2009 Ford E 250 Owners Manual

Download PDF Manual
2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Maintenance and Specifications ENGINE DATA Engine1 Cubic inches Required fuel 4.6L V8 engine 5.4L V8 engine 6.8L V10 engine 281 87 octane or (E-85)2 1-3-7-2-6-5-4-8 330 87 octane 415 87 octane Firing order Ignition system Coil on plug Spark plug gap 0.052–0.056 inch (1.32–1.42mm) 9.4:1 1-3-7-2-6-5-4-8 Coil on plug 0.051–0.057 inch (1.29–1.45mm) 9.0:1 1-6-5-10-2-7-3-8-4-9 Coil on plug 0.052–0.056 inch (1.32–1.42mm) 9.0:1 Compression ratio 1Refer to the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner’s Guide Supplement for diesel engine information. 24.6L V8 FFV engines only. Engine drivebelt routing • 4.6L V8, 5.4L V8 and 6.8L V10 engines without A/C 309 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Maintenance and Specifications • 4.6L V8, 5.4L V8 and 6.8L V10 engines with A/C IDENTIFYING YOUR VEHICLE Safety Compliance Certification Label (complete Ford built vehicles) The National Highway Traffic Safety Administration Regulations require that a Safety Compliance Certification Label be affixed to a vehicle and prescribe where the Safety Compliance Certification Label may be located. The Safety Compliance Certification Label is located on the structure (B-Pillar) by the trailing edge of the driver’s door or the edge of the driver’s door. 310 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Maintenance and Specifications Vehicle identification number (VIN) The VIN is located on the driver side instrument panel or on the certification label. It contains the following information: 1. World manufacturer identifier 2. Brake system / Gross Vehicle Weight Rating (GVWR) / Restraint System 3. Vehicle line, series, body type 4. Engine type 5. Check digit 6. Model year 7. Assembly plant 8. Production sequence number Certification label for incomplete vehicles On completed derivations of incomplete vehicles, the certification label is affixed at a location determined by a subsequent stage manufacturer of the completed vehicle. In these cases the completed vehicle is manufactured in two or more stages by two or more separate manufacturers. 311 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Maintenance and Specifications TRANSMISSION CODE DESIGNATIONS You can find a transmission code on the Safety Compliance Certification Label. The following table tells you which transmission each code represents. Description Four-speed automatic overdrive (4R75E) Five-speed automatic TorqShift with Tow/Haul Five-speed automatic 5R110W-Hi/Torque Code 312 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Accessories GENUINE FORD ACCESSORIES FOR YOUR VEHICLE A wide selection of Genuine Ford Accessories are available for your vehicle through your local Ford or Ford of Canada dealer. These quality accessories have been specifically engineered to fulfill your automotive needs; they are custom designed to complement the style and aerodynamic appearance of your vehicle. In addition, each accessory is made from high quality materials and meets or exceeds Ford’s rigorous engineering and safety specifications. Ford Motor Company will repair or replace any properly dealer-installed Genuine Ford Accessories found to be defective in factory-supplied materials or workmanship during the warranty period, as well as any component damaged by the defective accessories. The accessories will be warranted for whichever provides you the greatest benefit: • 12 months or 12,000 miles (20,000 km) (whichever occurs first), or • the remainder of your new vehicle limited warranty. Contact your dealer for details and a copy of the warranty. The following is a list of several Genuine Ford Accessories. Not all accessories are available for all models. For a complete listing of the accessories that are available for your vehicle, please contact your dealer or visit our online store at: www.fordaccessories.com. Exterior style Bug shields Deflectors Running boards Splash guards Interior style Electrochromatic compass/temperature interior mirrors Floor mats Lifestyle Trailer hitches, wiring harnesses and accessories Peace of mind Mobile-Ease™ hands-free communication system Remote start Vehicle security systems 313 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Accessories For maximum vehicle performance, keep the following information in mind when adding accessories or equipment to your vehicle: • When adding accessories, equipment, passengers and luggage to your vehicle, do not exceed the total weight capacity of the vehicle or of the front or rear axle (GVWR or GAWR as indicated on the Safety Compliance Certification label). Consult your authorized dealer for specific weight information. • The Federal Communications Commission (FCC) and Canadian Radio Telecommunications Commission (CRTC) regulate the use of mobile communications systems — such as two-way radios, telephones and theft alarms - that are equipped with radio transmitters. Any such equipment installed in your vehicle should comply with FCC or CRTC regulations and should be installed only by a qualified service technician. • Mobile communications systems may harm the operation of your vehicle, particularly if they are not properly designed for automotive use. • To avoid interference with other vehicle functions, such as anti-lock braking systems, amateur radio users who install radios and antennas onto their vehicle should not locate the Amateur Radio Antennas in the area of the driver’s side hood. • Electrical or electronic accessories or components that are added to the vehicle by the authorized dealer or the owner may adversely affect battery performance and durability. 314 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) A Index Accessory delay ..........................65 AdvanceTrac ..............................201 Air cleaner filter ...............302–304 Airbag supplemental restraint system ........................................110 and child safety seats ............112 description ..............................110 disposal ....................................114 driver airbag ............................112 indicator light .........................114 operation .................................112 passenger airbag .....................112 passenger deactivation switch ......................................115 Ambulance packages ....................9 Antifreeze (see Engine coolant) ................277 Anti-lock brake system (see Brakes) ......................198–199 Anti-theft system ........................88 arming the system ....................89 Audio system (see Radio) ......................22, 24, 29 Automatic transmission driving an automatic overdrive .................210, 212, 215 fluid, adding ............................298 fluid, checking ........................298 fluid, refill capacities ..............305 fluid, specification ..................305 Auxiliary Input Jack ...................36 Auxiliary power point .................63 Axle lubricant specifications ..........305 refill capacities ........................305 traction lok ..............................206 Battery .......................................274 acid, treating emergencies .....274 jumping a disabled battery ....245 maintenance-free ....................274 replacement, specifications ...304 servicing ..................................274 Belt-Minder威 .............................106 Booster seats .............................136 Brakes ........................................198 anti-lock ...........................198–199 anti-lock brake system (ABS) warning light ...........................199 fluid, checking and adding ....297 fluid, refill capacities ..............305 fluid, specifications .................305 lubricant specifications ..........305 parking ....................................199 shift interlock ..........................209 trailer .......................................187 Bulbs ............................................52 Capacities for refilling fluids ....305 Cell phone use ............................10 Changing a tire .........................235 Child safety seats ......................124 in front seat ............................125 in rear seat ..............................125 LATCH .....................................128 recommendations ...................122 tether anchorage hardware ...131 Child safety seats - booster seats ...........................................136 Cleaning your vehicle engine compartment ..............263 exterior ....................................266 315 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) D Daytime running lamps (see Lamps) ................................47 Dipstick automatic transmission fluid ..........................................298 engine oil .................................271 Driveline universal joint and slip yoke ....................................298 Driving under special conditions through water .........................223 Electronic message center .........71 Emergencies, roadside jump-starting ..........................245 Emergency Flashers .................226 Emission control system ..........293 Engine ........................................309 cleaning ...................................263 coolant .....................................277 diesel ...........................................8 fail-safe cooling .......................282 idle speed control ...................274 lubrication specifications .......305 refill capacities ........................305 service points ..........................269 starting after a collision .........226 Engine block heater .................196 Engine oil ..................................271 checking and adding ..............271 dipstick ....................................271 filter, specifications ........273, 304 recommendations ...................273 refill capacities ........................305 specifications ..........................305 Index instrument panel ....................265 interior .....................................265 plastic parts ............................264 safety belts ..............................265 washing ....................................261 waxing .....................................262 wheels ......................................262 wiper blades ............................264 Climate control (see Air conditioning or Heating) ......44–46 Clock adjust 6-CD in dash .............................30 AM/FM Stereo ...........................23 AM/FM/CD .................................25 Compass, electronic ....................62 calibration .................................63 set zone adjustment .................62 Console overhead ..............................60–61 Controls power seat .................................94 Coolant checking and adding ..............277 refill capacities ................281, 305 specifications ..........................305 Cruise control (see Speed control) ....................68 Customer Assistance ................224 Ford Extended Service Plan ..........................................258 Getting assistance outside the U.S. and Canada .....................258 Getting roadside assistance ...224 Getting the service you need .........................................253 Ordering additional owner’s literature .................................259 Utilizing the Mediation/Arbitration Program ...................................257 316 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Event data recording ....................6 Exhaust fumes ..........................196 Fail safe cooling ........................282 Flexible Fuel Vehicle (FFV) ....283 Fluid capacities .........................305 Four-Wheel Drive vehicles preparing to drive your vehicle .....................................207 Fuel ............................................283 calculating fuel economy .......290 cap ...........................................286 capacity ...................................305 choosing the right fuel ...........288 comparisons with EPA fuel economy estimates .................293 detergent in fuel .....................288 filling your vehicle with fuel ...........................283, 286, 290 filter, specifications ........283, 304 fuel pump shut-off switch .....226 improving fuel economy ........290 octane rating ...................288, 309 quality ......................................289 running out of fuel .................289 safety information relating to automotive fuels .....................283 Fuel - flex fuel vehicle (FFV) .................................283, 288 Fuses ..........................................228 Index Gauges .........................................19 Hazard flashers .........................226 Head restraints ...........................92 Headlamps ...................................47 aiming ........................................50 bulb specifications ....................53 daytime running lights .............47 flash to pass ..............................48 high beam .................................47 replacing bulbs .........................54 turning on and off ....................47 Heating heater only system .............44, 46 heating and air conditioning system .......................................45 Hood ..........................................269 Ignition ...............................193, 309 Illuminated visor mirror .............60 Infant seats (see Safety seats) .....................124 Inspection/maintenance (I/M) testing ........................................295 Instrument panel cleaning ...................................265 cluster ........................................14 lighting up panel and interior .......................................48 Garage door opener ....................61 Gas cap (see Fuel cap) ............286 Gas mileage (see Fuel economy) .................290 Jack ............................................235 positioning ...............................235 storage .....................................235 Jump-starting your vehicle ......245 317 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Index Keyless entry system autolock .....................................80 Keys .............................................90 positions of the ignition .........193 Lamps bulb replacement specifications chart ..................53 daytime running light ...............47 headlamps .................................47 headlamps, flash to pass ..........48 instrument panel, dimming .....48 interior lamps ...........................51 replacing bulbs .........................54 LATCH anchors .........................128 Lights, warning and indicator ....14 anti-lock brakes (ABS) ..........199 Load limits .................................170 Loading instructions .................176 Locks autolock .....................................80 doors ..........................................80 Lubricant specifications ...........305 Lug nuts ....................................244 Lumbar support, seats ...............94 Motorcraft parts ................267, 304 Navigation system .......................43 Octane rating ............................288 Oil (see Engine oil) ..................271 Parking brake ............................199 Parts (see Motorcraft parts) ....304 Power distribution box (see Fuses) ...............................231 Power door locks ........................80 Power mirrors .............................66 Power point .................................63 Power steering ..........................206 fluid, checking and adding ....296 fluid, refill capacity ................305 fluid, specifications .................305 Power Windows ...........................64 Preparing to drive your vehicle ........................................207 Message center ...........................71 warning messages .....................76 Mirrors ...................................65–66 automatic dimming rearview mirror ........................................65 fold away ...................................67 side view mirrors (power) .......66 Radio ................................22, 24, 29 Recommendations for attaching safety restraints for children ......................................122 Relays ........................................228 Remote entry system .................84 illuminated entry ......................88 318 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Index AM/FM/In-dash 6 CD ................30 Spare tire (see Changing the Tire) ...........238 Spark plugs, specifications .....................304, 309 Special notice ..............................10 ambulance conversions ..............9 diesel-powered vehicles .............8 utility-type vehicles ....................8 Specification chart, lubricants ...................................305 Speed control ..............................68 Stability system .........................201 Starting a flex fuel vehicle .......195 Starting your vehicle ........193–195 jump starting ..........................245 Steering wheel tilting .........................................60 Temperature control (see Climate control) ...........44, 46 Tilt steering wheel ......................60 Tire Pressure Monitoring System (TPMS) Tires, Wheels and Loading ....160 Tires ...........................142–143, 235 alignment ................................152 care ..........................................148 changing ..................235, 238–240 checking the pressure ............147 inflating ...................................144 label .........................................159 replacing ..........................150, 240 rotating ....................................152 safety practices .......................151 sidewall information ...............154 319 locking/unlocking doors ..............................80, 85–86 panic alarm ...............................86 replacement/additional transmitters ...............................87 replacing the batteries .............86 Reverse camera .........................220 Reverse sensing system ...........218 Roadside assistance ..................224 Roll stability control .................201 Safety belts (see Safety restraints) ..........................100–105 Safety defects, reporting ..........260 Safety restraints ................100–105 Belt-Minder威 ...........................106 extension assembly ................109 for adults .........................101–104 for children .............................120 warning light and chime ........105 Safety restraints - LATCH anchors ......................................128 Safety seats for children ..........124 Safety Compliance Certification Label ....................310 Satellite Radio Information ........40 Seats ............................................92 child safety seats ....................124 front seats .................................93 SecuriLock passive anti-theft system ....................................88, 90 Servicing your vehicle ..............268 Setting the clock AM/FM single CD .....................25 AM/FM stereo ...........................23 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Index snow tires and chains ............169 spare tire .........................236, 238 terminology .............................143 tire grades ...............................143 treadwear ........................142, 149 Towing .......................................177 recreational towing .................192 Trailer Brake Controller-Integrated ..............187 trailer towing ..........................177 wrecker ....................................251 Traction control ........................200 Traction-lok rear axle ...............206 Trailer Brake Controller-Integrated ................187 Transmission .............................209 brake-shift interlock (BSI) ....209 fluid, checking and adding (automatic) .............................298 fluid, refill capacities ..............305 lubricant specifications ..........305 ..................................51 Turn signal Upfitter controls .........................70 Vehicle loading ..........................170 Ventilating your vehicle ...........196 Warning lights (see Lights) .......14 Washer fluid ..............................270 Water, Driving through .............223 Windows power .........................................64 Windshield washer fluid and wipers ..........................................59 checking and adding fluid .....270 replacing wiper blades ...........271 Wrecker towing .........................251 320 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Table of Contents 14 14 19 22 22 24 29 36 40 43 44 44 45 47 47 51 52 59 59 60 64 65 68 70 71 80 80 80 88 Introduction Instrument Cluster Warning lights and chimes Gauges Entertainment Systems AM/FM stereo AM/FM stereo with CD AM/FM stereo with CDX6/MP3 Auxiliary input jack Satellite radio information Navigation system Climate Controls Heater only Manual heating and air conditioning Lights Headlamps Turn signal control Bulb replacement Driver Controls Windshield wiper/washer control Steering wheel adjustment Power windows Mirrors Speed control Upfitter controls Message center Locks and Security Keys Locks Anti-theft system 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) 92 92 100 110 120 140 142 144 160 170 177 187 192 193 193 198 200 201 201 209 218 220 224 224 226 226 228 235 244 245 251 Table of Contents Seating and Safety Restraints Seating Safety restraints Airbags Child restraints Tires, Wheels and Loading Tire information Tire inflation Tire Pressure Monitoring System (TPMS) Vehicle loading Trailer towing Trailer brake controller-integrated Recreational towing Driving Starting Brakes Traction Control™ Traction Control™/AdvanceTrac威 AdvanceTrac威 Transmission operation Reverse sensing system Reverse camera Roadside Emergencies Getting roadside assistance Hazard flasher control Fuel pump shut-off switch Fuses and relays Changing tires Wheel lug nut torque Jump starting Wrecker towing 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Table of Contents Customer Assistance Reporting safety defects (U.S. only) Reporting safety defects (Canada only) Cleaning Underbody preservation Maintenance and Specifications Engine compartment Engine oil Battery Engine coolant Fuel information Air filter(s) Part numbers Maintenance product specifications and capacities Engine data Accessories Index 253 260 260 261 266 268 269 271 274 277 283 302 304 305 309 313 315 All rights reserved. Reproduction by any means, electronic or mechanical including photocopying, recording or by any information storage and retrieval system or translation in whole or part is not permitted without written authorization from Ford Motor Company. Ford may change the contents without notice and without incurring obligation. Copyright © 2008 Ford Motor Company 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction CONGRATULATIONS Congratulations on acquiring your new Ford. Please take the time to get well acquainted with your vehicle by reading this handbook. The more you know and understand about your vehicle, the greater the safety and pleasure you will derive from driving it. For more information on Ford Motor Company and its products visit the following website: • In the United States: www.ford.com • In Canada: www.ford.ca • In Australia: www.ford.com.au • In Mexico: www.ford.com.mx Additional owner information is given in separate publications. This Owner’s Guide describes every option and model variant available and therefore some of the items covered may not apply to your particular vehicle. Furthermore, due to printing cycles it may describe options before they are generally available. Remember to pass on this Owner’s Guide when reselling the vehicle. It is an integral part of the vehicle. WARNING: Fuel pump shut-off switch (Diesel and Stripped Chassis vehicles only): In the event of an accident the safety switch will automatically cut off the fuel supply to the engine. The switch can also be activated through sudden vibration (e.g. collision when parking). To reset the switch, refer to the Fuel pump shut-off switch in the Roadside Emergencies chapter. SAFETY AND ENVIRONMENT PROTECTION Warning symbols in this guide How can you reduce the risk of personal injury to yourself or others? In this guide, answers to such questions are contained in comments highlighted by the warning triangle symbol. These comments should be read and observed. 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction Warning symbols on your vehicle When you see this symbol, it is imperative that you consult the relevant section of this guide before touching or attempting adjustment of any kind. Protecting the environment We must all play our part in protecting the environment. Correct vehicle usage and the authorized disposal of waste, cleaning and lubrication materials are significant steps towards this aim. Information in this respect is highlighted in this guide with the tree symbol. CALIFORNIA Proposition 65 Warning WARNING: Engine exhaust, some of its constituents, and certain vehicle components contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. In addition, certain fluids contained in vehicles and certain products of component wear contain or emit chemicals known to the State of California to cause cancer and birth defects or other reproductive harm. PERCHLORATE MATERIAL Certain components of this vehicle such as airbag modules, seat belt pretensioners, and button cell batteries may contain Perchlorate Material – Special handling may apply for service or vehicle end of life disposal. See www.dtsc.ca.gov/hazardouswaste/perchlorate. BREAKING-IN YOUR VEHICLE Your vehicle does not need an extensive break-in. Try not to drive continuously at the same speed for the first 1,000 miles (1,600 km) of new vehicle operation. Vary your speed frequently in order to give the moving parts a chance to break in. Drive your new vehicle at least 1,000 miles (1,600 km) before towing a trailer. For more detailed information about towing a trailer, refer to Trailer towing in the Tires, Wheels and Loading chapter. 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction Do not add friction modifier compounds or special break-in oils since these additives may prevent piston ring seating. See Engine oil in the Maintenance and Specifications chapter for more information on oil usage. SPECIAL NOTICES New Vehicle Limited Warranty For a detailed description of what is covered and what is not covered by your vehicle’s New Vehicle Limited Warranty, refer to the Warranty Guide/Customer Information Guide that is provided to you along with your Owner’s Guide. Service Data Recording Service data recorders in your vehicle are capable of collecting and storing diagnostic information about your vehicle. This potentially includes information about the performance or status of various systems and modules in the vehicle, such as engine, throttle, steering or brake systems. In order to properly diagnose and service your vehicle, Ford Motor Company, Ford of Canada, and service and repair facilities may access vehicle diagnostic information through a direct connection to your vehicle when diagnosing or servicing your vehicle. For U.S. only (if equipped), if you choose to use the SYNC威 Vehicle Health Report, you consent that certain diagnostic information may also be accessed electronically by Ford Motor Company and Ford authorized service facilities, and that the diagnostic information may be used for any purpose. See your SYNC威 supplement for more information. Event Data Recording Other modules in your vehicle — event data recorders — are capable of collecting and storing data during a crash or near crash event. The recorded information may assist in the investigation of such an event. The modules may record information about both the vehicle and the occupants, potentially including information such as: • how various systems in your vehicle were operating; • whether or not the driver and passenger seatbelts were buckled; • how far (if at all) the driver was depressing the accelerator and/or the • how fast the vehicle was traveling; and • where the driver was positioning the steering wheel. brake pedal; 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction To access this information, special equipment must be directly connected to the recording modules. Ford Motor Company and Ford of Canada do not access event data recorder information without obtaining consent, unless pursuant to court order or where required by law enforcement, other government authorities or other third parties acting with lawful authority. Other parties may seek to access the information independently of Ford Motor Company and Ford of Canada. Please note that once 911 Assist (if equipped) is enabled (set ON), 911 Assist may, through any paired and connected cell phone, disclose to emergency services that the vehicle has been in a crash involving the deployment of an airbag or, in certain vehicles, the activation of the fuel pump shut-off. Certain versions or updates to 911 Assist may also be capable of electronically or verbally disclosing to 911 operators the vehicle location, and/or other details about the vehicle or crash to assist 911 operators to provide the most appropriate emergency services. If you do not want to disclose this information, do not activate the feature. See your SYNC威 supplement for more information. Vehicle Modification Data Recording Some aftermarket products may cause severe engine and/or transmission damage; refer to the What is not covered section in The new vehicle limited warranty for your vehicle chapter of your vehicle’s Warranty Guide for more information. Some vehicles are equipped with Powertrain Control Systems that can detect and store information about vehicle modifications that increase horsepower and torque output; this information cannot be erased and will stay in the system’s memory even if the modification is removed. When a dealer or repair facility works on your vehicle, it may be necessary for them to access the information in the Powertrain Control System. This information will likely identify if any unauthorized modifications have been made to the system and may be used to determine if repairs will be covered by warranty. 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction Special instructions For your added safety, your vehicle is fitted with sophisticated electronic controls. WARNING: Please read the section Airbag Supplemental Restraint System (SRS) in the Seating and Safety Restraints chapter. Failure to follow the specific warnings and instructions could result in personal injury. WARNING: Front seat mounted rear-facing child or infant seats should NEVER be placed in front of an active passenger airbag. Notice to owners of diesel-powered vehicles Read the 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner’s Guide Supplement for information regarding correct operation and maintenance of your Diesel-powered light truck. Notice to owners of pickup trucks and utility type vehicles WARNING: Utility vehicles have a significantly higher rollover rate than other types of vehicles. Before you drive your vehicle, please read this Owner’s Guide carefully. Your vehicle is not a passenger car. As with other vehicles of this type, failure to operate this vehicle correctly may result in loss of vehicle control, vehicle rollover, personal injury or death. 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction Using your vehicle as an ambulance If your light truck is equipped with the Ford Ambulance Preparation Package, it may be utilized as an ambulance. Ford urges ambulance manufacturers to follow the recommendations of the Ford Incomplete Vehicle Manual, Ford Truck Body Builder’s Layout Book and the Qualified Vehicle Modifiers (QVM) Guidelines as well as pertinent supplements. For additional information, please contact the Truck Body Builders Advisory Service at 1–877–840–4338. Use of your Ford light truck as an ambulance, without the Ford Ambulance Preparation Package voids the Ford New Vehicle Limited Warranty and may void the Emissions Warranties. In addition, ambulance usage without the preparation package could cause high underbody temperatures, overpressurized fuel and a risk of spraying fuel which could lead to fires. If your vehicle is equipped with the Ford Ambulance Preparation Package, it will be indicated on the Safety Compliance Certification Label. The label is located on the driver’s side door pillar or on the rear edge of the driver’s door. You can determine whether the ambulance manufacturer followed Ford’s recommendations by directly contacting that manufacturer. Ford Ambulance Preparation Package is only available on certain Diesel engine equipped vehicles. 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction Using your vehicle as a stationary power source (PTO) Refer to the Driving chapter for more information and guidelines for operating a vehicle equipped with an aftermarket power take-off system. Cell phone use The use of Mobile Communications Equipment has become increasingly important in the conduct of business and personal affairs. However, drivers must not compromise their own or others’ safety when using such equipment. Mobile Communications can enhance personal safety and security when appropriately used, particularly in emergency situations. Safety must be paramount when using mobile communications equipment to avoid negating these benefits. Mobile Communication Equipment includes, but is not limited to cellular phones, pagers, portable email devices, in-vehicle communications systems, telematics devices and portable two-way radios. WARNING: Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using any device that may take their focus off the road. The driver’s primary responsibility is the safe operation of their vehicle. Only use cell phones and other devices not essential to the driving task when it is safe to do so. 10 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction Export unique (Non–United States/Canada) vehicle specific information For your particular global region, your vehicle may be equipped with features and options that are different from the ones that are described in this Owner’s Guide. A market unique supplement may be supplied that complements this book. By referring to the market unique supplement, if provided, you can properly identify those features, recommendations and specifications that are unique to your vehicle. This Owner’s Guide is written primarily for the U.S. and Canadian Markets. Features or equipment listed as standard may be different on units built for Export. Refer to this Owner’s Guide for all other required information and warnings. 11 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction These are some of the symbols you may see on your vehicle. Vehicle Symbol Glossary Safety Alert See Owner’s Guide Fasten Safety Belt Airbag - Front Airbag - Side Child Seat Tether Anchor Child Seat Lower Anchor Brake System Anti-Lock Brake System Parking Brake System Brake Fluid - Non-Petroleum Based Parking Aid System Stability Control System Speed Control Master Lighting Switch Hazard Warning Flasher Fog Lamps-Front Fuse Compartment Fuel Pump Reset Windshield Wash/Wipe Windshield Defrost/Demist Rear Window Defrost/Demist 12 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Introduction Vehicle Symbol Glossary Power Windows Front/Rear Child Safety Door Lock/Unlock Power Window Lockout Interior Luggage Compartment Release Panic Alarm Engine Oil Engine Coolant Engine Coolant Temperature Do Not Open When Hot Battery Avoid Smoking, Flames, or Sparks Battery Acid Explosive Gas Fan Warning Power Steering Fluid Maintain Correct Fluid Level MAX MIN Service Engine Soon Engine Air Filter Passenger Compartment Air Filter Jack Check Fuel Cap Low Tire Pressure Warning 13 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster WARNING LIGHTS AND CHIMES Warning lights and gauges can alert you to a vehicle condition that may become serious enough to cause expensive repairs. A warning light may illuminate when a problem exists with one of your vehicle’s functions. Many lights will illuminate when you start your vehicle to make sure the bulb works. If any light remains on after starting the vehicle, refer to the respective system warning light for additional information. If your vehicle is equipped with a Diesel engine, it has a unique cluster, refer to Starting the engine in your 6.0 and 6.4 Liter Power Stroke Direct Injection Turbo Diesel Owner’s Guide Supplement. Note: Some Warning Lights are reconfigurable telltale (RTT) indicator lights and will illuminate in the message center display and function the same as the warning light. Service engine soon: The Service engine soon indicator light illuminates when the ignition is first turned to the on position to check the bulb and to indicate whether the vehicle is ready for Inspection/Maintenance (I/M) testing. Normally, the ⬙Service engine soon⬙ light will stay on until the engine is cranked, then turn itself off if no malfunctions are present. However, if after 15 seconds the ⬙Service engine soon⬙ light blinks eight times, it means that the vehicle is not ready for I/M testing. See the Readiness for Inspection/Maintenance (I/M) testing in the Maintenance and Specifications chapter. 14 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster Solid illumination after the engine is started indicates the On Board Diagnostics System (OBD-II) has detected a malfunction. Refer to On board diagnostics (OBD-II) in the Maintenance and Specifications chapter. If the light is blinking, engine misfire is occurring which could damage your catalytic converter. Drive in a moderate fashion (avoid heavy acceleration and deceleration) and have your vehicle serviced immediately by your authorized dealer. WARNING: Under engine misfire conditions, excessive exhaust temperatures could damage the catalytic converter, the fuel system, interior floor coverings or other vehicle components, possibly causing a fire. Electronic throttle control (RTT): Displays when the engine has defaulted to a “limp-home” operation. Report the fault to a dealer at the earliest opportunity. Check fuel cap (RTT): Displays when the fuel cap may not be properly installed. Continued driving with this light on may cause the Service Engine Soon warning light to come on, refer to Fuel filler cap in the Maintenance and Specification chapter. Brake system warning light: To confirm the brake system warning light is functional, it will momentarily illuminate when the ignition is turned to the on position when the engine is not running, or in a position between on and start, or by applying the parking brake when the ignition is turned to the on position. If the brake system warning light does not illuminate at this time, seek service immediately from your authorized dealer. Illumination after releasing the parking brake indicates low brake fluid level and the brake system should be inspected immediately by your authorized dealer. BRAKE 15 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster WARNING: Driving a vehicle with the brake system warning light on is dangerous. A significant decrease in braking performance may occur. It will take you longer to stop the vehicle. Have the vehicle checked by your authorized dealer. Driving extended distances with the parking brake engaged can cause brake failure and the risk of personal injury. ABS Anti-lock brake system: If the ABS light stays illuminated or continues to flash, a malfunction has been detected, have the system serviced immediately by your authorized dealer. Normal braking is still functional unless the brake warning light also is illuminated. Airbag readiness: If this light fails to illuminate when the ignition is turned to on, continues to flash or remains on, have the system serviced immediately by your authorized dealer. A chime will sound when there is a malfunction in the indicator light. Safety belt: Reminds you to fasten your safety belt. A Belt-Minder威 chime will also sound to remind you to fasten your safety belt. Refer to the Seating and Safety Restraints chapter to activate/deactivate the Belt-Minder威 chime feature. Engine oil pressure (RTT): Displays when the oil pressure falls below the normal range, refer to Engine oil in the Maintenance and Specifications chapter. Engine coolant temperature (RTT): Displays when the engine coolant temperature is high. Stop the vehicle as soon as possible, switch off the engine and let cool. Refer to Engine coolant in the Maintenance and Specifications chapter. 16 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster WARNING: Never remove the coolant reservoir cap while the engine is running or hot. Low tire pressure warning (if equipped): Illuminates when your tire pressure is low. If the light remains on at start up or while driving, the tire pressure should be checked. Refer to Inflating your tires in the Tires, Wheels and Loading chapter. When the ignition is first turned to on, the light will illuminate for three seconds to ensure the bulb is working. If the light does not turn on or begins to flash, have the system inspected by your authorized dealer. For more information on this system, refer to Tire pressure monitoring system (TPMS) in the Tires, Wheels and Loading chapter. AdvanceTrac威 (if equipped): Flashes (two times per second) when the AdvanceTrac威 with RSC威 system is active. If the light remains on, or ⬙SERVICE RSC NOW⬙ is displayed in the odometer display with a chime, have the system serviced immediately by your authorized dealer. (Flashes one time every two seconds when AdvanceTrac威 with RSC威 system has not yet initialized and is not available.) For further information, refer to AdvanceTrac威 (Electronic stability control) with Roll stability control™ (RSC威) in the Driving chapter. WARNING: If your vehicle is equipped with the AdvanceTrac威 with RSC威 system, then it was designed to be operated with RSC威. Reduce speed and proceed to an authorized dealer to have the system serviced immediately. Transmission Tow/Haul Feature (if equipped): Illuminates when the Tow/Haul feature has been activated. Refer to the Driving chapter for transmission function and operation. If the light flashes steadily, have the system serviced immediately, damage to the transmission could occur. 17 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster Anti-theft system: Flashes when the SecuriLock™ Passive Anti-theft System has been activated. O/D OFF Overdrive off (if equipped): Illuminates when the overdrive function of the transmission has been turned off; refer to the Driving chapter. If the light does not illuminate, have the transmission serviced soon, or damage may occur. Charging system (RTT): Illuminates when the battery is not charging properly. If it stays on while the engine is running, there may be a malfunction with the charging system. Contact your authorized dealer as soon as possible. This indicates a problem with the electrical system or a related component. Speed control: Illuminates when the speed control is activated. Turns off when the speed control system is deactivated. Low fuel (RTT): Displays when the fuel level in the fuel tank is at or near empty (refer to Fuel gauge in this chapter). Turn signal: Illuminates when the left or right turn signal or the hazard lights are turned on. If the indicators stay on or flash faster, check for a burned out bulb. High beams: Illuminates when the high beam headlamps are turned on. Key-in-ignition warning chime: Sounds when the key is left in the ignition in the off or accessory position and the driver’s door is opened. 18 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster Headlamps on warning chime: Sounds when the headlamps or parking lamps are on, the ignition is off (the key is not in the ignition) and the driver’s door is opened. Parking brake on warning chime: Sounds when the parking brake is set, the engine is running and the vehicle is driven more than 3 mph (5 km/h). GAUGES Speedometer: Indicates the current vehicle speed. Engine coolant temperature gauge: Indicates engine coolant temperature. At normal operating temperature, the needle will be in the normal range (between “H” and “C”). If it enters the red section, the engine is overheating. Stop the vehicle as soon as safely possible, switch off the engine and let the engine cool. 19 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster WARNING: Never remove the coolant reservoir cap while the engine is running or hot. Odometer: Registers the total miles (kilometers) of the vehicle. Refer to Message center in the Driver Controls chapter on how to switch the display from Metric to English. Trip odometer: Registers the miles (kilometers) of individual journeys. Press the SELECT/RESET stem once to switch from the odometer to the trip odometer. Press the stem again to select Trip A and Trip B features. To reset the trip, press and hold the stem again until the trip reading is 0.0 miles. Tachometer: Indicates the engine speed in revolutions per minute. Driving with your tachometer pointer continuously at the top of the scale may damage the engine. Battery voltage gauge: Indicates the battery voltage when the ignition is in the on position. If the pointer moves and stays outside the normal operating range, have the vehicle’s electrical system checked by your authorized dealer as soon as possible. 20 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Instrument Cluster Engine oil pressure gauge: Indicates engine oil pressure. The needle should stay in the normal operating range (between “L” and “H”). If the needle falls below the normal range, stop the vehicle, turn off the engine and check the engine oil level. Add oil if needed. If the oil level is correct, have your vehicle checked by your authorized dealer. Fuel gauge: Indicates approximately how much fuel is left in the fuel tank (when the ignition is in the on position). The fuel gauge may vary slightly when the vehicle is in motion or on a grade. The FUEL icon and arrow indicates which side of the vehicle the fuel filler door is located. Refer to Filling the tank in the Maintenance and Specifications chapter for more information. 21 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems AUDIO SYSTEMS AM/FM stereo system (if equipped) WARNING: Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using any device that may take their focus off the road. The driver’s primary responsibility is the safe operation of their vehicle. Only use cell phones and other devices not essential to the driving task when it is safe to do so. Accessory delay: Your vehicle is equipped with accessory delay which allows you to operate the radio and other electrical accessories for up to ten minutes after the ignition has been turned off or until either front door is opened. to : Press 1. manually go up or down the radio frequency. Press and hold for a fast advance through radio frequencies. Also use in AUDIO mode to gain access to various settings. 22 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems 2. AUDIO: Press AUDIO repeatedly to gain access to the following settings: SEEK to adjust the audio between the left (L) and BAL (Balance): Press AUDIO to reach the balance setting. Use right (R) speakers. FAD (Fade)–If equipped with four speaker audio system: Press SEEK AUDIO to reach the fade feature. Use the audio between the front (F) and back (B) speakers. TREB (Treble): Press to adjust the treble setting. Use to adjust SEEK to adjust. BASS (Bass): Press to adjust the bass setting. Use SEEK to adjust. to SEEK 3. SEEK: Press access the previous/next strong station. 4. Memory presets: To set a station: Select frequency band AM/FM1/FM2; tune to a station, press and hold a preset button until sound returns. You can save up to 18 stations, six in AM, six in FM1 and FM2. 5. AM/FM: Press AM/FM to select AM/FM1/FM2 frequency band. 6. ON/OFF/Volume: Press VOL-PUSH to turn ON/OFF. Turn VOL-PUSH to increase/decrease volume. 7. CLK (Clock): Press CLK to toggle between displaying the radio frequency and the clock setting. 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) 23 Entertainment Systems Setting the clock: Press and hold CLK until the hours begin to flash. to manually increase/decrease the hours. Press SEEK to Press CLK again to set the minutes using manually increase/decrease the minutes. Allow 10 seconds to pass to confirm that the time has been set. SEEK AM/FM Single CD/MP3 sound system (if equipped) WARNING: Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using any device that may take their focus off the road. The driver’s primary responsibility is the safe operation of their vehicle. Only use cell phones and other devices not essential to the driving task when it is safe to do so. Accessory delay: Your vehicle is equipped with accessory delay. With this feature, the radio and other electrical devices may be used for up to ten minutes after the ignition is turned off or until either front door is opened. 24 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems (Tuner): Press to 1. manually go up or down the radio frequency. Also use in menu mode to select various settings. (Phone): Pressing 2. (Phone) results in “NO PHONE” message shown in display. 3. MENU: Press repeatedly to access the following settings: Setting the clock: Press MENU until SET HOURS or SET MINUTES is to manually increase/decrease. Press MENU again displayed. Use to disengage clock mode. AUTOSET: Press MENU until the display reads AUTOSET. Autoset allows you to set the strongest local radio stations without losing your original manually set preset stations for AM/FM1/FM2. Use to turn on/off. When the six strongest stations are filled, the station stored in preset 1 will begin playing. If there are less than six strong stations, the system will store the last one in the remaining presets. RBDS: Available only in FM mode. This feature allows you to search RBDS-equipped stations for a certain category of music format: CLASSIC, COUNTRY, INFORM, JAZZ/RB, ROCK, etc. To activate, press MENU repeatedly until RBDS (ON/OFF) appears in to toggle RBDS ON/OFF. When RBDS is OFF, the display. Use you will not be able to search for RBDS equipped stations or view the station name or type. To search for specific RBDS music categories: When the desired category appears in the display, press then press and release begin the search. To view the station name or type: When the desired category appears in the display, press TEXT/SCAN to toggle between displaying the station type (COUNTRY, ROCK, etc.) or the station name (WYCD, WXYZ, etc.). BASS: Press MENU to reach the bass setting. Use to find the desired type, or press and hold SCAN to SEEK, SEEK to adjust. 25 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems TREB (Treble): Press MENU to reach the treble setting. Use adjust. to to adjust. BAL (Balance): Press MENU to reach the balance setting. Use to adjust the audio between the left (L) and right (R) speakers. Press OK to close and return to the main menu. FADE (If equipped with four speaker audio system): Press MENU to adjust the audio between the to reach the fade setting. Use back (B) and front (F) speakers. SPEED VOL (Speed sensitive volume, if equipped): Press MENU to reach the SPEEDVOL setting. Radio volume automatically gets louder with increasing vehicle speed to compensate for road and wind noise. Use The default setting is off; increasing your vehicle speed will not change the volume level. Adjust 1–7: Increasing this setting from 1 (lowest setting) to 7 (highest setting) allows the radio volume to automatically change slightly with vehicle speed to compensate for road and wind noise. Recommended level is 1–3; SPEED OFF turns the feature off and level 7 is the maximum setting. TRACK/FOLDER MODE: Available only on MP3 discs in CD mode. In track mode, press the disc In folder mode, press within the selected folder. Press available). COMPRESS (Compression): Available only in CD/MP3 mode. Press to MENU until COMPRESS ON/OFF appears in the display. Use toggle ON/OFF. When COMPRESS is ON, the system will bring the soft and loud CD passages together for a more consistent listening level. 4. AUX: Press repeatedly to reach LINE IN (auxiliary audio mode). For location and further information on auxiliary audio mode, refer to Auxiliary input jack later in this chapter. to access the previous/next folder (if to scroll through tracks FOLDER, FOLDER to scroll through all tracks on SEEK, SEEK SEEK, SEEK 26 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems to OK 5. SEEK: In radio mode, to access the press previous/next strong station. In CD mode, press access the previous/next CD track. 6. (Play/Pause): This control is operational in CD/MP3 mode. When a CD/MP3 is playing, press to pause or play the current CD/MP3. The CD/MP3 status will display in the radio display. OK: Use in various menu selections. 7. SHUFFLE: Press SHUFFLE to engage shuffle mode. SHUFFLE ON will appear in the display. If you wish to engage shuffle mode right away, press SEEK to begin random play. Otherwise, random play will begin when the current track is finished playing. CD SHUF will appear in the display. To disengage, press SHUFFLE. SHUFFLE OFF will appear in the display. Note: In track mode, all tracks on the current disc will shuffle in random order. In MP3 folder mode, the system will randomly play all tracks within the current folder. 8. FOLDER press FOLDER folder on MP3 discs, if available. FOLDER: In folder mode, 9. FOLDER to access the press previous folder on MP3 discs, if available. 10. FF (Fast forward): Press FF to manually advance in a CD/MP3 track. 11. REW (Rewind): Press REW to manually reverse in a CD/MP3 track. : In folder mode, to access next 27 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems 12. Memory presets: To set a station, select the desired frequency band, AM, FM1 or FM2. Tune to the desired station. Press and hold a preset button until sound returns and PRESET # SAVED appears in the display. You can save up to 18 stations, six in AM, six in FM1 and FM2. 13. TEXT/SCAN: In radio and CD/MP3 mode, press and hold for a brief sampling of radio stations or CD tracks. Press again to stop. In MP3 mode, press and release to display track title, artist name, and disc title. In TEXT MODE, sometimes the display requires additional text to be to view the displayed. When the “>” indicator is active, press SEEK SEEK additional display text. When the “<” indicator is active, press to view the previous display text. 14. AM/FM: Press to select AM/FM1/FM2 frequency band. 15. ON/OFF/Volume: Press to turn ON/OFF. Turn to increase/decrease volume. Note: If the volume is set above a certain level and the ignition is turned off, the volume will come back on at a “nominal” listening level when the ignition switch is turned back on. 16. CD: Press to enter CD/MP3 mode. If a CD/MP3 is already loaded into the system, CD/MP3 play will begin where it ended last. If no CD is loaded, NO DISC will appear in the display. 17. CD. (CD eject): Press to eject a 18. CD slot: Insert a CD label side up in the CD slot. 28 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems Premium/Audiophile AM/FM in-dash six CD/MP3 satellite compatible sound system (if equipped) WARNING: Driving while distracted can result in loss of vehicle control, accident and injury. Ford strongly recommends that drivers use extreme caution when using any device that may take their focus off the road. The driver’s primary responsibility is the safe operation of their vehicle. Only use cell phones and other devices not essential to the driving task when it is safe to do so. Accessory delay: Your vehicle is equipped with accessory delay. With this feature, the radio and certain electrical accessories may be used for up to ten minutes after the ignition is turned off or until either front door is opened. (Tune/Disc selector): 1. In radio mode, press to manually go up frequency. Press and hold for a fast advance through radio frequencies. In menu mode, use to select various settings. In CD/MP3 mode, press to select the desired disc. In CATEGORY mode (if equipped), press to scroll through the list of available SIRIUS channel categories. the radio or down 29 2009 Econoline (eco) Owners Guide, 2nd Printing USA (fus) Entertainment Systems (Phone): Pressing Satellite radio is available only with a valid SIRIUS radio subscription. Check with your authorized dealer for availability. 2. (Phone) results in “NO PHONE” message shown in display. 3. MENU: Press repeatedly to access to the following settings: to adjust the hours/minutes. Setting the clock: Press until SELECT HOURS or SELECT MINS is displayed. Press SATELLITE RADIO MENU (if equipped): Press MENU when satellite radio mode is active to access. Press OK to enter into the satellite radio menu. Press • CATEGORY: Press OK to enter category mode. Press to cycle through the following options: to scroll through the list of available SIRIUS channel Categories (Pop, Rock, News, etc.) Press OK when the desired category appears in the display. After a category is selected, press SEEK to search for that specific category of channels only (i.e. ROCK). You may also select CATEGORY ALL to seek all available SIRIUS categories and channels. • SAVE SONG: Press OK to save the currently playing song in the system’s memory. (If you try to save something other than a song, CANT SAVE will appear in the display.) When the chosen song is playing on any satellite radio channel, the system will alert you with an audible prompt. Press OK while SONG ALERT is in the display and the system will take you to the channel playing the desired song. You can save up to 20 songs. If you attempt to save a song when the system is full, the display will read REPLACE SONG? Press OK to access the saved songs and press songs. When the song appears in the display that you would like to

Boost Classifieds - Car Advice, Reviews, Events & Classifieds

2009 Ford E 250 Owners Manual