2004 Toyota Camry Owners Manual

front passenger occupant classification system, “AIRBAG ON” indi- cator light, “AIRBAG OFF” indicator light, front passenger’s seat belt buckle switch, seat belt pretensioner assemblies, inflat- ors, warning light, interconnecting wiring and power sources. (For details, see “Ser- vice reminder indicators and warning buzz- ers” on page 111 in Section 1−6.) If any of the following conditions occurs, this indicates a malfunction of the airbags or seat belt pretensioners. Contact your Toyota dealer as soon as possible. D When the ignition key is turned to the “ON” position, the light does not come on or remains on for more than about 6 seconds.

D The light comes on while driving. D If any seat belt does not retract or cannot be pulled out due to a malfunc- tion or activation of the relevant seat belt pretensioner.

D The seat belt pretensioner assembly or

surrounding area has been damaged.

’04Camry_U (L/O 0307)

SRS airbags— —SRS driver airbag and front passenger airbag

In the following cases, contact your Toyota dealer as soon as possible: D The front of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause the seat belt pretensioners to operate. D Either seat belt pretensioner assembly scratched,

or cracked, or otherwise damaged.

surrounding area

is

The SRS (Supplemental Restraint Sys- tem) front airbags are designed to pro- vide further protection for the driver and front passenger in addition to the primary safety protection provided by the seat belts. In response to a severe frontal impact, the SRS front airbags work together with the seat belts to help reduce injury by inflating. The SRS front airbags help re- duce injuries mainly to the driver’s or front passenger’s head or chest caused by hit- ting the vehicle interior.

55

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

The front passenger airbag will not acti- vate if there is no passenger sitting in the front passenger seat. However, the front passenger airbag may deploy if luggage is put in the seat, or the seat belt is buckled up regardless of the presence of the oc- cupant in the seat. (As for the front pas- senger occupant classification system, see “—Front passenger occupant classification system” on page 70 in this Section.) Always wear your seat belt properly. Your vehicle is equipped with a crash sensing and diagnostic module, which will record the use of the seat belt restraint system by the driver when the SRS front airbags are inflated.

CAUTION

D The SRS front airbag system is de- signed only as a supplement to the primary protection of the driver and front passenger seat belt systems. The driver and front passenger can be killed or seriously injured by the inflating airbags if they do not wear the available seat belts properly. During sudden braking just before a collision, an unrestrained driver or front passenger can move for- ward into direct contact with or close proximity to the airbag which may then deploy during the colli- sion. To ensure maximum protection in an accident, the driver and all passengers the vehicle must wear their seat belts properly. Wear- ing a seat belt properly during an accident reduces the chances of death or serious injury or being thrown out of the vehicle. For in- structions and precautions concern- ing the seat belt system, see “Seat belts” on page 45 in this Section.

in

56

restraint

D Improperly seated and/or restrained infants and children can be killed or seriously injured by the deploy- ing airbags. An infant or child who is too small to use a seat belt should be properly secured using a child Toyota strongly recommends in- fants and children be placed in the rear seat of the vehicle and proper- ly restrained. The rear seat is the safest for infants and children. For instructions concerning the installa- tion of a child restraint system, see “Child restraint” on page 74 in this Section.

that all

system.

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

The SRS front airbags are designed to deploy in severe (usually frontal) colli- sions where the magnitude and duration of the forward deceleration of the ve- hicle exceeds the designed threshold level. The SRS front airbags will deploy if the severity of the impact is above the de- signed threshold level, comparable to an approximate 25 km/h (15 mph) collision when the vehicles has the impact straight into a fixed barrier that does not move or deform. However, threshold velocity will be considerably higher if the vehicle strikes an object, such as a parked vehicle or sign pole, which can move or deform on impact, or if the vehicle is involved in an underride collision in which the front of the vehicle “underrides”, or goes under, the bed of a truck, etc.). It in some collisions where the forward deceleration of the ve- hicle is very close to the designed thresh- old level, the SRS front airbags and the seat belt pretensioners may not activate together. Always wear your seat belts properly.

(e.g. a collision

is possible

that

this

’04Camry_U (L/O 0307)

Collision from the rear

Hitting a curb, edge of pavement or hard surface

Falling into or jumping over a deep hole

Collision from the side

Vehicle rollover

Landing hard or vehicle falling

The SRS front airbags are generally not designed to inflate if the vehicle is in- volved in a side or rear collision, if it rolls over, or if it is involved in a low− speed frontal collision. But, whenever a collision of any type causes sufficient forward deceleration of the vehicle, de- ployment of the SRS front airbags may occur.

The SRS front airbags may also deploy if a serious impact occurs to the under- side of your vehicle. Some examples are shown in the illustration.

57

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

8. Driver’s seat position sensor 9. Airbag sensor assembly 10. Airbag module for driver

(airbag and inflator)

fills

The airbag sensor assembly consists of a safing sensor and airbag sensor. The front airbag sensors constantly moni- tor the forward deceleration of the vehicle. If an impact results in a forward decelera- tion beyond the designed threshold level, the system triggers the airbag inflators. At this time a chemical reaction in the infla- tors very quickly the airbags with non−toxic gas to help restrain the forward motion of the occupants. The front airbags then quickly deflate, so that there is no obstruction of the driver’s vision should it be necessary to continue driving. When the airbags inflate, they produce a loud noise and release some smoke and residue along with non−toxic gas. This does not indicate a fire. This smoke may remain inside the vehicle for some time, and may cause some minor irritation to the eyes, skin or breathing. Be sure to wash off any residue as soon as possible to prevent any potential skin irritation with soap and water. If you can safely exit from the vehicle, you should do so imme- diately.

The SRS front airbag system consists mainly of the following components, and their locations are shown in the illustra- tion. 1. Front airbag sensors 2. SRS warning light 3. “AIRBAG ON” and “AIRBAG OFF” indi-

cator lights

4. Airbag module for front passenger

(airbag and inflator)

5. Front passenger occupant classification

system (ECU and sensors)

6. Front passenger’s seat belt buckle

switch

7. Driver’s seat belt buckle switch

58

injuries, especially

Deployment of the airbags happens in a fraction of a second, so the airbags must inflate with considerable force. While the system is designed to reduce serious inju- ries, primarily to the head and chest, it may also cause other, less severe injuries to the face, chest, arms and hands. These are usually in the nature of minor burns or abrasions and swelling, but the force of a deploying airbag can cause more seri- ous if an occupant’s hands, arms, chest or head is in close proximity to the airbag module at the time of deployment. This is why it is important for to: avoid placing any object or part of the body between the occupant and the airbag module; sit straight and well back into the seat; wear the available seat belt properly; and sit as far as possible from the airbag module, while still maintaining control of the ve- hicle. Parts of the airbag module (steering wheel hub, airbag cover and inflator) may be hot for several minutes after deployment, so do not inflate only once. The windshield may be damaged by absorbing some of the force of the inflat- ing airbag.

touch! The airbags

the occupant

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

CAUTION

The driver or front passenger who is too close to the steering wheel or dashboard during airbag deployment can be killed or seriously injured. Toyota strongly recommends that: D The driver sit as far back as pos- sible from the steering wheel while still maintaining control of the ve- hicle.

D The front passenger sit as far back

as possible from the dashboard.

D All vehicle occupants be properly restrained using the available seat belts.

For instructions and precautions con- cerning the seating position, see “—Front seat precautions” on page 38 in this Section.

is

in use, since

D Do not sit on the edge of the seat or lean against the dashboard when the vehicle the front passenger airbag could inflate with considerable speed and force. Anyone who is up against, or very close to, an airbag when it inflates, can be killed or seriously injured. Sit up straight and well back in the seat, and always use your seat belt properly.

D Toyota strongly recommends that all infants and children be placed in the rear seat of the vehicle and be properly restrained.

D Do not hold a child on your lap or in your arms. Use a child restraint system in the rear seat. For instruc- tions concerning the installation of a child restraint system, see “Child restraint” on page 74 in this Sec- tion.

59

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

the

D Do not modify or remove any wir- ing. Do not modify, remove, strike or open any components such as the steering wheel pad, steering wheel, column cover, dashboard near front passenger airbag, front passenger airbag cover, front passenger airbag or airbag sensor assembly. Doing so may prevent the front airbag system from activating correctly, cause sudden activation of the system or disable the sys- tem, which could result in death or serious injury.

Failure to follow these instructions can result in death or serious injury. Consult your Toyota dealer about any repair and modification.

D Do not put anything or any part of your body on or in front of the dashboard or steering wheel pad that houses the front airbag sys- tem. They might restrict inflation or cause death or serious injury as they are projected rearward by the force of the deploying airbags. Like- wise, the driver and front passenger should not hold objects their arms or on their knees.

in

60

NOTICE

consulting

front airbag system

Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the SRS in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player

z Modification of the suspension sys-

tem

z Modification of the front end struc-

ture

z Attachment of a grille guard (bull bar, kangaroo bar, etc.), snowplow, winches or any other equipment to the front end

z Repairs made on or near the front fenders, front end structure, con- sole, steering wheel or dashboard near the front passenger airbag

steering

column,

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

light system monitors

This warning the airbag sensor assembly, front airbag sen- sors, side and curtain shield airbag sen- sors, curtain shield airbag sensors, driv- er’s seat position sensor, driver’s seat belt buckle switch, front passenger occupant classification system, “AIRBAG ON” indi- cator light, “AIRBAG OFF” indicator light, front passenger’s seat belt buckle switch, seat belt pretensioner assemblies, inflat- ors, warning light, interconnecting wiring and power sources. (For details, see “Ser- vice reminder indicators and warning buzz- ers” on page 111 in Section 1−6.) If any of the following conditions occurs, this indicates a malfunction of the airbags or seat belt pretensioners. Contact your Toyota dealer as soon as possible. D When the ignition key is turned to the “ON” position, the light does not come on or remains on for more than about 6 seconds.

D The light comes on while driving.

This indicator comes on when the igni- tion key is turned to the “ON” position. It goes off after about 6 seconds. This means the SRS front airbags are oper- ating properly.

In the following cases, contact your Toyota dealer as soon as possible: D The SRS front airbags have been in-

flated.

D The front of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS front airbags to inflate.

D The pad section of the steering wheel or cover (shaded in the illustration) is scratched, cracked, or otherwise damaged.

passenger

airbag

front

61

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

—SRS side airbags and curtain shield airbags

NOTICE

Do not disconnect the battery cables before contacting your Toyota dealer.

The SRS (Supplemental Restraint Sys- tem) side airbags and curtain shield air- bags are designed to provide further protection for the driver, front passen- ger and rear outside passengers in addition to the primary safety protec- tion provided by the seat belts.

62

the seat belts

In response to a severe side impact, the SRS side airbags and curtain shield air- bags work with to help reduce injury by inflating. The SRS side airbags help reduce injuries mainly to the driver’s or front passenger’s chest and the SRS curtain shield airbags help reduce injuries mainly to the driver’s, front pas- senger’s or rear outside passenger’s head. The SRS side airbag on the passenger seat will not activate if there is no pas- senger sitting in the front passenger seat. However, the side airbag on the passen- ger seat may deploy if luggage is put in the seat, or the seat belt is buckled up regardless of the presence of the occu- pant in the seat. (As for the front passen- ger occupant classification system, see “—Front passenger occupant classification system” on page 70 in this Section.) The SRS curtain shield airbag on the pas- senger side are activated even with no passenger in the front seat or rear outside seat. The SRS curtain shield airbags may acti- vate even when the side airbags are not activated. Always wear your seat belt properly.

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

D Do not allow anyone to lean his/her head or any part of his/her body against the door or the area of the seat, pillar, rear pillar or roof side rail from which the SRS side airbag and curtain shield airbag deploy even if he/she is a child seated in the child restraint system. It is dan- gerous if the SRS side airbag and curtain shield airbag inflate, and the impact of the deploying airbag could cause death or serious injury to the occupant.

Your vehicle is equipped with a crash sensing and diagnostic module, which will record the use of the seat belt restraint system by the driver when the SRS side airbags and curtain shield airbags are in- flated.

CAUTION

D The SRS side airbag and curtain shield airbag system is designed only as a supplement to the prima- ry protection of the driver, and front passenger and rear outside passenger seat belt systems. To en- sure maximum protection in an ac- cident, the driver and all passen- gers in the vehicle must wear their seat belts properly. Wearing a seat belt properly during an accident re- duces the chances of death or seri- ous injury or being thrown out of the vehicle. For instructions and precautions concerning the seat belt system, see “Seat belts” on page 45 in this Section.

restraint

D Improperly seated and/or restrained infants and children can be killed or seriously injured by the deploy- ing airbags. An infant or child who is too small to use a seat belt should be properly secured using a child Toyota strongly recommends in- fants and children be placed in the rear seats of the vehicle and prop- erly restrained. The rear seats are the safest for infants and children. For the installation of a child restraint sys- tem, see “Child restraint” on page 74 in this Section.

instructions concerning

that all

system.

63

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

Collision from the rear

Collision from the front

Vehicle rollover

The SRS side airbags and curtain shield airbags are not generally designed to inflate if the vehicle is involved in a front or rear collision, if it rolls over, or if it is involved in a low−speed side collision.

The SRS side airbag and curtain shield airbag system may not activate if the vehicle is subjected to a collision from the side at certain angles, or a collision to the side of the vehicle body other than the passenger compartment as shown in the illustration. The SRS side airbags and curtain shield airbags are designed to inflate when the passenger compartment area suffers a se- vere impact from the side. Always wear your seat belts properly.

64

The SRS side airbag and curtain shield airbag system consists mainly of the fol- lowing components, and their locations are shown in the illustration. 1. SRS warning light 2. “AIRBAG ON” and “AIRBAG OFF” indi-

cator lights

3. Curtain shield airbag modules

(airbag and inflator)

4. Front passenger occupant classification

system (ECU and sensors)

5. Side airbag modules

(airbag and inflator)

6. Curtain shield airbag sensors 7. Side and curtain shield airbag sensors

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

8. Front passenger’s seat belt buckle

switch

this

inflators. At

inflators and/or

9. Airbag sensor assembly The SRS side airbag and curtain shield airbag system is controlled by the airbag sensor assembly. The airbag sensor as- sembly consists of a safing sensor and airbag sensor. the side and In a severe side impact, curtain shield airbag sensor and/or the curtain shield airbag sensor trigger(s) the side airbag the curtain shield airbag time a chemical reaction in the inflators quickly fills the airbags with non−toxic gas to help restrain the occu- pants. When the airbags inflate, they produce a fairly loud noise and release some smoke and residue along with non−toxic gas. This does not indicate a fire. This smoke may remain inside the vehicle for some time, and may cause some minor irritation to the eyes, skin or breathing. Be sure to wash off any residue as soon as possible to prevent any potential skin irritation with soap and water. If you can safely exit from the vehicle, you should do so imme- diately.

the lateral motion of

’04Camry_U (L/O 0307)

Deployment of the airbags happens in a fraction of a second, so the airbags must inflate with considerable force. While the system is designed to reduce serious inju- ries, it may also cause minor burns or abrasions and swelling. Front seats as well as parts of the front and rear pillars, and roof side rail may be hot for several minutes, but the airbags themselves will not be hot. The airbags are designed to inflate only once.

CAUTION

inflate with

SRS side airbags and curtain shield airbags considerable force. To reduce the possibility of death or serious injury when they in- flate, the driver, front passenger and rear outside passengers must: D Wear their seat belts properly. D Remain properly seated with their backs upright and against the seats at all times.

D Do not allow anyone to lean against the door when the vehicle is in use, since the side airbag and curtain shield airbag could inflate with con- siderable speed and force. Other- wise, he/she may be killed or seri- ously injured. Special care should be taken especially when you have a small child in the vehicle.

D Sit up straight and well back in the seat, distributing your weight evenly in the seat. Do not apply excessive weight the seats with a side airbag, and to the front pillar, rear pillar and roof side rail with a curtain shield airbag.

the outer side of

to

65

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

D Do not allow anyone to kneel on the passenger seat, facing the pas- senger’s side door, since the side airbag and curtain shield airbag could considerable speed and force. Otherwise, he/she may be killed or seriously injured. Special care should be taken espe- cially when you have a small child in the vehicle.

inflate with

D Do not allow anyone to get his/her head or hands out of windows the curtain shield airbags since could inflate with considerable speed and force. Otherwise, he/she may be killed or seriously injured. Special care should be taken espe- cially when you have a small child in the vehicle.

inflate, since

D Do not allow anyone to get his/her head closer to the area where the side airbag and curtain shield air- bag these airbags could considerable speed and force. Otherwise, he/she may be killed or seriously injured. Special care should be taken espe- cially when you have a small child in the vehicle.

inflate with

66

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

D Do not attach a cup holder or any other device or object on or around the door. When the side airbag in- flates, the cup holder or any other device or object will be thrown with great force or the side airbag may not activate correctly, resulting in injury. Likewise, death or serious the driver and front passenger should not hold objects their arms or on their knees.

in

D Do not attach a microphone or any other device or object around the area where the curtain shield airbag activates such as on the windshield glass, side door glass, front and rear pillars, roof side rail and assist grips. When the curtain shield air- bag inflates, the microphone or oth- er device or object will be thrown away with great force or the curtain shield airbag may not activate cor- rectly, resulting in death or serious injury.

D Do not hook a hanger, heavy or sharp pointed objects on the coat hook. If the curtain shield airbag inflates, those items will be thrown away with great force or the curtain shield airbag may not activate cor- rectly, resulting in death or serious injury. When you hang clothes, hang them on the coat hook direct- ly.

D Do not use seat accessories which cover the parts where the side air- bags inflate. Such accessories may prevent the side airbags from acti- vating correctly, causing death or serious injury.

D Do not modify or replace the seats or upholstery of the seats with side airbags. Such changes may prevent the side airbag system from activat- ing correctly, disable the system or cause the side airbags to inflate ac- cidentally, resulting in death or seri- ous injury.

67

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

D Do not disassemble or repair the front and rear pillars and roof side rails containing the curtain shield airbags. Such changes may disable the system or cause the curtain shield airbags to inflate accidental- ly, resulting in death or serious in- jury.

Failure to follow these instructions can result in death or serious injury. Consult your Toyota dealer about any repair and modification.

NOTICE

consulting

Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the SRS side airbag and curtain shield airbag system in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player

z Modification of the suspension sys-

tem

z Modification of the side structure of

the passenger compartment

z Repairs made on or near the con-

sole or front seat

This indicator comes on when the igni- tion key is turned to the “ON” position. It goes off after about 6 seconds. This means the SRS side airbags and curtain shield airbags are operating properly.

68

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

light system monitors

This warning the airbag sensor assembly, front airbag sen- sors, side and curtain shield airbag sen- sors, curtain shield airbag sensors, driv- er’s seat position sensor, driver’s seat belt buckle switch, front passenger occupant classification system, “AIRBAG ON” indi- cator light, “AIRBAG OFF” indicator light, front passenger’s seat belt buckle switch, seat belt pretensioner assemblies, inflat- ors, warning light, interconnecting wiring and power sources. (For details, see “Ser- vice reminder indicators and warning buzz- ers” on page 111 in Section 1−6.) If any of the following conditions occurs, this indicates a malfunction of the airbags or seat belt pretensioners. Contact your Toyota dealer as soon as possible. D When the ignition key is turned to the “ON” position, the light does not come on or remains on for more than about 6 seconds.

D The light comes on while driving.

’04Camry_U (L/O 0307)

In the following cases, contact your Toyota dealer as soon as possible: D Any of the SRS side airbags and cur- tain shield airbags have been inflated. D The portion of the doors (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS side airbags and curtain shield airbags to inflate.

D The surface of the seats with the side airbag (shaded is scratched, cracked, or otherwise dam- aged.

illustration)

the

in

D The portion of

the front pillars, rear pillars or roof side rail garnishes (pad- ding) containing the curtain shield air- bags inside (shaded in the illustration) is scratched, cracked, or otherwise damaged.

NOTICE

Do not disconnect the battery cables before contacting your Toyota dealer.

69

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

—Front passenger occupant classification system Your vehicle is equipped with a front passenger occupant classification sys- tem. This system detects the conditions 1—4 in the table on page 72 and based on these conditions activates or deacti- vates front passenger airbags. The sys- tem monitors the weight and load on the front passenger seat, and the seat belt buckle switch to determine condi- tions 1—4. In order for the system to detect the conditions correctly, do not do any of the following. D Put a heavy load in the front passen-

ger seat.

D Attach a seatback

table to the front

passenger seat seatback.

D Put weight on the front passenger by putting your hands or feet on the front passenger seat seatback from the rear passenger seat.

70

The “AIRBAG ON” and “AIRBAG OFF” indicator lights indicate the actuation of the front passenger airbag, side airbag on the front passenger seat and front passenger’s seat belt pretensioner. The “AIRBAG OFF” indicator light will be illuminated when the ignition switch is in the “ON” position with the condition 2 in the table shown below.

in the

the “AIRBAG OFF”

front passenger If an adult sits seat, light may also be illuminated if the following occurs. D A rear passenger lifts the front passen-

indicator

ger seat cushion with their legs.

D Objects are placed under the front pas-

senger seat.

D The

front passenger seatback

is

in

contact with the rear seat.

is

illuminated when an adult

To ensure the system correctly detects an adult sitting in the front passenger seat, make sure the above do not occur. Make sure that the “AIRBAG ON” indicator light is seated in the front passenger seat. If the “AIRBAG OFF” indicator light is illumina- ted, ask the passenger to sit up straight, well back in the seat, and with the seat belt worn correctly. If the “AIRBAG OFF” indicator light still remains illuminated, ei- ther ask the passenger to move to the rear seat, or if that is not possible, move the front passenger seat fully rearward.

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

The “AIRBAG ON” and “AIRBAG OFF” indicator lights will be illuminated ini- tially when the ignition key is turned to the “ON” position. After about four sec- onds, they will go off. After that, the front passenger occupant classification system operates and judges which indi- cator light be illuminated.

indicator

light and “AIRBAG The SRS warning OFF” if there is a malfunction in the front pas- senger occupant classification system.

light will come on

71

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

Condition and operation in the front passenger occupant classification system

Condition detected

by the front

passenger occupant classification system

1. Adult∗1
2. Child∗2 or child

restraint system∗3

3. Unoccupied

4. There is a

malfunction in the system

Indicator/warning light

Devices

“AIRBAG ON” and

“AIRBAG OFF” indicator lights

“AIRBAG ON”

“AIRBAG OFF”

Not illuminated

“AIRBAG OFF”

SRS warning

passenger’s

Front

light

Off

Off

Off

On

seat belt

reminder light

Flashing∗4
Flashing∗4

Off

Off

Front

passenger

airbag

Side airbag on the front passenger

seat

Curtain shield airbag in the

front

passenger

side

Front

passenger’s

seat belt

pretensioner

Activated

Activated

Deactivated

Deactivated

Deactivated

Activated

Deactivated

Activated

as an adult depending on his/her physique or posture.

recognize him/her as a child depending on his/her physique and posture.

∗1: The system judges a person of adult size as an adult. When a smaller adult sits in the front passenger seat, the system may ∗2: When a larger child who has outgrown a child restraint system sits in the front passenger seat, the system may recognize him/her ∗3: Never install a rear−facing child restraint system on the front passenger seat. A forward−facing child restraint system should only be installed on the front passenger seat when it is unavoidable. (See “Child restraint” on page 74 in this Section as for installing the child restraint system.) ∗4: In the event that the front passenger does not wear a seat belt.

72

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

CAUTION

To avoid potential death or serious injury when the front passenger occu- pant classification system does not detect the conditions correctly, ob- serve the following. D Do not recline the front passenger seat seatback so that it interferes with a rear seat as it may cause the “AIRBAG OFF” indicator light be il- luminated. If the seatback interferes with the rear seat, return the seat- back to a position where it does not interfere with the rear seat. Avoid reclining the front passenger seat seatback too much while the vehicle is moving, as it lessens the effectiveness of the seat belt.

If

the extender

D Make sure the “AIRBAG ON” indica- tor light is illuminated when using the seat belt extender for the front passenger seat. the “AIRBAG OFF” indicator light is illuminated, disconnect tongue from the seat belt buckle, then re- connect the seat belt. Reconnect the seat belt extender after making sure indicator light is illuminated. If you use the seat belt extender while the “AIR- BAG OFF” indicator light is illumi- nated, the front passenger airbag and side airbag on the front pas- senger side may not activate cor- rectly, which could cause death or serious injury in the event of colli- sion.

the “AIRBAG ON”

D If an adult sits

If

is

in

the

the

light

light should be

front passenger seat, the “AIRBAG ON” indicator illumi- “AIRBAG OFF” nated. indicator illuminated, ask the passenger to sit up straight, well back in the seat, feet on the floor, and with the seat belt worn correctly. the “AIRBAG OFF” indicator light still remains illumi- nated, either ask the passenger to move to the rear seat, or if that is not front the passenger seat fully rearward.

possible, move

If

the

D Wear the seat belt properly. D Make sure

front passenger’s seat belt tab has not been left in- serted into the buckle before some- one sits front passenger seat.

the

in

D Do not put a heavy

in the front passenger seatback pocket or attach a seatback table to the front passenger seat seatback.

load

D Do not let a rear passenger lift the front passenger seat with their feet or press on the seatback with their legs.

73

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

D Do not put objects under the front

passenger seat.

D Child restraint systems installed on the rear seat should not contact the front seatbacks.

The “AIRBAG ON” indicator light may be illuminated (the front passenger airbag and side airbag on the front passenger seat may deploy) even if observing the above cautions, when a child sits in, or a for- ward−facing is installed on the front passenger seat. Re- fer to all the cautions in “SRS airbags” on page 55 and “Child restraint” on page 74
in this Section.

restraint

system

child

’04Camry_U (L/O 0307)

Child restraint— —Child restraint precautions Toyota strongly urges the use of ap- propriate child restraint systems for children. The laws of all 50 states in the U.S.A. and Canada now require the use of a child restraint system. Your vehicle conforms to SAEJ1819. If a child is too large for a child restraint system, the child should sit in the rear seat and must be restrained using the vehicle’s seat belt. See “Seat belts” on page 45 in this Section for details.

CAUTION

D For effective protection in automo- bile accidents and sudden stops, a child must be properly restrained, using a seat belt or child restraint system depending on the age and size of the child. Holding a child in your arms is not a substitute for a child restraint system. In an acci- dent, the child can be crushed against the windshield, or between you and the vehicle’s interior.

D Toyota strongly urges use of a proper child restraint system which conforms to the size of the child, installed on the rear seat. Accord- ing to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat. D Never install a rear−facing child re- straint system on the front passen- ger seat even if the “AIRBAG OFF” indicator light is illuminated. In the event of an accident, the force of the rapid inflation of the front pas- senger airbag can cause death or serious if the rear−facing child restraint system is installed on front passenger seat.

injury to the child

the

74

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

the

D A forward−facing child restraint sys- to be tem should be allowed front passenger installed on seat only when it is unavoidable. Always move the seat as far back as possible even if the “AIRBAG OFF” indicator light is illuminated, because the front passenger airbag considerable could speed and the child may be killed or seriously in- jured.

force. Otherwise,

inflate with

D On vehicles with side airbags and curtain shield airbags, do not allow the child to lean his/her head or any part of his/her body against the door or the area of the seat, front or rear pillar or roof side rail from which the side airbags or curtain shield airbags deploy even if the child is seated in the child restraint system. It is dangerous if the side airbag and curtain shield airbag in- flate, and the impact could cause death or serious injury to the child.

If

installing a child

D Do not use the seat belt extender when restraint system on the front or rear passen- ger seat. installing a child re- straint system with the seat belt extender connected to the seat belt, the seat belt will not securely hold the child restraint system, which could cause death or serious injury to the child or other passengers in the event of collision.

D Make sure you have complied with all installation instructions provided by the child restraint manufacturer and that the system is properly se- cured. If it is not secured properly, it may cause death or serious injury to the child in the event of a sud- den stop or accident.

—Child restraint system A child restraint system for a small child or baby must itself be properly restrained on the seat with the lap por- tion of the lap/shoulder belt. You must carefully consult the manufacturer’s in- structions which accompany the child restraint system. To provide proper restraint, use a child restraint system following the manufactur- er’s instructions about the appropriate age and size of the child for the child restraint system. Install the child restraint system correctly following the instructions provided by its manufacturer. General directions are also provided under the following illustrations. restraint system should be The child installed on the rear seat. According to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat. When not using the child restraint system, keep it secured with the seat belt or place it in the trunk or somewhere other than the passenger compartment. This will pre- vent the event of a sudden stop or accident.

injuring passengers

from

in

it

75

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

(A) Infant seat

(C) Booster seat

—Types of child restraint system Child restraint systems are classified into the following 3 types depending on the child’s age and size. (A) Infant seat (B) Convertible seat (C) Booster seat Install the child restraint system following the instructions provided by its manufac- turer. Your vehicle has anchor brackets for se- curing the top strap of a child restraint system. For instructions about how to use the an- chor bracket, see “—Using a top strap” on page 87 in this Section. The child restraint lower anchorages ap- proved for your vehicle may also be used. See “—Installation with child restraint low- er anchorages” on page 89 in this Sec- tion.

76

(B) Convertible seat

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

—Installation with seat belt

(A) INFANT SEAT INSTALLATION An infant seat must be used in rear− facing position only.

’04Camry_U (L/O 0307)

CAUTION

D Never install a rear−facing child re- straint system on the front passen- ger seat even if the “AIRBAG OFF” indicator light is illuminated. In the event of an accident, the impact of the rapid inflation of the front pas- senger airbag could cause death or serious if the rear−facing child restraint system is installed on front passenger seat.

injury to the child

the

the

lock mechanism of

D Do not install a child restraint sys- tem on the rear seat if it interferes with the front seats. Otherwise, the child or front seat occupant(s) may be killed or seriously injured in case of sud- den braking or a collision.

D If the driver’s seat position does not allow sufficient space for safe the child installation, install re- straint system on the rear right seat.

77

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

CAUTION

D After inserting the tab, make sure the tab and buckle are locked and that the lap and shoulder portions of the belt are not twisted.

D Do not insert coins, clips, etc. in the buckle as this may prevent your child from properly latching the tab and buckle.

D If the seat belt does not function it cannot protect your normally, child from death or serious injury. Contact your Toyota dealer immedi- ately. Do not the child restraint system on the seat until the seat belt is fixed.

install

1. Run the lap and shoulder belt through or around the infant seat following the instructions provided by its manufactur- er and insert the tab into the buckle taking care not to twist the belt. Keep the lap portion of the belt tight.

78

2. Fully extend the shoulder belt to put it in the lock mode. When the belt is then retracted even slightly, it cannot be extended.

the

To hold infant seat securely, make sure the belt is in the lock mode before letting the belt retract.

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

3. While pressing the infant seat

firmly against the seat cushion and seatback, let the shoulder belt retract as far as it will go to hold the infant seat secure- ly.

CAUTION

Push and pull the child restraint sys- tem in different directions to be sure it is secure. Follow all the installation instructions provided by its manufac- turer.

4. To remove the infant seat, press the buckle release button and allow the belt to retract completely. The belt will move to work for an adult or older child passen- ger.

freely again and be ready

79

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

6. While pressing

the convertible seat firmly against the seat cushion and seatback, let the shoulder belt retract as far as it will go to hold the convert- ible seat securely.

CAUTION

Push and pull the child restraint sys- tem in different directions to be sure it is secure. Follow all the installation instructions provided by its manufac- turer.

7. Put a child on the child restraint sys- tem and secure the child, complying with the instructions provided by the child restraint system manufacturer.

Install the child restraint system on the front passenger seat only when it is un- avoidable. Your vehicle is equipped with a front passenger occupant classification system. In order to activate the occupant classification system correctly, install the forward−facing child restraint system on the front passenger seat in the following order: 1. Turn the ignition key to the “ON” posi-

tion.

2. Move the front passenger seat to the

rearward position.

3. Put the child restraint system on the front passenger seat without putting your weight on front passenger seat.

the

4. Insert the seat belt tab into the seat

belt buckle.

5. Fully extend the shoulder belt to put it in the lock mode. When the belt is then retracted even slightly, it cannot be extended. To hold the seat securely, make sure the belt is in the lock mode before letting the belt retract.

(B) CONVERTIBLE SEAT INSTALLATION A convertible seat must be used in for- ward−facing or rear−facing position de- pending on the age and size of the the child. When manufacturer’s the applicable age and size of the child as well as directions the child restraint system.

installing, follow instructions about

installing

for

80

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

light

indicator

illuminated when the ignition key

The “AIRBAG OFF” indicator light should be is “ON” and the child is in the child restraint system after following these procedures. The “AIRBAG OFF” indi- cates the SRS front passenger airbag and side airbag on the passenger side will not deploy. If the “AIRBAG ON” indicator light is illuminated, remove the child restraint system and reinstall it with the ignition key in the “ACC” or “LOCK” position. If the “AIRBAG ON” indicator light is illumi- nated when the ignition key is turned to the “ON” position, then the SRS front pas- senger airbag and side airbag on the pas- senger side may deploy in an accident. Do not drive the vehicle in this condition. Remove the child restraint system and contact your Toyota dealer.

’04Camry_U (L/O 0307)

CAUTION

the

D Never install a rear−facing child re- straint system on the front passen- ger seat. A forward−facing child re- straint system should only be installed on front passenger seat when unavoidable. If you must install the child restraint system on the front passenger seat, put the seat in its most rearward position, and install the forward−facing child restraint system in the proper or- der. Otherwise, the front passenger occupant classification system can not detect the presence of the child restraint system and the front pas- senger airbag and side airbag on the front passenger seat could deploy.

D Never install a rear−facing child re- straint system on the front passen- ger seat even if the “AIRBAG OFF” indicator light is illuminated. In the event of an accident, the impact of the rapid inflation of the front pas- senger airbag could cause death or serious if the rear−facing child restraint system is installed on front passenger seat.

injury to the child

the

81

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

D On vehicles with side airbags and curtain shield airbags, do not allow the child to lean his/her head or any part of his/her body against the door or the area of the seat, front or rear pillar or roof side rail from which the side airbags or curtain shield airbags deploy even if the child is seated in the child restraint system. It is dangerous if the side airbag and curtain shield airbag in- flate, and the impact could cause death or serious injury to the child.

Move seat fully back

the

D A forward−facing child restraint sys- tem should be allowed to be installed on front passenger seat only when it is unavoidable. Always move the seat as far back as possible even if the “AIRBAG OFF” indicator light is illuminated, because the front passenger airbag could considerable speed and the child may be killed or seriously in- jured.

force. Otherwise,

inflate with

82

the

lock mechanism of

D Do not install a child restraint sys- tem on the rear seat if it interferes with the front seats. Otherwise, the child or front seat occupant(s) may be killed or seriously injured in case of sud- den braking or a collision.

D If the driver’s seat position does not allow sufficient space for safe the child installation, install re- straint system on the rear right seat.

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

CAUTION

D After inserting the tab, make sure the tab and buckle are locked and that the lap and shoulder portions of the belt are not twisted.

D Do not insert coins, clips, etc. in the buckle as this may prevent your child from properly latching the tab and buckle.

D If the seat belt does not function it cannot protect your normally, child from death or serious injury. Contact your Toyota dealer immedi- ately. Do not the child restraint system on the seat until the seat belt is fixed.

install

2. Fully extend the shoulder belt to put it in the lock mode. When the belt is then retracted even slightly, it cannot be extended.

To hold the convertible seat securely, make sure the belt is in the lock mode before letting the belt retract.

83

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

1. Run the lap and shoulder belt through or around the convertible seat following its the instructions manufacturer and into the buckle taking care not to twist the belt. Keep the lap portion of the belt tight.

provided insert the

by tab

’04Camry_U (L/O 0307)

3. While pressing

the convertible seat firmly against the seat cushion and seatback, let the shoulder belt retract as far as it will go to hold the convert- ible seat securely.

CAUTION

Push and pull the child restraint sys- tem in different directions to be sure it is secure. Follow all the installation instructions provided by its manufac- turer.

4. To remove the convertible seat, press the buckle release button and allow the belt to retract completely. The belt will move to work for an adult or older child passen- ger.

freely again and be ready

84

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

(C) BOOSTER SEAT INSTALLATION A booster seat must be used in for- ward−facing position only.

’04Camry_U (L/O 0307)

D Do not allow the child to lean his/ her head or any part of his/her body against the door or the area of the seat, front or rear pillar or roof side rail from which the side airbags or curtain shield airbags deploy even if the child is seated in the child restraint system. It is dan- gerous if the side airbag and cur- tain shield airbag inflate, and the impact could cause death or seri- ous injury to the child.

Move seat fully back

CAUTION

the

D A forward−facing child restraint sys- to be tem should be allowed front passenger installed on seat only when it is unavoidable. Always move the seat as far back as possible even if the “AIRBAG OFF” indicator light is illuminated, because the front passenger airbag considerable could speed and the child may be killed or seriously in- jured.

force. Otherwise,

inflate with

85

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

CAUTION

D Always make sure the shoulder belt is positioned across the center of child’s shoulder. The belt should be kept away from child’s neck, but not falling off child’s shoulder. Otherwise, the child may be killed or seriously injured in case of sud- den braking or a collision.

D If the seat belt does not function normally, it cannot protect your child from death or serious injury. Contact your Toyota dealer immedi- ately. Do not the child restraint system on the seat until the seat belt is fixed.

install

could

D Both high−positioned lap belts and cause loose−fitting belts death or serious to sliding under the lap belt during a collision or other unintended event. Keep the lap belt positioned as low on a child’s hips as possible.

injuries due

D For child’s safety, do not place the

shoulder belt under child’s arm.

D After inserting the tab, make sure the tab and buckle are locked and that the lap and shoulder portions of the belt are not twisted.

D Do not insert coins, clips, etc. in the buckle as this may prevent your child from properly latching the tab and buckle.

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

1. Sit the child on a booster seat. Run the lap and shoulder belt through or around the booster seat and across the child following the instructions provided by its manufacturer and insert the tab into the buckle taking care not to twist the belt.

Make sure the shoulder belt is correctly across the child’s shoulder and that the lap belt is positioned as low as possible on child’s hips. See “Seat belts” on page 45 in this Section for details.

86

’04Camry_U (L/O 0307)

—Using a top strap

Symbol

Anchor brackets

2. To remove the child restraint system, the buckle release button and

press allow the belt to retract.

Follow the procedure below for a child restraint system that requires the use of a top strap.

Use the anchor bracket on the package tray behind the rear seat to attach the top strap. Anchor brackets are rear seating position. This symbol indicates the location of the anchor brackets.

for each

installed

87

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

TO USE THE ANCHOR BRACKET: 1. Outside anchor brackets only—

Remove the head restraint.

2. Open the lid of the anchor bracket.

88

3. Securely

fasten

the child restraint

system with the seat belt. Latch bracket and tighten the top strap.

the hook onto

the anchor

instructions

For the child re- straint system, see “Child restraint” on page 74 in this Section.

install

to

CAUTION

Make sure the top strap is securely latched, and check that the child re- straint system is secure by pushing and pulling it in different directions. Follow all the installation instructions provided by its manufacturer.

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

—Installation with child restraint lower anchorages

4. Replace the head restraint and lift it

up to the uppermost lock position.

specifications

Lower anchorages for the child restraint systems complying with the FMVSS225
or CMVSS210.2 are installed in the rear seat. The anchorages are installed in the clear- ance between the seat cushion and seat- back of both outside rear seats. Child restraint systems complying with the FMVSS225 or CMVSS210.2 specification can be fixed to these anchorages. In this case, it is not necessary to fix the child restraint system with a seat belt on the vehicle.

Canada only

Type A

89

2004 CAMRY from Jul. ’03 Prod. (OM33616U)

’04Camry_U (L/O 0307)

RESTRAINT

For owners in Canada The symbol on a child restraint system indicates the presence of a lower connec- tor system. CHILD INSTALLATION Type A— 1. Widen

the the clearance between seat cushion and seatback a little and confirm the position of the low- er anchorages near the button on the seatback.

SYSTEM

2. Latch the hooks of lower straps onto the anchorages and tighten the lower straps. Type B— 1. Widen

the the clearance between seat cushion and seatback a little and confirm the position of the low- er anchorages near the button on the seatback.

2. Latch the buckles onto the anchor-

ages.

it should be anchored. (For

If your child restraint system has a top strap, the installation of the top strap, see “—Using a top strap” on page 87 in this Section.)

Canada only

Type B

90

the installation details, refer

For to the instruction manual equipped with each product.

CAUTION

D When using the lower anchorages for the child restraint system, be sure that there are no irregular ob- jects around the anchorages or that the seat belt is not caught.

D Push and pull the child restraint system in different directions to be sure is secure. Follow all the installation instructions provided by its manufacturer.

it

the

lock mechanism of

D Do not install a child restraint sys- tem on the rear seat if it interferes