Login- Download PDF Manual
-
When the vehicle is serviced for scheduled maintenance, inspect surface of hoses and nylon tubing for evidence of heat and mechanical damage. Hard and brittle rubber, cracking, tears, cuts, abrasion, and excessive swelling indicate deterioration of the rubber. Particular attention should be made to examining those hose surfaces nearest to high heat sources, such as the exhaust manifold. Insure nylon tubing in these areas has not melted or collapsed.
MAINTAINING YOUR VEHICLE 263
Inspect all hose connections such as clamps and cou- plings to make sure they are secure and no leaks are present. NOTE: Often, fluid such as oil, power steering fluid, and brake fluid are used during assembly plant opera- tions to facilitate the assembly of hoses to couplings. Therefore, oil wetness at the hose-coupling area is not necessarily an indication of leakage. Actual dripping of hot fluid when systems are under pressure (during vehicle operation), should be noted before a hose is replaced based on leakage. Inspection of brake hoses should be performed NOTE: whenever the brake system is serviced and at every engine oil change. Inspect hydraulic brake hoses for surface cracking, scuffing, or worn spots. If there is any evidence of cracking, scuffing, or worn spots, the hose should be replaced immediately! Eventual deterioration of the hose can take place resulting in a possibility of a burst failure.
264 MAINTAINING YOUR VEHICLE
WARNING!
Worn brake hoses can burst and cause brake failure. You could have an accident. If you see any signs of cracking, scuffing, or worn spots, have the brake hoses replaced immediately.
Brake Fluid Level Check The fluid level in the master cylinder should be checked when performing underhood services, or immediately if the brake system warning light indicates system failure. Clean the top of the master cylinder area before removing the cap. Add fluid to bring the level up to the top of the “FULL” mark on the side of the master cylinder reservoir. Overfilling of fluid is not recommended because it may cause leaking in the system. Add enough fluid to bring the level up to the require- ments described on the brake fluid reservoir. With disc brakes, fluid level can be expected to fall as the brake pads wear. However, low fluid level may be caused by a leak and a checkup may be needed.
Use only manufacturer’s recommended brake fluid, refer to Recommended Fluids, Lubricants and Genuine Parts for correct fluid type.
WARNING!
• Overfilling the brake fluid reservoir can result in spilling brake fluid on hot engine parts and the brake fluid catching fire. • Use of a brake fluid that has a lower initial boiling point than the recommended MOPAR DOT 3
product or a brake fluid that is unidentified as to FMVSS specification may result in sudden brake failure during hard prolonged braking. You could have an accident.Use only brake fluid that has been in a tightly closed container to avoid contamination from foreign matter or moisture.
CAUTION!
Automatic Transmission
MAINTAINING YOUR VEHICLE 265
Do not allow petroleum base fluid to contaminate the brake fluid, all brake seal components could be damaged causing partial or complete brake failure.
Fuel System Hoses Electronic Fuel Injection high pressure fuel systems are designed with hoses and quick connect fittings which have unique material characteristics to provide adequate sealing and resist attack by deteriorated gasoline. You are urged to use only the manufacturer’s specified hoses with quick connect fittings, or their equivalent in material and specification, in any fuel system servicing. It is mandatory to replace any damaged hoses or quick connect fittings that have been removed during service. Care should be taken in installing quick connect fittings to insure they are properly installed and fully connected. See your authorized dealer for service.
Fluid Level Check Regular automatic transmission fluid level checks are not required. For this reason the dipstick is omitted. If you notice fluid loss or gear shift malfunction, have your authorized dealer check the transmission fluid level.
CAUTION!
Using a transmission fluid other than the manufac- turer’s recommended fluid may cause deterioration in transmission shift quality and/or torque converter shudder. Using a transmission fluid other than that recommended by the manufacturer will result in more frequent fluid and filter changes. Refer to the Recommended Fluids, Lubricants and Genuine Parts section for correct fluid type.
266 MAINTAINING YOUR VEHICLE
CAUTION!
The fluid level is preset at the factory and does not require adjustment under normal operating condi- tions. If a transmission fluid leak occurs, visit your authorized dealer immediately. Severe damage to the transmission may occur. Your authorized dealer has the proper tools to accurately adjust the fluid level.
Fluid and Filter Changes Automatic transmission fluid and filter should be changed as follows: Maintenance schedule “A” — No change necessary. Maintenance schedule “B” –Every 60,000 miles (96 000
km) change fluid and filter under the following condi- tions: • Police, taxi, limousine, commercial type operation, or trailer towing where the vehicle is driven regularly for more than 45 minutes of continuous operation.If the transmission is disassembled for any reason, the fluid and filter should be changed.
Front And Rear Wheel Bearings Front and rear wheel bearings are permanently sealed. No regular maintenance is required for these compo- nents. Appearance Care and Protection from Corrosion
Protection of Body and Paint from Corrosion Vehicle body care requirements vary according to geo- graphic locations and usage. Chemicals that make roads passable in snow and ice, and those that are sprayed on trees and road surfaces during other seasons, are highly corrosive to the metal in your vehicle. Outside parking, which exposes your vehicle to airborne contaminants, road surfaces on which the vehicle is operated, extreme hot or cold weather and other extreme conditions will have an adverse effect on paint, metal trim, and under- body protection. The following maintenance recommendations will enable you to obtain maximum benefit from the corrosion resistance built into your vehicle.
What Causes Corrosion? Corrosion is the result of deterioration or removal of paint and protective coatings from your vehicle. The most common causes are: • Road salt, dirt and moisture accumulation. • Stone and gravel impact. • Insects, tree sap and tar. • Salt in the air near seacoast localities. • Atmospheric fallout/industrial pollutants. Washing • Wash your vehicle regularly. Always wash your ve- hicle in the shade using a mild car wash soap, and rinse the panels completely with clear water. • If insects, tar or other similar deposits have accumu- • Use Mopar auto polish or equivalent to remove road film and stains and to polish your vehicle. Take care never to scratch the paint.
lated on your vehicle, wash it as soon as possible.
MAINTAINING YOUR VEHICLE 267
• Avoid using abrasive compounds and power buffing that may diminish the gloss or thin out the paint finish.
CAUTION!
Do not use abrasive or strong cleaning materials such as steel wool or scouring powder, which will scratch metal and painted surfaces.
Special Care • If you drive on salted or dusty roads or if you drive near the ocean, hose off the undercarriage at least once a month. • It is important that the drain holes in the lower edges of the doors, rocker panels and trunk be kept clear and open. • If you detect any stone chips or scratches in the paint, touch them up immediately. The cost of such repairs is considered the responsibility of the owner.
268 MAINTAINING YOUR VEHICLE
• If your vehicle is damaged due to an accident or similar cause which destroys the paint and protective coating have your vehicle repaired as soon as possible. The cost of such repairs is considered the responsibil- ity of the owner. • All wheels and wheel trim, especially aluminum and chrome plated wheels should be cleaned regularly with mild soap and water to prevent corrosion. To remove heavy soil, select a nonabrasive, non-acidic cleaner. Do not use scouring pads, steel wool, a bristle brush or metal polishes. Only Mopar or equivalent cleaners are recommended. Do not use oven cleaner. Avoid automatic car washes that use acidic solutions or harsh brushes that may damage the wheels’ protec- tive finish. • If you carry special cargo such as chemicals, fertilizers, de-icer salt, etc., be sure that such materials are well packaged and sealed. • If a lot of driving is done on gravel roads, consider
mud or stone shields behind each wheel.
• Use Mopar touch up paint or equivalent on scratches as soon as possible. Your dealer has touch up paint to match the color of your vehicle.
Interior Care Use Mopar Fabric Cleaner or equivalent to clean fabric upholstery and carpeting. Interior Trim should be cleaned starting with a damp cloth, a damp cloth with a mild detergent, then MOPAR Vinyl Cleaner or equivalent if absolutely necessary. Do not use harsh cleaners or Armorall. Use Mopar Vinyl Cleaner or equivalent to clean vinyl upholstery. Mopar Total Clean or equivalent is specifically recom- mended for leather upholstery. Your leather upholstery can be best preserved by regular cleaning with a damp soft cloth. Small particles of dirt can act as an abrasive and damage the leather upholstery and should be removed promptly with a damp cloth. Stubborn soils can be removed easily with a soft cloth and Mopar Total Clean or equivalent. Care should be taken to avoid soaking your leather upholstery with any liquid. Please do not use polishes, oils, cleaning fluids,
solvents, detergents, or ammonia based cleaners to clean your leather upholstery. Application of a leather condi- tioner is not required to maintain the original condition.
WARNING!
Do not use volatile solvents for cleaning purposes. Many are potentially flammable, and if used in closed areas they may cause respiratory harm.
Glass Surfaces All glass surfaces should be cleaned on a regular basis with any commercial household-type glass cleaner. Never use an abrasive type cleaner. Use caution when cleaning the inside rear window equipped with electric defrosters and radio antenna. Do not use scrapers or other sharp instruments which may scratch the elements. When cleaning the rear view mirror, spray cleaner on the towel or rag that you are using. Do not spray cleaner directly on the mirror.
MAINTAINING YOUR VEHICLE 269
Cleaning Plastic Instrument Cluster Lenses The lenses in front of the instruments in this vehicle are molded in clear plastic. When cleaning the lenses, care must be taken to avoid scratching the plastic. 1. Clean with a wet soft rag. A mild soap solution may be used, but do not use high alcohol content or abrasive cleaners. If soap is used, wipe clean with a clean damp rag. 2. Dry with a soft tissue. Seat Belt Maintenance Do not bleach, dye or clean the belts with chemical solvents or abrasive cleaners. This will weaken the fabric. Sun damage can also weaken the fabric. If the belts need cleaning, use a mild soap solution or lukewarm water. Do not remove the belts from the car to wash them. Replace the belts if they appear frayed or worn or if the buckles do not work properly.
270 MAINTAINING YOUR VEHICLE
Cleaning The Center Console Cup Holders Clean with a damp cloth or towel using a mild detergent with the cup holder in the center console. NOTE: The cup holder cannot be removed.
POWER DISTRIBUTION CENTERS
Front Power Distribution Center A power distribution center is located in the engine compartment. This center contains fuses and relays.
CAUTION!
• When installing the Power Distribution Center cover, it is important to ensure the cover is prop- erly positioned and fully latched. Failure to do so may allow water to get into the Power Distribu- tion Center, and possibly result in a electrical system failure. • When replacing a blown fuse, it is important to use only a fuse having the correct amperage rating. The use of a fuse with a rating other than indicated may result in a dangerous electrical system overload. If a properly rated fuse contin- ues to blow, it indicates a problem in the circuit that must be corrected.
Front Power Distribution Center
Front Power Distribution Center Fuses Cavity Fuse
20 Amp Yellow 20 Amp Yellow
Circuits Left High Beam Headlight Right High Beam Head- light — Horn Headlamp Washer
— 20 Amp Yellow 25 Amp Clear 15 Amp Dk. Blue Front Control Module
(FCM) 20 Amp Yellow Fog Lamp 15 Amp Dk. Blue Park Lamp 15 Amp Dk. Blue Non ABS Brakes 5 Amp Orange 20 Amp Yellow
Starter Auto Shutdown/ Powertrain Control Mod- ule (PCM) — —
— —
10
1112
1315
1617
18
19
20
21
22
23
24
2526
27Cavity Fuse 14
25 Amp Clear
20 Amp Yellow 15 Amp Dk. Blue Powertrain Control Mod-
MAINTAINING YOUR VEHICLE 271
Circuits Powertrain Control Mod- ule Injectors, Ignition Coils
ule Antilock Brake System (ABS) Valves Windshield Wiper/Washer Radiator Fan Starter ABS Pump Motor Radiator Fan High/Low High Intensity Lighting Radiator Fan Lighting Left High Beam/ Right Low Beam — Lighting Left Low Beam/ Right High Beam
30 Amp Pink
30 Amp Pink 50 Amp Red 20 Amp Lt. Blue 50 Amp Red 40 Amp Green 50 Amp Red 60 Amp Yellow 30 Amp Pink
— 30 Amp Pink
272 MAINTAINING YOUR VEHICLE
Rear Power Distribution Center There is also a power distribution center located in the trunk under an access panel. This center contains fuses and relays.
Rear Power Distribution Center
CAUTION!
• When installing the Power Distribution Center cover, it is important to ensure the cover is prop- erly positioned and fully latched. Failure to do so may allow water to get into the Power Distribu- tion Center, and possibly result in a electrical system failure. • When replacing a blown fuse, it is important to use only a fuse having the correct amperage rating. The use of a fuse with a rating other than indicated may result in a dangerous electrical system overload. If a properly rated fuse contin- ues to blow, it indicates a problem in the circuit that must be corrected.
Rear Power Distribution Center Fuses Cavity Fuse
60 Amp Clear 40 Amp Green — 40 Amp Green 30 Amp Pink
Circuits Ignition Off Draw Battery — Battery Heated Seat/Steering Col- umn Fuel Pump —
20 Amp Yellow — 15 Amp Dk. Blue Ignition Start/Run - Start 20 Amp Yellow 10 Amp Red
Console Power Outlet Rear Fog Lamp — If Equipped
25 Amp C/BRKR Memory Module/Door
Locks
25 Amp C/BRKR Passenger Power Seat 30 Amp C/BRKR Door Module Run/Acc/
10 Amp Red
Delay Sentry Key/Remote Key- less Entry/Cluster
10
11
12
1314
MAINTAINING YOUR VEHICLE 273
Cavity Fuse 15
16
17
18
19
20
21
22
23
24
25
26
27— — — 20 Amp Yellow 10 Amp Red — — — — — — — 10 Amp Red
28
29
10 Amp Red
5 Amp Orange
Circuits — — — Selectable Power Outlet Stop Lamp — — — — — — — Airbag/Occupant Classifi- cation Module Curtain Airbag - if equipped Sentry Key/Remote Key- less Entry/Powertrain Control Module Ignition Feed
274 MAINTAINING YOUR VEHICLE
Cavity Fuse 30
10 Amp Red
— — — — 5 Amp Orange
31
32
33
34
3536
37
3820 Amp Yellow 15 Amp Dk. Blue Transmission 5 Amp Orange
Analog Clock/Garage Door Opener
Circuits Steering Column Module/ Power Mirrors — — — — Power Antenna/Garage Door Opener/Ignition De- lay Radio/Navigation
Cavity Fuse 39
40
4110 Amp Red 5 Amp Orange 10 Amp Red
30 Amp Pink
42
43
44Circuits Heated Mirror Power Mirror Climate Control Module/ Headlamp Leveling — if equipped/Rear Park As- sist Automatic Temperature Control (ATC) Blower Mo- tor Rear Defroster
30 Amp Pink 20 Amp Lt. Blue Audio Amplifier
VEHICLE STORAGE If you are leaving your vehicle dormant for more than 21
days you may want to take steps to protect your battery. You may: • Disconnect the negative cable from the battery. • Anytime you store your vehicle, or keep it out of service (i.e. vacation) for two weeks or more, run the air conditioning system at idle for about five minutes in the fresh air and high blower setting. This will insure adequate system lubrication to minimize the possibility of compressor damage when the system is started again.MAINTAINING YOUR VEHICLE 275
REPLACEMENT LIGHT BULBS
LIGHT BULBS — Interior Bulb Number Rear Courtesy/Reading Lights. . . . . . . . . . . . . . W5W Rear Compartment (Trunk) Light . . . . . . . . . . . . . 579
Overhead Console Reading Lights. . . . . . . . . . . . . 578
Visor Vanity Lights . . . . . . . . . . . . . . . . . . . . . A6220
Glove Box Light . . . . . . . . . . . . . . . . . . . . . . . . . 194
Door Courtesy . . . . . . . . . . . . . . . . . . . . . . . . . . 562
Shift Indicator Light . . . . . . . . . . . . . . . . . JKLE14140
NOTE: For lighted switches, see your dealer for re- placement instructions. All of the interior bulbs are glass wedge base or glass cartridge types. Aluminum base bulbs are not approved and should not be used for replacement.276 MAINTAINING YOUR VEHICLE
Bulb Number
LIGHT BULBS — Exterior Low Beam Headlamp – High Intensity Discharge (HID) . . . . D1S (Serviced at Dealer) High Beam Headlamp . . . . . . . . . . . . . . . . . . . . 9005
Front Park/Turn Lamp . . . . . . . . . . . . . . . . . 3157AK Front Fog Lamp . . . . . . . 9145/H10 (Serviced at Dealer) Front Sidemarker . . . . . . . . . W5W (Serviced at Dealer) Tail/Stop Lamp . . . . . . . . . . . . . . . . . . . . . . . . . 3057
Tail Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3057
Turn Signal Lamp . . . . . . . . . . . . . . . . . . . . . . . 3057
Backup Lamp . . . . . . . . . . . . . . . . . . . . . . . . . . 3057
Center High Mount Stop Lamp (CHMSL). . . . . . . LED License . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . W5WBULB REPLACEMENT
Low Beam Headlamp, High Beam Headlamp, and Park/Turn Lamp
High Intensity Discharge Headlights (HID) The headlights are a type of high voltage discharge tube. High voltage can remain in the circuit even with the headlight switch off and the key removed. Because of this, you should not attempt to service a headlight bulb yourself. If a headlight bulb fails, take your vehicle to an authorized dealer for service.
WARNING!
A transient high tension occurs at the bulb sockets of High Intensity Discharge (HID) headlights when the headlight switch is turned ON. It may cause serious electrical shock or electrocution if not serviced prop- erly. See your authorized dealer for service.
NOTE: When HID headlights are turned on there is a blue hue to the lights. This diminishes and becomes more white after approximately 10 seconds, as the system charges. • Open the hood. • Twist the appropriate bulb socket assembly counter- clockwise and pull out. Pull the bulb out of the socket assembly.
NOTE: Removal of the air cleaner filter housing may be necessary prior to replacing bulbs on driver’s side head- lamp assembly. • Replace the bulb and push into socket assembly.
Reinstall the socket assembly, and turn clockwise.
MAINTAINING YOUR VEHICLE 277
278 MAINTAINING YOUR VEHICLE
CAUTION!
Do not touch the new bulb with your fingers. Oil contamination will severely shorten bulb life. If the bulb comes in contact with an oily surface, clean the bulb with rubbing alcohol.
Tail/Stop, Tail, Turn Signal Lamp, and Backup Lamp
1. Open the Trunk. 2. Remove two fasteners from the back of the tail lamp assembly.
3. Pull back the trunk liner. 4. Remove the remaining fastener from the back of the tail lamp assembly. 5. Push the electrical connector locking tab to the side.
6. Disconnect the electrical connector.
MAINTAINING YOUR VEHICLE 279
7. Pull tail lamp assembly clear from vehicle to access bulbs. Turn bulb sockets counter-clockwise to remove.
280 MAINTAINING YOUR VEHICLE
8. Pull the appropriate bulb to remove it from the socket. 9. Replace the bulb, reinstall the socket, and reattach the tail light assembly. 10. Close the trunk.
License Lamp
FLUIDS AND CAPACITIES
MAINTAINING YOUR VEHICLE 281
1. Remove the screws securing the light to the rear fascia. 2. Remove the bulb and socket assembly and pull the bulb from the socket.
Fuel (approximate) 6.1 Liter Engines (Premium 91
Octane) Engine Oil-With FilterU.S.
Metric
19 gal- lons
72 liters
6.1 Liter Engines (SAE 0W-40)
7 qts.
6.6 liters
Cooling System *
6.1 Liter Engines (Mopar威 Antifreeze/Coolant 5 Year/ 100,000 Mile Formula) or
equivalent.
14.8 qts
14.0 li-
ters
* Includes heater and coolant recovery bottle filled to MAX level.
3. Replace the bulb and reinstall the bulb and socket assembly. 4. Reattach the light to the rear fascia.
282 MAINTAINING YOUR VEHICLE
RECOMMENDED FLUIDS, LUBRICANTS AND GENUINE PARTS Engine Component Engine Coolant
Engine Oil (6.1 Liter)
Spark Plugs
Oil Filter (6.1 Liter) Fuel Selection (6.1 Liter) Chassis Component Automatic Transmission Brake Master Cylinder
Power Steering Reservoir
Rear Axle
Fluids, Lubricants and Genuine Parts Mopar威 Antifreeze/Coolant 5 Year/100,000 Mile Formula HOAT (Hybrid Or- ganic Additive Technology) or equivalent. Use API rated SM/CF full synthetic engine oil. SAE 0W-40 is recommended. Refer to the engine oil viscosity chart for the correct SAE grade meeting DaimlerChrysler Material Standard MS-10725. Refer to the Vehicle Emission Control Information label in the engine com- partment. Mopar威 05281090 or equivalent. Premium Unleaded 91 Octane Only or higher.
Fluids, Lubricants and Genuine Parts Mopar威 ATF+4 Automatic Transmission Fluid or equivalent. Mopar威 DOT 3 and SAE J1703 or equivalent should be used. Use only rec- ommended brake fluids. Mopar威 Power Steering Fluid + 4, Mopar威 ATF+4 Automatic Transmission Fluid or equivalent. API rated GL-5 SAE 75W140 Synthetic Gear Lubricant or equivalent.
MAINTENANCE SCHEDULES
CONTENTS
䡵 Emission Control System Maintenance . . . . . . 300
䡵 Maintenance Schedules . . . . . . . . . . . . . . . . . . 300▫ Schedule “B” . . . . . . . . . . . . . . . . . . . . . . . . 287
▫ Schedule “A” . . . . . . . . . . . . . . . . . . . . . . . . 294M
284 MAINTENANCE SCHEDULES
EMISSION CONTROL SYSTEM MAINTENANCE The “Scheduled” maintenance services, listed in bold type must be done at the times or mileages specified to assure the continued proper functioning of the emission control system. These, and all other maintenance services included in this manual, should be done to provide best vehicle performance and reliability. More frequent main- tenance may be needed for vehicles in severe operating conditions such as dusty areas and very short trip driving. Inspection and service also should be done any time a malfunction is suspected. NOTE: Maintenance, replacement, or repair of the emission control devices and systems on your vehicle may be performed by any automotive repair establish- ment or individual using any automotive part which has been certified pursuant to U.S. EPA or, in the State of California, California Air Resources Board regulations.
MAINTENANCE SCHEDULES
There are two maintenance schedules that show the required service for your vehicle. First is Schedule “B”. It is for vehicles that are operated under the conditions that are listed below and at the beginning of the schedule. Change the automatic trans- mission fluid and filter every 60,000 miles (96 000 km) if the vehicle is usually operated under one or more of the conditions marked with an 〫. • Day or night temperatures are below 32° F (0° C). • Stop and go driving. • Extensive engine idling. • Driving in dusty conditions. • Short trips of less than 10 miles (16 km). • More than 50% of your driving is at sustained high • Trailer towing.〫
speeds during hot weather, above 90° F (32° C).
vice).〫
• Taxi, police, or delivery service (commercial ser- • Off-road or desert operation. If ANY of these apply to you then change your NOTE: engine oil every 3,000 miles (5 000 km) or 3 months, whichever comes first and follow schedule “B” of the ⬙Maintenance Schedules⬙ section of this manual. IF ANY of these apply to you then flush and NOTE: replace the engine coolant every 102,000 miles (164,000
km) or 60 months, whichever comes first, and follow schedule B of the ⬙Maintenance Schedules⬙ section of this manual. NOTE: Most vehicles are operated under the conditions listed for Schedule ⬙B⬙. Second is Schedule “A”. It is for vehicles that are not operated under any of the conditions listed under Sched- ule ⬙B⬙. Use the schedule that best describes your driving condi- tions. Where time and mileage are listed, follow the interval that occurs first.MAINTENANCE SCHEDULES 285
NOTE: Under no circumstances should oil change intervals exceed 6000 miles (10 000 km) or 6 months whichever comes first.
CAUTION!
Failure to perform the required maintenance items may result in damage to the vehicle.
At Each Stop for Fuel • Check the engine oil level about 5 minutes after a fully warmed engine is shut off. Checking the oil level while the vehicle is on level ground will improve the accu- racy of the oil level reading. Add oil only when the level is at or below the ADD or MIN mark. • Check the windshield washer solvent and add if
required.
286 MAINTENANCE SCHEDULES
damage.
as required.
Once a Month • Check tire pressure and look for unusual wear or • Inspect the battery and clean and tighten the terminals • Check the fluid levels of coolant reservoir and brake • Check all lights and all other electrical items for correct • Check rubber seals on each side of the radiator for
master cylinder, and add as needed.
operation.
proper fit.
At Each Oil Change • Change the engine oil filter. • Inspect the exhaust system. • Inspect the brake hoses. • Inspect the CV joints and front and rear suspension • Check the coolant level, hoses, and clamps.
components.
SCHEDULE “B” Follow schedule “B” if you usually operate your vehicle under one or more of the following conditions. Change the automatic transmission fluid and filter every 60,000
miles (96 000 km) if the vehicle is usually operated under one or more of the conditions marked with an 〫. • Day or night temperatures are below 32° F (0° C). • Stop and go driving. • Extensive engine idling. • Driving in dusty conditions. • Short trips of less than 10 miles (16.2 km). • More than 50% of your driving is at sustained high • Trailer towing.〫speeds during hot weather, above 90° F (32° C).
SCHEDULE “B” 287
vices).〫
• Taxi, police or delivery service (commercial ser- • Off-road or desert operation. • If equipped for and operating with E-85 (ethanol)
fuel.
If ANY of these apply to you then change your NOTE: engine oil every 3,000 miles (5 000 km) or 3 months, whichever comes first and follow schedule “B” of the ⬙Maintenance Schedules⬙ section of this manual. IF ANY of these apply to you then flush and NOTE: replace the engine coolant every 102,000 miles (164,000
km) or 60 months, whichever comes first, and follow schedule B of the ⬙Maintenance Schedules⬙ section of this manual.288 SCHEDULE “B”
Miles (Kilometers) Change engine oil and engine oil filter, if not replaced at 3 months. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Inspect the front and rear brake linings and rotors. Replace the air conditioning filter. Rotate the tires.
3,000
(5 000)6,000
(10 000)9,000
(15 000)12,000
(20 000)15,000
(25 000)18,000
(30 000)Miles (Kilometers) Change engine oil and engine oil filter, if not replaced at 3 months. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Inspect the front and rear brake linings and rotors. Check and replace, if necessary, the PCV valve. * Replace the air conditioning filter. Rotate the tires.
21,000
(35 000)24,000
(40 000)27,000
(45 000)30,000
(50 000)33,000
(55 000)36,000
(60 000)SCHEDULE “B” 289
290 SCHEDULE “B”
Miles (Kilometers) Change engine oil and engine oil filter, if not replaced at 3 months. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Inspect the front and rear brake linings and rotors. Change the rear axle fluid. Replace the air conditioning filter. Rotate the tires.
39,000
(65 000)42,000
(70 000)45,000
(75 000)48,000
(80 000)51,000
(85 000)54,000
(90 000)Miles (Kilometers) Change engine oil and engine oil filter, if not replaced at 3 months. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Inspect the front and rear brake linings and rotors. Check and Inspect the accessory drive belt and tensioner. Replace if required. Check and replace, if necessary, the PCV valve. * ‡ Change the power steering fluid. Change the automatic transmission fluid and filter. Replace the air conditioning filter. Flush and replace engine coolant at 60 months if not done at 102,000 miles. Rotate the tires.
57,000
(95 000)60,000
(100 000)63,000
(105 000)66,000
(110 000)69,000
(115 000)72,000
(120 000)SCHEDULE “B” 291
292 SCHEDULE “B”
Miles (Kilometers) Change engine oil and engine oil filter, if not replaced at 3 months. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Inspect the front and rear brake linings and rotors. Check and replace, if necessary, the PCV valve. * ‡ Replace the air conditioning filter. Rotate the tires.
75,000
(125 000)78,000
(130 000)81,000
(135 000)84,000
(140 000)87,000
(145 000)90,000
(150 000)93,000
(155 000)Miles (Kilometers) Change engine oil and engine oil filter, if not re- placed at 3 months. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Replace the spark plugs. Inspect the front and rear brake linings and rotors. Check and Inspect the accessory drive belt and ten- sioner. Replace if required. Change the rear axle fluid. Replace the air conditioning filter. Flush and replace engine coolant at 102,000 miles if not done at 60 months. Rotate the tires. * This maintenance is recommended by the manufacture to the owner but is not required to maintain the emis- sions warranty.
SCHEDULE “B” 293
96,000
(160 000)99,000
(165 000)102,000
(170 000)105,000
(175 000)‡ This maintenance is not required if previously replaced. Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all receipts.
294 SCHEDULE “A”
SCHEDULE “A” Miles (Kilometers) [Months] Change engine oil and engine oil filter. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Inspect the front and rear brake linings and rotors. Replace the air conditioning filter. Rotate the tires.
6,000
(10 000)12,000
(20 000)18,000
(30 000)24,000
(40 000)30,000
(50 000)36,000
(60 000)[6]
[12]
[18]
[24]
[30]
[36]
Miles (Kilometers) [Months] Change engine oil and engine oil filter. Inspect the air cleaner filter and replace if required.* Replace the air cleaner filter. Inspect the front and rear brake linings and rotors. Check and Inspect the accessory drive belt and tensioner. Replace if required. Flush and replace engine coolant at 60 months if not done at 102,000 miles. Check and replace, if necessary, the PCV valve. * Replace the air conditioning filter. Rotate the tires.
42,000
(70 000)48,000
(80 000)54,000
(90 000)60,000
(100 000)66,000
(110 000)72,000
(120 000)SCHEDULE “A” 295
[42]
[48]
[54]
[60]
[66]
[72]
M
296 SCHEDULE “A”
Miles (Kilometers) [Months] Change engine oil and engine oil filter. Inspect the air cleaner filter and replace if re- quired.* Replace the air cleaner filter. Replace the spark plugs. Inspect the front and rear brake linings and rotors. Check and Inspect the accessory drive belt and ten- sioner. Replace if required. Check and replace, if necessary, the PCV valve. *‡ Flush and replace the engine coolant at 102,000
miles if not done at 60 months. Replace the air conditioning filter. Rotate the tires. * This maintenance is recommended by the manufacturer to the owner but is not required to maintain the emis- sions warranty.78,000
(130 000)84,000
(140 000)90,000
(150 000)96,000
(160 000)[78]
[84]
[96]
[90]
102,000
(170 000)[102]
‡ This maintenance is not required if previously replaced. Inspection and service should also be performed anytime a malfunction is observed or suspected. Retain all receipts.
WARNING!
You can be badly injured working on or around a motor vehicle. Do only that service work for which you have the knowledge and the right equipment. If you have any doubt about your ability to perform a service job, take your vehicle to a competent me- chanic.
SCHEDULE “A” 297
IF YOU NEED CONSUMER ASSISTANCE
CONTENTS
䡵 Suggestions For Obtaining Service For Your
Vehicle . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 284
▫ Prepare For The Appointment . . . . . . . . . . . . 300
▫ Prepare A List . . . . . . . . . . . . . . . . . . . . . . . . 300
▫ Be Reasonable With Requests . . . . . . . . . . . . . 300
䡵 If You Need Assistance . . . . . . . . . . . . . . . . . . 284
䡵 Warranty Information (U.S. Vehicles Only) . . . 302
䡵 Mopar威 Parts . . . . . . . . . . . . . . . . . . . . . . . . . 302䡵 Reporting Safety Defects . . . . . . . . . . . . . . . . . 303
▫ In Canada . . . . . . . . . . . . . . . . . . . . . . . . . . 303
䡵 Publication Order Forms . . . . . . . . . . . . . . . . . 303
䡵 Department Of Transportation Uniform TireQuality Grades . . . . . . . . . . . . . . . . . . . . . . . . 305
▫ Treadwear . . . . . . . . . . . . . . . . . . . . . . . . . . 305
▫ Traction Grades . . . . . . . . . . . . . . . . . . . . . . 305
▫ Temperature Grades . . . . . . . . . . . . . . . . . . . 306 9300 IF YOU NEED CONSUMER ASSISTANCE
SUGGESTIONS FOR OBTAINING SERVICE FOR YOUR VEHICLE
Prepare For The Appointment If you’re having warranty work done, be sure to have the right papers with you. Take your warranty folder. All work to be performed may not be covered by the warranty, discuss additional charges with the service manager. Keep a maintenance log of your vehicle’s service history. This can often provide a clue to the current problem. Prepare A List Make a written list of your vehicle’s problems or the specific work you want done. If you’ve had an accident, or work done that is not on your maintenance log, let the service advisor know. Be Reasonable With Requests If you list a number of items, and you must have your vehicle by the end of the day, discuss the situation with the service advisor and list the items in order of priority. At many dealers you may obtain a rental vehicle at a
minimal daily charge. If you need a rental, it is advisable to make these arrangements when you call for an ap- pointment.
IF YOU NEED ASSISTANCE The manufacturer and its dealers are vitally interested in your satisfaction. We want you to be happy with our products and services. Warranty service must be done by an authorized Chrysler, Dodge, or Jeep dealer. We strongly recommend that you take your vehicle to you selling dealer. They know you and your vehicle best, and are most concerned that you get prompt and high quality service. The manufacturer’s dealers have the facilities, factory-trained technicians, special tools, and the latest information to assure your vehicle is fixed correctly and in a timely manner. This is why you should always talk to your dealer’s service manager first. Most matters can be resolved with this process.
• If for some reason you are still not satisfied, talk to the general manager or owner of the dealership. They want to know if you need assistance. • If your dealership is unable to resolve the concern, you
may contact the Manufacturer’s Customer Center.
Any communication to the Manufacturer’s Customer Center should include the following information: • Owner’s name and address • Owner’s telephone number (home and office) • Dealership name • Vehicle identification number • Vehicle delivery date and mileage DaimlerChrysler Motors Corporation Customer Center P.O. Box 21–8004
Auburn Hills, MI 48321–8004
Phone: (800) 992-1997IF YOU NEED CONSUMER ASSISTANCE 301
DaimlerChrysler Canada Inc. Customer Center P.O. Box 1621
Windsor, Ontario N9A 4H6
Phone —(800) 465–2001
In Mexico contact: Av. Prolongacion Paseo de la Reforma, 1240
Sante Fe C.P. 05109
Mexico, D. F. In Mexico (915) 729–1248 or 729–1240
Outside Mexico (525) 729–1248 or 729–1240
Customer Assistance For The Hearing Or Speech Impaired (TDD/TTY) To assist customers who have hearing difficulties, the manufacturer has installed special TDD (Telecommuni- cation Devices for the Deaf) equipment at its Customer Center. Any hearing or speech impaired customer who has access to a TDD or a conventional teletypewriter (TTY) in the United States can communicate with the manufacturer by dialing 1–800–380–CHRY.302 IF YOU NEED CONSUMER ASSISTANCE
Service Contract You may have purchased a service contract for your vehicle to help protect you from the high cost of unex- pected repairs after your manufacturer’s new vehicle limited warranty expires. The manufacturer stands be- hind only the manufacturer’s Service Contracts. If you purchased a manufacturer’s Service Contract, you will receive Plan Provisions and an Owner Identification Card in the mail within three weeks of your vehicle delivery date. If you have any questions about your service contract, call the manufacturer’s Service Contract Na- tional Customer Hotline at 1-800-521-9922. The manufacturer will not stand behind any service contract that is not the manufacturer’s Service Contract. It is not responsible for any service contract other than the manufacturer’s Service Contract. If you purchased a service contract that is not a manufacturer’s Service Contract, and you require service after your manufactur- er’s new vehicle limited warranty expires, please refer to your contract documents, and contact the person listed in those documents.
We appreciate that you have made a major investment when you purchased your new vehicle. Your dealer has also made a major investment in facilities, tools, and training to assure that you are absolutely delighted with your ownership experience. You’ll be pleased with their sincere efforts to resolve any warranty issues or related concerns.
WARRANTY INFORMATION (U.S. Vehicles Only) See the Warranty Information Booklet for the terms and provisions of DaimlerChrysler’s warranties applicable to this vehicle.
MOPAR姞 PARTS Mopar威 fluids, lubricants, parts, and accessories are available from your dealer. They will help you keep your vehicle operating at its best.
REPORTING SAFETY DEFECTS In the 50 United States and Washington D.C.: If you believe that your vehicle has a defect which could cause a crash or cause injury or death, you should immediately inform the National Highway Traffic Safety Administra- tion (NHTSA) in addition to notifying the manufacturer. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign. However, NHTSA cannot become involved in individual problems between you, your dealer, and the manufacturer. To contact NHTSA, you may either call the Auto Safety Hotline toll free at 1-800-424-9393 (or 366-0123 in Wash- ington DC area) or write to: NHTSA, U.S. Dept. of Transportation, Washington DC 20590. You can also obtain other information about motor vehicle safety from the Hotline.
IF YOU NEED CONSUMER ASSISTANCE 303
In Canada: If you believe that your vehicle has a safety defect, you should contact the Customer Service Department imme- diately. Canadian customers who wish to report a safety defect to the Canadian government should write to Transport Canada, Motor Vehicle Defect Investigations and Recalls, 2780 Sheffield Road, Ottawa, Ontario K1B 3V9.
PUBLICATION ORDER FORMS To order the following manuals, you may use either the website or the phone numbers listed below. Visa, Mas- tercard, American Express, and Discover orders are ac- cepted. If you prefer mailing your payment, please call for an order form. NOTE: A street address is required when ordering manuals. (No P.O. Boxes).
304 IF YOU NEED CONSUMER ASSISTANCE
• Service Manuals.
• Owner’s Manuals.
These comprehensive service manuals provide the information that students and professional technicians need in diagnosing/troubleshooting, problem solving, maintaining, servicing and repairing DaimlerChrysler Corporation vehicles. A complete working knowledge of the vehicle, system and/or components is written in straightforward language with illustrations, diagrams and charts.
• Diagnostic Procedure Manuals.
Filled with diagrams, charts and detailed illustrations, these practical manuals make it easy for students and technicians to find and fix problems on computer- controlled vehicle systems and features. They show exactly how to find and correct problems the first time, using step-by-step troubleshooting and driveability procedures, proven diagnostic tests and a complete list of all tools and equipment.
These manuals have been prepared with the assistance of service and engineering specialists to acquaint you with specific Chrysler group vehicles. Included are starting, operating, emergency and maintenance pro- cedures as well as specifications, capabilities and safety tips.
Call Toll Free at: • 1–800–890–4038 (U.S.) • 1–800–387–1143 (Canada) Or Visit us on the World Wide Web at: • www.techauthority.daimlerchrysler.com • www.daimlerchrysler.ca/manuals
DEPARTMENT OF TRANSPORTATION UNIFORM TIRE QUALITY GRADES The following describes the tire grading categories estab- lished by the National highway Traffic Safety Adminis- tration. The specific grade rating assigned by the tire’s manufacturer in each category is shown on the sidewall of the tires on your car. All Passenger Car Tires Must Conform to Federal Safety Requirements in Addition to These Grades. Treadwear The treadwear grade is a comparative rating based on the wear rate of the tire when tested under controlled con- ditions on a specified government test course. For ex- ample, a tire graded 150 would wear one and a half (1
1/2) times as well on the government course as a tire graded 100. The relative performance of tires depends upon the actual conditions of their use, however, and may depart significantly from the norm due to variations in driving habits, service practices and differences in road characteristics and climate.IF YOU NEED CONSUMER ASSISTANCE 305
Traction Grades The traction grades, from highest to lowest, are A, B, and C, and they represent the tire’s ability to stop on wet pavement as measured under controlled conditions on specified government test surfaces of asphalt and con- crete. A tire marked C may have poor traction perfor- mance.
WARNING!
The traction grade is based on braking (straight- ahead) traction tests and does not include cornering (turning) performance.
306 IF YOU NEED CONSUMER ASSISTANCE
Temperature Grades The temperature grades are A (highest), B, and C, repre- senting the tire’s resistance to the generation of heat and its ability to dissipate heat when tested under controlled conditions on a specified indoor laboratory test wheel. Sustained high temperature can cause the material of the tire to degenerate and reduce tire life, and excessive temperature can lead to sudden tire failure. The grade C corresponds to a level of performance which all passen- ger car tires must meet under the Federal Motor Vehicle Safety Standard No. 109. Grades B and A represent higher levels of performance on the laboratory test wheel than the minimum required by law.
WARNING!
The temperature grade is established for a tire that is properly inflated and not overloaded. Excessive speed, underinflation, or excessive loading, either separately or in combination, can cause heat buildup and possible tire failure.
INDEX
10
308 INDEX
ABS (Anti-Lock Brake) System . . . . . . . . . . . . . 195
Adding Engine Coolant (Antifreeze) . . . . . . . . . 259
Adding Fuel . . . . . . . . . . . . . . . . . . . . . . . . . . 224
Adding Washer Fluid . . . . . . . . . . . . . . 104,105,257
Additives, Fuel . . . . . . . . . . . . . . . . . . . . . . . . 222
Adjustable Pedals . . . . . . . . . . . . . . . . . . . . . . . 94
Air Conditioner Maintenance . . . . . . . . . . . . . . 254
Air Conditioning Filter . . . . . . . . . . . . . . . . 179,255
Air Conditioning, Operating Tips . . . . . . . . . . . 180
Air Conditioning Refrigerant . . . . . . . . . . . . . . 255
Air Pressure, Tires . . . . . . . . . . . . . . . . . . . . . . 209
Airbag . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 35
Airbag Deployment . . . . . . . . . . . . . . . . . . . . 39,45
Airbag Light . . . . . . . . . . . . . . . . . . . . 40,47,57,135
Airbag Maintenance . . . . . . . . . . . . . . . . . . . . . . 46
Airbag, Side . . . . . . . . . . . . . . . . . . . . . . . . . . . 43
Airbag, Window . . . . . . . . . . . . . . . . . . . . . . 35,43
Alarm System . . . . . . . . . . . . . . . . . . . . . . . . . . 21
Alignment and Balance . . . . . . . . . . . . . . . . . . 214
Alterations/Modifications, Vehicle . . . . . . . . . . . . 7
Antenna, Satellite Radio . . . . . . . . . . . . . . . . . . 167
Antifreeze (Engine Coolant) . . . . . . . . . . . . 259,281
. . . . . . . . . . . . . . . . . . . . . . . . . . . . 260Disposal
. . . . . . . . . . . . . 195
Anti-Lock Brake System (ABS) Anti-Lock Warning Light . . . . . . . . . . . . . . . . . 135
Anti-Theft Security Alarm . . . . . . . . . . . . . . . . . 21
Appearance Care . . . . . . . . . . . . . . . . . . . . . . . 266
Auto Down Power Windows . . . . . . . . . . . . . . . 23
Auto Up Power Windows . . . . . . . . . . . . . . . . . 24
Automatic Dimming Mirror . . . . . . . . . . . . . . . . 63
Automatic Door Locks . . . . . . . . . . . . . . . . . . . . 17
Automatic Headlights . . . . . . . . . . . . . . . . . . . . 99
Automatic Temperature Control . . . . . . . . . . . . 173
Automatic Transmission . . . . . . . . . . . . 185,265,266
Adding Fluid . . . . . . . . . . . . . . . . . . . . . 266,282
Fluid and Filter Changes . . . . . . . . . . . . . . . . 266
Fluid Change . . . . . . . . . . . . . . . . . . . . . . . . 266
Fluid Level Check . . . . . . . . . . . . . . . . . . . . . 265
Fluid Type . . . . . . . . . . . . . . . . . . . . . . . . . . 282
Autostick . . . . . . . . . . . . . . . . . . . . . . . . . . 187,192Ball Joints . . . . . . . . . . . . . . . . . . . . . . . . . . . . 256
Battery . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 253
Jump Starting . . . . . . . . . . . . . . . . . . . . . . . . 235
Keyless Transmitter Replacement . . . . . . . . . . 21
Location . . . . . . . . . . . . . . . . . . . . . . . . . 236,253Bearings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 266
Belts, Drive . . . . . . . . . . . . . . . . . . . . . . . . . . . 250
Body Mechanism Lubrication . . . . . . . . . . . . . . 256
B-Pillar Location . . . . . . . . . . . . . . . . . . . . . . . 204
Brake Assist System . . . . . . . . . . . . . . . . . . . . . 108
Brake, Parking . . . . . . . . . . . . . . . . . . . . . . . . . 194
Brake System . . . . . . . . . . . . . . . . . . . . . . . 195,262
Anti-Lock . . . . . . . . . . . . . . . . . . . . . . . . . . . 195
Fluid Check . . . . . . . . . . . . . . . . . . . . . . 264,282
Hoses . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 263
. . . . . . . . . . . . . . . . . . . . . . . 136
Warning Light Brake/Transmission Interlock . . . . . . . . . . . . . . 192
Break-In Recommendations, New Vehicle . . . . . . 56
Bulb Replacement . . . . . . . . . . . . . . . . . . . . . . 276
. . . . . . . . . . . . . . . . . . . . . . . . . . . 275
Bulbs, Light
