used, which is normal. If this happens, the hands-free system will prompt you to reconnect.
• A new call cannot be initiated while
another call is in progress.
Sound settings
Call volume Call volume can be adjusted while a call is in progress using the buttons in the steering wheel keypad.
Audio system volume When PHONE is displayed, volume for the audio system can be adjusted in the normal way with the audio system's volume control. In order to adjust volume during a phone call, the
1 Not supported by all cell phones.
262
audio system must be switched to one of the other modes (FM, CD, etc). Audio system sound can be automatically muted when a phone call is received in
If you prefer to use the connected cell phone’s ring tone1, go to Phone Menu… Phone settings… Sounds and volume… Ring signals… Use cell phone signal
Phone Menu… Phone settings… Sounds and volume… Mute radio and adjust the volume with the center console.
keys on the
Ringing volume Go to Phone Menu… Phone settings… Sounds and volume… Ring volume
and adjust the volume with the the center console.
keys on
Ringing tones The hands-free system’s integrated ringing tones can be selected in Phone Menu… Phone settings… Sounds and volume…
Ring signals… Ring signal 1, etc.
NOTE
The connected cell phone’s ring tone is not switched off when one of the hands-free system's ringing tones is used.
More information about registering and connecting cell phones A maximum of 5 cell phones can be registered in the hands-free system. Registration only needs to be done once for each phone. After registration, the cell phones can then be found in the list of registered phones. Only one cell phone can be connected to hands-free at a time. Phones can be unregistered in Phone Menu… Bluetooth… Remove phone
Automatic connection When the hands-free system is active and the most recently connected cell phone is within range, it is detected automatically. When the audio system searches for the most recently connected phone, this phone’s name appears in the display. To manually connect a different cell phone, press EXIT.
Manual connection To connect a phone other than the one that was most recently connected or to switch
between cell phones that are already regis- tered in the hands-free system: Put the audio system in telephone mode and follow the instructions in the display or change the connected cell by going into the menu sys- tem under Phone Menu… Bluetooth… Connect phone or Change phone.
Phone book In order to use the hands-free system’s phone book (list of contacts), PHONE must be dis- played at the top of the center console display and the
symbol must be visible.
The audio system stores a copy of the phone book of each registered cell phone. The phone book is automatically copied each time a phone is connected. This function can be acti- vated in Phone settings… Synchronize phone book. Searches for contacts are only made in the phone book of the currently con- nected cell phone.
NOTE
If a particular cell phone does not support copying of the phone book, List is empty will be displayed when copying has been completed.
If the phone book contains information about someone who is trying to call you, this infor- mation will be shown in the display.
Searching for contacts The easiest way to search for a contact in the phone book is to press and hold any of the buttons 2–9 in the center console (no. 3 in the illustration on page 260. This starts a search based on the first letter on the button that has been pressed. The phone book can also be accessed by pressing the navigation buttons center console or by pressing on the steering wheel keypad. A search can also be made in the phone book’s search menu in Phone book… Search: 1. Enter the first letter of the contact’s name and press ENTER or simply press ENTER.
on the
2. Select the desired contact and press ENTER to make a call to that person.
Voice control If the cell phone that is currently connected allows calls to be made via voice commands, this function can be used by pressing and hold- ing ENTER.
Voice mail number The phone number to your voice mail can be changed in the menu Phone settings…
10 Audio
Bluetooth® hands-free connection
Call options… Voice mail number. If no number has been stored, this menu can be accessed by a prolonged press on button 1. Once a phone number has been stored, press and hold 1 to dial this number.
Call lists Lists of calls in a particular cell phone are cop- ied to the hands-free system each time that phone is connected. These lists are then upda- ted while the phone is connected. Press ENTER to show the most recently dialed num- bers. Other call lists can be found under Call register….
NOTE
Certain cell phones display the list of the most recently dialed numbers in reverse order.
Entering text Text is entered by using the number buttons in the center console. Press a button once to enter the first letter on the button, twice to enter the second letter, etc. Continue to press the button to display other characters. Press EXIT briefly to erase a character. Press and hold EXIT to erase all of the characters that buttons on have been entered. Use the
10
``
263
10 Audio
Bluetooth® hands-free connection
the center console to navigate among the char- acters.
5.1.3. Mute radio Synchronize phone book
5.2.
10
3.
2.
Last 10 missed calls Last 10 received calls Last 10 dialed calls
Bluetooth® menus Call register… 1. 1.1. 1.2. 1.3. Call register… Search 2.1. 2.2. Copy fr. cell phone Bluetooth… 3.1. 3.2. 3.3. 3.4. Call options… 4.1. 4.2. Phone settings… 5.1.
Automatic answer Voice mail number
Change phone Remove phone Connect fr. cell phone Car Bluetooth info
4.
5.
Sounds and volume… 5.1.1. Ring volume 5.1.2. Ring signals…
264
10 Audio
10
265
Label information.................................................................................. 268
Dimensions and weights....................................................................... 270
Fuel, oils, and fluids.............................................................................. 273
Engine oil............................................................................................... 274
Engine specifications............................................................................ 275
Electrical system................................................................................... 277
Three-way catalytic converter............................................................... 279
Overview of information and warning symbols..................................... 280
Volvo programs..................................................................................... 282
266
SPECIFICATIONS
11 Specifications
Label information
11
268
11 Specifications
Label information
Vehicle Identification Number (VIN)1
The VIN plate is located on the top left surface of the dashboard. The VIN is also stamped on the right hand door pillar.
Vehicle Emission Control Information Your Volvo is designed to meet all applicable emission standards, as evidenced by the cer- tification label on the underside of the hood. For further information regarding these regula- tions, please consult your Volvo retailer.
Model plate
Vehicle Identification Number (VIN). Codes for color and upholstery, etc. The model plate is located on the rear side of the B-pillar (the pillar between the front and rear passenger doors) and the rear passeng- er's door must be open in order to see it.
Federal Motor Vehicle Safety
Standards (FMVSS) specifications (USA) and Ministry of Transport (CMVSS) standards (Canada) Your Volvo is designed to meet all applicable safety standards, as evidenced by the certifi- cation label on the driver's side B-pillar (the structural member at the side of the vehicle, at the rear of the driver's door opening). For fur- ther information regarding these regulations, please consult your Volvo retailer.
Tire inflation pressures
This label indicates the correct inflation pres- sures for the tires that were on the vehicle when it left the factory. Canadian models have the upper decal. U.S. models have the lower decal.
1 The Vehicle Identification Number (VIN) should always be quoted in correspondence concerning your vehicle with the retailer and when ordering parts.
11
269
11 Specifications
Dimensions and weights
Dimensions
11
270
Position Dimension
Wheelbase
Length
Load length, floor, seatback down
Load length, floor
Load height
Height
Track, front
103.9 in. (264 cm)
175.9 in. (447 cm)
68.7 in. (175 cm)
38.4 in. (98 cm)
17.3 in. (44 cm)
57.2 in. (145 cm)
60.4 in. (154 cm)
Position Dimension
Track, rear
Load width, floor
Width
Width encl. door mirrors
Weights Category
Gross vehicle weight
Capacity weight
Permissible axle weight, front
Permissible axle weight, rear
Curb weight
Max. roof load
Max. trailer weight (w/o brakes)
Max. trailer weight (with brakes)
Max. tongue weight
USA
4320 lbs lbs
800 lbs
2380 lbs
2130 lbs
3260 - 3290 lbs
165 lbs
1540 lbs
2000 lbs
165 lbs
60.3 in. (153 cm)
40.4 in. (103 cm)
69.7 in. (177 cm)
79.6 in. (202 cm)
Canada
1960 kg
365 kg
1080 kg
970 kg
1480 - 1500 kg
All models: 75 kg
All models: 700 kg
All models: 900 kg
All models: 75 kg
11 Specifications
Dimensions and weights
11
``
271
11 Specifications
Dimensions and weights
CAUTION
The maximum permissible axle loads and/ or the gross vehicle weight must not be exceeded.
11
WARNING
When adding accessories, equipment, lug- gage and other cargo to your vehicle, the total capacity weight must not be exceeded.
272
11 Specifications
Fuel, oils, and fluids
Specifications and capacities Category
Fuel tank
Specification
Octane rating: unleaded gasoline, minimum octane requirement AKI 87, recommended rat- ing AKI 91 or above.
Capacity
15.9 US gallons (60 liters)
Engine oil (with filter replacement)
See page 274 for information on engine oil specifications.
6.1 US quarts (5.8 liters)
Automatic transmission oil
JWS 3309
8.14 US quarts (7.7 liters)
Coolant
Brake fluid
Volvo original coolant/antifreeze (50/50 mix- ture of water and anti-freeze)
10.5 US quarts (10 liters) – models with automatic transmission
DOT 4+ boiling point >536 °F (280 °C), P/N
9437433
0.63 US quarts (0.6 liters)
Power steering fluid
WSS M2C204-A or equivalent
1.3 US quarts (1.2 liters) – system and reservoir com- bined
Washer fluid reservoir
Use washer fluid solvent in cold weather con- ditions.
4.2 US qts (4 liters)
Air conditioning system
Refrigerant – R134a
1.2 lbs. (530 grams)
11
``
273
11 Specifications
Fuel, oils, and fluids
NOTE
NOTE
The transmission oil does not normally need to be changed during the service life of the vehicle. However, it may be necessary to replace the oil if the vehicle is often driven in areas of sustained temperature extremes (hot or cold), when towing a trailer over long distances, for prolonged driving in moun- tainous areas, or if the vehicle is often driven short distances in temperatures under 40 °F (5 °C).
Oil specifications Engine oil must meet the minimum ILSAC specification GF-4, API SL, or ACEA A1/B1. Lower quality oils may not offer the same fuel economy, engine performance, or engine pro- tection. Volume: 6.1 US qts (5.8 liters). Volume between the MIN and MAX marks on the dipstick: approximately 1.4 US qts (1.3 lit- ers). Volvo recommends Castrol. Depending on your driving habits, premium or synthetic oils may provide superior fuel econ- omy and engine protection. Consult your Volvo retailer or a trained and qualified Volvo service technician for recommendations on premium or synthetic oils. Oil additives must not be used.
11
274
Synthetic oil is not used when the oil is changed at the normal service intervals. This oil is only used at customer request, at additional charge. Please consult a trained and qualified Volvo service technician.
Oil viscosity Incorrect viscosity oil can shorten engine life under normal use. SAE 5W-30 will provide good fuel economy and engine protection. See the viscosity chart.
Viscosity chart
Extreme engine operation
Synthetic oils meeting SAE 0W-30 or 0W-40
and complying with oil quality requirements are
recommended for driving in areas of sustained
temperature extremes (hot or cold), when tow-
ing a trailer over long distances, and for pro- longed driving in mountainous areas.
American Petroleum Institute (API) symbol
The API Service Symbol "donut" is divided into three parts: • The upper section describes the oil's per-
formance level.
• The center identifies the oil's viscosity. • The lower section indicates whether the oil
has demonstrated energy-conserving properties in a standard test in comparison to a reference oil.
Engine designation
OutputA kW/rps hp/rpm
TorqueA Nm/rps ft. lbs./rpm
No. of cylinders
Displacement (liters/cubic inches)
Bore (mm/in.)
Stroke (mm/in.)
Compression ratio
Spark plugs type gap inches/mm tightening torque ft. lbs./Nm
11 Specifications
Engine specifications
B5254T7
169/83
227/5000
320/25-80
236/1500-4800
2.52/153.8
83/3.27
93.2/3.67
9.0:1
Volvo kit no. 30650379
0.027 in./0.7mm
22.5 ft. lbs./30 Nm
A The engine specifications for output and torque listed in this table are based on the use of premium fuel.
Charge air cooler (Intercooler) The engine employs a turbo-compressor to force air into the engine intake manifold and a charge air cooler to cool the compressed inlet
air. The resulting increase in air flow raises pressure in the intake manifold and increases engine power over that developed by the nor- mally-aspirated engine. The charge air cooler
(which resembles a radiator) is located between the turbo-compressor and intake manifold.
11
``
275
11 Specifications
Engine specifications
Fuel system The engine is equipped with a multiport fuel injection system.
11
276
11 Specifications
Electrical system
11
General information 12-volt system with voltage controlled gener- ator. Single wire system in which the chassis and engine block are used as conductors, grounded on the chassis.
Battery Voltage
Cold start capacity (CCA)
Reserve capacity (RC)
Capacity (Ah)
12 V
700 AA
135 min
80
A Models equipped with the Premium Sound audio system,
the Volvo Navigation System and/or keyless drive.
If the battery must be replaced, replace it with one with the same cold start capacity and reserve capacity as the original (see the decal on the battery).
WARNING
PROPOSITION 65 WARNING! Battery posts, terminals, and related acces- sories contain lead and lead compounds, chemicals known to the state of California to cause cancer and reproductive harm. Wash hands after handling.
Bulbs used in the car Bulb
Low beam headlights (models with halogen headlights)
High beam headlights (models with halogen headlights)
High beam headlights (models with Active Bending Lights* only)
Brake lights, back-up lights, rear fog light
Front turn signals (models with halogen only), rear turn signals
Output
Type
55W
55W
55W
21W
21W
H7
H9
H7
P21W
PY21W
* Option/accessory, for more information, see Introduction.
277
``
11 Specifications
Electrical system
Bulb
Front turn signals (models with Active Bending Lights*)
Rear parking lights, side marker lights (upper socket)
11
Rear parking lights (lower socket)
Footwell lighting, trunk light, license plate lighting
Vanity mirror
Front parking lights and side marker lights
Front fog lights*
Glove compartment light
NOTE
For information regarding any other bulbs not mentioned in this section, please con- tact your Volvo retailer or a trained and authorized Volvo service technician.
278
* Option/accessory, for more information, see Introduction.
Output
24W
5W
5W
5W
1.2W
5W
35W
3W
Type
PY24W
P21/W5
R5W
C5W
Festoon
W5W
H8
Festoon
11 Specifications
Three-way catalytic converter
components or location, or removing com- ponents, and/the repeated use of leaded fuel.
NOTE
Unleaded fuel is required for vehicles with three-way catalytic converters.
Three-way catalytic converter – general information • Keep your engine properly tuned. Certain engine malfunctions, particularly involving the electrical, fuel or distributor ignition systems, may cause unusually high three- way catalytic converter temperatures. Do not continue to operate your vehicle if you detect engine misfire, noticeable loss of power or other unusual operating condi- tions, such as engine overheating or back- firing. A properly tuned engine will help avoid malfunctions that could damage the three-way catalytic converter.
• Do not park your vehicle over combustible materials, such as grass or leaves, which can come into contact with the hot exhaust system and cause such materials to ignite under certain wind and weather condi- tions.
• Excessive starter cranking (in excess of one minute), or an intermittently firing or flooded engine can cause three-way cata- lytic converter or exhaust system over- heating.
• Remember that tampering or unauthorized modifications to the engine, the Electronic Control Module, or the vehicle may be ille- gal and can cause three-way catalytic con- verter or exhaust system overheating. This includes: altering fuel injection settings or components, altering emission system
11
279
Symbols in the main instrument panel
Symbol
Description
11 Specifications
Overview of information and warning symbols
11
Introduction The symbols in the vehicle's various displays are divided into three main categories: • Warning symbols • Indicator symbols • Information symbols The following tables list the most common symbols, their Description and the pages in this manual that provide more detailed information.
Warning symbol The red warning symbol lights up to indi- cate a problem related to safety and/or driva- bility. A message will also appear in the main instruments panel's display.
Information symbol The yellow information symbol lights up and a text message is displayed to provide the driver with necessary information about one of the vehicle's systems.
Indicator and warning symbols Symbol
Description
Page
Warning
Information
Malfunction indi- cator light
Fault in the ABS system
58
58
60
60
Rear fog light
60
Stability system STC or DSTC*
159
280
* Option/accessory, for more information, see Introduction.
Page
60
61
61
61
Fuel level warning light
Trailer turn signal indicator
Parking brake applied
SRS airbag sys- tem
Oil pressure warn- ing light
61
Seat belt reminder
61
11 Specifications
Overview of information and warning symbols
Symbol
Description
Generator warn- ing light
Page
61
Other information symbols Symbol
Description
Rain sensor*
Page
76
Information symbols in the ceiling console Symbol
Description
Page
Brake failure warning light
62
High beam indica- tor
56
Left turn signal
56
Right turn signal
56
Cruise control*
73
Seat belt reminder
61
Occupant weight sensor
28
11
Information symbols in the center console display Symbol
Description
Page
Surround sound (Premium Sound only)
HD radio
Audio files
CD folder
Bluetooth-con- nected cell phone
BluetoothTM hands-free
246
250
256
256
260
260
* Option/accessory, for more information, see Introduction.
281
11 Specifications
Volvo programs
Volvo On Call Roadside Assistance
Your new Volvo comes with a four year ON
CALL roadside assistance. Additional informa-
tion, features, and benefits are described in a
separate information package in your glove
compartment.
If you require assistance, dial:
In the U.S. 1-800-638-6586 (1-800-63-
VOLVO)
In Canada 1-800-263-0475
Technician certification In addition to Volvo factory training, Volvo sup- ports certification by the National Institute for Automotive Service Excellence (A.S.E.). Certi- fied technicians have demonstrated a high degree of competence in specific areas. Besides passing exams, each technician must also have worked in the field for two or more years before a certificate is issued. These pro- fessional technicians are best able to analyze vehicle problems and perform the necessary maintenance procedures to keep your Volvo at peak operating condition.
11
282
11 Specifications
11
283
12 Index
1, 2, 3 ...
12-volt sockets.......................................... 65
A/C (air conditioning)................................. 94
ABS (anti-lock brake system).................. 155
Accessory installation warning.................. 15
Adaptive brake lights............................... 154
Airbags
front...................................................... 24
inflatable curtain................................... 33
side impact........................................... 31
Airbag system............................................ 24
Air conditioning.......................................... 94
Air distribution table................................. 103
Air vents..................................................... 96
Alarm system........................................... 134
turning off sensors.............................. 135
Anti-lock Brake System (ABS)................. 155
Approach lighting...................................... 86
Audio files................................................ 256
12
284
Audio system
audio functions................................... 243
automatic sound control..................... 247
AUX port............................................. 243
compact disc care.............................. 257
Dolby Surround Pro Logic II............... 246
equalizer............................................. 247
HD digital radio................................... 250
menu settings..................................... 259
radio functions.................................... 248
selecting a sound source.................... 243
Sirius satellite radio............................ 252
sound settings.................................... 246
steering wheel keypad........................ 244
storing radio stations.......................... 248
subwoofer........................................... 246
USB/iPod(cid:159) connector........................ 244
Auto-dim rearview mirror........................... 80
Autolock..................................................... 85
Automatic locking retractor....................... 39
Automatic sound control......................... 247
Automatic transmission........................... 151
kickdown............................................ 152
oil........................................................ 273
shiftlock override................................ 153
Automatic transmission - Geartronic....... 152
AUX port.................................................. 243
Axle weight...................................... 186, 271
Backrest, rear seat, folding...................... 115
Bass......................................................... 246
Battery
maintenance....................................... 224
remote key, replacing......................... 124
specifications...................................... 277
warning symbols................................. 224
Battery – replacing................................... 225
Black box................................................... 13
Blind Spot Information System (BLIS)..... 167
Bluetooth cell phone connection............. 260
Booster cushion
accessory............................................. 46
Brake fluid........................................ 222, 273
Brake lights........................................ 67, 154
Brake system
anti-lock brakes (ABS)........................ 155
emergency brake assistance.............. 155
12 Index
fluid..................................................... 222
general information............................. 154
Bulbs
headlights........................................... 226
list of................................................... 277
Bulbs, replacing....................................... 226
Capacities, fluids..................................... 273
Capacity weight............................... 186, 271
Catalytic converter, three-way................. 279
CD player................................................. 256
Cell phone, hands-free connection......... 260
Central locking system - remote key....... 122
Chains...................................................... 189
Changing a wheel.................................... 198
Child restraints
recalls and registration......................... 50
Child restraint systems.............................. 40
booster cushions.................................. 46
convertible seats.................................. 44
infant seats........................................... 42
ISOFIX/LATCH anchors........................ 47
top tether anchors................................ 49
Child safety................................................ 38
booster cushions.................................. 46
child restraint systems.......................... 40
convertible seats.................................. 44
infant seats........................................... 42
Child safety locks.................................... 133
Climate system
air distribution..................................... 103
air vents................................................ 96
Electronic Climate Control.................. 100
manual climate control......................... 97
passenger compartment filter.............. 94
refrigerant..................................... 94, 273
Climate system, general information......... 94
Clock
setting................................................... 85
Cold weather precautions........................ 141
Compact disc care.................................. 257
Compass in rearview mirror....................... 80
Conserving electrical current................... 142
Convertible seats....................................... 44
Coolant.................................................... 273
changing............................................. 221
checking level of................................. 221
Courtesy lighting...................................... 110
Crash mode............................................... 37
Cruise control............................................ 73
Cup holders..................................... 112, 114
Curb weight..................................... 186, 271
Detachable key blade.............................. 124
Detachable trailer hitch............................ 165
Dimensions.............................................. 270
Disconnecting the front passenger’s air-
bag............................................................. 28
Display....................................................... 63
Dolby Pro Logic II (DPL II)........................ 246
Door mirrors............................................... 81
Driver distraction warning.......................... 15
Driving economically................................ 140
Driving through water.............................. 141
DSTC, stability system............................ 158
12
285
12 Index
Economical driving.................................. 140
Electrical current – conserving................ 142
Electrically operated moonroof.................. 83
Electrical system...................................... 277
Electronic Brake Force Distribution
(EBD)........................................................ 155
Electronic Climate Control......................... 95
air distribution table............................ 103
Electronic Climate Control (ECC)............. 100
Emergency brake..................................... 157
Emergency locking retractor...................... 39
Emergency starting.................................. 162
Emergency towing................................... 160
Emission inspection readiness................ 215
Engine
specifications...................................... 275
starting................................................ 148
starting with keyless drive.................. 150
Engine compartment overview................ 218
Engine oil................................................. 219
changing............................................. 219
checking............................................. 219
12
286
specifications...................................... 274
volumes.............................................. 273
Environment............................................... 14
Equalizer, audio system........................... 247
Eyelets for anchoring loads..................... 118
Fuel filler door
unlocking.............................................. 68
Fuel gauge................................................. 56
Fuel requirements.................................... 144
Fuel tank volume..................................... 273
Fuses, replacing...................................... 233
Federal Clean Air Act............................... 214
Flat tires
changing..................................... 192, 198
repairing with tire sealing system....... 193
Fluids and oils.......................................... 273
FM1/FM2 menu....................................... 248
Fog lights
front...................................................... 67
rear........................................................ 67
Front airbags.............................................. 24
disconnecting passenger’s side airbag 28
Front fog lights........................................... 67
Front seats............................................... 106
adjusting the head restraints.............. 108
manually operated.............................. 106
power.................................................. 106
Gasoline requirements............................. 144
Geartronic................................................ 152
Glossary of tire terminology..................... 185
Glove compartment................................. 113
locking................................................ 132
Gross vehicle weight (GVW)............ 186, 271
Hand brake (parking brake)..................... 157
Hazard warning flashers............................ 77
HD digital radio........................................ 250
Headlights.................................................. 66
Active Bending Lights........................... 66
changing bulbs................................... 226
high and low beams............................. 69
high beam flash.................................... 69
Headlight washers..................................... 75
Head restraints, rear seat........................ 115
High beam flash......................................... 69
High beams................................................ 69
Hoisting the vehicle................................. 215
Home safe lighting............................... 69, 86
Hood, opening......................................... 217
Ignition switch.......................................... 147
Immobilizer.............................................. 148
Immobilizer (start inhibitor)...................... 122
Important information................................ 10
Indicator and warning symbols............ 56, 58
Infant seats................................................ 42
Inflatable Curtain........................................ 33
Inflation pressure..................................... 179
Inflation pressure, checking..................... 179
Inflation pressure table
Canadian models................................ 182
US models.......................................... 181
Information and warning symbols, table
of.............................................................. 280
Information display.............................. 56, 63
messages in.......................................... 63
Information symbol.................................... 58
Inspection, preparing for......................... 215
Inspection readiness................................ 215
Instrument overview.................................. 54
Instrument panel.................................. 54, 56
Instrument panel lighting........................... 67
Interior lighting......................................... 110
iPod(cid:159) connector (audio system)............. 244
ISOFIX/LATCH anchors............................. 47
Jack
location of........................................... 192
Jump starting........................................... 162
12 Index
Key (ignition switch) positions................. 147
Key blade......................................... 124, 128
Keyless drive
location of antennas (pacemaker warn-
ing)...................................................... 129
locking and unlocking the vehicle...... 127
power seat memory............................ 128
starting the engine.............................. 150
Keylock.................................................... 148
Kickdown................................................. 152
12
Label information..................................... 268
LATCH (ISOFIX) anchors........................... 47
Lighting panel............................................ 66
Load anchoring eyelets........................... 118
Loading the vehicle
roof loads............................................ 166
Locking
from the inside.................................... 131
glove compartment............................. 132
Locking the vehicle.................................. 127
287
12 Index
Locks, child safety................................... 133
Long distance trips.................................. 142
Lug nuts (wheel nuts)............................... 191
12
Maintenance............................................ 214
hoisting the vehicle............................. 215
performed by the owner..................... 215
Manual climate control.............................. 97
Mirrors....................................................... 80
Model plate.............................................. 269
Moonroof................................................... 83
Motor oil........................................... 219, 274
checking............................................. 219
Occupant safety........................................ 18
Occupant weight sensor............................ 28
Octane recommendations....................... 144
288
Oil............................................................. 219
changing............................................. 219
checking............................................. 219
On Call Roadside Assistance.................. 282
Opening the hood.................................... 217
Opening the trunk from the inside........... 131
Owner maintenance................................. 215
Panel lighting, instrument.......................... 67
Park assist............................................... 171
Parking brake........................................... 157
Parking lights............................................. 66
Passenger’s side front airbag, disabling. . . 28
Periodic owner-performed maintenance. 215
Permissible axle weight........................... 186
Personal settings....................................... 85
Power door mirrors.................................... 81
Power front seat...................................... 106
memory function................................. 107
Power moonroof........................................ 83
Power steering fluid................................. 222
Power windows......................................... 78
Pregnancy, using seat belts during........... 21
Private locking......................................... 126
Radio
Sirius satellite radio............................ 252
Radio functions........................................ 248
HD digital radio................................... 250
Rain sensor - windshield wipers................ 76
Rear fog light............................................. 67
Rear park assist....................................... 171
Rear seat backrests, folding down.......... 115
Rear seats
center head restraint........................... 115
Rearview mirror.......................................... 80
auto-dim function................................. 80
Rearview mirror with compass.................. 80
Recalls, child restraints.............................. 50
Refrigerant (A/C system).................... 94, 273
Refueling.................................................. 146
fuel tank volume................................. 273
Registering child restraints........................ 50
12 Index
Remote key.............................................. 122
battery replacement............................ 124
functions............................................. 123
key blade............................................ 124
Replacing fuses....................................... 233
Reporting safety defects
Canada................................................. 19
USA....................................................... 18
Roof loads............................................... 166
Safety, occupant........................................ 18
Safety defects, reporting
Canada................................................. 19
USA....................................................... 18
Safety locks, child.................................... 133
Seat belt
reminder................................................ 21
Seat belts................................................... 20
Automatic locking retractor/Emergency
locking retractor.................................... 39
buckling................................................ 20
maintenance......................................... 22
pretensioners........................................ 20
unbuckling............................................ 20
use during pregnancy........................... 21
Seats, front.............................................. 106
Shiftlock
override............................................... 153
Side door mirrors....................................... 81
Side impact airbags................................... 31
Side impact protection (SIPS) airbags....... 31
Sirius satellite radio.................................. 252
Snow chains............................................ 189
Snow tires................................................ 189
Sound control, automatic........................ 247
Sound settings, audio system................. 246
Spare tire......................................... 190, 192
Stability system....................................... 158
Dynamic Stability Traction Control
(DSTC)................................................ 158
Starting the engine.................................. 148
with keyless drive............................... 150
Start inhibitor (immobilizer).............. 122, 148
STC, stability system............................... 158
Steering wheel
adjusting............................................... 77
keypad................................................ 244
Storage compartments............................ 112
Studded tires........................................... 189
Subwoofer............................................... 246
Sunroof (moonroof).................................... 83
Supplemental restraint system.................. 23
Symbols, overview................................... 280
12
Tachometer................................................ 56
Temporary spare tire....................... 190, 192
Three-way catalytic converter................. 279
Tire inflation............................................. 179
Tire inflation pressure
Canadian models................................ 182
US models.......................................... 181
Tire Pressure Monitoring System (TPMS) 200
Tires......................................................... 176
age...................................................... 176
changing..................................... 192, 198
changing from summer to winter........ 177
designations....................................... 183
glossary of terms................................ 185
improving economy............................ 176
289
12 Index
inflation............................................... 179
inflation pressure, checking................ 179
inflation pressure table, Canadian mod-
els....................................................... 182
inflation pressure table, US models.... 181
load ratings......................................... 180
rotation............................................... 177
snow................................................... 189
spare................................................... 190
spare tire (location)............................. 192
speed ratings...................................... 180
storing................................................. 177
studded............................................... 189
tire pressure monitoring system......... 200
tire sealing system.............................. 193
tread wear indicator............................ 178
uniform tire quality grading................. 188
winter driving...................................... 189
Tire sealing system.................................. 193
Top tether anchors (child restraint sys-
tems).......................................................... 49
Towing a trailer........................................ 163
trailer hitch.......................................... 165
Towing the vehicle................................... 160
Trailer hitch - detachable......................... 165
Trailer towing........................................... 163
Transmission
Geartronic........................................... 152
shiftlock override................................ 153
Tread wear indicator................................ 178
Treble....................................................... 246
Trip computer............................................ 71
Trips, long distance................................. 142
Trunk
opening from the inside...................... 131
Turn signals............................................... 69
indicator lights...................................... 56
Uniform Tire Quality Grading................... 188
Valet locking............................................ 126
Vehicle dimensions.................................. 270
Vehicle Event Data..................................... 13
Vehicle loading........................................ 186
roof loads............................................ 166
Vehicle maintenance................................ 214
performed by the owner..................... 215
Vehicle towing......................................... 160
Vehicle weights........................................ 271
VIN (Vehicle Identification Number)......... 269
Volvo and the environment........................ 14
Volvo maintenance.................................. 214
Volvo On Call Roadside Assistance........ 282
Warning flashers, hazard........................... 77
Warning symbol......................................... 58
Warranties................................................ 214
Washer fluid..................................... 221, 273
Washer fluid reservoir...................... 218, 221
Water, driving through............................. 141
Weights.................................................... 271
Wheel nuts............................................... 191
Wheels..................................................... 176
changing............................................. 198
storing................................................. 177
Whiplash Protection System (WHIPS)....... 35
12
290
Windows
power.................................................... 78
Windshield washer fluid reservoir............ 218
Windshield wiper blades.......................... 223
Windshield wipers...................................... 75
rains sensor.......................................... 76
Winter tires............................................... 189
Wiper blades
replacing windshield wipers............... 223
12 Index
12
291
12 Index
12
292
Kdakd8Vg8dgedgVi^dcIE&&+.%JH68VcVYV!6I&%'%!Eg^ciZY^cHlZYZc!<iZWdg\'%&%!8deng^\]i©'%%%"'%&%Kdakd8Vg8dgedgVi^dc
VOLVO S40
Owner's manual
Web Edition
Welcome to the world-wide family of Volvo owners. We trust that you will enjoy many years of safe driving in your Volvo, an automobile designed with your safety and comfort in mind. We encourage you to familiarize yourself with the equipment descriptions and operating instructions in this manual. We also urge you and your passengers to wear seat belts at all times in this (or any other) vehicle. And, of course, please do not operate a
vehicle if you may be affected by alcohol, medication or any impair- ment that could hinder your ability to drive. Your Volvo is designed to meet all applicable federal safety and emission standards. If you have any questions regarding your vehicle, please contact your Volvo retailer or see the section "Contacting Volvo" in this manual's "Introduction" chapter for information on get- ting in touch with Volvo in the United States and Canada.
Contents
Important information............................... 10
Environment.............................................. 14
0000 Introduction
Important warnings................................... 15 01
01 Safety
Occupant safety........................................ 18
Seat belts.................................................. 20
Supplemental Restraint System............... 23
Occupant Weight Sensor (OWS).............. 28
Side impact protection airbags................. 31
Inflatable Curtain (IC)................................ 33
Whiplash Protection System..................... 35
Crash mode.............................................. 37
Child safety............................................... 38
Child restraint systems............................. 40
Infant seats............................................... 42
Convertible seats...................................... 44
Booster cushions...................................... 46
ISOFIX/LATCH lower anchors.................. 47
Top tether anchors.................................... 49
Child restraint registration and recalls...... 50
0202 Instruments and controls
Instrument overview.................................. 54
Instrument panel....................................... 56
Indicator and warning symbols................. 58
Symbols – instrument panel..................... 60
Information display................................... 63
12-volt sockets......................................... 65
Lighting panel........................................... 66
Left-side steering wheel lever................... 69
Trip computer........................................... 71
Cruise control*.......................................... 73
Right-side steering wheel lever................. 75
Steering wheel adjustment, Hazard warn-
ing flashers................................................ 77
Power windows......................................... 78
Mirrors....................................................... 80
Power moonroof*...................................... 83
Personal settings...................................... 85
HomeLink® Wireless Control System*..... 88
* Option/accessory, for more information, see Introduction.
Contents
General information.................................. 94
Air vents.................................................... 96
Manual climate control.............................. 97
Electronic Climate Control (ECC)*.......... 100
Front seats.............................................. 106
Interior lighting........................................ 110
Storage compartments........................... 112
Rear seat................................................. 115
0303 Climate Air distribution......................................... 103 0404 Interior
Trunk ...................................................... 118 0505 Locks and alarm
Remote key and key blade..................... 122
Valet locking ........................................... 126
Keyless drive*.......................................... 127
Locking and unlocking............................ 131
Child safety locks.................................... 133
Alarm*..................................................... 134
* Option/accessory, for more information, see Introduction.
Contents
0606 Starting and driving
General information................................ 140
Fuel requirements................................... 144
Ignition switch......................................... 147
Starting the vehicle................................. 148
Starting the vehicle with keyless drive*... 150
Automatic transmission.......................... 151
Shiftlock override.................................... 153
Brake system.......................................... 154
Parking brake.......................................... 157
Stability system....................................... 158
Towing.................................................... 160
Jump starting.......................................... 162
Towing a trailer....................................... 163
Detachable trailer hitch........................... 165
Transporting loads.................................. 166
Blind Spot Information System (BLIS)*... 167
Rear park assist*..................................... 171
Washing and cleaning the car................. 206
Paint touch up......................................... 210
0707 Wheels and tires Tire Pressure Monitoring System (TPMS) 200 0808 Car care
General information................................ 176
Tire inflation............................................. 179
Inflation pressure—U.S. models ............ 181
Inflation pressure—Canadian models .... 182
Tire designations..................................... 183
Glossary of tire terminology.................... 185
Vehicle loading........................................ 186
Uniform tire quality gradings................... 188
Snow chains, snow tires, studded tires.. 189
Temporary spare..................................... 190
Wheel nuts.............................................. 191
Spare tire and jack ................................. 192
Tire Sealing System* .............................. 193
Changing a wheel................................... 198
* Option/accessory, for more information, see Introduction.
Contents
Introduction ............................................ 242
Audio functions....................................... 243
Radio functions....................................... 248
CD player................................................ 256
Audio menu............................................. 259
Volvo maintenance.................................. 214
Maintaining your car............................... 215
Hood....................................................... 217
Engine compartment............................... 218
Engine oil................................................ 219
Fluids...................................................... 221
Wiper blades........................................... 223
Battery..................................................... 224
Replacing bulbs...................................... 226
0909 Maintenance and servicing Fuses...................................................... 233 1010 Audio
Bluetooth® hands-free connection......... 260 1111 Specifications
Label information.................................... 268
Dimensions and weights......................... 270
Fuel, oils, and fluids................................ 273
Engine oil................................................ 274
Engine specifications.............................. 275
Electrical system..................................... 277
Three-way catalytic converter................. 279
Overview of information and warning sym-
bols......................................................... 280
Volvo programs....................................... 282
Contents
Index....................................................... 284
1212 Index
Contents
Introduction
Important information
Contacting Volvo
In the USA:
Volvo Cars of North America, LLC
Customer Care Center
1 Volvo Drive,
P.O. Box 914
Rockleigh, New Jersey 07647
1-800-458-1552
www.volvocars.us
In Canada:
Volvo Cars of Canada Corp
National Customer Service
175 Gordon Baker Road
North York, Ontario M2H 2N7
1-800-663-8255
www.volvocanada.com
10
About this manual • Before you operate your vehicle for the first
time, please familiarize yourself with the information found in the chapters "Instru- ments and controls" and "Starting and driving."
• Information contained in the balance of the manual is extremely useful and should be read after operating the vehicle for the first time.
• The manual is structured so that it can be
used for reference. For this reason, it should be kept in the vehicle for ready access. Footnotes Certain pages of this manual contain informa- tion in the form of footnotes at the bottom of the page. This information supplements the text that the footnote number refers to (a letter is used if the footnote refers to text in a table). Display texts There are several displays in the driver’s field of vision that show messages generated by various systems and functions in the vehicle. These texts are indicated in the Owner’s Man- ual by being in slightly larger type than the sur- rounding text and are printed in gray, (for example: Doors automatic lock).
Decals There are various types of decals in the vehicle whose purpose is to provide important infor- mation in a clear and concise way. The impor- tance of these decals is explained as follows, in descending order of importance. Risk of injury
G031590
Black ISO symbols on a yellow warning back- ground, white text/image on a black back- ground. Decals of this type are used to indicate potential danger. Ignoring a warning of this type could result in serious injury or death.
Risk of damage to the vehicle
Information
White ISO symbols and white text/image on a black or blue warning background and space for a message. If the information on decals of this type is ignored, damage to the vehicle could result.
White ISO symbols and white text/image on a black background. These decals provide gen- eral information.
NOTE
The decals shown in the Owner’s Manual are examples only and are not intended to be reproductions of the decals actually used in the vehicle. The purpose is to give an indi- cation of how they look and their approxi- mate location in the vehicle. The applicable information for your particular vehicle can be found on the respective decals in the vehicle.
Introduction
Important information
Types of lists used in the manual Procedures Procedures (step-by-step instructions), or actions that must be carried out in a certain order, are arranged in numbered lists in this manual.
If there is a series of illustrations associated with step-by-step instructions, each step in the procedure is numbered in the same way as the corresponding illustration. Lists in which letters are used can be found with series of illustrations in cases where the order in which the instructions are car- ried out is not important. Arrows with or without numbers are used to indicate the direction of a movement. If there are no illustrations associated with a step-by-step list, the steps in the procedure are indicated by ordinary numbers. Position lists
Red circles containing a number are used in general overview illustrations in which certain components are pointed out. The corresponding number is also used in the position list's description of the various components.
11
Introduction
Important information
Bullet lists Bullets are used to differentiate a number of components/functions/points of information that can be listed in random order. For example: • Coolant • Engine oil Continued `` `This symbol can be found at the lower right corner of an odd-numbered (right-hand) page to indicate that the current topic is continued on the following page.
Options and accessories Optional or accessory equipment described in this manual is indicated by an asterisk. Optional or accessory equipment may not be available in all countries or markets. Please note that some vehicles may be equipped dif- ferently, depending on special legal require- ments. Contact your Volvo retailer for additional infor- mation.
12
NOTE
WARNING
• All information, illustrations and specifi-
cations contained in this manual are based on the latest product information available at the time of publication.
• Volvo reserves the right to make model changes at any time, or to change spec- ifications or design without notice and without incurring obligation.
• Do not export your Volvo to another
country before investigating that coun- try's applicable safety and emission control requirements. In some cases it may be difficult or impossible to comply with these requirements. Modifications to the emission control system(s) may render your Volvo not certifiable for legal operation in the U.S., Canada and other countries.
WARNING
If your vehicle is involved in an accident, unseen damage may affect its drivability and safety.
CALIFORNIA proposition 65
Engine exhaust, some of its constituents,
and certain vehicle components contain or
emit chemicals known to the state of Cali-
fornia to cause cancer, and birth defects or
other reproductive harm. In addition, certain
fluids contained in vehicles and certain
products of component wear contain or
emit chemicals known to the State of Cali-
fornia to cause cancer, and birth defects or
other reproductive harm.
WARNING
Certain components of this vehicle such as air bag modules, seat belt pretensioners, adaptive steering columns, and button cell batteries may contain Perchlorate material. Special handling may apply for service or vehicle end of life disposal. See www.dtsc.ca.gov/hazardouswaste/ perchlorate.
Shiftlock (automatic transmission) When your vehicle is parked, the gear selector is locked in the P (Park) position. To release the selector from this position, turn the ignition key to position II (or start the engine), depress the brake pedal, press the button on the front side of the gear selector and move the selector from P (Park).
Keylock (automatic transmission) When you switch off the ignition, the gear selector must be in the P (Park) position before the remote key can be removed from the igni- tion switch.
Anti-lock Brake System (ABS) The ABS system in your vehicle performs a self-diagnostic test when the vehicle first rea- ches the speed of approximately 12 mph (20 km/h). The brake pedal will pulsate several times and a sound may be audible from the ABS control module. This is normal.
Fuel filler door Press the button on the light switch panel (see the illustration on page 68) when the vehicle is at a standstill to unlock the fuel filler door. Please note that the fuel filler door will remain unlocked until the vehicle begins to move for- ward. An audible click will be heard when the fuel filler door relocks.
Fuel filler cap The fuel filler door, located on the right rear quarter panel, is connected to your vehicle's central locking system.
Points to keep in mind • Do not export your Volvo to another coun-
try before investigating that country's applicable safety and exhaust emission requirements. In some cases it may be dif- ficult or impossible to comply with these requirements. Modifications to the emis- sion control system(s) may render your Volvo not certifiable for legal operation in the U.S., Canada and other countries.
• All information, illustrations and specifica- tions contained in this manual are based on the latest product information available at the time of publication. Please note that some vehicles may be equipped differ- ently, depending on special legal require- ments. Optional equipment described in this manual may not be available in all mar- kets.
• Volvo reserves the right to make model
changes at any time, or to change specifi- cations or design without notice and with- out incurring obligation.
Introduction
Important information
Vehicle event data (Black box) Your vehicle's driving and safety systems employ computers that monitor, and share with each other, information about your vehi- cle's operation. One or more of these comput- ers may store what they monitor, either during normal vehicle operation or in a crash or near- crash event. Stored information may be read and used by: • Volvo Car Corporation • service and repair facilities • law enforcement or government agencies • others who may assert a legal right to
know, or who obtain your consent to know such information.
13
Recycling As part of Volvo’s commitment to the environ- ment, it is essential for the vehicle to be recy- cled in an environmentally sound way. Almost the entire vehicle can be recycled and for that reason, the vehicle’s final owner is requested to contact a Volvo retailer for information about approved and certified recycling facilities.
Introduction
Environment
Volvo and the environment Volvo is committed to the well being of its cus- tomers. As a natural part of this commitment, we care about the environment in which we all live. Caring for the environment means an everyday involvement in reducing our environ- mental impact. Volvo's environmental activities are based on a holistic view, which means we consider the overall environmental impact of a product throughout its complete life cycle. In this context, design, production, product use, and recycling are all important considerations. In production, Volvo has partly or completely phased out several chemicals including CFCs, lead chromates, asbestos, and cadmium; and reduced the number of chemicals used in our plants 50% since 1991. Volvo was the first in the world to introduce into production a three-way catalytic converter with a Lambda sond, now called the heated oxygen sensor, in 1976. The current version of this highly efficient system reduces emissions of harmful substances (CO, HC, NOx) from the exhaust pipe by approximately 95 – 99% and the search to eliminate the remaining emis- sions continues. Volvo is the only automobile manufacturer to offer CFC-free retrofit kits for the air conditioning system of all models as far back as the 1975 model 240. Advanced elec- tronic engine controls and cleaner fuels are bringing us closer to our goal. In addition to
14
continuous environmental refinement of con- ventional gasoline-powered internal combus- tion engines, Volvo is actively looking at advanced technology alternative-fuel vehicles.
When you drive a Volvo, you become our part- ner in the work to lessen the car's impact on the environment. To reduce your vehicle's environmental impact, you can: • Maintain proper air pressure in your tires. Tests have shown decreased fuel econ- omy with improperly inflated tires.
• Follow the recommended maintenance schedule in your Warranty and Service Records Information booklet.
• Drive at a constant speed whenever pos-
sible.
• See a trained and qualified Volvo service technician as soon as possible for inspec- tion if the check engine (malfunction indi- cator) light illuminates, or stays on after the vehicle has started.
• Properly dispose of any vehicle-related
waste such as used motor oil, used batter- ies, brake pads, etc.
• When cleaning your vehicle, please use
genuine Volvo car care products. All Volvo car care products are formulated to be environmentally friendly.
Driver distraction A driver has a responsibility to do everything possible to ensure his or her own safety and the safety of passengers in the vehicle and oth- ers sharing the roadway. Avoiding distractions is part of that responsibility. Driver distraction results from driver activities that are not directly related to controlling the vehicle in the driving environment. Your new Volvo is, or can be, equipped with many fea- ture-rich entertainment and communication systems. These include hands-free cellular tel- ephones, navigation systems, and multipur- pose audio systems. You may also own other portable electronic devices for your own con- venience. When used properly and safely, they enrich the driving experience. Improperly used, any of these could cause a distraction. For all of these systems, we want to provide the following warning that reflects the strong Volvo concern for your safety. Never use these devi- ces or any feature of your vehicle in a way that distracts you from the task of driving safely. Distraction can lead to a serious accident. In addition to this general warning, we offer the following guidance regarding specific newer