Login- Download PDF Manual
-
24
Engine compartment / 7-2
Maintenance services / 7-4
Owner maintenance / 7-5
Scheduled maintenance service / 7-7
Explanation of scheduled maintenance items / 7-12
Engine oil / 7-15
Engine coolant / 7-16
Brake fluid / 7-19
Power steering fluid / 7-20
Washer fluid / 7-21
Automatic transmission fluid / 7-21
Parking brake / 7-22
Air cleaner / 7-22
Climate control air filter / 7-23
Wiper blades / 7-25
Battery / 7-28
Tires and wheels / 7-31Maintenance
Fuses / 7-44
Light bulbs / 7-54
Appearance care / 7-59
Emission control system / 7-65
California perchlorate notice / 7-68Maintenance
ENGINE COMPARTMENT
■■ Gasoline Engine (3.8L)
1. Engine coolant reservoir 2. Radiator cap 3. Brake fluid reservoir 4. Air cleaner 5. Engine oil dipstick 6. Engine oil filler cap 7. Windshield washer fluid reservoir 8. Fuse box 9. Power steering fluid reservoir (with EHPS) 10. Power steering fluid reservoir
(without EHPS) 11. Jumper terminal
* The actual engine room in the vehicle may differ from the illustration. * The battery is in the trunk.
OBH018003L
G010000ABH-EU
27
■■ Gasoline Engine (4.6L)
Maintenance
1. Engine coolant reservoir 2. Radiator cap 3. Brake fluid reservoir 4. Air cleaner 5. Engine oil dipstick 6. Engine oil filler cap 7. Windshield washer fluid reservoir 8. Fuse box 9. Power steering fluid reservoir (with EHPS) 10. Power steering fluid reservoir
(without EHPS) 11. Jumper terminal
* The actual engine room in the vehicle may differ from the illustration. * The battery is in the trunk.
OBH018005N
7 3
Maintenance
MAINTENANCE SERVICES G020000AEN You should exercise the utmost care to prevent damage to your vehicle and injury to yourself whenever performing any maintenance or inspection proce- dures. Should you have any doubts concerning the inspection or servicing of your vehi- cle, we strongly recommend that you have an authorized HYUNDAI dealer perform this work. An authorized HYUNDAI dealer has fac- tory-trained technicians and genuine HYUNDAI parts to service your vehicle properly. For expert advice and quality service, see an authorized HYUNDAI dealer. Inadequate, incomplete or insufficient servicing may result in operational prob- lems with your vehicle that could lead to vehicle damage, an accident, or person- al injury.
47
G020200AEN-EU Owner maintenance precautions Improper or incomplete service may result in problems. This section gives instructions only for the maintenance items that are easy to perform. As explained earlier in this section, sev- eral procedures can be done only by an authorized HYUNDAI dealer with special tools.
✽✽ NOTICE Improper owner maintenance during the warranty period may affect warran- ty coverage. For details, read the sepa- rate Owner’s Handbook & Warranty Information booklet provided with the vehicle. If you're unsure about any serv- icing or maintenance procedure, have it done by an authorized HYUNDAI deal- er.
G020100AEN-EU Owner’s responsibility
✽✽ NOTICE Maintenance Service and Record Retention are the owner's responsibility.
You should retain documents that show proper maintenance has been performed on your vehicle in accordance with the scheduled maintenance service charts shown on the following pages. You need this information to establish your compli- ance with the servicing and maintenance requirements of your vehicle warranties. Detailed warranty information is provided in your Owner’s Handbook & Warranty Information booklet. Repairs and adjustments required as a result of improper maintenance or a lack of required maintenance are not covered. We recommend you have your vehicle maintained and repaired by an author- ized HYUNDAI dealer. An authorized HYUNDAI dealer meets HYUNDAI’s high service quality standards and receives technical support from HYUNDAI in order to provide you with a high level of service satisfaction.
OWNER MAINTENANCE G030000AEN The following lists are vehicle checks and inspections that should be performed by the owner or an authorized HYUNDAI dealer at the frequencies indicated to help ensure safe, dependable operation of your vehicle. Any adverse conditions should be brought to the attention of your dealer as soon as possible. These Owner Maintenance Checks are generally not covered by warranties and you may be charged for labor, parts and lubricants used.
Maintenance
Owner maintenance schedule G030101AUN When you stop for fuel: (cid:129) Check the engine oil level. (cid:129) Check coolant level in coolant reser-
voir.
(cid:129) Check the windshield washer fluid
level.
(cid:129) Look for low or under-inflated tires.
WARNING
Be careful when checking your engine coolant level when the engine is hot. Scalding hot coolant and steam may blow out under pressure. This could cause burns or other serious injury.
WARNING - Maintenance
work
(cid:129) Performing maintenance work on a vehicle can be dangerous. You can be seriously injured while performing some maintenance procedures. If you lack sufficient knowledge and experience or the proper tools and equipment to do the work, have it done by an authorized HYUNDAI dealer.
(cid:129) Working under the hood with the engine running is dangerous. It becomes even more dangerous when you wear jewelry or loose clothing. These can become entangled in moving parts and result in injury. Therefore, if you must run the engine while work- ing under the hood, make certain that you remove all jewelry (espe- cially rings, bracelets, watches, and necklaces) and all neckties, scarves, and similar loose cloth- ing before getting near the engine or cooling fans.
7 5
G030105AUN-EU At least once a year: (cid:129) Clean body and door drain holes. (cid:129) Lubricate door hinges and checks, and
hood hinges.
(cid:129) Lubricate door and hood locks and
latches.
(cid:129) Lubricate door rubber weatherstrips. (cid:129) Check the air conditioning system. (cid:129) Check the power steering fluid level. (cid:129) Inspect and lubricate automatic trans-
mission linkage and controls. (cid:129) Clean battery and terminals. (cid:129) Check the brake fluid level.
Maintenance
G030102ABH While operating your vehicle: (cid:129) Note any changes in the sound of the exhaust or any smell of exhaust fumes in the vehicle.
(cid:129) Check for vibrations in the steering wheel. Notice any increased steering effort or looseness in the steering wheel, or change in its straight-ahead position.
(cid:129) Notice if your vehicle constantly turns slightly or “pulls” to one side when trav- eling on smooth, level road.
(cid:129) When stopping, listen and check for unusual sounds, pulling to one side, increased brake pedal travel or “hard- to-push” brake pedal.
(cid:129) If any slipping or changes in the oper- ation of your transmission occurs, check the transmission fluid level.
(cid:129) Check automatic transmission P (Park)
function.
(cid:129) Check parking brake. (cid:129) Check for fluid leaks under your vehicle (water dripping from the air condition- ing system during or after use is nor- mal).
G030103AUN At least monthly: (cid:129) Check coolant level in the engine
coolant reservoir.
(cid:129) Check the operation of all exterior lights, including the stoplights, turn sig- nals and hazard warning flashers.
(cid:129) Check the inflation pressures of all
tires including the spare.
G030104AUN At least twice a year (i.e.,every Spring and Fall): (cid:129) Check radiator, heater and air condi-
tioning hoses for leaks or damage.
(cid:129) Check windshield washer spray and wiper operation. Clean wiper blades with clean cloth dampened with wash- er fluid.
(cid:129) Check headlight alignment. (cid:129) Check muffler, exhaust pipes, shields
and clamps.
(cid:129) Check the lap/shoulder belts for wear
and function.
(cid:129) Check for worn tires and loose wheel
lug nuts.
67
SCHEDULED MAINTENANCE SERVICE G040000AUN-EU Follow Normal Maintenance Schedule if the vehicle is usually operated where none of the following conditions apply. If any of the following conditions apply, fol- low Maintenance Under Severe Usage Conditions. (cid:129) Repeated short distance driving. (cid:129) Driving in dusty conditions or sandy
If your vehicle is operated under the above conditions, you should inspect, replace or refill more frequently than the following Normal Maintenance Schedule. After 120 months or 150,000 miles (240,000 km) continue to follow the pre- scribed maintenance intervals.
areas.
(cid:129) Extensive use of brakes. (cid:129) Driving in areas where salt or other
corrosive materials are being used.
(cid:129) Driving on rough or muddy roads. (cid:129) Driving in mountainous areas. (cid:129) Extended periods of idling or low
speed operation.
(cid:129) Driving for a prolonged period in cold temperatures and/or extremely humid climates.
(cid:129) More than 50% driving in heavy city traffic during hot weather above 90°F (32°C).
Maintenance
7 7
Maintenance
G040100ABH-EU NORMAL MAINTENANCE SCHEDULE The following maintenance services must be performed to ensure good emission control and performance. Keep receipts for all vehicle emission services to protect your warranty. Where both mileage and time are shown, the frequency of service is deter- mined by whichever occurs first. R : Replace
I : Inspect and, after Inspection, clean, adjust, repair or replace if necessary.
MILES X 1000
7.5
15
22.5
30
37.5
45
52.5
60
67.5
75
82.5
90
97.5 105 112.5 120 127.5 135 142.5 150
No.
DESCRIPTION
KILOMETERS X 1000
12
MONTHS
24
12
36
18
48
24
60
30
72
36
84
42
96
108 120 132 144 156 168 180 192 204 216
228 240
48
54
60
66
72
78
84
90
96
102 108
114 120
EMISSION CONTROL ITEMS
ENGINE OIL AND FILTER
FUEL FILTER
FUEL LINES, FUEL HOSES AND CONNECTIONS
VACUUM HOSE
CRANKCASE VENTILATION HOSE
VAPOR HOSE AND FUEL FILLER CAP
AIR CLEANER FILTER
SPARK PLUGS (IRIDIUM COATED)
VALVE CLEARANCE *1 (3.8L)
10
FUEL TANK AIR FILTER
11
ELECTRONIC THROTTLE CONTROL
Replace every 7,500 miles (12,000 km) or 12 months
Replace every 100,000 miles (160,000 km) or 10 years
*1 : Inspect for excessive tappet noise and/or engine vibration and adjust if necessary.
87
NORMAL MAINTENANCE SCHEDULE (CONT.) R : Replace
I : Inspect and, after Inspection, clean, adjust, repair or replace if necessary.
MILES X 1000
7.5
15
22.5
30
37.5
45
52.5
60
67.5
75
82.5
90
97.5 105 112.5 120 127.5 135 142.5 150
No.
DESCRIPTION
KILOMETERS X 1000
12
MONTHS
24
12
36
18
48
24
60
30
72
36
84
42
96
108 120 132 144 156 168 180 192 204 216
228 240
48
54
60
66
72
78
84
90
96
102 108
114 120
Maintenance
GENERAL ITEMS
DRIVE BELT (AUTO-TENSIONER,
GENERATOR, P/STR'G, A/CON, W/PUMP)
COOLANT
AUTOMATIC TRANSMISSION FLUID*2
BRAKE FLUID
BRAKE HOSES AND LINES
REAR DISC BRAKE/PADS, PARKING BRAKE
FRONT DISC BRAKE/PADS,
CALIPERS AND ROTORS
EXHAUST PIPE AND MUFFLER
SUSPENSION MOUNTING BOLTS
At first, replace at 60,000 miles (96,000 km) or 60 months
After that, replace every 30,000 miles (48,000 km) or 24 months
Inspect every 37,500 miles (60,000 km) or 48 months
*2 : Use only the specified automatic transmission fluid. (Refer to “Recommended lubricants and capacities” in section 8 or the
label in the engine room.)
7 9
Maintenance
NORMAL MAINTENANCE SCHEDULE (CONT.) R : Replace
I : Inspect and, after Inspection, clean, adjust, repair or replace if necessary.
MILES X 1000
7.5
15
22.5
30
37.5
45
52.5
60
67.5
75
82.5
90
97.5 105 112.5 120 127.5 135 142.5 150
No.
DESCRIPTION
KILOMETERS X 1000
12
GENERAL ITEMS
MONTHS
STEERING GEAR BOX, LINKAGE & BOOTS
10
/LOWER ARM BALL JOINT, UPPER ARM BALL
JOINT
11
POWER STEERING FLUID
12
POWER STEERING PUMP, BELT AND HOSES
13
DRIVE SHAFTS AND BOOTS
14
AIR CONDITIONING REFRIGERANT
CLIMATE CONTROL AIR FILTER
15
16
17
18
(FOR EVAPORATOR AND BLOWER UNIT)
REAR AXLE OIL *3
REAR DIFFERENTIAL OIL*3
PROPELLER SHAFT
24
12
36
18
48
24
60
30
72
36
84
42
96
108 120 132 144 156 168 180 192 204 216
228 240
48
54
60
66
72
78
84
90
96
102 108
114 120
*3 : Rear axle oil and rear differential oil should be changed anytime they have been submerged in water.
10
G040200ABH-EU MAINTENANCE UNDER SEVERE USAGE CONDITIONS The following items must be serviced more frequently on cars normally used under severe driving conditions. Refer to the chart below for the appropriate maintenance intervals. R : Replace I : Inspect and, after inspection, clean, adjust, repair or replace if necessary
MAINTENANCE ITEM
MAINTENANCE
OPERATION
MAINTENANCE
INTERVALS
DRIVING
CONDITION
Maintenance
ENGINE OIL AND FILTER
AIR CLEANER FILTER
SPARK PLUGS
AUTOMATIC TRANSMISSION FLUID
FRONT DISC BRAKE/PADS, CALIPERS AND ROTORS
REAR DISC BRAKE/PADS, PARKING BRAKE
STEERING GEAR BOX, LINKAGE & BOOTS/
LOWER ARM BALL JOINT, UPPER ARM BALL JOINT
DRIVE SHAFTS AND BOOTS
REAR AXLE OIL
CLIMATE CONTROL AIR FILTER
(FOR EVAPORATOR AND BLOWER UNIT)
REAR DIFFERENTIAL OIL
PROPELLER SHAFT
SEVERE DRIVING CONDITIONS A - Repeatedly driving short distance of less than 5 miles (8 km) in normal
temperature or less than 10 miles (16 km) in freezing temperature
B - Extensive engine idling or low speed driving for long distances C - Driving on rough, dusty, muddy, unpaved, graveled or salt- spread roads D - Driving in areas using salt or other corrosive materials or in very cold
weather
EVERY 3,750 MILES (6,000 KM) OR 6 MONTHS
A, B, C, D, E, F, G, H, I, K
MORE FREQUENTLY
MORE FREQUENTLY
C, E
B, H
EVERY 60,000 MILES (96,000 KM)
A, C, D, E, F, G, H, I
MORE FREQUENTLY
MORE FREQUENTLY
MORE FREQUENTLY
C, D, G, H
C, D, G, H
C, D, E, F, G, H, I
EVERY 7,500 MILES (12,000 KM) OR 6 MONTHS
C, D, E, F, H
EVERY 60,000 MILES (96,000 KM)
A, C, E, F, G, H, I
MORE FREQUENTLY
EVERY 80,000 MILES (128,000 KM)
C, E
C, E, G, I, K
EVERY 7,500 MILES (12,000 KM) OR 6 MONTHS
C, E
E - Driving in sandy areas F - Driving in heavy traffic area over 90°F (32°C) G - Driving on uphill, downhill, or mountain road H - Towing a Trailer, or using a camper, or roof rack J - Driving over 106 mph (170 km/h) K - Frequently driving in stop-and-go conditions
- Driving as a patrol car, taxi, other commercial use or vehicle towing
7 11
G050400AEN-EU Fuel lines, fuel hoses and con- nections Check the fuel lines, fuel hoses and con- nections for leakage and damage. Have an authorized HYUNDAI dealer replace any damaged or leaking parts immedi- ately.
G050600AUN Vapor hose and fuel filler cap The vapor hose and fuel filler cap should be inspected at those intervals specified in the maintenance schedule. Make sure that a new vapor hose or fuel filler cap is correctly replaced.
Maintenance
EXPLANATION OF SCHEDULED MAINTENANCE ITEMS G050100AUN Engine oil and filter The engine oil and filter should be changed at the intervals specified in the maintenance schedule. If the car is being driven in severe conditions, more fre- quent oil and filter changes are required.
G050300ABH Fuel filter A clogged filter can limit the speed at which the vehicle may be driven, damage the emission system and cause multiple issues such as hard starting. If an exces- sive amount of foreign matter accumu- lates in the fuel tank, the filter may require replacement more frequently. After installing a new filter, run the engine for several minutes, and check for leaks at the connections. Fuel filters should be installed by an authorized HYUNDAI dealer.
G050200AUN Drive belts Inspect all drive belts for evidence of cuts, cracks, excessive wear or oil satu- ration and replace if necessary. Drive belts should be checked periodically for proper tension and adjusted as neces- sary.
12
G050700AUN Vacuum crankcase ventilation hoses Inspect the surface of hoses for evidence of heat and/or mechanical damage. Hard and brittle rubber, cracking, tears, cuts, abrasions, and excessive swelling indi- cate deterioration. Particular attention should be paid to examine those hose surfaces nearest to high heat sources, such as the exhaust manifold. Inspect the hose routing to assure that the hoses do not come in contact with any heat source, sharp edges or moving component which might cause heat dam- age or mechanical wear. Inspect all hose connections, such as clamps and cou- plings, to make sure they are secure, and that no leaks are present. Hoses should be replaced immediately if there is any evidence of deterioration or damage.
G050800AEN Air cleaner filter A Genuine HYUNDAI air cleaner filter is recommended when is replaced.
filter
the
G050900AUN Spark plugs Make sure to install new spark plugs of the correct heat range.
G051000AEN Valve clearance (3.8L) Inspect excessive valve noise and/or engine vibration and adjust if necessary. An authorized HYUNDAI dealer should perform the operation.
G051100AUN Cooling system Check cooling system components, such as radiator, coolant reservoir, hoses and connections for leakage and damage. Replace any damaged parts.
Maintenance
G051200AUN Coolant The coolant should be changed at the intervals specified in the maintenance schedule.
G051500AUN Brake hoses and lines Visually check for proper installation, chafing, cracks, deterioration and any leakage. Replace any deteriorated or damaged parts immediately.
G051600AUN Brake fluid Check brake fluid level in the brake fluid reservoir. The level should be between “MIN” and “MAX” marks on the side of the reservoir. Use only hydraulic brake fluid conforming to DOT 3 or DOT 4
specification.7 13
G052400AUN Drive shafts and boots Check the drive shafts, boots and clamps for cracks, deterioration, or damage. Replace any damaged parts and, if nec- essary, repack the grease.
G052500AUN Air conditioning refrigerant Check the air conditioning lines and con- nections for leakage and damage.
G052200AUN Steering gear box, linkage & boots/lower arm ball joint With the vehicle stopped and engine off, check for excessive free-play in the steering wheel. Check the linkage for bends or damage. Check the dust boots and ball joints for deterioration, cracks, or damage. Replace any damaged parts.
G052300AEN Power steering pump, belt and hoses Check the power steering pump and hoses for leakage and damage. Replace any damaged or leaking parts immedi- ately. Inspect the power steering belt (or drive belt) for evidence of cuts, cracks, excessive wear, oiliness and proper ten- sion. Replace or adjust it if necessary.
Maintenance
G051700AUN Parking brake Inspect the parking brake system includ- ing the parking brake pedal and cables.
G051900AUN Brake discs, pads, calipers and rotors Check the pads for excessive wear, discs for run out and wear, and calipers for fluid leakage.
G052000AUN Exhaust pipe and muffler Visually inspect the exhaust pipes, muf- fler and hangers for cracks, deterioration, or damage. Start the engine and listen carefully for any exhaust gas leakage. Tighten connections or replace parts as necessary.
G052100AUN Suspension mounting bolts Check the suspension connections for looseness or damage. Retighten to the specified torque.
14
ENGINE OIL 3.8L
3. Turn the engine off and wait for a few minutes (about 5 minutes) for the oil to return to the oil pan.
3.8L
4. Pull the dipstick out, wipe it clean, and
re-insert it fully.
Maintenance
WARNING - Radiator hose Be very careful not to touch the radiator hose when checking or adding the engine oil as it may be hot enough to burn you.
5. Pull the dipstick out again and check the level. The level should be between F and L.
CAUTION
Do not overfill with engine oil. Engine damage may result.
4.6L
OBH078002L
OBH078002N
G060100AEN-EU Checking the engine oil level 1. Be sure the vehicle is on level ground. 2. Start the engine and allow it to reach
normal operating temperature.
4.6L
OBH078003L
OBH078003N If it is near or at L, add enough oil to bring the level to F. Do not overfill.
Use a funnel to help prevent oil from being spilled on engine components.
Use only the specified engine oil.(Refer to “Recommended lubricants and capaci- ties”in section 8.)
7 15
ENGINE COOLANT G070000AUN The high-pressure cooling system has a reservoir filled with year-round antifreeze coolant. The reservoir is filled at the fac- tory. Check the antifreeze protection and coolant level at least once a year, at the beginning of the winter season, and before traveling to a colder climate.
G070100AEN Checking the coolant level
WARNING - Removing radiator cap
(cid:129) Never attempt to remove the radi- ator cap while the engine is oper- ating or hot. Doing so might lead to cooling system and engine damage and could result in seri- ous personal injury from escap- ing hot coolant or steam.
(Continued)
(Continued) (cid:129) Turn the engine off and wait until it cools down. Use extreme care when removing the radiator cap. Wrap a thick towel around it, and turn it counterclockwise slowly to the first stop. Step back while the pressure is released from the cooling system. When you are sure all the pressure has been released, press down on the cap, using a thick towel, and continue turning counterclockwise to remove it.
(cid:129) Even if the engine is not operat- ing, do not remove the radiator cap or the drain plug while the engine and radiator are hot. Hot coolant and steam may still blow out under pressure, causing seri- ous injury.
Maintenance
G060200AEN-EU Changing the engine oil and filter Have engine oil and filter changed by an authorized HYUNDAI dealer according to the Maintenance Schedule at the begin- ning of this section.
CALIFORNIA PROPOSI- TION 65 WARNING
Engine oil contains chemicals known to the State of California to cause cancer, birth defects and reproductive harm. Used engine oil may cause irritation or cancer of the skin if left in contact with the skin for prolonged periods of time. Always protect your skin by wash- ing your hands thoroughly with soap and warm water as soon as possible after handling used oil.
16
3.8L
4.6L
OBH078004
OBH078004N Check the condition and connections of all cooling system hoses and heater hoses. Replace any swollen or deterio- rated hoses. The coolant filled between F and L marks on the side of the coolant reservoir when the engine is cool.
level should be
If the coolant level is low, add enough specified coolant to provide protection against freezing and corrosion. Bring the level to F, but do not overfill. If frequent additions are required, see an authorized HYUNDAI dealer for a cooling system inspection.
G070101AUN Recommended engine coolant (cid:129) Use only soft (de-mineralized) water in
the coolant mixture.
(cid:129) The engine in your vehicle has alu- minum engine parts and must be pro- tected by an ethylene-glycol-based coolant to prevent corrosion and freez- ing.
(cid:129) DO NOT USE alcohol or methanol coolant or mix them with the specified coolant.
(cid:129) Do not use a solution that contains more than 60% antifreeze or less than 35% antifreeze, which would reduce the effectiveness of the solution.
Maintenance
For mixture percentage, refer to the fol- lowing table.
Ambient
Temperature
5°F (-15°C) -13°F (-25°C) -31°F (-35°C) -49°F (-45°C)
Mixture Percentage (volume)
Antifreeze
Water
35
40
50
6065
60
50
407 17
Maintenance
3.8L
4.6L
G070200AEN Changing the coolant Have coolant changed by an authorized HYUNDAI dealer according the Maintenance Schedule at the beginning of this section.
to
CAUTION
Put a thick cloth around the radiator cap before refilling the coolant in order to prevent the coolant from overflowing into engine parts such as the generator.
OBH078005
WARNING - Coolant
(cid:129) Do not use radiator coolant or antifreeze in the washer fluid reservoir.
(cid:129) Radiator coolant can severely obscure visibility when sprayed on the windshield and may cause loss of vehicle control or damage to paint and body trim.
OBH078005N
WARNING - Radiator cap
Do not remove the radiator cap when the engine and radiator are hot. Scalding hot coolant and steam may blow out under pres- sure causing serious injury.
18
BRAKE FLUID 3.8L
4.6L
If the level is low, add fluid to the MAX level. The level will fall with accumulated mileage. This is a normal condition asso- ciated with the wear of the brake linings. If the fluid level is excessively low, have the brake system checked by an author- ized HYUNDAI dealer.
Use only the specified brake fluid.(Refer to “Recommended lubricants or capaci- ties”in section 8.)
OBH078006L
Never mix different types of fluid.
WARNING - Loss of brake
fluid
In the event the brake system requires frequent additions of fluid, the vehicle should be inspected by an authorized HYUNDAI dealer.
OBH078006N
fluid
G080100AEN Checking the brake fluid level Check the fluid level in the reservoir peri- odically. The level should be between MAX and MIN marks on the side of the reservoir. Before removing the reservoir cap and adding brake fluid, clean the area around the reservoir cap thoroughly to prevent brake fluid contamination.
Maintenance
WARNING - Brake fluid
When changing and adding brake fluid, handle it carefully. Do not let it come in contact with your eyes. If brake fluid should come in contact with your eyes, immediately flush them with a large quantity of fresh tap water. Have your eyes examined by a doctor as soon as possible.
CAUTION
Do not allow brake fluid to contact the vehicle's body paint, as paint damage will result. Brake fluid, which has been exposed to open air for an extended time should never be used as its quality cannot be guaranteed. It should be disposed of properly.Don't put in the wrong kind of fluid.A few drops of miner- al-based oil, such as engine oil, in your brake system can damage brake system parts.
7 19
Maintenance
POWER STEERING FLUID Type A
Type B
OBH078022
OBH078048L
G090100ABH Checking the power steering fluid level With the vehicle on level ground, check the fluid level in the power steering reser- voir periodically. The fluid should be between MAX and MIN marks on the side of the gauge at the normal tempera- ture.
20
Before adding power steering fluid, thor- oughly clean the area around the reser- voir cap to prevent power steering fluid contamination. If the level is low, add fluid to the MAX level.
✽✽ NOTICE - (if equipped) Check that the fluid level is in the "HOT" range on the gauge. If the fluid is cold, check that it is in the "COLD" range (if equipped).
In the event the power steering system requires frequent addition of fluid, the vehicle should be inspected by an authorized HYUNDAI dealer.
CAUTION
(cid:129) To avoid damage to the power steering pump,do not operate the vehicle for prolonged periods with a low power steering fluid level.
(cid:129) Never start the engine when the
reservoir tank is empty.
(cid:129) When adding fluid,be careful that
dirt does not get into the tank.
(cid:129) Too little fluid can result in increased steering effort and/or noise from the power steering system.
(cid:129) The use of the non-specified fluid could reduce the effectiveness of the power steering system and cause damage to it.
Use only the specified power steering fluid.(Refer to "Recommended lubricants or capacities" in section 8.)
G090200AEN Checking the power steering hose Check the connections for oil leaks, dam- age and twists in the power steering hose before driving.
WASHER FLUID
OBH078008
G120100AUN Checking the washer fluid level The reservoir is translucent so that you can check the level with a quick visual inspection. Check the fluid level in the washer fluid reservoir and add fluid if necessary. Plain water may be used if washer fluid is not available. However, use washer solvent with antifreeze characteristics in cold cli- mates to prevent freezing.
WARNING - Coolant
(cid:129) Do not use radiator coolant or antifreeze in the washer fluid reservoir.
(cid:129) Radiator coolant can severely obscure visibility when sprayed on the windshield and may cause loss of vehicle control or damage to paint and body trim.
(cid:129) Windshield washer fluid agents contain some amounts of alcohol and can be flammable under cer- tain circumstances. Do not allow sparks or flame to contact the washer fluid or the washer fluid reservoir. Damage to the vehicle or occupants could occur.
(cid:129) Windshield washer fluid is poi- sonous to humans and animals. Do not drink and avoid contacting windshield washer fluid. Serious injury or death could occur.
Maintenance
AUTOMATIC TRANSMISSION FLUID G100100ABH It is recommended that the automatic transmission fluid should be checked by an authorized HYUNDAI dealer. In severe conditions, the fluid should be changed at an authorized HYUNDAI dealer in accordance to the scheduled maintenance at the beginning of this chapter.
CAUTION
The use of a non-specified fluid could result in transmission mal- function and failure. Use only specified automatic trans- mission to “Recommended lubricants and capacities”in section 8.)
(Refer
fluid.
7 21
Maintenance
FOOT PARKING BRAKE (IF EQUIPPED)
AIR CLEANER 3.8L
3.8L
4.6L
OBH058009
OBH078010L
4.6L
OBH078011
G140100ABH Checking the parking brake Check whether the stroke is within spec- ification when the parking brake pedal is depressed with 44 lb (20 kg, 196 N) of force. Also, the parking brake alone should securely hold the vehicle on a fair- ly steep grade. If the stroke is more or less than specified, have the parking brake adjusted by an authorized HYUNDAI dealer.
Stroke : 3 notch
22
OBH078010N
G160100ABH-EU Filter replacement It must be replaced when necessary, and should not be cleaned and reused.
OBH078011N 1. Loosen the air cleaner cover attaching
clips and open the cover.
Replace the filter according to the Maintenance Schedule. If the vehicle is operated in extremely dusty or sandy areas, replace the ele- ment more often than the usual recom- mended to “Maintenance under severe usage condi- tions”in this section.)
intervals.
(Refer
OBH078013
2. Replace the air cleaner filter. 3. Lock the cover with the cover attaching
clips.
CAUTION
(cid:129) Do not drive with the air cleaner removed;this will result in exces- sive engine wear.
(cid:129) When removing the air cleaner fil- ter, be careful that dust or dirt does not enter the air intake, or damage may result.
(cid:129) Use a HYUNDAI genuine part.Use of non-genuine parts could dam- age the air flow sensor.
Maintenance
CLIMATE CONTROL AIR FIL- TER G170100AEN Filter inspection The climate control air filter should be replaced every 15,000 miles (24,000
km). If the vehicle is operated in severely air-polluted cities or on dusty rough roads for a long period, it should be inspected more frequently and replaced earlier. When you replace the climate control air filter, replace it performing the following procedure, and be careful to avoid damaging other components.7 23
Maintenance
OBH078015
G170200ABH Filter replacement 1. With the glove box open, remove the stoppers on both sides to allow the glove box to hang freely on the hinges.
OBH078016
2. Remove the climate control air filter case pulling out both sides of the cover.OBH078017
3. Replace the climate control air filter. 4. Reassemble in the reverse order of
disassembly.
✽✽ NOTICE When replacing the climate control air filter install it properly. Otherwise, the system may produce noise and the effec- tiveness of the filter may be reduced.
24
WIPER BLADES
1JBA5122
G180100AUN Blade inspection ✽✽ NOTICE Commercial hot waxes applied by auto- matic car washes have been known to make the windshield difficult to clean.
Maintenance
Contamination of either the windshield or the wiper blades with foreign matter can reduce the effectiveness of the wind- shield wipers. Common sources of con- tamination are insects, tree sap, and hot wax treatments used by some commer- cial car washes. If the blades are not wip- ing properly, clean both the window and the blades with a good cleaner or mild detergent, and rinse thoroughly with clean water.
CAUTION
To prevent damage to the wiper blades, do not use gasoline, kerosene, paint thinner, or other solvents on or near them.
G180200AUN Blade replacement When the wipers no longer clean ade- quately, the blades may be worn or cracked, and require replacement.
CAUTION
To prevent damage to the wiper arms or other components, do not attempt to move the wipers manual- ly.
CAUTION
The use of a non-specified wiper blade could result in wiper malfunc- tion and failure.
7 25
Maintenance
OBH079041
OBH078042
G180201ABH-EU Front windshield wiper blade For your convenience, move the wind- shield wiper blades to the service posi- tion as follows; 1. Remove the key from the ignition
switch or turn off the engine.
2. Move the wiper switch to the single wiping position (MIST) and hold the switch until the wiper arm is in the fully up position.
3. Raise the wiper arm.
CAUTION
Do not allow the wiper arm to fall against the windshield,since it may chip or crack the windshield.
OBH078043
4. Press the button and pull the bladeassembly upward.
26
OBH078044
5. Install the blade assembly in thereverse order of removal.
6. Return the wiper arm on the wind-
shield.
7. Turn the ignition switch to the ON posi-
tion.
8. Move the wiper switch to any position
and then to the OFF position.
Maintenance
7 27
Maintenance
BATTERY
OBH078018
G190100BBH-EU For best battery service The battery is in the trunk. (cid:129) Keep the battery securely mounted. (cid:129) Keep the battery top clean and dry. (cid:129) Keep the terminals and connections clean, tight, and coated with petroleum jelly or terminal grease.
(cid:129) Rinse any spilled electrolyte from the battery immediately with a solution of water and baking soda.
28
WARNING - Battery dangers
Always read the following
