2005 Nissan Maxima Owners Manual

touch moving parts in the engine com- partment and that the cable clamps do not contact any other metal.

5. Start the engine of the booster vehicle and

let it run for a few minutes.

6. Keep the engine speed of the booster ve- hicle at about 2,000 rpm, and start the en- gine of the vehicle being jump started.

CAUTION

Do not keep the starter motor engaged for more than 10 seconds. If the engine does not start right away, turn the key off and wait 3 to 4 seconds before trying again.

7. After starting the engine, carefully discon- nect the negative cable and then the positive cable.

6-8 In case of emergency

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

IF YOUR VEHICLE OVERHEATS

If your vehicle is overheating (indicated by an extremely high temperature gauge reading), or if you feel a lack of engine power, detect abnormal noise, etc. take the following steps.

WARNING

c Do not continue to drive if your vehicle overheats. Doing so could cause engine damage or a vehicle fire.

c To avoid the danger of being scalded, never remove the radiator cap while the engine is still hot. When the radiator cap is removed, pressurized hot water will spurt out, possibly causing serious injury.

c Do not open the hood if steam is com-

ing out.

1. Move the vehicle safely off the road, apply the parking brake and move the shift lever to N (Neutral) (manual transmission) or to P (Park) (automatic transmission). Do not stop the engine.

2. Turn off the air conditioner (if so equipped). Open all the windows, move the heater or air conditioner temperature control to maximum hot and fan control to high speed.

3. Get out of the vehicle. Look and listen for steam or coolant escaping from the radiator before opening the hood. (If steam or cool- ant is escaping, turn off the engine.) Do not open the hood further until no steam or coolant can be seen.

6. After the engine cools down, check the cool- ant level in the engine coolant reservoir tank with the engine running. Add coolant to the engine coolant reservoir tank if necessary. Have your vehicle repaired at a NISSAN dealer.

4. Open the engine hood.

WARNING

If steam or water is coming from the en- gine, stand clear to prevent getting burned.

5. Visually check drive belts for damage or looseness. Also check if the cooling fan is running. The radiator hoses and radiator should not leak water. If coolant is leaking, the water pump belt is missing or loose, or the cooling fan does not run, stop the en- gine.

WARNING

Be careful not to allow your hands, hair, jewelry or clothing to come into contact with, or get caught in, engine belts or the engine cooling fan. The engine cooling fan can start at any time when the coolant temperature is high.

In case of emergency 6-9

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

TOWING YOUR VEHICLE

When towing your vehicle, all State (Provincial in Canada) and local regulations for towing must be followed. Incorrect towing equipment could dam- age your vehicle. Towing instructions are avail- able from a NISSAN dealer. Local service opera- tors are generally familiar with the applicable laws and procedures for towing. To assure proper towing and to prevent accidental damage to your vehicle, NISSAN recommends having a service operator tow your vehicle. It is advisable to have the service operator carefully read the following precautions:

WARNING

c Never ride in a vehicle that is being

towed.

c Never get under your vehicle after it has

been lifted by a tow truck.

CAUTION

c When towing, make sure that the trans- mission, axles, steering system and powertrain are in working condition. If any unit is damaged, dollies must be used.

c Always attach safety chains before

towing.

6-10 In case of emergency

For information about towing your vehicle behind a recreational vehicle (RV), refer to (cid:147)Flat towing(cid:148) in the (cid:147)Technical and consumer information(cid:148) sec- tion of this manual.

ACE0511

TOWING RECOMMENDED BY NISSAN NISSAN recommends that your vehicle be towed with the driving (front) wheels off the ground or place the vehicle on a flat bed truck as illustrated.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

c When towing automatic transmission models with the front wheels on towing dollies, or when towing manual trans- mission models with the front wheels on the ground: (cid:150) Turn the ignition key to the OFF po- sition, and secure the steering wheel in a straight-ahead position with a rope or similar device. Never secure the steering wheel by turning the ig- nition key to the LOCK position. This may damage the steering lock mechanism.

(cid:150) Move the gearshift lever to the N

(Neutral) position.

c When towing automatic or manual transmission models with the rear wheels on the ground (if you do not use towing dollies): Always release the parking brake.

ACE1001

CAUTION

c Never

tow automatic transmission models with the front wheels on the ground or four wheels on the ground (forward or backward), as this may cause serious and expensive damage to the transmission. If it is necessary to tow the vehicle with the rear wheels raised always use towing dollies under the front wheels.

LCE0102
VEHICLE RECOVERY (freeing a stuck vehicle) Front

WARNING

c Stand clear of a stuck vehicle. c Do not spin your tires at high speed. This could cause them to explode and result in serious injury. Parts of your vehicle could also overheat and be damaged.

In case of emergency 6-11

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/21/05—cathy X

CAUTION

c Tow chains or cables must be attached only to the main structural members of the vehicle or the towing hooks (if so equipped). Otherwise, the vehicle body will be damaged.

c Do not use the vehicle tie downs to free a vehicle stuck in sand, snow, mud, etc. Never tow the vehicle using the vehicle tie downs or recovery hooks.

c Always pull the cable straight out from the front or rear of the vehicle. Never pull the vehicle at an angle.

c Pulling devices should be routed so they do not touch any part of the sus- pension, steering, brake or cooling systems.

c Pulling devices such as ropes or canvas straps are not recommended for use in vehicle towing or recovery.

If your vehicle is stuck in sand, snow, mud, etc., use the following procedure:

1. Turn off the Vehicle Dynamic Control System

(if so equipped).

2. Make sure the area in front and behind the

vehicle is clear of obstructions.

6-12 In case of emergency

3. Turn the steering wheel right and left to clear

an area around the front tires.

4. Slowly rock the vehicle forward and back-

ward. c Shift back and forth between R (Reverse)

and D (Drive).

c Apply the accelerator as little as possible

to maintain the rocking motion.

c Release the accelerator pedal before

shifting between R and D.

c Do not spin the tires above 35 mph (55

km/h).

5.

If the vehicle can not be freed after a few tries, contact a professional towing service to remove the vehicle.

Rear

WARNING

c Stand clear of a stuck vehicle. c Do not spin your tires at high speed. This could cause them to explode and result in serious injury. Parts of your vehicle could also overheat and be damaged.

CAUTION

c Tow chains or cables must be attached only to the main structural members of the vehicle.

c Pulling devices should be routed so they do not touch any part of the sus- pension, steering, brake or cooling systems.

c Always pull the cable straight out from the front or rear of the vehicle. Never pull the vehicle at an angle.

c Pulling devices such as ropes or canvas straps are not recommended for use in vehicle towing or recovery.

If your vehicle is stuck in sand, snow, mud, etc., use the following procedure: 1. Turn off the Vehicle Dynamic Control System

(if so equipped).

2. Make sure the area in front and behind the

vehicle is clear of obstructions.

3. Turn the steering wheel right and left to clear

an area around the front tires.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

4. Slowly rock the vehicle forward and back-

ward. c Shift back and forth between R (Reverse)

and D (Drive).

c Apply the accelerator as little as possible

to maintain the rocking motion.

c Release the accelerator pedal before

shifting between R and D.

c Do not spin the tires above 35 mph (55

km/h).

5.

If the vehicle can not be freed after a few tries, contact a professional towing service to remove the vehicle.

In case of emergency 6-13

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

MEMO

6-14 In case of emergency

7 Appearance and care

Cleaning exterior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
Washing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
Waxing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
Removing spots . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-2
Underbody . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3
Glass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3
Aluminum alloy wheels . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3
Chrome parts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-3
Cleaning interior. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4

Floor mats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-4
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
Corrosion protection . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5

Most common factors contributing to vehicle corrosion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
Environmental factors influence the rate of corrosion . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 7-5
To protect your vehicle from corrosion . . . . . . . . . . . . 7-5

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

CLEANING EXTERIOR

In order to maintain the appearance of your ve- hicle, it is important to take proper care of it.

To protect the paint surfaces, please wash your vehicle as soon as you can: c after a rainfall to prevent possible damage

from acid rain.

c after driving on coastal roads. c when contaminants such as soot, bird drop- pings, tree sap, metal particles or bugs get on the paint surface.

c when dust or mud builds up on the surface. Whenever possible, store or park your vehicle inside a garage or in a covered area.

When it is necessary to park outside, park in a shady area or protect the vehicle with a body cover. Be careful not to scratch the paint surface when putting on or removing the body cover. WASHING Wash dirt off with a wet sponge and plenty of water. Clean the vehicle thoroughly using a mild soap, a special vehicle soap or general purpose dishwashing liquid mixed with clean, lukewarm (never hot) water. 7-2 Appearance and care

CAUTION

c Do not wash the vehicle with strong household soap, strong chemical deter- gents, gasoline or solvents.

c Avoid using tight-napped or

c Do not wash the vehicle in direct sun- light or while the vehicle body is hot, as the surface may become water-spotted. rough cloths, such as washing mitts. Care must removing caked-on dirt or other foreign sub- stances so the paint surface is not scratched or damaged.

taken when

be

Rinse the vehicle thoroughly with plenty of clean water. Inside flanges, seams and folds on the doors, hatches and hood are particularly vulnerable to the effects of road salt. Therefore, these areas must be cleaned regularly. Take care that the drain holes in the lower edge of the door are open. Spray water under the body and in the wheel wells to loosen the dirt and wash away road salt. A damp chamois can be used to dry the vehicle to avoid water spots.

WAXING Regular waxing protects the paint surface and helps retain new vehicle appearance. Polishing is recommended to remove built-up wax residue and to avoid a weathered appearance before re-applying wax.

A NISSAN dealer can assist you in choosing the proper product. c Wax your vehicle only after a thorough wash- ing. Follow the instructions supplied with the wax.

c Do not use a wax containing any abrasives, cutting compounds or cleaners that may damage the vehicle finish.

c If the surface does not polish easily, use a

(cid:147)road tar(cid:148) remover and wax again.

Machine compounding or aggressive polishing on a base coat/clear coat paint finish may dull the finish or leave swirl marks. REMOVING SPOTS Remove tar and oil spots, industrial dust, insects, and tree sap as quickly as possible from the surface of the paint to avoid lasting damage or staining. Special cleaning products are available at a NISSAN dealer or any automotive accessory store.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

UNDERBODY In areas where road salt is used in winter, it is necessary to clean the underbody regularly in order to prevent dirt and salt from building up and causing the acceleration of corrosion on the un- derbody and suspension. Before the winter pe- riod and again in the spring, the underseal must be checked and, if necessary, retreated.

Use glass cleaner to remove smoke and dust film from the glass surfaces. It is normal for glass to become coated with a film after the vehicle is parked in the hot sun. Glass cleaner and a soft cloth will easily remove this film.

CAUTION

When cleaning the inside of the windows, do not use sharp-edged tools, abrasive cleaners or chlorine-based disinfectant cleaners. They could damage the electri- cal conductors, radio antenna elements or rear window defroster elements. ALUMINUM ALLOY WHEELS Wash the wheels regularly, especially during win- ter months in areas where road salt is used. If not removed, road salt can discolor the wheels. CHROME PARTS Clean all chrome parts regularly with a non- abrasive chrome polish to maintain the finish.

Appearance and care 7-3

LAI0008

GLASS When cleaning the rear window, it may be easier to clean if the high-mounted stop light is removed first.

Be careful when removing the high-mounted stop light to reduce the risk of damaging the high-mounted stop light wires.

To remove the high-mounted stop light: s1 Push toward rear of vehicle. s2

Lift to remove.

The high-mounted stop light must be properly reinstalled before driving your vehicle.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

CLEANING INTERIOR

Occasionally remove loose dust from the interior trim, plastic parts and seats using a vacuum cleaner or soft brush. Wipe the vinyl and leather surfaces with a clean, soft cloth dampened in mild soap solution, then wipe clean with a dry, soft cloth. Before using any fabric protector, read the manufacturer(cid:146)s recommendations. Some fab- ric protectors contain chemicals that may stain or bleach the seat material. Use a cloth dampened only with water to clean the meter and gauge lens.

CAUTION

c Never use benzine, thinner or any simi-

lar material.

c Small dirt particles can be abrasive and damaging to leather surfaces and should be removed promptly. Do not use saddle soap, polishes, oils, clean- ing fluids, solvents, detergents or ammonia-based cleaners as they may damage the leather(cid:146)s natural finish.

c Never use fabric protectors unless rec-

ommended by the manufacturer.

c Do not use glass or plastic cleaner on meter or gauge lens covers. It may dam- age the lens cover.

7-4 Appearance and care

FLOOR MATS The use of genuine NISSAN floor mats can ex- tend the life of your vehicle carpet and make it easier to clean the interior. No matter what mats are used, be sure they are fitted for your vehicle and are properly positioned in the footwell to prevent interference with pedal operation. Mats should be maintained with regular cleaning and replaced if they be- come excessively worn.

WAI0006
Floor mat positioning aid (driver(cid:146)s side only) This vehicle includes a front floor mat bracket to act as a floor mat positioning aid. NISSAN floor mats have been specially designed for your ve- hicle model. The driver(cid:146)s side floor mat has a grommet hole incorporated in it. Position the mat by placing the floor mat bracket hook through the floor mat grommet hole while centering the mat in the footwell. Periodically check to make certain the mats are properly positioned.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

SEAT BELTS The seat belts can be cleaned by wiping them with a sponge dampened in a mild soap solution. Allow the belts to dry completely in the shade before using them. See (cid:147)Seat belt maintenance(cid:148) in the (cid:147)Safety (cid:150) Seats, seat belts and supplemen- tal restraint system(cid:148) section of this manual.

WARNING

Do not allow wet seat belts to roll up in the retractor. NEVER use bleach, dye or chemical solvents to clean the seat belts, since these materials may severely weaken the seat belt webbing.

CORROSION PROTECTION

MOST COMMON FACTORS CONTRIBUTING TO VEHICLE CORROSION c The accumulation of moisture-retaining dirt and debris in body panel sections, cavities, and other areas.

c Damage to paint and other protective coat- ings caused by gravel and stone chips or minor traffic accidents.

ENVIRONMENTAL FACTORS INFLUENCE THE RATE OF CORROSION Moisture Accumulation of sand, dirt and water on the ve- hicle body underside can accelerate corrosion. Wet floor coverings will not dry completely inside the vehicle, and should be removed for drying to avoid floor panel corrosion. Relative humidity Corrosion will be accelerated in areas of high relative humidity, especially those areas where the temperatures stay above freezing and where atmospheric pollution exists and road salt is used.

Temperature High temperatures accelerate the rate of corro- sion to those parts which are not well ventilated. Air pollution Industrial pollution, the presence of salt in the air in coastal areas, or heavy road salt use acceler- ates the corrosion process. Road salt also accel- erates the disintegration of paint surfaces. TO PROTECT YOUR VEHICLE FROM CORROSION c Wash and wax your vehicle often to keep the

vehicle clean.

c Always check for minor damage to the paint

and repair it as soon as possible.

c Keep drain holes at the bottom of the doors

open to avoid water accumulation.

c Check the underbody for accumulation of sand, dirt or salt. If present, wash with water as soon as possible.

CAUTION

c NEVER remove dirt, sand or other de- bris from the passenger compartment by washing it out with a hose. Remove dirt with a vacuum cleaner or broom.

Appearance and care 7-5

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

c Never allow water or other liquids to come in contact with electronic compo- nents inside the vehicle as this may damage them.

Chemicals used for road surface de-icing are extremely corrosive. They accelerate corrosion and deterioration of underbody components such as the exhaust system, fuel and brake lines, brake cables, floor pan and fenders. In winter, the underbody must be cleaned periodically. For additional protection against rust and corro- sion, which may be required in some areas, con- sult a NISSAN dealer.

7-6 Appearance and care

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

8 Maintenance and do-it-yourself

Maintenance requirements. . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
General maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-2
Explanation of general maintenance items . . . . . . . . . 8-2
Maintenance precautions . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-5
Engine compartment check locations . . . . . . . . . . . . . . . . 8-6
Engine cooling system . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-7
Checking engine coolant level . . . . . . . . . . . . . . . . . . . 8-7
Changing engine coolant . . . . . . . . . . . . . . . . . . . . . . . . 8-8
Engine oil. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-8
Checking engine oil level . . . . . . . . . . . . . . . . . . . . . . . . 8-8
Changing engine oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-9
Changing engine oil filter . . . . . . . . . . . . . . . . . . . . . . . 8-10
5-speed automatic transmission fluid . . . . . . . . . . . . . . . 8-11
Power steering fluid. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-11
Brake and clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-12
Brake fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-12
Clutch fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-12
Window washer fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-13
Window washer fluid reservoir . . . . . . . . . . . . . . . . . . 8-13
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-13
Jump starting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-15
Drive belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-15
Spark plugs. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-16

Replacing spark plugs . . . . . . . . . . . . . . . . . . . . . . . . . 8-16
Air cleaner . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-16
In-cabin microfilter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-17
Windshield wiper blades . . . . . . . . . . . . . . . . . . . . . . . . . . 8-20
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-20
Replacing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-20
Parking brake and brake pedal . . . . . . . . . . . . . . . . . . . . . 8-21
Checking parking brake . . . . . . . . . . . . . . . . . . . . . . . . 8-21
Checking brake pedal. . . . . . . . . . . . . . . . . . . . . . . . . . 8-21
Brake booster. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-22
Fuses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-22
Engine compartment . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-23
Passenger compartment . . . . . . . . . . . . . . . . . . . . . . . 8-24
Keyfob battery replacement . . . . . . . . . . . . . . . . . . . . . . . . 8-26
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .8-27
Headlights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-27
Exterior and interior lights. . . . . . . . . . . . . . . . . . . . . . . 8-28
Wheels and tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-33
Tire pressure. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-33
Tire labeling. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-36
Types of tires. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-39
Tire chains. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8-39
Changing wheels and tires . . . . . . . . . . . . . . . . . . . . . 8-40

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

MAINTENANCE REQUIREMENTS

GENERAL MAINTENANCE

Your new NISSAN has been designed to have minimum maintenance requirements with longer service intervals to save you both time and money. However, some day-to-day and regular maintenance is essential to maintain your NIS- SAN(cid:146)s good mechanical condition, as well as its emission and engine performance.

It is the owner(cid:146)s responsibility to make sure that the scheduled maintenance, as well as general maintenance, is performed.

As the vehicle owner, you are the only one who can ensure that your vehicle receives proper maintenance. You are a vital link in the mainte- nance chain. Scheduled maintenance

For your convenience, both required and optional scheduled maintenance items are described and listed in your (cid:147)NISSAN Service and Maintenance Guide.(cid:148) You must refer to that guide to ensure that necessary maintenance is performed on your NISSAN at regular intervals. General maintenance

General maintenance includes those items which should be checked during normal day-to-day op- eration. They are essential for proper vehicle op- eration. It is your responsibility to perform these maintenance procedures regularly as prescribed. 8-2 Maintenance and do-it-yourself

Performing general maintenance checks requires minimal mechanical skill and only a few general automotive tools. These checks or inspections can be done by you, a qualified technician, or, if you prefer, a NISSAN dealer. Where to go for service If maintenance service is required or your vehicle appears to malfunction, have the systems checked and corrected by a NISSAN dealer. NISSAN technicians are well-trained specialists who are kept up-to-date with the latest service information through technical bulletins, service tips, and in-dealership training programs. They are completely qualified to work on NISSAN ve- hicles before they work on your vehicle, rather than after they have worked on it. You can be confident that a NISSAN dealer(cid:146)s service department performs the best job to meet the maintenance requirements on your vehicle (cid:151) in a reliable and economic way.

During the normal day-to-day operation of the vehicle, general maintenance should be per- formed regularly as prescribed in this section. If you detect any unusual sounds, vibrations or smells, be sure to check for the cause or have a NISSAN dealer do it promptly. In addition, you should notify a NISSAN dealer if you think that repairs are required.

When performing any checks or maintenance work, closely observe the (cid:147)Maintenance precau- tions(cid:148) later in this section. EXPLANATION OF GENERAL MAINTENANCE ITEMS information on the following Additional items with (cid:147)*(cid:148) is found later in this section. Outside the vehicle The maintenance items listed here should be performed from time to time, unless otherwise specified. Doors and engine hood Check that the doors and engine hood operate properly. Also ensure that all latches lock securely. Lubricate hinges, latches, latch pins, rollers and links as necessary. Make sure that the secondary latch keeps the hood from opening when the primary latch is released.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

When driving in areas using road salt or other corrosive materials, check lubrication frequently. Lights* Clean the headlights on a regular basis. Make sure that the headlights, stop lights, tail lights, turn signal lights, and other lights are all operating properly and installed securely. Also check headlight aim. Road wheel nuts* When checking the tires, make sure no wheel nuts are missing, and check for any loose wheel nuts. Tighten if necessary. Tire rotation* Tires should be rotated every 7,500 miles (12,000 km). Tires* Check the pressure with a gauge often and always prior to long distance trips. If neces- sary, adjust the pressure in all tires, including the spare, to the pressure specified. Check carefully for damage, cuts or excessive wear. Wheel alignment and balance If the vehicle should pull to either side while driving on a straight and level road, or if you detect uneven or abnormal tire wear, there may be a need for wheel alignment. If the steering wheel or seat vibrates at normal highway speeds, wheel balancing may be needed. c For additional

information regarding tires, refer to (cid:147)Important Tire Safety Information(cid:148) (US) or (cid:147)Tire Safety Information(cid:148) (Canada) in the Warranty Information Booklet .

Windshield Clean the windshield on a regular basis. Check the windshield at least every six months for cracks or other damage. Have a dam- aged windshield repaired by a qualified repair facility. Windshield wiper blades* Check for cracks or wear if they do not wipe properly. Inside the vehicle The maintenance items listed here should be checked on a regular basis, such as when per- forming periodic maintenance, cleaning the ve- hicle, etc. Additional information on the following items with an (cid:147)*(cid:148) is found later in this sec- tion.

Accelerator pedal Check the pedal for smooth operation and make sure the pedal does not bind or require uneven effort. Keep the floor mat away from the pedal. Automatic transmission P (Park) position mechanism On a fairly steep hill check that your vehicle is held securely with the selector lever in the P (Park) position without applying any brakes. Brake pedal and booster* Check the pedal for smooth operation and make sure it has the proper distance under it when depressed fully. Check

the brake booster function. Be certain to keep the floor mat away from the pedal. Brakes Check that the brakes do not pull the vehicle to one side when applied. Clutch pedal* Make sure the pedal operates smoothly and check that it has the proper free travel. Parking brake* Check that the lever has the proper travel and confirm that your vehicle is held securely on a fairly steep hill with only the parking brake applied. Seats Check seat position controls such as seat adjusters, seatback recliner, etc. to ensure they operate smoothly and all latches lock securely in every position. Check that the head restraints move up and down smoothly and the locks (if so equipped) hold securely in all latched positions. Seat belts Check that all parts of the seat belt system (for example, buckles, anchors, adjusters and retractors) operate properly and smoothly, and are installed securely. Check the belt web- bing for cuts, fraying, wear or damage. Steering wheel Check for changes in the steer- ing system, such as excessive freeplay, hard steering or strange noises. Warning lights and chimes Make sure all warning lights and chimes are operating properly. Maintenance and do-it-yourself 8-3

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

Underbody The underbody is frequently ex- posed to corrosive substances such as those used on icy roads or to control dust. It is very important to remove these substances from the underbody, otherwise rust may form on the floor pan, frame, fuel lines and exhaust system. At the end of winter, the underbody should be thor- oughly flushed with plain water, in those areas where mud and dirt may have accumulated. See the (cid:147)Appearance and care(cid:148) section of this manual. Windshield washer fluid* Check that there is adequate fluid in the reservoir.

Windshield wiper and washer* Check that the wipers and washer operate properly and that the wipers do not streak. Windshield defroster Check that the air comes out of the defroster outlets properly and in sufficient quantity when operating the heater or air conditioner. Under the hood and vehicle The maintenance items listed here should be checked periodically (for example, each time you check the engine oil or refuel). Automatic transmission fluid level* Check the level after putting the selector lever in P with the engine idling at operating temperature. Battery* Check the fluid level It should be between the MAX and MIN lines. Ve- hicles operated in high temperatures or under severe conditions require frequent checks of the battery fluid level. Brake and clutch fluid levels* Make sure that the brake and clutch fluid level is between the MIN and MAX lines on the reservoir. Engine coolant level* Check the coolant level when the engine is cold. Engine drive belts* Make sure the drive belts are not frayed, worn, cracked or oily. 8-4 Maintenance and do-it-yourself

in each cell.

Engine oil level* Check the level after parking the vehicle on a level surface with the engine off. Wait more than 10 minutes for the oil to drain back into the oil pan. Exhaust system Make sure there are no loose supports, cracks or holes. If the sound of the exhaust seems unusual or there is a smell of exhaust fumes, immediately have the exhaust system inspected by a NISSAN dealer. See the carbon monoxide warning in the (cid:147)Starting and driving(cid:148) section of this manual. Fluid leaks Check under the vehicle for fuel, oil, water or other fluid leaks after the vehicle has been parked for a while. Water dripping from the air conditioner after use is normal. If you should notice any leaks or if gasoline fumes are evident, check for the cause and have it corrected imme- diately. Power steering fluid level* and lines Check the level when the fluid is cold, with the engine off. Check the lines for proper attachment, leaks, cracks, etc. Radiator and hoses Check the front of the radiator and clean off any dirt, insects, leaves, etc., that may have accumulated. Make sure the hoses have no cracks, deformation, rot or loose connections.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

MAINTENANCE PRECAUTIONS

When performing any inspection or maintenance work on your vehicle, always take care to prevent serious accidental injury to yourself or damage to the vehicle. The following are general precau- tions which should be closely observed.

WARNING

c Park the vehicle on a level surface, ap- ply the parking brake securely and block the wheels to prevent the vehicle from moving. For manual transmission models, move the shift lever to N (Neu- tral). For automatic transmission mod- els, move the selector lever to P (Park). c Be sure the ignition key is in the OFF or LOCK position when performing any parts replacement or repairs.

c Never leave the engine or automatic transmission related component har- nesses disconnected while the ignition switch is in the ON position.

c Never connect or disconnect the battery or any transistorized component while the ignition switch is in the ON position. c Your vehicle is equipped with an auto- matic engine cooling fan. It may come on at any time without warning, even if the ignition key is in the OFF position and the

engine is not running. To avoid injury, always disconnect the negative battery cable before working near the fan.

serviced by a NISSAN dealer because the fuel lines are under high pressure even when the engine is off.

c If you must work with the engine run- ning, keep your hands, clothing, hair and tools away from moving fans, belts and any other moving parts.

c It is advisable to secure or remove any loose clothing and remove any jewelry, such as rings, watches, etc. before working on your vehicle.

c Always wear eye protection whenever

you work on your vehicle.

c If you must run the engine in an en- closed space such as a garage, be sure there is proper ventilation for exhaust gases to escape.

c Never get under the vehicle while it is supported only by a jack. If it is neces- sary to work under the vehicle, support it with safety stands.

c Keep smoking materials,

flame and sparks away from the fuel tank and battery.

c On gasoline engine models with the multiport fuel injection (MFI) system, the fuel filter or fuel lines should be

CAUTION

c Do not work under the hood while the engine is hot. Turn the engine off and wait until it cools down.

c Avoid contact with used engine oil and Improperly disposed engine coolant. oil, engine coolant and/or other vehicle fluids can damage the environment. Al- ways conform to local regulations for disposal of vehicle fluid.

This (cid:147)Maintenance and do-it-yourself(cid:148) section gives instructions regarding only those items which are relatively easy for an owner to perform. A genuine NISSAN service manual is also avail- able. See (cid:147)Owner(cid:146)s Manual/Service Manual or- der information(cid:148) in the (cid:147)Technical and consumer information(cid:148) section of this manual. You should be aware that incomplete or improper servicing may result in operating difficulties or excessive emissions, and could affect warranty coverage. If in doubt about any servicing, have it done by a NISSAN dealer.

Maintenance and do-it-yourself 8-5

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

ENGINE COMPARTMENT CHECK LOCATIONS

Power steering fluid reservoir Engine oil filler cap Brake fluid reservoir

Air cleaner Battery Fuse/Fusible link box Transmission dipstick (A/T models) Engine oil dipstick

1. 2. 3. 4. Clutch fluid reservoir (M/T model) 5. 6. 7. 8. 9. 10. Radiator cap 11. Fuse block 12. Windshield washer fluid reservoir 13. Engine coolant reservoir NOTE: Engine cover removed for clarity.

8-6 Maintenance and do-it-yourself

LDI0330

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

ENGINE COOLING SYSTEM

NISSAN

Genuine

The engine cooling system is filled at the factory with Life Antifreeze/Coolant to provide year-round anti- freeze and coolant protection. The anti-freeze solution contains rust and corrosion inhibitors. Additional engine cooling system additives are not necessary.

Long

WARNING

c Never remove the radiator or coolant reservoir cap when the engine is hot. Wait until the engine and radiator cool down. Serious burns could be caused by high pressure fluid escaping from the radiator. See precautions in (cid:147)If your vehicle overheats(cid:148) found in the (cid:147)In case of emergency(cid:148) section of this manual. c The radiator is equipped with a pres- sure type radiator cap. To prevent en- gine damage, use only a genuine NISSAN radiator cap.

Outside temperature

down to

(cid:176)C

-35

(cid:176)F

-30

Demineral- ized or dis- tilled water

Genuine NISSAN Long Life Antifreeze/ Coolant or equivalent

50%

50%

CAUTION

When adding or replacing coolant, be sure to use only a Genuine NISSAN Long Life Antifreeze/Coolant (green) or equivalent with the proper mixture ratio of 50% anti- freeze and 50% demineralized or distilled water. The use of other types of coolant solutions or coolant colors, such as or- ange, may damage the engine cooling system.

WDI0332

CHECKING ENGINE COOLANT LEVEL Check the coolant level in the reservoir when the engine is cold. If the coolant level is below the MIN level, add coolant to the MAX level. If the reservoir is empty, check the coolant level in the radiator when the engine is cold. If there is insufficient coolant in the radiator, fill the radiator with coolant up to the filler opening and also add it to the reservoir up to the MAX level. If the cooling system frequently requires coolant, have it checked by a NISSAN dealer.

Maintenance and do-it-yourself 8-7

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

ENGINE OIL

CHANGING ENGINE COOLANT A NISSAN dealer can change the engine coolant. The service procedure can be found in the NISSAN Service Manual. Improper servicing can result in reduced heater performance and engine overheat- ing.

WARNING

c To avoid the danger of being scalded, never change the coolant when the en- gine is hot.

c Never remove the radiator cap when the engine is hot. Serious burns could be caused by high pressure fluid escaping from the radiator.

c Avoid direct skin contact with used coolant. If skin contact is made, wash thoroughly with soap or hand cleaner as soon as possible.

c Keep coolant out of the reach of chil-

dren and pets.

LDI0329

CHECKING ENGINE OIL LEVEL 1. Park the vehicle on a level surface and apply

the parking brake.

2. Start the engine and let it idle until it reaches

operating temperature.

3. Turn off the engine. Wait more than 10
minutes for the oil to drain back into the oil pan.

Engine coolant must be disposed of properly. Check your local regulations.

4. Remove the dipstick and wipe it clean. Re-

insert it all the way.

8-8 Maintenance and do-it-yourself

WDI0175
5. Remove the dipstick again and check the oil level. It should be between the H (High) and L (Low) marks sB . This is the normal oper- ating oil level range. If the oil level is below the L (Low) mark sA , remove the oil filler cap and pour recommended oil through the opening. Do not overfill sC .

6. Recheck oil level with the dipstick. It is normal to add some oil between oil maintenance intervals or during the break-in period, depending on the severity of operating conditions.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

CAUTION

Oil level should be checked regularly. Op- erating the engine with an insufficient amount of oil can damage the engine, and such damage is not covered by warranty.

If the oil filter is to be changed, remove and replace it at this time. See (cid:147)Changing engine oil filter(cid:148) later in this section.

WARNING

c Prolonged and repeated contact with used engine oil may cause skin cancer. c Try to avoid direct skin contact with used oil. If skin contact is made, wash thoroughly with soap or hand cleaner as soon as possible.

c Keep used engine oil out of reach of

children.

CAUTION

Be careful not to burn yourself. The engine oil may be hot.

c Waste oil must be disposed of prop-

erly.

c Check your local regulations.

6. Clean and reinstall the drain plug and a new washer. Securely tighten the drain plug with a wrench. Do not use excessive force. Drain plug tightening torque: 22 - 29 ft-lb (29 - 39 N•m)

Maintenance and do-it-yourself 8-9

WDI0216

CHANGING ENGINE OIL 1. Park the vehicle on a level surface and apply

the parking brake.

2. Start the engine and let it idle until it reaches

operating temperature, then turn it off.

3. Remove the oil filler cap by turning it coun-

terclockwise.

4. Place a large drain pan under the drain plug.

5. Remove the drain plug with a wrench by turning it counterclockwise and completely drain the oil.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

and

(cid:147)Capacities

7. Refill engine with recommended oil through the oil filler opening, then install the oil filler cap securely. See recommended fuel/lubricants(cid:148) in the (cid:147)Technical and con- sumer information(cid:148) section of this manual for drain and refill capacity. The drain and refill capacity depends on the oil temperature and drain time. Use these specifications for reference only. Always use the dipstick to determine when the proper amount of oil is in the engine.

5. Wipe the engine oil filter mounting surface

with a clean rag. Be sure to remove any old gasket material remaining on the mounting surface of the engine.

6. Coat the gasket on the new filter with clean

engine oil.

7. Screw on the oil filter until a slight resistance

is felt, then tighten an additional 2/3 turn.

8. Start

the engine and check for leakage

around the oil filter. Correct as required.

9. Turn the engine off and wait more than 10
minutes. Check the oil level. Add engine oil if necessary.

8. Start the engine. Check for leakage around the drain plug and oil filter. Correct as re- quired.

9. Turn the engine off and wait more than 10
minutes. Check the oil level with the dipstick. Add engine oil if necessary.

8-10 Maintenance and do-it-yourself

CHANGING ENGINE OIL FILTER 1. Park the vehicle on a level surface and apply

WDI0218

the parking brake.

2. Turn the engine off.

3. Place a large drain pan under the oil filter.

4. Loosen the oil filter with an oil filter wrench by turning it counterclockwise. Then remove the oil filter by turning it by hand.

CAUTION

Be careful not to burn yourself. The engine oil may be hot.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

CAUTION

c DO NOT OVERFILL. c Recommended

is NISSAN PSF or equivalent.

fluid

Genuine

5-SPEED AUTOMATIC TRANSMISSION FLUID

POWER STEERING FLUID

When checking or replacement is required, we recommend your NISSAN dealer for servicing.

WARNING

c Use only Genuine Matic K ATF. Do not

mix with other fluids.

c Using automatic transmission fluid other than Genuine Matic K ATF will cause deterioration in driveability and automatic transmission durability, and may damage the automatic transmis- sion, which is not covered by the NISSAN new vehicle limited warranty.

The specified automatic transmission fluid is also described on caution labels located in the engine compartment.

WDI0256
The fluid level should be checked using the HOT MAX range on the power steering fluid reservoir at fluid temperatures of 122(cid:176) - 176(cid:176)F (50(cid:176) - 80(cid:176)C) or using the COLD MAX range on the power steering fluid reservoir at fluid tempera- tures of 32(cid:176) - 86(cid:176)F (0(cid:176) - 30(cid:176)C). If the fluid is below the MIN line, add Genuine NISSAN PSF. Remove the cap and fill through the opening.

Maintenance and do-it-yourself 8-11

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

BRAKE AND CLUTCH FLUID

For further brake and clutch fluid specification information, to (cid:147)Capacities and recom- mended fuel/lubricants(cid:148) in the (cid:147)Technical and consumer information(cid:148) section of this manual.

refer

WARNING

Use only new fluid from a sealed con- tainer. Old, inferior or contaminated fluid may damage the brake and clutch sys- tems. The use of improper fluids can dam- age the brake system and affect the vehi- cle(cid:146)s stopping ability.

CAUTION

Do not spill the fluid on any painted sur- faces. This will damage the paint. If fluid is spilled, immediately wash the surface with water.

8-12 Maintenance and do-it-yourself

LDI0079

LDI0080

BRAKE FLUID Check the brake fluid level in the reservoir. If the fluid level is below the MIN line or the brake warning light comes on, add Genuine NISSAN Super Heavy Duty Brake Fluid or equivalent DOT 3 fluid up to the MAX line. If fluid must be added frequently, the system should be checked by a NISSAN dealer.

CLUTCH FLUID Check the clutch fluid level in the reservoir (manual transmissions only). If the fluid level is below the MIN line, add Genuine NISSAN Super Heavy Duty Brake Fluid or equivalent DOT 3 fluid up to the MAX line. If fluid must be added fre- quently, the system should be checked by a NISSAN dealer. For further brake and clutch fluid specification information, to (cid:147)Capacities and recom- mended fuel/lubricants(cid:148) in the (cid:147)Technical and consumer information(cid:148) section of this manual.

refer

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

WINDOW WASHER FLUID

BATTERY

LDI0335

WINDOW WASHER FLUID RESERVOIR Fill the window washer fluid reservoir periodically. Add window washer fluid when the low window washer fluid warning light comes on (if so equipped).

To fill the window washer fluid reservoir, lift the cap off the reservoir tank and pour the window washer fluid into the tank opening.

Add a washer solvent to the washer for better cleaning. In the winter season, add a windshield washer antifreeze. Follow the manufacturer(cid:146)s in- structions for the mixture ratio.

Refill the reservoir more frequently when driving conditions require an increased amount of win- dow washer fluid. Recommended fluid is Genuine NISSAN Wind- shield Washer Concentrate Cleaner & Anti- freeze or equivalent.

CAUTION

c Do not substitute engine anti-freeze coolant for window washer solution. This may result in damage to the paint. c Do not fill the window washer reservoir tank with washer fluid concentrates at full strength. Some methyl alcohol based washer fluid concentrates may permanently stain the grille if spilled while filling the window washer reser- voir tank.

c Pre-mix washer fluid concentrates with water to the manufacturer(cid:146)s recom- mended levels before pouring the fluid into the window washer reservoir tank. Do not use the window washer reservoir tank to mix the washer fluid concen- trate and water.

c Keep the battery surface clean and dry. Any corrosion should be washed off with a solu- tion of baking soda and water.

c Make certain the terminal connections are

clean and securely tightened.

c If the vehicle is not to be used for 30 days or longer, disconnect the negative (-) battery terminal cable to prevent discharge.

WARNING

c Do not expose the battery to flames or electrical sparks. Hydrogen gas gener- ated by the battery is explosive. Do not allow battery fluid to contact your skin, eyes, fabrics or painted surfaces. After touching a battery or battery cap, do not touch or rub your eyes. Thoroughly wash your hands. If the acid contacts your eyes, skin or clothing, immediately flush with water for at least 15 minutes and seek medical attention.

c Do not operate the vehicle if the fluid in the battery is low. Low battery fluid can cause a higher load on the battery which can generate heat, reduce bat- tery life, and in some cases lead to an explosion.

Maintenance and do-it-yourself 8-13

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

c When working on or near a battery, al- ways wear suitable eye protection and remove all jewelry.

c Battery posts, terminals and related ac- cessories contain lead and lead com- pounds. Wash hands after handling.

c Keep battery out of

children.

the reach of

8-14 Maintenance and do-it-yourself

WDI0224
1. Remove the battery caps with a screwdriver as shown. Use a cloth to protect the battery case.

2. Check the fluid level

LDI0302
If it is necessary to add fluid, add only distilled water to bring the level up to the bottom of the filler opening. Do not overfill.

in each cell

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

DRIVE BELTS

Vehicles operated in high temperatures or under severe conditions require frequent checks of the battery fluid level. JUMP STARTING If jump starting is necessary, see (cid:147)Jump starting(cid:148) in the (cid:147)In case of emergency(cid:148) section of this manual. If the engine does not start by jump starting, the battery may have to be replaced. Contact a NISSAN dealer.

WDI0226

2. Have the belts checked regularly for condi- tion and tension in accordance with the maintenance the (cid:147)NISSAN Service and Maintenance Guide(cid:148).

schedule

found

in

Power steering fluid pump

1. 2. Crankshaft 3. Generator 4.

Air conditioner

WARNING

Be sure the ignition key is in the OFF or LOCK position. The engine could rotate unexpectedly.

1. Visually inspect each belt for signs of un- usual wear, cuts, fraying or looseness. If the belt is in poor condition or is loose, have it replaced or adjusted by a NISSAN dealer.

Maintenance and do-it-yourself 8-15

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

SPARK PLUGS

AIR CLEANER

WARNING

Be sure the engine and ignition switch are off and that the parking brake is engaged securely.

CAUTION

Be sure to use the correct socket to re- move the spark plugs. An incorrect socket can damage the spark plugs.

If replacement is required, see your NISSAN dealer for assistance.

WDI0005

REPLACING SPARK PLUGS Platinum-tipped spark plugs It is not necessary to replace platinum-tipped spark plugs as frequently as conventional type spark plugs because they last much longer. Fol- low the maintenance log shown in the (cid:147)NISSAN Service and Maintenance Guide(cid:148). Do not service platinum-tipped spark plugs by cleaning or re- gapping. c Always replace spark plugs with rec-

ommended or equivalent ones.

8-16 Maintenance and do-it-yourself

LDI0336
The air cleaner filter should not be cleaned and reused. Replace it according to the maintenance log shown in the (cid:147)NISSAN Service and Mainte- nance Guide.(cid:148) When replacing the filter, wipe the inside of the air cleaner filter housing and the cover with a damp cloth.

Loosen the screw.

To remove the air cleaner filter: s1
s2 Disconnect the electrical connector. s3 Unlatch the clips and remove the air cleaner

cover. Remove the air cleaner filter.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

WARNING

c Operating the engine with the air cleaner removed can cause you or oth- ers to be burned. The air cleaner not only cleans the air, it stops the flame if the engine backfires. If it isn(cid:146)t there, and the engine backfires, you could be burned. Do not drive with the air cleaner removed, and be careful when working on the engine with the air cleaner removed.

c Never pour fuel into the throttle body or attempt to start the engine with the air cleaner removed. Doing so could result in serious injury.

IN-CABIN MICROFILTER The in-cabin microfilter restricts the entry of air- borne dust and pollen particles and reduces some objectionable outside odors. The filter is located behind the glove box. Refer to the (cid:147)NISSAN Service and Maintenance Guide(cid:148) for change intervals. To replace the filter, perform the following proce- dure:

LDI0323
1. Remove the 2 lower glove box hinge pins. Remove the glove box from the opening and let it hang by the cord.

LDI0324
2. Remove the filter cover from the intake unit by disengaging the 2 hook tabs at the bot- tom of the cover.

Maintenance and do-it-yourself 8-17

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

LDI0325

NOTE: The filter is marked (cid:147)UP(cid:148) with an arrow. The end of the filter with the arrow should face the rear of the vehicle. 3. Slide the filter into the housing.

8-18 Maintenance and do-it-yourself

LDI0157

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

NOTE: Make sure the filter sits on top of the 2
supporting tabs on the housing. 4. Replace the cover by inserting the upper tabs inside the housing slot and pushing the hook tabs until they snap on to the housing lip. Install the glove box door.

5. 6. Fill out the date information on the small replacement label and attach it to the glove box lid.

Maintenance and do-it-yourself 8-19

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

WINDSHIELD WIPER BLADES

CLEANING If your windshield is not clear after using the windshield washer or if a wiper blade chatters when running, wax or other material may be on the blade or windshield. Clean the outside of the windshield with a washer solution or a mild detergent. Your windshield is clean if beads do not form when rinsing with clear water. Clean each blade by wiping it with a cloth soaked in a washer solution or a mild detergent. Then rinse the blades with clear water. If your wind- shield is still not clear after cleaning the blades and using the wiper, replace the blades. 8-20 Maintenance and do-it-yourself

CAUTION

Worn windshield wiper blades can dam- age the windshield and impair driver vision.

REPLACING Replace the wiper blades if they are worn. s1
Lift the wiper arm away from the windshield. s2 Push the release tab, then move the wiper

blade down the wiper arm to remove.

s3 Remove the wiper blade.

4.

WDI0194
Insert the new wiper blade onto the wiper arm until it clicks into place.

CAUTION

c After wiper blade replacement, return the wiper arm to its original position; otherwise it may be damaged when the hood is opened.

c Make sure the wiper blades contact the glass; otherwise the arms may be dam- aged from wind pressure.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

PARKING BRAKE AND BRAKE PEDAL

WDI0337
Be careful not to let anything get into the washer nozzle sA . This may cause clogging or improper windshield washer operation. If something gets into the nozzle, remove it with a needle or small pin sB .

LDI0326

WDI0229

CHECKING PARKING BRAKE From the released position, pull the parking brake lever up slowly and firmly. If the number of clicks is out of the range listed, see a NISSAN dealer. c 7 - 8 clicks under pulling force of

44 lb (196 N).

CHECKING BRAKE PEDAL With the engine running, check the distance A between the upper surface of the pedal and the metal floor. If it is out of the range shown, see a NISSAN dealer. Distance A: Under depression force of 110 lb (490 N)

Automatic

Transmission

3.55 in (90.3 mm)

or more

Manual

Transmission

3.31 in (84 mm)

or more

Maintenance and do-it-yourself 8-21

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

Self-adjusting brakes Your vehicle is equipped with self-adjusting brakes. The front and rear disc-type brakes self-adjust every time the brake pedal is applied.

WARNING

See a NISSAN dealer for a brake system check if the brake pedal height does not return to normal. Brake pad wear indicators The disc brake pads on your vehicle have audible wear indicators. When a brake pad requires re- placement, a high pitched scraping or screech- ing sound will be heard when the vehicle is in motion. The noise will be heard whether or not the brake pedal is depressed. Have the brakes checked as soon as possible if the wear indicator sound is heard. Under some driving or climate conditions, occa- sional brake squeak, squeal or other noise may be heard. Occasional brake noise during light to moderate stops is normal and does not affect the function or performance of the brake system.

8-22 Maintenance and do-it-yourself

Proper brake inspection intervals should be followed. For more information regarding brake inspections, see the appropriate mainte- nance schedule information in the (cid:147)NISSAN Ser- vice and Maintenance Guide(cid:148). BRAKE BOOSTER Check the brake booster function as follows: 1. With the engine off, press and release the brake pedal several times. When brake pedal movement (distance of travel) remains the same from one pedal application to the next, continue on to the next step.

2. While depressing the brake pedal, start the engine. The pedal height should drop a little. 3. With the brake pedal depressed, stop the engine. Keep the pedal depressed for about 30 seconds. The pedal height should not change.

4. Run the engine for one minute without de- pressing the brake pedal, then turn it off. Depress the brake pedal several times. The pedal travel distance will decrease gradually with each depression as the vacuum is re- leased from the booster.

If the brakes do not operate properly, have the brakes checked by a NISSAN dealer.

FUSES

LDI0455
Two types of fuses are used. Type A is used in the fuse boxes in the engine compartment. Type B is used in the passenger compartment fuse box. Type A fuses are provided as spare fuses. They are stored in the passenger compartment fuse box. Type A fuses can be installed in the engine com- partment and passenger compartment fuse boxes.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

3. Remove the fuse box cover by pushing the

tab and lifting the cover up.

4. Remove the fuse with the fuse puller. The fuse puller is located in the center of the fuse block in the passenger compartment.

LDI0457
If a type A fuse is used to replace a type B fuse, the type A fuse will not be level with the fuse pocket as shown in the illustration. This will not affect the performance of the fuse. Make sure the fuse is installed in the fuse box securely. Type B fuses cannot be installed in the under- hood fuse boxes. Only use type A fuses in the underhood fuse boxes.

LDI0327

ENGINE COMPARTMENT

CAUTION

Never use a fuse of a higher or lower amperage rating than specified on the fuse box cover. This could damage the electrical system or cause a fire.

If any electrical equipment does not come on, check for an open fuse.

1. Be sure the ignition switch and the headlight

switch are OFF.

2. Open the engine hood.

Maintenance and do-it-yourself 8-23

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

5.

6.

WDI0452
If the fuse is open sA , replace it with a new fuse sB . If a new fuse also opens, have the electrical system checked and repaired by a NISSAN dealer.

Fusible links If the electrical equipment does not operate and fuses are in good condition, check the fusible links. If any of these fusible links are melted, replace with only genuine NISSAN parts.

8-24 Maintenance and do-it-yourself

PASSENGER COMPARTMENT

CAUTION

Never use a fuse of a higher or lower amperage rating than specified on the fuse box cover. This could damage the electrical system or cause a fire.

If any electrical equipment does not operate, check for an open fuse. 1. Be sure the ignition switch and the headlight

switch are OFF.

2. Pull the fuse box cover to remove. 3. Remove the fuse with the fuse puller.

LDI0328

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

WDI0452

LDI0456

4.

Type A

If the fuse is open sA , replace it with a known good fuse sB .

5. Push the fuse box cover to install. 6.

If a new fuse also opens, have the electrical system checked and repaired by a NISSAN dealer.

Type B

Maintenance and do-it-yourself 8-25

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

KEYFOB BATTERY REPLACEMENT

Replace the battery in the keyfob as follows: s1 Open the lid using a coin. s2 Remove the battery. s3

Install a new battery with the (cid:147)+(cid:148) facing down.

8-26 Maintenance and do-it-yourself

LPD0214
Recommended battery: CR2025 or equivalent. s4 Close the lid securely. 5. Press the

button, then the

button two or three times to check the key- fob operation.

If the battery is removed for any reason other than replacement, perform step 5. c An improperly disposed battery can hurt the environment. Always confirm local regulations for battery disposal. c The keyfob is water-resistant; how- ever, if it does get wet, immediately wipe completely dry.

c The operational range of the keyfob extends to approximately 33 ft (10 m) from the vehicle. This range may vary with conditions.

FCC Notice: Changes or modifications not expressly ap- proved by the manufacturer for compliance could void the user(cid:146)s authority to operate the equipment. This device complies with Part 15 of the FCC Rules and RSS-210 of Industry Canada. Operation is subject to the following two conditions: (1) This device may not cause harmful interference, and (2) this device must accept any interference received, in- cluding interference that may cause undes- ired operation of the device.

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

LIGHTS

HEADLIGHTS Replacing the xenon headlight bulb

WARNING

cHIGH VOLTAGE

When xenon headlights are on, they pro- duce a high voltage. To prevent an electric shock, never attempt to modify or disas- semble. Always have your xenon head- lights replaced at a NISSAN dealer. For additional information, see (cid:147)Headlight and turn signal switch(cid:148) in the (cid:147)Instru- ments and controls(cid:148) section. Replacing the halogen headlight bulb The headlight is a semi-sealed beam type which uses a replaceable headlight (halogen) bulb. Be- cause the headlight assembly must be removed from the vehicle for bulb replacement, see your NISSAN dealer.

CAUTION

c Aiming is not necessary after replacing the bulb. When aiming adjustment is necessary, contact a NISSAN dealer.

c Do not leave the headlight assembly open without a bulb installed for a long period of time. Dust, moisture, smoke, etc. entering the headlight body may affect bulb performance. Remove the bulb from the headlight assembly just before a replacement bulb is installed. c Only touch the plastic base when han- dling the bulb. Never touch the glass envelope. Touching the glass could sig- nificantly affect bulb life and/or head- light performance.

c High pressure halogen gas is sealed inside the halogen bulb. The bulb may break if the glass envelope is scratched or the bulb is dropped.

c Use the same number and wattage as

originally installed: Low beam:

Wattage: 55
Bulb no.: 9012*

High beam:

Wattage: 55
Bulb no.: 9012*

*: Always check with the Parts Depart- ment at a NISSAN dealer for the latest parts information.

Maintenance and do-it-yourself 8-27

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

EXTERIOR AND INTERIOR LIGHTS

Item

Wattage (W)

Bulb No.*

Headlight assembly

High/low (Halogen) High/low (Xenon) Day time running lamp Park/Turn Cornering

Front fog light Front personal/map lights Console box illumination Glove box light (if so equipped) Vanity mirror light Step light Rear personal lamps Rear console box light High-mounted stop light Trunk light Rear combination light

Tail/Stop/Turn Backup (reversing) Sidemarker License plate light

55

(special)

(cid:150)

27/8
27
55
3.4
3.8
3.4
2.1
3.8
3.4

27/5
13

9012
D2S 1156

1157NA 3156K

H3
(cid:150) 194
158
(cid:150) 194
(cid:150)

W5W W5W 158

3057K

912
168
168

* Always check with the Parts Department at a NISSAN dealer for the latest parts information.

8-28 Maintenance and do-it-yourself

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

Rear personal lights Step light

1. Map light 2. 3. 4. Cornering light 5. 6. 7. 8. High-mount stoplight 9. Headlamp assembly 10. Fog light

Rear combination light License plate light Trunk light

LDI0391

Maintenance and do-it-yourself 8-29

Z REVIEW COPY—2005 Maxima (max) Owners Manual—USA_English (nna) 03/08/05—tbrooks X

WDI0263

LDI0338