2005 Chevrolet Silverado Owners Manual

Left Bussed Electrical Center, Left Doors, Truck Body Controller, Flasher Module Parking Lamps Trailer Wiring Right Rear Parking and Sidemarker Lamps Left Rear Parking and Sidemarker Lamps Parking Lamps Relay Starter Relay Interior Lamps Stoplamps Truck Body Controller Battery Feed Sunroof Off-Road Lamps

5-133

Usage Vent Solenoid Canister/Quadrasteer Module Power Not Used Auxiliary Power Outlet — Console Ignition Relay Powertrain Control Module Electronic Throttle Control, Electronic Brake Controller Instrument Panel Cluster, Air Conditioning Relay, Turn Signal/Hazard Switch, Starter Relay Ride Control Backup Lamps Trailer Wiring Powertrain Control Module, Fuel Pump Fuel Pump (Relay) Back-up Lamps, Automatic Transmission Shift Lock Control System Rear Window Defogger Headlamp High Beam Relay Not Used

Fuses 02B

AIRBAG

FRT PARK

DRL

SEO IGN TBC IGN1
HI HDLP-LT LH HID DRL RVC

IPC/DIC

HVAC/ECAS CIG LTR HI HDLP-RT HDLP-LOW A/C COMP

A/C COMP

Usage Oxygen Sensors Supplemental Inflatable Restraint System Front Parking Lamps, Sidemarker Lamps Daytime Running Lamps (Relay) Rear Defog Relay Truck Body Controller Ignition High Beam Headlamp-Left Not Used Daytime Running Lamps Regulated Voltage Control Instrument Panel Cluster/Driver Information Center Climate Control Controller Cigarette Lighter High Beam Headlamp-Right Headlamp Low Beam Relay Air Conditioning Compressor Air Conditioning Compressor Relay

Fuses

4WS

RR HVAC

AUX PWR

IGN 1
PCM 1

ETC/ECM

IGN E

RTD TRL B/U

PCM B

F/PMP

B/U LP

RR DEFOG HDLP-HI PRIME

5-134

Fuses RR WPR RADIO

SEO B1

LO HDLP-LT

BTSI

CRNK LO HDLP-RT FOG LP FOG LP HORN

W/S WASH

W/S WASH

INFO

RADIO AMP RH HID HORN EAP TREC SBA

Usage Not Used Audio System Mid Bussed Electrical Center, Rear Heated Seats, HomeLink Headlamp Low Beam-Left Brake Transmission Shift Interlock System Starting System Headlamp Low Beam-Right Fog Lamp Relay Fog Lamps Horn Relay Windshield Washer Pump Relay Windshield Washer Pump OnStar®/Rear Seat Entertainment Radio Amplifier Not Used Horn Not Used All-Wheel Drive Module Supplemental Brake Assist

Auxiliary Electric Cooling Fan Fuse Block

The auxiliary electric cooling fan fuse block is located in the engine compartment on the driver’s side of the vehicle next to the underhood fuse block.

Lift the cover for access to the fuse/relay block.

Fuses

COOL/FAN COOL/FAN COOL/FAN

Usage Cooling Fan Cooling Fan Relay Fuse Cooling Fan Fuse

Relays

Usage

COOL/FAN 1 Cooling Fan Relay 1
COOL/FAN 3 Cooling Fan Relay 3
COOL/FAN 2 Cooling Fan Relay 2

5-135

Capacities and Specifications The following approximate capacities are given in English and metric conversions. See Recommended Fluids and Lubricants on page 6-13 for more information.

Application

Air Conditioning Refrigerant R134a

Cooling System

VORTECâ„¢ 4300 V6 Automatic with Front A/C* VORTECâ„¢ 4300 V6 Automatic with Front A/C** VORTECâ„¢ 4300 V6 Manual with Front A/C* VORTECâ„¢ 4300 V6 Manual with Front A/C** VORTECâ„¢ 4800 V8 Automatic with Front A/C* VORTECâ„¢ 4800 V8 Automatic with Front A/C** VORTECâ„¢ 4800 V8 Manual with Front A/C*

Capacities

English

1.6 lbs

14.8 qts 16.4 qts 15.1 qts 16.6 qts

—

16.8 qts

—

Metric

0.7 kg

14.0 L 15.5 L 14.3 L 15.7 L

—

15.9 L

—

5-136

Application

Capacities

English

Metric

Cooling System

VORTECâ„¢ 4800 V8 Manual with Front A/C** VORTECâ„¢ 5300 V8 Automatic with Front A/C* VORTECâ„¢ 5300 V8 Automatic with Front A/C** VORTECâ„¢ 6000 V8 Automatic* VORTECâ„¢ 6000 V8 Automatic** VORTECâ„¢ 6000 V8 Manual* VORTECâ„¢ 6000 V8 Manual** VORTECâ„¢ 8100 V8 HD Automatic* VORTECâ„¢ 8100 V8 HD Automatic** VORTECâ„¢ 8100 V8 Automatic* VORTECâ„¢ 8100 V8 Automatic** VORTECâ„¢ 8100 V8 Manual* VORTECâ„¢ 8100 V8 Manual**

* Engine Fan Driven cooling system ** Electric Cooling Fan system

17.0 qts

—

16.8 qts 16.0 qts 16.7 qts 16.4 qts

—

25.0 qts

—

26.9 qts

—

27.1 qt

—

16.1 L

—

15.9 L 15.1 L 15.8 L 15.5 L

—

23.7 L

—

25.5 L

—

25.6 L

—

5-137

Application

Capacities

English

Metric

Engine Oil with Filter

4300 V6
4800 V8; 5300 V8; 6000 V8
8100 V8

Fuel Tank

Short Bed and 2500 LD Long Bed and Chassis Cab (Pickup Box Delete) Chassis Cab 3500 and 3500HD — front Chassis Cab 3500 and 3500HD — rear

Wheel Nut Torque

4.5 qt 6.0 qt 6.5 qt

26.0 gal 36.0 gal 27.0 gal 23.0 gal

140 ft lb

4.3 L 5.7 L 6.1 L

98.0 L 136.0 L 102.0 L 87.0 L 190 Y

After refill, the level must be rechecked. Add enough engine coolant so that the fluid is within the proper operating range.

5-138

Engine

VIN Code

Transmission

Spark Plug Gap

Engine Specifications

VORTECâ„¢ 4300 V6

VORTECâ„¢ 4800 V8

VORTECâ„¢ 5300 V8

VORTECâ„¢ 5300 V8

VORTECâ„¢ 6000 V8

VORTECâ„¢ 6000 V8

VORTECâ„¢ 8100 V8

Automatic

Manual

Automatic

Manual

Automatic

Automatic

Automatic

Manual

Automatic

Manual

Automatic

Manual

0.060 inches (1.52 mm)

0.040 inches (1.01 mm)

0.040 inches (1.01 mm)

0.040 inches (1.01 mm)

0.040 inches (1.01 mm)

0.040 inches (1.01 mm)

0.060 inches (1.52 mm)

5-139

✍ NOTES

5-140

Section 6

Maintenance Schedule

Maintenance Schedule ......................................6-2
Introduction ...................................................6-2
Maintenance Requirements ..............................6-2
Your Vehicle and the Environment ....................6-2
Using Your Maintenance Schedule ....................6-2
Scheduled Maintenance ...................................6-4
Additional Required Services ............................6-6
Maintenance Footnotes ...................................6-8
Owner Checks and Services ..........................6-10

At the First 100, 1,000 and 6,000 Miles

(160, 1 600 and 10 000km) ...........................6-10
At Each Fuel Fill ..........................................6-10
At Least Once a Month .................................6-11
At Least Once a Year ...................................6-11
Recommended Fluids and Lubricants ...............6-13
Normal Maintenance Replacement Parts ..........6-16
Maintenance Record .....................................6-17

6-1

Maintenance Schedule

Introduction Important: Keep engine oil at the proper level and change as recommended.

Have you purchased the GM Protection Plan? The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet or your dealer for details.

Maintenance Requirements Notice: Maintenance intervals, checks, inspections, replacement parts and recommended fluids and lubricants as prescribed in this manual are necessary to keep your vehicle in good working condition. Any damage caused by failure to follow scheduled maintenance may not be covered by warranty.

6-2

Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep your vehicle in good working condition, but also helps the environment. All recommended maintenance is important. Improper vehicle maintenance can even affect the quality of the air we breathe. Improper fluid levels or the wrong tire inflation can increase the level of emissions from your vehicle. To help protect our environment, and to keep your vehicle in good condition, be sure to maintain your vehicle properly.

Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we do not know exactly how you will drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands or in many other ways. Because of all the different ways people use their vehicles, maintenance needs vary. You may need more frequent checks and replacements. So please read the following and note how you drive. If you have any questions on how to keep your vehicle in good condition, see your GM Goodwrench® dealer.

This schedule is for vehicles that:

carry passengers and cargo within recommended limits. You will find these limits on the tire and loading information label. See Loading Your Vehicle on page 4-50. are driven on reasonable road surfaces within legal driving limits. are driven off-road in the recommended manner. See Off-Road Driving on page 4-20. use the recommended fuel. See Gasoline Octane on page 5-6.

The services in Scheduled Maintenance on page 6-4
should be performed when indicated. See Additional Required Services on page 6-6 and Maintenance Footnotes on page 6-8 for further information.

{CAUTION:

Performing maintenance work on a vehicle can be dangerous. In trying to do some jobs, you can be seriously injured. Do your own maintenance work only if you have the required know-how and the proper tools and equipment for the job. If you have any doubt, see your GM Goodwrench® dealer to have a qualified technician do the work.

Some maintenance services can be complex. So, unless you are technically qualified and have the necessary equipment, you should have your GM Goodwrench® dealer do these jobs. When you go to your GM Goodwrench® dealer for your service needs, you will know that GM-trained and supported service technicians will perform the work using genuine GM parts. If you want to purchase service information, see Service Publications Ordering Information on page 7-13. Owner Checks and Services on page 6-10 tells you what should be checked, when to check it and what you can easily do to help keep your vehicle in good condition.

6-3

(cid:127) (cid:127) (cid:127) (cid:127) See Engine Oil Life System (Gasoline Engine) on page 5-23 for information on the Engine Oil Life System and resetting the system. When the CHANGE ENGINE OIL message appears, certain services, checks and inspections are required. Required services are described in the following for “Maintenance I” and “Maintenance II.” Generally, it is recommended that your first service be Maintenance I, your second service be Maintenance II and that you alternate Maintenance I and Maintenance II thereafter. However, in some cases, Maintenance II may be required more often. Maintenance I — Use Maintenance I if the CHANGE ENGINE OIL message comes on within 10 months since the vehicle was purchased or Maintenance II was performed. Maintenance II — Use Maintenance II if the previous service performed was Maintenance I. Always use Maintenance II whenever the message comes on 10 months or more since the last service or if the message has not come on at all for one year.

The proper replacement parts, fluids and lubricants to use are listed in Recommended Fluids and Lubricants on page 6-13 and Normal Maintenance Replacement Parts on page 6-16. When your vehicle is serviced, make sure these are used. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. We recommend the use of genuine GM parts.

Scheduled Maintenance When the CHANGE ENGINE OIL message comes on, it means that service is required for your vehicle. Have your vehicle serviced as soon as possible within the next 600 miles (1 000 km). It is possible that, if you are driving under the best conditions, the engine oil life system may not indicate that vehicle service is necessary for over a year. However, your engine oil and filter must be changed at least once a year and at this time the system must be reset. Your GM Goodwrench® dealer has GM-trained service technicians who will perform this work using genuine GM parts and reset the system. If the engine oil life system is ever reset accidentally, you must service your vehicle within 3,000 miles (5 000 km) since your last service. Remember to reset the oil life system whenever the oil is changed.

6-4

Scheduled Maintenance

Service

Maintenance I Maintenance II

Change engine oil and filter. See Engine Oil (Gasoline Engine) on page 5-20. Reset oil life system. See Engine Oil Life System (Gasoline Engine) on page 5-23. An Emission Control Service. Allison Transmission® only: Replace external control-main filter only at the first maintenance service performed on the vehicle.

Lubricate chassis components. See footnote #.

Visually check for any leaks or damage. See footnote (j).

Inspect engine air cleaner filter or change indicator (if equipped). If necessary, replace filter. See Engine Air Cleaner/Filter on page 5-25. An Emission Control Service. See footnotes † and (p).

Rotate tires and check inflation pressures and wear. See Tires on page 5-76.

Inspect brake system. See footnote (a).

Check engine coolant and windshield washer fluid levels and add fluid as needed.

Perform any needed additional services. See “Additional Required Services” in this section.

Inspect suspension and steering components. See footnote (b).

Inspect engine cooling system. See footnote (c).

Inspect wiper blades. See footnote (d).

•

• •

• •

•

•

•

• •

•

• •

•

•

• • •

6-5

Scheduled Maintenance (cont’d) Service

Maintenance I Maintenance II

Inspect restraint system components. See footnote (e).

Lubricate body components. See footnote (f).

Check transmission fluid level and add fluid as needed.

Inspect shields, vehicles with diesel engine or with GVWR above 10,000 lbs (4 536 kg) only. See footnote (n).

• • •

•

Additional Required Services The following services should be performed at the first maintenance service (I or II) after the indicated miles (kilometers) shown for each item.

Additional Required Services 75,000

25,000
(41 500)

50,000
(83 000)

(125 000)

•

•

•

•

•

•

•

100,000
(166 000)

125,000
(207 500)

150,000
(240 000)

•

•

•

•

•

•

•

•

Service and Miles (Kilometers)

Inspect fuel system for damage or leaks. Inspect exhaust system for loose or damaged components. Vehicles without a filter restriction indicator: Replace engine air cleaner filter. See Engine Air Cleaner/Filter on page 5-25. An Emission Control Service.

6-6

Additional Required Services (cont’d)

Service and Miles (Kilometers)

6-speed manual transmission only: Change clutch fluid. See footnote (l). Allison Transmission® only: Change automatic transmission fluid and filter (severe service). See footnote (m). Allison Transmission® only: Change automatic transmission fluid and filter (normal service). Except Allison Transmission®: Change automatic transmission fluid and filter (severe service). See footnote (h). Except Allison Transmission®: Change automatic transmission fluid and filter (normal service). Four-wheel drive with automatic transfer case only: Change transfer case fluid. See footnote (g). Inspect evaporative control system. An Emission Control Service. See footnotes † and (k). Replace spark plugs and inspect spark plug wires. An Emission Control Service.

25,000
(41 500)

50,000
(83 000)

75,000

(125 000)

100,000
(166 000)

125,000
(207 500)

150,000
(240 000)

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

•

6-7

Additional Required Services (cont’d)

Service and Miles (Kilometers)

Engine cooling system service (or every five years, whichever occurs first). An Emission Control Service. See footnote (i). Inspect engine accessory drive belt. An Emission Control Service. 5-speed manual transmission only: Change manual transmission fluid.

25,000
(41 500)

50,000
(83 000)

75,000

(125 000)

100,000
(166 000)

125,000
(207 500)

150,000
(240 000)

•

•

•

Maintenance Footnotes † The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

# Lubricate the front suspension, ball joints, steering linkage, transmission shift linkage and parking brake cable guides. Ball joints should not be lubricated unless their temperature is 10°F (−12°C) or higher, or they could be damaged. Vehicles used under severe commercial operating conditions require lubrication on a regular basis every 3,000 miles (5 000 km). (a) Visually inspect brake lines and hoses for proper hook-up, binding, leaks, cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Inspect drum brake linings for wear or cracks. Inspect other brake parts, including drums, wheel cylinders, calipers, parking brake, etc.

6-8

(b) Visually inspect front and rear suspension and steering system for damaged, loose or missing parts, signs of wear or lack of lubrication. Inspect power steering lines and hoses for proper hook-up, binding, leaks, cracks, chafing, etc. Visually check constant velocity joints, rubber boots and axle seals for leaks. (c) Visually inspect hoses and have them replaced if they are cracked, swollen or deteriorated. Inspect all pipes, fittings and clamps; replace with genuine GM parts as needed. To help ensure proper operation, a pressure test of the cooling system and pressure cap and cleaning the outside of the radiator and air conditioning condenser is recommended at least once a year. (d) Visually inspect wiper blades for wear or cracking. Replace blade inserts that appear worn or damaged or that streak or miss areas of the windshield. (e) Make sure the safety belt reminder light and all your belts, buckles, latch plates, retractors and anchorages are working properly. Look for any other loose or damaged safety belt system parts. If you see anything that might keep a safety belt system from doing its job, have it repaired. Have any torn or frayed safety belts replaced. Also look for any opened or broken airbag coverings, and have them repaired or replaced. (The airbag system does not need regular maintenance.)

(f) Lubricate all key lock cylinders, body door hinges, hood latch assembly, secondary latch, pivots, spring anchor, release pawl, tailgate hinges, tailgate linkage, tailgate handle pivot points, latch bolt, fuel door hinge, locks and folding seat hardware. More frequent lubrication may be required when exposed to a corrosive environment. Applying silicone grease on weatherstrips with a clean cloth will make them last longer, seal better and not stick or squeak. (g) Check vent hose at transfer case for kinks and proper installation. (h) Change automatic transmission fluid and filter if the vehicle GVWR is over 8600 lbs or if the vehicle is mainly driven under one or more of these conditions:

− In heavy city traffic where the outside temperature

regularly reaches 90°F (32°C) or higher.

− In hilly or mountainous terrain. − When doing frequent trailer towing. − Uses such as found in taxi, police or delivery

service.

(i) Drain, flush and refill cooling system. This service can be complex; you should have your dealer perform this service. See Engine Coolant on page 5-35 for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and filler neck. Pressure test the cooling system and pressure cap.

6-9

(j) A fluid loss in any vehicle system could indicate a problem. Have the system inspected and repaired and the fluid level checked. Add fluid if needed. (k) Inspect system. Check all fuel and vapor lines and hoses for proper hook-up, routing and condition. Check that the purge valve works properly (if equipped). Replace as needed. (l) Change clutch fluid (or every 24 months, whichever occurs first). (m) Change automatic transmission fluid and filter if the vehicle is mainly driven under one or more of these conditions:

− In heavy city traffic where the outside temperature

regularly reaches 90°F (32°C) or higher.

− In hilly or mountainous terrain. − When doing frequent trailer towing. − Uses such as found in taxi, police or delivery

service.

(n) Vehicles with diesel engine or with GVWR above 10,000 lbs (4 536 kg) only: Inspect shields for damage or looseness. Adjust or replace as required. This is a Noise Emission Control Service. Applicable only to vehicles sold in the United States. (p) If you drive regularly under dusty conditions, inspect the filter or change indicator (if equipped) at each engine oil change.

Owner Checks and Services These owner checks and services should be performed at the intervals specified to help ensure the safety, dependability and emission control performance of your vehicle. Your GM Goodwrench® dealer can assist you with these checks and services. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to your vehicle, make sure they are the proper ones, as shown in Recommended Fluids and Lubricants on page 6-13. At the First 100, 1,000 and 6,000 Miles (160, 1 600 and 10 000 km) Check dual wheel nut torque. For proper torque, see Capacities and Specifications on page 5-136.

At Each Fuel Fill It is important to perform these underhood checks at each fuel fill. Engine Oil Level Check Check the engine oil level and add the proper oil if necessary. See Engine Oil (Gasoline Engine) on page 5-20 for further details.

6-10

It is important to check your oil regularly

Notice: and keep it at the proper level. Failure to keep your engine oil at the proper level can cause damage to your engine not covered by your warranty. Engine Coolant Level Check Check the engine coolant level and add DEX-COOL® coolant mixture if necessary. See Engine Coolant on page 5-35 for further details. Windshield Washer Fluid Level Check Check the windshield washer fluid level in the windshield washer tank and add the proper fluid if necessary.

At Least Once a Month Tire Inflation Check Visually inspect your tires and make sure tires are inflated to the correct pressures. Do not forget to check your spare tire. See Tires on page 5-76 for further details. Check to make sure the spare tire is stored securely. Push, pull and then try to turn the spare tire. If it moves, tighten it. See Changing a Flat Tire on page 5-96.

At Least Once a Year Starter Switch Check

{CAUTION:

When you are doing this inspection, the vehicle could move suddenly. If the vehicle moves, you or others could be injured.

1. Before you start, be sure you have enough room

around the vehicle.

2. Firmly apply both the parking brake and the regular

brake. See Parking Brake on page 2-49 if necessary. Do not use the accelerator pedal, and be ready to turn off the engine immediately if it starts.

3. Try to start the engine in each gear. The starter should work only in PARK (P) or NEUTRAL (N). If the starter works in any other position, contact your GM Goodwrench® dealer for service.

6-11

Automatic Transmission Shift Lock Control System Check

{CAUTION:

When you are doing this inspection, the vehicle could move suddenly. If the vehicle moves, you or others could be injured.

1. Before you start, be sure you have enough room around the vehicle. It should be parked on a level surface.

2. Firmly apply the parking brake. See Parking Brake

on page 2-49 if necessary. Be ready to apply the regular brake immediately if the vehicle begins to move.

3. With the engine off, turn the ignition to RUN, but do

not start the engine. Without applying the regular brake, try to move the shift lever out of PARK (P) with normal effort. If the shift lever moves out of PARK (P), contact your GM Goodwrench® dealer for service.

Ignition Transmission Lock Check While parked, and with the parking brake set, try to turn the ignition to LOCK in each shift lever position.

The ignition should turn to LOCK only when the shift lever is in PARK (P). The key should come out only in LOCK.

Contact your GM Goodwrench® dealer if service is required. Parking Brake and Automatic Transmission Park (P) Mechanism Check

{CAUTION:

When you are doing this check, your vehicle could begin to move. You or others could be injured and property could be damaged. Make sure there is room in front of your vehicle in case it begins to roll. Be ready to apply the regular brake at once should the vehicle begin to move.

6-12

(cid:127) (cid:127) Park on a fairly steep hill, with the vehicle facing downhill. Keeping your foot on the regular brake, set the parking brake.

To check the parking brake’s holding ability: With the engine running and transmission in NEUTRAL (N), slowly remove foot pressure from the regular brake pedal. Do this until the vehicle is held by the parking brake only. To check the PARK (P) mechanism’s holding ability: With the engine running, shift to PARK (P). Then release the parking brake followed by the regular brake.

Contact your GM Goodwrench® dealer if service is required. Underbody Flushing Service At least every spring, use plain water to flush any corrosive materials from the underbody. Take care to clean thoroughly any areas where mud and other debris can collect.

Recommended Fluids and Lubricants Fluids and lubricants identified below by name, part number or specification may be obtained from your dealer.

Usage

Engine Oil

Engine Coolant

Hydraulic Brake

System

Fluid/Lubricant Engine oil which meets GM Standard GM6094M and displays the American Petroleum Institute Certified for Gasoline Engines starburst symbol. GM Goodwrench® oil meets all the requirements for your vehicle. To determine the proper viscosity for your vehicle’s engine, see Engine Oil (Gasoline Engine) on page 5-20. 50/50 mixture of clean, drinkable water and use only DEX-COOL® Coolant. See Engine Coolant on page 5-35. Delco Supreme 11 Brake Fluid or equivalent DOT-3 brake fluid.

Windshield

Washer Solvent GM Optikleen® Washer Solvent.

Hydraulic

Clutch System

(5-Speed Trans.)

Hydraulic Clutch Fluid (GM Part No. U.S. 12345347, in Canada 10953517) or equivalent DOT-3 brake fluid.

6-13

(cid:127) (cid:127) Fluid/Lubricant

Hydraulic Clutch Fluid. Use only GM Part No. U.S. 88958860, in Canada 88901244, Super DOT-4
brake fluid. GM Power Steering Fluid (GM Part No. U.S. 89021184, in Canada 89021186). GM Goodwrench® Synthetic Manual Transmission Fluid (GM Part No. U.S. 12346190, in Canada 10953477) or equivalent SAE 75W-85 GL-4 gear oil.

Synchromesh Transmission Fluid (GM Part No. U.S. 12345349, in Canada 10953465).

Synthetic Transmission Fluid approved to Allison Transmission® specification TES-295
(GM Part No. U.S. 12378515, in Canada 88900701). DEXRON®-III Automatic Transmission Fluid. Look for “Approved for the H-Specification” on the label.

Usage

Key Lock Cylinders

Floor Shift Linkage

Chassis

Lubrication

Front Axle (Four-Wheel

Drive)

Front Axle (All-Wheel

Drive)

Front Axle

Rear Axle

Fluid/Lubricant

Multi-Purpose Lubricant, Superlube (GM Part No. U.S. 12346241, in Canada 10953474). Lubriplate Lubricant Aerosol (GM Part No. U.S. 12346293, in Canada 992723) or lubricant meeting requirements of NLGI #2
Category LB or GC-LB. Chassis Lubricant (GM Part No. U.S. 12377985, in Canada 88901242) or lubricant meeting requirements of NLGI #2, Category LB or GC-LB. SAE 80W-90 Axle Lubricant (GM Part No. U.S. 1052271, in Canada 10950849). SAE 75W-90 Synthetic Axle Lubricant (GM Part No. U.S. 12378261, in Canada 10953455) meeting GM Specification 9986115. SAE 80W-90 Axle Lubricant (GM Part No. U.S. 1052271, in Canada 10950849). SAE 75W-90 Synthetic Axle Lubricant (GM Part No. U.S. 12378261, in Canada 10953455) meeting GM Specification 9986115.

Clutch System

Usage Hydraulic

(6-Speed Trans.)

Power Steering

System

Manual

Transmission (5-Speed with

Low Gear, RPO MW3)

Manual

Transmission

(5-Speed without

Low Gear, RPO MG5)

Manual

Transmission

(6-Speed)

Automatic

Transmission

6-14

Usage

Rear Axle (Steerable)

Manual

Transfer Case

Automatic

Transfer Case (Four-Wheel

Drive)

Transfer Case

(All-Wheel

Drive)

Front Axle Propshaft Spline or One-Piece Propshaft

Spline

(Two-Wheel

Drive with Auto.

Trans.)

Fluid/Lubricant

Usage

Fluid/Lubricant

Synthetic Axle Lubricant; use only GM Part No. U.S. 12378557, in Canada 88901362. Do not add friction modifier. DEXRON®-III Automatic Transmission Fluid. Look for “Approved for the H-Specification” on the label.

AUTO-TRAK II Fluid (GM Part No. U.S. 12378508, in Canada 10953626).

DEXRON®-III Automatic Transmission Fluid. Look for “Approved for the H-Specification” on the label.

Spline Lubricant, Special Lubricant (GM Part No. U.S. 12345879, in Canada 10953511) or lubricant meeting requirements of GM 9985830.

Rear Driveline Center Spline

Hood Hinges

Chassis Lubricant (GM Part No. U.S. 12377985, in Canada 88901242) or lubricant meeting requirements of NLGI #2, Category LB or GC-LB. Multi-Purpose Lubricant, Superlube (GM Part No. U.S. 12346241, in Canada 10953474).

Body Door Hinge Pins,

Tailgate Hinge and Linkage,

Folding

Seats and Fuel

Door Hinge

Tailgate Handle

Pivot Points,

Hinges,

Latch Bolt and

Linkage

Multi-Purpose Lubricant, Superlube (GM Part No. U.S. 12346241, in Canada 10953474).

Multi-Purpose Lubricant, Superlube (GM Part No. U.S. 12346241, in Canada 10953474).

Weatherstrip Conditioning

Weatherstrip

Squeaks

Dielectric Silicone Grease (GM Part No. U.S. 12345579, in Canada 992887). Synthetic Grease with Teflon, Superlube (GM Part No. U.S. 12371287, in Canada 10953437).

6-15

Normal Maintenance Replacement Parts Replacement parts identified below by name, part number, or specification can be obtained from your GM dealer.

Part

GM Part Number

ACDelco® Part Number

Engine Air Cleaner/Filter

High Capacity Standard

Oil Filter 4300 V6
4800 V8; 5300 V8; 6000 V8
8100 V8

Spark Plugs

4300 V6
4800 V8; 5300 V8; 6000 V8
8100 V8

Wiper Blades (ITTA Type) 22 inches (56.0 cm)

*A1518C high-capacity air cleaner filter may be substituted.

25313348
25313349

25010792
88984215
25324052

25162556
12571164
12578277

15153642

A1519C* A1518C

PF47
PF46
PF454

41–932
41–985
41–983

—

6-16

Maintenance Record After the scheduled services are performed, record the date, odometer reading, who performed the service and the type of services performed in the boxes provided. See Maintenance Requirements on page 6-2 in this section. Any additional information from Owner Checks and Services on page 6-10 can be added on the following record pages. Also, you should retain all maintenance receipts.

Date

Odometer Reading

Serviced By

Maintenance I or Maintenance II

Services Performed

Maintenance Record

6-17

Date

Odometer Reading

Serviced By

Maintenance I or Maintenance II

Services Performed

Maintenance Record (cont’d)

6-18

Date

Odometer Reading

Serviced By

Maintenance I or Maintenance II

Services Performed

Maintenance Record (cont’d)

6-19

Date

Odometer Reading

Serviced By

Maintenance I or Maintenance II

Services Performed

Maintenance Record (cont’d)

6-20

Section 7

Customer Assistance and Information

Customer Assistance and Information ...............7-2
Customer Satisfaction Procedure ......................7-2
Online Owner Center ......................................7-4
Customer Assistance for Text

Telephone (TTY) Users ................................7-4
Customer Assistance Offices ............................7-4
GM Mobility Reimbursement Program ................7-6
Roadside Assistance Program ..........................7-6
Courtesy Transportation ...................................7-8
Vehicle Data Collection and Event Data

Recorders ................................................7-10

Reporting Safety Defects ................................7-12

Reporting Safety Defects to the

United States Government ..........................7-12

Reporting Safety Defects to the

Canadian Government ................................7-12

Reporting Safety Defects to

General Motors .........................................7-13
Service Publications Ordering Information .........7-13

7-1

Customer Assistance and Information

Customer Satisfaction Procedure Your satisfaction and goodwill are important to your dealer and to Chevrolet. Normally, any concerns with the sales transaction or the operation of your vehicle will be resolved by your dealer’s sales or service departments. Sometimes, however, despite the best intentions of all concerned, misunderstandings can occur. If your concern has not been resolved to your satisfaction, the following steps should be taken:

STEP ONE: Discuss your concern with a member of dealership management. Normally, concerns can be quickly resolved at that level. If the matter has already been reviewed with the sales, service or parts manager, contact the owner of the dealership or the general manager.

STEP TWO: If after contacting a member of dealership management, it appears your concern cannot be resolved by the dealership without further help, contact the Chevrolet Customer Assistance Center by calling 1-800-222-1020. In Canada, contact GM of Canada Customer Communication Centre by calling 1-800-263-3777 (English) or 1-800-263-7854 (French).

We encourage you to call the toll-free number in order to give your inquiry prompt attention. Please have the following information available to give the Customer Assistance Representative: (cid:127) Vehicle Identification Number (VIN). This is available from the vehicle registration or title, or the plate at the top left of the instrument panel and visible through the windshield.

(cid:127) Dealership name and location. (cid:127) Vehicle delivery date and present mileage

(kilometers).

When contacting Chevrolet, please remember that your concern will likely be resolved at a dealer’s facility. That is why we suggest you follow Step One first if you have a concern.

7-2

STEP THREE: Both General Motors and your dealer are committed to making sure you are completely satisfied with your new vehicle. However, if you continue to remain unsatisfied after following the procedure outlined in Steps One and Two, you should file with the BBB Auto Line Program to enforce any additional rights you may have. Canadian owners refer to your Warranty and Owner Assistance Information booklet for information on the Canadian Motor Vehicle Arbitration Plan (CAMVAP).

The BBB Auto Line Program is an out of court program administered by the Council of Better Business Bureaus to settle automotive disputes regarding vehicle repairs or the interpretation of the New Vehicle Limited Warranty. Although you may be required to resort to this informal dispute resolution program prior to filing a court action, use of the program is free of charge and your case will generally be heard within 40 days. If you do not agree with the decision given in your case, you may reject it and proceed with any other venue for relief available to you.

You may contact the BBB Auto Line Program using the toll-free telephone number or write them at the following address:

BBB Auto Line Program Council of Better Business Bureaus, Inc. 4200 Wilson Boulevard Suite 800
Arlington, VA 22203-1838
Telephone: 1-800-955-5100

This program is available in all 50 states and the District of Columbia. Eligibility is limited by vehicle age, mileage, and other factors. General Motors reserves the right to change eligibility limitations and/or discontinue its participation in this program.

7-3

Online Owner Center The Owner Center is a resource for your GM ownership needs. Specific vehicle information can be found in one place. The Online Owner Center allows you to: (cid:127) Get e-mail service reminders. (cid:127) Access information about your specific vehicle,

including tips and videos and an electronic version of this owner’s manual (United States only).

(cid:127) Keep track of your vehicle’s service history and

maintenance schedule. Find GM dealers for service nationwide.

(cid:127) Receive special promotions and privileges only

available to members (United States only).

Refer to the web for updated information. To register your vehicle, visit www.MyGMLink.com (United States) or My GM Canada within www.gmcanada.com (Canada).

Customer Assistance for Text Telephone (TTY) Users To assist customers who are deaf, hard of hearing, or speech-impaired and who use Text Telephones (TTYs), Chevrolet has TTY equipment available at its Customer Assistance Center. Any TTY user can communicate with Chevrolet by dialing: 1-800-833-CHEV (2438). (TTY users in Canada can dial 1-800-263-3830.)

Customer Assistance Offices Chevrolet encourages customers to call the toll-free number for assistance. If a U.S. customer wishes to write to Chevrolet, the letter should be addressed to Chevrolet’s Customer Assistance Center.

7-4

(cid:127) Overseas — Customer Assistance Please contact the local General Motors Business Unit. Mexico, Central America and Caribbean Islands/Countries (Except Puerto Rico and U.S. Virgin Islands) — Customer Assistance

General Motors de Mexico, S. de R.L. de C.V. Customer Assistance Center Paseo de la Reforma # 2740
Col. Lomas de Bezares C.P. 11910, Mexico, D.F. 01-800-508-0000
Long Distance: 011-52-53 29 0 800

United States — Customer Assistance

Chevrolet Motor Division Chevrolet Customer Assistance Center P.O. Box 33170
Detroit, MI 48232-5170
1-800-222-1020
1-800-833-2438 (For Text Telephone devices (TTYs) Roadside Assistance: 1-800-CHEV-USA (243-8872) Fax Number: 313-381-0022

From Puerto Rico:

1-800-496-9992 (English) 1-800-496-9993 (Spanish) Fax Number: 313-381-0022

From U.S. Virgin Islands:

1-800-496-9994
Fax Number: 313-381-0022

Canada — Customer Assistance

General Motors of Canada Limited Customer Communication Centre, 163-005
1908 Colonel Sam Drive Oshawa, Ontario L1H 8P7
1-800-263-3777 (English) 1-800-263-7854 (French) 1-800-263-3830 (For Text Telephone devices (TTYs) Roadside Assistance: 1-800-268-6800

7-5

GM Mobility Reimbursement Program This program, available to qualified applicants, can reimburse you up to $1,000 toward eligible aftermarket driver’s or passenger’s adaptive equipment you may require for your vehicle, such as hand controls and wheelchair/scooter lifts. The offer is available for a limited period of time from the date of vehicle purchase/lease. For more details, or to determine your vehicle’s eligibility, visit gmmobility.com or call the GM Mobility Assistance Center at 1-800-323-9935. Text telephone (TTY) users, call 1-800-833-9935. GM of Canada also has a Mobility Program. Call 1-800-GM-DRIVE (463-7483) for details. TTY users call 1-800-263-3830.

Roadside Assistance Program As the owner of a new Chevrolet vehicle, you are automatically enrolled in the Chevrolet Roadside Assistance program. This value-added service is intended to provide you with peace of mind as you drive in the city or travel the open road. Call Chevrolet’s Roadside Assistance at 1-800-CHEV-USA, (1-800-243-8872) 24 hours a day, 365 days a year to speak with a Chevrolet Roadside Assistance representative. We will provide the following services during the Bumper-to-Bumper warranty period, at no expense to you:

Fuel Delivery: Delivery of enough fuel ($5 maximum) for the customer to get to the nearest service station. Lock-out Service (identification required): Replacement keys or locksmith service will be covered at no charge if you are unable to gain entry into your vehicle. Delivery of the replacement key will be covered within 10 miles (16 km).

(cid:127) Emergency Tow: Tow to the nearest dealership

for warranty service or in the event of a vehicle-disabling accident. Assistance provided when the vehicle is mired in sand, mud, or snow.

7-6

(cid:127) (cid:127) Flat Tire Change: Installation of a spare tire will be covered at no charge. The customer is responsible for the repair or replacement of the tire if not covered by a warrantable failure. Jump Start: No-start occurrences which require a battery jump start will be covered at no charge.

(cid:127) Dealer Locator Service In many instances, mechanical failures are covered under Chevrolet’s Bumper-to-Bumper warranty. However, when other services are utilized, our Roadside Assistance Representatives will explain any payment obligations you might incur. For prompt and efficient assistance when calling, please provide the following to the Roadside Assistance Representative: (cid:127) Your name, home address, and home

telephone number. Telephone number of your location. Location of the vehicle.

(cid:127) Model, year, color, and license plate number. (cid:127) Mileage, Vehicle Identification Number (VIN),

and delivery date of the vehicle.

(cid:127) Description of the problem. While we hope you never have the occasion to use our service, it is added security while traveling for you and your family. Remember, we are only a phone call away. Chevrolet Roadside Assistance: 1-800-CHEV-USA (1-800-234-8872), text telephone (TTY) users, call 1-888-889-2438. Chevrolet reserves the right to limit services or reimbursement to an owner or driver when, in Chevrolet’s judgement, the claims become excessive in frequency or type of occurrence. Roadside Assistance is not part of or included in the coverage provided by the New Vehicle Limited Warranty. Chevrolet reserves the right to make any changes or discontinue the Roadside Assistance program at any time without notification.

7-7

(cid:127) (cid:127) (cid:127) (cid:127) Canadian Roadside Assistance Vehicles purchased in Canada have an extensive roadside assistance program accessible from anywhere in Canada or the United States. Please refer to the Warranty and Owner Assistance Information book.

Courtesy Transportation Chevrolet has always exemplified quality and value in its offering of motor vehicles. To enhance your ownership experience, we and our participating dealers are proud to offer Courtesy Transportation, a customer support program for new vehicles. The Courtesy Transportation program is offered to retail purchase/lease customers in conjunction with the Bumper-to-Bumper coverage provided by the New Vehicle Limited Warranty. Several transportation options are available when warranty repairs are required. This will reduce your inconvenience during warranty repairs.

Scheduling Service Appointments When your vehicle requires warranty service, you should contact your dealer and request an appointment. By scheduling a service appointment and advising your service consultant of your transportation needs, your dealer can help minimize your inconvenience. If your vehicle cannot be scheduled into the service department immediately, keep driving it until it can be scheduled for service, unless, of course, the problem is safety-related. If it is, please call your dealership, let them know this, and ask for instructions. If the dealer requests that you simply drop the vehicle off for service, you are urged to do so as early in the work day as possible to allow for same day repair. Transportation Options Warranty service can generally be completed while you wait. However, if you are unable to wait, Chevrolet helps minimize your inconvenience by providing several transportation options. Depending on the circumstances, your dealer can offer you one of the following:

7-8

Shuttle Service Participating dealers can provide you with shuttle service to get you to your destination with minimal interruption of your daily schedule. This includes a one way or round trip shuttle service to a destination up to 10 miles (16 km) from the dealership. Public Transportation or Fuel Reimbursement If your vehicle requires overnight warranty repairs, reimbursement of up to a five-day maximum may be available for the use of public transportation such as a taxi or bus. In addition, should you arrange transportation through a friend or relative, reimbursement for reasonable fuel expenses of up to a five-day maximum may be available. Claim amounts should reflect actual costs and be supported by original receipts.

Courtesy Rental Vehicle Your dealer may arrange to provide you with a courtesy rental vehicle or reimburse you for a rental vehicle that you obtain if your vehicle is kept for a warranty repair. Reimbursement will be limited to a maximum of $30.00 a day and must be supported by receipts. This requires that you sign and complete a rental agreement and meet state, local and rental vehicle provider requirements. Requirements vary and may include minimum age requirements, insurance coverage, credit card, etc. You are responsible for fuel usage charges and may also be responsible for taxes, levies, usage fees, excessive mileage or rental usage beyond the completion of the repair. Generally it is not possible to provide a like-vehicle as a courtesy rental.

7-9

Additional Program Information Courtesy Transportation is available during the Bumper-to-Bumper warranty coverage period, but it is not part of the New Vehicle Limited Warranty. A separate booklet entitled “Warranty and Owner Assistance Information” furnished with each new vehicle provides detailed warranty coverage information. Courtesy Transportation is available only at participating GM dealers and all program options, such as shuttle service, may not be available at every dealer. Please contact your GM dealer for specific information about availability. All Courtesy Transportation arrangements will be administered by appropriate dealer personnel. Canadian Vehicles: For warranty repairs during the Complete Vehicle Coverage period of the General Motors of Canada New Vehicle Limited Warranty, alternative transportation may be available under the Courtesy Transportation Program. Please consult your dealer for details. General Motors reserves the right to unilaterally modify, change or discontinue Courtesy Transportation at any time and to resolve all questions of claim eligibility pursuant to the terms and conditions described herein at its sole discretion.

Vehicle Data Collection and Event Data Recorders Your vehicle, like other modern motor vehicles, has a number of sophisticated computer systems that monitor and control several aspects of the vehicle’s performance. Your vehicle uses on-board vehicle computers to monitor emission control components to optimize fuel economy, to monitor conditions for airbag deployment and, if so equipped, to provide anti-lock braking and to help the driver control the vehicle in difficult driving situations. Some information may be stored during regular operations to facilitate repair of detected malfunctions; other information is stored only in a crash event by computer systems, such as those commonly called event data recorders (EDR). In a crash event, computer systems, such as the Airbag Sensing and Diagnostic Module (SDM) in your vehicle may record information about the condition of the vehicle and how it was operated, such as data related to engine speed, brake application, throttle position, vehicle speed, safety belt usage, airbag readiness, airbag performance, and the severity of a collision. If your vehicle is equipped with Quadrasteer, steering performance, including yaw rate, steering wheel angle, and lateral acceleration, is also recorded. This information has been used to improve vehicle crash performance and may be used to improve crash performance of future vehicles and driving safety.

7-10

Unlike the data recorders on many airplanes, these on-board systems do not record sounds, such as conversation of vehicle occupants. To read this information, special equipment is needed and access to the vehicle or the device that stores the data is required. GM will not access information about a crash event or share it with others other than: (cid:127) with the consent of the vehicle owner or, if the

vehicle is leased, with the consent of the lessee, in response to an official request of police or similar government office, as part of GM’s defense of litigation through the discovery process, or as required by law.

In addition, once GM collects or receives data, GM may:

use the data for GM research needs,

(cid:127) make it available for research where appropriate

confidentiality is to be maintained and need is shown, or share summary data which is not tied to a specific vehicle with non-GM organizations for research purposes.

Others, such as law enforcement, may have access to the special equipment that can read the information if they have access to the vehicle or the device that stores the data. If your vehicle is equipped with OnStar®, please check the OnStar® subscription service agreement or manual for information on its operations and data collection.

7-11

(cid:127) (cid:127) (cid:127) (cid:127) (cid:127) Reporting Safety Defects to the Canadian Government If you live in Canada, and you believe that your vehicle has a safety defect, you should immediately notify Transport Canada, in addition to notifying General Motors of Canada Limited. You may write to:

Transport Canada 330 Sparks Street Tower C Ottawa, Ontario K1A 0N5

Reporting Safety Defects

Reporting Safety Defects to the United States Government If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA), in addition to notifying General Motors. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or General Motors. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (or 366-0123 in the Washington, D.C. area) or write to:

NHTSA, U.S. Department of Transportation Washington, D.C. 20590

You can also obtain other information about motor vehicle safety from the hotline.

7-12

Reporting Safety Defects to General Motors In addition to notifying NHTSA (or Transport Canada) in a situation like this, we certainly hope you will notify General Motors. Please call the Chevrolet Customer Assistance Center at 1-800-222-1020, or write:

Chevrolet Motor Division Chevrolet Customer Assistance Center P.O. Box 33170
Detroit, MI 48232-5170

In Canada, please call us at 1-800-263-3777 (English) or 1-800-263-7854 (French). Or, write: General Motors of Canada Limited Customer Communication Centre, 163-005
1908 Colonel Sam Drive Oshawa, Ontario L1H 8P7

Service Publications Ordering Information Service Manuals Service Manuals have the diagnosis and repair information on engines, transmission, axle suspension, brakes, electrical, steering, body, etc. Transmission, Transaxle, Transfer Case Unit Repair Manual This manual provides information on unit repair service procedures, adjustments, and specifications for GM transmissions, transaxles, and transfer cases. Service Bulletins Service Bulletins give technical service information needed to knowledgeably service General Motors cars and trucks. Each bulletin contains instructions to assist in the diagnosis and service of your vehicle. In Canada, information pertaining to Product Service Bulletins can be obtained by contacting your General Motors dealer or by calling 1-800-GM-DRIVE (1-800-463-7483).

7-13

Owner’s Information Owner publications are written specifically for owners and intended to provide basic operational information about the vehicle. The owner’s manual will include the Maintenance Schedule for all models. In-Portfolio: Includes a Portfolio, Owner’s Manual, and Warranty Booklet. RETAIL SELL PRICE: $35.00
Without Portfolio: Owner’s Manual only. RETAIL SELL PRICE: $25.00
Current and Past Model Order Forms Service Publications are available for current and past model GM vehicles. To request an order form, please specify year and model name of the vehicle.

ORDER TOLL FREE: 1-800-551-4123
Monday-Friday 8:00 AM - 6:00 PM Eastern Time For Credit Card Orders Only (VISA-MasterCard-Discover), visit Helm, Inc. on the World Wide Web at: www.helminc.com Or you can write to:

Helm, Incorporated P.O. Box 07130
Detroit, MI 48207

Prices are subject to change without notice and without incurring obligation. Allow ample time for delivery. Note to Canadian Customers: All listed prices are quoted in U.S. funds. Canadian residents are to make checks payable in U.S. funds.

7-14

A

Accessory Power Outlets ................................. 3-19
Adding Equipment to Your Airbag-Equipped

Vehicle ....................................................... 1-78
Additives, Fuel ................................................. 5-7
Add-On Electrical Equipment ........................... 5-127
Air Cleaner/Filter, Engine ................................. 5-25
Air Conditioning .............................. 3-21, 3-22, 3-25
Airbag

Off Light ..................................................... 3-34
Passenger Status Indicator ........................... 3-36
Readiness Light .......................................... 3-34
Airbag Sensing and Diagnostic Module (SDM) .... 7-10
Airbag System ................................................ 1-62

Adding Equipment to Your Airbag-Equipped

Vehicle ................................................... 1-78
Airbag Off Switch ........................................ 1-69
How Does an Airbag Restrain? ...................... 1-67
Passenger Sensing System ........................... 1-72
Servicing Your Airbag-Equipped Vehicle .......... 1-77
What Makes an Airbag Inflate? ...................... 1-67
What Will You See After an Airbag Inflates? .... 1-68
When Should an Airbag Inflate? .................... 1-65
Where Are the Airbags? ............................... 1-64
All-Wheel Drive ............................................... 5-58
All-Wheel Drive (AWD) System ......................... 2-48

AM-FM Radio ................................................. 3-70
Antenna, Fixed Mast ...................................... 3-126
Antenna, XMâ„¢ Satellite Radio Antenna

System ..................................................... 3-126
Anti-Lock Brake System (ABS) ........................... 4-7
Anti-Lock Brake, System Warning Light .............. 3-41
Appearance Care .......................................... 5-118
Aluminum or Chrome-Plated Wheels ............. 5-123
Care of Safety Belts ................................... 5-121
Chemical Paint Spotting .............................. 5-125
Cleaning Exterior Lamps/Lenses .................. 5-122
Fabric/Carpet ............................................ 5-118
Finish Care ............................................... 5-122
Finish Damage .......................................... 5-124
Glass Surfaces .......................................... 5-121
Instrument Panel ........................................ 5-120
Interior Plastic Components ......................... 5-120
Leather .................................................... 5-120
Sheet Metal Damage .................................. 5-124
Tires ........................................................ 5-124
Underbody Maintenance ............................. 5-125
Vehicle Care/Appearance Materials ............... 5-125
Vinyl ........................................................ 5-120
Washing Your Vehicle ................................. 5-121
Weatherstrips ............................................ 5-121
Windshield and Wiper Blades ...................... 5-123
Ashtrays ........................................................ 3-20

Audio System(s) ............................................. 3-69
AM-FM Radio ............................................. 3-70
Audio Steering Wheel Controls .................... 3-123
Care of Your Cassette Tape Player ............... 3-125
Care of Your CD and DVD Player ................ 3-126
Care of Your CDs and DVDs ....................... 3-126
Chime Level Adjustment ............................. 3-126
Fixed Mast Antenna ................................... 3-126
Radio with Cassette and CD ......................... 3-83
Radio with CD ............................................ 3-73
Radio with Six-Disc CD ................................ 3-97
Rear Seat Audio (RSA) ............................... 3-121
Setting the Time for Radios with Radio

Data Systems (RDS) ................................ 3-70

Setting the Time for Radios without Radio

Data Systems (RDS) ................................ 3-69
Theft-Deterrent Feature ............................... 3-123
Understanding Radio Reception ................... 3-124
XMâ„¢ Satellite Radio Antenna System ........... 3-126
Automatic Headlamp System ............................ 3-15
Automatic Transmission

Fluid .................................................. 5-27, 5-30
Operation ................................................... 2-26
Auxiliary Roof Mounted Lamp Switch ................. 3-17

Battery .......................................................... 5-53
Battery Warning Light ...................................... 3-38
Before Leaving on a Long Trip ......................... 4-40
Brake

Anti-Lock Brake System (ABS) ........................ 4-7
Emergencies ................................................ 4-8
Parking ...................................................... 2-49
System Warning Light .................................. 3-40
Brakes .......................................................... 5-49
Braking ........................................................... 4-6
Braking in Emergencies ..................................... 4-8
Break-In, New Vehicle ..................................... 2-21
Bulb Replacement ........................................... 5-65

Center High-Mounted Stoplamp (CHMSL)

and Cargo Lamp ...................................... 5-70

Front Turn Signal, Sidemarker and Daytime

Running Lamps ........................................ 5-67
Halogen Bulbs ............................................ 5-65
Headlamps ................................................. 5-65
Pickup Box Identification and Fender

Marker Lamps ......................................... 5-71
Replacement Bulbs ...................................... 5-74
Roof Marker Lamps ..................................... 5-68
Taillamps .................................................... 5-72
Buying New Tires ........................................... 5-90

C

California Fuel .................................................. 5-6
Canadian Owners ................................................ ii Capacities and Specifications .......................... 5-136
Carbon Monoxide ................... 2-14, 2-54, 4-44, 4-69
Care of

Safety Belts .............................................. 5-121
Your Cassette Tape Player .......................... 3-125
Your CD and DVD Player ........................... 3-126
Your CDs and DVDs .................................. 3-126
Cargo Lamp ................................................... 3-19
Center Console Storage Area ........................... 2-72
Center High-Mounted Stoplamp (CHMSL)

and Cargo Lamp ......................................... 5-70
Center Passenger Position, Safety Belts ............. 1-23
Chains, Tire ................................................... 5-94
Check

Engine Light ............................................... 3-44
Checking Things Under the Hood ...................... 5-12
Chemical Paint Spotting ................................. 5-125
Child Restraints

Child Restraint Systems ............................... 1-36
Infants and Young Children ........................... 1-33
Lower Anchorages and Top Tethers for

Children (LATCH System) .......................... 1-44
Older Children ............................................. 1-30
Securing a Child Restraint Designed for

the LATCH System ................................... 1-46

Child Restraints (cont.)

Securing a Child Restraint in a Center

Rear Seat Position ................................... 1-49

Securing a Child Restraint in a Rear

Outside Seat Position ............................... 1-47

Securing a Child Restraint in the Center

Front Seat Position ................................... 1-50

Securing a Child Restraint in the Right

Front Seat Position (Crew Cab) .................. 1-51

Securing a Child Restraint in the

Right Front Seat Position (Regular and Extended Cab) ............. 1-54, 1-59
Top Strap ................................................... 1-40
Top Strap Anchor Location ............................ 1-42
Where to Put the Restraint ........................... 1-38
Chime Level Adjustment ................................. 3-126
Cigarette Lighter ............................................. 3-20
Cleaning

Aluminum or Chrome-Plated Wheels ............. 5-123
Exterior Lamps/Lenses ................................ 5-122
Fabric/Carpet ............................................ 5-118
Finish Care ............................................... 5-122
Glass Surfaces .......................................... 5-121
Instrument Panel ........................................ 5-120
Interior Plastic Components ......................... 5-120
Leather .................................................... 5-120
Tires ........................................................ 5-124
Underbody Maintenance ............................. 5-125
Vinyl ........................................................ 5-120

Cleaning (cont.)

Washing Your Vehicle ................................. 5-121
Weatherstrips ............................................ 5-121
Windshield and Wiper Blades ...................... 5-123
Climate Control System ................................... 3-21
Dual .......................................................... 3-22
Dual Automatic ............................................ 3-25
Outlet Adjustment ........................................ 3-30
Clutch, Hydraulic ............................................. 5-34
Coinholder(s) .................................................. 2-72
Comfort Guides, Rear Safety Belt ..................... 1-28
Content Theft-Deterrent .................................... 2-19
Control of a Vehicle .......................................... 4-5
Coolant

Engine Temperature Gage ............................ 3-42
Heater, Engine ............................................ 2-25
Surge Tank Pressure Cap ............................. 5-38