dry.
If they need cleaning, use a mild soap solution or lukewarm water. Never use bleach, dye, or abrasive clean- ers—they may severely weaken the belts. (See “Cleaning the interior” in Section 5.)
D Replace the belt assembly (includ- ing bolts) if it has been used in a severe impact. The entire assembly should be replaced even if damage is not obvious.
Do not allow the child to stand up or kneel on either rear or front seats. An unrestrained child could suffer serious in- jury or death during emergency braking or a collision. Also, do not let the child sit on your lap. It does not provide sufficient restraint. Pregnant woman. Toyota recommends the use of a seat belt. Ask your doctor for specific lap belt should be worn securely and as low as possible over the hips and not on the waist. Injured person. Toyota recommends the use of a seat belt. Depending on the inju- ry, first check with your doctor for specific recommendations.
recommendations. The
CAUTION
the vehicle
in their seats Persons should ride their seat belts properly wearing whenever is moving. Otherwise, they are much more likely to suffer serious bodily injury or death in the event of sudden braking or a collision. When using the seat belts, observe the following: D Use the belt for only one person at a time. Do not use a single belt for two or more people—even children. D Avoid reclining the seatbacks too much. The seat belts provide maxi- mum protection when the seatbacks are in the upright position. (Refer to the seat adjustment instructions.) D Be careful not to damage the belt webbing or hardware. Take care that they do not get caught or pinched in the seat or doors.
D Inspect the belt system periodically. Check for cuts, fraying, and loose parts. Damaged parts should be re- placed. Do not disassemble or modify the system.
2000 CAMRY CNG (OM33519U)
21
’00CAMRY CNG (L/O9908)
—Front seat belts and rear outside seat belts
If the seat belt cannot be pulled out of the retractor, firmly pull the belt and release it. You will then be able to smoothly pull the belt out of the retractor. When a passenger’s shoulder belt is com- pletely extended and retracted even slightly, the belt is locked in that position and cannot be extended. This fea- ture is used to hold the child restraint system securely. (For details, see “Child restraint” in this section.) To free the belt again, fully retract the belt and then pull the belt out once more.
then
is
Adjust the seat as needed (front seats only) and sit up straight and well back in the seat. To fasten your belt, pull it out of the retractor and insert the tab into the buckle. You will hear a click when the tab locks into the buckle. The seat belt length automatically adjusts to your size and the seat position. The retractor will lock the belt during a sudden stop or on impact. It also may lock if you lean forward too quickly. A slow, easy motion will allow the belt to extend, and you can move around freely.
CAUTION
D After inserting the tab, make sure the tab and buckle are locked and that the belt is not twisted.
D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.
D If the seat belt does not function normally, immediately contact your authorized Toyota CNG dealer. Do not use the seat until the seat belt is fixed. It cannot protect an adult occupant or your child from injury.
22
2000 CAMRY CNG (OM33519U)
Seat belts with an adjustable shoulder anchor— Adjust the shoulder anchor position to your size. To raise: Slide the anchor up. To lower: Push in the lock release button and slide the anchor down. After adjustment make sure the anchor is locked in position.
CAUTION
Always make sure the shoulder belt is positioned across the center of your shoulder. The belt should be kept away from your neck, but not falling off your shoulder. Failure to do so could reduce the amount of protection in an accident and cause serious injures in a collision.
’00CAMRY CNG (L/O9908)
CAUTION
Take up slack
Too high
lap
D High−positioned
belts
and loose−fitting belts both could cause serious injuries due to sliding un- der the lap belt during a collision or other unintended result. Keep the lap belt positioned as low on hips as possible.
Keep as low on hips as possible
D For your safety, do not place the
shoulder belt under your arm.
the
lap and
the position of
Adjust shoulder belts. Position the lap belt as low as possible on your hips—not on your waist, then ad- just it to a snug fit by pulling the shoulder portion upward through the latch plate.
2000 CAMRY CNG (OM33519U)
23
’00CAMRY CNG (L/O9908)
—Rear center seat belt
Lengthen
CAUTION
D After inserting the tab, make sure the tab and buckle are locked and that the belt is not twisted.
D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.
D If the seat belt does not function normally, immediately contact your authorized Toyota CNG dealer. Do not use the seat until the seat belt is fixed. It cannot protect an adult occupant or your child from injury.
To release the belt, press the buckle−re- lease button and allow the belt to re- tract. If the belt does not retract smoothly, pull it out and check for kinks or twists. Then make sure it remains untwisted as it re- tracts.
Sit up straight and well back in the seat. To fasten your belt, insert the tab into the buckle. You will hear a click when the tab locks into the buckle. If the belt is not long enough for you, hold the tab at a right angle to the belt and pull on the tab.
24
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Too high
Adjust to a snug fit
Keep as low on hips as possible
Remove excess length of the belt and adjust the belt position. To shorten the belt, pull the free end of the belt. Position the lap belt as low as possible on your hips—not on your waist, then ad- just it to a snug fit.
CAUTION
High−positioned and loose−fitting lap belts could cause serious injuries due to sliding under the lap belt during a collision or other unintended result. Keep the lap belt positioned as low on hips as possible.
—Seat belt extender If your seat belt cannot be fastened se- curely because it is not long enough, a personalized seat belt extender is avail- able from your authorized Toyota CNG dealer free of charge. Please contact your authorized Toyota CNG dealer so that he/she can order the proper required length for the extender. Bring to wear for proper measurement and selec- tion of length. Additional ordering informa- tion is available at your authorized Toyota CNG dealer.
the heaviest coat you expect
To release the belt, press the buckle−re- lease button.
CAUTION
When using the seat belt extender, observe the following. Failure to fol- low these instructions could result in less effectiveness of the seat belt re- straint system in case of vehicle acci- dent, increasing the chance of per- sonal injury. D Never use the seat belt extender if you can fasten the seat belt without it.
2000 CAMRY CNG (OM33519U)
25
’00CAMRY CNG (L/O9908)
CAUTION
D After inserting the tab, make sure the tab and buckle are locked and that the seat belt extender is not twisted.
D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.
D If the seat belt does not function normally, immediately contact your authorized Toyota CNG dealer. Do not use the seat until the seat belt is fixed. It cannot protect an adult occupant or your child from injury.
D Remember that the extender pro- vided for you may not be safe when used on a different vehicle, or for another person or at a different seating position than the one origi- nally intended for.
To connect the extender to the seat belt, insert the tab into the seat belt buckle so that the “PRESS” signs on the buckle−release buttons of the ex- tender and the seat belt are both facing outward as shown. You will hear a click when the tab locks into the buckle. When releasing the seat belt, press on the buckle−release button on the extender, not on the seat belt. This helps prevent damage to the vehicle interior and extend- er itself. When not and store in the vehicle for future use.
in use, remove the extender
26
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
—Front seat belt pretensioners
The driver and front passenger’s seat belt pretensioners are designed to be activated in response to a severe fron- tal impact. When the airbag sensor detects the shock of a severe frontal impact, the front seat belt is quickly drawn back in by the re- tractor so that the belt snugly restrains the front seat occupants. The seat belt pretensioners are activated even with no passenger in the front seat. Collisions occurring at certain speeds and angles may cause the seat belt preten- sioners and SRS airbags not to operate all together.
This indicator comes on when the igni- tion key is turned to the “ACC” or “ON” position. It goes off after about 6 seconds. This means the front seat belt pretensioners are operating proper- ly. This warning the airbag sensor assembly, front airbag sen- sors, seat belt pretensioner assemblies, warning interconnecting wiring and power sources. (For details, see “Service reminder indicators and warning buzzers” in Section 1−5.)
light system monitors
light,
The seat belt pretensioner system mainly consists of the following components and their locations are shown in the illustra- tion. 1. Front airbag sensors 2. SRS warning light 3. Seat belt pretensioner assemblies 4. Airbag sensor assembly The seat belt pretensioner is controlled by the airbag sensor assembly. The airbag sensor assembly consists of a safing sen- sor and airbag sensor.
2000 CAMRY CNG (OM33519U)
27
When a seat belt pretensioner is acti- vated, an operating noise may be heard and a small amount of smoke−like gas may be released. This gas is harmless and does not indicate that a fire is occur- ring. Once the seat belt pretensioner has been activated, the seat belt retractor remains locked.
CAUTION
Do not modify, remove, strike or open the front seat belt pretensioner as- semblies, airbag sensor or surround- ing area or wiring. Doing any of these may cause sudden operation of the front seat belt pretensioners or disable the system, which could re- sult in serious injury. Failure to follow these can result in serious injuries.
instructions
’00CAMRY CNG (L/O9908)
NOTICE
consulting
Do not perform any of the following changes without your authorized Toyota CNG dealer. Such interfere with proper changes can operation belt pretensioners in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player
seat
the
of
z Repairs on or near the front seat
belt retractor assemblies
z Modification of the suspension sys-
tem
z Modification of the front end struc-
ture
z Attachment of a grille guard (bull bar, kangaroo bar, etc.), snowplow, winches or any other equipment to the front end
z Repairs made on or near the front fenders, front end structure or con- sole
the
following conditions occurs,
This front seat belt pretensioner system has a service reminder indicator to inform the driver of operating problems. If either of this indicates a malfunction of the airbags or pretensioners. Contact your authorized Toyota CNG dealer as soon as possible to service the vehicle. D The light does not come on when the ignition key is turned to the “ACC” or “ON” position, or the light remains on. D The light comes on or flashes while
28
2000 CAMRY CNG (OM33519U)
driving.
D If either front seat belt does not retract or can not be pulled out due to a malfunction or activation of the preten- sioner.
D The front seat belt pretensioner assem- bly or surrounding area has been dam- aged.
D The front part of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause to operate.
the seat belt pretensioners
D The front seat belt pretensioner assem- bly is scratched, cracked, or otherwise damaged.
’00CAMRY CNG (L/O9908)
SRS driver and front passenger airbags
CAUTION
A driver or front passenger too close to the steering wheel or dashboard during airbag deployment can be killed or seriously injured. Toyota strongly recommends that: D The driver sit as far back as pos- sible from the steering wheel while still maintaining control of the ve- hicle.
D The front passenger sit as far back
as possible from the dashboard.
D All vehicle occupants be properly restrained using the available seat belts.
The SRS (Supplemental Restraint Sys- tem) airbags are designed to provide further protection for the driver and front passenger in addition to the pri- mary safety protection provided by the seat belts. In response to a severe frontal impact, the SRS airbags work together with the seat belts to help reduce injury by inflat- ing. The SRS airbags help to reduce inju- ries mainly to the driver’s or front passen- ger’s head or chest directly hitting the steering wheel or dashboard. The passen- ger airbag is activated even with no pas- senger in the front seat. Be sure to wear your seat belt.
2000 CAMRY CNG (OM33519U)
29
’00CAMRY CNG (L/O9908)
this
However, threshold velocity will be considerably higher if the vehicle strikes an object, such as a parked vehicle or sign pole, which can move or deform on impact, or if it is involved in an underride collision (e.g. a collision in which the nose of the vehicle “underrides”, or goes under, the bed of a truck, etc.). It is possible that in some collisions at the lower zone of airbag sensor detection and activation the SRS airbags and seat belt pretensioners will not operate all together. For the safety of all occupants, always wear your seat belts.
The SRS airbag system is designed to activate in response to a severe frontal impact within the shaded area between the arrows in the illustration. The SRS airbags will deploy if the severi- ty of the impact is above the designed threshold level, comparable to an approxi- mate 25 km/h (15 mph) collision when impacting straight into a fixed barrier that does not move or deform. If the severity of the impact is below the above threshold the SRS airbags may not deploy.
level,
This indicator comes on when the igni- tion key is turned to the “ACC” or “ON” position. It goes off after about 6 seconds. This means the SRS airbags are operating properly. This warning the airbag sensor assembly, front airbag sen- sors, inflators, warning light, interconnect- ing wiring and power sources. (For details, see indicators and warning buzzers” in Section 1−5.)
light system monitors
reminder
“Service
30
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Collision from the rear
Collision from the side
Hitting a curb, edge of pavement or hard material
Falling into or jumping over a deep hole
Vehicle rollover
Landing hard or vehicle falling
The SRS airbags are not designed to inflate if the vehicle is involved in a side or rear collision, if it rolls over, or if it is involved in a low−speed frontal collision.
The SRS airbags may deploy if a seri- ous impact occurs to the underside of your vehicle. Some examples are shown in the illustration.
The SRS airbag system consists mainly of the following components, and their loca- tions are shown in the illustration. 1. Front airbag sensors 2. SRS warning light 3. Airbag module
for passenger (airbag
and inflator)
4. Airbag sensor assembly 5. Airbag module for driver (airbag and
inflator)
The airbag sensor assembly consists of a safing sensor and airbag sensor.
2000 CAMRY CNG (OM33519U)
31
’00CAMRY CNG (L/O9908)
the windshield as
A crash severe enough to inflate the air- bags may break the vehicle buckles. In vehicles with a pas- senger airbag the windshield may also be damaged by absorbing some of the force of the inflating airbag.
CAUTION
D The SRS airbag system is designed only as a supplement to the prima- ry protection of the driver side and front passenger side seat belt sys- tems. The front seat occupants can be killed or seriously injured by an inflating airbag if they do not wear the available seat belts. During sud- den braking just before a collision, an unrestrained driver or front pas- senger can move forward into direct contact with or close proximity to the airbag which may then deploy during the collision. To ensure max- imum protection in an accident, the driver and all passengers in the ve- hicle must wear their seat belts. Wearing a seat belt during an acci- dent reduces the chances of death or serious injury or being thrown out of the vehicle. For instructions and precautions concerning the seat belt system, see “Seat belts” in this section.
the
fills
inflators quickly
In a severe frontal impact, sensors detect deceleration and the system triggers the airbag inflators. Then a chemical reaction in the airbags with non−toxic gas to help restrain the forward motion of the occupants. When the airbags inflate, they produce a fairly loud noise and release some smoke and residue along with non−toxic gas. This does not indicate a fire. This gas is nor- mally harmless; however, for those who have delicate skin, it may cause a minor skin irritation. Be sure to wash off any residue as soon as possible to prevent any potential skin irritation. Deployment of the airbags happens in a fraction of a second, so the airbags must inflate with considerable force. While the system is designed to reduce serious inju- ries, it may also cause minor burns or abrasions and swelling. Parts of the airbag module (steering wheel hub, dashboard) may be hot for several minutes, but the airbags themselves will not be hot. The airbags are designed to inflate only once.
32
2000 CAMRY CNG (OM33519U)
D Improperly seated and/or restrained infants and children can be killed or seriously injured by a deploying airbag. An infant or child who is too small to use a seat belt should be properly secured using a child restraint system. Toyota strongly recommends infants and children be placed in the rear seat of re- strained. The rear seat is the safest for in- structions concerning the installa- tion of a child restraint system, see “Child restraint” in this section.
the vehicle and properly
infants and children. For
that all
’00CAMRY CNG (L/O9908)
D Never put a rear−facing child re- straint system on the front seat be- cause the force of the rapid infla- tion of the passenger airbag can cause death or serious injury to the child.
Move seat fully back
D A forward−facing child restraint sys- tem should be allowed to be put on the front seat only when it is un- avoidable. Always move the seat as far back as possible, because the force of a deploying airbag could cause death or serious injury to the child.
D For
instructions concerning
the installation of a child restraint sys- tem, see “Child restraint” in this section.
2000 CAMRY CNG (OM33519U)
33
’00CAMRY CNG (L/O9908)
D Do not sit on the edge of the seat or lean over the dashboard when the vehicle is in use. The airbags inflate with considerable speed and force; you may be killed or serious- ly injured. Sit up straight and well back in the seat, and always use your seat belt.
D Do not allow a child to stand up, or to kneel on the front passenger seat. The airbag inflates with con- siderable speed and force; the child may be killed or seriously injured. D Do not hold a child on your lap or in your arms. Use a child restraint system in the rear seat. For instruc- tions concerning the installation of a child restraint system, see “Child restraint” in this section.
D Do not put objects or your pets on or in front of the dashboard or steering wheel pad that houses the airbag system. They might restrict inflation or cause death or serious injury as they are projected rear- ward by the force of deploying air- bags. Likewise, the driver and front passenger should not hold things in their arms or on their knees.
34
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
D Do not modify or remove any wir- ing. Do not modify, remove, strike or open any components such as the steering wheel pad, steering wheel, column cover, front passen- ger airbag cover, front passenger airbag or airbag sensor assembly. Doing any of these may cause sud- den SRS airbag inflation or disable the system, which could result in death or serious injury. instructions Failure to follow these can result in death or serious injury.
NOTICE
consulting
Do not perform any of the following changes without your authorized Toyota CNG dealer. Such changes can interfere with proper operation of the SRS airbag system in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player
z Modification of the suspension sys-
tem
z Modification of the front end struc-
ture
z Attachment of a grille guard (bull bar, kangaroo bar, etc.), snowplow, winches or any other equipment to the front end
z Repairs made on or near the front fenders, front end structure, con- sole, steering wheel or dashboard near the front passenger airbag
steering
column,
If either of
This SRS airbag system has a service reminder indicator to inform the driver of operating problems. the following conditions occurs, this indicates a malfunction of the airbags. Contact your authorized Toyota CNG dealer as soon as possible to service the vehicle. D The light does not come on when the ignition key is turned to the “ACC” or “ON” position, or the light remains on.
D The light comes on while driving.
2000 CAMRY CNG (OM33519U)
35
’00CAMRY CNG (L/O9908)
NOTICE
Do not disconnect the battery cables before contacting your authorized Toyota CNG dealer.
Child restraint— —Child restraint precautions Toyota strongly urges the use of child restraint systems for children small enough to use them. The laws of all fifty states in the U.S.A. and Canada now require the use of a child restraint system. Your vehicle conforms to SAEJ1819. If a child is too large for a child restraint system, the child should sit in the rear seat and must be restrained using the vehicle’s seat belt. See “Seat belts” for details.
CAUTION
D For effective protection in automo- bile accidents and sudden stops, children must be properly re- strained using a seat belt or child restraint system depending on the age and size of the child. Holding a child in your arms is not a sub- stitute for a child restraint system. In an accident, the child can be crushed against the windshield, or between you and the vehicle’s inte- rior.
In the following cases, contact your autho- rized Toyota CNG dealer as soon as pos- sible: D The SRS airbags have been inflated. D The front part of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS airbags to inflate.
D The pad section of the steering wheel or cover (shaded in the illustration) is scratched, cracked, or otherwise damaged.
passenger
airbag
front
36
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
D Toyota strongly urges use of a proper child restraint system which conforms to the size of the child, and is put on the rear seat. Accord- ing to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat. D Never put a rear−facing child re- straint system on the front seat. In the event of an accident, the force of the rapid inflation of the airbag can cause death or serious injury if a rear−facing child restraint system is put on the front seat.
D Unless it is unavoidable, do not put the
restraint system on
a child front seat.
D A forward−facing child restraint sys- tem should be allowed to be put on the front seat only when it is un- avoidable. Always move the seat as far back as possible, because the force of a deploying airbag could cause death or serious injury to the child.
D Make sure that you have complied with all installation instructions pro- vided restraint manufacturer and that the system is properly secured.
child
the
by
the manufacturer’s
—Child restraint system A child restraint system for a small child or baby must itself be properly restrained on the seat with either the lap belt or the lap portion of the lap/ shoulder belt. You must carefully con- sult instructions which accompany the child restraint system. To provide proper restraint, use a child restraint system following the manufactur- er’s instructions about the appropriate age and size of the child for the restraint sys- tem. Install the child restraint system correctly following the instructions provided by its manufacturer of the system. General di- rections are also provided under the fol- lowing illustrations. The child restraint system should be installed on the rear seat. According to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat.
2000 CAMRY CNG (OM33519U)
37
’00CAMRY CNG (L/O9908)
When not using the child restraint system, keep it secured with the seat belt or place it in the trunk or somewhere other than the passenger compartment. This will pre- vent the event of a sudden stop or accident.
injuring passengers
from
in
it
—Types of child restraint system Child restraint systems are classified into the following 3 types depending on the child’s age and size. (A) Infant seat (B) Convertible seat (C) Booster seat Install the child restraint system following the instructions provided by its manufac- turer.
CAUTION
D Never put a rear−facing child re- straint system on the front seat. In the event of an accident, the force of the rapid inflation of the airbag can cause death or serious injury if a rear−facing child restraint system is put on the front seat.
D Unless it is unavoidable, do not put the
restraint system on
a child front seat.
D A forward−facing child restraint sys- tem should be allowed to be put on the front seat only when it is un- avoidable. Always move the seat as far back as possible, because the force of a deploying airbag could cause death or serious injury to the child. D After
installing the child restraint system, make sure it is secured in place following the manufacturer’s instructions. If it is not restrained securely, it may cause death or se- rious the event of a sudden stop or accident.
the child
injury
to
in
38
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
—Installation with 2−point type seat belt
(A) Infant seat
(C) Booster seat
(A) INFANT SEAT INSTALLATION An infant seat is used in rear−facing position only.
(B) Convertible seat
2000 CAMRY CNG (OM33519U)
39
’00CAMRY CNG (L/O9908)
CAUTION
D After inserting the tab, make sure the tab and buckle are locked and that the lap belt is not twisted.
D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.
D If the seat belt does not function it cannot protect your normally, injury. Contact your child authorized Toyota CNG dealer im- mediately. Do not use the seat until the seat belt is fixed.
from
CAUTION
Do not put a rear−facing child re- straint system on the rear seat if it interferes with the lock mechanism of the front seats. This can cause severe injury to the child and front passen- ger in case of sudden braking or a collision.
1. Run
the
lap belt
the center
infant seat
through or around the instructions provided by its manufactur- er and insert the tab into the buckle taking care not to twist the lap belt.
following
40
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
2. While pressing the infant seat
firmly against the seat cushion and seatback, tighten the lap belt by pulling its free end to hold the infant seat securely.
CAUTION
3. To remove the infant seat, press the
buckle−release button.
Push and pull the child restraint sys- tem in different directions to be sure it is secure. Follow all the installation instructions provided by its manufac- turer.
2000 CAMRY CNG (OM33519U)
41
’00CAMRY CNG (L/O9908)
1. Run
lap belt
the center
through or following around its by the instructions tab into manufacturer and the buckle taking care not to twist the lap belt.
the convertible seat provided insert the
(B) CONVERTIBLE SEAT INSTALLATION A convertible seat is used in forward− facing and rear−facing position depend- ing on the child’s age and size. When installing, the manufacturer’s instructions about the applicable child’s age and size as well as directions for installing a child restraint system.
follow
CAUTION
Do not put a rear−facing child re- straint system on the rear seat if it interferes with the lock mechanism of the front seats. This can cause severe injury to the child and front passen- ger in case of sudden braking or a collision.
42
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
CAUTION
D After inserting the tab, make sure the tab and buckle are locked and that the lap belt is not twisted.
D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.
D If the seat belt does not function it cannot protect your normally, injury. Contact your child authorized Toyota CNG dealer im- mediately. Do not use the seat until the seat belt is fixed.
from
2. While pressing
the convertible seat firmly against the seat cushion and seatback, tighten the lap belt by pulling its free end to hold the convertible seat securely.
CAUTION
Push and pull the child restraint sys- tem in different directions to be sure it is secure. Follow all the installation instructions provided by its manufac- turer.
2000 CAMRY CNG (OM33519U)
43
’00CAMRY CNG (L/O9908)
—Installation with 3−point type seat belt
3. To remove the convertible seat, press
the buckle−release button.
(A) INFANT SEAT INSTALLATION An infant seat is used in rear−facing position only.
CAUTION
D Never put a rear−facing child re- straint system on the front seat be- cause the force of the rapid infla- tion of the passenger airbag can cause death or serious injury to the child.
44
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
CAUTION
D After inserting the tab, make sure the tab and buckle are locked and that the lap and shoulder portions of the belt are not twisted.
D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.
D If the seat belt does not function it cannot protect your normally, injury. Contact your child authorized Toyota CNG dealer im- mediately. Do not use the seat until the seat belt is fixed.
from
D Do not put a rear−facing child re- straint system on the rear seat if it interferes with the lock mechanism of the front seats. This can cause severe injury to the child and front passenger in case of sudden brak- ing or a collision.
1. Run the lap and shoulder belt through or around the infant seat following the instructions provided by its manufactur- er and insert the tab into the buckle taking care not to twist the belt. Keep the lap portion of the belt tight.
2000 CAMRY CNG (OM33519U)
45
’00CAMRY CNG (L/O9908)
2. Fully extend the shoulder belt to put it in the lock mode. When the belt is then retracted even slightly, it cannot be extended.
the
To hold infant seat securely, make sure the belt is in the lock mode before letting the belt retract.
3. While pressing the infant seat
firmly against the seat cushion and seatback, let the shoulder belt retract as far as it will go to hold the infant seat secure- ly.
CAUTION
Push and pull the child restraint sys- tem in different directions to be sure it is secure. Follow all the installation instructions provided by its manufac- turer.
46
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
4. To remove the infant seat, press the buckle−release button and allow the belt to retract completely. The belt will move to work for an adult or older child passen- ger.
freely again and be ready
(B) CONVERTIBLE SEAT INSTALLATION A convertible seat is used in forward− facing and rear−facing position depend- ing on the child’s age and size. When installing, follow the manufacturer’s in- structions about the applicable child’s age and size as well as directions for installing a child restraint system.
CAUTION
D Never put a rear−facing child re- straint system on the front seat be- cause the force of the rapid infla- tion of the passenger airbag can cause death or serious injury to the child.
2000 CAMRY CNG (OM33519U)
47
’00CAMRY CNG (L/O9908)
Move seat fully back
D A forward−facing child restraint sys- tem should be allowed to be put on the front seat only when it is un- avoidable. Always move the seat as far back as possible, because the force of a deploying airbag could cause death or serious injury to the child.
D Do not put a rear−facing child re- straint system on the rear seat if it interferes with the lock mechanism of the front seats. This can cause severe injury to the child and front passenger in case of sudden brak- ing or a collision.
48
2000 CAMRY CNG (OM33519U)
1. Run the lap and shoulder belt through or around the convertible seat following its the instructions manufacturer and into the buckle taking care not to twist the belt. Keep the lap portion of the belt tight.
provided insert the
by tab
’00CAMRY CNG (L/O9908)
CAUTION
D After inserting the tab, make sure the tab and buckle are locked and that the lap and shoulder portions of the belt are not twisted.
D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.
D If the seat belt does not function