1995 Chevrolet Monte Carlo Owners Manual

Some fuses are in a fuse block on the passenger side of the instrument panel. Pull I FUSES to expose the fuses.

Instrument Panel Fuse Block

3 3 0 3 4 n o 0 n o 0 3 7 ~ 3 8 ~ 3 9 ~ 4 0 o n 0 0 0 0 0411[420 0 0 0

O 3 2 0

45

35

36

43

44

Additional fuses are in the underhood electrical centers on the right and left sides of the engine compartment. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace a bad fuse with a new one of the identical size and rating, 6-54

Circuit Description Breaker

Power Windows Power Seats

Fuse

10

11

12 14

15

16

19

21

Rating Description CIGAR LIGHTER -- Instrument Panel and Console Cigar Lighters HAZARD FLASHER I/P ELECTRONICS BATTERY FEED -- Chime Module, Electronic Brake Control Module (EBCM), Theft Deterrent Module, Radio AIR BAG #2 -- Sensing and Diagnostic Module (SDM), Starter Relay ANTI-THEFT -- Theft Deterrent Module HVAC BLOWER MOTOR -- Blower Motor Relay HVAC #1 -- Air Temperature Valve Motor, Daytime Running Lamps Module (with DRL), HVAC Control Assembly, Multifunction Lever Cruise Control Switch REAR DEFOG -- W A C Control Assembly Rear Window Defogger Switch POWER ACCESSORY #I -- Door Lock Switches AIR BAG #1 -- Sensing and Diagnostic Module (SDM)

Fuse Rating

23 24

28

29 30 32

33

38 39

Description STOPLAMPS -- TCC/Brake Switch HVAC #2 -- HVAC Control Assembly, Solenoid Box CTSY LAMPS -- Vanity Mirrors, Defogger Relay, UP Compartment Lamp, Trunk Courtesy Lamp, Header Courtesy and Reading Lamp, I/S Lighted Rearview Mirror, Dome Lamp WIPER -- Wiper Switch TURN SIGNAL -- Turn Signal Flasher POWER LOCKS -- Door Lock Relay, Keyless Entry Receiver ABS -- Electronic Brake Control Module (EBCM), ABS Relay RADIO -- Radio I/€' ELECTRONICS IGNITION FEED -- Headlamp Switch, Cruise Control Cut-Out Switch, Sensing and Diagnostic Module (SDM), TCC/Brake Switch, Instrument Cluster, Chime Module, Keyless Entry Receiver, Daytime Running Lamps Module (with DRL)

6-55

Underhood Electrical Center -- Passenger Side I,

on0 000 R/CMPT REL ECM BAT ENG EMIS CRUISE on0

TCC

F/INJN

ECM IGN

ELEK IGN

6-56

Fuse WCMPT REL ECM BAT

TCC

ENG EMIS

CRUISE

F/INJN

Description Remote Trunk Release Powertrain Control Module (PCM), Fuel Pump/Oil Pressure Switch, Fuel Pump Relay, Fan Cont #1 Relay Automatic Transaxle, Transaxle Range Switch (VIN M only) Generator, Digital Exhaust Recirculation (DEGR) Valve, Evaporative Emissions (EVAP) Canister Purge Valve Solenoid, Heated Oxygen Sensor, Fan Cont #2 Relay, A/C CMPR Relay (VIN M only) Cruise Control Module, A/C CMPR Relay (VIN X only) Fuel Injectors, High Resolution 24X Crankshaft Position Sensor, Camshaft Position Sensor

Fuse ECM IGN

ELEK IGN

10 11 12

13

Description Powertrain Control Module (PCM), Mass Air Flow (MAF) Sensor (VIN X only) Electronic Ignition (EI) Control Module UP Fuse Block FAN CONT #1 Relay Passenger Side Underhood Electrical Center and I/P Fuse Blocks: Fuses 5, 14,23 and 32 FAN CONT #2 Relay and I/P Fuse Block: Fuse 16, Power Seat Circuit Breaker “D”

Relay 14 15 16

17

18

Description FUEL PUMP A/C CMPR FAN CONT #2 -- Secondary Cooling Fan (Passenger Side) FAN CONT # 1 -- Primary Cooling Fan (Driver Side) Not Used

6-57

Underhood Electrical Center -- Driver Side

ODD 000 uno

FOG LPS PARKLPS

HORN

VAR PIS

Fuse FOG LPS PARK LPS HORN VAR P/S

Description Fog Lamps Headlamp Switch Horn Relay, Underhood Lamp EVO Steering

6-58

Fuse 10

11

12

13

Relay 14 15 16

Description IGN SW2 -- I/P Fuse Block: PWR WDO and Circuit Breaker “D”; Passenger Side Underhood Electrical Center: TCC and ENG EMIS Fuses IGN SWl -- I/P Fuse Block: Radio, Wiper, HVAC, ABS and Turn Signal Fuses; Passenger Side Underhood Electrical Center: F/IJN, ECM IGN and ELEK IGN Fuses HD LPS -- Circuit Breaker to Headlamp Switch ABS -- ABS Relay

Description ABS -- Anti-lock Brake System FOG LPS HORN

Power Windows and Other Power Options Circuit breakers in the fuse panel protect the power windows and other power accessories. When the current load is too heavy, the circuit breaker opens and closes, protecting the circuit until the problem is fixed.

Headlamp Wiring The headlamp wiring is protected by a circuit breaker in the underhood electrical center. An electrical overload will cause the lamps to go on and off, or in some cases to remain off. If this happens, have your headlamp system checked right away. Windshield Wipers The windshield wiper motor is protected by a circuit breaker and a fuse. If the motor overheats due to heavy snow, etc., the wiper will stop until the motor cools. If the overload is caused by some electrical problem, have it fixed.

6-59

Number

Bulb

Replacement Bulbs

Exterior Lamps

Back-up ................................. 3057 Center High-Mounted Stop ................. 891T2 Front Parking/Turn Signal . . . . . . . . . . . . . . . . . 3057NA Headlamp. High Beam ..................... 9005 Headlamp. Low Beam ...................... 9006 License Plate ..................... 194 or 24 (234) Sidemarker. Front .......................... 194 Sidemarker. Rear ........................... 194 Stop/Tail/Turn Signal ...................... 3057

Interior Lamps Bulb Number Ashtray .................................. 194 Center Instrument Cluster ............... 161 or 194 Console Shift Indicator ....................... 73 Dome .................................... 561 Door Lock Switch ........................... 73 Glove Box ................................ 194 Heater and Air Conditioning Control .... T-1.75, T-1.5 High-Beam Indicator ....................... 161 Luggage Compartment ...................... 920 Inside Rearview Mirror Reading ............... 192 Side Window Switch ......................... 73

Capacities and Specifications

Automatic Transaxle

Pan Removal and Replacement . . . . . 7 quarts (6.7 L) After Complete Overhaul . . . . . . . . . 10 quarts (9.5 L)

When drainingheplacing converter; nzore.fZuid may be needed. Cooling System Including Reservoir

3.1L (Code M) . . . . . . . . . . . . . . 11.6 quarts (10.94 L) 3.4L (Code X) . . . . . . . . . . . . . . 12.3 quarts (11.65 L)

Refrigerant (R-l34a), Air Conditioning* . . . . . . . . . . . . . . . . . . . . . . . . . . . .

2.0 pounds (0.9 1 kg)

Engine Crankcase

Oil and Filter Change . . . . . . . . . . . . . 5 quarts (4.7 L) Fuel Tank . . . . . . . . . . . . . . . . . . . 17.1 gallons (64.7 L) *See “Air Conditioning Refrigerants” later in this section.

Engine Specifications Type . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . Displacement . . . . . . . . . . . . . . . . . . . . . . . . . . . Compression Ratio ..................... Firing Order . . . . . . . . . . . . . . . . . . . . . . . . . . . . Thermostat Temperature . . . . . . . . . . . . . . . . . . Valve Arrangement . . . . . . . . . . . . . . . . . . . . . .

3.1L (Code M)

V6

191 CID (3.1L)

9.6: 1

1-2-3-4-5-6 195°F (91°C)

In-Head

3.4L (Code X)

V6

207 CID (3.4L)

9.25: 1

1-2-3-4-5-6 195°F (91 “C)

In-Head

6-61

Air Conditioning Refrigerants Not all air conditioning refrigerants are the same. If the air conditioning system in your vehicle needs refrigerant, be sure the proper refrigerant is used. If you’re not sure, ask your Chevrolet dealer. For additional information, see your “Warranty and Owner Assistance Information” booklet.

6-62

NOTES

6-63

NOTES

0 Section 7 Maintenance Schedule

IMPORTANT: KEEP ENGINE OILr AT THE PROPER

LEVEL AND CHANGE A:

RECOMMENDED

This section covers the maintenance required for your Chevrolet. Your vehicle needs these services to retain its

1 protection Plan 1 safety, dependability and emission control performance. E,

Introduction Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep your vehicle in good working condition, but also helps the environment. All recommended maintenance procedures are important. Improper vehicle maintenance or the removal of important components can significantly affect the quality of the air we breathe. Improper fluid levels or even the wrong tire inflation can increase the level of emissions from your vehicle. To help protect our environment, and to help keep your vehicle in good condition, please maintain your vehicle properly.

Huve you purchased the GM Protection Plan? The Plan supplements your new vehicle warranties. See your Chevrolet dealer for details.

7-1

How This Section is Organized The remainder of this section is divided into five parts: “Part A: Scheduled Maintenance Services” shows what to have done and how often. Some of these services can be complex, so unless you are technically qualified and have the necessary equipment, you should let your dealer’s service department or another qualified service center do these jobs.

If you are skilled enough to do some work on your vehicle, you will probably want to get the service information GM publishes. You will find a list of publications and how to get them in this manual. See “Service Publications” in the Index. 7-2

“Part B: Owner Checks and Services” tells you what should be checked whenever you stop for fuel. It also explains what you can easily do to help keep your vehicle in good condition. “Part C: Periodic Maintenance Inspections” explains important inspections that your Chevrolet dealer’s service department or another qualified service center should perform. “Part D: Recommended Fluids and Lubricants” lists some products GM recommends to help keep your vehicle properly maintained. These products, or their equivalents, should be used whether you do the work yourself or have it done. “Part E: Maintenance Record’’ provides a place for you to record the maintenance performed on your vehicle. Whenever any maintenance is performed, be sure to write it down in this part. This will help you determine when your next maintenance should be done. In addition, it is a good idea to keep your maintenance receipts. They may be needed to qualify your vehicle for warranty repairs.

Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we don’t know exactly how you’ll drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands or in many other ways. Because of all the different ways people use their GM vehicles, maintenance needs vary. You may even need more frequent checks and replacements than you’ll find in the schedules in this section. So please read this section and note how you drive. If you have any questions on how to keep your vehicle in good condition, see your Chevrolet dealer. This part tells you the maintenance services you should have done and when you should schedule them. If you go to your dealer for your service needs, you’ll know that GM-trained and supported service people will perform the work using genuine GM parts.

The proper fluids and lubricants to use are listed in Part D. Make sure whoever services your vehicle uses these. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. These schedules are for vehicles that:

carry passengers and cargo within recommended limits. You will find these limits on your vehicle’s Tire-Loading Information label. See “Loading Your Vehicle” in the Index. are driven on reasonable road surfaces within legal driving limits. use the recommended unleaded fuel. See “Fuel” in the Index.

Selecting the Right Schedule First you’ll need to decide which of the two schedules is right for your vehicle. Here’s how to decide which schedule to follow:

7-3

Maintenance Schedule

Schedule I Definition Follow Maintenance Schedule I if any one of these is true for your vehicle:

Most trips are less than 5 to 10 miles (8 to 16 km). This is particularly important when outside temperatures are below freezing.

0 Most trips include extensive idling (such as frequent

driving in stop-and-go traffic). Most trips are through dusty areas.

0 You frequently tow a trailer or use a carrier on top of

your vehicle.

Schedule I should also be followed if the vehicle is used for delivery service, police, taxi, or other commercial application.

7-4

Schedule I Intervals Every 3,000 Miles (5 000 km) or 3 Months

Engine Oil and Filter Change

Chassis Lubrication

Every 6,000 Miles (10 000 km) or 6 months At 6,000 Miles (10 000 km) - Then Every 12,000 Miles (25 000 km)

Tire Rotation

Every 15,000 Miles (25 000 km)

Air Cleaner Filter Inspection, if dnving in dusty conditions

Every 30,000 Miles (50 000 km) Air Cleaner Filter Replacement Spark Plug Replacement Spark Plug Wire Inspection Fuel Tank, Cap and Lines Inspection Engine Accessory Drive Belt Inspection (or every

24 months)

Cooling System Service (or every 24 months)

Automatic Transaxle Service (severe conditions)

Every 50,000 Miles (83 000 km) At 60,000 Miles (100 000 km) - Then Every 15,000 Miles (25 000 km)

Camshaft Timing Belt lnspection (3.4L Code X

engine only)

Maintenance Schedule I Schedule I1 Definition

Follow Schedule I1 only if none of the conditions from Schedule I is true.

Schedule I1 Intervals Every 7,500 Miles (12 500 km)

Engine Oil and Filter Change (or every 12 months) Chassis Lubrication (or every 12 months) At 7,500 Miles (12 500 km) - Then Every 15,000 Miles (25 000 km)

Tire Rotation

Every 30,000 Miles (50 000 km)

Engine Accessory Drive Belt Inspection (or every

24 months)

Cooling System Service (or every 24 months) Spark Plug Replacement Spark Plug Wire Inspection Air Cleaner Filter Replacement Fuel Tank, Cap and Lines Inspection

Automatic Transaxle Service (severe conditions)

Every 50,000 Miles (83 000 km) At 60,000 Miles (100 000 km) - Then Every 15,000 Miles (25 000 km)

Camshaft Timing Belt Inspection (3.4L Code X

engine only)

7-5

I Maintenance Schedule I

The services shown in this schedule up to 100,000 miles (166 000 km) should be performed after 100,000 miles (166 000 km) at the same intervals. Footnotes

The U.S. Environmental Protection Agency or the

California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of vehicle useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

3,000 Miles (5 000 kmj 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

DATE ACTUAL MILEAGE SERVICED

BY:

7-6

1 Maintenance Schedule I 6,000 Miles (10 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

9,000 Miles (15 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

, , .

7-7

I Maintenance Schedule I I 12,000 Mikes (20 000 km) fJ Change- engine oil and filter (or every

3 months, whichever o c m s first). An Emission Control Service. Lubricate the slfiift linkage, parking brake cable guides, underbody contact points and lidcage (or every 6 months, whichever occu1*s first)

15,000 Miles (25.000 km) 0, Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Sewice.

0 Inspect air cleaner filter if you are drivi~g

in dusty conditions. Replace filter if necessary. An Emmion Control Sewice.

7-8

I Maintenance Schedule I 18,000 Miles (30 000 km) 17 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

21,000 Miles (35 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Con fro1 Service.

DATE

ACTUAL MILEAGE

DATE ACTUAL MILEAGE

I SERVICED B Y I

7-9

27,000 Miles (45 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

I Maintenance Schedule I 24,000 Miles (40 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY:

7-10

Maintenance Schedule I 30,000 Miles (50 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable

guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

0 Inspect engine accessory drive belt (or

every 24 months, whichever occurs first). An Emission Control Service. 0 Drain, flush and refill cooling system (or every 24 months, whichever occurs first). See “Engine Coolant’’ in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service.

0 Replace spark plugs. An Emission Control

17 Replace air cleaner filter. Replace filter

more often under dusty conditions. An Emission Control Service.

0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. i-

0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information.

Service.

7-11

36,000 Miles (60 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

I Maintenance Schedule I 33,000 Miles (55 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

I DATE

I ACTUAL MILEAGE ISERVICED

BY I

7-12

1 Maintenance Schedule I 39,000 Miles (65 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

42,000 Miles (70 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service. Lubricate the (or every 6 months, whichever occurs first). Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE

SERVICED B Y

7-13

I

I Maintenance Schedule I 45,000 Miles (75 000 km)

_____

~~

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Inspect air cleaner filter if you are driving in dusty conditions. Replace filter if necessary. An Emission Control Service.

48,000 Miles (80 000 km) El Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs €irst).

I DATE

I ACTUAL MILEAGE

ISERVICED

BY:^

7-14

1 DATE

ACTUAL

MILEAGE

SERVICED

BY:

51,000 Miles (85 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

I Maintenance Schedule I 50,000 Miles (83 000 km) 0 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

If you do not use your vehicle under any of these conditions, the fluid andfilter do not require changing.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

Maintenance Schedule I 54,000 Miles (90 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

57,000 Miles (95 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

[7 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE ACTUAL MILEAGE SERVICED

BY:

DATE ACTUAL MILEAGE SERVICED

BY:

Maintenance Schedule I 60,000 Miles (100 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shft linkage, parlung brake cable guides, underbody contact points and linkage (or every 6 months, whchever occurs first).

0 Inspect engine accessory drive belt (or

Control Service.

every 24 months, whichever occurs first). An Emission Control Service. 0 Inspect camshaft timing belt. An Emission 0 Drain, flush and refill cooling system (or every 24 months, whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service.

Replace spark plugs. An Emission Control Service.

0 Inspect spark plug wires. An Emission Control 0 Replace air cleaner filter. Replace filter

Service.

more often under dusty conditions. An Emission Control Service.

0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Enzi.ssion Control Service.?

DATE

ACTUAL MILEAGE

SERVICED BY:

7-17

I Maintenance Schedule I 63,000 Miles (105 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

66,000 Miles (110 000 knz) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

BY:

7-18

-~ -

I Maintenance Schedule I 69,000 Miles (115 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

72,000 Miles (120 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

DATE SERVICED

ACTUAL MILEAGE

BY:

DATE ACTUAL MILEAGE SERVICED

BY:

7-19

I Maintenance Schedule I 75,000 Miles (125 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service.

0 Inspect camshaft timing belt. An Emission

Control Service.

78,000 Miles (130 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL

MILEAGE

SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

BY:

1 Maintenance Schedule I 81,000 Miles (135 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

84,000 Miles (140 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

DATE

ACTUAL MILEAGE

3 I ACTUAL MILEAGE SERVICED

BY:

7-21

I

Maintenance Schedule I 87,000 Miles (145 000 km) 17 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE ACTUAL MILEAGE SERVICED

BY:

90,000 Miles (150 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

I3 Inspect engine accessory drive belt (or

Control Service.

every 24 months, whichever occurs first). An Emission Control Service. 0 Inspect camshaft timing belt. An Emission 0 Drain, flush and refill cooling system (or every 24 months, whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service.

Maintenance Schedule I

0 Replace spark plugs. An Emission Control 0 Inspect spark plug wires. An Emission Control

Service.

Service. Replace air cleaner filter. Replace filter more often under dusty conditions. An Emission Control Service.

0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Elnission Control Service. 3

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

I DATE

I ACTUAL MILEAGE

ISERVICED

BY: I

7-23

1 Maintenance Schedule I 93,000 Miles (155 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

96,000 Miles (160 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 6 months, whichever occurs first).

DATE

ACTUAL MILEAGE

SERVICED BY.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-24

I Maintenance Schedule I 99,000 Miles (165 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

100,000 Miles (1 66 000 km) 0 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

If you do not use your vehicle under any of these conditions, the fluid and filter do not require changing.

I DATE

I ACTUALMILEAGE

ISERVICED BY1

7-25

I Maintenance Schedule I1

The services shown in this schedule up to 100,000 miles (166 000 km) should be performed after 100,000 miles (166 000 km) at the same intervals. Footnotes j- The U.S. Environmental Protection Agency or the California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of vehicle useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded.

7-26

7,500 Miles (12 500 km) 0 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE SERVICED BY:

~~

I Maintenance Schedule I1 I 15,000 Miles (25 000 km)

Change engine oil and filter (or every 12 months, whichever occurs first). AII Emission Corztr-ol Service. Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

22,500 Miles (37 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-27

I Maintenance Schedule I1 30,000 Miles (50 000 km)

Change engine oil and filter (or every 12 months, whichever occurs first). AH Ernissiorl Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

0 Inspect engine accessory drive belt (or

every 24 months, whichever occurs first). An Emission Control Service. 0 Drain, flush and refill cooling system (or every 24 months, whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Ernission Control Senice.

7-28

Service. Sen!ic*r. *I

0 Replace spark plugs. ,411 E i ~ i ~ ~ i 0 l 7 C m d 0 Inspect spark plug wires. AI? Emissio1z Control 0 Replace air cleaner filter. AI? E1~ission C o m d 0 Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any An Emissiou Control Service. * damage. Replace parts as needed.

SerLlice.

I Maintenance Schedule I1 1 37,500 Miles (62 500 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

45,000 Miles (75 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

ACTUAL MILEAGE SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-29

50,000 Miles (83 000 km) 0 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside temperature regularly reaches 90 O F (32°C) or higher.

delivery service.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or If you do not use your vehicle under uny of th.ese conditions, the fluid and filter do k i t require chunging. SERVICED B Y I

I ACTUAL MILEAGE

I DATE

7-30

52,500 Miles (87 500 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

DATE

ACTUAL MILEAGE

SERVICED B Y

1 Maintenance Schedule I1 I 60,000 Miles (100 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shft linkage, p a r h g brake cable

guides, underbody contact points and &age (or every 12 months, whchever occurs first).

0 Inspect engine accessory drive belt (or

Control Service.

every 24 months, whichever occurs first). An Emission Control Service. 0 Inspect camshaft timing belt. An Emission 0 Drain, flush and refill cooling system (or every 24 months, whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service.

Service.

0 Replace spark plugs. An Emission Control 0 Replace air cleaner filter. An Emission Control 0 Inspect fuel tank, cap and lines for damage

Service.

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

7-31

I Maintenance Schedule I1 67,500 Miles (112 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information.

75,000 Miles (125 000 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first). 0 Inspect camshaft timing belt. An Emission

Control Service.

DATE SERVICED

ACTUAL MILEAGE

BY:

I DATE

I ACTUAL MILEAGE ISERVICED

B Y I

7-32

82,500 Miles (137 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Ernixyim Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first). 0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information.

90,000 Miles (150 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). A11 Emissiorl Corztrol SPr-vic*e.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first). 0 Inspect engine accessory drive belt (or

every 24 months, whichever occurs first). An Emissiorl Co17trol Service. Inspect camshaft timing belt. AH E1nissim Coz~trol Serl!ic-.e.

DATE

ACTUAL MILEAGE

SERVICED B Y

(Continued)

7-33

I Maintenance Schedule I1

90,000 Miles (150 000 km) (Continued)

Drain, flush and refill cooling system (or every 24 months, whichever occurs first). See “Engine Coolant’’ in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service.

Service.

0 Replace spark plugs. An Emission Control 0 Replace air cleaner filter. An Emission Control c? Inspect spark plug wires. An Emission Control

Service. Service. 7

7-34

Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

I Maintenance Schedule I1 I 97,500 Miles (162 500 km) I7 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Lubricate the shift linkage, parking brake cable guides, underbody contact points and linkage (or every 12 months, whichever occurs first).

0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information.

100,000 Miles (166 000 km) 0 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

lfyou do not use your vehicle under any of these conditions, the fluid and filter do not require changing.

7-35

Part B: Owner Checks and Services Listed below are owner checks and services which should be performed at the intervals specified to help ensure the safety, dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to your vehicle, make sure they are the proper ones, as shown in Part D. At Each Fuel Fill It is important for you or a service station attendant to perform these underhood checks at each.fuelfil1.

Engine Oil Level Check the engine oil level and add the proper oil if necessary. See “Engine Oil” in the Index for further details.

Engine Coolant Level Check the engine coolant level and add the proper coolant mix if necessary. See “Coolant” in the Index for further details.

Windshield Washer Fluid Level Check the windshield washer fluid level in the windshield washer tank and add the proper fluid if necessary. See “Windshield Washer Fluid” in the Index for further details. At Least Once a Month Tire Inflation Check tire inflation. Make sure tires are inflated to the pressures specified on the Tire-Loading Information label. See “Loading Your Vehicle” in the Index. See “Tires” in the Index for further details.

Cassette Deck Clean cassette deck. Cleaning should be done every 50 hours of tape play. See “Audio Systems” in the Index for further details. At Least Once a Year Key Lock Cylinders Lubricate the key lock cylinders with the lubricant specified in Part D.

Body Lubrication Lubricate all hinges and latches, including those for the hood, rear compartment, glove box door, console door and any folding seat hardware. Part D tells you what to use. More frequent lubrication may be required when exposed to a corrosive environment.

Starter Switch

Brake-Transaxle Shift Interlock -- BTSI (Automatic Transaxle)

1. Before you start, be sure you have enough room

around the vehicle.

2. Firmly apply both the parking brake (see “Parking

Brake’’ in the Index if necessary) and the regular brake. NOTE: Do not use the accelerator pedal, and be ready to turn off the engine immediately if it starts.

3. Try to start the engine in each gear. The starter should work only in PARK (P) or NEUTRAL (N). If the starter works in any other position, your vehicle needs service.

1.

2.

3.

Before you start, be sure you have enough room around the vehicle. It should be parked on a level surface. Firmly apply the parking brake (see “Parking Brake’’ in the Index if necessary). NOTE: Be ready to apply the regular brake immediately if the vehicle begins to move. With the engine off, turn the key to the RUN position, but don’t start the engine. Without applying the regular brake, try to move the shift lever out of PARK (P) with normal effort. If the shift lever moves out of PARK (P), your vehicle’s BTSI needs service.

7-37

Steering Column Lock While parked, and with the parking brake set, try to turn the key to LOCK in each shift lever position. 0 The key should turn to LOCK only when the shift

lever is in PARK (P). The key should come out only in LOCK.

Parking Brake and Automatic Transaxle PARK (P) Mechanism Check

Park on a fairly steep hill, with the vehicle facing downhill. Keeping your foot on the regular brake, set the parking brake.

To check the parking brake: With the engine running and transaxle in NEUTRAL (N), slowly remove foot pressure from the regular brake pedal. Do this until the vehicle is held by the parking brake only. To check the PARK (P) mechanism’s holding ability: Shift to PARK (P). Then release all brakes.

Underbody Flushing At least every spring, use plain water to flush any corrosive materials from the underbody. Take care to clean thoroughly any areas where mud and other debris can collect.

Part C: Periodic Maintenance Inspections Listed below are inspections and services which should be performed at least twice a year (for instance, each spring and fall). You should let your GM dealer’s service department or other qualified service center do these jobs. Make sure any necessary repairs are completed at once. Restraint Systems Now and then, make sure all your belts, buckles, latch plates, retractors, anchorages and reminder systems are working properly. Look for any loose parts or damage. If you see anything that might keep a restraint system from doing its job, have it repaired. Steering, Suspension and Front-Wheel-Drive Axle Boot and Seal Inspection Inspect the front and rear suspension and steering system for damaged, loose or missing parts, signs of wear, or lack of lubrication. Inspect the power steering lines and hoses for proper hookup, binding, leaks, cracks, chafing, etc. Clean and then inspect the drive axle boot seals for damage, tears or leakage. Replace seals if necessary.

Exhaust System Inspection Inspect the complete exhaust system. Inspect the body near the exhaust system. Look for broken, damaged, missing or out-of-position parts as well as open seams, holes, loose connections, or other conditions which in the floor pan or could let could cause a heat build-up exhaust fumes into the vehicle. See “Engine Exhaust” in the Index. Throttle Linkage Inspection Inspect the throttle linkage for interference or binding, and for damaged or missing parts. Replace parts as needed. Brake System Inspection Inspect the complete system. Inspect brake lines and hoses for proper hookup, binding, leaks, cracks, chafing, etc. Inspect disc brake pads for wear and rotors for surface condition. Also inspect drum brake linings for wear and cracks. Inspect other brake parts, including drums, wheel cylinders, calipers, parking brake, etc. Check parking brake adjustment. You may need to have your brakes inspected more often if your driving habits or conditions result in frequent braking.

7-39

Part D: Recommended Fluids and Lubricants NOTE: Fluids and lubricants identified below by name, part number or specification may be obtained from your GM dealer.

USAGE

Engine Oil

Engine Coolant

FLUIDfiUBRICANT Engine oil with the American Petroleum Institute Certified For Gasoline Engines “Starburst” symbol of the proper viscosity. To determine the preferred viscosity for your vehicle’s engine, see “Engine Oil” in the Index. 50/50 mixture of water (preferably distilled) and good quality ethylene glycol base antifreeze (GM Part No. 1052753 or equivalent) conforming to GM Specification 1825M or approved recycled coolant conforming to GM Specification 1825M.

7-40

FLUIDfiUBRICANT USAGE

Coolant Supplement

GM Part No. 3634621 or equivalent with a complete flush and refill.

Hydraulic Brake Delco Supreme ll@ Brake Fluid System

(GM Part No. 1052535 or equivalent DOT-3 brake fluid). Chassis lubricant (GM Part No. 1052497 or equivalent) or lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB.

Parking Brake Guides

Power Steering GM Hydraulic Power Steering Fluid (GM Part No. 1052884 or System equivalent). DEXRON@-I11 Automatic Transmission Fluid. Lubricate with Multi-Purpose Lubricant (GM Part No. 12345 120) or synthetic SAE 5W-30 engine oil.

Automatic Transaxle Key Lock Cylinders

USAGE

Automatic Transaxle Shift Linkage Chassis Lubrication

Windshield Washer Solvent

Hood Latch Assembly a. Pivots and

Spring Anchor

b. Release Pawl

FLUID/LUBRICANT

Engine oil.

~ ~ ~ _ _ _ _ _

Chassis lubricant (GM Part No. 1052497 or equivalent) or lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB. GM Optikleen@ Washer Solvent (GM Part No. 1051515) or equivalent.

FLUID/LUBRICANT USAGE Hood and Door Hinges, Fuel Door Hinge Weatherstrip Conditioning

Engine oil or Lubriplate Lubricant (GM Part No. 1050109).

Dielectric Silicone Grease (GM Part No. 12345579 or equivalent).

See “Replacement Parts” in the Index for recommended replacement filters, valves and spark plugs.

a. Engine oil.

b. Chassis lubricant (GM Part

No. 1052497 or equivalent) or lubricant meeting requirements of NLGI Grade 2, Category LB or GC-LB.

Part E: Maintenance Record After the scheduled services are performed, record the date, odometer reading and who performed the service in the boxes provided after the maintenance interval.

Any additional information from “Owner Checks and Services” or “Periodic Maintenance” can be added on the following record pages. Also, you should retain all maintenance receipts. Your owner information portfolio is a convenient place to store them.

Maintenance Record

DATE

ODOMETER READING

BY

MAINTENANCE PERFORMED SERVICED

7-42

Maintenance Record

MAINTENANCE

PERFORMED

READING DATE

SERVICED

ODOMETER

BY

7-43

Maintenance Record

7-44

0 Section 8 Customer Assistance Information

Here you will find out how to contact Chevrolet if you need assistance. This section also tells you how to obtain service publications and how to report any safety defects. Customer Satisfaction Procedure Your satisfaction and goodwill are important to your dealer and Chevrolet. Normally, any concern with the sales transaction or the operation of your vehicle will be resolved by your dealer’s Sales or Service Departments. Sometimes, however, despite the best intentions of all concerned, misunderstandings can occur. If your concern has not been resolved to your satisfaction, the following steps should be taken: STEP ONE -- Discuss your concern with a member of dealership management. Normally, concerns can be quickly resolved at that level. If the matter has already been reviewed with the Sales, Service, or Parts Manager, contact the owner of the dealership or the General Manager.

STEP TWO -- If after contacting a member of dealership management, it appears your concern cannot be resolved by the dealer without further help, contact the Chevrolet Customer Assistance Center by calling 1-800-222- 1020. In Canada, contact GM of Canada Customer Assistance Center in Oshawa by calling 1-800-263-3777 (English) or 1-800-263-7854 (French). In Mexico, call (525) 254-3777. In Puerto Rico, call 1-800-496-9992 (English) or 1-800-496-9993 (Spanish). In the U.S. Virgin Islands, call 1-800-496-9994. In other overseas locations, contact GM North American Export Sales in Canada by calling 1-905-644-4112.

8-1

For prompt assistance, please have the following information available to give the Customer Assistance Representative: 0 Your name, address, home and business telephone

numbers

0 Vehicle Identification Number (This is available

from the vehicle registration or title, or the plate at the top left of the instrument panel and visible through the windshield.)

0 Dealership name and location 0 Vehicle delivery date and present mileage 0 Nature of concern We encourage you to call the toll-free number listed previously in order to give your inquiry prompt attention. However, if you wish to write Chevrolet, write to:

Chevrolet Motor Division Chevrolet Customer Assistance Center P.O. Box 7047 Troy, MI 48007-7047

Refer to your Warranty and Owner Assistance Information booklet for addresses of Canadian and GM Overseas offices. When contacting Chevrolet, please remember that your concern will likely be resolved in the dealership, using the dealership’s facilities, equipment and personnel. That is why we suggest you follow Step One first if you have a concern. Customer Assistance for the Hearing or Speech Impaired (TDD) To assist customers who have hearing difficulties, Chevrolet has installed special TDD (Telecommunication Devices for the Deaf) equipment at its Customer Assistance Center. Any hearing or speech impaired customer who has access to a TDD or a conventional teletypewriter (TTY) can communicate with Chevrolet by dialing: 1 -800-TDD-CHEV. (TDD users in Canada can dial 1-800-263-3830.)

8-2

GM Participation in BBB AUTO LINE - Alternative Dispute Resolution Program* *This program may not be available in all states, depending on state law. Canadian owners refer to your Warranty and Owner Assistance Information booklet. General Motors reserves the right to change eligibility limitations and/or to discontinue its participation in this program. Both Chevrolet and your Chevrolet dealer are committed to making sure you are completely satisfied with your new vehicle. Our experience has shown that, if a situation arises where you feel your concern has not been adequately addressed, the Customer Satisfaction Procedure described earlier in this section is very successful. There may be instances where an impartial third-party can assist in arriving at a solution to a disagreement regarding vehicle repairs or interpretation of the New Vehicle Limited Warranty. To assist in resolving these disagreements, Chevrolet voluntarily participates in BBB AUTO LINE.

BBB AUTO LINE is an out-of-court program administered by the Better Business Bureau system to settle disputes between customers and automobile manufacturers. This program is available free of charge to customers who currently own or lease a GM vehicle. If you are not satisfied after following the Customer Satisfaction Procedure, you may contact the BBB using the toll-free telephone number, or write them at the following address:

BBB AUTO LINE Council of Better Business Bureaus 4200 Wilson Boulevard Suite 800 Arlington, VA 22203 Telephone: 1-800-955-5 100

To file a claim, you will be asked to provide your name and address, your Vehicle Identification Number (VIN), and a statement of the nature of your complaint. Eligibility is limited by vehicle age and mileage, and other factors.

We prefer you utilize the Customer Satisfaction Procedure before you resort to AUTO LINE, but you may contact the BBB at any time. The BBB will attempt to resolve the complaint serving as an intermediary between you and Chevrolet. If this mediation is unsuccessful, an informal hearing will be scheduled where eligible customers may present their case to an impartial third-party arbitrator. The arbitrator will make a decision which you may accept or reject. If you accept the decision, GM will be bound by that decision. The entire dispute resolution procedure should ordinarily take about forty days from the time you file a claim until a decision is made. Some state laws may require you to use this program before filing a claim with a state-run arbitration program or in the courts. For further information, contact the BBB at 1-800-955-5100 or the Chevrolet Customer Assistance Center at 1-800-222- 1020.

REPORTING SAFETY DEFECTS TO THE UNITED STATES GOVERNMENT If you believe that your vehicle has a defect which could cause a crash or could cause injury or death, you should immediately inform the National Highway Traffic Safety Administration (NHTSA), in addition to notifying General Motors. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, or General Motors. To contact NHTSA, you may either call the Auto Safety Hotline toll-free at 1-800-424-9393 (or 366-0123 in the Washington, D.C. area) or write to:

NHTSA, U.S. Department of Transportation Washington, D.C. 20590

You can also obtain other information about motor vehicle safety from the Hotline.

8-4

REPORTING SAFETY DEFECTS TO THE CANADIAN GOVERNMENT If you live in Canada, and you believe that your vehicle has a safety defect, you should immediately notify Transport Canada, in addition to notifying General Motors of Canada Limited. You may write to:

Transport Canada Box 8880 Ottawa, Ontario K1G 352.

REPORTING SAFETY DEFECTS TO GENERAL MOTORS In addition to notifying NHTSA (or Transport Canada) in a situation like this, we certainly hope you’ll notify us. Please call us at 1-800-222-1020, or write:

Chevrolet Motor Division Chevrolet Customer Assistance Center P.O. Box 7047 Troy, MI 48007-7047

In Canada, please call us at 1-800-263-3777 (English) or 1-800-263-7854 (French). Or, write: General Motors of Canada Limited Customer Assistance Center 1908 Colonel Sam Drive Oshawa, Ontario LlH 8P7

Chevrolet Roadside Assistance Program To enhance Chevrolet’s strong commitment to customer satisfaction, Chevrolet is excited to announce the establishment of the ChevroletIGeo Roadside Assistance Center. As the owner of a 1995 ChevroletIGeo, your membership in Roadside Assistance is free. 24-Hour Roadside Assistance Number Roadside Assistance is available 24 hours a day, 365 days a year’ by calling 1-800-CHEV USA (1-800-243-8872). This toll-free number will provide you over-the-phone roadside assistance with minor mechanical problems. If your problem cannot be resolved over the phone, our advisors have access to a nationwide network of dealer recommended service providers.

8-5

The following services are available: 0 Towing

Locksmith 0 Tire repair 0 Glass replacement 0 Rental car or taxi 0 Additional services, as necessary 0 Courtesy Transportation Courtesy Transportation Chevrolet/Geo offers Courtesy Transportation for customers needing warranty service. Courtesy Transportation will be offered in conjunction with the coverage provided by the BUMPER TO BUMPER New Vehicle Limited Warranty to eligible purchasers of 1995 Chevrolet/Geo passenger car and light duty trucks (please see your selling dealer for details). Courtesy Transportation Includes: 0 One way shuttle ride for any warranty repair

completed during the same day. Up to $30 maximum daily vehicle rental allowance for any overnight warranty repair up to 5 days, OR

Up to $30 maximum daily cab, bus or other transportation allowance in lieu of rental for any overnight warranty repair up to 5 days, OR Up to $10 daily fuel allowance for rides provided by another person (i.e., friend, neighbor, etc.) in lieu of rental or any overnight warranty repair up to 5 days. NOTE: All Courtesy Transportation arrangements will be administered by your Chevrolet/Geo dealership service management. Claim amounts should reflect all actual costs. Chevrolet/Geo Courtesy Transportation is not part of the BUMPER TO BUMPER New Vehicle Limited Warranty. Chevrolet/Geo reserves the right to make any changes or discontinue Courtesy Transportation at any time without notification. For additional program details contact your Chevrolet/Geo dealer.

In Canada, please consult your GM dealer for information on courtesy transportation. The Roadside Assistance Center uses companies that will provide you with quality and priority service. When roadside services are required, our advisors will explain any payment obligations that may be incurred for utilizing outside services.

8-6

For prompt assistance when calling, please have the following information available to give to the advisor:

Vehicle Identification Number

0 License plate number 0 Vehicle color 0 Vehicle location 0 Telephone number where you can be reached 0 Vehicle mileage 0 Description of problem Canadian Roadside Assistance Vehicles purchased in Canada have an extensive Roadside Assistance program accessible from anywhere in Canada or the United States. Please refer to the separate brochure provided by the dealer or call 1-800-268-6800 for emergency services.