2002 Chevrolet Tracker Owners Manual

3. Follow the directions on the container label. 4. Apply cleaner with a clean sponge. Don’t saturate

the material and don’t rub it roughly.

5. As soon as you’ve cleaned the section, use a sponge

to remove any excess cleaner.

6. Wipe cleaned area with a clean, water-dampened

towel or cloth.

7. Wipe with a clean cloth and let dry.

6-57

Special Fabric Cleaning Problems Stains caused by such things as catsup, coffee (black), egg, fruit, fruit juice, milk, soft drinks, vomit, urine and blood can be removed as follows: 1. Carefully scrape off excess stain, then sponge the

soiled area with cool water.

2. If a stain remains, follow the cleaner instructions

described earlier.

3. If an odor lingers after cleaning vomit or urine, treat the area with a water/baking soda solution: 1 teaspoon (5 ml) of baking soda to 1 cup (250 ml) of lukewarm water.

4. Let dry. Stains caused by candy, ice cream, mayonnaise, chili sauce and unknown stains can be removed as follows: 1. Carefully scrape off excess stain. 2. First, clean with cool water and allow to

dry completely.

3. If a stain remains, follow the cleaner instructions

described earlier.

Cleaning Vinyl Use warm water and a clean cloth. D Rub with a clean, damp cloth to remove dirt.

You may have to do it more than once.

D Things like tar, asphalt and shoe polish will stain if

you don’t get them off quickly. Use a clean cloth and a vinyl/leather cleaner. See your dealer for this product.

Cleaning Leather Use a soft cloth with lukewarm water and a mild soap or saddle soap and wipe dry with a soft cloth. Then, let the leather dry naturally. Do not use heat to dry. D For stubborn stains, use a leather cleaner. See your

dealer for this product.

D Never use oils, varnishes, solvent-based or abrasive cleaners, furniture polish or shoe polish on leather.

D Soiled or stained leather should be cleaned

immediately. If dirt is allowed to work into the finish, it can harm the leather.

6-58

Cleaning the Top of the Instrument Panel Use only mild soap and water to clean the top surfaces of the instrument panel. Sprays containing silicones or waxes may cause annoying reflections in the windshield and even make it difficult to see through the windshield under certain conditions. Cleaning Interior Plastic Components Use only a mild soap and water solution on a soft cloth or sponge. Commercial cleaners may affect the surface finish. Care of Safety Belts Keep belts clean and dry.

CAUTION:

Do not bleach or dye safety belts. If you do, it may severely weaken them. In a crash, they might not be able to provide adequate protection. Clean safety belts only with mild soap and lukewarm water.

Cleaning Glass Surfaces Glass should be cleaned often. GM Glass Cleaner or a liquid household glass cleaner will remove normal tobacco smoke and dust films on interior glass. See “Appearance Care and Materials” in the Index.

NOTICE:

Don’t use abrasive cleaners on glass, because they may cause scratches. Avoid placing decals on the inside rear window, since they may have to be scraped off later. If abrasive cleaners are used on the inside of the rear window, an electric defogger element may be damaged. Any temporary license should not be attached across the defogger grid.

6-59

Cleaning the Outside of the Windshield, Backglass and Wiper Blades If the windshield is not clear after using the windshield washer, or if the wiper blade chatters when running, wax, sap or other material may be on the blade or windshield. Clean the outside of the windshield with a full-strength glass cleaning liquid. The windshield is clean if beads do not form when you rinse it with water. Grime from the windshield will stick to the wiper blades and affect their performance. Clean the blade by wiping vigorously with a cloth soaked in full-strength windshield washer solvent. Then rinse the blade with water. Check the wiper blades and clean them as necessary; replace blades that look worn. Weatherstrips Silicone grease on weatherstrips will make them last longer, seal better, and not stick or squeak. Apply silicone grease with a clean cloth at least every six months. During very cold, damp weather more frequent application may be required. See “Recommended Fluids and Lubricants” in the Index.

Cleaning the Outside of Your Vehicle The paint finish on your vehicle provides beauty, depth of color, gloss retention and durability. Washing Your Vehicle The best way to preserve your vehicle’s finish is to keep it clean by washing it often with lukewarm or cold water. Don’t wash your vehicle in the direct rays of the sun. Use a car washing soap. Don’t use strong soaps or chemical detergents. Be sure to rinse the vehicle well, removing all soap residue completely. You can get GM-approved cleaning products from your dealer. See “Appearance Care and Materials” in the Index. Don’t use cleaning agents that are petroleum based, or that contain acid or abrasives. All cleaning agents should be flushed promptly and not allowed to dry on the surface, or they could stain. Dry the finish with a soft, clean chamois or an all-cotton towel to avoid surface scratches and water spotting. High pressure car washes may cause water to enter your vehicle.

6-60

Cleaning Exterior Lamps/Lenses Use only lukewarm or cold water, a soft cloth and a car washing soap to clean exterior lamps and lenses. Follow instructions under “Washing Your Vehicle.” Finish Care Occasional waxing or mild polishing of your vehicle by hand may be necessary to remove residue from the paint finish. You can get GM-approved cleaning products from your dealer. See “Appearance Care and Materials” in the Index. Your vehicle has a “basecoat/clearcoat” paint finish. The clearcoat gives more depth and gloss to the colored basecoat. Always use waxes and polishes that are non-abrasive and made for a basecoat/clearcoat paint finish.

NOTICE:

Machine compounding or aggressive polishing on a basecoat/clearcoat paint finish may dull the finish or leave swirl marks.

Foreign materials such as calcium chloride and other salts, ice melting agents, road oil and tar, tree sap, bird droppings, chemicals from industrial chimneys, etc., can damage your vehicle’s finish if they remain on painted surfaces. Wash the vehicle as soon as possible. If necessary, use non-abrasive cleaners that are marked safe for painted surfaces to remove foreign matter. Exterior painted surfaces are subject to aging, weather and chemical fallout that can take their toll over a period of years. You can help to keep the paint finish looking new by keeping your vehicle garaged or covered whenever possible.

6-61

The plastic windows are pliable and can be scratched if you don’t take these precautions when you clean them: D Wipe off dust with a soft cotton cloth moistened with

clean, cool or lukewarm water. Don’t use a “dry” cloth. Wipe in one direction only, not back and forth.

D To remove frost, snow or ice, use lukewarm water.

Don’t use a scraper or any de-icing fluids.

D Wash the windows with a soft cloth and clean, cool or lukewarm water. Never use a dry cloth, hot water, strong soap or detergent, solvents or harsh cleaning agents. Rinse thoroughly and wipe with a slightly moist soft, clean cloth.

D Don’t put any labels, stickers or tape on windows.

It’s hard to remove adhesives left on the window when such items are removed. If a sticker or label must be removed, remove any adhesive left on the window while the adhesive is still soft and sticky. Press on a new sticker or piece of tape and then lift it off again; keep doing this until all the adhesive lifts off with the sticker or tape.

Special Care for Canvas Top and Plastic Windows Your canvas top should be cleaned often. If you use an automatic car wash, use one with water jets and hanging cloths. High pressure car washes may cause water to enter your vehicle. When you hand wash the top, do it in partial shade. Use a mild soap, lukewarm water and a soft sponge. A chamois or cloth may leave lint on the top, and a brush can chafe the threads in the top fabric. Don’t use detergents, harsh cleaners, solvents or bleaching agents. Wet the entire vehicle and wash the top evenly to avoid spots or rings. Let the soap remain on the fabric for a few minutes. When the top is really dirty, use a mild foam-type cleaner. Thoroughly rinse the entire vehicle, then let the top dry in direct sunlight. To protect the canvas top: D After you wash the vehicle, make sure the top is

completely dry before you open or remove it.

D Don’t get any vinyl cleaner on the vehicle’s painted

finish; it could leave streaks.

D If you decide to go through an automatic car wash,

ask the manager if the equipment could damage your top.

6-62

Cleaning Aluminum Wheels (If Equipped) Keep your wheels clean using a soft clean cloth with mild soap and water. Rinse with clean water. After rinsing thoroughly, dry with a soft clean towel. A wax may then be applied. The surface of these wheels is similar to the painted surface of your vehicle. Don’t use strong soaps, chemicals, abrasive polishes, abrasive cleaners, cleaners with acid or abrasive cleaning brushes on them because you could damage the surface. Do not use chrome polish on aluminum wheels. Don’t take your vehicle through an automatic car wash that has silicon carbide tire cleaning brushes. These brushes can also damage the surface of these wheels.

Cleaning Tires To clean your tires, use a stiff brush with a tire cleaner.

NOTICE:

When applying a tire dressing always take care to wipe off any overspray or splash from all painted surfaces on the body or wheels of the vehicle. Petroleum-based products may damage the paint finish and tires.

Sheet Metal Damage If your vehicle is damaged and requires sheet metal repair or replacement, make sure the body repair shop applies anti-corrosion material to the parts repaired or replaced to restore corrosion protection. Original manufacturer replacement parts will provide the corrosion protection while maintaining the warranty.

6-63

Chemical Paint Spotting Some weather and atmospheric conditions can create a chemical fallout. Airborne pollutants can fall upon and attack painted surfaces on your vehicle. This damage can take two forms: blotchy, ringlet-shaped discolorations, and small irregular dark spots etched into the paint surface. Although no defect in the paint job causes this, Chevrolet will repair, at no charge to the owner, the surfaces of new vehicles damaged by this fallout condition within 12 months or 12,000 miles (20 000 km) of purchase, whichever occurs first.

Finish Damage Any stone chips, fractures or deep scratches in the finish should be repaired right away. Bare metal will corrode quickly and may develop into a major repair expense. Minor chips and scratches can be repaired with touch-up materials available from your dealer or other service outlets. Larger areas of finish damage can be corrected in your dealer’s body and paint shop. Underbody Maintenance Chemicals used for ice and snow removal and dust control can collect on the underbody. If these are not removed, accelerated corrosion (rust) can occur on the underbody parts such as fuel lines, frame, floor pan and exhaust system even though they have corrosion protection. At least every spring, flush these materials from the underbody with plain water. Clean any areas where mud and other debris can collect. Dirt packed in closed areas of the frame should be loosened before being flushed. Your dealer or an underbody car washing system can do this for you.

6-64

GM Vehicle Care/Appearance Materials

6-65

Vehicle Identification Number (VIN)

This is the legal identifier for your vehicle. It appears on a plate in the front corner of the instrument panel, on the driver’s side. You can see it if you look through the windshield from outside your vehicle. The VIN also appears on the Vehicle Certification and Service Parts labels and the certificates of title and registration.

Engine Identification The 8th character in your VIN is the engine code. This code will help you identify your engine, specifications and replacement parts.

Service Parts Identification Label You’ll find this label inside the glove box on the door. It’s very helpful if you ever need to order parts. On this label is: D your VIN, D the model designation, D paint information and D a list of all production options and

special equipment.

Be sure that this label is not removed from the vehicle.

6-66

Electrical System Add-On Electrical Equipment

NOTICE:

Don’t add anything electrical to your vehicle unless you check with your dealer first. Some electrical equipment can damage your vehicle and the damage wouldn’t be covered by your warranty. Some add-on electrical equipment can keep other components from working as they should.

Your vehicle has an air bag system. Before attempting to add anything electrical to your vehicle, see “Servicing Your Air Bag-Equipped Vehicle” in the Index.

Fuses and Circuit Breakers The wiring circuits in your vehicle are protected from short circuits by fuses, circuit breakers and thermal links in the wiring itself. This greatly reduces the chance of fires caused by electrical problems. Look at the copper-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace a bad fuse with a new one of the correct size. If you ever have a problem on the road and don’t have a spare fuse, you can borrow one. Just pick some feature of your vehicle that you can get along without -- like the radio or cigarette lighter -- and use its fuse, if it is the size you need. Replace it as soon as you can. Before replacing a fuse, turn every vehicle electrical switch off. There are two fuse blocks in your vehicle: the instrument panel fuse block and the engine compartment fuse block.

6-67

Instrument Panel Fuse Block

Fuse P/W DOM TAIL

HAZ IG

CIG

Usage Power Windows Dome Light, Radio Memory License Plate Light, Clearance/Marker Lights, Instrument Panel Illumination, Warning Tone Hazard Lights, Turn Signal O2 Sensor Heater, Cruise Control, Ignition Coil, Meter, G Sensor Cigar/Cigarette Lighter, Radio, Power Mirror

This fuse block is located under the driver’s side of the instrument panel. The fuses here protect each separate circuit including headlamps. There are spare fuses inside the fuse box. If you have electrical failure, check here first.

6-68

Fuse D/L STP

FOG DEF

S/H TRN

WIP

Usage Door Locks Brake Light, Horn, Center High-Mounted Stop Lamp, Cruise Control Not Used Rear Window Defogger, DRL, Heater, Air Conditioning Not Used Turn Signal, Back-Up Light, Hazard Lights Windshield Wiper/Washer, Rear Window Wiper/Washer

Fuses for the air bags are located next to the instrument panel fuse block.

Engine Compartment Fuse Block

The engine compartment fuse block is located in the engine compartment on the passenger’s side of the vehicle and protects all electrical loads. See “Engine Compartment Overview” in the Index for more information on location. For access to the main fuses, pull off the cover.

6-69

Fuse Usage

10

Cigar Lighter, Radio, I.G. Coil, Meter, Wiper, Washer, Rear Defroster, Turn Signals, Back-Up Lamps Anti-Lock Brake System All Electrical Loads Air Conditioning

Replacement Bulbs Lamps Back-up Lamp Front Parking and Turn Signal Headlamp (Halogen)

. . . . . . . . . . . . . . . . . . . . . . . . . . .

Bulb Number 921
1157 NA

. . . . . . . . . . .

High Beam

. . . . . . . . . . . . .

Low Beam

. . . . . . . . . . . . . .

Rear Hazard and Turn Signal Rear Parking and Brake

. . . . .

GM Part No. 91174685
or equivalent GM Part No. 91174687
or equivalent 921
GM Part No. 91174349
or equivalent 194

. . . . . . . . . . . . . . . .

Sidemarker

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Fuse Usage

Accessory Power Outlet Electronic Fuel Injection System Right Headlamp Left Headlamp, High-Beam Indicator Heater Hazard Lamps, Rear Combination Lamps, Dome Light, Horn

6-70

For any bulb not listed here contact your dealer.

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Capacities and Specifications The following approximate capacities are given in English and metric conversions. Cooling System 1.6L Engine (Canada Only) 2.0L Engine 2.5L Engine Engine Oil with Filter 1.6L Engine (Canada Only) 2.0L Engine 2.5L Engine Fuel Tank Two-Door Convertible Four-Door Hardtop

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

. . . . . . . . . . . .

4.4 quarts (4.2 L)** 5.5 quarts (5.2 L)** 5.8 quarts (5.5 L)**

5.8 quarts (5.5 L) 6.9 quarts (6.5 L) 8.5 quarts (8.0 L)

14.8 U.S. gallons (56 L) 16.9 U.S. gallons (64 L)

. . . . . . . . . . . . . .

. . . . . . . . . . . . . . . . . . . . . . . .

2.6 quarts (2.5 L)*

1.6 quarts (1.5 L)* 2.0 quarts (1.9 L)*

Automatic Transmission Drain and Refill Manual Transmission Four-Wheel Drive Two-Wheel Drive Differential Front Rear Transfer Case

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

1.1 quarts (1.0 L)* 2.3 quarts (2.2 L)* 1.8 quarts (1.7 L)

*Recheck fluid level after filling. See “Automatic Transmission Fluid” or “Manual Transmission Fluid” in the Index. **When changing the oil filter, additional oil may be needed. Recheck the oil level after filling. See “Engine Oil” in the Index.

6-71

Engine Specifications 1.6L Engine Specifications (Canada Only) VIN Engine Code . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Type

L4

2.0L Engine Specifications VIN Engine Code Type

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

L4

2.5L Engine Specifications VIN Engine Code Type

. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

V6

Air Conditioning Refrigerant Capacity If you do your own service work, you’ll need the proper service manual. See “Doing Your Own Service Work” in the Index for additional information. It is recommended that service work on your air conditioning system be performed by a qualified technician. Air Conditioning

Refrigerant R134a

. . . . . . . . . . . . .

0.9 lbs. (0.4 kg)

Use Referigant Oil, R134a Systems

Wheel and Tires Wheel Nut Torque Tire Pressure

. . . . . . . . . . . . . .

. . . . . . . . . . . . .

69 lb-ft (95 N·m) See the Tire-Loading Information label. See “Loading Your Vehicle” in the Index.

6-72

Normal Maintenance Replacement Parts Engine Air Cleaner/Filter

. . . .

GM Part No. 30025009
or equivalent

Engine Oil Filter

1.6L Engine (Canada Only) 2.0L Engine

. . . . . . . . . . . . .

. . . . . . . . . . . . .

2.5L Engine

. . . . . . . . . . . . .

Passenger Compartment

Air Filter

. . . . . . . . . . . . . . .

GM Part No. 25011520
or equivalent (PF-53) GM Part No. 91173772
or equivalent GM Part No. 91176162
or equivalent

GM Part No. 91175923
or equivalent

PCV Valve

1.6L Engine (Canada Only) 2.0L Engine

. . . . . . . . . . . . .

. . . . . . . . . . . . .

. . . . . . . . . . . . .

2.5L Engine

Spark Plugs

1.6L Engine (Canada Only)

2.0L/2.5L Engine

GM Part No. 96068664
or equivalent GM Part No. 91174516
or equivalent GM Part No. 91176183
or equivalent

. . . . . . . . . . . .

GM Part No. 91173854, 91176053 or 91173855
DENSO SK20PR-A11 or NGK IFR6E11
Gap: 0.043 inch (1.1 mm) GM Part No. 91176020, 91173854 or 91173855
DENSO SK16PR11 or NGK IFR5J11
Gap: 0.043 inch (1.1 mm)

. . . . . . .

6-73

Section 7 Maintenance Schedule

This section covers the maintenance required for your vehicle. Your vehicle needs these services to retain its safety, dependability and emission control performance.

7-2
7-4
7-9
7-30

Introduction Part A: Scheduled Maintenance Services Short Trip/City Scheduled Maintenance Long Trip/Highway Scheduled Maintenance

7-44
7-49
7-51
7-54

Part B: Owner Checks and Services Part C: Periodic Maintenance Inspections Part D: Recommended Fluids and Lubricants Part E: Maintenance Record

7-

7-1

Introduction Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep your vehicle in good working condition, but also helps the environment. All recommended maintenance procedures are important. Improper vehicle maintenance can even affect the quality of the air we breathe. Improper fluid levels or the wrong tire inflation can increase the level of emissions from your vehicle. To help protect our environment, and to keep your vehicle in good condition, please maintain your vehicle properly. Maintenance Requirements Maintenance intervals, checks, inspections and recommended fluids and lubricants as prescribed in this manual are necessary to keep your vehicle in good working condition. Any damage caused by failure to follow recommended maintenance may not be covered by warranty.

Have you purchased the GM Protection Plan? The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet or your dealer for details.

7-2

How This Section is Organized This maintenance schedule is divided into five parts: “Part A: Scheduled Maintenance Services” explains what to have done and how often. Some of these services can be complex, so unless you are technically qualified and have the necessary equipment, you should let your dealer’s service department or another qualified service center do these jobs.

CAUTION:

Performing maintenance work on a vehicle can be dangerous. In trying to do some jobs, you can be seriously injured. Do your own maintenance work only if you have the required know-how and the proper tools and equipment for the job. If you have any doubt, have a qualified technician do the work.

If you want to get the service information, see “Service and Owner Publications” in the Index.

“Part B: Owner Checks and Services” tells you what should be checked and when. It also explains what you can easily do to help keep your vehicle in good condition. “Part C: Periodic Maintenance Inspections” explains important inspections that your dealer’s service department or another qualified service center should perform. “Part D: Recommended Fluids and Lubricants” lists some recommended products necessary to help keep your vehicle properly maintained. These products, or their equivalents, should be used whether you do the work yourself or have it done. “Part E: Maintenance Record” is a place for you to record and keep track of the maintenance performed on your vehicle. Keep your maintenance receipts. They may be needed to qualify your vehicle for warranty repairs.

7-3

Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we don’t know exactly how you’ll drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands or in many other ways. Because of all the different ways people use their vehicles, maintenance needs vary. You may need more frequent checks and replacements. So please read the following and note how you drive. If you have any questions on how to keep your vehicle in good condition, see your dealer. This part tells you the maintenance services you should have done and when you should schedule them. If you go to your dealer for your service needs, you’ll know that GM-trained and supported service people will perform the work using genuine GM parts.

7-4

The proper fluids and lubricants to use are listed in Part D. Make sure whoever services your vehicle uses these. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. These schedules are for vehicles that: D carry passengers and cargo within recommended limits. You will find these limits on your vehicle’s Tire-Loading Information label. See “Loading Your Vehicle” in the Index.

D are driven on reasonable road surfaces within legal

driving limits.

D are driven off-road in the recommended

manner. See “Off-Road Driving With Your Four-Wheel-Drive Vehicle” in the Index. D use the recommended fuel. See “Fuel” in

the Index.

Selecting the Right Schedule First you’ll need to decide which of the two schedules is right for your vehicle. Here’s how to decide which schedule to follow:

Scheduled Maintenance

Short Trip/City Definition

Short Trip/City Intervals

Follow the Short Trip/City Scheduled Maintenance if any one of these conditions is true for your vehicle: D Most trips are less than 5 miles (8 km). This is

particularly important when outside temperatures are below freezing.

D Most trips include extensive idling (such as frequent

driving in stop-and-go traffic).

D You frequently tow a trailer or use a carrier on top

of your vehicle.

D If the vehicle is used for delivery service, police, taxi

or other commercial application.

One of the reasons you should follow this schedule if you operate your vehicle under any of these conditions is that these conditions cause engine oil to break down sooner.

Every 3,000 Miles (5 000 km): Engine Oil and Filter

Change (or 3 months, whichever occurs first).

Every 6,000 Miles (10 000 km): Passenger

Compartment Air Filter Inspection (If Equipped). Tire Rotation.

Every 15,000 Miles (25 000 km): Engine Air Cleaner

Filter Inspection, if driving in dusty conditions. Front Wheel Bearing Repack (2WD only) (or at each brake relining, whichever occurs first). Automatic Transmission Service (severe conditions only). Manual Transmission Fluid Change. Transfer Case Fluid Change. Differential Fluid Change. Valve Lash (Clearance) Adjustment (1.6L Code 6 engine only). Propeller Shafts and U-Joints Inspection (or every 15 months, whichever occurs first).

(Continued)

7-5

Scheduled Maintenance

Short Trip/City Intervals

Short Trip/City Intervals

Every 30,000 Miles (50 000 km): Engine Air Cleaner

Filter Replacement. Passenger Compartment Air Filter Replacement (If Equipped). Ignition Coil Plug Cap Inspection (or every 30 months, whichever occurs first). Engine Accessory Drive Belt Inspection (or every 30 months, whichever occurs first). Cooling System Service (or every 30 months, whichever occurs first). Fuel Tank, Cap and Lines Inspection. Fuel Filter Replacement (or every 30 months, whichever occurs first).

Every 45,000 Miles (75 000 km): Automatic

Transmission Fluid Hose Inspection (or every 45 months, whichever occurs first).

Every 60,000 Miles (100 000 km): Fuel Tank Cap

Gasket Replacement. Emission System Hoses Inspection. Camshaft Timing Belt Replacement (1.6L Code 6 engine only). Brake Fluid Service. Spark Plug Replacement. Spark Plug Wire Replacement (or every 60 months, whichever occurs first).

At 90,000 Miles (150 000 km): Camshaft Timing Belt

Inspection (1.6L Code 6 engine only).

Every 100,000 Miles (166 000 km): Automatic

Transmission Service (normal conditions).

Every 120,000 Miles (200 000 km): Evaporative

Emissions Canister and Air Suction Filter Replacement (or every 120 months, whichever occurs first). Engine Accessory Drive Belt Replacement (or every 120 months, whichever occurs first).

These intervals only summarize maintenance services. Be sure to follow the complete scheduled maintenance on the following pages.

7-6

Scheduled Maintenance

Long Trip/Highway Definition

Long Trip/Highway Intervals

Follow this scheduled maintenance only if none of the conditions from the Short Trip/City Scheduled Maintenance are true. Do not use this schedule if the vehicle is used for trailer towing, driven in a dusty area or used off paved roads. Use the Short Trip/City schedule for these conditions. Driving a vehicle with a fully warmed engine under highway conditions will cause engine oil to break down slower.

Every 7,500 Miles (12 500 km): Engine Oil and Filter

Change (or every 7.5 months, whichever occurs first). Tire Rotation.

Every 15,000 Miles (25 000 km): Automatic

Transmission Service (severe conditions only). Passenger Compartment Air Filter Inspection (If Equipped). Valve Lash (Clearance) Adjustment (1.6L Code 6 engine only). Propeller Shafts and U-Joints Inspection (or every 15 months, whichever occurs first).

7-7

Scheduled Maintenance

Long Trip/Highway Intervals

Long Trip/Highway Intervals

Every 30,000 Miles (50 000 km): Engine Accessory

Drive Belt Inspection (or every 30 months, whichever occurs first). Cooling System Service (or every 30 months, whichever occurs first). Fuel Tank, Cap and Lines Inspection. Engine Air Cleaner Filter Replacement. Passenger Compartment Air Filter Replacement (If Equipped). Ignition Coil Plug Cap Inspection (or every 30 months, whichever occurs first). Front Wheel Bearing Repack (2WD only) (or at each brake relining, whichever occurs first). Manual Transmission Fluid Change. Transfer Case Fluid Change. Differential Fluid Change. Fuel Filter Replacement (or every 30 months, whichever occurs first).

Every 45,000 Miles (75 000 km): Automatic

Transmission Fluid Hose Inspection (or every 45 months, whichever occurs first).

Every 60,000 Miles (100 000 km): Fuel Tank Cap

Gasket Replacement. Emission System Hoses Inspection. Camshaft Timing Belt Replacement (1.6L Code 6 engine only). Spark Plug Replacement. Spark Plug Wire Replacement (or every 60 months, whichever occurs first) (1.6L Code 6 engine only). Brake Fluid Service.

At 90,000 Miles (150 000 km): Camshaft Timing Belt

Inspection (1.6L Code 6 engine only).

Every 100,000 Miles (166 000 km): Automatic

Transmission Service (normal conditions).

Every 120,000 Miles (200 000 km): Evaporative

Emissions Canister and Air Suction Filter Replacement (or every 120 months, whichever occurs first).

These intervals only summarize maintenance services. Be sure to follow the complete scheduled maintenance on the following pages.

7-8

Short Trip/City Scheduled Maintenance

The services shown in this schedule up to 100,000 miles (166 000 km) should be repeated after 100,000 miles (166 000 km) at the same intervals for the life of this vehicle. The service shown at 120,000 miles (200 000 km) should be repeated at the same interval after 120,000 miles (200 000 km) for the life of this vehicle. See “Owner Checks and Services” and “Periodic Maintenance Inspections” following.

Footnotes [ The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. # Lubricate the parking brake lever and cable, suspension system and propeller shafts and steering wheel linkage. + A good time to check your brakes is during tire rotation. See “Brake System Inspection” under “Periodic Maintenance Inspections” in Part C of this schedule.

7-9

Short Trip/City Scheduled Maintenance

3,000 Miles (5 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

6,000 Miles (10 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

9,000 Miles (15 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-10

Short Trip/City Scheduled Maintenance

12,000 Miles (20 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

15,000 Miles (25 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j Inspect engine air cleaner filter if you are driving in dusty conditions.

Replace filter if necessary. An Emission Control Service. (See footnote [.)

j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

(Continued)

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-11

Short Trip/City Scheduled Maintenance

15,000 Miles (25 000 km) (Continued) j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Change manual transmission fluid. j Change transfer case fluid. j Change differential fluid. j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect propeller shafts and U-joints for looseness and damage (or every

15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

7-12

Short Trip/City Scheduled Maintenance

18,000 Miles (30 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

21,000 Miles (35 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

24,000 Miles (40 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

7-13

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

Short Trip/City Scheduled Maintenance

27,000 Miles (45 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

30,000 Miles (50 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Replace passenger compartment air filter. j Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap

gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote [.)

j Inspect engine accessory drive belts (or every 30 months,

whichever occurs first). An Emission Control Service.

j Drain, flush and refill cooling system (or every 30 months, whichever occurs

first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. (See footnote [.)

7-14

Short Trip/City Scheduled Maintenance

j Inspect ignition coil plug cap (or every 30 months, whichever occurs first).

An Emission Control Service. (See footnote [.)

j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

j Replace engine air cleaner filter.

An Emission Control Service.

j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

(Continued)

7-15

Short Trip/City Scheduled Maintenance

30,000 Miles (50 000 km) (Continued) j Change manual transmission fluid. j Change transfer case fluid. j Change differential fluid. j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Replace fuel filter (or every 30 months, whichever occurs first, or

sooner if filter is clogged). An Emission Control Service. (See footnote [.)

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

33,000 Miles (55 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-16

Short Trip/City Scheduled Maintenance

36,000 Miles (60 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

39,000 Miles (65 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

42,000 Miles (70 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

7-17

Short Trip/City Scheduled Maintenance

45,000 Miles (75 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

j Inspect automatic transmission fluid hose (or every 45 months,

whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Inspect engine air cleaner filter if you are driving in dusty conditions.

Replace filter if necessary. An Emission Control Service. (See footnote [.)

j Change manual transmission fluid.

7-18

Short Trip/City Scheduled Maintenance

j Change transfer case fluid. j Change differential fluid. j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

48,000 Miles (80 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

7-19

Short Trip/City Scheduled Maintenance

51,000 Miles (85 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

54,000 Miles (90 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

57,000 Miles (95 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-20

Short Trip/City Scheduled Maintenance

60,000 Miles (100 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Replace passenger compartment air filter. j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Inspect engine accessory drive belts (or every 30 months, whichever occurs

first). An Emission Control Service.

(Continued)

7-21

Short Trip/City Scheduled Maintenance

60,000 Miles (100 000 km) (Continued) j Drain, flush and refill cooling system (or every 30 months, whichever occurs

first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. (See footnote [.)

j Replace spark plugs.

An Emission Control Service.

j Inspect ignition coil plug cap (or every 30 months, whichever occurs first).

An Emission Control Service.

j Replace spark plug wires (or every 60 months, whichever occurs first)

(1.6L Code 6 engine only). An Emission Control Service.

j Drain, refill and bleed the brake system. j Replace the camshaft timing belt (1.6L Code 6 engine only).

An Emission Control Service. (See footnote [.)

j Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap

gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote [.)

j Replace engine air cleaner filter.

An Emission Control Service.

7-22

Short Trip/City Scheduled Maintenance

j Rotate tires. See “Tire Inspection and Rotation” in the Index for

proper rotation pattern and additional information. (See footnote +.)

j Replace fuel filter (or every 30 months, whichever occurs first).

An Emission Control Service. (See footnote [.)

j Change manual transmission fluid. j Change transfer case fluid. j Change differential fluid. j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect emission system hoses and replace as necessary.

An Emission Control Service. (See footnote [.)

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

63,000 Miles (105 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-23

Short Trip/City Scheduled Maintenance

66,000 Miles (110 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

69,000 Miles (115 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

72,000 Miles (120 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

7-24

Short Trip/City Scheduled Maintenance

75,000 Miles (125 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Inspect engine air cleaner filter if you are driving in dusty conditions.

Replace filter if necessary. An Emission Control Service. (See footnote [.)

j Change manual transmission fluid. j Change transfer case fluid.

(Continued)

7-25

Short Trip/City Scheduled Maintenance

75,000 Miles (125 000 km) (Continued) j Change differential fluid. j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

78,000 Miles (130 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

81,000 Miles (135 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-26

Short Trip/City Scheduled Maintenance

84,000 Miles (140 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

87,000 Miles (145 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

90,000 Miles (150 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Replace passenger compartment air filter. j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

j Inspect automatic transmission fluid hose (or every 45 months,

whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

(Continued)

7-27

Short Trip/City Scheduled Maintenance

90,000 Miles (150 000 km) (Continued) j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Inspect engine accessory drive belts (or every 30 months, whichever

occurs first).

j Inspect camshaft timing belt (1.6L Code 6 engine only).

An Emission Control Service. (See footnote [.)

j Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap

gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote [.)

j Inspect ignition coil plug cap (or every 30 months, whichever occurs first).

An Emission Control Service.

7-28

Short Trip/City Scheduled Maintenance

j Drain, flush and refill cooling system (or every 30 months, whichever occurs

first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. (See footnote [.)

j Replace engine air cleaner filter.

An Emission Control Service.

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

j Change manual transmission fluid. j Change transfer case fluid. j Change differential fluid. j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Replace fuel filter (or every 30 months, whichever occurs first).

An Emission Control Service. (See footnote [.)

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

7-29

Short Trip/City Scheduled Maintenance

93,000 Miles (155 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

96,000 Miles (160 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

99,000 Miles (165 000 km) j Change engine oil and filter (or every 3 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-30

Short Trip/City Scheduled Maintenance

100,000 Miles (166 000 km) j If you haven’t used your vehicle under severe service conditions listed

previously and, therefore, haven’t changed your automatic transmission fluid, change both the fluid and filter.

120,000 Miles (200 000 km) j Replace evaporative emission canister and air suction filter

(or every 120 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

DATE

ACTUAL MILEAGE

SERVICED BY:

SERVICED BY:

7-31

Long Trip/Highway Scheduled Maintenance

The services shown in this schedule up to 100,000 miles (166 000 km) should be repeated after 100,000 miles (166 000 km) at the same intervals for the life of this vehicle. The service shown at 120,000 miles (200 000 km) should be repeated at the same interval after 120,000 miles (200 000 km) for the life of this vehicle. See “Owner Checks and Services” and “Periodic Maintenance Inspections” following.

Footnotes [ The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. # Lubricate the parking brake lever and cable, suspension system and propeller shafts and steering wheel linkage. + A good time to check your brakes is during tire rotation. See “Brake System Inspection” under “Periodic Maintenance Inspections” in Part C of this schedule.

7-32

Long Trip/Highway Scheduled Maintenance

7,500 Miles (12 500 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

15,000 Miles (25 000 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

j If Equipped: Inspect passenger compartment air filter. j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

(Continued)

7-33

Long Trip/Highway Scheduled Maintenance

15,000 Miles (25 000 km) (Continued) j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

22,500 Miles (37 500 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

30,000 Miles (50 000 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Replace passenger compartment air filter. j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

7-34

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

Long Trip/Highway Scheduled Maintenance

j Change automatic transmission fluid and filter if the vehicle is mainly driven

under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

j Inspect engine accessory drive belts (or every 30 months, whichever

occurs first).

j Drain, flush and refill cooling system (or every 30 months, whichever occurs

first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. (See footnote [.)

(Continued)

7-35

Long Trip/Highway Scheduled Maintenance

30,000 Miles (50 000 km) (Continued) j Inspect ignition coil plug cap (or every 30 months, whichever occurs first).

An Emission Control Service. (See footnote [.)

j Replace engine air cleaner filter.

An Emission Control Service.

j Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap

gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote [.)

j Change manual transmission fluid. j Change transfer case fluid. j Change differential fluid. j Replace fuel filter (or every 30 months, whichever occurs first, or

sooner if filter is clogged). An Emission Control Service. (See footnote [.)

j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

7-36

Long Trip/Highway Scheduled Maintenance

37,500 Miles (62 500 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

45,000 Miles (75 000 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Inspect passenger compartment air filter. j Inspect automatic transmission fluid hose (or every 45 months,

whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

(Continued)

7-37

Long Trip/Highway Scheduled Maintenance

45,000 Miles (75 000 km) (Continued) j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

52,500 Miles (87 500 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

7-38

Long Trip/Highway Scheduled Maintenance

60,000 Miles (100 000 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j If Equipped: Replace passenger compartment air filter. j For Two-Wheel-Drive vehicles only: Clean and repack the front wheel

bearings (or at each brake relining, whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

j Inspect engine accessory drive belts (or every 30 months, whichever occurs first).

An Emission Control Service.

(Continued)

7-39

Long Trip/Highway Scheduled Maintenance

60,000 Miles (100 000 km) (Continued) j Drain, flush and refill cooling system (or every 30 months, whichever occurs

first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service. (See footnote [.)

j Replace spark plugs.

An Emission Control Service.

j Inspect ignition coil plug cap (or every 30 months, whichever occurs first).

An Emission Control Service.

j Replace engine air cleaner filter.

An Emission Control Service.

j Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap

gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote [.)

j Change manual transmission fluid. j Change transfer case fluid. j Change differential fluid. j Replace fuel filter (or every 30 months, whichever occurs first).

An Emission Control Service.(See footnote [.)

7-40

Long Trip/Highway Scheduled Maintenance

j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect emission system hoses and replace as necessary.

An Emission Control Service.(See footnote [.)

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

j Replace the camshaft timing belt (1.6L Code 6 engine only).

An Emission Control Service.(See footnote [.)

j Replace spark plug wires (or every 60 months, whichever occurs first).

An Emission Control Service.

j Drain, refill and bleed the brake system. 67,500 Miles (112 500 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

7-41

Long Trip/Highway Scheduled Maintenance

75,000 Miles (125 000 km) j Change engine oil and filter (or every 7.5 months, whichever occurs first).

An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

j If Equipped: Inspect passenger compartment air filter. j Change automatic transmission fluid and filter if the vehicle is mainly

driven under one or more of these conditions: – In heavy city traffic where the outside temperature regularly

reaches 90_F (32_C) or higher. – In hilly or mountainous terrain. – When doing frequent trailer towing. – Uses such as found in taxi, police or delivery service. If you do not use your vehicle under any of these conditions, change the fluid and filter every 100,000 miles (166 000 km).

j Rotate tires. See “Tire Inspection and Rotation” in the Index for proper

rotation pattern and additional information. (See footnote +.)

j Inspect the valve lash and adjust if necessary (1.6L Code 6 engine only).

An Emission Control Service.

j Inspect propeller shafts and U-joints for looseness and damage

(or every 15 months, whichever occurs first). Inspect more frequently if used off-road or for pulling a trailer. Tighten U-joint flange bolts if necessary.

7-42