Login- Download PDF Manual
-
191
’01CAMRY CNG (L/O0009)
Checking and replacing fuses
Type A
Good
Blown
Type B
Good
Blown
Type C
Good
Blown
If the headlights or other electrical components do not work, check the fuses. If any of the fuses are blown, they must be replaced. See “Fuse locations” in Section 7−1 for locations of the fuses. Turn the ignition switch and inoperative component off. Pull a suspected fuse straight out and check it. Determine which fuse may be causing the problem. The lid of the fuse box shows the name of the circuit for each fuse. See Section 8 of this manual for the functions controlled by each circuit.
192
2001 CAMRY CNG_U (OM33542U)
can
you
Type A fuses can be pulled out by the pull−out tool. The location of the pull−out tool is shown in the illustration. If you are not sure whether the fuse has blown, try replacing the suspected fuse with one that you know is good. If the fuse has blown, push a new fuse into the clip. Only install a fuse with the amperage rat- ing designated on the fuse box lid. If you do not have a spare fuse, in an emergency the “A/C” “MIRROR−HEATER”, fuse, which may be dispensable for normal driving, and use it if its amperage rating is the same. If you cannot use one of the same amper- age, use one that is lower,but as close as possible to, the rating. If the amperage is lower than that specified, the fuse might blow out again but this does not indicate anything wrong. Be sure to get the correct fuse as soon as possible and return the substitute to its original clip. It is a good idea to purchase a set of spare fuses and keep them in your ve- hicle for emergencies.
“DOME” or
pull
out
’01CAMRY CNG (L/O0009)
the new
If fuse immediately blows out, there is a problem with the electrical sys- tem. Have your authorized Toyota CNG dealer correct it as soon as possible.
CAUTION
Never use a fuse with a higher am- perage rating, or any other object, in place of a fuse. This may cause ex- tensive damage and possibly a fire.
Adding washer fluid If any washer does not work or low windshield washer fluid level warning light comes on, the washer tank may be empty. Add washer fluid. You may use plain water as washer fluid. in cold areas where tempera- However, tures freezing point, use fluid containing antifreeze. This washer product is available at your authorized Toyota CNG dealer and most auto parts stores. Follow the manufacturer’s direc- tions for how much to mix with water.
range below
NOTICE
Do not use engine antifreeze or any other substitute because it may dam- age your vehicle’s paint.
following
illustrations show how
Replacing light bulbs— The to gain access to the bulbs. When replacing a bulb, make sure the ignition switch and light switch are off. Use bulbs with the wattage ratings given in the table.
CAUTION
Halogen bulbs have pressurized gas inside and require special handling. They can burst or shatter if scratched or dropped. Hold a bulb only by its plastic or metal case. Do not touch the glass part of a bulb with bare hands.
NOTICE
Only use a bulb of the listed type.
2001 CAMRY CNG_U (OM33542U)
193
’01CAMRY CNG (L/O0009)
W Type
A: HB3 halogen bulbs B: HB4 halogen bulbs C: Single end bulbs D: Wedge base bulbs E: Wedge base bulbs (amber) F: Double end bulbs
the
The inside of the lens of exterior lights such as headlights may temporarily fog up when the lens becomes wet in the rain or in a car wash. This is not a problem because the is caused by fogging temperature difference between the outside and the windshield fogged up in the rain. However, if there is a large drop of water on the inside of the lens, or if there is water pooled the light, contact your Toyota CNG dealer.
inside of
inside
lens,
just
like
the
Light bulbs
Headlights (high)
Headlights (low)
Parking, front side marker and front turn signal lights
Rear side marker lights
Rear turn signal lights
Stop/tail lights
Back−up lights
Bulb No. 9005
9006
3157
NA3156
or
3157
3157921
194
3.8
60
51
27/8
27
27/8
18
18
10
1.2
3.8
License plate lights —
High mounted stoplight Interior light
Glove box light
Trunk light
21CP
—
—
—
194
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
—Headlights
Low beam
Hi beam
1. Open the hood. Turn the bulb base counterclockwise to the front of the vehicle as shown.
2. Unplug the connector while depress-
ing the lock release.
If the connector is tight, wiggle it.
3. Install a new bulb and connector
into the mounting hole.
Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your authorized Toyota CNG dealer.
2001 CAMRY CNG_U (OM33542U)
195
’01CAMRY CNG (L/O0009)
—Parking, front side marker and front turn signal lights
Use a flat−bladed screwdriver. Remove and install the cover clips as shown in the following illustrations.
Removing the cover clips
Use a flat−bladed screw driver. To protect the surface, place several sheets of paper over the surface.
196
2001 CAMRY CNG_U (OM33542U)
Installing the cover clips
’01CAMRY CNG (L/O0009)
—Rear side maker, rear turn signal and stop/tail lights
Use a Phillips−head screwdriver. Remove and install the cover clips as shown in the following illustrations.
Removing the cover clips
2001 CAMRY CNG_U (OM33542U)
197
Installing the cover clips
’01CAMRY CNG (L/O0009)
—Stop/tail lights
a: Rear side marker light b: Rear turn signal light c: Stop/tail light
198
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
—Back−up lights
Use a flat−bladed screwdriver.
2001 CAMRY CNG_U (OM33542U)
199
’01CAMRY CNG (L/O0009)
—License plate lights
Remove and shown in the following illustrations.
install the cover clips as
Removing the cover clips
200
2001 CAMRY CNG_U (OM33542U)
Installing the cover clips
’01CAMRY CNG (L/O0009)
—High mounted stoplight
2001 CAMRY CNG_U (OM33542U)
201
’01CAMRY CNG (L/O0009)
202
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
SECTION 8
SPECIFICATIONS Dimensions and weight Engine Fuel Service specifications Tires Fuses
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
204
204
204
205
207
2072001 CAMRY CNG_U (OM33542U)
203
’01CAMRY CNG (L/O0009)
Fuel Fuel type:
Compressed natural gas
Service pressure:
line, CNG (Compressed
24800 kPa (3600 psig)
Equivalent gasoline capacity:
43 L (11.4 gal., 9.5 lmp.gal.)
Water volume:
135 L (35.7 gal., 29.7 lmp.gal.)
Dimensions and weight Overall length mm (in.) Overall width mm (in.) Overall height mm (in.) mm (in.) Wheelbase mm (in.) Front tread Rear tread mm (in.) Vehicle capacity weight (occupants + luggage)
4790 (188.6) 1780
(70.1) (55.9)∗ 1419
2670 (105.1) (60.9) 1548
1519
(59.8)∗: Unladen vehicle
kg (lb)
410
(900)
Engine Model:
5S−FNE
Type:
4 cylinder Natural Gas)
in
Bore and stroke, mm (in.):
87.0 91.0 (3.43 3.58)
Displacement, cm3 (cu. in.):
2164 (132.0)
204
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Service specifications ENGINE Valve clearance (engine cold), mm (in.):
Intake Exhaust
0.19—0.29 (0.007—0.011) 0.28—0.38 (0.011—0.015)
ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.):
With filter Without filter
3.6 (3.8, 3.2) 3.4 (3.6, 3.0)
Spark plug type:
DENSO
PK20TR8−G
Oil grade:
Spark plug gap, mm(in.):
0.8 (0.031) belt
Drive Borroughs No.BT−33−73F (used belt), Ibf:
tension measured with gauge
tension
drive
belt
API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recom- mended.
Recommended oil viscosity (SAE):
Generator belt Power steering pump belt
130"10
80"205W-30 Preferred
Temperature range anticipated before next oil change
COOLING SYSTEM Total capacity, L (qt., Imp. qt.):
6.9 (7.3, 6.1)
Coolant type:
“TOYOTA Long Life Coolant” or equiva- lent With ethylene−glycol type coolant for a proper corrosion protection of aluminum components Do not use alcohol type antifreeze or plain water alone.
BATTERY Open voltage∗ at 20_C (68_F): 12.6—12.8V Fully charged 12.2—12.4V Half charged 11.8—12.0V Discharged
∗: Voltage that is checked 20 minutes af- the
is removed with all
the key
ter lights turned off
Charging rates:
5 A max.
If
the
Note: is necessary, make sure to do so with a battery that is the same standard as the original.
replacement
2001 CAMRY CNG_U (OM33542U)
205
’01CAMRY CNG (L/O0009)
Fluid type:
SAE J1703 or FMVSS No.116 DOT 3
STEERING Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type:
Automatic transmission fluid DEXRONrII or III
AUTOMATIC TRANSAXLE Automatic transmission
Fluid capacity (drain and refill), L (qt., Imp. qt.):
Up to 2.5 (2.6, 2.2)
Fluid type:
Automatic DEXRONrIIl (DEXRONrII)
transmission
fluid D−ll or
Differential
Fluid capacity L (qt., Imp. qt.):
1.6 (1.7, 1.4)
Fluid type:
Automatic DEXRONrIII (DEXRONrII)
transmission
fluid D−II or
BRAKES Minimum pedal clearance when depressed with the force of 490 N (50 kgf, 110 lbf) with the engine running, mm (in.):
70 (2.8)
Pedal free play, mm (in.):
1—6 (0.04—0.24)
Pad wear limit, mm (in.):
1.0 (0.04)
Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment when pulled with the force of 196 N (20 kgf, 44 lbf):
5—8 clicks
206
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Fuses
Tires
Tire size:
Spare tire Except spare tire
T145/80R16 105M P205/65R15 92H
Tire pressure, kPa (kgf/cm2 or bar, psi):
Spare tire Except spare tire
420 (4.2, 60)
Normal driving
For all loads including full rated loads For reduced loads (1 to 4 passengers)
Trailer driving
220 (2.2, 32) 200 (2.0, 29) 220 (2.2, 32)
When driving under the above vehicle load conditions at sustained high speeds above 160 km/h (100 mph), in countries where such speeds are permitted by−law, inflate the front and rear tires to 240 kPa (2.4 kgf/cm2 or bar, 35 psi) provided that it does not exceed the maximum cold tire pressure molded on the tire sidewall.
Wheel size: Spare tire Except spare tire
4T 15 6JJ
Wheel nut torque, N·m (kgf·m, ft·lbf):
104 (10.5, 77)
NOTE: For a complete
tires or replacing wheels), see “Checking tire pressure” through “Replacing wheels” in Section 7−2.
tires (e.g. replacing
information on
2001 CAMRY CNG_U (OM33542U)
207
Engine compartment
’01CAMRY CNG (L/O0009)
Engine compartment
Engine compartment
Instrument panel
Fuses (type A) 1. A/C 10 A: Air conditioning system 2. SPARE 10 A: Spare fuse 3. SPARE 15 A: Spare fuse 4. SPARE 30 A: Spare fuse 5. ALT−S 5 A: Charging system 6. HEAD (RH) 20 A: Right−hand headlight 7. EFI 20 A: Multiport fuel injection sys- injection
tem/sequential multiport system, A/F sensor 8. HORN 10 A: Horn 9. HAZARD 15 A: Emergency flasher
fuel
208
10. AM2 30 A: Gauge and meter, SRS airbag system, seat belt pretensioners, multiport fuel injection system/sequen- tial multiport injection system, “IGN” and “STARTER” fuses
fuel
11. TEL 5 A: No circuit 12. HEAD (LH) 20 A: Left−hand headlight 13. RADIO NO.1 20 A: Audio system 14. DOME 7.5 A: Clock,
ignition switch light, power
interior
trunk
light, light, door lock system
15. ECU−B 10 A: Anti−lock brake system, SRS airbag system, seat belt preten- sioners
2001 CAMRY CNG_U (OM33542U)
16. A/F HTR 25 A: No circuit 17. DOOR SUB 25A: No circuit 18. INJ 20 A: Multiport fuel injection sys- injection
tem/sequential multiport system, starting system
fuel
19. DRL NO.2 5 A: No circuit 20. H−LP LH (LWR) 15 A: No circuit 21. H−LP RH (LWR) 15 A: No circuit 22. SEAT−HEATER 20 A: No circuit 23. HEATER 10 A: Air conditioning system,
rear window defogger
24. GAUGE 10 A: Gauges and meters, back−up lights, cruise control system, charging system, power windows, ser- vice reminder indicators and warning buzzers
25. WIPER 25 A: Windshield wipers and
washer
26. MIRROR−HEATER 10 A: Outside rear
view mirror defogger
27. ECU−IG 15 A: Cruise control system, anti−lock brake system, SRS airbag system, seat belt pretensioners, shift lock control system, multiport fuel in- jection system/sequential multiport fuel injection system
28. IGN 5 A: Gauges and meters, charging system, SRS airbag system, seat belt injection pretensioners, multiport system/sequential multiport injec- tion system
fuel
fuel
29. STOP 15 A: Stop lights, cruise control system, high−mounted stoplight, anti− lock brake system, shift lock control system, multiport fuel injection system/ sequential multiport fuel injection sys- tem
’01CAMRY CNG (L/O0009)
tail
30. TAIL 10 A: Parking lights, license plate front side marker lights, lights, multiport fuel injection system/ sequential multiport fuel injection sys- tem
lights,
31. POWER−OUTLET 15 A: Power outlet 32. OBD 7.5 A: On−board diagnosis sys-
tem
33. FOG 15 A: No circuit 34. STARTER 5 A: Gauges and meters, multiport fuel injection system/sequen- tial multiport fuel injection system
35. DOOR 25 A: Power door lock system 36. PANEL 7.5 A: Gauge and meter, audio system, cigarette lighter, glove box light, clock, instrument panel light con- indicators, air trol, service conditioning control panel lights, ash- tray light, emergency flasher, rear win- dow defogger, electronically controlled automatic transmission system
reminder
37. TURN 7.5 A: Emergency flasher 38. RAD−NO.2 7.5 A: Audio system 39. CIG 15 A: Cigarette lighter, shift lock control system, power rear view mirror controls, power door lock system, SRS airbag system, seat belt pretensioners, air conditioning system
2001 CAMRY CNG_U (OM33542U)
Fuses (type B) 40. CDS 30 A: Electric cooling fans 41. RDI 30 A: Electric cooling fans 42. MAIN 40 A: “HEAD (RH)” and “HEAD
(LH)” fuses
43. HTR 50 A: “AM1” and “A/C” fuses 44. DEF 40 A: Rear window defogger 45. PWR 30 A: Power window control sys-
tem
46. AM1 40 A: “POWER−OUTLET”, “CIG”, “RAD−NO.2”, “TURN”, “WIPER”, “ECU− IG”, “GAUGE”, and “HEATER” fuses
47. CDS NO.2 30 A: No Circuit Fuses (type C) 48. ALT 100 A: “RDI” and “CDS” fuses 49. FL ABS 60 A: Anti−lock brake system
209
’01CAMRY CNG (L/O0009)
210
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
SECTION 9
REPORTING SAFETY DEFECTS FOR U.S. OWNERS AND UNIFORM TIRE QUALITY GRADING Reporting safety defects for U.S. owners Uniform tire quality grading
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
212
2122001 CAMRY CNG_U (OM33542U)
211
’01CAMRY CNG (L/O0009)
To contact NHTSA, you may ei- ther call the Auto Safety Hotline toll−free at 1−800−424−9393 (or 366−0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hot- line.
Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.
campaign.
212
2001 CAMRY CNG_U (OM33542U)
Uniform tire quality grading This information has been prepared in ac- cordance with regulations issued by the National Highway Traffic Safety Adminis- tration of the U.S. Department of Trans- portation. It provides the purchasers and/ or prospective purchasers of Toyota vehicles with information on uniform tire quality grading. Your authorized Toyota CNG dealer will help answer any questions you may have as you read this information. DOT quality grades—All passenger car tires must conform to Federal Safety Requirements these grades. Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A
in addition
to
from
treadwear grade
Treadwear—The is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150
would wear one and a half (1−1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual condi- tions of their use, however, and may de- part significantly the norm due to variations in driving habits, service prac- tices and differences in road characteris- tics and climate. Traction AA, A, B, C—The traction grades, from highest to lowest, are AA, A, B, and C, and they represent the tire’s ability to stop on wet pavement as mea- sured under controlled conditions on spe- cified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this is based on braking (straight ahead) traction tests and does not include cornering (turning) traction.tire
’01CAMRY CNG (L/O0009)
Temperature A, B, C—The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissi- pate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to de- generate and reduce tire life, and exces- sive temperature can lead to sudden tire failure. The grade C corresponds to a lev- el of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No. 109. Grades B and A represent higher levels of perfor- mance on the laboratory test wheel than the minimum required by law. Warning: The temperature grades for this tire are established for a tire that is prop- erly inflated and not overloaded. Exces- sive speed, underinflation, or excessive loading, either separately or in combina- tion, can cause heat buildup and possible tire failure.
2001 CAMRY CNG_U (OM33542U)
213
’01CAMRY CNG (L/O0009)
214
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Important information about this manual
Safety and vehicle damage warnings
Safety symbol
Throughout this manual, you will see safety and vehicle dam- age warnings. You must follow these warnings carefully to avoid possible injury or damage. The types of warnings, what they look like, and how they are used in this manual are explained as follows:
CAUTION
This is a warning against something which may cause injury to people if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk to yourself and other people.
NOTICE
This is a warning against something which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed about what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.
the safety symbol When you see shown above, it means: “Do not...”; “Do not do this”; or “Do not let this happen”.
ii
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Important information about your Toyota
New vehicle warranty
Your new vehicle limited warranties:
is covered by
the
following Toyota
D New vehicle warranty D Emission control systems warranty D Others further
information, please refer
For Manual Supplement”.
to
the “Owner’s
Your responsibility for maintenance
It is the owner’s responsibility to make sure that the specified maintenance is performed. Section 6 gives de- tails of these maintenance requirements. Also included is general maintenance. For scheduled in Section 6 maintenance the “Owner’s Manual Supplement”.
information, please refer
to
Accessories, spare parts and modification of your Toyota
A wide variety of non−genuine spare parts and accesso- ries for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these products and is not responsible for their perfor- mance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle.
This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durabili- ty, and may even violate governmental regulations. In addition, damage or performance problems resulting from the modification may not be covered under warranty.
iii
2001 CAMRY CNG_U (OM33542U)
Installation of a mobile two−way radio system
fuel
injection system/sequential multiport
As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as multiport fuel injection system, cruise control system, anti−lock brake system, SRS airbag system and seat belt pretensioner system, be sure to check with your authorized Toyota CNG dealer for precautionary measures or special instructions regarding installation.
’01CAMRY CNG (L/O0009)
Scrapping of your Toyota
The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. If the vehicle is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt pretensioner removed and disposed of by the quali- fied service shop or by your authorized Toyota CNG dealer before you dispose of your vehicle.
iv
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Precautions for CNG
Refueling station information
Your vehicle may use compressed natural gas (CNG) for fuel.
D Handle the CNG vehicle with care as the fuel tank and pipes of it are filled with extremely high pres- sure gas. In this case, close the manual shutoff valve and have your authorized Toyota CNG dealer carry out an inspection.
D You will be able to tell if fuel is leaking out of the vehicle by the sound of the leaking fuel and the smell of the fuel.
D Be careful not to run out of fuel. There are less CNG stations than gasoline stations so we recom- mend that you refuel early.
For details, see “Fuel” and “Fuel system” in Section 2.
For information on refueling stations for CNG, contact Natural Gas Vehicle Coalition (NGVC) at the address and numbers listed below.
Natural Gas Vehicle Coalition
1515 Wilson Blvd. Arlington, Va. 22209
Phone: (703) 527−3022
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
vi
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Foreword
Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the operation of your new Toyota. Please read it thoroughly and have all the occupants follow the instructions carefully. Doing so will help you enjoy many years of safe and trouble−free motoring. For important information about this manual and your Toyota, read the follow- ing pages carefully. When it comes to service, remember that your authorized Toyota CNG dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality maintenance and any other assistance you may require. Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improvement, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle.
© 2000 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Quick index D If a service reminder indicator or warning buzzer comes on 70
D If your vehicle will not start 142
D If your engine stalls while driving 145
D If your vehicle overheats 145
D If you have a flat tire 146
D If your vehicle needs to be towed 154
D Tips for driving during break−in period 116
D How to start the engine 130
D General maintenance 167
D Complete index . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Gas station information Fuel type:. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Compressed natural gas See page 116 for detailed information.
Service pressure:
24800 kPa (3600 psig)
Equivalent gasoline capacity:
43 L (11.4 gal., 9.5 lmp. gal.)
Water volume:
135 L (35.7 gal., 29.7 lmp. gal.)
See page 118 for detailed information.
Engine oil:
API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recommended. See page 180 for detailed information.
Automatic transmission fluid:
Automatic transmission fluid D−II or DEXRONrIII (DEXRONrII)
Tire information: See pages 184 through 187. Tire pressure: See page 207.
2001 CAMRY CNG_U (OM33542U)
U −3
Publication No. OM33542U Part No. 01999-33542
Printed in Japan 01−0009−00CNG ( U)
’01CAMRY CNG (L/O0009)
You should know as much about the quality and importance of proper maintenance of your new vehicle as the people who built it.
The Toyota authorized Repair Manual tells you how to maintain your vehicle and enables you to correctly perform your own maintenance.
The best way to keep your new vehicle in top running order is to maintain it properly from the moment you drive it off the showroom floor.
The Toyota authorized Repair Manual is packed with literally everything you need to know to perform your own maintenance in virtually every area of your new vehicle.
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Maintenance procedures for the engine, chassis, body, electrical system, and more, are clearly explained and illustrated.
Periodic maintenance and tune−up
Periodic maintenance and tune−up helps to pre- vent small problems from growing into larger ones lat- er on. The repair manual outlines exactly what main- tenance is required and clearly explains how to do the work yourself step−by−step.
Areas covered include such things as spark plug re- placement, valve clearance adjustment and engine oil and filter replacement.
Where to obtain the
Repair Manual
The repair manual for CAMRY CNG, written in English, may be purchased as applicable from your authorized Toyota CNG dealer. Pub. Name: 2001 CAMRY CNG Repair Manual
Supplement
Pub. No.: RM830U (for CNG) Pub. Name: 2001 CAMRY Repair Manual Pub. No.: RM819U1 (Maintenance, Preparation, Service specifications and Diagnos- tics) RM819U2 (Engine, Chassis and Body)
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
SECTION 1− 1
OPERATION OF INSTRUMENTS AND CONTROLS Overview of instruments and controls Instrument panel overview Instrument cluster overview Indicator symbols on the instrument panelel
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Instrument panel overview
1. Side defroster outlets 2. Side vents 3. Instrument cluster 4. Center vents 5. Glove box 6. Garage door opener box or
auxiliary box
7. Power door lock switches 8. Power window switches 9. Cup holders 10. Cup holder or rear ashtray 11. Parking brake lever 12. Automatic transmission selector lever 13. Auxiliary box 14. Hood lock release lever 15. Window lock switch
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
1. Power rear view mirror control switches 2. Headlight and turn signal switch 3. Wiper and washer switches 4. Clock/outside temperature gauge 5. Emergency flasher switch 6. Car audio 7. Rear window and outside rear view
mirror defoggers switch 8. Air conditioning controls 9. Front ashtray 10. Power outlet 11. Cigarette lighter 12. Ignition switch 13. Cruise control switch 14. Tilt steering lock release lever 15. Instrument panel light control knob
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Instrument cluster overview
1. Engine coolant temperature gauge 2. Service reminder indicators and
indicator lights
3. Fuel gauge
4. Speedometer 5. Odometer and two trip meters 6. Tachometer
7. Trip meter reset knob 8. Low fuel level warning light
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Indicator symbols on the instrument panel
Brake system warning light∗1
Low windshield washer fluid level warning light∗1
Seat belt reminder light∗1
Discharge warning light∗1
Malfunction indicator lamp∗1
Turn signal indicator lights
Headlight high beam indicator light
Overdrive−off indicator light
Low oil pressure warning light∗1
Cruise control indicator light∗2
Anti−lock brake system warning light∗1
Automatic transmission indicator lights
Open door warning light∗1
Rear light failure warning light∗1
SRS warning light∗1
∗1: For details, see “Service reminder indicators and warning
buzzers” in Section 1−5.
∗2: If this light flashes, see “Cruise control” in Section 1−6.
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
SECTION 1− 2
OPERATION OF INSTRUMENTS AND CONTROLS Keys and Doors Keys Side doors Power windows Trunk lid Hood Refueling
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
10
12
14
152001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Keys
Side doors
Your vehicle is supplied with two kinds of keys. 1. Master key—This key works in every
lock.
2. Sub key—This key will not work in the
glove box and trunk.
To protect things locked in the glove box or trunk when you have your vehicle parked, leave the sub key with the atten- dant. Since lid can be locked without a key, you should always carry a spare master key in case you accidentally lock your keys inside the ve- hicle.
the doors and
trunk
KEY NUMBER PLATE Your key number is shown on the plate. Keep the plate in a safe place such as your wallet, not in the vehicle. If you should lose your keys or if you need additional keys, duplicates can be made by your authorized Toyota CNG dealer using the key number. We recommend you to write down the key number and keep it in safe place.
LOCKING AND UNLOCKING WITH KEY Insert the key into the keyhole and turn it. To lock: Turn the key forward. To unlock: Turn the key backward. All lock and unlock simulta- neously with either front door. In the driv- er’s door lock, turning the key once will unlock the driver’s door and twice in suc- cession will unlock all the doors simulta- neously.
the doors
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
LOCKING AND UNLOCKING WITH POWER DOOR LOCK SWITCH Push the switch. To lock: Push the switch on the front side. To unlock: Push the switch on the rear side. All the doors lock or unlock simultaneous- ly.
Driver’s side
LOCKING AND UNLOCKING WITH INSIDE LOCK BUTTON Move the lock button. To lock: Push the knob forward. To unlock: Pull the knob backward. Closing the door with the lock knob in the lock position will also lock the door. Be careful not to lock your keys in the ve- hicle. The door cannot be locked if you leave the key in the ignition switch.
Passenger’s side
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Power windows
CAUTION
Before driving, be sure that the doors are closed and locked, especially when small children are in the ve- hicle. Along with the proper use of seat belts, locking the doors helps prevent the driver and passengers from being thrown out from the ve- hicle during an accident. It also helps prevent the doors from being opened unintentionally.
The windows can be operated with the switch on each door. The power windows work when the ignition switch is in the “ON” position. Key off operation: If both front doors are closed, they work for 43 seconds even after the ignition switch is turned off. They stop working when either is opened. OPERATING THE DRIVER’S WINDOW Use the switch on the driver’s door. Normal operation: The window moves as long as you hold the switch. To open: Lightly push down the switch. To close: Pull up the switch.
front door
to
the
lock
lever
the “LOCK”
REAR DOOR CHILD−PROTECTORS Move position as shown on the label. This feature allows you to lock a rear door so it can be opened from the outside only, not from inside. We recommend us- ing this feature whenever small children are in the vehicle.
10
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
Window lock switch
Automatic operation (to open only): Push the switch completely down and then release it. The window will fully open. To stop the window partway, lightly pull the switch up and then release it.
THE
PASSENGERS’
OPERATING WINDOWS Use the switches on the passengers’ doors. The driver’s door also has switches that control the passengers’ windows. The window moves as long as you hold the switch. To open: Push down the switch. To close: Pull up the switch. If you push in the window lock switch on the driver’s door, the passengers’ windows cannot be operated.
2001 CAMRY CNG_U (OM33542U)
11
’01CAMRY CNG (L/O0009)
Trunk lid—
CAUTION
Keep the trunk lid closed while driv- ing. This not only keeps the luggage from being thrown out but also pre- vents exhaust gases from entering the vehicle.
“Luggage stowage precautions”
To open the trunk lid from the outside, insert the master key and turn it clock- wise. in See Section 2 for precautions in loading lug- gage. To close the trunk lid, lower it and press down on it. After closing the trunk lid, try pulling it up to make sure it is securely closed.
CAUTION
To avoid serious personal injury, you must do the following. D Always make sure the heads, hands and other parts of the bodies of all occupants are kept completely in- side the vehicle before you close the power windows. If someone’s neck, head or hands gets caught in a closing window, it could result in a serious injury. When anyone closes the power windows, make sure that he/she operates the win- dows safely.
D When small children are in the ve- hicle, never let them use the power window switches without supervi- sion. Use the window lock switch to prevent from making unex- pected use of the switches.
them
D Never leave small children alone in the vehicle, especially with the igni- tion key still inserted. They could use the power window switches and get in a window. Unat- tended children can be involved in serious accidents.
trapped
12
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
—Lock release lever
—Luggage security system
—Internal trunk release handle
To open the trunk lid from the driver’s seat, pull up on the lock release lever.
This system deactivates the lock re- lease lever so that things locked in the trunk can be protected. After closing the trunk lid, insert the master key and turn it counterclockwise to deactivate the lock release lever. After closing the trunk lid, try pulling it up to make sure it is securely locked.
If a person is locked in the trunk, pull down the phosphorescent handle (illu- minated for a while) on the inside of trunk lid in case of emergency to open the trunk lid. The handle illuminating time depends on the intensity of the light thrown on the handle.
2001 CAMRY CNG_U (OM33542U)
13
’01CAMRY CNG (L/O0009)
Hood
CAUTION
D Always lock the trunk lid and all doors, and keep away the vehicle keys out of children’s reaches.
D Never leave children unattended in the vehicle. Unsupervised children may lock themselves in the vehicle or trunk and suffer serious injuries or death.
To open the hood: 1. Pull the hood lock release lever. The
hood will spring up slightly.
CAUTION
Before driving, be sure that the hood is closed and securely locked. Other- wise, the hood may open unexpected- ly while driving and an accident may occur.
14
2001 CAMRY CNG_U (OM33542U)
2. In front of the vehicle, pull up the the
lever and
lift
auxiliary catch hood.
Before closing the hood, check to see that you have not forgotten any tools, rags, etc. Then lower the hood and make sure it If necessary, press down gently on the front edge to lock it.
into place.
locks
that
meets
Refueling— —Refueling precaution When refueling, you must use a special nozzle ANSI/AGA NGV−1−1994 standards. There are three types of nozzles. Use a P36 type nozzle for this vehicle. If a P36 nozzle is not available at a nearby CNG station, you may use another type of nozzle, but you cannot expect to get a completely full tank with it. For your safety, ask and follow the in- structions at the refueling station when refueling. Before starting to refuel, wipe off mud or dirt that may be deposited around the fuel receptacle. You will hear a chattering noise from the tank when it is being filled, but this is quite normal. If you hear fuel leaking from the fuel re- ceptacle, stop refueling immediately and have your authorized Toyota CNG dealer check the fuel receptacle. For information on CNG stations, refer to the station “Refueling station information” on page v in the beginning of this manual.
’01CAMRY CNG (L/O0009)
—Refueling method (high speed refueling)
CAUTION
D In order to safety refuel and avoid serious personal the CNG station staff to refuel the ve- hicle with CNG for you.
injury, ask
D Do not start the engine while refuel- ing. As the natural gas is flam- mable, an explosion or a fire could occur. Also, do not smoke or allow open flames when refueling. D If you smell or hear fuel
leaking while refueling, immediately stop re- fueling. Do not refuel it until after the leak has been repaired.
This indicates that the refueling plug door is on the left side of your vehicle.
2001 CAMRY CNG_U (OM33542U)
15
’01CAMRY CNG (L/O0009)
2. Remove the rubber cap. Check there is no mud or dirt around the fuel receptacle.
3. Fit the filling nozzle securely on the
fuel receptacle.
There are various types of filling nozzles so follow the instructions at each CNG station.
There are two ways of natural gas re- fueling: high and low speed. This manu- al explains typical high speed refueling. As for the low speed refueling method, follow the manufacturer for the refueling equipments. 1. To open the refueling plug door, pull
instructions provided by
the
the lever up. When refueling, turn off the engine.
16
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
5. Refueling will stop automatically when the tank is full. When discon- necting the filling nozzle, follow the instructions of the refueling station. Reverse the procedure to disconnect the nozzle after filling the tank. When disconnecting the filling nozzle, you may hear a brief hissing sound as a small amount of fuel escapes, but this is nor- mal.
4. Turn the valve lever to fasten the nozzle to the fuel receptacle and to start filling the tank.
2001 CAMRY CNG_U (OM33542U)
17
’01CAMRY CNG (L/O0009)
18
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
SECTION 1− 3
OPERATION OF INSTRUMENTS AND CONTROLS Seats, Seat belts, Steering wheel and Mirrors Seats Front seats Head restraints Seat belts SRS driver and front passenger airbagsgs Child restraint Tilt steering wheel Outside rear view mirrors Anti−glare inside rear view mirroror Sun visors
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
20
20
22
22
31
39
56
57
58
592001 CAMRY CNG_U (OM33542U)
19
’01CAMRY CNG (L/O0009)
Seats While the vehicle is being driven, all ve- hicle occupants should have the seatback upright, sit well back in the seat and prop- erly wear the seat belts provided.
Front seats— —Seat adjustment precautions Adjust the driver’s seat so that the foot pedals, steering wheel and instrument panel controls are within easy reach of the driver.
CAUTION
CAUTION
D While adjusting the seat, do not put your hands under the seat or near the moving parts. You may catch and injure your hands or fingers.
D Do not drive the vehicle unless the occupants are properly seated. Do top of a not allow sitting on folded−down seatback, or the luggage compartment. Persons not properly seated and/or properly re- strained by seat belts can be se- verely injured in the event of emer- gency braking or a collision.
in
D During driving, do not allow pas- to stand up or move sengers around between seats. Severe inju- ries can occur in the event of emer- gency braking or a collision.
D Adjustments should not be made while the vehicle is moving, as the seat may unexpectedly move and cause the driver to lose control of the vehicle.
D When adjusting the seat, be careful not to hit the seat against a pas- senger or luggage.
D After adjusting the seat position, try sliding it forward and backward to make sure it is locked in posi- tion.
D After adjusting the seatback, exert body pressure to make sure it is locked in position.
D Do not put objects under the seats. The objects may interfere with the seat−lock mechanism or unexpect- edly push up the seat position ad- justing lever; the seat may suddenly move, causing the driver to lose control of the vehicle.
20
2001 CAMRY CNG_U (OM33542U)
’01CAMRY CNG (L/O0009)
—Adjusting front seats
1. SEAT POSITION ADJUSTING LEVER Hold the center of the lever and pull it up. Then slide the seat to the desired position with slight body pressure and release the lever. 2. SEATBACK
ADJUSTING
ANGLE
LEVER
3. SEAT CUSHION HEIGHT ADJUSTING
KNOB
Turn the knob either way.
lever up. lean back to the desired angle
Lean forward and pull the Then and release the lever.
CAUTION
To reduce the risk of sliding under the lap belt during a collision, avoid reclining the seatback any more than needed. The seat belts provide maxi- mum protection in a frontal or rear collision when the driver and the pas- senger are sitting up straight and well back If you are reclined, the lap belt may slide past your hips and apply restraint forces directly to the abdomen. Therefore, in the event of a frontal collision, the risk of personal injury may increase with increasing recline of the seat- back.
in the seats.
2001 CAMRY CNG_U (OM33542U)
21
’01CAMRY CNG (L/O0009)
Head restraints
Front
Rear
22
For your safety and comfort, adjust the head restraint before driving. To raise: Pull it up. To lower: Push it down while pressing the lock release button. Front head restraint only—You can also move the head restraint forward or back- ward. If such adjustment is desired, pull or push on the top of the head restraint. The head restraint is most effective when it is close to your head. Therefore, using a cushion on the seatback is not recom- mended.
