Download PDF Manual


’03Camry_U (L/O 0301)


Seats While the vehicle is being driven, all ve- hicle occupants should have the seatback upright, sit well back in the seat and prop- erly wear the seat belts provided.


CAUTION


D Do not drive the vehicle unless the occupants are properly seated. Do not allow passengers to sit on top of a folded−down seatback, or in the luggage compartment or cargo area. Persons not properly seated and/or properly restrained by seat belts can be severely injured in the event of emergency braking or a collision.


D During driving, do not allow pas- sengers to stand up or move around between seats. Otherwise, severe the event of emergency braking or a collision.


injuries can occur


in


Front seats— —Front seat precautions Driver seat


CAUTION


The SRS driver airbag deploys with considerable force, and can cause death or serious injury especially if the driver is very close to the airbag. The National Highway Traffic Safety Administration (“NHTSA”) advises: Since the risk zone for driver airbag is the first 50—75 mm (2—3 in.) of inflation, placing yourself 250 mm (10
in.) from your driver airbag provides you with a clear margin of safety. This distance is measured from the center of the steering wheel to your breastbone. If you sit less than 250
mm in.) away now, you can change your driving position in sever- al ways: D Move your seat to the rear as far as you can while still reaching the pedals comfortably.


(10


38


D Slightly recline


the back of


the seat. Although vehicle designs vary, many drivers can achieve the 250
mm (10 in.) distance, even with the driver seat all the way forward, sim- ply by reclining the back of the seat somewhat. If reclining the back of your seat makes it hard to see the road, raise yourself by using a firm, non−slippery cushion, or raise the seat if your vehicle has that feature.


D If your steering wheel is adjustable, tilt it downward. This points the air- bag toward your chest instead of your head and neck.


The seat should be adjusted as rec- ommended by NHTSA above, while still maintaining control of the foot pedals, steering wheel, and your view of the instrument panel controls.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


Front passenger seat


CAUTION


The SRS front passenger airbag also deploys with considerable force, and can cause death or serious injury es- pecially if the front passenger is very close to the airbag. The front passen- ger seat should be as far from the airbag as possible with the seatback adjusted, so the front passenger sits upright.


’03Camry_U (L/O 0301)


—Front seat precautions (on vehicles with SRS side airbags)


—Seat adjustment precautions


CAUTION


CAUTION


The SRS side airbags are installed in the driver and front passenger seats. Observe the following precautions. D Do not lean against the front door when the vehicle is in use, since the side airbag inflates with consid- erable speed and force. Otherwise, you may be killed or seriously in- jured.


D Do not use seat accessories which cover the area where the side air- bags inflate. Such accessories may prevent the side airbags from acti- vating correctly, causing death or serious injury.


D Do not modify or replace the seats or upholstery of front seats with side airbags. Such changes may prevent the side airbags from acti- vating correctly, disable the system or cause the side airbags to inflate accidentally, resulting in death or serious injury.


D Adjustments should not be made while the vehicle is moving, as the seat may unexpectedly move and cause the driver to lose control of the vehicle.


D When adjusting the seat, be careful that the seat does not hit a passen- ger or luggage.


D After adjusting the seat position, re- lease the lever and try sliding the seat forward and backward to make sure it is locked in position.


D After adjusting the seatback, push your body back against the seat to make sure the seat in position.


locked


is


D Do not put objects under the seats. Otherwise, the objects may interfere with the seat−lock mechanism or unexpectedly push up the seat posi- lever and the seat tion adjusting may suddenly move, causing the driver to lose control of the vehicle.


39


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


—Adjusting front seats (manual seat)


D While adjusting the seat, do not put your hands under the seat or near the moving parts. Otherwise, your hands or fingers may be caught and injured.


1. SEAT POSITION ADJUSTING LEVER Hold the center of the lever and pull it up. Then slide the seat to the desired position with slight body pressure and release the lever. 2. SEAT CUSHION HEIGHT ADJUSTING


KNOB


Turn the knob either way. ANGLE 3. SEATBACK


LEVER


ADJUSTING


lever up. lean back to the desired angle


Lean forward and pull the Then and release the lever.


40


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


CAUTION


To reduce the risk of sliding under the lap belt during a collision, avoid reclining the seatback any more than needed. The seat belts provide maxi- mum protection in a frontal or rear collision when the driver and the pas- senger are sitting up straight and well back If you are reclined, the lap belt may slide past your hips and apply restraint forces directly to the abdomen. In the event of a frontal collision, the more the seat is reclined, the greater the risk of personal injury.


in the seats.


4. SEAT


LUMBAR


SUPPORT


ADJUSTING KNOB


Turn the knob either way.


’03Camry_U (L/O 0301)


—Adjusting front seats (power seat)


1. SEAT POSITION AND SEAT CUSHION


HEIGHT ADJUSTING SWITCH


Move the control switch in the desired direction. Releasing the switch will stop the seat at that position. Do not place anything under front seats, as this might interfere with the seat movement. 2. SEATBACK


ADJUSTING


ANGLE


the


SWITCH


Move the control switch in the desired direction. Releasing the switch will stop the seat- back at that position.


41


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


CAUTION


To reduce the risk of sliding under the lap belt during a collision, avoid reclining the seatback any more than needed. The seat belts provide maxi- mum protection in a frontal or rear collision when the driver and the pas- senger are sitting up straight and well back If you are reclined, the lap belt may slide past your hips and apply restraint forces directly to the abdomen. In the event of a frontal collision, the more the seat is reclined, the greater the risk of personal injury.


in the seats.


3. SEAT


LUMBAR


SUPPORT


ADJUSTING KNOB


Turn the knob either way.


42


’03Camry_U (L/O 0301)


Fold−down rear seat


1. Pull up the seatback security lock


lever 1 to the unlock position.


2. Pull up the lock release button 2. 3. Fold down the seatback. Each seatback can be folded separately.


This will enlarge the trunk as far as the seatbacks. See “Luggage stowage precau- tions” on page 202 in Section 2 for pre- cautions when loading luggage.


NOTICE


Make sure the luggage loaded in the enlarged trunk will not damage the webbing of the rear center seat belt when folded down.


left seatback


the


is


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


Seat heaters


CAUTION


When returning the seatback to the upright position, observe the follow- ing precautions in order to prevent personal injury in a collision or sud- den stop: D Make sure the seatback is securely locked by pushing forward and rear- ward on the top of the seatback and that the red mark at the button on the top of the seatback cannot be seen. Failure to do so will pre- vent the seat belt from operating properly.


D Make sure the seat belts are not twisted or caught in the seatback and are arranged the proper position and are ready to use.


in


turn off


To turn on the seat heater, push the switch. To the seat heater, push the switch once again. At this time, the indicator light will illu- minate to indicate the seat heater is operating. The key must be in the “ON” position.


CAUTION


the seat heater because


Occupants must use caution when op- erating it may make them feel too hot or cause burns at low temperatures (erythema, varicella). Use extra caution for; D Babies, small children, elderly per- sons, sick persons or handicapped persons


D Persons who have delicate skin D Persons who are exhausted D Persons who have taken alcohol or drugs which induce sleep (sleeping drug, cold remedy, etc.)


To prevent the seat overheating, do not use the seat heater with a blan- ket, cushion, or other insulating ob- jects which cover the seat.


43


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


Head restraints


NOTICE


z Do not put unevenly weighed ob- jects on the seat and do not stick sharp objects (needles, nails, etc.) into the seat.


z When cleaning the seats, do not use organic substances (paint thin- ner, benzine, alcohol, gasoline, etc.). They may damage the heater and seat surface.


z To prevent the battery from being the switch off


discharged, when the engine is not running.


turn


Front


Rear


44


’03Camry_U (L/O 0301)


For your safety and comfort, adjust the head restraint before driving. To raise: Pull it up. To lower: Push it down while pressing the lock release button. The head restraint is most effective when it is close to your head. Therefore, using a cushion on the seatback is not recom- mended.


CAUTION


D Adjust the center of the head re- straint so that it is closest to the top of your ears.


D After adjusting the head restraint, make sure it is locked in position. the head re-


D Do not drive with


straints removed.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


Armrest


To use shown above.


the armrest, pull


it out as


Seat belts— —Seat belt precautions Toyota strongly urges that the driver and passengers in the vehicle be properly re- strained at all times with the seat belts provided. Failure to do so could increase the chance of injury and/or the severity of injury in accidents. The seat belts provided for your vehicle are designed for people of adult size, large enough to properly wear them. Child. Use a child restraint system ap- propriate for the child until the child be- comes large enough to properly wear the vehicle’s seat belts. See “Child restraint” on page 69 for details. If a child is too large for a child restraint system, the child should sit in the rear seat and must be restrained using the vehicle’s seat belt. According to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat. If a child must sit in the front seat, the seat belts should be worn properly. If an accident occurs and the seat belts are not worn properly, the force of the rapid infla- tion of the airbag may cause death or serious injury to the child.


Do not allow the child to stand up or kneel on either rear or front seats. An unrestrained child could suffer serious in- jury or death during emergency braking or a collision. Also, do not let the child sit on your lap. It does not provide sufficient restraint. Pregnant woman. Toyota recommends the use of a seat belt. Ask your doctor for specific lap belt should be worn securely and as low as possible over the hips and not on the waist. Injured person. Toyota recommends the use of a seat belt. Depending on the inju- ry, first check with your doctor for specific recommendations.


recommendations. The


45


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


CAUTION


the vehicle


in their seats Persons should ride their seat belts properly wearing whenever is moving. Otherwise, they are much more likely to suffer serious bodily injury or death in the event of sudden braking or a collision. When using the seat belts, observe the following: D Use the belt for only one person at a time. Do not use a single belt for two or more people—even children. D Avoid reclining the seatbacks too much. The seat belts provide maxi- mum protection when the seatbacks are in the upright position. (Refer to the seat adjustment instructions.) D Be careful not to damage the belt webbing or hardware. Take care that they do not get caught or pinched in the seat or doors.


D Inspect the belt system periodically. Check for cuts, fraying, and loose parts. Damaged parts should be re- placed. Do not disassemble or modify the system.


46


’03Camry_U (L/O 0301)


—Front and rear seat belts


D Keep the belts clean and dry.


If they need cleaning, use a mild soap solution or lukewarm water. Never use bleach, dye, or abrasive clean- ers—they may severely weaken the belts. (See “Cleaning the interior” on page 247 in Section 5.)


D Replace the belt assembly (includ- ing bolts) if it has been used in a severe impact. The entire assembly should be replaced even if damage is not obvious.


Adjust the seat as needed (front seats only) and sit up straight and well back in the seat. To fasten your belt, pull it out of the retractor and insert the tab into the buckle. You will hear a click when the tab locks into the buckle. The seat belt length automatically adjusts to your size and the seat position. The retractor will lock the belt during a sudden stop or on impact. It also may lock if you lean forward too quickly. A slow, easy motion will allow the belt to extend, and you can move around freely.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


CAUTION


Always make sure the shoulder belt is positioned across the center of your shoulder. The belt should be kept away from your neck, but not falling off your shoulder. Failure to do so could reduce the amount of protection in an accident and cause serious injures in a collision.


If the seat belt cannot be pulled out of the retractor, firmly pull the belt and release it. You will then be able to smoothly pull the belt out of the retractor. When a passenger’s shoulder belt is com- pletely extended and retracted even slightly, the belt is locked in that position and cannot be extended. This fea- ture is used to hold the child restraint system securely. (For details, see “Child restraint” on page 69 in this section.) To free the belt again, fully retract the belt and then pull the belt out once more.


then


is


Seat belts with an adjustable shoulder anchor— Adjust the shoulder anchor position to your size. To raise: Slide the anchor up. To lower: Push in the lock release button and slide the anchor down. After adjustment make sure the anchor is locked in position.


CAUTION


D After inserting the tab, make sure the tab and buckle are locked and that the belt is not twisted.


D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.


D If the seat belt does not function normally, immediately contact your Toyota dealer. Do not use the seat until the seat belt is fixed. It cannot protect an adult occupant or your child from injury.


47


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


Take up slack


Too high


CAUTION


D Both high−positioned lap belts and loose−fitting belts could cause seri- ous injuries due to sliding under the lap belt during a collision or other unintended result. Keep the lap belt positioned as low on hips as possible.


D For your safety, do not place the


shoulder belt under your arm.


Keep as low on hips as possible


the


lap and


the position of


Adjust shoulder belts. Position the lap belt as low as possible on your hips—not on your waist, then ad- just it to a snug fit by pulling the shoulder portion upward through the latch plate.


48


To release the belt, press the buckle−re- lease button and allow the belt to re- tract. If the belt does not retract smoothly, pull it out and check for kinks or twists. Then make sure it remains untwisted as it re- tracts.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


from your Toyota dealer


—Seat belt extender If your seat belts cannot be fastened se- curely because they are not long enough, a personalized seat belt extender is avail- able free of charge. Please contact your local Toyota dealer so that the dealer can order the proper re- quired length for the extender. Bring the heaviest coat you expect to wear for prop- er measurement and selection of length. Additional ordering information is available at your Toyota dealer.


CAUTION


D Remember that the extender pro- vided for you may not be safe when used on a different vehicle, for another person, or at a different seating position than the one origi- nally intended.


the


When using the seat belt extender, following precautions. observe Failure to follow these instructions could reduce the effectiveness of the seat belt restraint system in case of vehicle the chance of personal injury. D Never use the seat belt extender if you can fasten the seat belt without it.


increasing


accident,


To connect the extender to the seat belt, insert the tab into the seat belt buckle so that the “PRESS” signs on the buckle−release buttons of the ex- tender and the seat belt are both facing outward as shown. You will hear a click when the tab locks into the buckle. When releasing the seat belt, press on the buckle−release button on the extender, not on the seat belt. This helps prevent damage to the vehicle interior and extend- er itself. When not and store in the vehicle for future use.


in use, remove the extender


49


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


—Seat belt comfort guides


CAUTION


D After inserting the tab, make sure the tab and buckle are locked and that the seat belt extender is not twisted.


D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.


D If the seat belt does not function normally, immediately contact your Toyota dealer. Do not use the seat until the seat belt is fixed. It cannot protect an adult occupant or your child from injury.


50


Seat belt comfort guides are stored in the both pockets on the rear seatback.


the sides of


The outside shoulder belt comfort guides for the rear seat outside posi- tions will provide added seat belt com- fort for children who have outgrown child restraints and for small adults. When the outside shoulder belt is in- serted through the guide, the comfort guide pulls the belt away from the neck and head of an occupant. To use the comfort guide, do as fol- lows.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


INSTALLING THE COMFORT GUIDE 1. Pull from


the comfort guide


the


pocket.


3. Buckle, position and release the seat belt. (For wearing the seat belt, see “—Front and rear seat belts” on page 46 in this section.) Make sure the shoulder belt crosses the shoul- der.


2. Pinch the two edges of the shoulder belt for the rear seat outside posi- tion with your fingers and slide the belt past the slot of the guide as shown above. At this time, the elas- tic cord must be behind the seat belt.


CAUTION


Make sure the belt is not twisted and that it lies flat. The elastic cord must be behind the guide must be on the front.


the belt and


51


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


—Front seat belt pretensioners


The driver and front passenger’s seat belt pretensioners are designed to be activated in response to a severe fron- tal impact. When the airbag sensor detects the shock of a severe frontal impact, the front seat belts are quickly drawn back in by the retractors so that the belts snugly restrain the front seat occupants. The front seat belt pretensioners are acti- vated even with no passenger in the front seat. Collisions occurring at certain speeds and angles may cause the seat belt preten- sioners and SRS airbags not to operate all together.


light system monitors


This indicator comes on when the igni- tion key is turned to the “ON” position. It goes off after about 6 seconds. This means the front seat belt pretensioners are operating properly. This warning the airbag sensor assembly, front airbag sen- sors, side and curtain shield airbag sen- sors, curtain shield airbag sensors, driv- er’s seat position sensor, driver’s seat belt buckle switch, front seat belt pretensioner assemblies, inflators, warning light, inter- connecting wiring and power sources. (For details, see “Service reminder indicators and warning buzzers” on page 105 in Sec- tion 1−5.)


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


THE


AND


STORING


REMOVING COMFORT GUIDE Pinch the two edges of the seat belt together so that you can slide them out of the guide. Store the guide with the elastic cord into the pocket.


CAUTION


To reduce the chance of in case of an accident or a sudden stop while driving, remove and store the comfort guide in its pocket when it is not in use.


injury


52


’03Camry_U (L/O 0301)


When the front seat belt pretensioners are activated, an operating noise may be heard and a small amount of smoke−like gas may be released. This gas is harm- less and does not indicate that a fire is occurring. Once front seat belt pretensioners the have been activated, the seat belt retrac- tors remain locked.


CAUTION


Do not modify, remove, strike or open the front seat belt pretensioner as- semblies, airbag sensor or surround- ing area or wiring. Doing so may cause sudden operation of the front seat belt pretensioners or disable the system, which could result in death or serious injury. Failure to follow these instructions can result in death or serious inju- ries. Consult your Toyota dealer about any repairs and modifications.


NOTICE


consulting


Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the front seat belt pretensioners in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player


z Repairs on or near the front seat


belt retractor assemblies


z Modification of the suspension sys-


tem


z Modification of the front end struc-


ture


z Attachment of a grille guard (bull bar, kangaroo bar, etc.), snowplow, winches or any other equipment to the front end


z Repairs made on or near the front fenders, front end structure or con- sole


53


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


The front seat belt pretensioner system mainly consists of the following compo- nents and their locations are shown in the illustration. 1. Front airbag sensors 2. SRS warning light 3. Front seat belt pretensioner assemblies 4. Airbag sensor assembly The front seat belt pretensioners are con- trolled by the airbag sensor assembly. The airbag sensor assembly consists of a saf- ing sensor and airbag sensor.


’03Camry_U (L/O 0301)


SRS driver airbag and front passenger airbag


In the following cases, contact your Toyota dealer as soon as possible: D The front of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause the front seat belt pretensioners to op- erate.


D Either front seat belt pretensioner as- sembly is scratched, cracked, or otherwise dam- aged.


surrounding


area


or


following


conditions occurs,


This front seat belt pretensioner system has a service reminder indicator to inform the driver of operating problems. If any of the this indicates a malfunction of the airbags or pretensioners. Contact your Toyota dealer as soon as possible the vehicle. D The light does not come on when the ignition key is turned to the “ON” posi- tion, or the light remains on.


to service


D The light comes on or flashes while


driving.


D If either front seat belt does not retract or can not be pulled out due to a malfunction or activation of the relevant front seat belt pretensioner.


54


The SRS (Supplemental Restraint Sys- tem) front airbags are designed to pro- vide further protection for the driver and front passenger in addition to the primary safety protection provided by the seat belts. In response to a severe frontal impact, the SRS front airbags work together with the seat belts to help reduce injury by inflating. The SRS front airbags help to reduce injuries mainly to the driver’s or front passenger’s head or chest caused by directly hitting the steering wheel or dash- board. The front passenger airbag is acti- vated even with no passenger in the front seat. Be sure to wear your seat belt properly.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


Your vehicle is equipped with a crash sensing and diagnostic module, which will record the use of the seat belt restraint system by the driver when the SRS air- bags are inflated.


CAUTION


The driver or front passenger who is too close to the steering wheel or dashboard during airbag deployment can be killed or seriously injured. Toyota strongly recommends that: D The driver sit as far back as pos- sible from the steering wheel while still maintaining control of the ve- hicle.


D The front passenger sit as far back


as possible from the dashboard.


D All vehicle occupants be properly restrained using the available seat belts.


light system monitors


This indicator comes on when the igni- tion key is turned to the “ON” position. It goes off after about 6 seconds. This means the SRS front airbags are oper- ating properly. This warning the airbag sensor assembly, front airbag sen- sors, side and curtain shield airbag sen- sors, curtain shield airbag sensors, driv- er’s seat position sensor, driver’s seat belt buckle switch, front seat belt pretensioner assemblies, inflators, warning light, inter- connecting wiring and power sources. (For details, see “Service reminder indicators and warning buzzers” on page 105 in Sec- tion 1−5.)


The SRS front airbags are designed to deploy in severe (usually frontal) colli- sions where the magnitude and duration of the forward deceleration of the ve- hicle exceeds the designed threshold level. The SRS front airbags will deploy if the severity of the impact is above the de- signed threshold level, comparable to an approximate 25 km/h (15 mph) collision when the vehicles has the impact straight into a fixed barrier that does not move or deform. However, threshold velocity will be considerably higher if the vehicle strikes an object, such as a parked vehicle or sign pole, which can move or deform on impact, or if the vehicle is involved in an underride collision in which the front of the vehicle “underrides”, or goes under, the bed of a truck, etc.). It in some collisions where the forward deceleration of the ve- hicle is very close to the designed thresh- old level, the SRS front airbags and the seat belt pretensioners may not activate together. Always wear your seat belts properly.


(e.g. a collision


is possible


that


this


55


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


Collision from the rear


Hitting a curb, edge of pavement or hard material


Falling into or jumping over a deep hole


Collision from the side


Vehicle rollover


Landing hard or vehicle falling


The SRS front airbags are generally not designed to inflate if the vehicle is in- volved in a side or rear collision, if it rolls over, or if it is involved in a low− speed frontal collision. But, whenever a collision of any type causes sufficient forward deceleration of the vehicle, de- ployment of the SRS front airbags may occur.


The SRS front airbags may also deploy if a serious impact occurs to the under- side of your vehicle. Some examples are shown in the illustration.


56


The SRS airbag system mainly consists of the following components, and their loca- tions are shown in the illustration. 1. Front airbag sensors 2. SRS warning light 3. Airbag module for front passenger


(airbag and inflator)


4. Driver’s seat belt buckle switch 5. Driver’s seat position sensor 6. Airbag sensor assembly 7. Airbag module for driver


(airbag and inflator)


The airbag sensor assembly consists of a safing sensor and airbag sensor.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


The airbag sensors constantly monitor the forward deceleration of the vehicle. If an impact results in a forward deceleration beyond the designed threshold level, the system triggers the airbag inflators. At this time a chemical reaction in the inflators very quickly fills the airbags with non−tox- ic gas to help restrain the forward motion of the occupants. The airbags then quickly deflate, so that there is no obstruction of the driver’s vision should it be necessary to continue driving. When the airbags inflate, they produce a loud noise and release some smoke and residue along with non−toxic gas. This does not indicate a fire. This smoke may remain inside the vehicle for some time, and may cause some minor irritation to the eyes, skin or breathing. Be sure to wash off any residue as soon as possible to prevent any potential skin irritation with soap and water. If you can physically and safely exit the vehicle after a collision, you should do so at the first opportunity.


injuries, especially


Deployment of the airbags happens in a fraction of a second, so the airbags must inflate with considerable force. While the system is designed to reduce serious inju- ries, primarily to the head and chest, it may also cause other, less severe injuries to the face, chest, arms and hands. These are usually in the nature of minor burns or abrasions and swelling, but the force of a deploying airbag can cause more seri- ous if an occupant’s hands, arms, chest or head are in close proximity to the airbag module at the time of deployment. This is why it is important for to: avoid placing any object or part of the body between the occupant and the airbag module; sit straight and well back into the seat; wear the available seat belt properly; and sit as far as possible from the airbag module, while still maintaining control of the ve- hicle. Parts of the airbag module (steering wheel hub, airbag cover and inflator) may be hot for several minutes after deployment, so do not inflate only once. The windshield may be damaged by absorbing some of the force of the inflat- ing airbag.


touch! The airbags


the occupant


CAUTION


D The SRS airbag system is designed only as a supplement to the prima- ry protection of the driver side and front passenger side seat belt sys- tems. The front seat occupants can be killed or seriously injured by the inflating airbags if they do not wear the available seat belts properly. During sudden braking just before a collision, an unrestrained driver or front passenger can move for- ward into direct contact with or close proximity to the airbag which may then deploy during the colli- sion. To ensure maximum protection in an accident, the driver and all passengers the vehicle must wear their seat belts properly. Wear- ing a seat belt properly during an accident reduces the chances of death or serious injury or being thrown out of the vehicle. For in- structions and precautions concern- ing the seat belt system, see “Seat belts” on page 45 in this section.


in


57


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


restraint


D Improperly seated and/or restrained infants and children can be killed or seriously injured by the deploy- ing front airbags. An infant or child who is too small to use a seat belt should be properly secured using a child Toyota strongly recommends in- fants and children be placed in the rear seat of the vehicle and proper- ly restrained. The rear seat is the safest for infants and children. For instructions concerning the installa- tion of a child restraint system, see “Child restraint” on page 69 in this section.


that all


system.


’03Camry_U (L/O 0301)


D Never install a rear−facing child re- straint system on the front passen- ger seat because the force of the rapid inflation of the front passen- ger airbag can cause death or seri- ous injury to the child.


Move seat fully back


the


D A forward−facing child restraint sys- tem should be allowed to be installed on front passenger seat only when it is unavoidable. Always move the seat as far back as possible, because the force of the deploying front passenger air- bag could cause death or serious injury to the child.


58


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


D On vehicles with side airbags and curtain shield airbags, do not allow the child to lean against the door or around the door even if the child is seated in the child restraint sys- tem. It is dangerous if the side air- bag and curtain shield airbag in- flate, and the impact could cause death or serious injury to the child. the installation of a child restraint sys- tem, see “Child restraint” on page 69 in this section.


instructions concerning


D For


is


in use, since


D Do not sit on the edge of the seat lean over the dashboard when or the vehicle the front airbags inflate with consider- able speed and force. Otherwise, you may be killed or seriously in- jured. Sit up straight and well back in the seat, and always use your seat belt properly.


the


D Do not allow a child to stand up or to kneel on front passenger seat, since the front airbag inflates with considerable speed and force. Otherwise, the child may be killed or seriously injured.


D Do not hold a child on your lap or in your arms. Use a child restraint system in the rear seat. For instruc- tions concerning the installation of a child restraint system, see “Child restraint” on page 69 in this sec- tion.


59


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


D Do not modify or remove any wir- ing. Do not modify, remove, strike or open any components such as the steering wheel pad, steering wheel, column cover, dashboard near front passenger airbag, front passenger airbag cover, front passenger airbag or airbag sensor assembly. Doing so may cause sud- den SRS front airbag inflation or disable the system, which could re- sult in death or serious injury.


the


Failure to follow these instructions can result in death or serious injury. Consult your Toyota dealer about any repairs and modifications.


D Do not put objects or your pets on or in front of the dashboard or steering wheel pad that houses the front airbag system. They might re- strict inflation or cause death or serious injury as they are projected rearward by the force of the deploy- ing airbags. Likewise, the driver and front passenger should not hold objects in their arms or on their knees.


60


NOTICE


consulting


front airbag system


Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the SRS in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player


z Modification of the suspension sys-


tem


z Modification of the front end struc-


ture


z Attachment of a grille guard (bull bar, kangaroo bar, etc.), snowplow, winches or any other equipment to the front end


z Repairs made on or near the front fenders, front end structure, con- sole, steering wheel or dashboard near the front passenger airbag


steering


column,


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


NOTICE


Do not disconnect the battery cables before contacting your Toyota dealer.


In the following cases, contact your Toyota dealer as soon as possible: D The SRS front airbags have been in-


flated.


D The front of the vehicle (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS front airbags to inflate.


D The pad section of the steering wheel or cover (shaded in the illustration) is scratched, cracked, or otherwise damaged.


passenger


airbag


front


61


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


following


conditions occurs,


front airbag system has a This SRS service reminder indicator to inform the driver of operating problems. If either of the this indicates a malfunction of the airbags. Contact your Toyota dealer as soon as possible to service the vehicle. D The light does not come on when the ignition key is turned to the “ON” posi- tion, or the light remains on.


D The light comes on while driving.


’03Camry_U (L/O 0301)


SRS side airbags and curtain shield airbags


The SRS (Supplemental Restraint Sys- tem) side airbags and curtain shield air- bags are designed to provide further protection for the driver, front passen- ger and rear outside passengers in addition to the primary safety protec- tion provided by the seat belts.


62


the seat belts


In response to a severe side impact, the SRS side airbags and curtain shield air- bags work with to help reduce injury by inflating. The SRS side airbags help to reduce injuries mainly to the driver’s or front passenger’s chest and the SRS curtain shield airbags help to reduce injuries mainly to the driver’s, front passenger’s or rear outside passenger’s head. The SRS side airbag and curtain shield airbag on the passenger side are activated even with no passenger in the front seat or rear seat. The curtain shield airbags may activate even when the side airbags are not acti- vated. Be sure to wear your seat belt properly. Your vehicle is equipped with a crash sensing and diagnostic module, which will record the use of the seat belt restraint system by the driver when the SRS side airbags and curtain shield airbags are in- flated.


CAUTION


inflate with


injury when they


SRS side airbags and curtain shield airbags considerable force. To avoid potential death or se- rious inflate, the driver, front passenger and rear out- side passengers must: D Wear their seat belts properly. D Remain properly seated with their back upright and against the seat at all times.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


light system monitors


This indicator comes on when the igni- tion key is turned to the “ON” position. It goes off after about 6 seconds. This means the SRS side airbags and curtain shield airbags are operating properly. This warning the airbag sensor assembly, front airbag sen- sors, side and curtain shield airbag sen- sors, curtain shield airbag sensors, driv- er’s seat position sensor, driver’s seat belt buckle switch, front seat belt pretensioner assemblies, inflators, warning light, inter- connecting wiring and power sources. (For details, see “Service reminder indicators and warning buzzers” on page 105 in Sec- tion 1−5.)


inflate


The SRS side airbag and curtain shield airbag system may not if the vehicle is subjected to a collision from the side at certain angles, or a collision to the side of the vehicle body other than the passenger compartment as shown in the illustration. The SRS side airbags and curtain shield airbags are designed to inflate when the passenger compartment area suffers a se- vere impact from the side. Always wear your seat belts properly.


Collision from the rear


Collision from the front


Vehicle rollover


The SRS side airbags and curtain shield airbags are not designed to inflate if the vehicle is involved in a front or rear collision, if it rolls over, or if it is involved in a low−speed side collision.


63


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


The SRS side airbag and curtain shield airbag system is controlled by the airbag sensor assembly. The airbag sensor as- sembly consists of a safing sensor and airbag sensor. the side and In a severe side impact, curtain shield airbag sensor and/or the curtain shield airbag sensor trigger(s) the side airbag and curtain shield airbag inflat- ors and/or the curtain shield airbag inflat- ors. At this time a chemical reaction in the inflators quickly fills the airbags with non−toxic gas to help restrain the lateral motion of the occupants. When the airbags inflate, they produce a fairly loud noise and release some smoke and residue along with non−toxic gas. This does not indicate a fire. This gas is nor- mally harmless; however, for those who have delicate skin, it may cause a minor skin irritation. Be sure to wash off any residue as soon as possible to prevent any potential skin irritation. Deployment of the airbags happens in a fraction of a second, so the airbags must inflate with considerable force. While the system is designed to reduce serious inju- ries, it may also cause minor burns or abrasions and swelling.


Front seats as well as parts of the front and rear pillars, and roof side may be hot for several minutes, but the airbags them- selves will not be hot. The airbags are designed to inflate only once.


CAUTION


D The SRS side airbag and curtain shield airbag system is designed only as a supplement to the prima- ry protection of the driver side, and front and rear outside passenger side seat belt systems. To ensure maximum protection in an accident, the driver and all passengers in the vehicle must wear their seat belts. Wearing a seat belt during an acci- dent reduces the chances of death or serious injury or being thrown out of the vehicle. For instructions and precautions concerning the seat belt system, see “Seat belts” on page 45 in this section.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


The SRS side airbag and curtain shield airbag system mainly consists of the fol- lowing components, and their locations are shown in the illustration. 1. SRS warning light 2. Curtain shield airbag modules


(airbag and inflator)


3. Side airbag modules


(airbag and inflator)


4. Curtain shield airbag sensors 5. Side and curtain shield airbag sensors 6. Airbag sensor assembly


64


D Improperly seated and/or restrained infants and children can be killed or seriously injured by a deploying airbag. An infant or child who is too small to use a seat belt should be properly secured using a child restraint system. Toyota strongly recommends infants and children be placed in the rear seat of re- strained. The rear seat is the safest for in- structions concerning the installa- tion of a child restraint system, see “Child restraint” on page 69 in this section.


the vehicle and properly


infants and children. For


that all


’03Camry_U (L/O 0301)


D Do not allow a child to lean his/her head or any part of his/her body against the front door or the area of the seat, front pillar, rear pillar or roof side from which the side airbag and curtain shield airbag deploy even if he/she is seated in the child restraint system. It is dan- gerous if the side airbag and cur- tain shield airbag inflate, and the impact could cause death or seri- ous injury to the child. For instruc- tions concerning the installation of a child restraint system, see “Child restraint” on page 69 in this sec- tion.


D Do not lean against the door when the vehicle is in use, since the side airbag and curtain shield airbag in- flate with considerable speed and force. Otherwise, you may be killed or seriously injured. Special care should be taken especially when you have a small child in the ve- hicle.


D Sit up straight and well back in the seat, distributing your weight evenly in the seat. Do not apply excessive weight to the outer side of the front seats with a side airbag, and to the front pillar, rear pillar and roof side rail with a curtain shield airbag.


65


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


D Do not get your head closer to the area where the side airbag and cur- tain shield airbag inflate, since these airbags inflate with consider- able speed and force. Otherwise, you may be killed or seriously in- jured. Special care should be taken especially when you have a small child in the vehicle.


D Do not allow a child to kneel on the passenger seat facing the passen- ger’s side door, since the side air- bag and curtain shield airbag inflate with considerable speed and force. Otherwise, the child may be killed or seriously injured.


D Do not attach a cup holder or any other device or object on or around the door. When the side airbag in- flates, the cup holder or any other device or object will be thrown with great force or the side airbag may not activate correctly, resulting in injury. Likewise, death or serious the driver and front passenger should not hold objects their arms or on their knees.


in


66


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


D Do not hook a hanger, heavy or sharp pointed objects on the coat hook. If the curtain shield airbag inflates, those items will be thrown away with great force or the curtain shield airbag may not activate cor- rectly. When you hang clothes, hang them on the coat hook direct- ly.


D Do not use seat accessories which cover the parts where the side air- bags inflate. Such accessories may prevent the side airbags from acti- vating correctly, causing death or serious injury.


D Do not modify or replace the seats or upholstery of front seats with side airbags. Such changes may disable the system or cause the side airbags to inflate accidentally, resulting in death or serious injury.


D Do not disassemble or repair the front pillar, rear pillar and roof side rail containing the curtain shield airbags. Such changes may disable the system or cause the curtain shield airbags to inflate accidental- ly, resulting in death or serious in- jury.


Failure to follow these instructions can result in death or serious injury. Consult your Toyota dealer about any repairs and modifications.


NOTICE


consulting


Do not perform any of the following changes without your Toyota dealer. Such changes can interfere with proper operation of the SRS side airbag and curtain shield airbag system in some cases. z Installation of electronic devices such as a mobile two−way radio, cassette tape player or compact disc player


z Modification of the suspension sys-


tem


67


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


D Do not attach a microphone or any other device or object around the part where the curtain shield airbag activates such as on the windshield glass, side door glass, front and rear pillars, roof side and assist grips. When the curtain shield air- bag inflates, the microphone or oth- er device or object will be thrown with great the curtain shield airbag may not activate cor- rectly, resulting in death or serious injury.


force or


’03Camry_U (L/O 0301)


z Modification of the side structure of


the passenger compartment


z Repairs made on or near the con-


sole


If either of this occurs,


This SRS side airbag and curtain shield airbag system has a service reminder indicator to inform the driver of operating problems. following conditions malfunction of the airbags. Contact your Toyota dealer as soon as possible to service the vehicle. D The light does not come on when the ignition key is turned to the “ON” posi- tion, or the light remains on.


the indicates


D The light comes on or flashes while


driving.


68


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


In the following cases, contact your Toyota dealer as soon as possible: D The SRS side airbags and curtain


shield airbags have been inflated.


D The portion of the doors (shaded in the illustration) was involved in an accident that was not severe enough to cause the SRS side airbags and curtain shield airbags to inflate.


D The surface of the seats with the side airbag (shaded is scratched, cracked, or otherwise dam- aged.


illustration)


the


in


D The portion of


roof side


the front pillars, rear pillars and rail garnishes (padding) containing the curtain shield airbags inside (shaded in the illustra- tion) is scratched, cracked, or other- wise damaged.


NOTICE


Do not disconnect the battery cables before contacting your Toyota dealer.


’03Camry_U (L/O 0301)


Child restraint— —Child restraint precautions Toyota strongly urges the use of child restraint systems for children small enough to use them. The laws of all 50 states in the U.S.A. and Canada now require the use of a child restraint system. Your vehicle conforms to SAEJ1819. If a child is too large for a child restraint system, the child should sit in the rear seat and must be restrained using the vehicle’s seat belt. See “Seat belts” on page 45 for details.


CAUTION


D For effective protection in automo- bile accidents and sudden stops, a child must be properly restrained, using a seat belt or child restraint system depending on the age and size of the child. Holding a child in your arms is not a substitute for a child restraint system. In an acci- dent, the child can be crushed against the windshield, or between you and the vehicle’s interior.


D Toyota strongly urges use of a proper child restraint system which conforms to the size of the child, installed on the rear seat. Accord- ing to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat. D Never install a rear−facing child re- straint system on the front seat. In the event of an accident, the force of the rapid inflation of the airbag can cause death or serious injury if a rear−facing child restraint system is installed on the front seat.


the


D A forward−facing child restraint sys- to be tem should be allowed front passenger installed on seat only when it is unavoidable. Always move the seat as far back as possible, because the force of the deploying front passenger air- bag could cause death or serious injury to the child.


69


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


D On vehicles with side airbags and curtain shield airbags, do not allow the child to lean against the door or around the door even if the child is seated in the child restraint sys- tem. It is dangerous if the side air- bag and curtain shield airbag in- flate, and the impact could cause death or serious injury to the child. D Make sure that you have complied with all installation instructions pro- vided restraint manufacturer and that the system is properly secured.


child


the


by


70


’03Camry_U (L/O 0301)


—Child restraint system A child restraint system for a small child or baby must itself be properly restrained on the seat with the lap por- tion of the lap/shoulder belt. You must carefully consult the manufacturer’s in- structions which accompany the child restraint system. To provide proper restraint, use a child restraint system following the manufactur- er’s instructions about the appropriate age and size of the child for the child restraint system. Install the child restraint system correctly following the instructions provided by its manufacturer. General directions are also provided under the following illustrations. restraint system should be The child installed on the rear seat. According to accident statistics, the child is safer when properly restrained in the rear seat than in the front seat.


CAUTION


D Never install a rear−facing child re- straint system on the front seat. In the event of an accident, the force of the rapid inflation of the airbag can cause death or serious injury if a rear−facing child restraint system is installed on the front seat.


the


D A forward−facing child restraint sys- to be tem should be allowed front passenger installed on seat only when it is unavoidable. Always move the seat as far back as possible, because the force of the deploying front passenger air- bag could cause death or serious injury to the child.


D On vehicles with side airbags and curtain shield airbags, do not allow the child to lean against the door or around the door even if the child is seated in the child restraint sys- tem. It is dangerous if the side air- bag and curtain shield airbag in- flate, and the impact could cause death or serious injury to the child.


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


D After


installing the child restraint system, make sure it is secured in place following the manufacturer’s instructions. If it is not restrained securely, it may cause death or se- rious the event of a sudden stop or accident.


the child


injury


to


in


When not using the child restraint system, keep it secured with the seat belt or place it in the trunk or somewhere other than the passenger compartment. This will pre- vent the event of a sudden stop or accident.


injuring passengers


from


in


it


’03Camry_U (L/O 0301)


—Types of child restraint system Child restraint systems are classified into the following 3 types depending on the child’s age and size. (A) Infant seat (B) Convertible seat (C) Booster seat Install the child restraint system following the instructions provided by its manufac- turer. Your vehicle has anchor brackets for se- curing the top strap of a child restraint system. For instructions about how to use the an- chor bracket, see “—Using a top strap” on page 81 in this section. The child restraint lower anchorages ap- proved for your vehicle may also be used. See “—Installation with the child restraint lower anchorages” on page 83 in this sec- tion.


(A) Infant seat


(B) Convertible seat


71


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


—Installation with seat belt


(C) Booster seat


(A) INFANT SEAT INSTALLATION An infant seat is used in rear−facing position only.


CAUTION


D Never install a rear−facing child re- straint system on the front passen- ger seat because the force of the rapid inflation of the front passen- ger airbag can cause death or seri- ous injury to the child.


72


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


1. Run the lap and shoulder belt through or around the infant seat following the instructions provided by its manufactur- er and insert the tab into the buckle taking care not to twist the belt. Keep the lap portion of the belt tight.


CAUTION


D After inserting the tab, make sure the tab and buckle are locked and that the lap and shoulder portions of the belt are not twisted.


D Do not insert coins, clips, etc. in the buckle as this may prevent you from properly latching the tab and buckle.


D If the seat belt does not function it cannot protect your normally, child injury. Contact your Toyota dealer immediately. Do not use the child restraint system until the seat belt is fixed.


from


73


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


the


lock mechanism of


D Do not install a child restraint sys- tem on the rear seat if it interferes with the front seats. This can cause death or serious injury to the child and front passenger in case of sudden brak- ing or a collision.


D If the driver’s seat position does not allow sufficient space for safe the child installation, install re- straint system on the rear right seat.


’03Camry_U (L/O 0301)


2. Fully extend the shoulder belt to put it in the lock mode. When the belt is then retracted even slightly, it cannot be extended.


the


To hold infant seat securely, make sure the belt is in the lock mode before letting the belt retract.


3. While pressing the infant seat


firmly against the seat cushion and seatback, let the shoulder belt retract as far as it will go to hold the infant seat secure- ly.


CAUTION


Push and pull the child restraint sys- tem in different directions to be sure it is secure. Follow all the installation instructions provided by its manufac- turer.


74


2003 CAMRY from Jan. ’03 Prod. (OM33593U)


’03Camry_U (L/O 0301)


4. To remove the infant seat, press the buckle−release button and allow the belt to retract completely. The belt will move to work for an adult or older child passen- ger.


freely again and be ready


(B) CONVERTIBLE SEAT INSTALLATION A convertible seat is used in forward− facing or rear−facing position depend- ing on the child’s age and size. When installing, follow the manufacturer’s in-

Loading...
x