1997 Chevrolet Malibu Owners Manual

tire’s rubber.

The tread or sidewall is cracked, cut or snagged deep enough to show cord or fabric. The tire has a bump, bulge or split.

0 The tire has a puncture, cut or other damage that

can’t be repaired well because of the size or location of the damage.

Buying New Tires To find out what kind and size of tires you need, look at the Tire-Loading Information label. The tires installed on your vehicle when it was new had a Tire Performance Criteria Specification (TPC Spec) number on each tire’s sidewall. When you get new tires, get ones with that same TPC Spec number. That way your vehicle will continue to have tires that are designed to give proper endurance, handling, speed rating, traction, ride and other things during normal service on your vehicle. If your tires have an all-season tread design, the TPC number will be followed by an “MS” (for mud and snow).

6-39

If you ever replace your tires with those not having a TPC Spec number, make sure they are the same size, load range, speed rating and construction type (bias, bias-belted or radial) as your original tires.

Mixing tires could cause you to lose control while driving. If you mix tires of different sizes or types (radial and bias-belted tires), the vehicle may not handle properly, and you could have a crash. Using tires of different sizes may also cause damage to your vehicle. Be sure to use the same size and type tires on all wheels. It’s all right to drive with your compact spare, though. It was developed for use on your vehicle.

Uniform Tire Quality Grading The following information relates to the system developed by the United States National Highway Traffic Safety Administration, which grades tires by treadwear, traction and temperature performance. (This applies only to vehicles sold in the United States.) The grades are molded on the sidewalls of most passenger car tires. The Uniform Tire Quality Grading system does not apply to deep tread, winter-type snow tires, space-saver or temporary use spare tires, tires with nominal rim diameters of 10 to 12 inches (25 to 30 cm), or to some limited-production tires. While the tires available on General Motors passenger cars and light trucks may vary with respect to these grades, they must also conform to Federal safety requirements and additional General Motors Tire Performance Criteria (TPC) standards.

6-40

Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled conditions on a specified government test course. For example, a tire graded 150 would wear one and a half (1 1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual conditions of their use, however, and may depart significantly from the norm due to variations in driving habits, service practices and differences in road characteristics and climate. Traction -- A, B, C The traction grades, from highest to lowest, are A, B, and C, and they represent the tire’s ability to stop on wet pavement as measured under controlled conditions on specified government test surfaces of asphalt and concrete. A tire marked C may have poor traction performance. Warning: The traction grade assigned to this tire is based on braking (straight ahead) traction tests and does not include cornering (turning) traction.

Temperature -- A, B, C The temperature grades are A (the highest), B, and C, representing the tire’s resistance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure. The grade C corresponds to a level of performance which all passenger car tires must meet under the Federal Motor Vehicle Safety Standard No. 109. Grades B and A represent higher levels of performance on the laboratory test wheel than the minimum required by law. Warning: The temperature grade for this tire is established for a tire that is properly inflated and not overloaded. Excessive speed, underinflation, or excessive loading, either separately or in combination, can cause heat buildup and possible tire

failure.

6-41

Wheel Alignment and Tire Balance The wheels on your vehicle were aligned and balanced carefully at the factory to give you the longest tire life and best overall performance. Scheduled wheel alignment and wheel balancing are not needed. However, if you notice unusual tire wear or your vehicle pulling one way or the other, the alignment may need to be reset. If you notice your vehicle vibrating when driving on a smooth road, your wheels may need to be rebalanced. Wheel Replacement Replace any wheel that is bent, cracked, or badly rusted or corroded. If wheel nuts keep coming loose, the wheel, wheel bolts and wheel nuts should be replaced. If the wheel leaks air, replace it (except some aluminum wheels, which can sometimes be repaired). See your Chevrolet dealer if any of these conditions exist.

Your dealer will know the kind of wheel you need. Each new wheel should have the same load-carrying capacity, diameter, width, offset and be mounted the same way as the one it replaces. If you need to replace any of your wheels, wheel bolts or wheel nuts, replace them only with new GM original equipment parts. This way, you will be sure to have the right wheel, wheel bolts and wheel nuts for your Chevrolet model.

Using the wrong replacement wheels, wheel bolts or wheel nuts on your vehicle can be dangerous. It could affect the braking and handling of your vehicle, make your tires lose air and make you lose control. You could have a collision in which you or others could be injured. Always use the correct wheel, wheel bolts and wheel nuts for replacement.

6-42

Tire Chains

NOTICE:

Use tire chains only where legal and only when you must. Use only SAE Class “St’ type chains that are the proper size for your tires. Install them on the front tires and tighten them as tightly as possible with the ends securely fastened. Drive slowly and follow the chain manufacturer’s instructions. If you can hear the chains contacting your vehicle, stop and retighten them. If the contact continues, slow down until it stops. Driving too fast or spinning the wheels with chains on will damage your vehicle.

NOTICE:

The wrong wheel can also cause problems with bearing life, brake cooling, speedometer or odometer calibration, headlamp aim, bumper height, vehicle ground clearance and tire or tire chain clearance to the body and chassis.

See “Changing a Flat Tire” in the Index for more information.

Used Replacement Wheels

Putting a used wheel on your vehicle is dangerous. You can’t know how it’s been used or how far it’s been driven. It could fail suddenly and cause an accident. If you have to replace a wheel, use a new GM original equipment wheel.

Appearance Care Remember, cleaning products can be hazardous. Some are toxic. Others can burst into flame if you strike a match or get them on a hot part of the vehicle. Some are dangerous if you breathe their fumes in a closed space. When you use anything from a container to clean your Chevrolet, be sure to follow the manufacturer’s warnings and instructions. And always open your doors or windows when you’re cleaning the inside. Never use these to clean your vehicle:

Gasoline 0 Benzene Naphtha

0 Carbon Tetrachloride

Acetone

0 Paint Thinner

Turpentine

0 Lacquer Thinner

Nail Polish Remover

They can all be hazardous -- some more than others -- and they can all damage your vehicle, too.

Don’t use any of these unless this manual says you can. In many uses, these will damage your vehicle:

Alcohol

0 Laundry Soap

Bleach Reducing Agents

Cleaning the Inside of Your Chevrolet Use a vacuum cleaner often to get rid of dust and loose dirt. Wipe vinyl or leather with a clean, damp cloth. Your Chevrolet dealer has two cleaners, a solvent-type spot lifter and a foam-type powdered cleaner. They will clean normal spots and stains very well. Do not use them on vinyl or leather. Here are some cleaning tips: 1. Always read the instructions on the cleaner label. 2. Clean up stains as soon as you can -- before they set. 3. Use a clean cloth or sponge, and change to a clean area

often. A soft brush may be used if stains are stubborn. 4. Use solvent-type cleaners in a well-ventilated area

only. If you use them, don’t saturate the stained area.

5. If a ring forms after spot cleaning, clean the entire

area immediately or it will set.

Using Foam-Type Cleaner on Fabric 1. Vacuum and brush the area to remove any loose dirt. 2. Always clean a whole trim panel or section. Mask

surrounding trim along stitch or welt lines.

3. Mix Multi-Purpose Powdered Cleaner following the

directions on the container label.

4. Use suds only and apply with a clean sponge. Don’t

saturate the material and don’t rub it roughly.

5. As soon as you’ve cleaned the section, use a sponge

to remove the suds.

6. Rinse the section with a clean, wet sponge. 7. Wipe off what’s left with a slightly damp paper towel

or cloth.

8. Dry it immediately with a blow dryer. 9. Wipe with a clean cloth.

Using Solvent-Type Cleaner on Fabric First, see if you have to use solvent-type cleaner at all. Some spots and stains will clean off better with just water and mild soap. If you need to use a solvent: 1. Gently scrape excess soil from the trim material with

a clean, dull knife or scraper.

2. Use very little cleaner, light pressure and clean cloths

(preferably cheesecloth). Cleaning should start at the outside of the stain, “feathering” toward the center.

3. Keep changing to a clean section of the cloth. 4. When you clean a stain from fabric, immediately dry the area with a blow dryer to help prevent a cleaning ring.

6-45

Special Cleaning Problems Greasy or Oily Stains Stains caused by grease, oil, butter, margarine, shoe polish, coffee with cream, chewing gum, cosmetic creams, vegetable oils, wax crayon, tar and asphalt can be removed as follows: 1. Carefully scrape off excess stain. 2. Follow the solvent-type instructions described

earlier.

Shoe polish, wax crayon, tar and asphalt will stain if left on a vehicle’s seat fabric. They should be removed as soon as possible. Be careful, because the cleaner will dissolve them and may cause them to spread. Non-C :--y Stains Stains caused by catsup, coffee (black), egg, fruit, fruit juice, milk, soft drinks, wine, vomit, urine and blood can be removed as follows: 1. Carefully scrape off excess stain, then sponge the

soiled area with cool water.

2. If a stain remains, follow the foam-type instructions

described earlier.

3. If an odor lingers after cleaning vomit or urine,

treat the area with a waterhaking soda solution: 1 teaspoon (5 ml) of baking soda to 1 cup (250 ml) of lukewarm water.

4. If needed, clean lightly with solvent-type cleaner. Combination Stains Stains caused by candy, ice cream, mayonnaise, chili sauce and unknown stains can be removed as follows: 1. Carefully scrape off excess stain. 2. Clean with cool water and allow to dry. 3. If a stain remains, clean it with solvent-type cleaner. Cleaning Vinyl Use warm water and a clean cloth.

Rub with a clean, damp cloth to remove dirt. You may have to do it more than once.

0 Things like tar, asphalt and shoe polish will stain

if you don’t get them off quickly. Use a clean cloth and a vinyueather cleaner. See your dealer for this product.

6-46

-leaning the Top of the Instrument Panel use only mild soap and water to clean the top surfaces of the instrument panel. Sprays containing silicones or waxes may cause annoying reflections in the windshield and even make it difficult to see through the windshield under certain conditions. Care of Safety Belts Keep belts clean and dry.

\ CAUTION:

Do not bleach or dye safety belts. may severely weaken them. In a crash, they might not be able to provide adequate protection. Clean safety belts only with mild soap and lukewarm water.

If you do, it

Glass Glass should be cleaned often. GM Glass Cleaner (GM Part No. 1050427) or a liquid household glass cleaner will remove normal tobacco smoke and dust films on interior glass. Don't use abrasive cleaners on glass, because they may inside rear cause scratches. Avoid placing decals on the If window, since they may have to be scraped off later. abrasive cleaners are used on the inside of the rear window, an electric defogger element may be damaged. Any temporary license should not be attached across the defogger grid.

6-47

Cleaning the Outside of the Windshield and Wiper Blades If the windshield is not clear after using the windshield washer, or if the wiper blade chatters when running, wax, sap or other material may be on the blade or windshield. Clean the outside of the windshield with GM Windshield Cleaner, Bon Ami@ Powder (non-scratching glass cleaning powder), GM Part No. 105001 1. The windshield is clean if beads do not form when you rinse it with water. Grime from the windshield will stick to the wiper blades and affect their performance. Clean the blade by wiping vigorously with a cloth soaked in full-strength windshield washer solvent. Then rinse the blade with water. Check the wiper blades and clean them as necessary; replace blades that look worn.

Weatherstrips Silicone grease on weatherstrips will make them last longer, seal better, and not stick or squeak. Apply silicone grease with a clean cloth at least every six months. During very cold, damp weather more frequent application may be required. (See “Recommended Fluids and Lubricants” in the Index.) Cleaning the Outside of Your Chevrolet The paint finish on your vehicle provides beauty, depth of color, gloss retention and durability. Washing Your Vehicle The best way to preserve your vehicle’s finish is to keep it clean by washing it often with lukewarm or cold water. Don’t wash your vehicle in the direct rays of the sun. Don’t use strong soaps or chemical detergents. Use liquid hand, dish or car washing (mild detergent) soaps. Don’t use cleaning agents that are petroleum based, or that contain acid or abrasives. All cleaning agents should be flushed promptly and not allowed to dry on the surface, or they could stain. Dry the finish with a soft, clean chamois or an all-cotton towel to avoid surface scratches and water spotting.

6-48

High pressure car washes may cause water to enter your vehicle.

NOTICE:

Cleaning Exterior LampsLenses Use lukewarm or cold water, a soft cloth and a liquid hand, dish or vehicle washing (mild detergent) soap to clean exterior lamps and lenses. Follow instructions under “Washing Your Vehicle.” Finish Care Occasional waxing or mild polishing of your Chevrolet by hand may be necessary to remove residue fkom the paint finish. You can get GM-approved cleaning products from your dealer. (See “Appearance Care and Materials” in the Index.) Your Chevrolet has a “basecoatklearcoat” paint finish. The clearcoat gives more depth and gloss to the colored basecoat. Always use waxes and polishes that are non-abrasive and made for a basecoatklearcoat paint finish.

Machine compounding or aggressive polishing on a basecoat/clearcoat paint finish may dull the finish or leave swirl marks.

Foreign materials such as calcium chloride and other salts, ice melting agents, road oil and tar, tree sap, bird droppings, chemicals from industrial chimneys, etc., can damage your vehicle’s finish if they remain on painted surfaces. Wash the vehicle as soon as possible. If necessary, use non-abrasive cleaners that are marked safe for painted surfaces to remove foreign matter. Exterior painted surfaces are subject to aging, weather and chemical fallout that can take their toll over a period of years. You can help to keep the paint finish looking new by keeping your Chevrolet garaged or covered whenever possible.

6-49

Aluminum Wheels (If Equipped) Keep your wheels clean using a soft clean cloth with mild soap and water. Rinse with clean water. After rinsing thoroughly, dry with a soft clean towel. A wax may then be applied. The surface of these wheels is similar to the painted surface of your vehicle. Don’t use strong soaps, chemicals, abrasive polishes, abrasive cleaners or abrasive cleaning brushes on them because you could damage the surface. Don’t take your vehicle through an automatic car wash that has silicon carbide tire cleaning brushes. These brushes can also damage the surface of these wheels.

Tires To clean your tires, use a stiff brush with a tire cleaner.

NOTICE:

When applying a tire dressing always take care to wipe off any overspray or splash from all painted surfaces on the body or wheels of the vehicle. Petroleum-based products may damage the paint finish.

Sheet Metal Damage If your vehicle is damaged and requires sheet metal repair or replacement, make sure the body repair shop applies anti-corrosion material to the parts repaired or replaced to restore corrosion protection.

6-50

Chemical Paint Spotting Some weather and atmospheric conditions can create a chemical fallout. Airborne pollutants can fall upon and attack painted surfaces on your vehicle. This damage can take two forms: blotchy, ringlet-shaped discolorations, and small irregular dark spots etched into the paint surface. Although no defect in the paint job causes this, Chevrolet will repair, at no charge to the owner, the surfaces of new vehicles damaged by this fallout condition within 12 months or 12,000 miles (20 000 km) of purchase, whichever occurs first.

Finish Damage Any stone chips, fractures or deep scratches in the finish should be repaired right away. Bare metal will corrode quickly and may develop into a major repair expense. Minor chips and scratches can be repaired with touch-up materials available from your dealer or other service outlets. Larger areas of finish damage can be corrected in your dealer’s body and paint shop. .erbody Maintenance Chemicals used for ice and snow removal and dust control can collect on the underbody. If these are not removed, accelerated corrosion (rust) can occur on the underbody parts such as he1 lines, frame, floor pan and exhaust system even though they have corrosion protection. At least every spring, flush these materials from the underbody with plain water. Clean any areas where mud and other debris can collect. Dirt packed in closed areas of the frame should be loosened before being flushed. Your dealer or an underbody car washing system can do this for you.

6-51

Appearance Care Materials Chart

6-52

Vehicle -dentification Number (VIN)

L e

ENGINE A

CODE MODEL YEAR

f \ ASSEMBLY

PLANT

Service Parts Identification Label You’ll find this label on your spare tire cover. It’s very helpful if you ever need to order parts. On this label is:

your VIN, the model designation, paint information and a list of all production options and special equipment.

This is the legal identifier for your Chevrolet. It appears on a plate in the front comer of the instrument panel, on Be sure that this label the driver’s side. You can see it if you look through the windshield from outside your vehicle. The VIN also appears on the Vehicle Certification and Service Parts labels and the certificates of title and registration. Engine Iden The 8th character m your VIN is the engine code. This code will help you identify your engine, specifications and replacement parts.

-. .-on

. ..

is not removed from the vehicle.

6-53

Electrical System Add-on Electrical Equipment

NOTICE:

Don’t add anything electrical to your Chevrolet unless you check with your dealer first. Some electrical equipment can damage your vehicle and the damage wouldn’t be covered by your warranty. Some add-on electrical equipment can keep other components from working as they should.

Your vehicle has an air bag system. Before attempting to add anything electrical to your Chevrolet, see “Servicing Your Air Bag-Equipped Chevrolet” in the Index.

Headlamp Wiring The headlamp wiring is protected by fuses, one for each headlamp, in the fuse block. An electrical overload will cause the lamps to turn off. If this happens, have your headlamp wiring checked right away.

dshield Wipers

lne windshield wiper motor is protected by an internal circuit breaker and a fuse. If the motor overheats due to heavy snow, etc., the wiper will stop until the motor cools. If the overload is caused by some electrical problem and not snow, etc., be sure to get it fixed. Power Windows and Other Power Options Circuit breakers in the fuse block protect the power windows and other power accessories. When the current load is too heavy, the circuit breaker opens and closes, protecting the circuit until the problem is fixed or goes away.

6-54

Instrument Panel Fuse Block

The instrument panel fuse blocks are located at each end of the instrument panel. To access the fuses, open the fuse panel door by pulling out. To replace the door, insert the hooks at the front end first, then push the door in to the instrument panel to

I secure it.

Fuses and Circuit Breakers The wiring circuits in your vehicle are protected from short circuits by a combination of fuses, circuit breakers and fusible thermal links in the wiring itself. This greatly reduces the chance of fires caused by electrical problems. Look at the silver-colored band inside the fuse. If the band is broken or melted, replace the fuse. Be sure you replace a bad fuse with a new one of the identical size and rating. If you ever have a problem on the road and don’t have a spare fuse, you can borrow one that has the same amperage. Just pick a feature of your vehicle that you can get along without -- like the radio or cigarette lighter -- and use its fuse, if it is the correct amperage. Replace it as soon as you can. Also, there are spare fuses in the left side instrument panel door. There are three fuse blocks in your vehicle: two instrument panel fuse blocks and the engine compartment fuse block.

6-55

Instrument Panel Fuse Block - Left

In the left instrument panel fuse block, there are spare fuses and a fuse puller.

MICRO

u n o

STOP HAZARD

IPCMVAC

Usage Radio Wipers Trunk Release and Remote Lock Control Turn Signals

STOP LPS HAZARD LPS IPCMYAC BATT MICRO RELAY TRUNK REL CIRCUIT BRKR PWR SEATS MICRO RELAY DR UNLOCK MICRO RELAY DR LOCK MICRO RELAY DRIVERS DR UNLOCK

6-56

Usage Power Mirrors Air Bag Body Function Control Module Powertrain Control Module Door Locks Body Function Control Module, Cluster Stoplamps Hazard Lamps Cluster, Climate Control Remote Trunk Release

Power Seats

Door Locks

Door Locks

Not Used

Instrument Panel Fuse Block - Right

SPARE FUSES

A. INST LPS 6. CRUISE SW C. HVAC BLOWER D. CRUISE E. FOG LPS F. INT LPS G. RDO BATT H. SUNROOF

CIRCUIT R WNDWS

MICRO

Fuse A)

Usage Instrument Panel Lights, Dimmer Cruise Control Climate Control System

Usage Cruise Control Fog Lamps Interior Lamps, Body Function Control Module Radio Sunroof Power Windows

Fog Lamps

CIRCUIT BRKR PWR WINDOWS MICRO RELAY FOG LPS

6-57

Engine Compartment Fuse Block

The engine compartment fuse block is located on the driver’s side of the engine compartment, near the air cleaner.

Fuse Maxi-Fuses 1) 2)

Usage

Ignition Switch Left-Hand Electrical Center-Power Seats, Power Mirrors, Door Locks, Trunk Release and Remote Lock Control

6-58

3)

4)

Left-Hand Electrical Center-Stoplamps, Hazard Lamps, Body Function Control Module, Cluster, Climate Control System Right-hand Electrical Center-Fog Lamps, Radio, Body Function Control Module, Interior Lamps Ignition Switch Not Used Anti-Lock Brakes Cooling Fans

Rear Defog Not Used Anti-Lock Brakes Cooling Fan HVAC Blower (Climate Control) Cooling Fans Cooling Fans

35) 36) 37)

3 8)

Air Conditioning Compressor Not Used Fuel Pump Automatic Light Control Automatic Light Control Horn Daytime Running Lamps

Spare Fuses Rear Defog Accessory Power Outlets, Cigar Lighter Anti-Lock Brakes Anti-Lock Brakes Air Conditioning Compressor, Body Function Control Module Automatic Transaxle

6-59

Mini-Fuses 39)

Mini-Fuses 47)

Powertrain Control Module, Ignition Anti-Lock Brakes Ignition System Back-up Lamps, Brake-Transaxle Shift Interlock Horn Powertrain Control Module Parking Lamps Rear Defog, Daytime Running Lamps, Climate Control System

Canister Purge Valve, Powertrain Control Module, Exhaust Gas Recirculation, Heated 0 2 Sensor Fuel Pump, Injectors Generator Right-Hand Headlamp Left-Hand Headlamp Cooling Fan WAC Blower (Climate Control ) Fuse Puller for Mini-Fuses Tach Test Point for Diagnostic Testing

6-60

Lamps

Replacement Bulbs Outside High-Beam Headlamp .................... .................... Low-Beam Headlamp Front Park/Turn ...................... Back-UpRear Turn ...................... High Level Stop .......................... TaiVStoplamp ........................... Inside Dome ..................................

9005 9006 3 157 NA 3 156 921 3057

561

Capacities and Specifications Engine Crankcase 2.4L Engine .................... 4 quarts (3.8 L) 3 100 Engine .................. 4.5 quarts (4.3 L) Cooling System 2.4L Engine ................. 11.3 quarts (10.7 L) 3100 Engine ................ 13.6 quarts (12.9 L) Refrigerant, Air Conditioning . . . . . See refrigerant charge label under the hood. Fuel Tank ................. 15.2 gallons (57.5 L) Tire Pressures, Sizes ........... See Tire-Loading Information label on the rear driver’s side passenger door. Wheel Nut Torque .......... 100 lb-ft (140 N-m) NOTE: All capacities are approximate. When adding, be sure to fill to the appropriate level or as recommended in this manual. See “Recommended Fluids and Lubricants” in the Index.

6-61

2.4L Engine Specifications VIN Engine Code ........................... Type .................................... L4 Displacement ........................ 2.4 Liters Firing Order .......................... 1-3-4-2 Horsepower ............................. 150 Thermostat Temperature ........... 180°F (82°C) 3100 Engine Specifications VIN Engine Code ........................... M Type .................................... V6 Displacement ........................ 3.1 Liters Firing Order ...................... 1-2-3-4-5-6 Horsepower ............................. 155 Thermostat Temperature ........... 195°F (91 “C) Air Conditioning Refrigerants Not all air conditioning refrigerants are the same. If the air conditioning system in your vehicle needs is used. refrigerant, be sure the proper refrigerant If you’re not sure, ask your Chevrolet dealer.

6-62

Normal Maintenance Replacement Parts Air Cleaner Element 2.4L ....................... AC Type A- 1279C 3 100 ....................... AC Type A- 1279C Engine Oil Filter 2.4L .......................... AC Type PF-44 3100 .......................... ACTypePF-47 Spark Plugs 2.4L .......... AC Q p e 041 -9 10 (Platinum Plug) Gap: 0.060 inch (1.52 mm) 3100 .......... AC Type 04 1-940 (Platinum Plug) Gap: 0.060 inch (1.52 mm) Windshield Wiper Blades Passenger’s Side ............... 19 inches (48 cm) Driver’s Side ................. 22 inches (56 cm) Dimensions Length ................. 190.4 inches (483.7 cm) Width ................... 69.4 inches (176.3 cm) Height ................... 56.4 inches (143.2 cm) Wheelbase ................ 107 inches (271 -9 cm) Front Tread ................ .59 inches (149.9 cm) Rear Tread ............... 59.3 inches (1 50.5 cm)

0 Section 7 Maintenance Schedule

This section covers the maintenance required for your Chevrolet. Your vehicle needs these services to retain its safety, dependability and emission control performance.

7-2 7-2 7-3 7-4 7-4 7-5 7-5 7-6 7-6

Introduction to Your Maintenance Schedule Your Vehicle and the Environment How this Section is Organized Using Your Maintenance Schedule Selecting the Right Schedule for Your Vehicle Short Trip/City Definition Short TripKity Intervals Long TripMghway Definition Long TripMghway Intervals

7-37 7-37 7-38 7-38 7-41 7-42 7-43 7-43

Owner Checks at Each Fuel Fill-up What to Check at Least Once a Month What to Check at Least Twice a Year What to Check at Least Once a Year Periodic Maintenance Inspections Recommended Fluids and Lubricants Tips for Keeping Track of Maintenance A Place to Record Maintenance Procedures

Introduction Your Vehicle and the Environment Proper vehicle maintenance not only helps to keep your vehicle in good working condition, but also helps the environment. All recommended maintenance procedures are important. Improper vehicle maintenance can even affect the quality of the air we breathe. Improper fluid levels or the wrong tire inflation can increase the level of emissions from your vehicle. To help protect our environment, and to keep your vehicle condition, please maintain your vehicle properly.

in good

IMPORTANT: KEEP ENGINE OIL AT THE PROPER RECOMMENDED

LEVEL AND CHANGE AS

1 Protection Plan

Have you purchased the GM Protection Plan? The Plan supplements your new vehicle warranties. See your Warranty and Owner Assistance booklet, or your Chevrolet dealer for details.

7-2

How This Section is Organized The remainder of this section is divided into five parts: “Part A: Scheduled Maintenance Services” shows what to have done and how often. Some of these services can be complex, so unless you are technically qualified and have the necessary equipment, you should let your dealer’s service department or another qualified service center do these jobs.

Performing maintenance work on a vehicle can be dangerous. In trying to do some jobs, you can be seriously injured. Do your own maintenance work only if you have the required know-how and the proper tools and equipment for the job. If you have any doubt, have a qualified technician do the work.

If you are skilled enough to do some work on your vehicle, you will probably want to get the service information GM publishes. See “Service and Owner Publications’’ in the Index.

“Part B: Owner Checks and Services” tells you what should be checked and when. It also explains what you can easily do to help keep your vehicle in good condition. “Part C: Periodic Maintenance Inspections’’ explains important inspections that your Chevrolet dealer’s service department or another qualified service center should perform. “Part D: Recommended Fluids and Lubricants” lists some products GM recommends to help keep your vehicle properly maintained. These products, or their equivalents, should be used whether you do the work yourself or have it done. “Part E: Maintenance Record” provides a place for you to record the maintenance performed on your vehicle. Whenever any maintenance is performed, be sure to write it down in this part. This will help you determine when your next maintenance should be done. In addition, it is a good idea to keep your maintenance receipts. They may be needed to qualify your vehicle for warranty repairs.

7-3

The proper fluids and lubricants to use are listed in Part D. Make sure whoever services your vehicle uses these. All parts should be replaced and all necessary repairs done before you or anyone else drives the vehicle. These schedules are for vehicles that:

carry passengers and cargo within recommended limits. You will find these limits on your vehicle’s Tire-Loading Information label. See “Loading Your Vehicle” in the Index.

0 are driven on reasonable road surfaces within legal

driving limits. use the recommended fuel. See “Fuel” in the Index.

Selecting the Right Schedule First you’ll need to decide which of the two schedules is right for your vehicle. Here’s how to decide which schedule to follow:

Part A: Scheduled Maintenance Services Using Your Maintenance Schedule We at General Motors want to help you keep your vehicle in good working condition. But we don’t know exactly how you’ll drive it. You may drive very short distances only a few times a week. Or you may drive long distances all the time in very hot, dusty weather. You may use your vehicle in making deliveries. Or you may drive it to work, to do errands or in many other ways. Because of all the different ways people use their GM vehicles, maintenance needs vary. You may even need more frequent checks and replacements than you’ll find in the schedules in this section. So please read this section and note how you drive. If you have any questions on how to keep your vehicle condition, see your Chevrolet dealer. This part tells you the maintenance services you should have done and when you should schedule them. If you go to your dealer for your service needs, you’ll know that GM-trained and supported service people will perform the work using genuine GM parts.

in good

7-4

Maintenance Schedule I Short Trip/City Definition Follow the Short Trip/City Maintenance Schedule if any one of these conditions is true for your vehicle:

Most trips are less than 5 to 10 miles (8 to 16 km). This is particularly important when outside temperatures are below freezing.

0 Most trips include extensive idling (such as frequent

driving in stop-and-go traffic). Most trips are through dusty areas.

0 You frequently tow a trailer or use a carrier on top of your vehicle. (With some models, you should never tow a trailer. See “Towing a Trailer” in the Index.)

0 If the vehicle is used for delivery service, police, taxi

or other commercial application.

One of the reasons you should follow this schedule if you operate your vehicle under any of these conditions is that these conditions cause engine oil to break down soonep:

Short Trip/City Intervals

Every 3,000 Miles (5 000 km): Engine Oil and Filter

Change (or 3 months, whichever occurs first). Every 6,000 Miles (10 000 km): Tire Rotation. Every 15,000 Miles (25 000 km): Air Cleaner Filter

Inspection, if driving in dusty conditions.

Every 30,000 Miles (50 000 km): Air Cleaner Filter Replacement. Fuel Tank, Cap and Lines Inspection. Every 50,000 Miles (83 000 km): Automatic Transaxle

Service (severe conditions only).

Every 60,000 Miles (100 000 km): Engine Accessory

Drive Belt Inspection.

Every 100,000 Miles (166 000 km): Spark Plug Wire

Inspection. Spark Plug Replacement.

Every 150,000 Miles (240 000 km): Cooling System

Service (or every 60 months, whichever occurs first).

These intervals only summarize maintenance services. Be sure to follow the complete maintenance schedule on the following pages.

7-5

Maintenance Schedule

Long Trip/Hig;hway Definition

Follow this maintenance schedule only if none of the conditions from the Short TripKity Maintenance Schedule is true. Do not use this schedule if the vehicle is used for trailer towing, driven in a dusty area or used off paved roads. Use the Short TripKity schedule for these conditions. Driving a vehicle with a filly warmed engine under highway conditions causes engine oil to break down slowei:

1 - 0

I Low Trip/Hiehwav Intervals Every 7,500 Miles (12 500 km): Engine Oil and Filter Change (or every 12 months, whichever occurs first). Tire Rotation.

Every 30,000 Miles (50 000 km): Air Cleaner Filter

Replacement. Fuel Tank, Cap and Lines Inspection. Every 50,000 Miles (83 000 km): Automatic Transaxle

Service (severe conditions only).

Every 60,000 Miles (100 000 km): Engine Accessory

Drive Belt Inspection.

Every 100,000 Miles (166 000 km): Spark Plug Wire

Inspection. Spark Plug Replacement.

Every 150,000 Miles (240 000 km): Cooling System

Service (or every 60 months, whichever occurs first).

These intervals only summarize maintenance services. Be sure to follow the complete maintenance schedule on the following pages.

IShort TripKity Maintenance Schedule I

3,000 Miles (5 000 km) 0 Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

The services shown in this schedule up to 100,000 miles (166 000 km) should be performed after 100,000 miles (166 000 km) at the same intervals. The services shown at 150,000 miles (240 000 km) should be performed at the same interval after 150,000 miles (240 000 km). See “Owner Checks and Services” and “Periodic Maintenance Inspections” following. Footnotes

The U.S. Environmental Protection Agency or the

California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior completion of the vehicle’s useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. + A good time to check your brakes is during tire rotation. See “Brake System Inspection” under “Periodic Maintenance Inspection” in Part C of this schedule.

to the

DATE

ACTUAL MILEAGE

SERVICED BY: I

7-7

I Short TripKity Maintenance Schedule 6,000 Miles (10 000 km) 0 Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

9,000 Miles (15 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-8

I Short Trip/City Maintenance Schedule I 12,000 Miles (20 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

[7 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

15,000 Miles (25 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote?.)

DATE ACTUAL MILEAGE SERVICED

BY

7-9

I Short TripKity Maintenance Schedu 18,000 Miles (30 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

17 Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

21,000 Miles (35 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

I DATE

I ACTUAL MILEAGE

ISERVICED

BY: I

I Short Trip/City Maintenance Schedule 24,000 Miles (40 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). .An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

27,000 Miles (45 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-11

I Short Trip/City Maintenance Schedule 30,000 Miles (50 000 km)

33,000 Miles (55 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service. Replace air cleaner filter. An Emission Control Service.

0 Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Sewice. (See footnote? .) 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.) DATE

ACTUAL MILEAGE

3 SERVICED BY:

DATE

a 4 -

ACTUAL MILEAGE

SERVICED BY:

I Short TripKity Maintenance Schedule I 36,000 Miles (60 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

39,000 Miles (65 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE SERVICED

ACTUAL MILEAGE

BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

I Short TripKity Maintenance Schedule 42,000 Miles (70 000 km) 0 Change engine oil and filter (or every

45,000 Miles (75 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

3 months, whichever occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote-f-.)

DATE ACTUAL

MILEAGE

SERVICED BY:

DATE ACTUAL MILEAGE SERVICED

BY:

7-14

I Short TripKity Maintenance Schedule I 48,000 Miles (80 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

50,000 Miles (83 000 km) 0 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 OF (32°C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or lf you do not use your vehicle under any of these conditions, the fluid and filter do not require changing.

delivery service.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-15

I ,Short Trip/City Maintenance Schedule 51,000 Miles (85 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

I SERVICED BY:

DATE

ACTUAL

MILEAGE

7-16

54,000 Miles (90 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

ACTUAL MILEAGE ,

SERVICED BY:

DATE

I Short Trip/City Maintenance Schedule 57,000 Miles (95 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE SERVICED BY:

60,000 Miles (100 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Inspect engine accessory drive belt. An Emission Control Service. 0 Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote? .)

(Continued)

I Short TripKity Maintenance Schedu 60,000 Miles (100 000 km) (Continued) 0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

63,000 Miles (105 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY.

DATE

ACTUAL MILEAGE

SERVICED BY:

7-18

I Short Trip/City Maintenance Schedule I 66,000 Miles (110 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

69,000 Miles (115 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

ACTUAL MILEAGE SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

B Y

7-19

I Short Trip/City Maintenance Schedule 72,000 Miles (120 000 km)

Change engine oil and filter (or every 3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

75,000 Miles (125 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Inspect air cleaner filter if you are driving

in dusty conditions. Replace filter if necessary. An Emission Control Service. (See footnote? .)

ACTUAL MILEAGE SERVICED BY: I 1

DATE

ACTUAL MILEAGE SERVICED BY: I

DATE

7-20

I Short Trip/City Maintenance Schedule 78,000 Miles (130 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

81,000 Miles (135 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE __

SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

BY:

I Short TripKity Maintenance Schedule 84,000 Miles (140 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

87,000 Miles (145 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE SERVICED

ACTUAL MILEAGE

BY:

7-22

I Short Trip/City Maintenance Schedule 90,000 Miles (150 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Replace air cleaner filter. 0 Inspect fuel tank, cap and lines for damage

An Emission Control Service.

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.)

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

I Short Trip/City Maintenance Schedule 93,000 Miles (155 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

96,000 Miles (160 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

DATE

ACTUAL MILEAGE

SERVICED BY:

7-24

I Short TripKity Maintenance Schedule I 99,000 Miles (165 000 km) 0 Change engine oil and filter (or every

3 months, whichever occurs first). An Emission Control Service.

100,000 Miles (1 66 000 km) I7 Inspect spark plug wires (except 2.4L Code 0 Replace spark plugs.

T engine). An Emission Control Service.

An Emission Control Service. Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32°C) or higher.

- In hilly or mountainous terrain.

(Continued)

DATE

ACTUAL MILEAGE

SERVICED BY:

~~

I Short Trip/City Maintenance Schedule

100,000 Miles (166 000 km) (Continued) - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

lfyou do not use your vehicle under any of these conditions, the fluid and filter do not require changing.

150,000 Miles (240 000 km) 0 Drain, flush and refill cooling system (or every 60 months since last service, whichever occurs first). See “Engine Coolant” in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test cooling system and pressure cap. An Emission Control Service.

DATE

I’UAL MILEAGE SERVICED

BY:

DATE ACTUAL MILEAGE SERVICED

BY:

Long Trip/Highway Maintenance Schedule

The services shown in this schedule up to 100,000 miles (166 000 km) should be performed after 100,000 miles (166 000 km) at the same intervals. The services shown at 150,000 miles (240 000 km) should be performed at the same interval after 150,000 miles (240 000 km). See “Owner Checks and Services” and “Periodic Maintenance Inspections” following. Footnotes The U.S. Environmental Protection Agency or the

California Air Resources Board has determined that the failure to perform this maintenance item will not nullify the emission warranty or limit recall liability prior to the completion of the vehicle’s useful life. We, however, urge that all recommended maintenance services be performed at the indicated intervals and the maintenance be recorded. + A good time to check your brakes is during tire rotation. See “Brake System Inspection” under “Periodic Maintenance Inspections” in Part C of this schedule.

7,500 Miles (12 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

I7 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

I DATE

ACTUAL

MILEAGE

SERVICED

BY:

7-27

Long Trip/Highway Maintenance Schedule 15,000 Miles (25 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

22,500 Miles (37 500 km) 0 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. 0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information. (See footnote +.)

DATE

ACTUAL MILEAGE

SERVICED BY:

7-28

Long TripMighway Maintenance Schedule 30,000 Miles (50 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Sewice. Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper rotation pattern and additional information. (See footnote +.)

El Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.)

37,500 Miles (62 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation’’ in the Index for proper rotation pattern and additional information. (See footnote +.)

DATE ACTUAL MILEAGE SERVICED

BY:

7-29

Long Tripmighway Maintenance Schedule

45,000 Miles (75 000 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

50,000 Miles (83 000 km) 0 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

temperature regularly reaches 90 O F (32 O C) or higher.

- In hilly or mountainous terrain. - When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

I f you do not use your vehicle under any of these conditions, the fluid and$lter do not require changing.

DATE ACTUAL MILEAGE SERVICED

BY:

7-30

Long Tripmighway Maintenance Schedule 52,500 Miles (87 500 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

60,000 Miles (100 000 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional infomation. (See footnote +.)

0 Inspect engine accessory drive belt. An Emission Control Service. 0 Replace air cleaner filter. An Emission Control Service.

(Continued)

7-31

Long Tripmighway Maintenance Schedule

60,000 Miles (100 000 km) (Continued) 0 Inspect fuel tank, cap and lines for damage

or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.)

67,500 Miles (112 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

DATE ACTUAL MILEAGE SERVICED

B Y

DATE

I ACTUAL MILEAGE

SERVICED BY I

75,000 Miles (125 000 km) 0 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

82,500 Miles (137 500 km)

Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. Rotate tires. See “Tire Inspection and Rotation” in the Index for proper rotation pattern and additional information. (See footnote +.)

DATE ACTUAL MILEAGE SERVICED

BY:

DATE ACTUAL MILEAGE SERVICED

BY:

Long Tripmighway Maintenance Schedule 90,000 Miles (150 000 km) 0 Change engine oil and filter (or every 12 months, whichever occurs first). An Emission Control Service. 0 Replace air cleaner filter. An Emission Control Service. 0 Inspect fuel tank, cap and lines for damage or leaks. Inspect fuel cap gasket for any damage. Replace parts as needed. An Emission Control Service. (See footnote?.)

0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information. (See footnote +.)

7-34

I Long Tripmighway Maintenance Schedule 97,500 Miles (142 500 km) 0 Change engine oil and filter (or every

12 months, whichever occurs first). An Emission Control Service.

0 Rotate tires. See “Tire Inspection and

Rotation’’ in the Index for proper rotation pattern and additional information. (See footnote +.)

T engine). An Emission Control Service.

100,000 Miles (144 000 km) 0 Inspect spark plug wires (except 2.4L Code 0 Replace spark plugs. 0 Change automatic transaxle fluid and filter if the vehicle is mainly driven under one or more of these conditions: - In heavy city traffic where the outside

An Emission Control Service.

temperature regularly reaches 90 OF (32 O C) or higher.

- In hilly or mountainous terrain.

(Continued)

DATE

ACTUAL MILEAGE

SERVICED BY.

7-35

1 Lone TridHighway Maintenance Schedule I 100,000 Miles (1 66 000 km) (Continued)

- When doing frequent trailer towing. - Uses such as found in taxi, police or

delivery service.

lfyou do not use your vehicle under any of these conditions, the fluid and filter do not require changing.

150,000 Miles (240 000 km) 0 Drain, flush and refill cooling system (or every 60 months since last service, whichever occurs first). See “Engine Coolant’’ in the Index for what to use. Inspect hoses. Clean radiator, condenser, pressure cap and neck. Pressure test the cooling system and pressure cap. An Emission Control Service.

DATE

ACTUAL MILEAGE

SERVICED BY:

ACTUAL MILEAGE DATE

SERVICED BY:

Part B: Owner Checks and Services Listed below are owner checks and services which should be performed at the intervals specified to help ensure the safety, dependability and emission control performance of your vehicle. Be sure any necessary repairs are completed at once. Whenever any fluids or lubricants are added to your vehicle, make sure they are the proper ones, as shown in Part D. At Each Fuel Fill It is important for you or a service station attendant to pe@orm these underhood checks at each fuel fill. Engine Oil Level Check Check the engine oil level and add the proper oil if necessary. See “Engine Oil” in the Index for further details.

the proper fluid if

Engine Coolant Level Check Check the engine coolant level and add the proper coolant mix if necessary. See “Engine Coolant” in the Index for further details. Windshield Washer Fluid Level Check Check the windshield washer fluid level in the windshield washer tank and add necessary. See “Windshield Washer Fluid” in the Index for further details. At Least Once a Month Tire Inflation Check Make sure tires are inflated to the correct pressures. See “Tires” in the Index for further details. Cassette Deck Service Clean cassette deck. Cleaning should be done every 50 hours of tape play. See “Audio Systems” in the Index for further details.

7-37

At Least Once a Year Key Lock Cylinders Service Lubricate the key lock cylinders with specified in Part D.

the lubricant

Body Lubrication Service Lubricate all body door hinges and latches, including those for the hood and trunk lid. Part D tells you what to use. More frequent lubrication may be required when exposed to a corrosive environment.

At Least Twice a Year Restraint System Check Make sure the safety belt reminder light and all your belts, buckles, latch plates, retractors and anchorages are working properly. Look for any other loose or damaged safety belt system parts. If you see anything that might keep a safety belt system from doing its job, have it repaired. Have any torn or frayed safety belts replaced. Also look for any opened or broken air bag coverings, and have them repaired or replaced. (The air bag system does not need regular maintenance.)

Wiper Blade Check Inspect wiper blades for wear or cracking. Replace blade inserts that appear worn or damaged or that streak or miss areas of the windshield. Also see “Wiper Blades, Cleaning” in the Index.

7-3s

Starter Switch Check

I A CAUTION: - - I

CAUTION:

A\

Brake-Transaxle Shift Interlock (BTSI) Check

When you are doing this check, the vehicle could move suddenly. If it does, you or others could be injured. Follow the steps below.

When you are doing this check, the vehicle could move suddenly. If it does, you or others could be injured. Follow the steps below.

1. Before you start, be sure you have enough room

around the vehicle.

2. Firmly apply both the parking brake (see “Parking

Brake” in the Index if necessary) and the regular brake. NOTE: Do not use the accelerator pedal, and be ready to turn off the engine immediately if it starts.

3. Try to start the engine in each gear. The starter

should work only in PARK (P) or NEUTRAL (N). If the starter works in any other position, your vehicle needs service.

1. Before you start, be sure you have enough room

around the vehicle. It should be parked on a level surface.

2. Firmly apply the parking brake (see “Parking Brake”

in the Index if necessary). NOTE: Be ready to apply the regular brake immediately if the vehicle begins to move.

3. With the engine off, turn the key to the ON position,

but don’t start the engine. Without applying the regular brake, try to move the shift lever out of PARK (P) with normal effort. If the shift lever moves out of PARK (P), your vehicle’s BTSI needs service.

7-39

Ignition Transaxle Lock Check While parked, and with the parking brake set, try to turn the ignition key to OFF in each shift lever position.

The key should turn to OFF only when the shift lever is in PARK (P) .

On all vehicles, the key should come out only in OFF. Parking Brake and Automatic Transaxle PARK (P)

When you are doing this check, your vehicle could begin to move. You or others could be injured and property could be damaged. Make