2004 Dodge Durango Owners Manual

system is serviced or at intervals specified. Inspect hy- draulic brake hoses for surface cracking, scuffing or worn spots. If there is any evidence of cracking, scuffing, or worn spots, the hose should be replaced immediately! Eventual deterioration of the hose can take place with possible burst failure.

WARNING!

Worn brake hoses can burst and cause brake failure. You could have an accident. If you see any sign of cracking, scuffing, or worn spots, have the brake hoses replaced immediately.

Automatic Transmission

Fluid Level Check – 3.7L Engine This fluid level should be checked when the engine is fully warmed up and the fluid in the transmission is heated to its normal operating temperature. Operation of the transmission with an improper fluid level will greatly reduce the life of the transmission and of the fluid. Check the fluid whenever the vehicle is serviced for other reasons.

MAINTAINING YOUR VEHICLE 315

NOTE: Whenever the fluid level is checked, especially on a vehicle used in severe service, the condition of the fluid should be noted. If the fluid is dark and has a strong odor, fluid should be changed. A physical change in the fluid may be the result of overheating, resulting in fluid degradation. This is pos- sible in severe service or if the vehicle is equipped with a non-factory installed air-conditioning unit. To check the automatic transmission fluid level properly, the following procedure must be used: 1. The vehicle must be on level ground. 2. The engine should be running at curb idle speed for a minimum of 60 seconds. 3. Fully apply parking brake. 4. Place the gear selector briefly in each gear position ending with the lever in N (Neutral).

316 MAINTAINING YOUR VEHICLE

5. Remove the dipstick and feel if the fluid is hot or warm. Hot fluid is approximately 180°F (82°C), the normal operating temperature after the vehicle has been driven at least 15 miles (24 km). The fluid cannot be comfortably held between the finger tips. Warm is when fluid is between 85° and 125°F (29° and 52°C). 6. Wipe the dipstick clean and reinsert until seated. Remove dipstick and note reading.

a. If the fluid is hot, the reading should be in the crosshatched area marked “OK”. b. If the fluid is warm, the reading should be between the two holes.

If the fluid level is low, add sufficient fluid to bring to the proper level. Fluid is added through the dipstick tube.

NOTE: To prevent dirt and water from entering the transmission after checking or replenishing fluid, make certain that the dipstick cap is properly reseated. Fluid Level Check – 4.7L/5.7L Engine Check the fluid level while the transmission is at normal operating temperature 180°F (82°C). This occurs after at least 15 miles (24 km) of driving. At normal operating temperature the fluid cannot be held comfortably be- tween the fingertips. To check the automatic transmission fluid level properly, the following procedure must be used: 1. Operate the engine at idle speed and normal operating temperature. 2. The vehicle must be on level ground. 3. Fully apply the parking brake and press the brake pedal.

4. Place the gear selector momentarily in each gear position ending with the lever in P (Park). 5. Remove the dipstick, wipe it clean and reinsert it until seated. 6. Remove the dipstick again and note the fluid level on both sides. The fluid level should be between the “HOT” (upper) reference holes on the dipstick at normal operat- ing temperature. Verify that solid coating of oil is seen on both sides of the dipstick. If the fluid is low, add as required into the dipstick tube. Do not overfill. After adding any quantity of oil through the oil fill tube, wait a minimum of two (2) minutes for the oil to fully drain into the transmission before rechecking the fluid level. If it is necessary to check the transmission below NOTE: the operating temperature, the fluid level should be between the two “COLD” (lower) holes on the dipstick with the fluid at approximately 70°F ( 21°C) (room temperature). If the fluid level is correctly established at

MAINTAINING YOUR VEHICLE 317

room temperature, it should be between the “HOT” (upper) reference holes when the transmission reaches 180°F ( 82°C). Remember it is best to check the level at the normal operating temperature.

CAUTION!

Be aware that if the fluid temperature is below 50°F (10°C) it may not register on the dipstick. Do not add fluid until the temperature is elevated enough to produce an accurate reading.

7. Check for leaks. Release parking brake. To prevent dirt and water from entering the transmission after checking or replenishing fluid, make certain that the dipstick cap is properly reseated. It is normal for the

318 MAINTAINING YOUR VEHICLE

dipstick cap to spring back slightly from its fully seated position, as long as its seal remains engaged in the dipstick tube. Automatic Transmission Fluid And Filter Change To obtain best performance and long life for automatic transmissions, the manufacturer recommends that they be given regular maintenance service by an Authorized Dodge Dealer or Service Center. It is important that the transmission be adjusted periodically, the fluid main- tained at the correct level, and that it be drained and refilled as specified. Follow the proper Maintenance Schedule for your type of driving. It is important that proper lubricant is used in the transmission. Refer to Recommended Fluids, Lubricants and Genuine Parts for correct fluid type. It is important that the transmission fluid be maintained at the pre- scribed level using the recommended fluid.

CAUTION!

Using a transmission fluid other than the manufac- turers recommended fluid may cause deterioration in transmission shift quality and/or torque converter shudder. Using a transmission fluid other than the manufacturers recommended fluid will result in more frequent fluid and filter changes. Refer to Recommended Fluids, Lubricants and Genuine Parts for correct fluid type.

Special Additives The manufacturer strongly recommends against the ad- dition of any additives to the transmission. Exception to this policy is the use of special dyes to aid in detecting fluid leaks. The use of transmission sealers should be avoided, since they may adversely affect seals.

Transfer Case Inspect the transfer case for fluid leaks. If a fluid leak is evident the transfer case fluid level may be low. Have the transfer case serviced immediately.

CAUTION!

Damage may result from operation of the vehicle with low transfer case fluid.

The transfer case fluid should be drained and refilled at the intervals specified. Lubricant Selection Refer to Recommended Fluids, Lubricants and Genuine Parts for correct fluid type.

MAINTAINING YOUR VEHICLE 319

Axles Refer to Recommended Fluids, Lubricants and Genuine Parts for correct fluid type. The manufacturer does not recommend regularly sched- uled oil changes for axles in vehicles whose operation is classified as normal truck service. NOTE: The presence of water in the gear lubricant will result in corrosion and possible failure of differential components. Operation of the vehicle in water, as may be encountered in some off-highway types of service, will require draining and refilling the axle to avoid damage. Rear Axle Rear Axle fluid levels should be 7/89 (22 mm) below the fill plug hole for 8 1/49 axles, and 1 5/89 (41 mm) below the fill plug hole for 9 1/49 axles.

320 MAINTAINING YOUR VEHICLE

Front Axle Front Axle fluid level should be at the bottom of the filler hole plug. Selection of Lubricating Grease The National Lubricating Grease Institute (NLGI) has developed a symbol (Certification Mark) to aid the vehicle owner in the proper selection of grease for chassis components. This symbol, an example shown below, is located on the grease container and identifies the appli- cation and quality of the grease.

are

There two groups identified, those for wheel bearings (Letter “G”) and those for chassis (Letter “L”) lubrication. Perfor- mance categories within these groups result in dual letter for each group. The letter des- ignations shown in the ex- ample the highest quality level available and when combined as shown can be used for chassis lubrication. Use only those greases that have the NLGI symbol on the container along with the proper quality level for your application.

designations

are

Appearance Care and Protection from Corrosion

Protection of Body and Paint from Corrosion Vehicle body care requirements vary according to geo- graphic locations and usage. Chemicals that make roads passable in snow and ice, and those that are sprayed on trees and road surfaces during other seasons, are highly corrosive to the metal in your vehicle. Outside parking, which exposes your vehicle to airborne contaminants, road surfaces on which the vehicle is operated, extreme hot or cold weather and other extreme conditions will have an adverse effect on paint, metal trim, and under- body protection. The following maintenance recommendations will enable you to obtain maximum benefit from the corrosion resistance built into your vehicle. What Causes Corrosion? Corrosion is the result of deterioration or removal of paint and protective coatings from your vehicle.

MAINTAINING YOUR VEHICLE 321

The most common causes are: † Road salt, dirt and moisture accumulation. † Stone and gravel impact. † Insects, tree sap and tar. † Salt in the air near seacoast localities. † Atmospheric fallout/industrial pollutants. Washing † Wash your vehicle regularly. Always wash your ve- hicle in the shade using a mild car wash soap, and rinse the panels completely with clear water. † If insects, tar or other similar deposits have accumu- † Use Mopart auto polish to remove road film and stains and to polish your vehicle. Take care never to scratch the paint.

lated on your vehicle, wash it as soon as possible.

322 MAINTAINING YOUR VEHICLE

† Avoid using abrasive compounds and power buffing that may diminish the gloss or thin out the paint finish.

CAUTION!

Do not use abrasive or strong cleaning materials such as steel wool or scouring powder, which will scratch metal and painted surfaces.

Special Care † If you drive on salted or dusty roads or if you drive near the ocean, hose off the undercarriage at least once a month. † It is important that the drain holes in the lower edges of the doors, rocker panels and liftgate be kept clear and open.

† If you detect any stone chips or scratches in the paint, touch them up immediately. The cost of such repairs is considered the responsibility of the owner. † If your vehicle is damaged due to an accident or similar cause which destroys the paint and protective coating have your vehicle repaired as soon as possible. The cost of such repairs is considered the responsibil- ity of the owner. † All wheels and wheel trim, especially aluminum and chrome plated wheels should be cleaned regularly with mild soap and water to prevent corrosion. To remove heavy soil, select a nonabrasive, non-acidic cleaner. Do not use scouring pads, steel wool, a bristle brush or metal polishes. Only Mopart cleaners are recommended. Do not use oven cleaner. Avoid auto- matic car washes that use acidic solutions or harsh brushes that may damage the wheels’ protective fin- ish.

† If you carry special cargo such as chemicals, fertilizers, de-icer salt, etc., be sure that such materials are well packaged and sealed. † If a lot of driving is done on gravel roads, consider † Use Mopart touch up paint on scratches as soon as possible. Your dealer has touch up paint to match the color of your vehicle.

mud or stone shields behind each wheel.

Interior Care Use Mopart Fabric Cleaner to clean fabric upholstery and carpeting. Use Mopart Vinyl Cleaner to clean vinyl upholstery and trim. Mopart Total Clean is specifically recommended for leather upholstery.

MAINTAINING YOUR VEHICLE 323

Your leather upholstery can be best preserved by regular cleaning with a damp soft cloth. Small particles of dirt can act as an abrasive and damage the leather upholstery and should be removed promptly with a damp cloth. Stubborn soils can be removed easily with a soft cloth and Mopart Total Clean. Care should be taken to avoid soaking your leather upholstery with any liquid. Please do not use polishes, oils, cleaning fluids, solvents, deter- gents, or ammonia based cleaners to clean your leather upholstery. Application of a leather conditioner is not required to maintain the original condition.

WARNING!

Do not use volatile solvents for cleaning purposes. Many are potentially flammable, and if used in closed areas they may cause respiratory harm.

324 MAINTAINING YOUR VEHICLE

Glass Surfaces All glass surfaces should be cleaned on a regular basis with any commercial household-type glass cleaner. Never use an abrasive type cleaner. Use caution when cleaning inside rear windows equipped with electric defrosters or windshields equipped with a windshield wiper de-icer. Do not use scrapers or other sharp instru- ments which may scratch the elements. When cleaning the rear view mirror, spray cleaner on the towel or rag that you are using. Do not spray cleaner directly on the mirror. Cleaning Plastic Instrument Cluster Lenses The lenses in front of the instruments in this vehicle are molded in clear plastic. When cleaning the lenses, care must be taken to avoid scratching the plastic.

1. Clean with a wet soft rag. A mild soap solution may be used, but do not use high alcohol content or abrasive cleaners. If soap is used, wipe clean with a clean damp rag. 2. Dry with a soft tissue. Seat Belt Maintenance Do not bleach, dye or clean the belts with chemical solvents or abrasive cleaners. This will weaken the fabric. Sun damage will also weaken the fabric. If the belts need cleaning, use a mild soap solution or lukewarm water. Do not remove the belts from the car to wash them. Replace the belts if they appear frayed or worn or if the buckles do not work properly.

POWER DISTRIBUTION CENTER (FUSE/RELAY) Your vehicle is equipped with two electrical power distribution centers located next to each other in the left side of the engine compartment. Thess power distribution centers house new plug-in “Maxi” fuses which replace all the in-line fusible links previously used. The power distribution centers also contain “Mini”fuses and plug-in “ISO” relays. A label inside the latching cover of the Power Distribution Cen- ters identifies each component for ease of replacement, if necessary. These fuses and relays can be obtained from your dealer.

MAINTAINING YOUR VEHICLE 325

FUSE BLOCK The fuse block contains blade-type mini-fuses, relays, and circuit breakers for high-current circuits. It is located in the left kick panel. It is accessible through a snap-in cover.

326 MAINTAINING YOUR VEHICLE

CAUTION!

When replacing a blown fuse, it is important to use only a fuse having the correct amperage rating. The use of a fuse with a rating other than indicated may result in a dangerous electrical system overload. If a properly rated fuse continues to blow, it suggests a problem in the circuit that must be corrected.

If you are leaving your vehicle dormant for NOTE: longer than 21 days you may want to take steps to protect your battery. You may do this by disconnecting the battery or by disconnecting the two ignition-off draw (I.O.D.) fuses located in the Auxiliary Power Distribution Center (PDC) located in the engine compartment. The I.O.D. cavities include a snap-in retainer that allows the fuse to be disconnected, without removing it from the fuse block. Pressing the I.O.D. fuse back into the cavity reconnects it.

VEHICLE STORAGE If you are storing your vehicle for more than 21 days, we recommend that you take the following steps to mini- mize the drain on your vehicle’s battery: † Disconnect the Ignition-Off Draw fuse (I.O.D.) fuse located in the Power Distribution Center (PDC). The I.O.D. cavity includes a snap-in retainer that allows the fuse to be disconnected, without removing it from the fuse block. † The transfer case should be placed in the 4HI mode and kept in this position to minimize the battery drain. † As an alternative to the above steps you may discon-

nect the negative cable from the battery.

REPLACEMENT LIGHT BULBS

BULB REPLACEMENT

MAINTAINING YOUR VEHICLE 327

Dome Light . . . . . . . . . . . . . . . . . . . . . . . . WL212–2
Liftgate Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 567
Overhead Console Lights . . . . . . . . . . . . . PLW214–2A Reading Light . . . . . . . . . . . . . . . . . . . . . . . WL212–2
Visor Vanity Lights . . . . . . . . . . . . . . . Not Serviceable

LIGHT BULBS — Outside Bulb No. Headlight . . . . . . . . . . . . . . . . . . . . . . . . . . . . . H13
Front Park and Turn Sidemarker . . . . . . . . . . . 3457AK Front Auxilliary Park . . . . . . . . . . . . . . . . . . . . . . 194
Back-Up . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3057
Center High Mounted Stoplight . . . . . . . . . . . . . . 921
Fog Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . 9006LL Rear Sidemarker . . . . . . . . . . . . . . . . . . . . . . . . . 168
License Plate Light . . . . . . . . . . . . . . . . . . . . . . . 168
Rear Tail, Stop, Turn Signal. . . . . . . . . . . . . . . . . 3057

Headlights/Parking/Turn Signal

1. Remove the two bolts attaching the headlight to the inner fender panel.

328 MAINTAINING YOUR VEHICLE

2. Remove one nut that attaches the headlight to the inner fender panel. Access to the nut is possible by removing the fender panel access door which is located in the wheel liner. 3. Grasp the headlight and pull firmly to disengage the headlight from the fender panel. 4. While firmly holding the headlight in your hands disconnect all connectors by following the procedure described in step number 5 below.

5. Remove the bulb connector from the headlight making sure to pull and release the red tab on all connectors. Loosen the connector by pressing down on the black and/or green release which is located below or above the red tab. The green release is located above the red tab on the 9008, the black release is located above the 3457AK red tab, and the black release is located below the 194 red tab. 6. Remove and replace the bulb. NOTE: These are Halogen bulbs. Take care not to touch the bulb with your fingers. Body oils from your fingers could cause excessive heat build-up which reduces bulb life.

Rear Side Marker, Tail Lights, Turn Signals And Backup Lights — Replacement

1. Remove the two push-pins from the tail light housing.

MAINTAINING YOUR VEHICLE 329

330 MAINTAINING YOUR VEHICLE

2. Rotate the light to the outboard side of the vehicle and remove.

3. Unlock and remove electrical connector.

4. Remove the three screws holding the bulb strip to the back of the tail light lens.

5. Remove the bulb strip from the tail light lens.

MAINTAINING YOUR VEHICLE 331

332 MAINTAINING YOUR VEHICLE

6. Remove bulbs from bulb strip by pulling the bulb straight out.

License Lights

2. Rotate the socket 1/4 turn counterclockwise.

MAINTAINING YOUR VEHICLE 333

1. Remove the two screws securing the lens to the liftgate.

3. Pull bulb from socket.

334 MAINTAINING YOUR VEHICLE

Center High-Mounted Stoplight

1. Remove two screws securing stoplight housing assem- bly to the liftgate.

3. Pull bulb straight from socket to remove.

2. Turn socket 1/4 counterclockwise and free from hous- ing.

Fog Lights

1. Rotate bulb and connector 1/4 turn counterclockwise. 2. Pull bulb off of connector.

FLUIDS AND CAPACITIES

Fuel

3.7L/4.7L, 87 Octane

5.7L, 89 Octane

Engine Oil (with filter)

3.7L, SAE 5W-30, API Certified 4.7L, SAE 5W-30, API Certified 5.7L, SAE 5W-30, API Certified

Cooling System (includes 2.1 Qts./2L for coolant bottle 3.7L without Rear Heat (Mopart Antifreeze/Coolant 5

Year/100,000 Mile Formula)

MAINTAINING YOUR VEHICLE 335

NOTE: For foglights ensure that the takeout push- fasteners are relocated back in their positions; one in the foglight molding and the other in the hydroform.

U.S.

27 Gal. 27 Gal

5 Qt. 6 Qt. 7 Qt.

13.5 Qt.

Metric

102L 102L

4.7L 5.7L 6.6L

12.9L

336 MAINTAINING YOUR VEHICLE

3.7L with Rear Heat (Mopart Antifreeze/Coolant 5

Year/100,000 Mile Formula)

4.7L without Rear Heat (Mopart Antifreeze/Coolant 5

Year/100,000 Mile Formula)

4.7L with Rear Heat (Mopart Antifreeze/Coolant 5

Year/100,000 Mile Formula)

5.7L without Rear Heat (Mopart Antifreeze/Coolant 5

Year/100,000 Mile Formula)

5.7L with Rear Heat (Mopart Antifreeze/Coolant 5

Year/100,000 Mile Formula)

NOTE: All fluid capacities are approximate capacities.

U.S.

14.5 Qt.

13.1 Qt.

14.2 Qt.

NA

16.6 Qt.

Metric

13.8L

12.5L

13.5L

NA

15.8L

MAINTAINING YOUR VEHICLE 337

RECOMMENDED FLUIDS, LUBRICANTS AND GENUINE PARTS

Engine Component Engine Coolant

Engine Oil Engine Oil Filter Spark Plugs

Fuel Selection 3.7L/4.7L Fuel Selection 5.7L

Fluids, Lubricants and Genuine Parts Mopart Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Organic Additive Technology) P/N 5011764AB or equivalent. Use SAE 5W-30, API Certified, meeting material standard MS-6395. Mopart Engine Oil Filter, P/N 5281090 or equivalent. Refer to the Vehicle Emission Control Information label in the engine compartment. 87 Octane, (R+M)/2 Method 89 Octane, (R+M)/2 Method

338 MAINTAINING YOUR VEHICLE

Chassis Component Automatic Transmission Transfer Case Front Axle Rear Axle Brake Master Cylinder

Power Steering Reservoir

Fluids, Lubricants and Genuine Parts. Mopart ATF+4, Automatic Transmission Fluid. Mopart ATF+4, Automatic Transmission Fluid. SAE 75W-90 Multipurpose Type, GL-5 Gear Lubricant. SAE 75W-140 Synthetic Gear Lubricant. Mopart DOT 3 and SAE J1703 should be used. If DOT 3 brake fluid is not available, then DOT 4 is acceptable. Use only recommended brake fluids. Mopart ATF+4, Automatic Transmission Fluid.

MAINTENANCE SCHEDULES

CONTENTS

m Emission Control System Maintenance . . . . . . . . 340
m Emissions Testing . . . . . . . . . . . . . . . . . . . . . . . 340
m Maintenance Schedules . . . . . . . . . . . . . . . . . . . 341

N Schedule “B” . . . . . . . . . . . . . . . . . . . . . . . . 343
N Schedule “A” . . . . . . . . . . . . . . . . . . . . . . . . 353

M

340 MAINTENANCE SCHEDULES

EMISSION CONTROL SYSTEM MAINTENANCE The “Scheduled” maintenance services, listed in bold type on the following pages must be done at the times or mileages specified to assure the continued proper func- tioning of the emission control system. These, and all other maintenance services included in this manual, should be done to provide best vehicle performance and reliability. More frequent maintenance may be needed for vehicles in severe operating conditions such as dusty areas and very short trip driving. Inspection and service also should be done any time a malfunction is suspected. NOTE: Maintenance, replacement, or repair of the emis- sion control devices and systems on your vehicle may be performed by any automotive repair establishment or individual using any automotive part which has been certified pursuant to U.S. EPA or, in the State of Califor- nia, California Air Resources Board regulations.

EMISSIONS TESTING In some localities, it may be or will become a legal requirement to ensure that all emissions components and systems are functioning properly as a part of the test procedure. The test center accomplishes this by checking the On Board Diagnostic System (OBD) system with an electronic scan tool. If your vehicle has recently been serviced, the OBD system may have been reset to a 9not ready9 condition because the OBD system has not had sufficient time since the servicing to reconfirm that emissions components are operating properly. In most cases, a reasonable mix and amount of normal city and highway driving and at least one overnight-off period will be required to prepare your vehicle for this check; however your dealer has the equipment and procedures required to make certain that the OBD system of your vehicle is ready for the required testing.

MAINTENANCE SCHEDULES There are two maintenance schedules that show the required service for your vehicle. First is Schedule “B”. It is for vehicles that are operated under the conditions that are listed below and at the beginning of the schedule. † Day or night temperatures are below 32° F (0° C). † Stop and go driving. † Extensive engine idling. † Driving in dusty conditions. † Short trips of less than 10 miles (16 km). † More than 50% of your driving is at sustained high † Trailer towing. † Taxi, police, or delivery service (commercial service). † Off-road or desert operation.

speeds during hot weather, above 90° F (32° C).

† If equipped for and operating with E-85 (ethanol)

MAINTENANCE SCHEDULES 341

fuel.

If ANY of these apply to you then change your NOTE: engine oil every 3,000 miles (5 000 km) or 3 months, whichever comes first and follow schedule “B” of the 9Maintenance Schedules9 section of this manual. NOTE: Most vehicles are operated under the conditions listed for Schedule 9B9. Second is Schedule “A”. It is for vehicles that are not operated under any of the conditions listed under Sched- ule 9B9. Use the schedule that best describes your driving condi- tions. Where time and mileage are listed, follow the interval that occurs first. NOTE: Under no circumstances should oil change in- tervals exceed 6000 miles (10 000 km) or 6 months whichever comes first.

M

342 MAINTENANCE SCHEDULES

CAUTION!

Failure to perform the required maintenance items may result in damage to the vehicle.

At Each Stop for Fuel † Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accu- racy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark. † Check the windshield washer solvent and add if

required.

Once a Month † Check tire pressure and look for unusual wear or

damage.

as required.

† Inspect the battery and clean and tighten the terminals † Check the fluid levels of coolant reservoir, brake master cylinder, and transmission and add as needed. † Check all lights and all other electrical items for correct

operation.

At Each Oil Change † Change the engine oil filter. † Inspect the exhaust system. † Inspect the brake hoses. † Inspect the CV joints (if equipped) and front suspen- † Check the automatic transmission fluid level. † Check the coolant level, hoses, and clamps.

sion components.

Schedule “B” Follow schedule “B” if you usually operate your vehicle under one or more of the following conditions. † Day or night temperatures are below 32° F (0° C). † Stop and go driving. † Extensive engine idling. † Driving in dusty conditions. † Short trips of less than 10 miles (16 km). † More than 50% of your driving is at sustained high

speeds during hot weather, above 90° F (32° C).

SCHEDULE “B” 343

† Trailer towing. † Taxi, police, or delivery service (commercial service). † Off-road or desert operation. † If equipped for and operating with E-85 (ethanol)

fuel.

If ANY of these apply to you then change your NOTE: engine oil every 3,000 miles (5 000 km) or 3 months, whichever comes first and follow schedule “B” of the 9Maintenance Schedules9 section of this manual.

344 SCHEDULE “B”

Miles (Kilometers) Change engine oil and engine oil filter. Rotate tires. Change rear axle fluid. Change front axle fluid (4X4). Inspect engine air cleaner filter, replace if neces- sary.

3,000
(5 000)

6,000
(10 000)

9,000
(14 000)

12,000
(19 000)

15,000
(24 000)

Miles (Kilometers) Change engine oil and engine oil filter. Rotate tires. Change rear axle fluid. Change front axle fluid (4X4). Check transfer case fluid level (4X4). Inspect brake linings. Inspect engine air cleaner filter, replace if neces- sary. Replace spark plugs. Inspect PCV valve, replace as necessary.* Drain and refill automatic transmission fluid and change main sump filter (4.7L/5.7L only).

18,000
(29 000)

SCHEDULE “B” 345

21,000
(34 000)

24,000
(38 000)

27,000
(43 000)

30,000
(48 000)

346 SCHEDULE “B”

Miles (Kilometers) Change engine oil and engine oil filter. Rotate tires. Change rear axle fluid. Change front axle fluid (4X4). Inspect brake linings. Inspect engine air cleaner filter, replace if neces- sary.

33,000
(53 000)

39, 000
(62 000)

36,000
(58 000)

42,000
(67 000)

45,000
(72 000)

SCHEDULE “B” 347

48,000
(77 000)

51,000
(82 000)

57,000
(91 000)

54,000
(86 000)

Miles (Kilometers) Change engine oil and engine oil filter. Rotate tires. Change rear axle fluid. Change front axle fluid (4X4). Inspect brake linings. Inspect engine air cleaner filter, replace if necessary. Replace spark plugs. Inspect PCV valve, replace as necessary.* Inspect and replace ignition cables if necessary (5.7L only). Inspect auto tension drive belt and replace if required. Drain and refill automatic transmission fluid, change filter (3.7L). This applies only if your vehicle is used for police, taxi, fleet, or trailer towing. Drain and refill automatic transmission fluid and change main sump filter (4.7L/5.7L only). Inspect transfer case fluid (4X4).

60,000
(96 000)

348 SCHEDULE “B”

Miles (Kilometers) Change engine oil and engine oil filter. Rotate tires. Change rear axle fluid. Change front axle fluid (4X4). Inspect brake linings. Inspect engine air cleaner filter, replace if neces- sary. Inspect auto tension drive belt and replace if re- quired.

63,000
(101 000)

66,000
(106 000)

69,000
(110 000)

72,000
(115 000)

75,000
(120 000)

Miles (Kilometers ) Change engine oil and engine oil filter. Rotate tires. Change rear axle fluid. Change front axle fluid (4X4). Check transfer case fluid level (4X4). Inspect brake linings. Inspect engine air cleaner filter, replace if neces- sary. Replace spark plugs. Inspect PCV valve, replace as necessary.* Inspect auto tension drive belt and replace if re- quired. Drain and refill automatic transmission fluid and change main sump and cooler return filter (if equipped) (4.7L/5.7L only).

78,000
(125 000)

81,000
(130 000)

84,000
(134 000)

87,000
(139 000)

90,000
(144 000)

SCHEDULE “B” 349

350 SCHEDULE “B”

Miles (Kilometers) Change engine oil and engine oil filter. Rotate tires. Flush and replace engine coolant. Change rear axle fluid. Change front axle fluid (4X4).

93,000
(149 000)

96,000
(154 000)

99,000
(158 000)

100,000
(160 000)

102,000
(163 000)

Miles (Kilometers) Change engine oil and engine oil filter. Rotate tires. Change rear axle fluid. Change front axle fluid (4X4). Inspect brake linings. Inspect engine air cleaner filter, replace if necessary. Replace spark plugs. Inspect and replace ignition cables if neces- sary (5.7L only). Inspect PCV valve, replace as necessary.* Inspect auto tension drive belt and replace if required.‡ Drain and refill transfer case fluid (4X4).

105,000
(168 000)

108,000
(173 000)

111,000
(178 000)

114,000
(182 000)

117,000
(187 000)

120,000
(192 000)

SCHEDULE “B” 351

352 SCHEDULE “B”

105,000
(168 000)

Miles (Kilometers) Drain and refill automatic transmission fluid, change filter (3.7L). This applies only if your vehicle is used for police, taxi, fleet, or trailer towing. Drain and refill automatic transmission fluid and change main sump filter (4.7L/5.7L only). * This maintenance is recommended by the manufacture to the owner but is not required to maintain the emis- sions warranty. ‡ This maintenance is not required if previously replaced.

108,000
(173 000)

111,000
(178 000)

114,000
(182 000)

117,000
(187 000)

120,000
(192 000)

Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all re- ceipts.

Schedule “A” Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate tires. Check transfer case fluid level (4X4). Inspect brake linings. Replace engine air cleaner filter. Replace spark plugs.

SCHEDULE “A” 353

6,000
(10 000)

12,000
(19 000)

18,000
(29 000)

24,000
(38 000)

30,000
(48 000)

[6]

[12]

[24]

[18]

[30]

M

354 SCHEDULE “A”

Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate tires. Check transfer case fluid level (4X4). Flush and replace engine coolant at 60
months, regardless of mileage. Inspect brake linings. Replace engine air cleaner filter. Replace spark plugs. Inspect PCV valve, replace as necessary. * Inspect and replace ignition cables if necessary (5.7L only). Inspect auto tension drive belt and replace if required.

36,000
(58 000)

42,000
(67 000)

48,000
(77 000)

54000
(84 000)

60,000
(96 000)

66,000
(106 000)

[36]

[42]

[48]

[54]

[66]

[60]

Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate tires. Check transfer case fluid level (4X4). Inspect brake linings. Replace engine air cleaner filter. Replace spark plugs. Inspect PCV valve, replace as necessary.* Inspect auto tension drive belt and replace if required.‡ Drain and refill automatic transmission fluid and change sump and cooler return filter (if equipped) (4.7L/5.7L only).

72,000
(115 000)

78,000
(125 000)

84,000
(134 000)

90,000
(144 000)

96,000
(154 000)

100,000
(160 000)

SCHEDULE “A” 355

[78]

[84]

[72]

[96]

[90]

M

356 SCHEDULE “A”

Miles (Kilometers) [Months] Change engine oil and engine oil filter. Rotate tires. Drain and refill tranfer case fluid (4X4). Flush and replace engine coolant, if not done at 60 mos. Flush and replace engine coolant, if not done at 102,000
miles (163 000 km) Inspect brake linings. Replace engine air cleaner filter. Replace spark plugs. Inspect PCV valve, replace as necessary.* * This maintenance is recommended by the manufacture to the owner but is not required to maintain the emis- sions warranty.

102,000
(163 000)

[102]

108,000
(173 000)

[108]

114,000
(182 000)

[114]

120,000
(192 000)

[120]

‡ This maintenance is not required if previously per- formed.

Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all re- ceipts.

SCHEDULE “A” 357

WARNING!

You can be badly injured working on or around a motor vehicle. Do only that service work for which you have the knowledge and the right equipment. If you have any doubt about your ability to perform a service job, take your vehicle to a competent me- chanic.

IF YOU NEED CONSUMER ASSISTANCE

CONTENTS

m Suggestions For Obtaining Service For Your

Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 360
N Prepare For The Appointment . . . . . . . . . . . . 360
N Prepare A List . . . . . . . . . . . . . . . . . . . . . . . . 360
N Be Reasonable With Requests . . . . . . . . . . . . . 360
m If You Need Assistance . . . . . . . . . . . . . . . . . . . 360

m Warranty Information . . . . . . . . . . . . . . . . . . . . 363
m Mopart Parts . . . . . . . . . . . . . . . . . . . . . . . . . 365
m Reporting Safety Defects . . . . . . . . . . . . . . . . . . 365
N In Canada . . . . . . . . . . . . . . . . . . . . . . . . . . 365
m Publication Order Forms . . . . . . . . . . . . . . . . . . 366

360 IF YOU NEED CONSUMER ASSISTANCE

SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE

Prepare For The Appointment If you’re having warranty work done, be sure to have the right papers with you. Take your warranty folder. All work to be performed may not be covered by the warranty, discuss additional charges with the service manager. Keep a maintenance log of your vehicle’s service history. This can often provide a clue to the current problem. Prepare A List Make a written list of your vehicle’s problems or the specific work you want done. If you’ve had an accident, or work done that is not on your maintenance log, let the service advisor know.

Be Reasonable With Requests If you list a number of items, and you must have your vehicle by the end of the day, discuss the situation with the service advisor and list the items in order of priority. At many dealers you may obtain a rental vehicle at a minimal daily charge. If you need a rental, it is advisable to make these arrangements when you call for an ap- pointment.

IF YOU NEED ASSISTANCE The manufacturer and its dealers are vitally interested in your satisfaction. We want you to be happy with our products and services. Your selling dealer is best equipped and most anxious to provide prompt resolution for any warranty issue or related matter that you may experience. The manufactur- er’s dealers have the facilities, factory-trained techni- cians, special tools, and the latest information to assure your vehicle is fixed correctly and in a timely manner.

The manufacturer has empowered its dealers to make warranty and repair decisions that ensure you are not inconvenienced. There is no need for you to wait for a decision from the manufacturer. If a special circumstance occurs that requires information from the manufacturer, we have asked the dealer’s service management to make the contact on your behalf. This is why you should always talk to your dealer’s service manager first. Most matters can be resolved with this process. † If for some reason you are still not satisfied, talk to the general manager or owner of the dealership. They want to know if you need assistance. † If your dealership is unable to resolve the concern, you

may contact the Manufacturer’s Customer Center.

IF YOU NEED CONSUMER ASSISTANCE 361

Any communication to the Manufacturer’s Customer Center should include the following information: † Owner’s name and address † Owner’s telephone number (home and office) † Dealership name † Vehicle identification number † Vehicle delivery date and mileage DaimlerChrysler Motors Corporation Customer Center P.O. Box 21–8004
Auburn Hills, MI 48321–8004
Phone: (800) 992-1997
DaimlerChrysler Canada Inc. Customer Center P.O. Box 1621
Windsor, Ontario N9A 4H6
Phone —(800) 465–2001

362 IF YOU NEED CONSUMER ASSISTANCE

In Mexico contact: Av. Prolongacion Paseo de la Reforma, 1240
Sante Fe C.P. 05109
Mexico, D. F. In Mexico (915) 729–1248 or 729–1240
Outside Mexico (525) 729–1248 or 729–1240
Customer Assistance For The Hearing Or Speech Impaired (TDD/TTY) To assist customers who have hearing difficulties, the manufacturer has installed special TDD (Telecommuni- cation Devices for the Deaf) equipment at its Customer Center. Any hearing or speech impaired customer who has access to a TDD or a conventional teletypewriter (TTY) in the United States can communicate with the manufacturer by dialing 1–800–380–CHRY.

Service Contract You may have purchased a service contract for your vehicle to help protect you from the high cost of unex- pected repairs after your manufacturer’s new vehicle limited warranty expires. The manufacturer stands be- hind only the manufacturer’s Service Contracts. If you purchased a manufacturer’s Service Contract, you will receive Plan Provisions and an Owner Identification Card in the mail within three weeks of your vehicle delivery date. If you have any questions about your service contract, call the manufacturer’s Service Contract Na- tional Customer Hotline at 1-800-521-9922. The manufacturer will not stand behind any service contract that is not the manufacturer’s Service Contract. It is not responsible for any service contract other than the manufacturer’s Service Contract. If you purchased a service contract that is not a manufacturer’s Service

Contract, and you require service after your manufactur- er’s new vehicle limited warranty expires, please refer to your contract documents, and contact the person listed in those documents. We appreciate that you have made a major investment when you purchased your new vehicle. Your dealer has also made a major investment in facilities, tools, and training to assure that you are absolutely delighted with your ownership experience. You’ll be pleased with their

IF YOU NEED CONSUMER ASSISTANCE 363

sincere efforts to resolve any warranty issues or related concerns.

WARRANTY INFORMATION See your manufacturer’s Warranty Information Booklet for information on warranty coverage and transfer of warranty.

364 IF YOU NEED CONSUMER ASSISTANCE

MOPART PARTS Mopart fluids, lubricants, parts, and accessories are available from your dealer. They will help you keep your vehicle operating at its best.

REPORTING SAFETY DEFECTS In the 50 United States and Washington D.C.: If you believe that your vehicle has a defect which could cause a crash or cause injury or death, you should immediately inform the National Highway Traffic Safety Administra- tion (NHTSA) in addition to notifying the manufacturer. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, and the manufacturer.

IF YOU NEED CONSUMER ASSISTANCE 365

To contact NHTSA, you may either call the Auto Safety Hotline toll free at 1-800-424-9393 (or 366-0123 in Wash- ington DC area) or write to: NHTSA, U.S. Dept. of Transportation, Washington DC 20590. You can also obtain other information about motor vehicle safety from the Hotline. In Canada: If you believe that your vehicle has a safety defect, you should contact the Customer Service Department imme- diately. Canadian customers who wish to report a safety defect to the Canadian government should write to Transport Canada, Motor Vehicle Defect Investigations and Recalls, 2780 Sheffield Road, Ottawa, Ontario K1B 3V9.

366 IF YOU NEED CONSUMER ASSISTANCE

PUBLICATION ORDER FORMS To order the following manuals, you may use either the website or the phone numbers listed below. Visa, Mas- tercard, American Express, and Discover orders are ac- cepted. If you prefer mailing your payment, please call for an order form. NOTE: A street address is required when ordering manuals. (No P.O. Boxes).

† Service Manuals.

These comprehensive service manuals provide the information that students and professional technicians need in diagnosing/troubleshooting, problem solving, maintaining, servicing and repairing DaimlerChrysler Corporation vehicles. A complete working knowledge of the vehicle, system and/or components is written in straightforward language with illustrations, diagrams and charts.

† Diagnostic Procedure Manuals.

Filled with diagrams, charts and detailed illustrations, these practical manuals make it easy for students and technicians to find and fix problems on computer- controlled vehicle systems and features. They show exactly how to find and correct problems the first time, using step-by-step troubleshooting and driveability procedures, proven diagnostic tests and a complete list of all tools and equipment.

† Owner’s Manuals.

These manuals have been prepared with the assistance of service and engineering specialists to acquaint you with specific Chrysler group vehicles. Included are starting, operating, emergency and maintenance pro- cedures as well as specifications, capabilities and safety tips.

IF YOU NEED CONSUMER ASSISTANCE 367

Call Toll Free at 1–800–890–4038 (U.S.) or 1–800–387–1143
(Canada) Or Visit us on the World Wide Web at: www.techauthority.daimlerchrysler.com or www.daimlerchrysler.ca/manuals

INDEX

10

370 INDEX

. . . . . . . . . . 309
Adding Engine Coolant (Antifreeze) Adding Fuel . . . . . . . . . . . . . . . . . . . . . . . . 245,270
Air Cleaner, Engine . . . . . . . . . . . . . . . . . . . . . . 298
Air Conditioner Maintenance . . . . . . . . . . . . . . . 302
Air Conditioning . . . . . . . . . . . . . . . . . . . . . . . . 184
Air Conditioning Controls . . . . . . . . . . . . . . . . . 184
Air Conditioning Refrigerant . . . . . . . . . . . . . 302,303
Air Conditioning System . . . . . . . . . . . . . . . . 179,302
Air Filter . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 298
Air Pressure, Tires . . . . . . . . . . . . . . . . . . . . 231,239
Airbag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 38,153
Airbag Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 50
Alarm . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 24,149
Alarm, Panic . . . . . . . . . . . . . . . . . . . . . . . . . . . . 21
. . . . . . . . . . . . . . . . . . . 238
Alignment and Balance Alterations/Modifications, Vehicle . . . . . . . . . . . . . 6
Antenna, Satellite Radio . . . . . . . . . . . . . . . . . . . 176
Antifreeze (Engine Coolant) . . . . . . . . . . . . . . 308,335
Anti-Lock Brake System . . . . . . . . . . . . . . . . . . . 218

Anti-Lock Warning Light . . . . . . . . . . . . . . . . . . 149
Anti-Theft System . . . . . . . . . . . . . . . . . . . . . 24,149
Appearance Care . . . . . . . . . . . . . . . . . . . . . . . . 321
Arming Theft System . . . . . . . . . . . . . . . . . . . . . . 25
Auto Unlock . . . . . . . . . . . . . . . . . . . . . . . . . . . . 16
Automatic Dimming Mirror . . . . . . . . . . . . . . . 70,74
Automatic Door Locks . . . . . . . . . . . . . . . . . . . . . 15
Automatic Headlights . . . . . . . . . . . . . . . . . . . . 106
Automatic Temperature Control . . . . . . . . . . . . . 184
Automatic Transaxle . . . . . . . . . . . . . . . . . . . . . . 203
Automatic Transmission . . . . . . . . . . . . . 200,203,315
Adding Fluid . . . . . . . . . . . . . . . . . . . . . . 316,317
Fluid and Filter Changes . . . . . . . . . . . . . . . . . 318
Fluid Level Check . . . . . . . . . . . . . . . . . . . 315,316
Fluid Type . . . . . . . . . . . . . . . . . . . . . . . . 318,338
Gear Ranges . . . . . . . . . . . . . . . . . . . . . . . . . . 203
Special Additives . . . . . . . . . . . . . . . . . . . . . . 318
. . . . . . . . . . . . . . . . . . . . . . 207
Torque Converter Axle Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 338

INDEX 371

Axle Lubrication . . . . . . . . . . . . . . . . . . . . . . . . 319

Ball Joints . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 304
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 300
Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . 280
Emergency Starting . . . . . . . . . . . . . . . . . . . . . 280
Gas Caution . . . . . . . . . . . . . . . . . . . . . . . . . . 280
Keyless Transmitter Replacement . . . . . . . . . . . . 24
Saving Feature . . . . . . . . . . . . . . . . . . . . . . . . 105
Belts, Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . . 297
Belts, Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 29
Body Mechanism Lubrication . . . . . . . . . . . . . . . 304
B-Pillar Location . . . . . . . . . . . . . . . . . . . . . . . . 226
Brake Fluid . . . . . . . . . . . . . . . . . . . . . . . . . . . . 338
Brake System . . . . . . . . . . . . . . . . . . . . . . . . 218,313
Anti-Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Disc Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . 313
Fluid Check . . . . . . . . . . . . . . . . . . . . . . . . . . 313
Hoses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 314

Master Cylinder . . . . . . . . . . . . . . . . . . . . . . . 313
Parking . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 217
Warning Light . . . . . . . . . . . . . . . . . . . . . 149,151
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 218
Brakes Brake/Transmission Interlock . . . . . . . . . . . . . . . 203
Break-In Recommendations, New Vehicle . . . . . . . . 62
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . . 327
Bulbs, Light . . . . . . . . . . . . . . . . . . . . . . . . . . . . 327

Calibration, Compass . . . . . . . . . . . . . . . . . . . . . 124
Capacities, Fluid . . . . . . . . . . . . . . . . . . . . . . . . 335
Caps, Filler

Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 303
Car Washes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 321
Carbon Monoxide Warning . . . . . . . . . . . . . . . . . 248
Cargo . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 250
Catalytic Converter . . . . . . . . . . . . . . . . . . . . 249,299
CD Player . . . . . . . . . . . . . . . . . . . . . . . . . . 155,161
Cellular Phone . . . . . . . . . . . . . . . . . . . . . . . . 74,179

10

372 INDEX

. . . . . . . . . . . . 334
Center High Mounted Stop Light . . . . . . . . . . . . . . . . . . . . . . . 250
Certification Label Changing A Flat Tire . . . . . . . . . . . . . . . . . . . . . 272
Charging . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 280
Chart, Tire Sizing . . . . . . . . . . . . . . . . . . . . . . . . 223
Child Restraint . . . . . . . . . . . . . . . . . . . . . . 50,51,61
Child Restraint Tether Anchors . . . . . . . . . . . . . 54,60
Child Restraint with Automatic Belts . . . . . . . . . . . 35
Child Seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 55
Circuit Breakers . . . . . . . . . . . . . . . . . . . . . . . . . 325
Climate Control . . . . . . . . . . . . . . . . . . . . . . . . . 179
Clock . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 154
Compact Disc Maintenance . . . . . . . . . . . . . . . . . 178
Compact Spare Tire . . . . . . . . . . . . . . . . . . . . . . 234
Compass . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 124
Compass Calibration . . . . . . . . . . . . . . . . . . . . . 124
Compass Variance . . . . . . . . . . . . . . . . . . . . . . . 125
Computer, Trip/Travel . . . . . . . . . . . . . . . . . . . . 120
Console, Floor . . . . . . . . . . . . . . . . . . . . . . . . . . 137

Console, Overhead . . . . . . . . . . . . . . . . . . . . . . . 119
Contract, Service . . . . . . . . . . . . . . . . . . . . . . . . 362
Converter, Catalytic . . . . . . . . . . . . . . . . . . . . . . 249
Coolant . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 310
Coolant Pressure Cap . . . . . . . . . . . . . . . . . . . . . 310
Cooling System . . . . . . . . . . . . . . . . . . . . . . . . . 306
Adding Coolant (Antifreeze) . . . . . . . . . . . . . . 309
Coolant Capacity . . . . . . . . . . . . . . . . . . . . . . 335
. . . . . . . . . . . . . . . . . . . . . . . . . 310
Coolant Level Disposal of Used Coolant . . . . . . . . . . . . . . . . 308
Drain, Flush, and Refill . . . . . . . . . . . . . . . . . . 308
Inspection . . . . . . . . . . . . . . . . . . . . . . . . . . . 306
Points to Remember . . . . . . . . . . . . . . . . . . . . 311
Radiator Cap . . . . . . . . . . . . . . . . . . . . . . . . . 310
Selection of Coolant . . . . . . . . . . . . . . . 308,335,337
Temperature Gauge . . . . . . . . . . . . . . . . . . . . . 146
Cruise Control . . . . . . . . . . . . . . . . . . . . . . . . . . 116
Cup Holder . . . . . . . . . . . . . . . . . . . . . . . . . . . . 138
Customer Assistance . . . . . . . . . . . . . . . . . . . . . 360

Daytime Running Lights . . . . . . . . . . . . . . . . . . . 107
Dealer Service . . . . . . . . . . . . . . . . . . . . . . . . . . 291
Defroster, Rear Window . . . . . . . . . . . . . . . . . . . 195
Defroster, Windshield . . . . . . . . . . . . . . . . 63,182,187
Delay Wipers . . . . . . . . . . . . . . . . . . . . . . . . . . . 110
Diagnostic System, Onboard . . . . . . . . . . . . . . . . 289
Dimmer Switch, Headlight . . . . . . . . . . . . . . . . . 147
Dipsticks

Automatic Transmission . . . . . . . . . . . . . . . . . 316
Oil (Engine) . . . . . . . . . . . . . . . . . . . . . . . . . . 292
Power Steering . . . . . . . . . . . . . . . . . . . . . . . . 303
Disarming, Theft System . . . . . . . . . . . . . . . . . . . 25
Disc Brakes . . . . . . . . . . . . . . . . . . . . . . . . . . . . 313
Disposal

. . . . . . . . . . . . . . . . . . . . . . . . . 308
Used Coolant