2003 Honda S2000 Owners Manual

9.

Fasten your seat belt. Check that your passenger has fastened his or her seat belt (see page

15

).

Turn the ignition switch ON (II). Check the indicator lights in the instrument panel.

10.

Start the engine (see page

135

).

11.

Check the gauges and indicator lights in the instrument panel (see page

45

).

Main MenuTable of Contentsst０２／０８／０６　１８：２７：２９　３１Ｓ２Ａ６３０　０１３８　

1.

Apply the parking brake.

2.

3.

In cold weather, turn off all electrical accessories to reduce the drain on the battery.

Push the clutch pedal down all the way. The ENGINE START button has no effect unless the clutch pedal is depressed.

4.

Turn the ignition key to ON (II) position.

ENGINE START BUTTON Without touching the accelerator 5. pedal, push the ENGINE START button. If the engine does not start right away, do not hold the ENGINE START button for more than 15 seconds at a time. Pause for at least 10 seconds before trying again.

Starting the Engine

6.

7.

If the engine does not start within 15 seconds, or starts but stalls right away, repeat step 5 with the accelerator pedal pressed half-way down. If the engine starts, release pressure on the accelerator pedal so the engine does not race.

If the engine still does not start, press the accelerator pedal all the way down and hold it there while starting in order to clear flooding. As before, hold the ENGINE START button for no more than 15 seconds. Return to step 6 if the engine does not start. If it starts, lift your foot off the accelerator pedal so the engine does not race.

Driving

135

Main MenuTable of Contentsst０２／０８／０６　１８：２７：３６　３１Ｓ２Ａ６３０　０１３９　

Starting the Engine

Starting in Cold Weather at High Altitude (Above 8,000 feet/ 2,400 meters) An engine is harder to start in cold weather. The thinner air found at high altitude above 8,000 feet (2,400 meters) adds to the problem.

Use the following procedure:

1.

Turn off all electrical accessories to reduce the drain on the battery.

2.

Push the accelerator pedal half- way to the floor and hold it there while starting the engine. Do not hold the ENGINE START button for more than 15 seconds. When the engine starts, release the accelerator pedal gradually as the engine speeds up and smooths out.

3.

If the engine fails to start in step 2, push the accelerator pedal to the floor and hold it there while you try to start the engine for no more than 15 seconds. If the engine does not start, return to step 2.

136

Driving

Main MenuTable of Contentsst０２／０８／０６　１８：２７：４３　３１Ｓ２Ａ６３０　０１４０　

6-speed Manual Transmission

Rapid slowing or speeding-up can cause loss of control on slippery surfaces. If you crash, you can be injured.

Use extra care when driving on slippery surfaces.

Come to a full stop before you shift into Reverse. You can damage the transmission by trying to shift into Reverse with the car moving. Push down the clutch pedal, and pause for a few seconds before shifting into Reverse, or shift into one of the forward gears for a moment. This stops the gears so they won’t ‘‘grind.’’

When slowing down, you can get extra braking from the engine by shifting to a lower gear. This extra braking can help you maintain a safe speed and prevent your brakes from overheating while going down a steep hill. Before downshifting, make sure engine speed will not go into the tachometer’s red zone in the lower gear.

Driving

137

The manual transmission is synchro- nized in all forward gears for smooth operation. It has a lockout so you cannot shift directly from Fifth to Reverse instead of Sixth (see page ). When shifting up or down, 138
make sure you push the clutch pedal down all the way, shift to the next gear, and let the pedal up gradually. When you are not shifting, do not rest your foot on the clutch pedal. This can cause your clutch to wear out faster.

Main MenuTable of Contentsst０２／０８／０６　１８：２７：５３　３１Ｓ２Ａ６３０　０１４１　

6-speed Manual Transmission

Recommended Shift Points Drive in the highest gear that lets the engine run and accelerate smoothly. This will give you the best fuel economy and effective emis- sions control. The following shift points are recommended:

Shift Up

Normal Acceleration

1st to 2nd 2nd to 3rd 3rd to 4th 4th to 5th 5th to 6th

15 mph (24 km/h) 25 mph (40 km/h) 40 mph (64 km/h) 47 mph (75 km/h) 52 mph (83 km/h)

Engine Speed Limiter If you exceed the maximum speed for the gear you are in, the engine speed will enter into the tachometer’s red zone. If this occurs, you may feel the engine cut in and out. This is caused by a limiter in the engine’s computer controls. The engine will run normally when you reduce the RPM below the red zone.

Before downshifting, make sure the engine will not go into the tachometer’s red zone.

138

Driving

Reverse Lockout

The 6-speed manual transmission has a lockout so you cannot accidentally shift from Fifth to Reverse instead of Sixth.

With the clutch pedal depressed, move the shift lever to the Reverse side of the Neutral gate. Then push the shift lever down and shift to Reverse.

Main MenuTable of Contentsst０２／０８／０６　１８：２８：０４　３１Ｓ２Ａ６３０　０１４２　

Always use the parking brake when you park your car. The indicator on the instrument panel shows that the parking brake is not fully released; it does not indicate that the parking brake is firmly set. Make sure the parking brake is set firmly or your car may roll if it is parked on an incline.

If the car is facing uphill, turn the front wheels away from the curb and put the transmission in first gear. If the car is facing downhill, turn the front wheels toward the curb and put the transmission in reverse gear.

Make sure the parking brake is fully released before driving away. Driving with the parking brake partially set can overheat or damage the rear brakes.

Parking

Parking Tips

Make sure the convertible top and the windows are closed.

Turn off the lights.

Place any packages, valuables, etc., in the trunk or take them with you.

Lock the doors with the key or the remote transmitter.

Never park over dry leaves, tall grass, or other flammable materials. The three way catalytic converter gets very hot, and could cause these materials to catch on fire.

Driving 139

Main MenuTable of Contentsst０２／０８／０６　１８：２８：１３　３１Ｓ２Ａ６３０　０１４３　

The Braking System

Your Honda is equipped with disc brakes at all four wheels. A power assist helps reduce the effort needed on the brake pedal. The ABS helps you retain steering control when braking very hard.

Put your foot on the brake pedal only when you intend to brake. Resting your foot on the pedal keeps the brakes applied lightly, causing them to build up heat. Heat build-up can reduce how well your brakes work. It also keeps your brake lights on all the time, confusing drivers behind you.

Constant application of the brakes when going down a long hill builds up heat and reduces their effective- ness. Use the engine to assist the brakes by downshifting to a lower gear and taking your foot off the accelerator pedal.

Check your brakes after driving through deep water. Apply the brakes moderately to see if they feel normal. If not, apply them gently and frequently until they do. Since a longer distance is needed to stop with wet brakes, be extra cautious and alert in your driving.

Brake Wear Indicators All four brakes have audible brake wear indicators. When the brake pads need replacing, you will hear a distinctive metallic ‘‘screeching’’ sound when you apply the brakes. If you do not have the brake pads replaced, they will begin screeching all the time.

Your brakes may sometimes squeal or squeak when you apply them lightly. Do not confuse this with the brake wear indicators. They make a very audible ‘‘screeching.’’

140

Driving

Main MenuTable of Contentsst０２／０８／０６　１８：２８：２１　３１Ｓ２Ａ６３０　０１４４　

The Braking System

Brake System Design The hydraulic system that operates the brakes has two separate circuits. Each circuit works diagonally across the car (the left-front brake is connected with the right-rear brake, etc.). If one circuit should develop a problem, you will still have braking at two wheels.

Anti-lock Brakes Your car has an Anti-lock Brake System (ABS) as standard equipment. ABS helps to prevent the wheels from locking up and skidding during hard braking, allowing you to retain steering control.

When the front tires skid, you lose steering control; the car continues straight ahead even though you turn the steering wheel. The ABS helps to prevent lock-up and helps you retain steering control by pumping the brakes rapidly; much faster than a person can do it.

Front

CONTINUED

Driving 141

Main MenuTable of Contentsst０２／０８／０６　１８：２８：３０　３１Ｓ２Ａ６３０　０１４５　

The Braking System

You should never pump the brake pedal; this defeats the purpose of the ABS. Let the ABS work for you by always keeping firm, steady pressure on the brake pedal as you steer away from the hazard. This is sometimes referred to as ‘‘stompandsteer.’’

You will feel a pulsation in the brake pedal when the ABS activates, and you may hear some noise. This is normal; it is the ABS rapidly pumping the brakes.

Activation varies with the amount of traction your tires have. On dry pavement, you will need to press on the brake pedal very hard before you activate the ABS. However, you may feel the ABS activate immediately if you are trying to stop on snow or ice.

142

Driving

ImportantSafetyReminders ABS does not reduce the time or distance it takes to stop the car; only helps with steering control during braking. You should always maintain a safe following distance from other vehicles.

it

on loose or

A car with ABS may require a longer distance to stop uneven surfaces, such as gravel or snow, than a car without anti-lock. Slow down and allow a greater distance between cars under those conditions.

ABS will not prevent a skid that results from changing direction abruptly, such as trying to take a corner too fast or making a sudden lane change. Always drive at a safe, prudent speed for the road and weather conditions.

ABS cannot prevent a loss of stability. Always steer moderately when you are braking hard. Severe or sharp steering wheel movement can still cause your car to veer into oncoming traffic or off the road.

Main MenuTable of Contentsst０２／０８／０６　１８：２８：３６　３１Ｓ２Ａ６３０　０１４６　

The Braking System

ABSIndicator

ANTI-LOCK BRAKE SYSTEM INDICATOR

＊

＊

U.S. indicator shown

47

The ABS is self-checking. If anything goes wrong, the ABS indicator on the instrument panel comes on (see page ). This means the anti-lock function of the braking system has shut down. The brakes still work like a conventional system without anti- lock, providing normal stopping ability. You should have the dealer inspect your car as soon as possible.

Driving

143

Main MenuTable of Contentsst０２／０８／０６　１８：２８：４５　３１Ｓ２Ａ６３０　０１４７　

Driving in Bad Weather

−

Always drive

Driving Technique slower than you would in dry weather. It takes your car longer to react, even in conditions that may seem just barely damp. Apply smooth, even pressure to all the controls. Abrupt steering wheel movements or sudden, hard appli- cation of the brakes can cause loss of control in wet weather. Be extra cautious for the first few miles (kilometers) of driving while you adjust to the change in driving conditions. This is especially true in snow. A person can forget some snow-driving techniques during the summer months. Practice is needed to relearn those skills.

Exercise extra caution when driving in rain after a long dry spell. After months of dry weather, the first rains bring oil to the surface of the roadway, making it slippery.

Rain, fog, and snow conditions require a different driving technique because of reduced traction and visibility. Keep your car well- maintained and exercise greater caution when you need to drive in bad weather. The cruise control should not be used in these conditions.

144

Driving

−

Being able to see

Visibility clearly in all directions and being visible to other drivers are important in all weather conditions. This is more difficult in bad weather. To be seen more clearly during daylight hours, turn on your headlights.

Inspect your windshield wipers and washers frequently. Keep the wind- shield washer reservoir full of the proper fluid. Have the windshield wiper blades replaced if they start to streak the windshield or leave parts unwiped. Use the defrosters and air conditioning to keep the windows from fogging up on the inside (see page

91

).

Main MenuTable of Contentsst０２／０８／０６　１８：２８：５４　３１Ｓ２Ａ６３０　０１４８　

Traction − Check your tires frequently for wear and proper pressure. Both are important in preventing ‘‘hydroplaning’’ (loss of traction on a wet surface). In the winter, mount snow tires on all four wheels for the best handling.

Watch road conditions carefully, they can change from moment to moment. Wet leaves can be as slip- pery as ice. ‘‘Clear’’ roads can have patches of ice. Driving conditions can be very hazardous when the outside temperature is near freezing. The road surface can become covered with areas of water puddles mixed with areas of ice, so your traction can change without warning.

Be careful when downshifting. If traction is low, you can lock up the drive wheels for a moment and cause a skid.

Driving in Bad Weather, Towing a Trailer

Towing a Trailer Your car is not designed to tow a trailer. Attempting to do so can void your warranties.

Be very cautious when passing, or being passed by other cars. The spray from large cars reduces your visibility, and the wind buffeting can cause you to lose control.

Driving

145

Main MenuTable of Contentsst０２／０８／０６　１８：２９：０４　３１Ｓ２Ａ６３０　０１５０　

Maintenance

This section explains why it is important to keep your car well maintained and how to follow basic maintenance safety precautions.

This section also includes Maintenance Schedules for normal driving and severe driving conditions, a Maintenance Record, and instruc- tions for simple maintenance tasks you may want to take care of yourself.

If you have the skills and tools to per- form more complex maintenance tasks on your Honda, you may want to purchase the Service Manual. See page for information on how to obtain a copy, or see your Honda dealer.

261

Maintenance Safety

...................... . 148
Important Safety Precautions . 149
Maintenance Schedule ................. . 150
Required Maintenance Record . 157
... . 159
Owner Maintenance Checks ....... .............................. Fluid Locations . 160
. 161
...................................... Engine Oil . 161
.................................. . 161
.................... . 162
.............................. .................................... . 162
. 163
..... . 165
............................. . 165
............ . 167
....... .................... . 171

Adding Oil Recommended Oil Synthetic Oil Additives Changing the Oil and Filter

Adding Engine Coolant Replacing Engine Coolant

Windshield Washers 6-speed Manual Transmission

Cooling System

Differential Fluid Brake and Clutch Fluid

........................................... .......................... ................ ............................ ........................... ..................... ....................................

. 172
. 173
. 174
. 174
. 175
. 176
. 178

Air Cleaner Element Hood Latch

Brake System Clutch System

Fluid

Spark Plugs

Replacement Specifications

Battery Wiper Blades Air Conditioning System Dust and Pollen Filter Drive Belt Tires

.................................... .............................. ............................ ........................................... ................................. .............. .................. ....................................... ............................................... ...................................... .................................. .............................. ............................. ................................... ... ...................... .......................... ............................. ............................ ............................................. ..................... ........................ ...........................

Inflation Inspection Maintenance Tire Rotation Tire Wear Replacing Tires and Wheels Wheels and Tires Winter Driving

Headlight Aiming Replacing Bulbs

Snow Tires Tire Chains

Storing Your Car

Lights

. 178
. 178
. 180
. 181
. 184
. 186
. 187
. 188
. 189
. 189
. 191
. 192
. 192
. 192
. 193
. 194
. 194
. 195
. 195
. 196
. 198
. 198
. 206

Maintenance 147

Main Menust０２／０８／０６　１８：２９：１１　３１Ｓ２Ａ６３０　０１５１　

Maintenance Safety

Regularly maintaining your car is the best way to protect your investment. Proper maintenance is essential to your safety and the safety of your passengers. It will also reward you with more economical, trouble-free driving, and help reduce air pollution.

This section includes instructions for simple maintenance tasks, such as checking and adding oil. Any service items not detailed in this section should be performed by a Honda technician or other qualified mechanic.

Some of the most important safety precautions are given here. However, we cannot warn you of every conceivable hazard that can arise in performing maintenance. Only you can decide whether or not you should perform a given task.

Improperly maintaining this car or failing to correct a problem before driving can cause a crash in which you can be seriously hurt or killed.

Always follow the inspection and maintenance recommendations and schedules in this owner’s manual.

148

Maintenance

Failure to properly follow maintenance instructions and precautions can cause you to be seriously hurt or killed.

Always follow the procedures and precautions in this owner’s manual.

Main MenuTable of Contentsst０２／０８／０６　１８：２９：１９　３１Ｓ２Ａ６３０　０１５２　

Maintenance Safety

Important Safety Precautions Before you begin any maintenance, make sure your car is parked on level ground and that the parking brake is set. Also, be sure the engine is off. This will help to eliminate several potential hazards:

Carbon monoxide poisoning from engine exhaust. Be sure there is adequate ventilation whenever you operate the engine.

Burns from hot parts. Let the engine and exhaust system cool before touching any parts.

Injury from moving parts. not run the engine unless in- structed to do so.

Do

Read the instructions before you begin, and make sure you have the tools and skills required.

To reduce the possibility of fire or explosion, be careful when working around gasoline or batteries. Use a commercially available degreaser or parts cleaner, not gasoline, to clean parts. Keep cigarettes, sparks, and flames away from the battery and all fuel-related parts.

You should wear eye protection and protective clothing when working near the battery or when using compressed air.

Maintenance

149

Main MenuTable of Contentsst０２／０８／０６　１８：２９：２８　３１Ｓ２Ａ６３０　０１５３　

Maintenance Schedule

The Maintenance Schedule specifies how often you should have your car serviced and what things need attention. It is essential that you have your car serviced as scheduled to retain its high level of safety, dependability, and emissions control performance.

150

Maintenance

Which Schedule to Follow: Service your car according to the time and mileage periods on one of the Maintenance Schedules on the following pages. Select the schedule for ‘‘Severe Conditions’’ if most of your driving is done under one or more of the conditions listed on that page. Otherwise, follow the schedule for ‘‘Normal Conditions.’’

The services and time or distance intervals shown in the maintenance schedule assume you will use your car as normal transportation for your passenger and possessions. You should also follow these recommendations:

Avoid exceeding your car’s load limit. This puts excess stress on the engine, brakes, and many other parts of your car. The load limit is shown on the label on the driver’s doorjamb.

Operate your car on reasonable roads within the legal speed limit.

Drive your car regularly over a distance of several miles (kilometers).

Always use unleaded gasoline with the proper octane rating (see page 120

).

Main MenuTable of Contentsst０２／０８／０６　１８：２９：３５　３１Ｓ２Ａ６３０　０１５４　

Your authorized Honda dealer knows your car best and can provide competent, efficient service. However, service at a dealer is not mandatory to keep your warranties in effect. Maintenance may be done by any qualified service facility or person who is skilled in this type of automotive service. Keep all the receipts as proof of completion, and have the person who does the work fill out the Maintenance Record. Check your warranty booklet for more information.

We recommend the use of genuine Honda parts and fluids whenever you have maintenance done. These are manufactured to the same high- quality standards as the original components, so you can be confident of their performance and durability.

U.S. Cars: Maintenance, replacement or repair of emissions control devices and systems may be done by any automotive repair establishment or individual using parts that are ‘‘certified’’ to EPA standards.

Maintenance Schedule

＃

According to state and federal regulations, failure to perform maintenance on the items marked with will not void your emissions warranties. However, Honda recommends that all maintenance services be performed at the recommended time or mileage period to ensure long-term reliability.

Maintenance

151

Main MenuTable of Contentsst０２／０８／０６　１８：２９：５４　３１Ｓ２Ａ６３０　０１５５　

U.S. Owners Follow the Normal Conditions Maintenance Schedule if the severe driving conditions specified in the Severe Conditions Maintenance Schedule do not apply.

NOTE: If you only drive under a OCCASIONALLY ‘‘severe’’ condition, you should follow the Normal Conditions Maintenance Schedule.

Canadian Owners Follow the Maintenance Schedule for Severe Conditions.

＃

See information on maintenance and emissions warranty, last column, page

151

−

Service at the indicated distance or time whichever comes first. Replace engine oil Replace engine oil filter Check engine oil and coolant Replace air cleaner element Inspect valve clearance Replace spark plugs Inspect drive belt Inspect idle speed Replace engine coolant

Replace transmission fluid Replace rear differential fluid Inspect front and rear brakes Replace brake fluid Check parking brake adjustment Replace dust and pollen filter Check tire inflation and condition

miles x 1,000
km x 1,000
months

15
24
12

30
105
48
168
24
84
Replace every 7,500 miles (12,000 km) or 1 year

75
120
60

90
144
72

60
96
48

45
72
36

120
192
96

Check oil and coolant at each fuel stop

Adjust only if noisy

120,000 miles (192,000 km) or 10 years, then every 60,000 miles

(96,000 km) or 5 years

Every 3 years (independent of mileage)

Visually inspect the following items:

Every 7,500 miles (12,000 km)

Tie rod ends, steering gear box, and boots Suspension components Driveshaft boots Brake hoses and lines (including ABS) All fluid levels and condition of fluids Exhaust system ＃ Fuel lines and connections

＃

152

Maintenance

Main MenuTable of Contentsst０２／０８／０６　１８：３０：０２　３１Ｓ２Ａ６３０　０１５６　

Service at the indicated distance or time, whichever comes first. Do the items in U.S. Owners Canadian owners:

Follow the schedule for Severe Conditions.

to determine which schedule to use.

Refer to page

152

−

A, B, C

as required for each distance/time interval.

Replace brake fluid (independent of mileage).

Replace brake fluid (independent of mileage).

7,500 mi/12,000 km 15,000 mi/24,000 km/1 yr 22,500 mi/36,000 km 30,000 mi/48,000 km/2 yrs 37,500 mi/60,000 km 3 yrs 45,000 mi/72,000 km/3 yrs 52,500 mi/84,000 km 60,000 mi/96,000 km/4 yrs 67,500 mi/108,000 km 75,000 mi/120,000 km/5 yrs 82,500 mi/132,000 km 6 yrs 90,000 mi/144,000 km/6 yrs 97,500 mi/156,000 km 105,000 mi/168,000 km/7 yrs

112,500 mi/180,000 km 120,000 mi/192,000 km/8 yrs

9 yrs 120,000 mi/192,000 km/10 yrs

Do items in A. Do items in A, B. Do items in A. Do items in A, B, C. Do items in A. â–¡ Do items in A, B. Do items in A. Do items in A, B, C. Do items in A. Do items in A, B. Do items in A. â–¡ Do items in A, B, C. Do items in A. â–¡ â–¡ â–¡ Do items in A, B. Do items in A. â–¡ Do items in A, B, C. â–¡ â–¡ 60,000 mi/96,000 km/5 yrs.

Inspect valve clearance. Check idle speed. Replace spark plugs.

Replace transmission fluid.

Replace brake fluid (independent of mileage). Replace engine coolant, then replace every

＃

â–¡ â–¡ â–¡ â–¡ â–¡ â–¡ â–¡ â–¡ â–¡ â–¡

Replace engine oil. Check tire inflation and condition. Replace engine oil filter. Inspect front and rear brakes. Check parking brake adjustment. Inspect tie rod ends, steering gear box and boots. Inspect suspension components. Inspect driveshaft boots. Inspect brake hoses and lines (including ABS). Check all fluid levels, condition of fluids, and check for leaks. Inspect exhaust system. □ ＃ Inspect fuel lines and connections. □ ＃ Replace air cleaner element. □ Replace rear differential fluid. □ Replace dust and pollen filter. □ Inspect drive belt. □

See information on maintenance and emissions warranty, last column, page

151

Note:

Check engine oil and coolant at each fuel stop. Check and adjust valve clearance, cold engine, only if noisy.

Maintenance 153

Main MenuTable of Contentsst０２／０８／０６　１８：３０：２６　３１Ｓ２Ａ６３０　０１５７　

miles x 1,000
km x 1,000
months

−

Service at the indicated distance or time whichever comes first. Replace engine oil and oil filter Check engine oil and coolant Replace air cleaner element Use normal schedule except in dusty conditions Inspect valve clearance Replace spark plugs Inspect drive belt Inspect idle speed Replace engine coolant

Replace transmission fluid Replace rear differential fluid Inspect front and rear brakes Replace brake fluid Check parking brake adjustment Replace dust and pollen filter ＊ Lubricate all hinges, locks and latches Check tire inflation and condition

15
24
12

30
48
24

45
72
36

60
96
48

75
120
60

90
144
72

105
168
84

120
192
96

Replace every 3,750 miles (6,000 km) or 6 months

Check oil and coolant at each fuel stop

Adjust only if noisy

120,000 miles (192,000 km) or 10 years, then every 60,000 miles

(96,000 km) or 5 years

Inspect every 7,500 miles (12,000 km) or 6 months

Every 3 years (independent of mileage)

Visually inspect the following items:

Every 7,500 miles (12,000 km)

Tie rod ends, steering gear box, and boots Suspension components, Driveshaft boots Brake hoses and lines (including ABS) All fluid levels and condition of fluids Exhaust system , Fuel lines and connections Lights and controls, Vehicle underbody

＃

＃

Every 7,500 miles (12,000 km) or 6 months

＊

1 :

Refer to page

187

for replacement information under special driving conditions.

154

Maintenance

U.S. Owners Follow the Severe Conditions Maintenance Schedule if you drive your vehicle MAINLY under one or more of the following conditions:

Driving less than 5 miles (8
km) per trip or, in freezing temperatures, driving less than 10 miles (16 km) per trip. Driving in extremely hot [over 90°F (32°C)] conditions. Extensive idling or long periods of stop-and-go driving. Driving in mountainous conditions. Driving on muddy, dusty, or de-iced roads.

Canadian Owners Follow the Maintenance Schedule for Severe Conditions.

＃

See information on maintenance and emissions warranty, last column, page

151

Main MenuTable of Contentsst０２／０８／０６　１８：３０：３７　３１Ｓ２Ａ６３０　０１５８　

Service at the indicated distance or time, whichever comes first. Do the items in U.S. Owners Canadian Owners

Use the Maintenance Schedule for Severe Conditions.

to determine which schedule to use.

Refer to page

154

−

−

A, B, C, D, E

as required for each distance/time.

3,750 mi/6,000 km 7,500 mi/12,000 km 11,250 mi/18,000 km 15,000 mi/24,000 km/1 yr 18,750 mi/30,000 km 22,500 mi/36,000 km 26,250 mi/42,000 km 30,000 mi/48,000 km/2 yrs 33,750 mi/54,000 km 37,500 mi/60,000 km 41,250 mi/66,000 km 3 yrs 45,000 mi/72,000 km/3 yrs 48,750 mi/78,000 km 52,500 mi/84,000 km 56,250 mi/90,000 km 60,000 mi/96,000 km/4 yrs 63,750 mi/102,000 km 67,500 mi/108,000 km 71,250 mi/114,000 km 75,000 mi/120,000 km/5 yrs 78,750 mi/126,000 km

Do items in A. Do items in A, B. Do items in A. Do items in A, B, C. Do items in A. Do items in A, B. Do items in A. Do items in A, B, C, D. Do items in A. Do items in A, B. Do items in A. â–¡ Do items in A, B, C. Do items in A. Do items in A, B. Do items in A. Do items in A, B, C, D, E. Do items in A. Do items in A, B. Do items in A. Do items in A, B, C. Do items in A.

Replace brake fluid (independent of mileage).

â–¡ â–¡ â–¡ â–¡ â–¡ â–¡ â–¡ â–¡ â–¡

Replace engine oil and filter. Inspect front and rear brakes. Check tire inflation and condition. Inspect tie rod ends, steering gear box and boots. Inspect suspension components. Inspect driveshaft boots. Replace air cleaner element. Check parking brake adjustment. Lubricate all hinges, locks and latches with multipurpose grease. Replace rear differential fluid. Inspect brake hoses and lines (including ABS). Check all fluid levels, condition of fluids, and check for leaks. Inspect exhaust system. □ ＃ Inspect fuel lines and connections. □ ＃ Check all lights. □ Inspect the underbody. □ Inspect drive belt. □ Replace dust and pollen filter . □ ＊ Replace transmission fluid. □

â–¡ â–¡ â–¡

See dust and pollen filter on page conditions. See information on maintenance and emissions warranty, last column, page

for replacement information under special driving

187

＊

1 :

＃ Note:

Check engine oil and coolant at each fuel stop. Check and adjust valve clearance, cold engine, only if noisy.

151

CONTINUED Maintenance 155

Main MenuTable of Contentsst０２／０８／０６　１８：３０：４３　３１Ｓ２Ａ６３０　０１５９　

See dust and pollen filter on page information under special driving conditions. See information on maintenance and emissions warranty, last column, page

for replacement

151

187

＊

1 :

＃

NOTE:

Check engine oil and coolant at each fuel stop. Check and adjust valve clearance, cold engine, only if noisy.

Replace brake fluid (independent of mileage).

Inspect valve clearance. Check idle speed. Replace spark plugs.

Do items in A, B. Do items in A. â–¡ Do items in A, B, C, D. Do items in A. Do items in A, B. Do items in A. â–¡ â–¡ â–¡ Do items in A, B, C. Do items in A. Do items in A, B. Do items in A. Do items in A, B, C, D. â–¡ â–¡ 60,000 mi/96,000 km/5 yrs.

Replace brake fluid (independent of mileage). Replace engine coolant, then replace every

82,500 mi/132,000 km 86,250 mi/138,000 km 6 yrs 90,000 mi/144,000 km/6 yrs 93,750 mi/150,000 km 97,500 mi/156,000 km 101,250 mi/162,000 km 105,000 mi/168,000 km/7 yrs

108,750 mi/174,000 km 112,500 mi/180,000 km 116,250 mi/186,000 km 120,000 mi/192,000 km/8 yrs 9 yrs 120,000 mi/192,000 km/10 yrs

156

Maintenance

Main MenuTable of Contentsst０２／０８／０６　１８：３０：５２　３１Ｓ２Ａ６３０　０１６０　

Required Maintenance Record (for Normal and Severe Schedules)

You or the servicing dealer can record all completed maintenance here, whether you follow the schedule for normal conditions (page conditions (page

). Keep the receipts for all work done on your vehicle.

154

152

) or severe

3,750 mi 6,000 km

7,500 mi 12,000 km

11,250 mi 18,000 km

15,000 mi 24,000 km (or 1 year)

18,750 mi 30,000 km

22,500 mi 36,000 km

26,250 mi 42,000 km

30,000 mi 48,000 km (or 2 years)

Signature or dealer stamp

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

33,750 mi 54,000 km

37,500 mi 60,000 km

41,250 mi 66,000 km

45,000 mi 72,000 km (or 3 years)

48,750 mi 78,000 km

52,500 mi 84,000 km

56,250 mi 90,000 km

60,000 mi 96,000 km (or 4 years)

Signature or dealer stamp mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

CONTINUED 157

Maintenance

Main MenuTable of Contentsst０２／０８／０６　１８：３１：００　３１Ｓ２Ａ６３０　０１６１　

Required Maintenance Record (for Normal and Severe Schedules)

63,750 mi 102,000 km

67,500 mi 108,000 km

71,250 mi 114,000 km

75,000 mi 120,000 km (or 5 years)

78,750 mi 126,000 km

82,500 mi 132,000 km

86,250 mi 138,000 km

90,000 mi 144,000 km (or 6 years)

Signature or dealer stamp mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

158

Maintenance

93,750 mi 150,000 km

97,500 mi 156,000 km

101,250 mi 162,000 km

105,000 mi 168,000 km (or 7 years)

108,750 mi 174,000 km

112,500 mi 180,000 km

116,250 mi 186,000 km

120,000 mi 192,000 km (or 8 years)

Signature or dealer stamp mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

mi/km

Date

Main MenuTable of Contentsst０２／０８／０６　１８：３１：０９　３１Ｓ２Ａ６３０　０１６２　

Owner Maintenance Checks

You should check the following items at the specified intervals. If you are unsure of how to perform any check, turn to the page given.

Engine oil level time you fill the fuel tank. See page

Check every

123

−

Engine coolant level radiator reserve tank every time you fill the fuel tank. See page

Check the

124

−

−

Windshield washer fluid Check the level in the reservoir monthly. If weather conditions cause you to use the washers frequently, check the reservoir each time you stop for fuel. See page

171

−

Tires Check the tire pressure monthly. Examine the tread for wear and foreign objects. See page 189

−

Check the operation of

Lights the headlights, parking lights, taillights, high-mount brake light, turn signals, brake lights, and license plate lights monthly. See page

196

Brakes and clutch fluid level monthly. See page

Check the 174

−

Maintenance 159

Main MenuTable of Contentsst０２／０８／０６　１８：３１：１４　３１Ｓ２Ａ６３０　０１６３　

ENGINE OIL FILL CAP

CLUTCH FLUID (Gray cap)

BRAKE FLUID (Gray cap)

COOLANT RESERVOIR

Fluid Locations

WASHER FLUID (Blue cap)

ENGINE OIL DIPSTICK

160

Maintenance

Main MenuTable of Contentsst０２／０８／０６　１８：３１：２４　３１Ｓ２Ａ６３０　０１６４　

Adding Oil

damage components in the engine compartment.

Make sure the API Certification Seal says ‘‘For Gasoline Engines.’’

Engine Oil

Recommended Oil Oil is major contributor to your engine’s performance and longevity. Always use a premium-grade detergent oil displaying the API Certification Seal. This seal indicates the oil is energy conserving, and that it meets the American Petroleum Institute’s latest requirements. It is highly recommended that you use Honda Motor Oil in your vehicle for as long as you own it.

To add oil, unscrew and remove the engine oil fill cap on top of the left valve cover. Pour in the oil, and replace the engine oil fill cap. Tighten it securely. Wait a few minutes and recheck the oil level. Do not fill above the upper mark; you could damage the engine.

Pour the oil slowly and carefully so you do not spill. Clean up any spills immediately. Spilled oil could

API CERTIFICATION SEAL

CONTINUED

Maintenance 161

Main MenuTable of Contentsst０２／０８／０６　１８：３１：３２　３１Ｓ２Ａ６３０　０１６５　

Engine Oil

The oil’s viscosity or weight is provided on the container’s label. Select the oil for your car according to this chart.

Ambient Temperature

Synthetic Oil You may use a synthetic motor oil if it meets the same requirements given for a conventional motor oil: it displays the API Certification Seal, and it is the proper weight as shown on the chart. When using synthetic oil, you must follow the oil and filter change intervals given in the maintenance schedule.

Additives Your Honda does not require any oil additives. Additives may adversely affect your engine’s or transmission’s performance and durability.

An oil with a viscosity of 10W-30 is preferred for optimum fuel economy and year-round protection in your Honda. You may use a 5W-40 oil if the temperature in your area goes below 0°F (

20°C).

−

162

Maintenance

Main MenuTable of Contentsst０２／０８／０６　１８：３１：４３　３１Ｓ２Ａ６３０　０１６６　

Engine Oil

Changing the Oil and Filter Always change the oil and filter according to the time and distance (miles/kilometers) recommenda- tions in the maintenance schedule. The oil and filter collect contami- nants that can damage your engine if they are not removed regularly.

Changing the oil and filter requires special tools and access from underneath the car. The car should be raised on a service station-type hydraulic lift for this service. Unless you have the knowledge and proper equipment, you should have this maintenance done by a skilled mechanic.

1.

Run the engine until it reaches normal operating temperature, then shut it off.

WASHER

OIL DRAIN BOLT

2.

Remove the engine oil fill cap. Remove the oil drain bolt from the bottom of the engine. Drain the oil into an appropriate container.

OIL FILTER

3.

Remove the oil filter and let the remaining oil drain. A special wrench (available from your Honda dealer) is required to remove the filter.

4.

Install a new oil filter according to instructions that come with it.

CONTINUED

Maintenance 163

Main MenuTable of Contentsst０２／０８／０６　１８：３１：５２　３１Ｓ２Ａ６３０　０１６７　

9.

Turn off the engine, let it sit for several minutes, then check the oil level. If necessary, add oil to bring the level to the upper mark on the dipstick.

Improper disposal of engine oil can be harmf ul to the environment. If you change your own oil, please dispose of the used oil properly. Put it in a sealed container and take it to a recycling center. Do not discard it in a trash bin