Login- Download PDF Manual
-
Natural 15 Amp Blue
20 Amp Yellow
Description
Power Ignition Run — Adjustable Pedals LED Power-IGN Run — HVAC — Cabin Compartment Node (CCN) Illumi- nation Audio_Amplifier
Variable Gate Turbo (VGT) — Turbo Die- sel Power Outlet IP
368 MAINTAINING YOUR VEHICLE
Cavity Cartridge
Fuse
39
40
41
4230 Amp Pink
Mini Fuse 10 Amp Red
20 Amp Yellow
—
Description
Seatbelt Tension Reducer/Power IGN Run/Acc Power IGN Run/Acc — Cigar Lighter/Rear Power Point — Diesel PCM (Diesel Only)
CAUTION!
• When installing the Integrated Power Module cover, it is important to ensure the cover is prop- erly positioned and fully latched. Failure to do so may allow water to get into the Integrated Power Module, and possibly result in a electrical system failure. • When replacing a blown fuse, it is important to use only a fuse having the correct amperage rating. The use of a fuse with a rating other than indicated may result in a dangerous electrical system over- load. If a properly rated fuse continues to blow, it indicates a problem in the circuit that must be corrected.
VEHICLE STORAGE If you are storing your vehicle for more than 21 days, we recommend that you take the following steps to mini- mize the drain on your vehicle’s battery: • Disconnect the Ignition-Off Draw (IOD) fuse located in the Integrated Power Module, located in the engine compartment. The IOD cavity includes a snap-in re- tainer that allows the fuse to be disconnected without removing it from the fuse block. • The electronic shift transfer case should be placed in the 4HI mode and kept in this position to minimize the battery drain. • As an alternative to the above steps you may discon- • Any time you store your vehicle or keep it out of service (i.e., vacation) for two weeks or more, run the air conditioning system at idle for about five minutes
nect the negative cables from both batteries.
MAINTAINING YOUR VEHICLE 369
in the fresh air and high blower setting. This will ensure adequate system lubrication to minimize the possibility of compressor damage when the system is started again.
NOTE: • When reinstalling the IOD fuse push firmly until fully seated; the gauges in the instrument cluster will do a full sweep when the ignition key is cycled to RUN. This is a normal condition. • When the vehicle is shipped from the factory, the IOD fuse is in the up or extracted position. If the radio, interior lamps, keyless entry or other features do not work with the key OFF, check the position of the fuse (or check to see if the fuse is blown) to ensure that it is fully seated. When the IOD fuse is extracted, the instrument cluster in the odometer window will dis- play ⬙NO FUSE.”
BULB REPLACEMENT
Headlight (Halogen)/Front Park and Turn Lights
CAUTION!
This is a halogen bulb. Avoid touching the glass with your fingers. Reduced bulb life will result.
370 MAINTAINING YOUR VEHICLE
REPLACEMENT LIGHT BULBS
LIGHT BULBS — Inside Bulb No. Overhead Console Lights . . . . . . . . . . . . . . . TS 212-2
Dome Light. . . . . . . . . . . . . . . . . . . . . . . . . . . . 7679
NOTE: For lighted switches, see your authorized dealer for replacement instructions. All of the inside bulbs are brass or glass-wedge base. Aluminum base bulbs are not approved.Bulb No. LIGHT BULBS — Exterior Backup . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1156
Fog Light . . . . . . . . . . . . . . . . . . . . . . . . . . . 9006LL Headlight (Halogen) . . . . . . . . . . . . . . . . . . . . . . H13
Side Marker, Park & Turn Signal . . . . . . . . . . . . . 1157
Rear License Plate Lamp. . . . . . . . . . . . . . . . . . . 1157
Rear Cargo Light. . . . . . . . . . . . . . . . . . . . . . . . . 912
Tail & Stop . . . . . . . . . . . . . . . . . . . . . . . . . . . . 11571. Open the hood. 2. Remove the two bolts from the front of the headlight housing.
MAINTAINING YOUR VEHICLE 371
3. Remove the plug from the inner fender well.
372 MAINTAINING YOUR VEHICLE
4. Remove the nut through the access hole.
NOTE: For easier removal, pull the headlight assembly straight forward, applying the greatest amount of force to the outer edge of the headlight assembly.
5. Pull the housing out from the fender to allow room to disconnect the electrical connectors.
6. Unlock and pull connector straight from the base of the headlight halogen bulb.
MAINTAINING YOUR VEHICLE 373
7. Twist connector on the side marker/turn signal/park light bulb 1⁄4 turn and remove connector and bulb from housing. 8. Remove housing from vehicle with headlight halogen bulb in housing. 9. Twist the headlight halogen bulb 1⁄4 turn and remove headlight bulb from the housing. 10. Replace headlight or side marker/turn signal/park light bulb. Do not touch the headlight halogen bulb. 11. Reverse procedure for installation of bulbs and housing.
374 MAINTAINING YOUR VEHICLE
Fog Lights
1. Reach under the vehicle, unlock and twist connector counterclockwise 1⁄4 turn and remove connector and bulb from housing.
3. Reverse procedure for housing.
installation of bulbs and
2. Pull bulb straight from the connector.
Cab Top Clearance Lights — If Equipped
1. Remove the two screws from the top of the light.
2. Rotate the socket 1⁄4 turn and pull it from the light assembly.
MAINTAINING YOUR VEHICLE 375
376 MAINTAINING YOUR VEHICLE
3. Pull the bulb straight from its socket and replace.
FLUID AND CAPACITIES
Fuel (Approximate) Standard Rear Tank Optional Midship Tank Engine Oil with Filter 5.7L Engine (SAE 5W-20, API Certified) (For vehicles operating under a gross combined weight rating less than 14,000 lbs.) 5.7L Engine (SAE 5W-30, API Certified) (For vehicles operating under a gross combined weight rating greater than 14,000 lbs.) Cooling System 5.7L Engine (MOPAR威 Antifreeze/Coolant 5
Year/100,000 Mile Formula) or equivalent.MAINTAINING YOUR VEHICLE 377
U.S.
52 Gallons 22 Gallons
7 Quarts
7 Quarts
Metric
197 Liters 83 Liters
6.6 Liters
6.6 Liters
18.7 Quarts
17.7 Liters
378 MAINTAINING YOUR VEHICLE
FLUIDS, LUBRICANTS AND GENUINE PARTS
Engine Component Engine Coolant
Engine Oil (5.7L Engine) (For ve- hicles operating under a gross com- bined weight rating less than 14,000 lbs.) Engine Oil (5.7L Engine) (For ve- hicles operating under a gross com- bined weight rating greater than 14,000 lbs.) Engine Oil Filter (5.7L Engine) Spark Plugs (5.7L Engine) Fuel Selection (5.7L Engine)
Fluid, Lubricant, or Genuine Part Antifreeze/Coolant 5–Year/100,000 Mile Formula HOAT (Hybrid Organic Additive Technology) Use API Certified SAE 5W-20 Engine Oil, meeting the requirements of Chrysler Material Standard MS-6395. Refer to your engine oil filler cap for correct SAE grade.
Use API Certified SAE 5W-30 Engine Oil, meeting the requirements of Chrysler Material Standard MS-6395. Refer to your engine oil filler cap for correct SAE grade.
MOPAR威 Engine Oil Filter (P/N 04884899AB) or equivalent. LZFR5C–11 (Gap 0.043 in [1.09 mm]) 87 Octane Acceptable - 89 Octane Recommended
MAINTAINING YOUR VEHICLE 379
Chassis Component Automatic Transmission (5-Speed 545RFE) Transfer Case Front and Rear Axle Fluid (4500/ 5500) Brake Master Cylinder
Power Steering Reservoir
Fluid, Lubricant, or Genuine Part MOPAR威 ATF+4 Automatic Transmission Fluid
MOPAR威 ATF+4 Automatic Transmission Fluid GL-5 SAE 75W-90 Synthetic (MS-9763) or equivalent.
MOPAR威 DOT 3 and SAE J1703 should be used or equivalent. If DOT 3
brake fluid is not available, then DOT 4 is acceptable. Use only recom- mended brake fluids. MOPAR威 ATF+4 Automatic Transmission FluidMAINTENANCE SCHEDULES
CONTENTS
䡵 Emissions Control System Maintenance . . . . . . 382
䡵 Maintenance Schedule . . . . . . . . . . . . . . . . . . 382▫ 5.7L Gas Engine . . . . . . . . . . . . . . . . . . . . . 382
M
382 MAINTENANCE SCHEDULES
EMISSIONS CONTROL SYSTEM MAINTENANCE The Scheduled Maintenance services listed in bold type must be done at the times or mileages specified to ensure the continued proper functioning of the emissions control system. These and all other maintenance services in- cluded in this manual, should be done to provide best vehicle performance and reliability. More frequent main- tenance may be needed for vehicles in severe operating conditions, such as dusty areas and very short trip driving. Inspection and service should also be done anytime a malfunction is suspected. NOTE: Maintenance, replacement or repair of the emis- sions control devices and systems on your vehicle may be performed by any automotive repair establishment or individual using any automotive part that has been certified pursuant to U.S. EPA or in the State of Califor- nia, California Air Resources Board regulations.
MAINTENANCE SCHEDULE
5.7L Gas Engine The oil change indicator system will remind you that it is time to take your vehicle in for scheduled maintenance. The “Change Oil” message will flash in the instrument cluster odometer and a single chime will sound, indicat- ing that an oil change is necessary. Based on engine operation conditions the oil change indicator message will illuminate, this means that service is required for your vehicle. Have your vehicle serviced as soon as possible, within the next 500 miles (805 km). NOTE: • The oil change indicator message will not monitor the time since the last oil change. Change your vehicles oil if it has been 6 months since your last oil change even if the oil change indicator message is NOT illumi- nated.
vehicle off-road for an extended period of time.
• Change your engine oil more often if you drive your • Under no circumstances should oil change intervals exceed 6,000 miles (10,000 km) or 6 months, whichever comes first.
Your dealer will reset the oil change indicator message after completing the scheduled oil change. If this sched- uled oil change is performed by someone other than your dealer the message can be reset by referring to the steps described under “Odometer/Trip Odometer” under “In- strument Cluster Description” in Section 4 of this. At Each Stop for Fuel • Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accu- racy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark.
• Check the windshield washer solvent and add if
MAINTENANCE SCHEDULES 383
required.
damage.
Once a Month • Check tire pressure and look for unusual wear or • Inspect the battery and clean and tighten the terminals • Check the fluid levels of coolant reservoir, brake master cylinder, power steering and transmission and add as needed. • Check all lights and other electrical items for correct
as required.
operation.
Required Maintenance Intervals Refer to the Maintenance Schedules on the following pages for the required maintenance intervals.
384 MAINTENANCE SCHEDULES
At Each Oil Change • Change the engine oil filter. • Inspect the brake hoses and lines. • Lubricate outer tie rod ends.
CAUTION!
Failure to perform the required maintenance items may result in damage to the vehicle.
6,000 Miles (10,000 km) or 6 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
MAINTENANCE SCHEDULES 385
12,000 Miles (20,000 km) or 12 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the CV joints. Perform the first inspection at 12,000 miles (20 000 km) or
12 months.
❏ Inspect exhaust system. Perform the first inspection at 12,000 miles (20 000 km) or
12 months.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
M
386 MAINTENANCE SCHEDULES
18,000 Miles (30,000 km) or 18 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the front & rear axle fluid.
Change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
24,000 Miles (40,000 km) or 24 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lubricate outer tie rod ends. ❏ Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Inspect the CV joints. ❏ Inspect exhaust system.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 387
30,000 Miles (50,000 km) or 30 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Replace the engine air cleaner filter. ❏ Replace the spark plugs (5.7L engine). ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the transfer case fluid.
36,000 Miles (60,000 km) or 36 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the front & rear axle fluid. Change if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
M
388 MAINTENANCE SCHEDULES
42,000 Miles (70,000 km) or 42 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
48,000 Miles (80,000 km) or 48 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lubricate outer tie rod ends. ❏ Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Inspect the CV Joints. ❏ Inspect exhaust system.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 389
54,000 Miles (90,000 km) or 54 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the front & rear axle fluid.
Change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
60,000 Miles (100,000 km) or 60 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ Replace the engine air cleaner filter. ❏ Replace the spark plugs (5.7L engine). ❏ Inspect the brake linings, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Change the automatic transmission fluid & filter(s) if using your vehicle for any of the
following: police, taxi, fleet or frequent trailer towing.
❏ Inspect the transfer case fluid, add if necessary. ❏ Flush and replace the engine coolant at 60 months if not done at 102,000 miles
(170 000 km).
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
M
390 MAINTENANCE SCHEDULES
66,000 Miles (110,000 km) or 66 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
72,000 Miles (120,000 km) or 72 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lubricate outer tie rod ends. ❏ Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Inspect the front & rear axle fluid. Change if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
❏ Inspect the CV Joints. ❏ Inspect exhaust system.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
78,000 Miles (130,000 km) or 78 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
84,000 Miles (140,000 km) or 84 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ If using your vehicle for any of the
following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
❏ Inspect the brake linings, replace if
necessary.
❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
Odometer Reading
Date
Odometer Reading
Repair Order #
Dealer Code
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
MAINTENANCE SCHEDULES 391
M
392 MAINTENANCE SCHEDULES
90,000 Miles (150,000 km) or 90 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ Replace the engine air cleaner filter. ❏ Replace the spark plugs (5.7L engine). ❏ Inspect and replace PCV valve if necessary. † ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the front & rear axle fluid. Change if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
❏ Inspect the transfer case fluid.
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
96,000 Miles (160,000 km) or 96 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lubricate outer tie rod ends. ❏ Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Inspect the CV Joints. ❏ Inspect exhaust system.
MAINTENANCE SCHEDULES 393
102,000 Miles (170,000 km) or 102 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Flush and replace the engine coolant if
not done at 60 months.
❏ Flush and replace power steering fluid.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
M
394 MAINTENANCE SCHEDULES
108,000 Miles (180,000 km) or 108 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the front & rear axle fluid. Change if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
114,000 Miles (190,000 km) or 114 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
120,000 Miles (200,000 km) or 120 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ Replace the engine air cleaner filter. ❏ Replace the spark plugs (5.7L engine). ❏ Inspect the brake linings, replace if necessary. ❏ Lubricate outer tie rod ends. ❏ Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Inspect the CV Joints. ❏ Inspect exhaust system. ❏ Inspect the transfer case fluid, change if using your vehicle for any of the following: fleet,
off-road, or frequent trailer towing.
❏ Change the automatic transmission fluid & filter(s). ❏ Replace accessory drive belt(s).
MAINTENANCE SCHEDULES 395
126,000 Miles (210,000 km) or 126 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the front & rear axle fluid.
Change if using your vehicle for police, taxi, fleet, off-road or frequent trailer towing.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
M
396 MAINTENANCE SCHEDULES
132,000 Miles (220,000 km) or 132 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ If using your vehicle for any of the
following: Dusty or off-road conditions. Inspect the engine air cleaner filter, replace if necessary.
❏ Inspect the brake linings, replace if
necessary.
❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
138,000 Miles (230,000 km) or 138 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends.
Odometer Reading
Date
Odometer Reading
Repair Order #
Dealer Code
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
144,000 Miles (240,000 km) or 144 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil filter. ❏ Rotate tires. ❏ If using your vehicle for any of the following: Dusty or off-road conditions. Inspect the
engine air cleaner filter, replace if necessary. ❏ Inspect the brake linings, replace if necessary. ❏ Lubricate outer tie rod ends. ❏ Inspect the front suspension, tie rod ends, and boot seals, replace if necessary. ❏ Lube front drive shaft fitting (4x4 only). ❏ Inspect the front & rear axle fluid. Change if using your vehicle for police, taxi, fleet,
off-road or frequent trailer towing.
❏ Inspect the CV Joints. ❏ Inspect exhaust system.
MAINTENANCE SCHEDULES 397
150,000 Miles (250,000 km) or 150 Months Maintenance Service Schedule ❏ Change the engine oil and engine oil
filter.
❏ Rotate tires. ❏ Replace the engine air cleaner filter. ❏ Replace the spark plugs (5.7L engine). ❏ Lube front drive shaft fitting (4x4 only). ❏ Lubricate outer tie rod ends. ❏ Inspect the transfer case fluid.
Odometer Reading
Repair Order #
Date
Dealer Code
Odometer Reading
Repair Order #
Date
Dealer Code
Signature Authorized Chrysler Dealer
Signature Authorized Chrysler Dealer
398 MAINTENANCE SCHEDULES
† This maintenance is recommended by the manufacturer to the owner, but is not required to maintain emissions warranty.
WARNING!
You can be badly injured working on or around a motor vehicle. Do only that service work for which you have the knowledge and the right equipment. If you have any doubt about your ability to perform a service job, take your vehicle to a competent me- chanic.
IF YOU NEED CONSUMER ASSISTANCE
CONTENTS
䡵 Suggestions For Obtaining Service For Your
Vehicle. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 401
▫ Prepare For The Appointment . . . . . . . . . . . 401
▫ Prepare A List . . . . . . . . . . . . . . . . . . . . . . 401
▫ Be Reasonable With Requests . . . . . . . . . . . . 401
. . . . . . . . . . . . . . . . . 401
▫ Chrysler LLC Customer Center . . . . . . . . . . 402
▫ Chrysler Canada Inc. Customer Center . . . . . 402
▫ In Mexico Contact . . . . . . . . . . . . . . . . . . . . 402䡵 If You Need Assistance
▫ Customer Assistance For The Hearing Or
▫ Service Contract
Speech Impaired (TDD/TTY) . . . . . . . . . . . . 403
. . . . . . . . . . . . . . . . . . . . . 403
䡵 Warranty Information (U.S. Vehicles Only) . . . . 404
䡵 MOPAR威 Parts . . . . . . . . . . . . . . . . . . . . . . . 404
䡵 Reporting Safety Defects . . . . . . . . . . . . . . . . 404▫ In The 50 United States And Washington,
D.C. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 404
▫ In Canada . . . . . . . . . . . . . . . . . . . . . . . . . 405400 IF YOU NEED CONSUMER ASSISTANCE
䡵 Publication Order Forms 䡵 Department Of Transportation Uniform Tire
. . . . . . . . . . . . . . . . 405
Quality Grades . . . . . . . . . . . . . . . . . . . . . . . . 406
▫ Treadwear . . . . . . . . . . . . . . . . . . . . . . . . . 407▫ Traction Grades . . . . . . . . . . . . . . . . . . . . . 407
▫ Temperature Grades . . . . . . . . . . . . . . . . . . 408SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE
Prepare For The Appointment If you’re having warranty work done, be sure to have the right papers with you. Take your warranty folder. All work to be performed may not be covered by the warranty. Discuss additional charges with the service manager. Keep a maintenance log of your vehicle’s service history. This can often provide a clue to the current problem. Prepare A List Make a written list of your vehicle’s problems or the specific work you want done. If you’ve had an accident or work done that is not on your maintenance log, let the service advisor know. Be Reasonable With Requests If you list a number of items and you must have your vehicle by the end of the day, discuss the situation with
IF YOU NEED CONSUMER ASSISTANCE 401
the service advisor and list the items in order of priority. At many authorized dealers, you may obtain a rental vehicle at a minimal daily charge. If you need a rental, it is advisable to make these arrangements when you call for an appointment.
IF YOU NEED ASSISTANCE The manufacturer and its authorized dealers are vitally interested in your satisfaction. We want you to be happy with our products and services. Warranty service must be done by an authorized dealer. We strongly recommend that you take the vehicle to an authorized dealer. They know you and the vehicle best, and are most concerned that you get prompt and high quality service. The manufacturer’s authorized dealers have the facilities, factory-trained technicians, special tools, and the latest information to ensure the vehicle is fixed correctly and in a timely manner.
402 IF YOU NEED CONSUMER ASSISTANCE
This is why you should always talk to an authorized dealer’s service manager first. Most matters can be re- solved with this process. • If for some reason you are still not satisfied, talk to the general manager or owner of the authorized dealer- ship. They want to know if you need assistance. • If an authorized dealership is unable to resolve the concern, you may contact the manufacturer’s customer center.
Any communication to the manufacturer’s customer cen- ter should include the following information: • Owner’s name and address • Owner’s telephone number (home and office) • Authorized dealership name • Vehicle Identification Number (VIN)
• Vehicle delivery date and mileage Chrysler LLC Customer Center P.O. Box 21–8004
Auburn Hills, MI 48321–8004
Phone: (800) 992-1997
Chrysler Canada Inc. Customer Center P.O. Box 1621
Windsor, Ontario N9A 4H6
Phone: (800) 465–2001
In Mexico contact: Av. Prolongacion Paseo de la Reforma, 1240
Sante Fe C.P. 05109
Mexico, D. F. In Mexico City: 5081-7568
Outside Mexico City: 1-800-505-1300Customer Assistance For The Hearing Or Speech Impaired (TDD/TTY) To assist customers who have hearing difficulties, the manufacturer has installed special TDD (Telecommuni- cation Devices for the Deaf) equipment at its customer center. Any hearing or speech impaired customer, who has access to a TDD or a conventional teletypewriter (TTY) in the United States, can communicate with the manufacturer by dialing 1–800–380–CHRY. Service Contract You may have purchased a service contract for a vehicle to help protect you from the high cost of unexpected repairs after the manufacturer’s New Vehicle Limited Warranty expires. The manufacturer stands behind only the manufacturer’s service contracts. If you purchased a manufacturer’s service contract, you will receive Plan Provisions and an Owner Identification Card in the mail within three weeks of the vehicle delivery date. If you
IF YOU NEED CONSUMER ASSISTANCE 403
have any questions about the service contract, call the manufacturer’s Service Contract National Customer Hot- line at 1-800-521-9922. The manufacturer will not stand behind any service contract that is not the manufacturer’s service contract. It is not responsible for any service contract other than the manufacturer’s service contract. If you purchased a ser- vice contract that is not a manufacturer’s service contract, and you require service after the manufacturer’s New Vehicle Limited Warranty expires, please refer to the contract documents, and contact the person listed in those documents. We appreciate that you have made a major investment when you purchased the vehicle. An authorized dealer has also made a major investment in facilities, tools, and training to assure that you are absolutely delighted with the ownership experience. You’ll be pleased with their sincere efforts to resolve any warranty issues or related concerns.
404 IF YOU NEED CONSUMER ASSISTANCE
WARNING!
Engine exhaust, some of its constituents, and certain vehicle components contain, or emit, chemicals known to the State of California to cause cancer and birth defects, or other reproductive harm. In addi- tion, certain fluids contained in vehicles and certain products of component wear contain, or emit, chemi- cals known to the State of California to cause cancer and birth defects, or other reproductive harm.
WARRANTY INFORMATION (U.S. Vehicles Only) See the Warranty Information Booklet for the terms and provisions of Chrysler Motors LLC warranties applicable to this vehicle.
MOPAR姞 PARTS Mopar威 fluids, lubricants, parts, and accessories are available from an authorized dealer. They will help keep the vehicle operating at its best.
REPORTING SAFETY DEFECTS
In The 50 United States And Washington, D.C. If you believe that your vehicle has a defect that could cause a crash or cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA) in addition to notifying the manufacturer. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your authorized dealer, and the manufacturer.
To contact NHTSA, you may either call the Auto Safety Hotline toll free at 1–888–327–4236 (TTY: 1–800–424– 9153), or go to http://www.safercar.gov; or write to: Administra- tor, NHTSA, 400 Seventh Street, SW., Washington, D.C. 20590. You can also obtain other information about motor vehicle safety from http://www.safercar.gov. In Canada If you believe that your vehicle has a safety defect, you should contact the Customer Service Department imme- diately. Canadian customers who wish to report a safety defect to the Canadian government should write to: Transport Canada, Motor Vehicle Defect Investigations and Recalls, 2780 Sheffield Road, Ottawa, Ontario K1B 3V9.
IF YOU NEED CONSUMER ASSISTANCE 405
PUBLICATION ORDER FORMS To order the following manuals, you may use either the website or the phone numbers listed below. Visa, Mas- tercard, American Express, and Discover orders are ac- cepted. If you prefer mailing your payment, please call for an order form. NOTE: A street address is required when ordering manuals (no P.O. Boxes). • Service Manuals
These comprehensive Service Manuals provide the information that students and professional technicians need in diagnosing/troubleshooting, problem solving, maintaining, servicing, and repairing Chrysler LLC vehicles. A complete working knowledge of the ve- hicle, system, and/or components is written in straightforward language with illustrations, diagrams, and charts.
406 IF YOU NEED CONSUMER ASSISTANCE
• Diagnostic Procedure Manuals
Diagnostic Procedure Manuals are filled with dia- grams, charts and detailed illustrations. These practi- cal manuals make it easy for students and technicians to find and fix problems on computer-controlled ve- hicle systems and features. They show exactly how to find and correct problems the first time, using step-by- step troubleshooting and drivability procedures, proven diagnostic tests and a complete list of all tools and equipment. • Owner’s Manuals
These Owner’s Manuals have been prepared with the assistance of service and engineering specialists to acquaint you with specific Chrysler LLC vehicles. Included are starting, operating, emergency and main- tenance procedures as well as specifications, capabili- ties and safety tips.
Call toll free at: • 1–800–890–4038 (U.S.) • 1–800–387–1143 (Canada) Or Visit us on the Worldwide Web at: • www.techauthority.com
DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES The following tire grading categories were established by the National Highway Traffic Safety Administration. The specific grade rating assigned by the tire’s manufacturer in each category is shown on the sidewall of the tires on your vehicle. All passenger car tires must conform to Federal safety requirements in addition to these grades.
Treadwear The Treadwear grade is a comparative rating, based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and one-half times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual conditions of their use, however, and may depart significantly from the norm due to variations in driving habits, service practices, and differences in road charac- teristics and climate.
IF YOU NEED CONSUMER ASSISTANCE 407
Traction Grades The Traction grades, from highest to lowest, are AA, A, B, and C. These grades represent the tire’s ability to stop on wet pavement, as measured under controlled conditions on specified government test surfaces of asphalt and concrete. A tire marked C may have poor traction perfor- mance.
WARNING!
The traction grade assigned to this tire is based on straight-ahead braking traction tests, and does not include acceleration, cornering, hydroplaning, or peak traction characteristics.
408 IF YOU NEED CONSUMER ASSISTANCE
Temperature Grades The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissipate heat, when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure. The grade C corresponds to a level of performance, which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No. 109. Grades B and A repre- sent higher levels of performance on the laboratory test wheel, than the minimum required by law.
WARNING!
The temperature grade for this tire is established for a tire that is properly inflated and not overloaded. Excessive speed, under-inflation, or excessive load- ing, either separately or in combination, can cause heat buildup and possible tire failure.
INDEX
10
410 INDEX
. . . . . . . . . . . . . . . . . . . . . . . . . . . 285
Adding Fuel Adjustable Pedals . . . . . . . . . . . . . . . . . . . . . . . 131
Air Cleaner, Engine (Engine Air Cleaner Filter) . . . 340
Air Conditioner Maintenance . . . . . . . . . . . . . . . 342
Air Conditioning Refrigerant . . . . . . . . . . . . . 342,343
Air Conditioning System . . . . . . . . . . . . . . . . 207,342
Air Conditioning System, Zone Control . . . . . . . . 210
. . . . . . . . . . . . . . . . . . . . 267,276
Air Pressure, Tires Airbag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 48,53
Airbag Light . . . . . . . . . . . . . . . . . . . . . . . . . 75,163
Airbag On/Off Switch . . . . . . . . . . . . . . . . . . . . . 53
Alarm Light . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
Alarm (Security Alarm) . . . . . . . . . . . . . . . . . . . . 19
Alarm System (Security Alarm) . . . . . . . . . . . . . . . 19
Alterations/Modifications, Vehicle . . . . . . . . . . . . . 7
Antenna, Satellite Radio . . . . . . . . . . . . . . . . . . . 200
Antifreeze (Engine Coolant) . . . . . . . . . . . . . . 349,350
. . . . . . . . . . . . . . . . . . . . . . . . . . . 377
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 352Capacities Disposal
. . . . . . . . . . . . . . . 170,257
Anti-Lock Warning Light Anti-Theft Security Alarm (Theft Alarm) . . . . . . . . 19
Anti-Theft System . . . . . . . . . . . . . . . . . . . . . . . . 19
Appearance Care . . . . . . . . . . . . . . . . . . . . . . . . 359
Ashtray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 145
Assistance Towing . . . . . . . . . . . . . . . . . . . . . . . 100
Automatic Dimming Mirror . . . . . . . . . . . . . . . . . 82
. . . . . . . . . . . . . . . . . . . . . . 12
Automatic Transaxle Automatic Transmission . . . . . . . . . . . . . . . . . . . 356
Fluid and Filter Changes . . . . . . . . . . . . . . . . . 358
Fluid Level Check . . . . . . . . . . . . . . . . . . . . . 357
Fluid Type . . . . . . . . . . . . . . . . . . . . . . . . 356,379
Shifting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Special Additives . . . . . . . . . . . . . . . . . . . . . . 359
Automatic Transmission (Diesel Engine Only) . . . . 356
Axle Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . 356,379
Axle Lubrication (Axle Fluid) . . . . . . . . . . . . . . . 356Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 341
INDEX 411
Emergency Starting . . . . . . . . . . . . . . . . . . . . . 326
Saving Feature (Protection) . . . . . . . . . . . . . . . 124
Belts, Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 36
Body Builders Guide . . . . . . . . . . . . . . . . . . . . . . . 6
Body Mechanism Lubrication . . . . . . . . . . . . . . . 343
B-Pillar Location . . . . . . . . . . . . . . . . . . . . . . . . 262
Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 379
Brake System . . . . . . . . . . . . . . . . . . . . . . . . 255,353
Anti-Lock (ABS) . . . . . . . . . . . . . . . . . . . . . . . 256
Fluid Check . . . . . . . . . . . . . . . . . . . . . . . . . . 353
Master Cylinder . . . . . . . . . . . . . . . . . . . . . . . 353
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 254
. . . . . . . . . . . . . . . . . . . . . . . . 168
Warning Light Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . 370
Bulbs, Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 370Cab Top Clearance Lights . . . . . . . . . . . . . . . . . . 375
Calibration, Compass . . . . . . . . . . . . . . . . . . . . . 141
Capacities, Antifreeze (Engine Coolant) . . . . . . . . 377Capacities, Fluid . . . . . . . . . . . . . . . . . . . . . . . . 377
Caps, FillerOil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . 339
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 253
. . . . . . . . . . . . . . . 351
Radiator (Coolant Pressure) Car Washes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 360
Carbon Monoxide Warning . . . . . . . . . . . . . . . . . 284
CD (Compact Disc) Player . . . . . . . . . . . . . . . 173,187
. . . . . . . . . . . . . . . . . . . . . . . . . . 86
Cellular Phone . . . . . . . . . . . . . . . . . . . . . . . . . 45
Center Lap Belts Center Seat Storage Compartment . . . . . . . . . 148,150
. . . . . . . . . . . . . . . . . . . . . . . 287
Certification Label Chart, Tire Sizing . . . . . . . . . . . . . . . . . . . . . . . . 259
Check Engine Light . . . . . . . . . . . . . . . 168
(Malfunction Indicator Light) Child Restraint . . . . . . . . . . . . . . . . . . . . . . . . . . 60
Child Restraint Tether Anchors . . . . . . . . . . . . . 64,67
Child Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . 60,66
Cigar Lighter . . . . . . . . . . . . . . . . . . . . . . . . . . . 14510
412 INDEX
Cleaning Wheels
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . 361
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . 204
Clock . . . . . . . . . . . . . . . . . . . . . . . . 172,175,189,195
Compact Disc (CD) Maintenance . . . . . . . . . . . . . 203
Compass . . . . . . . . . . . . . . . . . . . . . . . . . . . 140,141
Compass Calibration . . . . . . . . . . . . . . . . . . . . . 141
Compass Variance . . . . . . . . . . . . . . . . . . . . . . . 143
Computer, Trip/Travel . . . . . . . . . . . . . . . . . . . . 136
Contract, Service . . . . . . . . . . . . . . . . . . . . . . . . 403
Coolant Pressure Cap (Radiator Cap) . . . . . . . . . . 351
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . 348
Adding Coolant (Antifreeze) . . . . . . . . . . . . . . 350
Coolant Capacity . . . . . . . . . . . . . . . . . . . . . . 377
. . . . . . . . . . . . . . . . . . . . . . 348,352
Coolant Level Disposal of Used Coolant . . . . . . . . . . . . . . . . 352
Drain, Flush, and Refill . . . . . . . . . . . . . . . . . . 349
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . 352
Points to Remember . . . . . . . . . . . . . . . . . . . . 352Pressure Cap . . . . . . . . . . . . . . . . . . . . . . . . . 351
Radiator Cap . . . . . . . . . . . . . . . . . . . . . . . . . 351
Selection of Coolant (Antifreeze) . . . . . . . . . 349,378
. . . . . . . . . . . . . . 133
Cruise Control (Speed Control) Cupholders . . . . . . . . . . . . . . . . . . . . . . . . . . . . 146
Customer Assistance . . . . . . . . . . . . . . . . . . . . . 401. . . . . . . . . . . . . . . . . . . . . . 57
Data Recorder, Event Daytime Running Lights . . . . . . . . . . . . . . . . . . . 126
Dealer Service . . . . . . . . . . . . . . . . . . . . . . . . . . 337
Defroster, Rear Window . . . . . . . . . . . . . . . . . . . 153
Defroster, Windshield . . . . . . . . . . . . . . . . 74,205,208
Delay (Intermittent) Wipers . . . . . . . . . . . . . . . . . 129
Differential, Limited-Slip . . . . . . . . . . . . . . . . . . 249
Dipsticks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 338
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 253
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 340
Antifreeze (Engine Coolant) . . . . . . . . . . . . . . . 352
Engine Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . 340Disposal
Door Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
DrivingThrough Flowing, Rising, or Shallow Standing Water . . . . . . . . . . . . . . . . . . . . . . . . 250
Dual Rear Wheels . . . . . . . . . . . . . . . . . . . . . 280,322
DVD Player (Video Entertainment System™) . . . . 201. . . . . . . . . . . . . . . 153
Electric Rear Window Defrost Electrical Power Outlets . . . . . . . . . . . . . . . . . . . 144
Electronic Speed Control (Cruise Control) . . . . . . 133
Electronically Shifted Transfer Case . . . . . . . . 234,242
Emergency Brake . . . . . . . . . . . . . . . . . . . . . . . . 254
Emergency, In Case ofFreeing Vehicle When Stuck . . . . . . . . . . . . . . . 330
Hazard Warning Flasher . . . . . . . . . . . . . . . . . 314
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . 326
Tow Hooks . . . . . . . . . . . . . . . . . . . . . . . . . . 330
Towing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 331
Emission Control System Maintenance . . . . . . . . . 382INDEX 413
Engine
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 335
. . . . . . . . . . . . . . . . . . . . . . . . . . 340
Air Cleaner Block Heater . . . . . . . . . . . . . . . . . . . . . . . . . 223
Break-In Recommendations . . . . . . . . . . . . . . . . 72
Compartment Identification . . . . . . . . . . . . . . . 335
Coolant (Antifreeze) . . . . . . . . . . . . . . . . . . . . 378
Exhaust Gas Caution . . . . . . . . . . . . . . . . . . 73,284
Flooded, Starting . . . . . . . . . . . . . . . . . . . . . . 222
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . 326
Oil . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 338,378
Oil Filler Cap . . . . . . . . . . . . . . . . . . . . . . . . . 339
Oil Selection . . . . . . . . . . . . . . . . . . . . . . . . . . 339
. . . . . . . . . . . . . . . . . . . . . . . . . 340
Oil Synthetic . . . . . . . . . . . . . . . . . . . . 164
Temperature Gauge Event Data Recorder . . . . . . . . . . . . . . . . . . . . . . 57
Exhaust Gas Caution . . . . . . . . . . . . . . . . 73,284,345
Exhaust System . . . . . . . . . . . . . . . . . . . . . . . 73,345
Exterior Lighting . . . . . . . . . . . . . . . . . . . . . . . . 12510
414 INDEX
Fabric Care . . . . . . . . . . . . . . . . . . . . . . . . . . . . 361
FiltersAir Cleaner Engine Fuel Engine Oil
. . . . . . . . . . . . . . . . . . . . . . . . . . 340
. . . . . . . . . . . . . . . . . . . . . . . . . . 378
. . . . . . . . . . . . . . . . . . . . . 338,340,378Flashers
Turn Signal
. . . . . . . . . . . . . . . . . . . . . . . . . . 127
Flat Tire Stowage . . . . . . . . . . . . . . . . . . . . . . . . 326
Flooded Engine Starting . . . . . . . . . . . . . . . . . . . 222
Fluid, Brake . . . . . . . . . . . . . . . . . . . . . . . . . . . 379
Fluid Capacities . . . . . . . . . . . . . . . . . . . . . . . . . 377
Fluid Level ChecksBrake . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 353
Manual Transmission . . . . . . . . . . . . . . . . . . . 356
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 253
Transfer Case . . . . . . . . . . . . . . . . . . . . . . . . . 356
Fluids, Lubricants and Genuine Parts . . . . . . . . . . 378
Fog Lights . . . . . . . . . . . . . . . . . . . . . . . 126,167,374
Fold Flat Load Floor . . . . . . . . . . . . . . . . . . . . . 154Four Wheel Drive . . . . . . . . . . . . . . . . . . . . . . . 230
Four-Way Hazard Flasher . . . . . . . . . . . . . . . . . . 314
. . . . . . . . . . . . . . . . . . . 330
Freeing A Stuck Vehicle Front Axle (Differential) . . . . . . . . . . . . . . . . . . . 355
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 281
Fuel Adding . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 285
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 378
Diesel Filler Cap (Gas Cap) . . . . . . . . . . . . . . . . . . . . 286
Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 378
Gauge . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Octane Rating . . . . . . . . . . . . . . . . . . . . . . . . 281
Requirements . . . . . . . . . . . . . . . . . . . . . . . . . 281
Tank Capacity . . . . . . . . . . . . . . . . . . . . . . . . 377
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 364Fuses
. . . . . . . . . . . . . . . 286,336
Gas Cap (Fuel Filler Cap) Gasoline (Fuel) . . . . . . . . . . . . . . . . . . . . . . . . . 281
Gasoline, Reformulated . . . . . . . . . . . . . . . . . . . 281INDEX 415
Gauges . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
. . . . . . . . . . . . . . . . . . . 164
Coolant Temperature Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 171
Oil Pressure . . . . . . . . . . . . . . . . . . . . . . . . . . 164
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . 163
Tachometer . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Voltmeter . . . . . . . . . . . . . . . . . . . . . . . . . . . . 162
. . . . . . . . . . . . . . . . . . . . . . . . . . . 225
Gear Ranges General Information . . . . . . . . . . . . . . . . . . . . 18,114
Glass Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . 363
Grocery Bag Retainer . . . . . . . . . . . . . . . . . . . . . 153
Gross Axle Weight Rating . . . . . . . . . . . . . . . . . . 290
Gross Vehicle Weight Rating . . . . . . . . . . . . . . . . 289
Guide, Body Builders . . . . . . . . . . . . . . . . . . . . . . 6
GVWR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 287Hands-Free Phone (UConnect威)
. . . . . . . . . . . . . . 86
Hazard
Driving Through Flowing, Rising, or Shallow Standing Water . . . . . . . . . . . . . . . . . . . . . . . . 250
Hazard Warning Flasher . . . . . . . . . . . . . . . . . . . 314
Head Restraints . . . . . . . . . . . . . . . . . . . . . . . . . 117
Headlights . . . . . . . . . . . . . . . . . . . . . . . . . . . . 370
Cleaning . . . . . . . . . . . . . . . . . . . . . . . . . . . . 363
High Beam . . . . . . . . . . . . . . . . . . . . . . . . . . 128
High Beam/Low Beam Select Switch . . . . . . . . 128
Lights On Reminder . . . . . . . . . . . . . . . . . . . . 126
Passing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
Switch . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
Heated Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . 153
Heated Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . 120
Heater . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 207
Heater, Engine Block . . . . . . . . . . . . . . . . . . . . . 223
High Beam/Low Beam Select (Dimmer) Switch . . 12810
416 INDEX
Hitches
Trailer Towing . . . . . . . . . . . . . . . . . . . . . . . . 292
Hoisting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 326
Hood Release . . . . . . . . . . . . . . . . . . . . . . . . . . 121
Hub Caps . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 321Key
Ignition . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12
Ignition Key Removal . . . . . . . . . . . . . . . . . . . . . 12
Illuminated Entry . . . . . . . . . . . . . . . . . . . . . . . . 20
Immobilizer (Sentry Key) . . . . . . . . . . . . . . . . . . . 15
. . . . . . . . . . . . . . . . . . . . . . . . . . 60
Infant Restraint Inflation Pressure Tires . . . . . . . . . . . . . . . . . . . . 276
Inside Rearview Mirror . . . . . . . . . . . . . . . . . . . . 81
Instrument Cluster . . . . . . . . . . . . . . . . . . . . 161,162
Instrument Panel and Controls . . . . . . . . . . . . . . 160
Instrument Panel Lens Cleaning . . . . . . . . . . . . . 363
Integrated Power Module (Fuses) . . . . . . . . . . . . 364
Interior Appearance Care . . . . . . . . . . . . . . . . . . 362Interior Lights . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Intermittent Wipers (Delay Wipers) . . . . . . . . . . . 129
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 4Jack Location . . . . . . . . . . . . . . . . . . . . . . . . . . . 315
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . . . 326Key, Programming . . . . . . . . . . . . . . . . . . . . . . . . 17
Key, Replacement . . . . . . . . . . . . . . . . . . . . . . . . 16
Key, Sentry (Immobilizer) . . . . . . . . . . . . . . . . . . . 15
Keyless Entry System . . . . . . . . . . . . . . . . . . . . . . 21
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12. . . . . . . . . . . . . . 127
Lane Change and Turn Signals Lap Belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 45
Lap/Shoulder Belts . . . . . . . . . . . . . . . . . . . . . . . 36
LATCH (Lower Anchors and Tether for CHildren) . . . . . . . . . . . . . . . . . . . . . . 64
Life of Tires . . . . . . . . . . . . . . . . . . . . . . . . . . . . 274INDEX 417
Lights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 75,123
Airbag . . . . . . . . . . . . . . . . . . . . . . . . . . . . 57,163
Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 165
Anti-Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . 170
Anti-Lock Warning . . . . . . . . . . . . . . . . . . . . . 257
Brake Warning . . . . . . . . . . . . . . . . . . . . . . . . 168
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . 370
Cap Top Clearance . . . . . . . . . . . . . . . . . . . . . 375
Check Engine (Malfunction Indicator) . . . . . . . . 168
Cruise . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Daytime Running . . . . . . . . . . . . . . . . . . . . . . 126
Fog . . . . . . . . . . . . . . . . . . . . . . . . . . 126,167,374
Four-Wheel Drive Indicator . . . . . . . . . . . . . . . 234
Hazard Warning Flasher . . . . . . . . . . . . . . . . . 314
Headlights . . . . . . . . . . . . . . . . . . . . . . . . . . . 125
High Beam . . . . . . . . . . . . . . . . . . . . . . . . 128,163
High Beam Indicator . . . . . . . . . . . . . . . . . . . . 163
High Beam/Low Beam Select . . . . . . . . . . . . . 128
Illuminated Entry . . . . . . . . . . . . . . . . . . . . . . . 20. . . . . . . . . . . . . . . . . . . . . 162
Instrument Cluster Interior . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Lights On Reminder . . . . . . . . . . . . . . . . . . . . 126
Passing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
Seat Belt Reminder . . . . . . . . . . . . . . . . . . . . . 163
Security Alarm (Theft Alarm) . . . . . . . . . . . . . . 165
Service . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 370
Theft Alarm (Security Alarm) . . . . . . . . . . . . . . 165
Transfer Case . . . . . . . . . . . . . . . . . . . . . . . . . 234
Transmission Warning . . . . . . . . . . . . . . . . . . . 171
Turn Signal . . . . . . . . . . . . . . . . . . . . . 127,162,370
Warning (Instrument Cluster Description) . . . . . 162
Limited-Slip Differential . . . . . . . . . . . . . . . . 249,356
Loading Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . 287
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 262
Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Child Protection . . . . . . . . . . . . . . . . . . . . . . . . 30
Door . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 27
Keys . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 12Tires
10
418 INDEX
Power Door . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Steering Wheel . . . . . . . . . . . . . . . . . . . . . . . . . 14Lower Anchors and Tether for CHildren . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 64
(LATCH) Lubrication, Body . . . . . . . . . . . . . . . . . . . . . . . 343
Lug Nuts . . . . . . . . . . . . . . . . . . . . . . . . . . . 320,322
Lumbar Support . . . . . . . . . . . . . . . . . . . . . . . . 118Electric Powered . . . . . . . . . . . . . . . . . . . . . . . 83
Outside . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 82
Rearview . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Trailer Towing . . . . . . . . . . . . . . . . . . . . . . . . . 84
Modifications/Alterations, Vehicle . . . . . . . . . . . . . 7
Mopar Parts . . . . . . . . . . . . . . . . . . . . . . . . . 337,404
Multi-Function Control Lever . . . . . . . . . . . . . . . 126Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . 337
Maintenance Free Battery . . . . . . . . . . . . . . . . . . 341
Maintenance Procedures . . . . . . . . . . . . . . . . . . . 338
Maintenance Schedule . . . . . . . . . . . . . . . . . 382,384
Maintenance Schedules . . . . . . . . . . . . . . . . . . . . 382
Manual, Service . . . . . . . . . . . . . . . . . . . . . . . . . 405
Manual Transmission Fluid Level Check . . . . . . . . . . . . . . . . . . . . . 356
Lubricant Selection . . . . . . . . . . . . . . . . . . . . . 379
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Automatic Dimming . . . . . . . . . . . . . . . . . . . . . 82Navigation Radio . . . . . . . . . . . . . . . . . . . . . . . . 194
Navigation System . . . . . . . . . . . . . . . . . . . . . . . 194
New Vehicle Break-In Period . . . . . . . . . . . . . . . . 72Occupant Restraints . . . . . . . . . . . . . . . . . . . . . . . 35
Octane Rating, Gasoline (Fuel) . . . . . . . . . . . . . . 281
. . . . . . . . . . . . . . . . . . . . . . . . . . 166,171
Odometer Trip . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 166,171
Oil Change Indicator . . . . . . . . . . . . . . . . . . . . . 167
Oil, Engine . . . . . . . . . . . . . . . . . . . . . . . . . . . . 378
Capacity . . . . . . . . . . . . . . . . . . . . . . . . . . . . 377INDEX 419
Change Interval . . . . . . . . . . . . . . . . . . . . . . . 339
Dipstick . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 338
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 340
Disposal Filter . . . . . . . . . . . . . . . . . . . . . . . . . 338,340,378
Identification Logo . . . . . . . . . . . . . . . . . . . . . 339
Materials Added to . . . . . . . . . . . . . . . . . . . . . 340
Pressure Gauge . . . . . . . . . . . . . . . . . . . . . . . 164
Recommendation . . . . . . . . . . . . . . . . . . . . . . 339
Synthetic . . . . . . . . . . . . . . . . . . . . . . . . . . . . 340
Viscosity . . . . . . . . . . . . . . . . . . . . . . . . . . . . 339
Onboard Diagnostic System . . . . . . . . . . . . . . . . 336
Operating Precautions . . . . . . . . . . . . . . . . . . . . 336
Operator Manual (Owner’s Manual) . . . . . . . . . . . . 4
Outside Rearview Mirrors . . . . . . . . . . . . . . . . . . 82
Overdrive . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 227
Overdrive OFF Switch . . . . . . . . . . . . . . . . . . . . 227
Overhead Console . . . . . . . . . . . . . . . . . . . . . . . 136
Overhead Travel Information Center . . . . . . . . . . 136
Overheating, Engine . . . . . . . . . . . . . . . . . . . . . . 165Owner’s Manual (Operator Manual)
. . . . . . . . . 4,405
Parking Brake . . . . . . . . . . . . . . . . . . . . . . . . . . 254
Passenger Airbag On/Off Switch . . . . . . . . . . . . . 53
Passing Light . . . . . . . . . . . . . . . . . . . . . . . . . . . 128
Pedals, Adjustable . . . . . . . . . . . . . . . . . . . . . . . 131
Pets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 72
Pets, Transporting . . . . . . . . . . . . . . . . . . . . . . . . 72
. . . . . . . . . . . . . . . . . . . . . . . . . . 86
Phone, Cellular Phone, Hands-Free (UConnect威) . . . . . . . . . . . . . . 86
Placard, Tire and Loading Information . . . . . . . . . 262
PowerDoor Locks . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Mirrors . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 83
Outlet (Auxiliary Electrical Outlet) . . . . . . . . . . 144
Seats . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 118
Sliding Rear Window . . . . . . . . . . . . . . . . . 34,154
Steering . . . . . . . . . . . . . . . . . . . . . . . . . . 252,253
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3210
420 INDEX
Power Steering Fluid . . . . . . . . . . . . . . . . . . . . . 379
Pregnant Women and Seat Belts . . . . . . . . . . . . . . 47
Programming Transmitters (Remote Keyless Entry). . . . . . . . . . . . . . . . . . . . 24
Radial Ply Tires . . . . . . . . . . . . . . . . . . . . . . . . . 272
Radiator Cap (Coolant Pressure Cap) . . . . . . . 348,351
Radio, Navigation . . . . . . . . . . . . . . . . . . . . . . . 194
Radio Operation . . . . . . . . . . . . . . . . . . . . . . 173,187
Radio Remote Controls . . . . . . . . . . . . . . . . . . . . 201
Radio, Satellite . . . . . . . . . . . . . . . . . . . . . . . 195,197
Radio (Sound Systems) . . . . . . . . . . . . . . . . . 173,187
Rear Axle (Differential) . . . . . . . . . . . . . . . . . 355,356
Rear Window Features . . . . . . . . . . . . . . . . . . . . 153
Rear Window, Sliding . . . . . . . . . . . . . . . . . . . 34,154
Reclining Front Seats . . . . . . . . . . . . . . . . . . . . . 116
Recorder, Event Data . . . . . . . . . . . . . . . . . . . . . . 57
Recreational Towing . . . . . . . . . . . . . . . . . . . . . . 304
. . . . 305,307Shifting into Transfer Case Neutral (N)
Shifting out of Transfer Case Neutral (N)
. . . . . . . . . . . . . . . . . . . . . . . 306,309
Reformulated Gasoline . . . . . . . . . . . . . . . . . . . . 281
Refrigerant . . . . . . . . . . . . . . . . . . . . . . . . . . . . 343
Reminder, Seat Belt . . . . . . . . . . . . . . . . . . . . . . . 46
Remote Keyless Entry (RKE) . . . . . . . . . . . . . . . . . 21
Remote Sound System (Radio) Controls . . . . . . . . 201
Remote Starting System . . . . . . . . . . . . . . . . . . . . 26
Replacement Keys . . . . . . . . . . . . . . . . . . . . . . . . 16
Replacement Parts . . . . . . . . . . . . . . . . . . . . . . . 337
Replacement Tires . . . . . . . . . . . . . . . . . . . . . . . 274
Reporting Safety Defects . . . . . . . . . . . . . . . . . . . 404
Resetting Oil Change Indicator . . . . . . . . . . . . . . 167
Restraint, Head . . . . . . . . . . . . . . . . . . . . . . . . . 117
Restraints, Child . . . . . . . . . . . . . . . . . . . . . . . 60,66
Restraints, Occupant . . . . . . . . . . . . . . . . . . . . . . 35
Rotation, Tires . . . . . . . . . . . . . . . . . . . . . . . . . . 279Safety Checks Inside Vehicle . . . . . . . . . . . . . . . . . 74
Safety Checks Outside Vehicle . . . . . . . . . . . . . . . 75
Safety Defects, Reporting . . . . . . . . . . . . . . . . . . 404
Safety Information, Tire . . . . . . . . . . . . . . . . . . . 258
