Login- Download PDF Manual
-
ing life, brake cooling, speedometer/odom- eter calibration, stopping ability, headlight aim, bumper height, vehicle ground clear- ance, and tire or snow chain clearance to the body and chassis.
2000 CAMRY CNG (OM33519U)
181
CAUTION
D Do not drive with the snow tires
incorrectly inflated.
D Never drive over 120 km/h (75 mph)
with any type of snow tires.
TIRE CHAIN SELECTION Use the tire chains of correct size and type. Use SAE Class “S” type radial tire chains except radial cable chains or V−bar type chains. Regulations regarding the use of tire chains vary according to location or type of road, so always check them before installing chains. CHAIN INSTALLATION Install the chains on the front tires as tightly as possible. Do not use tire tires. Retighten chains on chains after km (1/4—1/2 mile). When installing chains on your tires, care- fully follow the instructions of the chain manufacturer.
rear driving
0.5—1.0
the
’00CAMRY CNG (L/O9908)
Replacement with used wheels is not rec- ommended as they may have been sub- jected to rough treatment or high mileage and could fail without warning. Also, bent wheels which have been straightened may have structural damage and therefore should not be used. Never use an inner tube in a leaking wheel which is designed for a tubeless tire.
182
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
SECTION 7− 3
DO−IT−YOURSELF MAINTENANCE Electrical components
Checking battery condition
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
184
Battery recharging precautions
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
185
Checking and replacing fuses
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
186
Adding washer fluid
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
187
Replacing light bulbs
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
187
2000 CAMRY CNG (OM33519U)
183
’00CAMRY CNG (L/O9908)
Checking battery condition— —Precautions
CAUTION
BATTERY PRECAUTIONS The battery produces flammable and explosive hydrogen gas. D Do not cause a spark from the bat-
tery with tools.
D Do not smoke or light a match near
the battery.
The electrolyte contains poisonous and corrosive sulfuric acid. D Avoid contact with eyes, skin or
clothes.
D Never ingest electrolyte. D Wear protective safety glasses when
working near the battery.
D Keep children away from the bat-
tery.
D If electrolyte gets on your skin, thoroughly wash the contact area. If you feel pain or burning, get medi- cal attention immediately.
D If electrolyte gets on your clothes, there is a possibility of its soaking through to your skin, so immediate- ly take off the exposed clothing and follow the procedure above, if nec- essary.
D If you accidentally swallow electro- lyte, drink a large quantity of water or milk. Follow with milk of magne- sia, beaten raw egg or vegetable oil. Then go immediately for emer- gency help.
EMERGENCY MEASURES D If electrolyte gets
in your eyes, flush your eyes with clean water immediately immediate medical attention. If possible, con- tinue to apply water with a sponge or cloth while en route to the medi- cal office.
and get
184
2000 CAMRY CNG (OM33519U)
—Checking battery exterior
Terminals
Ground cable
Hold−down clamp
Check the battery for corroded or loose terminal connections, cracks, or loose hold−down clamp. a. If the battery is corroded, wash it off with a solution of warm water and bak- ing soda. Coat the outside of the termi- nals with grease to prevent further cor- rosion.
b. If the terminal connections are loose, their clamp nuts—but do not
tighten overtighten.
c. Tighten
the hold−down clamp only enough to keep the battery firmly in place. Overtightening may damage the battery case.
’00CAMRY CNG (L/O9908)
—Checking battery fluid
NOTICE
Type A
z Be sure the engine and all accesso- ries are off before performing main- tenance.
z When checking the battery, remove the ground cable from the negative terminal (“−” mark) first and rein- stall it last.
z Be careful not to cause a short cir-
cuit with tools.
z Take care no solution gets into the
battery when washing it.
Green
Dark
Clear or light yellow
Type B
Blue
White
Red
CHECKING BY HYDROMETER Check hydrometer color.
the battery condition by
the
Hydrometer color
Type A
Type B
GREEN
BLUE
Condition
Good
DARK
WHITE
CLEAR or LIGHT YELLOW
RED
Charging necessary. Have battery checked by your authorized Toyota CNG dealer.
Have battery checked by your authorized Toyota CNG dealer.
Battery recharging precautions During recharging, the battery is pro- ducing hydrogen gas. Therefore, before recharging: 1. If recharging with the battery installed on the vehicle, be sure to disconnect the ground cable.
2. Be sure the power switch on the re- charger the charger cables to the battery and when disconnecting them.
is off when connecting
CAUTION
D Always charge the battery in an un- confined area. Do not charge the battery in a garage or closed room where there is not sufficient ventila- tion.
D Only do a slow charge (5 A or less). Charging at a quicker rate is dangerous. The battery may ex- plode, causing personal injuries.
NOTICE
Never recharge the battery while the engine is running. Also, be sure all accessories are turned off.
2000 CAMRY CNG (OM33519U)
185
’00CAMRY CNG (L/O9908)
Checking and replacing fuses
Type A
Good
Blown
Type B
Good
Blown
Type C
Good
Blown
If the headlights or other electrical components do not work, check the fuses. If any of the fuses are blown, they must be replaced. See “Fuse locations” in Section 7−1 for locations of the fuses. Turn the ignition switch and inoperative component off. Pull a suspected fuse straight out and check it. Determine which fuse may be causing the problem. The lid of the fuse box shows the name of the circuit for each fuse. See Section 8 of this manual for the functions controlled by each circuit.
186
2000 CAMRY CNG (OM33519U)
can
you
Type A fuses can be pulled out by the pull−out tool. The location of the pull−out tool is shown in the illustration. If you are not sure whether the fuse has blown, try replacing the suspected fuse with one that you know is good. If the fuse has blown, push a new fuse into the clip. Only install a fuse with the amperage rat- ing designated on the fuse box lid. If you do not have a spare fuse, in an emergency the “A/C” “MIRROR−HEATER”, fuse, which may be dispensable for normal driving, and use it if its amperage rating is the same. If you cannot use one of the same amper- age, use one that is lower,but as close as possible to, the rating. If the amperage is lower than that specified, the fuse might blow out again but this does not indicate anything wrong. Be sure to get the correct fuse as soon as possible and return the substitute to its original clip. It is a good idea to purchase a set of spare fuses and keep them in your ve- hicle for emergencies.
“DOME” or
pull
out
’00CAMRY CNG (L/O9908)
the new
If fuse immediately blows out, there is a problem with the electrical sys- tem. Have your authorized Toyota CNG dealer correct it as soon as possible.
CAUTION
Never use a fuse with a higher am- perage rating, or any other object, in place of a fuse. This may cause ex- tensive damage and possibly a fire.
Adding washer fluid If any washer does not work or low windshield washer fluid level warning light comes on, the washer tank may be empty. Add washer fluid. You may use plain water as washer fluid. in cold areas where tempera- However, tures freezing point, use fluid containing antifreeze. This washer product is available at your authorized Toyota CNG dealer and most auto parts stores. Follow the manufacturer’s direc- tions for how much to mix with water.
range below
NOTICE
Do not use engine antifreeze or any other substitute because it may dam- age your vehicle’s paint.
following
illustrations show how
Replacing light bulbs— The to gain access to the bulbs. When replacing a bulb, make sure the ignition switch and light switch are off. Use bulbs with the wattage ratings given in the table.
CAUTION
Halogen bulbs have pressurized gas inside and require special handling. They can burst or shatter if scratched or dropped. Hold a bulb only by its plastic or metal case. Do not touch the glass part of a bulb with bare hands.
NOTICE
Only use a bulb of the listed type.
2000 CAMRY CNG (OM33519U)
187
’00CAMRY CNG (L/O9908)
A: HB3 halogen bulbs B: HB4 halogen bulbs C: Single end bulbs D: Wedge base bulbs E: Wedge base bulbs (amber) F: Double end bulbs
—Headlights
Low beam
Hi beam
1. Open the hood. Turn the bulb base counterclockwise to the front of the vehicle as shown.
W Type
Light bulbs
Headlights (high)
Headlights (low)
Parking, front side marker and front turn signal lights
Rear side marker lights
Bulb No. 9005
9006
3157
NA60
51
27/8
194
3.8
3156
or
Rear turn signal lights
3157
Stop and tail lights 3157Back−up lights
921
License plate lights —
High mounted stoplight Interior light
Glove box light
Trunk light
21CP
—
—
—
27
27/8
18
18
10
1.2
3.8
188
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
—Parking, front side marker and front turn signal lights
2. Unplug the connector while depress-
ing the lock release.
If the connector is tight, wiggle it.
3. Install a new bulb and connector
into the mounting hole.
Aiming is not necessary after replacing the bulb. When aiming adjustment is nec- essary, contact your authorized Toyota CNG dealer.
Use a flat−bladed screwdriver. Remove and install the cover clips as shown in the following illustrations.
2000 CAMRY CNG (OM33519U)
189
’00CAMRY CNG (L/O9908)
Removing the cover clips
Use a flat−bladed screw driver. To protect the surface, place several sheets of paper over the surface.
Installing the cover clips
190
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
—Rear side maker, rear turn signal, stop and tail lights
Use a Phillips−head screwdriver. Remove and install the cover clips as shown in the following illustrations.
Removing the cover clips
Installing the cover clips
2000 CAMRY CNG (OM33519U)
191
’00CAMRY CNG (L/O9908)
—Stop and tail lights
a: Rear side marker light b: Rear turn signal light c: Stop and tail light
192
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
—Back−up lights
—License plate lights
Use a flat−bladed screwdriver.
Remove and shown in the following illustrations.
install the cover clips as
2000 CAMRY CNG (OM33519U)
193
’00CAMRY CNG (L/O9908)
—High mounted stoplight
Removing the cover clips
Installing the cover clips
194
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
2000 CAMRY CNG (OM33519U)
195
’00CAMRY CNG (L/O9908)
196
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
SECTION 8
SPECIFICATIONS Dimensions and weight Engine Fuel Service specifications Tires Fuses
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
198
198
198
199
201
2012000 CAMRY CNG (OM33519U)
197
’00CAMRY CNG (L/O9908)
Fuel Fuel type:
Compressed natural gas
Service pressure:
line, CNG (Compressed
24800 kPa (3600 psig)
Equivalent gasoline capacity:
43 L (11.4 gal., 9.5 lmp.gal.)
Water volume:
135 L (35.7 gal., 29.7 lmp.gal.)
Dimensions and weight Overall length mm (in.) Overall width mm (in.) Overall height mm (in.) mm (in.) Wheelbase mm (in.) Front tread Rear tread mm (in.) Vehicle capacity weight (occupants + luggage)
4790 (188.6) 1780
(70.1) (55.9)∗ 1419
2670 (105.1) (60.9) 1548
1519
(59.8)∗: Unladen vehicle
kg (lb)
410
(900)
Engine Model:
5S−FNE
Type:
4 cylinder Natural Gas)
in
Bore and stroke, mm (in.):
87.0 91.0 (3.43 3.58)
Displacement, cm3 (cu. in.):
2164 (132.0)
198
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Service specifications ENGINE Valve clearance (engine cold), mm (in.):
Intake Exhaust
0.19—0.29 (0.007—0.011) 0.28—0.38 (0.011—0.015)
ENGINE LUBRICATION Oil capacity (drain and refill), L (qt., Imp. qt.):
With filter Without filter
3.6 (3.8, 3.2) 3.4 (3.6, 3.0)
Spark plug type:
DENSO
PK20TR8−G
Oil grade:
Spark plug gap, mm(in.):
0.8 (0.031)
Drive belt roughs No.BT−33−73F (used belt), Ibf:
tension measured with Bor- gauge
tension
drive
belt
Generator belt Power steering pump belt
130"10
80"20API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recom- mended.
Recommended oil viscosity (SAE):
COOLING SYSTEM Total capacity, L (qt., Imp. qt.):
6.9 (7.3, 6.1)
Coolant type:
“TOYOTA Long Life Coolant” or equiva- lent With ethylene−glycol type coolant for a proper corrosion protection of aluminum components Do not use alcohol type antifreeze or plain water alone.
BATTERY Open voltage∗ at 20_C (68_F): 12.6—12.8V Fully charged 12.2—12.4V Half charged 11.8—12.0V Discharged
∗: Voltage that is checked 20 minutes af- the
is removed with all
the key
ter lights turned off
Charging rates:
5 A max.
2000 CAMRY CNG (OM33519U)
199
’00CAMRY CNG (L/O9908)
Fluid type:
SAE J1703 or FMVSS No.116 DOT 3
STEERING Wheel free play:
Less than 30 mm (1.2 in.)
Power steering fluid type:
Automatic transmission fluid DEXRONrII or III
AUTOMATIC TRANSAXLE Automatic transmission
Fluid capacity (drain and refill), L (qt., Imp. qt.):
Up to 2.5 (2.6, 2.2)
Fluid type:
Automatic DEXRONrIIl (DEXRONrII)
transmission
fluid D−ll or
Differential
Fluid capacity L (qt., Imp. qt.):
1.6 (1.7, 1.4)
Fluid type:
Automatic DEXRONrIII (DEXRONrII)
transmission
fluid D−II or
BRAKES Minimum pedal clearance when depressed with the pressure of 490 N (50 kgf, 110
lbf) with the engine running, mm (in.):70 (2.8)
Pedal free play, mm (in.):
1—6 (0.04—0.24)
Pad wear limit, mm (in.):
1.0 (0.04)
Lining wear limit, mm (in.):
1.0 (0.04)
Parking brake adjustment when pulled with the force of 196 N (20 kgf, 44 lbf):
5—8 clicks
200
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Fuses
Tires
Tire size:
Spare tire Except spare tire
T145/80R16 105M P205/65R15 92H
Tire pressure, kPa (kgf/cm2 or bar, psi):
Spare tire Except spare tire
420 (4.2, 60)
Normal driving
For all loads including full rated loads For reduced loads (1 to 4 passengers)
Trailer driving
220 (2.2, 32) 200 (2.0, 29) 220 (2.2, 32)
When driving under the above vehicle load conditions at sustained high speeds above 160 km/h (100 mph), in countries where such speeds are permitted by−law, inflate the front and rear tires to 240 kPa (2.4 kgf/cm2 or bar, 35 psi) provided that it does not exceed the maximum cold tire pressure molded on the tire sidewall.
Wheel size: Spare tire Except spare tire
4T 15 6JJ
Wheel nut torque, N·m (kgf·m, ft·lbf):
104 (10.5, 77)
2000 CAMRY CNG (OM33519U)
201
Engine compartment
’00CAMRY CNG (L/O9908)
16. A/F HTR 25 A: No circuit 17. DOOR SUB 25A: Power door lock sys-
tem
18. SEAT−HEATER 20 A: No circuit 19. HEATER 10 A: Air conditioning system,
rear window defogger
20. GAUGE 10 A: Gauges and meters, back−up lights, cruise control system, charging system, power windows, ser- vice reminder indicators and warning buzzers
21. WIPER 25 A: Windshield wipers and
washer
22. MIRROR−HEATER 10 A: Outside rear
view mirror defogger
23. ECU−IG 15 A: Cruise control system, anti−lock brake system, SRS airbag system, seat belt pretensioners, shift lock control system, multiport fuel in- jection system/sequential multiport fuel injection system
24. IGN 5 A: Gauges and meters, charging system, SRS airbag system, seat belt injection pretensioners, multiport system/sequential multiport injec- tion system
fuel
fuel
Engine compartment
Instrument panel
Fuses (type A) 1. A/C 10 A: Air conditioning system 2. SPARE 10 A: Spare fuse 3. SPARE 15 A: Spare fuse 4. SPARE 30 A: Spare fuse 5. ALT−S 5 A: Charging system 6. HEAD (RH) 20 A: Right−hand headlight 7. EFI 20 A: Multiport fuel injection sys- injection
tem/sequential multiport system, A/F sensor 8. HORN 10 A: Horn 9. HAZARD 15 A: Emergency flasher
fuel
202
10. AM2 30 A: Gauge and meter, SRS airbag system, seat belt pretensioners, multiport fuel injection system/sequen- tial multiport injection system, “IGN” and “STARTER” fuses
fuel
11. TEL 5 A: No circuit 12. HEAD (LH) 20 A: Left−hand headlight 13. RADIO NO.1 20 A: Audio system 14. DOME 7.5 A: Clock,
ignition switch light, power
interior
trunk
light, light, door lock system
15. ECU−B 10 A: Anti−lock brake system, SRS airbag system, seat belt preten- sioners
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
34. RAD−NO.2 7.5 A: Audio system 35. CIG 15 A: Cigarette lighter, shift lock control system, power rear view mirror controls, power door lock system, SRS airbag system, seat belt pretensioners, air conditioning system
Fuses (type B) 36. CDS 30 A: Electric cooling fans 37. RDI 30 A: Electric cooling fans 38. MAIN 40 A: “HEAD (RH)” and “HEAD
(LH)” fuses
39. HTR 50 A: “AM1” and “A/C” fuses 40. DEF 40 A: Rear window defogger 41. PWR 30 A: Power window control sys-
tem
42. AM1 40 A: “POWER−OUTLET”, “CIG”, “RAD−NO.2”, “TURN”, “WIPER”, “ECU− IG”, “GAUGE”, and “HEATER” fuses
43. CDS NO.2 30 A: No Circuit Fuses (type C) 44. ALT 100 A: “RDI” and “CDS” fuses 45. ABS 60 A: Anti−lock brake system
2000 CAMRY CNG (OM33519U)
203
25. STOP 15 A: Stop lights, cruise control system, high−mounted stoplight, anti− lock brake system, shift lock control system, multiport fuel injection system/ sequential multiport fuel injection sys- tem
tail
26. TAIL 10 A: Parking lights, license plate front side marker lights, lights, multiport fuel injection system/ sequential multiport fuel injection sys- tem
lights,
27. POWER−OUTLET 15 A: Power outlet 28. OBD 7.5 A: On−board diagnosis sys-
tem
29. FOG 15 A: No circuit 30. STARTER 5 A: Gauges and meters, multiport fuel injection system/sequen- tial multiport fuel injection system
31. DOOR 25 A: Power door lock system 32. PANEL 7.5 A: Gauge and meter, audio lighter, glove box system, cigarette light, clock, instrument panel light con- indicators, air trol, service conditioning control panel lights, ash- tray light, emergency flasher, rear win- dow defogger, electronically controlled automatic transmission system
reminder
33. TURN 7.5 A: Emergency flasher
’00CAMRY CNG (L/O9908)
204
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
SECTION 9
REPORTING SAFETY DEFECTS FOR U.S. OWNERS AND UNIFORM TIRE QUALITY GRADING Reporting safety defects for U.S. owners Uniform tire quality grading
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
206
2062000 CAMRY CNG (OM33519U)
205
’00CAMRY CNG (L/O9908)
To contact NHTSA, you may ei- ther call the Auto Safety Hotline toll−free at 1−800−424−9393 (or 366−0123 in Washington, D.C. area) or write to: NHTSA, U.S. Department of Transportation, Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from the Hot- line.
Reporting safety defects for U.S. owners If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately in- form the National Highway Traffic Safety Administration (NHTSA) in addition to notifying Toyota Motor Sales, U.S.A., Inc. (Toll−free: 1−800−331−4331). If NHTSA receives similar com- plaints, it may open an investiga- tion, and if it finds that a safety defect exists in a group of ve- hicles, it may order a recall and remedy However, NHTSA cannot become involved in individual problems between you, your dealer, or Toyota Motor Sales, U.S.A., Inc.
campaign.
206
2000 CAMRY CNG (OM33519U)
Uniform tire quality grading This information has been prepared in ac- cordance with regulations issued by the National Highway Traffic Safety Adminis- tration of the U.S. Department of Trans- portation. It provides the purchasers and/ or prospective purchasers of Toyota vehicles with information on uniform tire quality grading. Your authorized Toyota CNG dealer will help answer any questions you may have as you read this information. DOT quality grades—All passenger car tires must conform to Federal Safety Requirements these grades. Quality grades can be found where applicable on the tire sidewall between tread shoulder and maximum section width. For example: Treadwear 200 Traction AA Temperature A
in addition
to
from
treadwear grade
Treadwear—The is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150
would wear one and a half (1−1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual condi- tions of their use, however, and may de- part significantly the norm due to variations in driving habits, service prac- tices and differences in road characteris- tics and climate. Traction AA, A, B, C—The traction grades, from highest to lowest, are AA, A, B, and C, and they represent the tire’s ability to stop on wet pavement as mea- sured under controlled conditions on spe- cified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this is based on braking (straight ahead) traction tests and does not include cornering (turning) traction.tire
’00CAMRY CNG (L/O9908)
Temperature A, B, C—The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissi- pate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to de- generate and reduce tire life, and exces- sive temperature can lead to sudden tire failure. The grade C corresponds to a lev- el of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No. 109. Grades B and A represent higher levels of perfor- mance on the laboratory test wheel than the minimum required by law. Warning: The temperature grades for this tire are established for a tire that is prop- erly inflated and not overloaded. Exces- sive speed, underinflation, or excessive loading, either separately or in combina- tion, can cause heat buildup and possible tire failure.
2000 CAMRY CNG (OM33519U)
207
’00CAMRY CNG (L/O9908)
208
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Foreword
Welcome to the growing group of value−conscious people who drive Toyotas. We are proud of the advanced engineering and quality construction of each vehicle we build. This Owner’s Manual explains the features of your new Toyota. Please read it and follow the instructions carefully so that you can enjoy many years of safe motoring. When it comes to service, remember that your authorized Toyota CNG dealer knows your vehicle best and is interested in your complete satisfaction. He will provide quality maintenance and any other assistance you may require. Please leave this Owner’s Manual in this vehicle at the time of resale. The next owner will need this information also. All information and specifications in this manual are current at the time of printing. However, because of Toyota’s policy of continual product improve- ment, we reserve the right to make changes at any time without notice. Please note that this manual applies to all models and explains all equipment, including options. Therefore, you may find some explanations for equipment not installed on your vehicle.
© 1999 TOYOTA MOTOR CORPORATION All rights reserved. This material may not be reproduced or copied, in whole or in part, without the written permission of Toyota Motor Corporation.
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Quick index D If a service reminder indicator or warning buzzer comes on D If your vehicle will not start D If your engine stalls while driving D If your vehicle overheats D If you have a flat tire D If your vehicle needs to be towed D Tips for driving during break−in period D How to start the engine D General maintenance Gas station information Fuel type:
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
66
138
141
141
142
150
112
126
163U −2
Compressed natural gas
See page 112 for detailed information.
Service pressure:
24800 kPa (3600 psig)
Equivalent gasoline capacity:
43 L (11.4 gal., 9.5 lmp. gal.)
Water volume:
135 L (35.7 gal., 29.7 lmp. gal.)
See page 114 for detailed information.
Engine oil:
API grade SJ, “Energy−Conserving” or ILSAC multigrade engine oil is recommended. See page 174 for detailed information.
Automatic transmission fluid:
Automatic transmission fluid D−II or DEXRONrIII (DEXRONrII)
Tire information: See pages 178 through 181. Tire pressure: See page 201.
2000 CAMRY CNG (OM33519U)
Publication No. OM33519U Part No. 01999-33519
Printed in Japan 01−9908−00CNG ( U)
New vehicle warranty
Your new vehicle limited warranties:
is covered by
the
following Toyota
D New vehicle warranty D Emission control systems warranty D Others further
information, please refer
For Manual Supplement”.
to
the “Owner’s
Your responsibility for maintenance
It is the owner’s responsibility to make sure that the specified maintenance is performed. Section 6 gives de- tails of these maintenance requirements. Also included is general maintenance. For scheduled in Section 6 maintenance the “Owner’s Manual Supplement”.
information, please refer
to
’00CAMRY CNG (L/O9908)
Accessories, spare parts and modification of your Toyota
A wide variety of non−genuine spare parts and accesso- ries for Toyota vehicles are currently available in the market. You should know that Toyota does not warrant these products and is not responsible for their perfor- mance, repair, or replacement, or for any damage they may cause to, or adverse effect they may have on, your Toyota vehicle.
This vehicle should not be modified with non−genuine Toyota products. Modification with non−genuine Toyota products could affect its performance, safety or durabili- ty, and may even violate governmental regulations. In addition, damage or performance problems resulting from the modification may not be covered under warranty.
ii
2000 CAMRY CNG (OM33519U)
Installation of a mobile two−way radio system
fuel
injection system/sequential multiport
As the installation of a mobile two−way radio system in your vehicle could affect electronic systems such as multiport fuel injection system, cruise control system, anti−lock brake system, SRS airbag system and seat belt pretensioner system, be sure to check with your authorized Toyota CNG dealer for precautionary measures or special instructions regarding installation.
Scrapping of your Toyota
The SRS airbag and seat belt pretensioner devices in your Toyota contain explosive chemicals. If the vehicle is scrapped with the airbags and pretensioners left as they are, this may cause an accident such as fire. Be sure to have the systems of the SRS airbag and seat belt pretensioner removed and disposed of by the quali- fied service shop or by your authorized Toyota CNG dealer before you dispose of your vehicle.
’00CAMRY CNG (L/O9908)
Precautions for CNG
Your vehicle may use compressed natural gas (CNG) for fuel.
D Handle the CNG vehicle with care as the fuel tank and pipes of it are filled with extremely high pres- sure gas. In this case, close the manual shutoff valve and have your authorized Toyota CNG dealer carry out an inspection.
D You will be able to tell if fuel is leaking out of the vehicle by the sound of the leaking fuel and the smell of the fuel.
D Be careful not to run out of fuel. There are less CNG stations than gasoline stations so we recom- mend that you refuel early.
For details, see “Fuel” and “Fuel system” in Section 2.
iii
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Refueling station information
For information on refueling stations for CNG, contact Natural Gas Vehicle Coalition (NGVC) at the address and numbers listed below.
Natural Gas Vehicle Coalition
1515 Wilson Blvd. Arlington, Va. 22209
Phone: (703) 527−3022
iv
2000 CAMRY CNG (OM33519U)
’00CAMRY CNG (L/O9908)
Important information about this manual
Safety and vehicle damage warnings
Safety symbol
In this manual, you will see CAUTION and NOTICE warn- ings. These are used in the following ways:
CAUTION
This is a warning against something which may cause injury to people if the warning is ignored. You are informed what you must or must not do in order to avoid or reduce the risk to yourself and other people.
NOTICE
This is a warning against something which may cause damage to the vehicle or its equipment if the warning is ignored. You are informed what you must or must not do in order to avoid or reduce the risk of damage to your vehicle and its equipment.
In this manual, you will also see a circle with a slash through it. This means “Do not”, “Do not do this”, or “Do not let this happen”.
2000 CAMRY CNG (OM33519U)
