1996 Pontiac Grand PRIX Owners Manual

bulb socket. Snap the electrical connector into a new bulb socket. Install the screws. Replace the socket into the housing and turn clockwise until it snaps in place. Replace the cover and pins.

6-43

Center High-Mounted Stoplamp (2-Door Models)

i y

3. Pull out the bulb.

4. Push in a new bulb. 5. Clip the bulb carrier back into place. 6. Replace the cover and screws.

1. Remove two screws and the cover. 2. Unclip the bulb carrier and pull it out.

To remove the stoplamp lens to clean the window, remove the two nuts on either side of the housing.

6-44

Center High-Mounted Stoplamp (&Door Models)

3. Lift the tabs at the

top and bottom of the socket and pull it from the housing.

4. Pull out the bulb. 5. Pushin a new bulb. 6. Push the socket back into the housing. Make sure the

tabs snap in place.

7. Replace the cover and screws.

1. Remove the two screws from the cover. 2. Pull down the cover.

6-45

Taillamps

1. Remove the plastic

retainers and pull the carpet away from the rear of the trunk.,

2. If the socket has a tab, squeeze it. Turn the socket

counterclockwise. 3. Pull out the socket. 4. Pull the bulb out of the socket. 5. Push in a new bulb. 6. Replace the socket into the housing and

turn clockwise.

7. Reposition the carpet and install the plastic retainers.

Rear Lamp Bar

5 L

L A

4. Turn the socket

counterclockwise until it pops loose from ,the housing.

1. Remove the plastic retainers and pull the carpet

away from the rear of the trunk.

2. Remove the wing nuts. 3. Pull the housing away from the body of the vehicle.

5. 6. 7. 8.

9. 10. 11.

Pull out the socket. Pull the,bulb out ofthe socket. Push in a new bulb. Replace the socket into the housing and turn clockwise. Replace the housing to the body of the vehicle: Install the wing nuts. Reposition the carpet and install the plastic retainers.

Tires We don’t make tires. Your new Pontiac comes with high-quality tires made by a leading tire manufac%urer. If you ever have questions about your tire warranty and where to obtain service, see your Pontiac Warranty booklet for details.

A CAUTION:

Poorly maintained and improperly used tires are dangerous. 0 Overloading your tires can cause

overheating as a result of too much friction. You could have an air-out and a serious accident. See “Loading Your Vehicle” in the Index.

CAUTION: (Continued)

Windshield Wiper Blade Replacement 1. Pull the windshield wiper arm away from

the windshield.

2. Lift the release clip with a screwdriver and pull the

blade off the wiper arm.

3. Push the new wiper blade securely onto the wiper arm. For information on replacement blade length and type, see “Replacement Parts” in the Index.

6-48

Underinflated tires pose the same danger as overloaded tires. The resulting accident could cause serious injury. Check all tires frequently to maintain the recommended pressure. Tire pressure should be checked when your tires are cold. Overinflated tires are more likely to be cut, punctured or broken by a sudden impact -- such as when you hit a pothole. Keep tires at the recommended pressure. Worn, old tires can cause accidents. If your tread is badly worn, or if your tires have been damaged, replace them.

InflatiIn -- Tire Pressure The Tire-Loading rnrormation label, located on the inside of the trunk lid, shows the correct inflation pressures for your tires when they’re cold. “Cold” means your vehicle has been sitting for at least three hours or driven no more than 1 mile (1.6 km).

NOTICE:

Don’t let anyone tell you that underinflation or overinflation is all right. It’s not. If your tires don’t have enough air (underinflation), you can get the following:

Too much flexing Too much heat

0 Tire overloading

Bad wear Bad handling Bad fuel economy.

If your tires have too much air (overinflation), you can get the following:

Unusual wear Bad handling Rough ride Needless damage from road hazards.

6-49

~

When to Check. Check your tires once a month or more. Don? forget your compact spare tire. It should be at 60 psi (420 @a). How to Check Use a good quality pocket-type gage to check tire pressure. You can’t tell if your tires awproperly inflated simply by looking at them. Radial tires may look properly inflated even when they’re underinflated. Be sure to put the valve caps back on the valve stems. They help prevent leaks by keeping out dirt and moisture. Tire Inspection and Rotation Tires should be inspected every 6,000 to 8,000 miles (1.0 000 to 13 000 Ian) for any signs of unusual wear. If unusual wear is present, rotate your tires as soon as pos-sible and check wheel alignment. Also check for damaged tires or wheels. See “When It’s Time for New Tires” and “Wheel Replacement” later in this section for more information.

The purpose of regular rotation is to achieve more uniform wear for all tires on the vehicle. The first rotation is the most important. See “Scheduled Maintenance Services” in the Index for scheduled rotation intervals. When rotating your tires, always use the correct rotation pattern shown here. ., !. Don’t include the compact spare tire in your I I . .( ’ ’ tire rotation.

. ,

’

.L

6-50 \

After the tires have been rotated, adjust the front and rear inflation pressures as shown on the Tire-Loading Information label. Make certain that all wheel nuts are properly tightened. See “Wheel Nut Torque” in the Index.

Rust or dirt on a wheel, or on the parts to-which it is fastened, can make wheel nuts become loose after a time. The wheel could come off and cause an accident. When you change a wheel, remove any rust or dirt from places where the wheel attaches to the vehicle. In an emergency, you can use a cloth or a paper towel to do this; but be sure to use a scraper or wire brush later, if you need to, to get all the rust or dirt ‘off. (See “Changing a Flat Tire” in the Index.)

6,’ . 1. ‘ 1 . . -. . . .,

;C

P .

Then It’s Time for New Tires

One way to tell when it’s time for new tires is to check the treadwear indicators, which will appear when your tires have only 11/16 inch (I .6 mm) or less of tread remaining.

l l .

You needknwt.re if any of the following statements are true:

~~

You can see. the indicators at three or more places around the tire. You can see cord or fabric showing through the tire’s rubber. The tread or sidewall is cracked, cut or snagged deep enough to show cord or fabric. The tire has a bump, bulge or split. The tire has a puncture, cut or other damage that can’t be repaired well because of the size or location of the damage.

6-51

Mixing tires could cause you to lose control while driving. If ,you mix tires of different sizes or types (radial and bias-belted tires), the vehicle may not handle properly, and you could have a crash. Using tires of different sizes may also cause damage to your vehicle. Be sure to use the same size and type tires on all wheels. .. i- ' '.i i.!;:; It's all right to drive with your compact spare, though. It was developed for use on your vehicle.

. ; I :*

,( '

Buying New Tires To find out what lund and size of tires you need, look at the Tire-Loading Information.labe1. The tires installed on your vehicle w a Tire Performance Criteria Specification ("PC Spec) number on each .tire's sidewall. When you get new tires, get ones with that same TPC Spec number. That way your vehicle will continue to have tires that are designed to give proper endurance, handling, speed rating, traction, ride and other things during normal sen;ice on your vehicle. If your tires have an all-season tread design, the TPC number will be followed by an "MS" (for mud and snow). If you ever replace your tires with tho'se not having a TPC Spec number, make sure they are the same size, load range, speed rating and construction type (bias, bias-belted or radial) as your original tires.

6-52

Uniform Tire Quality Grading The following information relates to the system developed by the United States National Highway Traffic Safety Administration, which grades tires by treadwear, traction and temperature performance. (This applies only to vehicles sold in the United States.) The grades are molded on the sidewalls of most passenger car tires. The Uniform Tire Quality Grading system does not apply to deep tread, winter-type snow tires, space-saver or temporary use spare tires, tires with nominal rim diameters of 10 to 12 inches (25 to 30 cm), or to some While the tires available on General Motors passenger cars and light trucks may vary with respect grades,, they must also conform to Federal safety requirements and additional General Motors Tire pavement as measured under controlled Peiformance Criteria (TPC) standards.

Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and a half (1 1/2) times as well on the-government course as a tire graded 100. The relative performance of tires depends upon the actual conditions of their use, however, and may depart significantly from the norm due to variations in driving habits, service practices and differences in road characteristics and climate.

'.'Traction -- A, B, C

limited-production tires.

to these

. .'-I

I .

;,*?;;x.,<

The traction grades, from highest to lowest, are A, B, and C, and they represent the tire's' ability to stop on wet specified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this tire is based on braking (straightahead) traction tests and does not include cornering (turning) traction.

conditioa on

6-53

Temperature -- A, B, C

The temperature grades are A (the highest), B, and C, representing h e tire's resistance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained hgh temperature can cause the material of the tire to degenerate- and reduce tire life, and excessive temperature can lead to sudden tire failure. The grade 'C corresponds to a level of performance which all passenger car tires must meet under the Federal Motor Vehicle. Safety Standard No. 109. Grades €3 and A represent higher levels of performance on the laboratory test wheel than the minimum required by law. Warning: n e temperature grade for this tire is established for a tire that is properly inflated and not overloaded. Excessive speed, underinflation, or excessive loading, either separately 'or in Combination, can cause heat buildup and possible tire failure.

Wheel Alignment and Tire Balance The wheels on your vehicle were aligned and balanced carefully at the factory to give you the longest tire life and best overall performance. In most cases, you will not need to have your wheels aligned again. However, if you notice unusual tire wear or your vehicle pulling one way or the other, the alignment may-need to be reset. If you notice your vehicle vibrating when driving on a smooth road, your wheels may need to be rebalanced. Wheel Replacement Replace any wheel *at is bent, cracked, or badly rusted or corroded. If wheel nuts keep coming loose, the wheel, wheel bolts .and wheel nuts should be replaced. If the wheel leaks air, replace it (except some aluminum wheels, which can sometimes be repaired). See your Pontiac dealer if any of these conditions exist.

Your dealer will know the kind of wheel you need. Each new wheel should have the same load-carrying capacity, diameter, width, offset and be mounted the same way as the one it replaces. If you need to replace any of your wheels,. wheel bolts or wheel nuts, replace them only with new GM original equipment parts. This way, you will be sure to have the right wheel, wheel bolts and wheel nuts for your Pontiac model.

NOTICE:

The wrong wheel can also cause problems with bearing life, brake cooling, speedometer or odometer calibration, headlamp aim, bumper height, vehicle ground clearance and tire or tire chain clearance to the body and chassis.

See "Changing a Flat Tire" in the Index\for more information.

Using the wrong replacement wheels, wheel bolts or wheel nuts on your vehicle can be dangerous. It could affect the braking and ,handling of your vehicle, make your tires lose air and make you lose control. You could have a collision in which you or others could be injured. Always use the correct wheel, wheel bolts and wheel nuts for replacement.

dangerous. You can't know how it's been used or how many miles it's been driven.~It could fail

r Eire Chai-n, - NOTICE:

If your Pontiac has P215/60R16 or P225/60R16 size tires, don’t use tire chains. They can damage your vehicle. If you have other tires, me tire chains only where legal and only when yon must. Use only SAE Class 44S’9 typd. chains that are the proper size for your tires. Instau them on the front tires and tighten them as tightly as possible with the en& securely fastened. Drive slowly and fonow the chain manufacturer’s instructions. If you can hear the chains contacting your vehicle, stop and retighten them, If the contact contimes, slow down until it stops. Driving too fast or spinning the wheels with chains on will damage your vehicle.

Appearance Care Remember, cleaning products can be hazardous. Some are toxic, Others can burst into flame if you strike a match or get them on a hot part of the vehicle. Some are dangerous if you breathe their fumes in a closed space. When you use anything from a container to clean your Pontiac, be sure to follow the manufacturer’s warnings and instructions. And always open your doors or windows when you’re cleaning the inside. Never use these to clean your vehicle: 0 Gasoline 0 Benzene Naphtha

0 Carbon Tetrachloride

Acetone Paint Thinner Turpentine

9 Lacquer Thinner 0 Nail Polish Remover They can all be hazardous - some more than others -- and they can all damage your vehicle, too.

Don't use any of these unless this manual says you can. In many uses, these will damage your vehicle:

If a ring forms after spot cleaning, clean the entire area immediately or it will set.

Alcohol Laundry Soap Bleach Reducing Agents

Cleaning the Inside of Your Pontiac to get .rid of dust and loose Use a vacuum cleaner often dirt. Wipe vinyl or leather with a clean, damp cloth. Your Pontiac dealer has two GM cleaners, a solvent-type spot lifter and a foam-type powdered cleaner. They will clean normal spots and stains very well. Do not use them on vinyl or leather. Here are some cleaning tips:

Always read the'instructions on the cleaner label.' Clean up stains as soon as you can -- before they set. Use a clean cloth or sponge, and change to a clean area often. A soft brush may be used if stains are stubborn. Use solvent-type cleaners in a well-ventilated area only. If

use them, don't saturate the stained area.

you

Using Foam-Type Cleaner on Fabric 1. Vacuum and brush the area to remove any

loose dirt.

2. Always clean a whole

trim panel or section. Mask surrounding trim along stitch or welt lines.

3. Mix Multi-Purpose Powdered Cleaner following

the directions on the container label.

4. Use suds only and apply with a clean sponge. 5. Don't saturate the material. 6. Don't rub it roughly. y. +?;= := - . . .. . .. . h 7. As soon as you've cleaned the section, use a sponge

.-.,<~, . ., ', 1 . ',-'.: ;,I>< '

- ; :i e , , '9 I

' . - ,;,:

. -~

I , ,,

,<

;i'

to remove the suds.

8. Rinse the section with a clean, wet sponge. 9. Wipe off what's left with a slightly damp paper

towel or cloth.

10. Then dry it immediately with a blow dryer. 11. Wipe with a clean cloth.

." , 7

I. ... : * -4..y> , ,.it. i , : . I ..' k., c57

' I:

Using Solvent-Qpe Cleaner on Fabric First, see if you have to use solvent-type cleaner at all. Some.spots and stains will clean off better with just water and miId soap. If you need to use a solvent:

Gently scrape excess soil from.the trim material with a clean, dull knife or scraper. Use very little 'cleaner, light pressure and clean cloths (preferably cheesecloth). Cleaning should start at the outside of the stain, "feathering" toward the center. Keep changing,to a , When you clean a stain from fabric, immediately dry the area with a blow dryer to help prevent a cleaning ring.

clean section of the cloth.

SpeciaI Cleaning Problem Greasy ar Oily S t a b Stains caused by grease, oil, butter, margarine, shoe polish, coffee with cream, chewing gum,-cosmetic creams, vegetable oils, wax crayon, tar and asphalt can be removed as follows: 1. Carefully scrape off excess stain.' 2., Follow the solvent-type instructions described earlier.

6-58

3. Shoe polish, wax crayon, tar and asphalt will stain if

left on a vehicle's seat fabric. They should be removed as soon as possible. Be careful, because the cleaner will dissolve them and may cause ,them to spread.

Non-Greasy Stains Stains caused by catsup, coffee (black), egg, fruit, fruit juice, milk, soft drinks, wine, vomit, urine and blood can be removed as follows: 1. Carefully scrape off excess stain, then sponge the

soiled area with cool water.

2. If a stain remains, follow the foam-type instructions

described earlier.

3. If an odor lingers after cleaning vomit or urine, treat the area with a waterhaking soda solution: 1 teaspoon (5 ml) of baking soda to 1 cup (250 ml) of lukewarm wate~:~,.'-~~"':~-r-'~!,: . . . ' . .' *

E% 7:- 3 - b : . - , 3 - .

4. Lf needed, clean lightly with solvent-type cleaner. Combination. Stains Stains caused by candy,'ice,cream, mayonnaise, chili sauce and unknown stains can be removed as follows:

.C \\

Carefully scrape off excess stain, then clean with cool water and allow to dry.

0 If a stain remains, clean it with solvent-type cleaner.

Cleaning Vinyl Use warm water and a clean cloth.

Rub with a clean, damp cloth to remove dirt. You may have to do it more ,than once.

0 Things like tar, asphalt and shoe polish will stain if you don't get them off quickly. Use a clean cloth and a GM Vinylhather Cleaner or an equivalent product.

Cleaning Leather Use a soft cloth with lukewarm water and a mild soap or saddle soap.

For stubborn stains, use a GM VinylLeather Cleaner or an equivalent product. Never use oils, varnishes, solvent-based or abrasive cleaners, furniture polish or shoe polish on leather. Soiled leather should be cleaned immediately. If dirt is allowed to work 'into the finish, it can harm the leather.

Cleaning the Top of the Instrument Panel Use only mild soap'and water to clean the top surfaces of the instrument panel. Sprays containing silicones or waxes may cause annoying reflections in the windshield and even make it difficult to see through the windshield under certain conditions.

Care of Safety Belts Keep belts clean and dry.

A CAUTION.

Do not bleach or dye safety belts. If you do, it may severely weaken them. In a crash, they might not be able to provide adequate protection. Clean safety belts only with mild soap and lukewarm water.

',

Glass Glass should be cleaned often. GM Glass Cleaner (GM Part No. 1050427) or a liquid household glass cleaner will remove normal tobacco smoke and dust films. Don't use abrasive cleaners on glass, because they may cause scratches. Avoid placing decals on the inside rear window, since they may have to be scraped off later. If abrasive cleaners are used on the inside of the rear window, an electric defogger element may be damaged. Any temporary license should not be attached across the defogger grid.

%

Cleaning the Outside of the Windshield and Wiper Blades If the windshield is not clear after using the windshield washer, or if the wiper blade chatters when running, wax or other material may be on the blade or windshield. Clean the outside of the windshield with GM Windshield Cleaner, Bon-Ami Powder@ (GM Part No. 105001 1). The windshield is clean if beads do not form when you rinse it with water. Clean the blade by wiping vigorously with a cloth soaked in full-strength windshield washer solvent. Then rinse the blade with water. Wiper blades should be checked on a regular basis and replaced when worn. Weatherstrips Silicone grease on weatherstrips will make them last longer, seal better, and not stick or squeak. Apply silicone grease with a clean cloth at least every six months. During very cold, damp weather more frequent application may be required. (See "Recommended and Fluids Lubricants"

in the Index.)

+&q?y-'"". : and durability. $;,p;%*

Cleaning the Outside of Your Pontiac The paint finish on your vehicle provides beauty, depth of color, gloss rqtention washing oh ~ i i c l e The best way to preserve your vehicle's finish is to keep it clean by washing it often with lukewarm or cold water. Don't wash your vehicle in the direct rays of the sun. Don't use strong soaps or chemical detergents. Use liquid hand, dish or car washing (mild detergent) soaps. Don't use cleaning agents that are petroleum based, or that contain acid or abrasives. All cleaning agents should be flushed promptly and not allowed to dry on the surface, or they could stain; Dry the finish with a soft, clean chamois or a 1 ~ 0 ~ % cotton towel to avoid surface scratches and water spotting. High pressure car washes may cause water to enter your vehicle.

Finish Care Occasional waxing or mild polishing of your Pontiac by hand may be necessary to remove residue from the paint finish. You can get GM-approved cleaning products from your dealer. (See “Appearance Care and Materials” in the Index.) Your Pontiac has a f‘basecoat/clearcoat” paint finish. The clearcoat gives more depth and gloss to the colored basecoat. Always use waxes and polishes that are non-abrasive and made for a basecoatklearcoat paint finish.

NOTICE:

Machine compounding,or aggressive polishing on a basecoatklearcoat paint finish may dull the finish or leave swirl ‘marks.

\ Foreign materials such as calcium chloride and other salts, ice melting agents, road oil and tar, tree sap, bird droppings, chemicals from industrial chimneys, etc., can damage your vehicle’s finish if they remain on painted surfaces. Wash the vehicle as soon as possible.

If necessary, use non-abrasive cleaners that are marked safe for painted surfaces to remove foreign matter. Exterior painted surfaces are subject to aging, weather and chemical fallout that can take their toll over a period of years. You can help to keep the paint finish looking new by keeping your Pontiac garaged or covered whenever possible. Aluminum Wheels (If So Equipped) Keep *your wheels clean using a soft clean cloth with mild soap and water. Rinse with clean water. After rinsing thoroughly, dry with a soft clean towel. A wax may then be applied. The surface of these wheels is similar to the painted surface of your vehicle. Don’t use strong soaps, chemicals, abrasive polishes, abrasive cleaners or abrasive cleaning brushes on them because you could damage the surface. Don’t take your vehicle through an automatic car wash that has silicon carbide tire cleaning brushes. These brushes can also damage the surface of these wheels.

6-61

Tires To clean your tires, use a stiff brush witha tire cleaner.

NOTICE:

take care to

When applying a tire dressing always wipe off any overspray or splash from all painted surfaces on the body or wheels of -the vehicle. Petroleum-based products may damage the paint finish. Sheet Metal Damage If your vehicle is damaged and requires sheet metal repair or replacement, make sure the body repair shop applies anti-corrosion material to the parts repaired or, replaced to restore corrosion protection. Finish Damage Any stme chips, fractures or deep scratches in the f i i h should be repaired right away. Bare metal will corrode quickly and may develbp into a major repair expense. Minor chips and scratches can be repaired with touch-up materials available from your dealer or other service: outlets. Larger areas of finish damage can be corrected in your dealer's body and paint shop. 6-62

i . .. . i . #

q> ' .c

Underbody Maintenance Chemicals used for ice and snow removal and dust control can collect on the underbody. If these are not removed, accelerated corrosion (rust) can occur on the underbody parts such as fuel lines, frame, floor pan and exhaust system even though they have corrosion protection. At least every spring, flush these materials from the underbody with plain water. Clean any areas where mud and other debris can collect. Dirt packed in closed areas of the frame should be loosened before being flushed. Your dealer or an underbody car washing system 'can do this for you. Chemical Paint Spotting Some weather and atmospheric conditions can create a chemical fallout. Airborne pollutants can fall upon and attack painted surfaces on your vehicle. This damage can take two forms: blotchy, ringlet-shaped discolorations, and small irregular dark spots etched into the paint surface. Although no defect in the paint job causes this, Pontiac will repair, at no charge to the owner, the surfaces of new vehicles damaged by this fallout condition within 12 months or 12,000 miles (20 0010 km) of purchase, whichever occurs first.

Appearance Care Materials Chart

~~

PART NUMBER

SIZE

DESCRIPTION

USAGE

1050004 1050 172 IO50 173 1050174 1050201 1050214 1050427

2.75 sq. ft.

16 oz. (0.473 L) 16 oz. (0.473 L) 16 oz. (0.473 L) 16 oz. (0.473 L) oz. (0.946 L) 23 oz. (0.680 L)

Tar and Road Oil Remover Chrome Cleaner and Polish

Shines vehicle without scratching Chamois

Also removes old waxes and polishes

Removes rust and corrosion Removes soil and black marks White Sidewall Tire Cleaner

Manic Mirror Cleaner Polish Vinyl and Leather Cleaner 32

Exterior cleaner and polish Spot and stain removal

Cleans grease, grime and smoke film Glass Cleaner

6-63

Vehicle Identification Number (VIN)

ld I I I1 11111111 1111 111 111111 111

Service Parts Identification Label You’ll find t h s label on your spare tire cover. It’s very helpful if you ever need to order parts. On this label is:

1.

E N G I N E A 6 .) 1 ASSEMBLY

CODE MODEL YEAR

PLANT

your VIN, the model designation,. 0 paint information, and

Tlus is the legal identifier for your Pontiac. It appears on a plate in the front corner of the instrument panel, on the driver’s side. You can see it if you look through the windshield from outside your vehicle. The VIN also appears on the Vehicle Certification and Service Parts labels and the certificates of title and registration. Engine Identification The eighth character in your VIN is the engine code. This code will help you identify your engine, specifications and replacement parts.

a list of all production options and special equipment. Be sure that this label is not removed from the vehicle. Electrical System Add-on Electrical Equipment

NOTICE:

Don’t add anything electrical to your Pontiac unless you check with your dealer first. Some electrical equipment can damage your vehicle and the damage wouldn’t be covered by your warranty. Some add-on electrical equipment can keep other components from working as they should.

~~~~

~~~~~

Your vehicle has an air bag system. Before attempting to add anything electrical to your Pontiac, see “Servicing Your Air Bag-Equipped Pontiac” in the Index. Headlamp Wiring The headlamp wiring is protected by a circuit breaker in the underhood electrical center. An electrical overload will cause the lamps to go on and’off, or in some cases to remain off. If this happens, have your headlamp system checked right away. Windshield Wipers The windshield wiper motor is protected by a circuit breaker and a fuse. If the motor overheats due to heavy snow, etc., the wiper will stop until the motor cools. If the overload is caused by some electrical problem, have it fixed. Power Windows and Other Power Options Circuit breakers in the fuse panel protect the power windows and other power accessories. When the current load is too heavy, the circuit breaker opens and closes, protecting the circuit until the problem is fixed.

Fuses and Circuit Breakers The wiring circuits in your vehicle are protected from short circuits by a combination of fuses, circuit breakers, and fusible thermal links in the wiring itself. This greatly reduces the chance of fires caused by electrical problems. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace abad fuse with a new one of the identical size and rating.

Instrument Panel Fuse Block

The fuses are in a fuse block on the passenger’s side of the instrument panel. Pull off the cover labeled FUSES to expose the fuses.

6-65

Fuse

10

11 12

13

14

Circuit Breaker

Description

Power Windows Power Seats

Description CIGARETTE LIGHTER --' Instrument Panel Cigarette Lighter DRL MDL HVAC #2 -- €WAC Control Assembly Solenoid Box HAZARD FLASHER POWER ACCESSORY #2 -- Sunroof Control Unit LOCK CONTROL -- Door Lock Relay I/P ELECTRONICS BATTERY FEED -- Chime Module, Ele'ctronic , Brake Control Module (EBCM), Theft-Deterrent Module, Radio, Radio Amplifier, Trip Computer STARTER RELAY ANTI-THEFT -- Theft-Deterrent Module ABS -- Electronic Brake Control Module (EBCM), ABS Relay HVAC BLOWER MOTOR -- Blower Motor Relay

. 2 . ..

' I- ...,.

- .

, I , 7.2:

Fuse 15

16

Description HVAC #I -- Air Temperature Valve Motor, Trip Computer, Daytime Running Lamps (DRL) Module, HVAC Control Assembly, Multifunction Lever Cruise Control Switch REAR DEFOG. -- HVAC Control Assembly Rear Window Defogger Switch

POWER

ACCESSORY

19

21 AIR 23 , 24 28

#1 -- Antenna Relay, Power Mirror Switch, Door Lock Switches, Door Handle Switches

BAG -- Air Bag System

STOPLAMPS -- TCCBrake Switch CRUISE CONTROL CTSY LAMPS -- Vanity Mirrors, I/P Courtesy Lamps, UP Compartment Lamp, Trunk Courtesy Lamp, Header Courtesy and Reading Lamp, US Lighted Rearview Mirror, Dome and Reading Lamp, Quarter Courtesy Lamps

Description

Fuse 29 30 32 37 ' 38

39

WIPER -- Wiper Switch TURN SIGNAL -- Turn Signal Flasher POWER LOCKS -- Door Lock Relay AUXILIARY POWER RADIO -- Radio, Steering Wheel Radio Switches I/P ELECTRONICS IGNITION FEED -- Headlamp Switch, Cruise Control Cut-Out Switch, Air Bag System, TCC/Brake Switch, Instrument Cluster, Chime. Module, Second-Gear Start Switch, Head-Up Display (HUD) Switch, Daytime Running Lamps (Dm) Module

Underhood Electrical Center -- Passenger’s Side

Some fuses are in the underhood electrical center on the passenger’s side of the engine compatment-

6-68

Fuse WCMPT REL Remote Trunk Release, Back-up

Description

ECM BAT,

A/C CONT TCC

Lamps Powertrain Control Module (PCM), Fuel Pump, Fuel Pump Relay, Fan Cont #1 Relay A/C CMPR Relay (VIN M only) Automatic Transaxle, Transaxle Range Switch (VIN M only)

Relay 14 15 16

17

18

Description FUEL PUMP N C CMPR FAN CONT #2 -- Secondary Cooling Fan (Passenger's Side) FAN CONT #1-- Primary Cooling Fan (Driver's Side) Ignition Relay

Fuse F/INJN ECM IGN

ELEK IGN

10 11 12

13

Description Fuel Injectors Powertrain Control Module (PCM), Mass Air Flow (MAF) Sensor (VIN X only), EGR, CCP, Oxygen Sensor, VAC CAN SW, FAN #2 Relay Electronic Ignitioin (EI) Control Module I/P Fuse Block FAN CONT #1 Relay Passenger's Side Underhood Electrical Center and I/P Fuse Blocks: Fuses 5 , 14,23 and 32 FAN CONT #2 Relay and I/P Fuse Block: Fuse 16, Power Seat Circuit Breaker D

Jnderhood Electrical Center -- Driver’s Side

000 0’00

FOG LPS PARKLPS

HORN

ABS

VAR PIS

Some fuses are in the underhood electrical center on the passenger’s side of the engine compartment.

Fuse FOG LPS PARK LPS HORN VAR P/S ABS

Description Fog Lamps Headlamp Switch Horn Relay, Underhood Lamp EVO Anti-Lock Brake System

6-70

Relay 14 15 16

Description ABS -- Anti-Lock Brake System FOG LPS HORN

Fuse 10

11

12

13

Description IGN SW2 -- IA? Fuse Block: PWR WDO and Circuit Breaker D; Passenger's Side Underhood Electrical Center: TCC and ENG EMIS Fuses IGN SWl -- I/p Fuse Block: Radio, Wiper, HVAC, ABS and Turn Signal Fuses; Passenger's Side Underhood Electrical Center: F/IJN, ECM IGN and ELEK IGN Fuses HD LPS -- 30 Amp Circuit Breaker to Headlamp Switch ABS -- ABS Relay

Replacement Bulbs Exterior Lamps Bulb Back-up ............................... Center High-Mounted Stoplamp Roof-Mountd ....................... Shelf-Mounted ........................

Number

3057

891T2 2355

. Fog 2-Door Models . . . . . . . . . . . . . . . . . H3 (GTP 880) 88 1 4-Door Models

.........................

Front Parking/Turn Signal

2-Door Models ...................... 4-Door Models

.........................

3 157NA 889

Headlamp. High-Beam

2-Door Models .................... H4352 (U) 9005 4-Door Models

........................

Exterior Lamps Headlamp. Low-B'eam

Number

Bulb

2-Door Models 4-Door Models

. . . . . . . . . . . . . . . . . . H4351 (L) . . . . . . . . . . . . . . . . . . . . . . 9006 . . . . . . . . . . . . . . . . . . . . . . 193 Headlamp. Auxiliary License Plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . 194 ......................... 3057 Light Bar. Front Light Bar Panel. Rear ...................... 194 Sidemarker. Front 2-Door Models .......................... 4-Door Models ........................ Sidemarker. Rear Stop/Tail/Turn Signal .....................

24 24NA . . . . . . . . . . . . . . . . . . . . . . . . . 194 3057

Bulb

194 . . . . . . . 161, 194, 194R

Lamps Interior

Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Center Instrument Cluster Courtesy Dome ................................. 561 Door .......................... 562 or 212-2 Instrument Panel ........................ 194 GloveBox .............................. 194 Heater and Air Conditioning Control . . . T- 1 .O, T- 1.5 High-Beam Indicator ...................... 161 Instrument Cluster Indicator . . . . . . . . . . . . . . PC 16 1 920 Luggage Compartment Reading Dome . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Inside Rearview Mirror . . . . . . . . . . . . . . . . . . . 192 Rear Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . 906 . . . . . . . . . . . . . . PC161 Turn Signal Indicator . . . . . . . . . . . . . . . . . 74 . . . . . . . . . Visor Vanity

....................

Capacities and Specifications

Automatic Transaxle Pan Removal and Replacement . . . 4 quarts (3.8 L) After Complete Overhaul . . . . . . . . 7 quarts (6.7 L) When drainingheplacing converter or auxiliary cooler; more fluid may be needed. Automatic Transaxle with Overdrive Pan Removal and Replacement . . . 7 quarts (6.7 L) After Complete Overhaul . . . . . . . 10 quarts (9.5 L) When draining/replacing converter or auxiliary cooler; more fluid may be needed. Cooling System Including Reservoir 3.1L (Code M) . . . . . . . . . . . . 11.6 quarts (10.93 L) 3.4L (Code X) . . . . . . . . . . . . . 12.3 q g m i11.65 L) Refrigerant (R-l34a), Air Conditioning* . . . . . . . . . . . . . . 2.0 pounds (0.9 1 kg) Engine Crankcase 3.1L (Code M) . . . . . . . . . . . . . . . . 4 quarts (3.8 L) 3.4L (Code X) . . . . . . . . . . . . . . . . . 5 quarts (4.7 L)

Add 1/2 quart more when the filter is changed. Fuel Tank *See “Air Conditioning Refrigerants” later in this section.

. . . . . . . . . . . . . . . . . 16.5 gallons (62.0 L)

6-73

Engine Specifications Type ........................ Displacement ................ Compression Ratio ........... Firing Order ................ Thermostat Temperature ....... Horsepower .................

3.1L (Code M) 191 err, (3.1L)

V6

9.5: 1

1-2-3-4-5-6 195°F (91 "C) 160 @ 5200

3.4L (Code X)

V6

207 CID (3.4L)

9.25: 1

1-2-3-4-5-6 195°F (91°C) 215 @ 5200

. . 107.5” (2730 mm)

. 59.5” (1512 mm) . . . 58.0” (1472 mm)

Vehicle Dimensions Wheelbase . , Tread Width Front . . . . Rear . . . . . . . . . . . . Overall Length Coupe . . . . . . . . . . . . . . . . . . 194.8” (4947 mm) Sedan ..................... 194.9” (4951 mm) Overall Width . . . . . . . . . . . . . . . . 7 1.9‘‘ (1 825 mm) Overall Height Coupe .................... 52.9” (1 341 mm) Sedan . . . . . . . . . . . . . . . . . . . . . 54.8” (1 39 1 mm)

Normal Maintenance Replacement Parts Air Cleaner Filter Engines - * * *

. . * * . *

* . * .

Battery 3.1L (Code M) ..................... 3.4L (Code X) ......................

600 CCA 690 CCA

! Engine Oil Filter

. . . . . . .

. . PF47 . . PF51

3.1L (Code M) . . . . . . . 3.4L (Code X) . . . . . . PCV Valve 3.1L (Code M) ..................... 3.4L (Code X) ...................... Radiator Cap All Engines . . . . . . . . . . . . RC27 Spark Plugs 3.1L (Code M) . . , ...... ACType41-940 Gap: 0.060” (1.52 mm) 3.4L (Code X) . . . . . . . . . . . . . . . . AC Type 41-919 Gap: 0.045” (1.14 mm)

CV892C CV895C

. . . . . . .

Windshield Wiper Blade Replacement Length ........................ Type ................................... Air Conditioning Refrigerants Not all air conditioning refrigerants are the same. If the air conditioning system in your vehicle needs refrigerant, be sure the proper refrigerant is used. If you’re not sure, ask your Pontiac dealer.

20” (508 mm) pin

6-75

'.

6-76 -

Section 7 Maintenance Schedule

IMPORTANT. KEEP ENGINE OIL AT THE PROPER

RECOMMENDED

LEVEL AND CHANGE AS This section covers the maintenance required for your Pontiac. Your vehicle needs these services to retain its safety, dependability and emission control performance.

I Protection

Introduction Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep your vehicle in good working condition, but also helps the environment. All recommended maintenance procedures are important. Improper vehicle maintenance can even affect the quality of the air we breathe. Improper fluid levels or the wrong tire inflation can increase the level of emissions from your vehicle. T~ help protect our environment, and io keep your vehicle in good condition, please maintain your vehicle properly.

7-1

How This Section is Organized The remainder of this section is divided into five parts: “Part A: Scheduled Mainterqmce Services” shows what to have done and how often. Some of these services can be complex, so unless you are technically qualified and have the necessary equipment, you should let your dealer’s service department or another qualified service center do these jobs.

Performing maintenance work on a vehicle can , be dangerous. In trying to do some jobs, you can be seriously injured. Do your own maintenance work only if you have the required know-how and the proper tools and .e@pment for the job. If you have any doubt, have a qualified technician do the work.

If you are skilled enough to do some work on your vehicle, you will probably want to get the service information GM publishes. See “Service and Owner Publications’’ in the Index.

“Part B: Owner Checks and Services” tells you what should be checked whenever you stop for fuel. It also explains what you can easily do to help keep your vehicle in good condition. “Part C: Periodic Maintenance Inspections” explains important inspections that your Pontiac dealer’s service department or another qualified service center should perform. “Part D: Recommended Fluids and Lubricants” lists some products GM recommends to help keep your vehicle properly maintained. These products, or their equivalents, should be used whether you do the work yourself or have it done. “Part E: Maintenance Record” provides a place for you to record the maintenance performed on your vehicle. Whenever any maintenance is performed, be sure to write it down in this part. This will help you determine when your next maintenance should be done. In addition, it is a good idea to keep your maintenance receipts. They may be needed to qualify your vehicle for warranty repairs.

Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we don’t know exactly how you’ll drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands or in many other ways. Because of all the different ways people use their GM vehicles, maintenance needs vary. You may even need more frequent checks and replacements than you’ll find in the schedules in this section. So please read this section and note how you drive. If you have any questions on how to keep your vehicle in good condition, see your Pontiac dealer. This part tells you the maintenance services you should have done and when you should schedule them. If you go to your dealer for your service needs, you’ll know that GM-trained and supported service people will perform the work using genuine GM parts.

The proper fluids and lubricants to use are listed in Part D. Make sure whoever services your vehicle uses these. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. These schedules are for vehicles that:

carry passengers and cargo within recommended limits. You will find these limits on your vehicle’s Tire-Loading Information label. See “Loading Your Vehicle” in the Index. are driven on reasonable road surfaces within legal driving limits. use the recommended fuel. See “Fuel” in the Index.

Selecting the Right Schedule First you’ll need to decide which of the two schedules is right for your vehicle. Here’s how to decide which schedule to follow:’

7-3

Maintenance Schedule

Short BipICity Definition

Follow the Short Trip/City Maintenance Schedule if any one of these conditions is true for your vehicle:

Most trips are less than 5 to 10 miles (8 to 16 km). This is particularly important when outside temperatures are below freezing. Most trips include extensive idling (such as frequent driving in stop-and-go traffic). Most trips are through dusty areas. You frequently tow\a trailer or use a carrier on top of your vehicle. If the vehicle is used for delivery service, police, taxi or other commercial application.

One of the reasons you should follow this schedule if you operate your vehicle under any of these conditions is that these conditions cause engine oil t,o break down soonex

Short Trip/City Intervals Every 3,000 Miles (5 000 km): Engine Oil and Filter

Change (or 3 months, whichever occurs first).

Every 6,000 Miles (10 000 km): Chassis Lubrication

At 6,000 Miles (10 000 km) -- Then Every

(or 6 months, whichever occurs first). 12,000 Miles (20 000 km): Tire Rotation.

Every 15,000 Miles (25 000 km): Air Cleaner Filter

Inspection, if driving in dusty conditions.

Every 30,000 Miles (50 000 km): Air Cleaner Filter Replacement. Fuel Tank, Cap and Lines Inspection.

Every 50,000 Miles (83 000 km): Automatic Transaxle

Service (severe conditions only). Every 60,000 Miles (100 000 km): Engine Accessory At 60,000 Miles (100 000 km) -- Then Every Drive Belt Inspection. 15,000 Miles (25 000 km): Camshaft Timing Belt Inspection (3.4L Code X engine only).

Every 100,000 Miles (166 000 km): Cooling System

Service (or every 60 months, whichever occurs first). Spark Plug Wire Inspection. Spark Plug Replacement.

These intervals only summarize maintenance services. Be sure to follow the complete maintenance schedule on the following pages.

Maintenance Schedule

Follow this maintenance schedule only if none of the conditions from the Short Trip/City Maintenance Schedule is true. Driving a vehicle with afilly warmed engine under highway conditions causes engine oil to break down slowel:

Every 7,500 Miles (12 500 km): Engine Oil and Filter Change (or every 12 months, whichever occurs first). Chassis Lubrication (or every 12 months, whchever occurs first). At 7,500 Miles (12 500 km) -- Then Every 15,000 Miles (25 000 km): Tire Rotation. Every 30,000 Miles (50 000 km): Air Cleaner Filter

Replacement. Fuel Tank, Cap and Lines Inspection. Every 50,000 Miles (83 000 km): Automatic Transaxle

Service (severe conditions only).

Drive Belt Inspection.

Every 60,000 Miles (100 000 km): Engine Accessory At 60,000 Miles (100 000 km) -- Then Every 15,000 Miles (25 000 km): Camshaft Timing Belt Inspection (3.4L Code X engine only).

Every 100,000 Miles (166 000 km): Cooling System

Service (or every 60 months, whichever occurs first). Spark Plug Wire Inspection. Spark Plug Replacement.

These intervals only summarize maintenance services. Be sure to follow the complete mainmzance schedule on the following pages.

7-5

1 Short TripKity Maintenance Schedule I

3,000 Miles (5 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

, The services shown in this schedule up to 100,000 miles (166 000 h) should be performed after 100,000 miles (166 000 km) at the same intervals. Footnotes The U.S. Environmental Protection Agency or the

California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emissim warranty or limit recall liability prior to the completion of the vehicle's useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

DATE

ACTUAL'MILEAGE SERVICED BY:

I 9,000 Miles (15 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

I Short TriplCity Maintenance Schedule .6,000 Miles (10 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

0 Lubricate steering ball joints (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. During tire rotation, check brake calipers for freedom of movement. Refer to the appropriate GM service manual for proper caliper service procedures.

ACTUAL MILEAGE SERVICED

BY:

I DATE

I ACTUAL MILEAGE [SERVICED

BY: I

7-7

12,000 Miles (20 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate steering ball joints (or every

6 months, whichever occurs' first).

15,000 Miles (25 00.0 km) Cl Change engine oil and filter (or every

3 months, whicheyer occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you 'are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service.

DATE

ACTUAL MILEAGE SERVICED

BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

_ _ _ ~

7-8

I 21,000 Miles (35 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

I Short TripKity Maintenance Schedule 18,000 Miles (30 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

0 Lubricate steering ball joints (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. During tire rotation, check brake calipers for freedom of movement. Refer to the appropriate GM service manual for proper caliper service procedures.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY

7-9

24,000 Miles (40 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

0 Lubricate steering.bal1 joints (or every

6 months, whichever occurs first).

27,000 Miles (45 OOO'km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). h Emission Control Service.

-.

DATE

ACTUAL,MILEAGE SERVICED B E

7-10

I Short Trip/City Maintenance Schedule 30,000 Miles (50 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service. Lubricate ,steering ball joints (or every 6 months, whichever occurs first).

0 Replace air cleaner filter. An Emission Control Service.

0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. During tire rotation, check brake calipers for freedom of movement. Refer to the appropriate GM service manual for proper caliper service procedures.

DATE SERVICED

ACTUAL MILEAGE

BY:

7-11

33 OQO Miles (55 000: km) 17 Change engine oil and filter (or every

> . .

~~

3 months, whichever occurs first). An Emission Control Service.

36,00( [I] Change engine oil and filter (or every

3 months, whichever occurs first). An Emimion Control Service.

0 Lubricate steering ball joints (or every

6 months, whichever occurs first).

DATE ACTUAL MILEAGE SERVICED

BY:

DATE SERVICED

ACTUAL MILEAGE

BY

I Short TripKity Maintenance Schedule 39,000 Miles (65 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

42,000 Miles (70 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate steering ball joints (or every 0 Rotate tires. See' "Tire Inspection and

6 months, whichever occurs first).

Rotation" in the Index for proper rotation pattern and additional information. During tire rotation, check brake calipers for freedom of movement. Refer to the appropriate GM service manual for proper caliper service procedures.

DATE ACTUAL

MILEAGE

SERVICED BY:

7-13

1 Short TripKity Maintenance Schednle I 45,000 Miles (75 000 km) L Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter 'if necessary. An Emission Control Sewice. f

48,000 Miles (80 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

0 Lubricate steering ball joints (or every

6 months, whichever occurs first).

I DATE

I ACTUALMILEAGE

(SERVICEDBY:

I Shbrt Trip/City Maintenance Schedule 50,000 Miles (83 000 km)

Change automatic transaxle fluid and,filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 "F (32°C) or higher.

51,000 Miles (85 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found irftaxi, police or

delivery service.

If you do nut use your vehicle under any of these conditions, the fluid andJilter do not require changing.

DATE ACTUAL MILEAGE

' SERVICED BY:

7-15

57,000 Miles (95 000 km) 0 ‘Change engine oil and filter (or every

3 months, whichever occurs fist). An Emission Control Service.

I Short Trip/City Maintenance Schedule I 54,000 Miles (90 000 km) 17 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice. Lubricate steering ball joints (or every 6 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. During tire rotation, check brake calipers for freedom of movement. Refer to the appropriate GM service manual for proper caliper service procedures.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-16

I

I Short TripKity Maintenance Schedule I 60,000 Miles (100 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

17 Lubricate steering ball joints (or every

6 months, whichever occurs first). Inspect engine accessory drive belt. An Emission Control Service.

0 Vehicles with 3.4L Code X engine only:

Inspect camshaft timing belt. An Emission Control Service.

0 Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

DATE ACTUAL MILEAGE SERVICED

BY:

63,000 Miles (105 000 km) Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Sewice.

66,000 Miles ‘(110 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

c] Lubricate steering ball joints (or every 0 Rotate tires. See “Tire Inspection and

6 months, whichever occurs first).

Rotation” in the Index for proper rotation pattern and additional information. During tire rotation, check brake calipers for freedom of movement. Refer to the appropriate GM service manual for proper caliper service procedures.

1 DATE ACTUAL

SERVICED BY: I

SERVICED BY:

DATE ACTUAL

MILEAGE

MILEAGE

I 72,000 Miles (120 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first), An Emission Control Service.

0 Lubricate steering ball joints (or every

6 months, whichever occurs first).

I Short TripKity Maintenance Schedule 69,000 Miles, (115 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE ACTUAL MILEAGE SERVICED

BY:

I Short Trip/City Maintenance Schedule

0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if , necessary. An Emission Control Service. Cl Vehicles with 3.4L Code X engine only:

Inspect camshaft timing belt. An Emission Control Service.

DATE ACTUAL'MILEAGE

SERVICED

BY:

78,000 Miles (130 000 km) 0 Change engine oil and filter (or every

3 ,months, whichever occurs first). An Emission Control Service.

0 Lubricate steering ball joints (or every 0 Rotate tires. See "Tire Inspection and

6 months, whichever occurs first).

Rotation" in the Index for proper rotation pattern and additional information. During tire rotation, check brake calipers for freedom of movement. Refer to the appropriate GM service manual for proper caliper service procedures. I ACTUAL MILEAGE

(SEWICED BY:

I DATE

1 Short Trip/City Maintenance Schedule 81,000 Miles (135 000 km)

84,000 Miles (140 000 km)

Change engine oil and filter (or every

:&++:. ;3 munths, whichever occurs' first).

.?

,..

An Emission Control Sewice.

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Lubricate steering ball joints (or every ' 6 months, whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

7-21

90,000 Miles (150 000 km)

. E l

Change engine oil and, filter (or every 3 months, whichever occurs first). An Emission Control Service.

0 Lubricate steering ball joints (or every 0 Vehicles with 3.4L Code X engine only:

6 months, whichever occurs first).

Inspect camshaft timing belt. An Emission Control Service. 0 Replace air cleaner filter. ,

An Emission Control Service.

Short Trip/City Maintenance Schedule 87,000 Miles (145 008) k 0 Change engine oil and filter (or every